Fermentation of wheat: effects of backslopping different proportions of pre-fermented wheat on the microbial and chemical composition

The objective of the study was to examine effect of backslop on the chemical and microbiological characteristics of fermented wheat (FW). Coarsely ground wheat was mixed with water (1:3 wt/wt) and inoculated with 6 log cfu ml(-1) each of an overnight culture of Lactobacillus plantarum and Pediococcus pentosaceus. Four fermentation treatments were conducted in 45 1, closed, PVC containers over 48 hours. Three treatments investigated the benefits of the addition of previously fermented wheat (backslopping, BSL) at different proportions (0.20, 0.33 or 0.42 kg) to freshly prepared wheat. The control treatment contained no addition of BSL. Elimination of coliforms from the FW within 48 h was only achieved through backslopping; where coliform bacteria counts decreased from approximately 6.5 log10 cfu ml(-1) to less than 3 log10 cfu ml(-1). There was no apparent advantage in increasing the backslop proportion above 0.20. However, the exclusion of coliform bacteria required the pH to remain below 4.0 for at a minimum of 24 h. The results of these studies indicate that fermentation of wheat has the potential to reduce the risk of feed-borne colibacillosis and provides a practical alternative to producers that cannot ferment multiple diets or have limited fermentation capacity.     

Studies on production of alcoholic beverages from some tropical fruits

The varieties of alcoholic beverages from watermelon; watermelon-banana and watermelon-pineapple mixtures were produced by using monoculture and mixed culture fermentation techniques. Three yeast species, namely, Saccharomyces cerevisiae, Kleochera apicalata, Torulospora delbruckii and four bacterial species Leuconostoc oenos, Lactobacillus Sp, Micrococcus luteus and Streptococcus lactis were identified during the study. The daily succession of these organisms in the various fermenting samples differed in cell mass and occurrence due to their different growth conditions and factors present. A higher bacterial load (3.9 ± 0.2-4.4 ± 0.3) log (cfu) ml^?1 than yeast (2.8 ± 00-4.6 ± 0.4) log (cfu) ml^?1 counts was observed in the mixed culture fermentation, while in the monoculture fermentation, a higher yeast load (4.3 ± 0.3-4.7 ± 0.2) log (cfu) ml^?1 than bacterial loads (2.7 ± 0.1-4.1 ± 0.3) log (cfu) ml^?1 counts was recovered. The results obtained from the present study indicated that monoculture-fermented beverages were of better quality as compared to the mixed culture fermented ones. The monoculture-fermented beverage from watermelon-pineapple mixture was ranked as the best alcoholic beverage based on sensory evaluation score.     

Use of autochthonous lactic acid bacteria starters to ferment mango juice for promoting its probiotic roles

Strains of Leuconostoc mesenteroides, Pediococcus pentosaceus, and Lactobacillus brevis were identified from mango fruits by partial 16S rDNA gene sequence. Based on the ability of producing mannitol and diacetyl, Leuconostoc mesenteroides MPL18 and MPL39 were selected within the lactic acid bacteria isolates, and used as mixed starters to ferment mango juice (MJ). Both the autochthonous strains grew well in fermented mango juice (FMJ) and remained viable at 9.81 log cfu mL^?1 during 30 days of storage at 4°C. The content of total sugar of FMJ was lower than that of MJ, while the concentration of mannitol was higher than that of MJ, and the concentration of diacetyl was 3.29 ± 0.12 mg L^?1. Among detected organic acids including citric acid, gallic acid, lactic acid, and acetic acid, only citric acid and gallic acid were found in MJ, while all detected organic acids were found in FMJ. The concentration of lactic acid of FMJ was the highest (78.62 ± 13.66 mM) among all detected organic acids. The DPPH radical scavenging capacity of FMJ was higher than that of MJ. Total phenolic compounds were better preserved in FMJ. The acidity and sweetness had a noticeable impact on the overall acceptance of the treated sample.     

