Acetate Degradation at 70 degrees C in Upflow Anaerobic Sludge Blanket Reactors and Temperature Response of Granules Grown at 70 degrees C

Anaerobic acetate degradation at 70 degrees C and at 55 degrees C (as a reference) was studied by running laboratory upflow anaerobic sludge blanket (UASB) reactors inoculated with mesophilic granular sludge. In UASB reactors fed with acetate-containing media (3 g of chemical oxygen demand [COD] per liter, corresponding to 47 mM acetate) approximately 50 days was needed at 70 degrees C and less than 15 days was needed at 55 degrees C to achieve an effluent COD of 500 to 700 mg/liter. In the UASB reactors at both 70 and 55 degrees C up to 90% of the COD was removed. Batch assays showed that sludges from two 70 degrees C UASB reactors, one run at a low effluent acetate concentration and the other run at a high effluent acetate concentration, exhibited slightly different responses to temperatures in the range from 37 to 70 degrees C. Both 70 degrees C sludges, as well as the 55 degrees C sludge, produced methane at temperatures of 37 to 73 degrees C. The 55 degrees C sludge exhibited shorter lag phases than the 70 degrees C sludges and higher specific methane production rates between 37 and 65 degrees C.     

Effects of Temperature on Methanogenesis in a Thermophilic (58°C) Anaerobic Digestor

The short-term effects of temperature on methanogenesis from acetate or CO₂ in a thermophilic (58°C) anaerobic digestor were studied by incubating digestor sludge at different temperatures with ¹⁴C-labeled methane precursors (¹⁴CH₃COO⁻ or ¹⁴CO₂). During a period when Methanosarcina sp. was numerous in the sludge, methanogenesis from acetate was optimal at 55 to 60°C and was completely inhibited at 65°C. A Methanosarcina culture isolated from the digestor grew optimally on acetate at 55 to 58°C and did not grow or produce methane at 65°C. An accidental shift of digestor temperature from 58 to 64°C during this period caused a sharp decrease in gas production and a large increase in acetate concentration within 24 h, indicating that the aceticlastic methanogens in the digestor were the population most susceptible to this temperature increase. During a later period when Methanothrix sp. was numerous in the digestor, methanogenesis from ¹⁴CH₃COO⁻ was optimal at 65°C and completely inhibited at 75°C. A partially purified Methanothrix enrichment culture derived from the digestor had a maximum growth temperature near 70°C. Methanogenesis from ¹⁴CO₂ in the sludge was optimal at 65°C and still proceeded at 75°C. A CO₂-reducing Methanobacterium sp. isolated from the digestor was capable of methanogenesis at 75°C. During the period when Methanothix sp. was apparently dominant, sludge incubated for 24 h at 65°C produced more methane than sludge incubated at 60°C, and no acetate accumulated at 65°C. Methanogenesis was severely inhibited in sludge incubated at 70°C, but since neither acetate nor H₂ accumulated, production of these methanogenic substrates by fermentative bacteria was probably the most temperature-sensitive process. Thus, there was a correlation between digestor performance at different temperatures and responses to temperature by cultures of methanogens believed to play important roles in the digestor.     

Thermophilic (55-65 degrees C) and extreme thermophilic (70-80 degrees C) sulfate reduction in methanol and formate-fed UASB reactors

The feasibility of thermophilic (55-65 degrees C) and extreme thermophilic (70-80 degrees