The role of nisin in fuel ethanol production with Saccharomyces cerevisiae

Aims: To investigate the effects of nisin on lactobacilli contamination of yeast during ethanol fermentation and to determine the appropriate concentration required to control the growth of selected lactobacilli in a YP/glucose media fermentation model. Methods and Results: The lowest concentration of nisin tested (5 IU ml^?1) effectively controlled the contamination of YP/glucose media with 10⁶ CFU ml^?1 lactobacilli. Lactic acid yield decreased from 5·0 to 2·0 g l^?1 and potential ethanol yield losses owing to the growth and metabolism of Lactobacillus plantarum and Lactobacillus brevis were reduced by 11 and 7·8%, respectively. Approximately, equal concentrations of lactic acid were produced by Lact. plantarum and Lact. brevis in the presence of 5 and 2 IU ml^?1 nisin, respectively, thus demonstrating the relatively higher nisin sensitivity of Lact. brevis for the strains in this study. No differences were observed in the final ethanol concentrations produced by yeast in the absence of bacteria at any of the nisin concentrations tested. Conclusions: Metabolism of contaminating bacteria was reduced in the presence of 5 IU ml^?1 nisin, resulting in reduced lactic acid production and increased ethanol production by the yeast. Significance and Impact of the Study: Bacteriocins represent an alternative to the use of antibiotics for the control of bacterial contamination in fuel ethanol plants and may be important in preventing the emergence of antibiotic‐resistant contaminating strains.     

Inactivation of Cronobacter spp. (Enterobacter sakazakii) in infant formula using lactic acid,copper sulfate and monolaurin

Aims: To investigate the effect of lactic acid (LA), copper (II), and monolaurin as natural antimicrobials against Cronobacter in infant formula. Methods and Results: The effect of LA (0·1, 0·2 and 0·3% v/v), copper (II) (10, 50 and 100 μg ml^?1) and monolaurin (1000, 2000, and 3000 μg ml^?1) suspended into tween‐80? or dissolved in ethanol against Cronobacter in infant formula was investigated. Reconstituted infant formula and powdered infant formula were inoculated with five strains of Cronobacter spp. at the levels of c. 1 × 10⁶ CFU ml^?1 and 1 × 10³ CFU g^?1, respectively. LA at 0·2% v/v had a bacteriostatic effect on Cronobacter growth, whereas 0·3% v/v LA resulted in c. 3 log₁₀ reduction. Copper (II) at the levels of 50 μg ml^?1 and 100 μg ml^?1 elicited c. 1 and 2 log₁₀ reductions, respectively. The combination of 0·2% LA and 50 μg ml^?1 copper (II) resulted in a complete elimination of the organism. Monolaurin exhibited a slight inhibitory activity against Cronobacter (c. 1·5 log₁₀ difference) compared to the control when ethanol was used to deliver monolaurin. Conclusions: A complete elimination of Cronobacter was obtained when a combination of sublethal concentrations of LA (0·2%) and copper (II) (50 μg ml^?1) was used. Significance and Impact of the Study: The use of the synergistic interactive combination of LA and copper (II) could be beneficial to control Cronobacter in the infant formula industry.     

Effects of thymol and diphenyliodonium chloride against Campylobacter spp. during pure and mixed culture in vitro

Aims: To determine if the purported deaminase inhibitors diphenyliodonium chloride (DIC) and thymol reduce the growth and survivability of Campylobacter. Methods and Results: Growth rates of Campylobacter jejuni and Camp. coli were reduced compared to unsupplemented controls during culture in Muellar–Hinton broth supplemented with 0·25 μmol DIC or thymol ml^?1 but not with 0·01 μmol monensin ml^?1 or 1% ethanol. Recovery of Camp. jejuni and Camp. coli was reduced >5 log₁₀ CFU from controls after 24 h pure culture in Bolton broth supplemented with 0·25 or 1·0 μmol DIC ml^?1 or with 1·0 μmol thymol ml^?1. Similarly, each test Campylobacter strain was reduced >3 log₁₀ CFU from controls after 24 h mixed culture with porcine faecal microbes in Bolton broth supplemented with 0·25 or 1·0 μmol DIC ml^?1 or with 1·0 μmol thymol ml^?1. Treatments with 0·25 μmol thymol ml^?1, 0·01 μmol monensin ml^?1 or 1% ethanol were less effective. Ammonia production during culture or incubation of cell lysates was reduced by 0·25 or 1·0 μmol DIC ml^?1 but only intermittently reduced, if at all, by the other treatments. Conclusions: Diphenyliodonium chloride and thymol reduced growth, survivability and ammonia production of Camp. jejuni and Camp. coli. Significance and Impact of the Study: Results suggest a potential physiological characteristic that may be exploited to develop interventions.     

In vitro degradation of wheat straw by anaerobic fungi from small ruminants

Abstract

Anaerobic ruminal fungi may play an active role in fibre degradation as evidenced by the production of different fibrolytic enzymes in culture filtrate. In the present study, 16 anaerobic fungal strains were isolated from ruminal and faecal samples of sheep and goats. Based on their morphological characteristics they were identified as species of Anaeromyces, Orpinomyces, Piromyces and Neocallimastix. Isolated Neocallimastix sp. from goat rumen showed a maximum activity of CMCase (47.9 mIU ml^?1) and filter paper cellulase (48.3 mIU ml^?1), while Anaeromyces sp. from sheep rumen showed a maximum xylanolytic activity (48.3 mIU ml^?1). The cellobiase activity for all the isolates ranged from 178.0 – 182.7 mIU ml^?1. Based on the enzymatic activities, isolated Anaeromyces sp. from sheep rumen and Neocallimastix sp. from goat rumen were selected for their potential of in vitro fibre degradation. The highest in vitro digestibility of NDF (23.2%) and DM (34.4%) was shown for Neocallimastix sp. from goat rumen, as compared to the digestibility of NDF and DM in the control group of 17.5 and 25.0%, respectively.     

Nisin A and Polymyxin B as Synergistic Inhibitors of Gram-positive and Gram-negative Bacteria

Nisin A and polymyxin B were tested alone and in combination in order to test their antagonism against Listeria innocua HPB13 and Escherichia coli RR1, respectively. While the combination of both antibacterial substances was synergistically active against both target bacteria, nisin A alone did not show any inhibition of E. coli RR1. The nisin A/polymyxin B combination at 1.56/2.5 μg ml^?1 caused lysis of about 35.86 ± 0.35 and 73.36 ± 0.14% of L. innocua HPB13 cells after 3 and 18 h, respectively. Polymyxin B at 0.12 μg ml^?1 and nisin A/polymyxin B at 4.64/0.12 μg ml^?1 decreased the numbers of viable E. coli RR1 cells by about 0.23 and 0.65 log₁₀ CFU ml^?1, respectively, compared to the control. Our data suggest that the concentration of nisin A required for the effective control of pathogenic strains Listeria spp. could be lowered considerably by combination with polymyxin B. The use of lower concentrations of nisin A or polymyxin B should slow the emergence of bacterial populations resistant to these agents.     

Prevention of the accumulation of Alicyclobacillus in apple concentrate by restricting the continuous process running time

Aims: To study the accumulation of vegetative cells and endospores of Alicyclobacillus, as well as viable aerobic counts during the continuous production of apple juice concentrate. Methods and Results: Apples were processed for a continuous process running time of 108 h (processing rate 1·8–2·0 t h^?1) without clean‐in‐place (CIP) procedures in‐between different batches. Samples from single‐strength apple juice, concentrate after evaporation (±30°Brix), the final product (concentrate pasteurized at 102–104°C for 90 s) and condensate water (by‐product of the juice concentration process) were collected every 12 h. From 12 to 84 h of processing, vegetative Alicyclobacillus counts in single‐strength apple juice increased significantly (P < 0·05) from 1 to 3·15 log₁₀ CFU ml^?1. Accumulation patterns of vegetative cells in apple concentrate and the final product were similar from 24 to 84 h of processing, with the respective counts increasing from 0·13 to 1·63 and 0·01 to 1·69 log₁₀ CFU ml^?1. The highest Alicyclobacillus endospore counts in single‐strength juice, concentrate and the final product was at 84 h of processing with 1·32, 1·59 and 1·64 log₁₀ CFU ml^?1, respectively. Conclusions: Alicyclobacillus vegetative cells and endospores accumulate in fruit concentrates during a continuous process running time of 108 h. Significance and Impact of the Study: In conjunction with good manufacturing practices, fruit concentrate manufactures can minimize Alicyclobacillus accumulation in fruit concentrates by limiting the continuous process running time between clean‐ups to under 84 h.     

Lactobacillus pentosus CECT 4023 T co-utilizes glucose and xylose to produce lactic acid from wheat straw hydrolysate: Anaerobiosis as a key factor

Lactic acid is a versatile chemical that can be produced via fermentation of lignocellulosic materials. The heterolactic strain Lactobacillus pentosus CECT 4023 T, that can consume glucose and xylose, was studied to produce lactic acid from steam exploded wheat straw prehydrolysate. The effect of temperature and pH on bacterial growth was analyzed. Besides, the effect of oxygen on lactic acid production was tested and fermentation yields were compared in different scenarios. This strain showed very high tolerance to the inhibitors contained in the wheat straw prehydrolysate. The highest lactic acid yields based on present sugar, around 0.80 g g⁻¹, were obtained from glucose in presence of 25%, 50%, and 75% v v⁻¹ of prehydrolysate in strict anaerobiosis. Lactic fermentation of wheat straw hydrolysate obtained after enzymatic hydrolysis of the prehydrolysate yielded 0.39 g of lactic acid per gram of released sugars, which demonstrated the high potential of L. pentosus to produce lactic acid from hemicellulosic hydrolysates. Results presented herein not only corroborated the ability of L. pentosus to grow using mixtures of sugars, but also demonstrated the suitability of this strain to be applied as an efficient lactic acid producer in a lignocellulosic biorefinery approach. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 35: e2739, 2019     

Production of thermo-alkali-stable xylanase by a novel polyextremophilic Bacillus halodurans TSEV1 in cane molasses medium and its applicability in making whole wheat bread

A high titre of thermo-alkali-stable xylanase was attained in cane molasses medium. When the culture variables for endoxylanase production were optimized [cane molasses 7 %, soluble alkaline extract of wheat bran (SAE-WB) 37 % and ammonium chloride 0.30 %], a 4.5-fold enhancement in xylanase production (69 U ml^?1) was achieved as compared to that in the unoptimized medium (15 U ml^?1). The enzyme titre attained in shake flasks could be sustained in a 7-l laboratory bioreactor. An activity band corresponding to 40 kDa was visualized on SDS-PAGE zymogram analysis. The enzyme has broad range of pH and temperature for activity with optima at 9.0 and 80 °C, and stable between pH 4.0 and 11.0 with 85 % retention of activity. It has T _1/2 of 40 and 15 min at 70 and 80 °C. The enzyme is halotolerant since it displays activity in the presence of salt up to 15 %, and remains 100 % active in the absence of salt. The supplementation of whole wheat dough with xylanase improves antistaling property, reducing sugar content, bread volume with prebiotic xylooligosaccharides in bread. This is the first report on xylanase production in cane molasses medium with SAE-WB as the inducer and its applicability in whole wheat bread making that improves human health.     

Zinc seed coating improves the growth,grain yield and grain biofortification of bread wheat

This study, comprising three independent experiments, was conducted to optimize the zinc (Zn) application through seed coating for improving the productivity and grain biofortification of wheat. Experiment 1 was conducted in petri plates, while experiment 2 was conducted in sand-filled pots to optimize the Zn seed coating using two sources (ZnSO₄, ZnCl₂) of Zn. In the first two experiments, seeds of two wheat cultivars Lasani-2008 and Faisalabad-2008 were coated with 0.25, 0.50, 0.75, 1.00, 1.25, 1.50, 1.75 and 2.00 g Zn kg^?1 seed using ZnSO₄ and ZnCl₂ as Zn sources. The results of experiment I revealed that seed coating with 1.25 and 1.50 g Zn kg^?1 seed using both sources of Zn improved the seedling emergence. However, seed coated with 1.25 and 1.50 g Zn kg^?1 seed using ZnSO₄ was better regarding improvement in seedling growth and seedling dry weight. The results of the second experiment indicated that seed coated with 1.25 and 1.50 g Zn kg^?1 seed using ZnSO₄ improved the seedling emergence and seedling growth of tested wheat cultivars. However, seed coating beyond 1.5 g Zn kg^?1 seed using either Zn source suppressed the seedling emergence. Third experiment was carried out in glass house in soil-filled earthen pots. Seeds of both wheat cultivars were coated with pre-optimized treatments (1.25, 1.50 g Zn kg^?1 seed) using both Zn sources. Seed coating with all treatments of ZnSO₄ and seed coating with 1.25 g Zn kg^?1 seed using ZnCl₂ improved the seedling emergence and yield-related traits of wheat cultivars. Seed coating with 1.25 g Zn kg^?1 seed also improved the chlorophyll a and b contents. Maximum straw Zn contents, before and after anthesis, were recorded from seed coated with 1.5 g Zn kg^?1 seed using either Zn source. Increase in grain yield from seed coating followed the sequence 1.25 g Zn kg^?1 seed (ZnSO₄) >1.25 g Zn kg^?1 seed (ZnCl₂) >1.5 g Zn kg^?1 seed (ZnSO₄). However, increase in grain Zn contents from seed coated was 1.5 g Zn kg^?1 seed (ZnCl₂) >1.25 and 1.5 g Zn kg^?1 seed (ZnCl₂, ZnSO₄) >1.25 g Zn kg^?1 seed (ZnSO₄). Seed coating with Zn increased the grain Zn contents from 21 to 35 %, while 33–55 % improvement in grain yield was recorded. In conclusion, wheat seeds may be coated with 1.25 g Zn kg^?1 seed using either source of Zn for improving the grain yield and grain Zn biofortification.     

Development and evaluation of Trichoderma asperellum preparation for control of sheath blight of rice (Oryza sativa L.)

Sheath blight, which is caused by Rhizoctonia solani, is a disease that majorly impacts rice production. A biocontrol agent used for control rice sheath blight must be sprayed on the stem at specific times during rice growth, a process that is labour-intensive and renders the antagonist vulnerable to environmental factors. In this study, Trichoderma asperellum T12 was used to produce preparation by solid-state fermentation using a surface-response method. Rice hull was selected as a carrier based on its ability to sustain the T12 floating in the water and protect T12 from ultraviolet irradiation. The production of a T12-based preparation required 32% wheat bran, 7% inoculum, 2.3 g kg^?1 (NH₄)₂SO₄ and 65% water content, with fermentation at 27.5°C for 30 days and agitation every six days. The preparation demonstrated 90% biocontrol efficacy and significantly (P > 0.05) increased the seed-set rate and 1000-grain weight as compared with the pathogen treatment. The population of Trichoderma on the surface of rice leaf sheath in the treatment applied with T12 preparation increased from 232 cfu (colony forming units) g^?1 fw (fresh weight) to 436 cfu g^?1 fw during rice growth stage, which was significantly (P > 0.05) higher than pathogen treatment. The population of R. solani on the leaf sheath increased from 41 cfu g^?1 fw to 271 cfu g^?1 fw in the pathogen treatment, while remained stable (P > 0.05) at level of 10–23 cfu g^?1 fw in T12 preparation applied treatment. Biocontrol of sheath blight by the addition of the preparation to the soil is effective and decreases the costs of agro-industrial waste disposal.     

Enrichment of biologically active 18-β glycyrrhetinic acid in Glycyrrhiza glabra root by solid state fermentation

This paper describes the in situ bioconversion of glycyrrhizin of Glycyrrhiza glabra root to 18-β glycyrrhetinic acid by solid state fermentation. Fermentation was carried out with two different fungal strains, Penicillium chrysogenum and Rhizopus oryzae. The solid state fermentation was carried out under stationary state and under rotating state. Penicillium chrysogenum is a better producer of 18-β glycyrrhetinic acid than Rhizopus oryzae. The induced P. chrysogenum seed culture produces higher 18-β glycyrrhetinic acid with 2.955 mg g^?1 and maximum β-glucuronidase activity of 3,583.8 U ml^?1 under stationary solid state fermentation. The mycelium growth and bioconversion rate is highest at pH of 5.5 and 4.5, respectively. G. glabra root supplemented with a solution of dextrose 9 g l^?1, MnSO₄?·?H₂O 3 g l^?1 and (NH₄)₂SO₄ 0.540 g l^?1 produces 48.580 mg of 18-β glycyrrhetinic acid per gram of G. glabra root, i.e. 86.74 % bioconversion by P. chrysogenum in 96 h under stationary state solid state fermentation.     

Assessment of nitrate leaching loss on a yield-scaled basis from maize and wheat cropping systems

Background and aims

It is so far a gap in knowledge to assess nitrate (NO₃ ^?) leaching loss linking with crop yield for a given cereal cropping system.

Methods

We conducted a meta-analysis on 32 published studies reporting both NO₃ ^? leaching losses and crop yields in the maize (N?=?20) and wheat (N?=?12) systems.

Results

On average, 22 % and 15 % of applied fertilizer N to wheat and maize systems worldwide are leached in the form of NO₃ ^?, respectively. The average area-scaled NO₃ ^- leaching loss for maize (57.4 kg N ha^?1) was approx. two times higher than for wheat (29.0 kg N ha^?1). While, if scaled to crop yields, the average yield-scaled NO₃ ^? losses were comparable between maize (5.40 kg N Mg^?1) and wheat (5.41 kg N Mg^?1) systems. Across all sites, the lowest yield-scaled NO₃ ^? leaching losses were observed at slightly suboptimal fertilization rates, corresponding to 90 % and 96 % of maximum maize or wheat yields, respectively.

Conclusions

Our findings suggest that small adjustments of agricultural N management practices can effectively reduce yield-scaled NO₃ ^? leaching losses. However, further targeted field experiments are still needed to identify at regional scale best agricultural management practices for reducing yield-scaled NO₃ ^? leaching losses in maize and wheat systems.     

Enhanced production of gibberellin A4 (GA4) by a mutant of Gibberella fujikuroi in wheat gluten medium

Mutants of Gibberella fujikuroi with different colony characteristics, morphology and pigmentation were generated by exposure to UV radiation. A mutant, Mor-189, was selected based on its short filament length, relatively high gibberellin A₄ (GA₄) and gibberellin A₃ (GA₃) production, as well as its lack of pigmentation. Production of GA₄ by Mor-189 was studied using different inorganic and organic nitrogen sources, carbon sources and by maintaining the pH of the fermentation medium using calcium carbonate. Analysis of GA₄ and GA₃ was done by reversed-phase high-performance liquid chromatography and LC-MS. The mutants of G. fujikuroi produced more GA₄ when the pH of the medium was maintained above 5. During shake flask studies, the mutant Mor-189 produced 210 mg l^?1 GA₄ in media containing wheat gluten as the nitrogen source and glucose as the carbon source. Fed-batch fermentation in a 14 l agitated fermenter was performed to evaluate the applicability of the mutant Mor-189 for the production of GA₄. In 7-day fed-batch fermentation, 600 mg l^?1 GA₄ were obtained in the culture filtrate. The concentration of GA₄ and GA₃ combined was 713 mg l^?1, of which GA₄ accounted for 84% of the total gibberellin. These values are substantially higher than those published previously. The present study indicated that, along with maintenance of pH and controlled glucose feeding, the use of wheat gluten as the sole nitrogen source considerably enhances GA₄ production by the mutant Mor-189.     

Boza, a natural source of probiotic lactic acid bacteria

Aims: To evaluate the probiotic properties of strains isolated from boza, a traditional beverage produced from cereals. Methods and Results: The strains survived low pH conditions (pH 3·0), grew well at pH 9·0 and were not inhibited by the presence of 0·3% (w/v) oxbile. Cytotoxicity levels of the bacteriocins, expressed as CC₅₀, ranged from 38 to 3776 μg ml^?1. Bacteriocin bacST284BZ revealed high activity (EC₅₀ = 735 μg ml^?1) against herpes simplex virus type 1. Growth of Mycobacterium tuberculosis was 69% repressed after 5 days in the presence of bacST194BZ. Various levels of auto‐cell aggregation and co‐aggregation with Listeria innocua LMG 13568 were observed. Adhesion of the probiotic strains to HT‐29 cells ranged from 18 to 22%. Conclusions: Boza is a rich source of probiotic lactic acid bacteria. All strains survived conditions simulating the gastrointestinal tract and produced bacteriocins active against a number of pathogens. Adherence to HT‐29 and Caco‐2 cells was within the range reported for Lactobacillus rhamnosus GG, a well‐known probiotic. In addition, the high hydrophobicity readings recorded define the strains as good probiotics. Significance and Impact of the Study: Boza contains a number of different probiotic lactic acid bacteria and could be marketed as a functional food product.     

Root colonisation of Pseudomonas aeruginosa strain UPMP3 and induction of defence‐related genes in oil palm (Elaeis guineensis)

Pseudomonas aeruginosa strain UPMP3 labelled with β‐glucuronidase (gusA) and green fluorescent protein (gfp) by electrotransformation yielded ca 1 × 10⁷ transformants µg^?1 DNA. The data obtained from the dilution plate count showed that over 28 days both epiphytic and endophytic populations of P. aeruginosa strain UPMP3 increased from 5.76 log₁₀ [colony forming unit (CFU) + 1] g^?1 fresh weight (FW) to 8.19 log₁₀ (CFU + 1) g^?1 FW and 4.10 log₁₀ (CFU + 1) g^?1 FW to 6.23 (CFU + 1) g^?1 FW, respectively. Confocal laser scanning microscopic analysis of oil palm roots treated with gusA:gfp‐tagged P. aeruginosa strain UPMP3 showed intense root colonisation over the sampling period. The root surface colonisation by P. aeruginosa strain UPMP3 was followed by a second stage, characterised by cortical infection, and a third stage, which involves xylem ingression. The colonisation of oil palm roots by the gusA:gfp‐tagged strain was concentrated on root areas potentially rich in nutrients such as the elongation zones, ridges between epidermal cells and points of secondary adventitious root emergence. Different expression levels of defence‐related genes, namely, chitinase and β‐1,3‐glucanase in the strain UPMP3–host interaction recorded over 28 days, suggested the potential role of P. aeruginosa strain UPMP3 in triggering the defence mechanism in oil palm. This is the first report on root colonisation and upregulation of defence‐related genes on oil palm roots by P. aeruginosa strain UPMP3 and shows the potential of this strain to be used as a biocontrol agent in oil palm.     

Effects of lactic acid fermentation and gamma irradiation of barley on antinutrient contents and nutrient digestibility in mink (Mustela vison) with and without dietary enzyme supplement

Abstract

The experiment was conducted to study the effects of fermentation of barley, using two different strains of lactic acid bacteria, a Lactobacillus plantarum/pentosus strain isolated from spontaneously fermented rye sourdough (AD2) and a starch-degrading Lactobacillus plantarum (AM4), on contents of mixed-linked (1 → 3) (1 → 4)-β-glucans, α-amylase inhibitor activity, inositol phosphates, and apparent digestibility of macronutrients in mink. Effects of fermentation were compared with effects of gamma irradiation (γ-irradiation: ⁶⁰Co γ-rays at 25 kGy). The diets were fed to mink with and without a supplementary enzyme preparation. Both lactic acid fermentation and γ-irradiation followed by soaking and incubation, reduced concentrations of soluble β-glucans, phytate and α-amylase inhibitor activity. Dietary enzyme supplementation increased significantly digestibility of crude protein, fat, starch and crude carbohydrate (CHO). Fermentation of the barley increased digestibility of starch and CHO. Fermentation with lactic acid bacteria AD2 resulted in higher starch and CHO digestibility than strain AM4, and had greater effect than γ-irradiation, soaking and incubation. The highest digestibility of starch and CHO was obtained after AD2 fermentation followed by enzyme supplementation. It is concluded that both lactic acid fermentation of barley and enzyme supplementation have positive nutritional implications in the mink by limiting the effects of antinutrients and improving digestibility and energy utilization.     

Production of aglycone protopanaxatriol from ginseng root extract using Dictyoglomus turgidum β-glycosidase that specifically hydrolyzes the xylose at the C-6 position and the glucose in protopanaxatriol-type ginsenosides

The hydrolytic activity of a recombinant β-glycosidase from Dictyoglomus turgidum that specifically hydrolyzed the xylose at the C-6 position and the glucose in protopanaxatriol (PPT)-type ginsenosides followed the order Rf > Rg₁ > Re > R₁ > Rh₁ > R₂. The production of aglycone protopanaxatriol (APPT) from ginsenoside Rf was optimal at pH 6.0, 80 °C, 1 mg ml^?1 Rf, and 10.6 U ml^?1 enzyme. Under these conditions, D. turgidum β-glycosidase converted ginsenoside R₁ to APPT with a molar conversion yield of 75.6 % and a productivity of 15 mg l^?1 h^?1 after 24 h by the transformation pathway of R₁ → R₂ → Rh₁ → APPT, whereas the complete conversion of ginsenosides Rf and Rg₁ to APPT was achieved with a productivity of 1,515 mg l^?1 h^?1 after 6.6 h by the pathways of Rf → Rh₁ → APPT and Rg₁ → Rh₁ → APPT, respectively. In addition, D. turgidum β-glycosidase produced 0.54 mg ml^?1 APPT from 2.29 mg ml^?1 PPT-type ginsenosides of Panax ginseng root extract after 24 h, with a molar conversion yield of 43.2 % and a productivity of 23 mg l^?1 h^?1, and 0.62 mg ml^?1 APPT from 1.35 mg ml^?1 PPT-type ginsenosides of Panax notoginseng root extract after 20 h, with a molar conversion yield of 81.2 % and a productivity of 31 mg l^?1 h^?1. This is the first report on the APPT production from ginseng root extract. Moreover, the concentrations, yields, and productivities of APPT achieved in the present study are the highest reported to date.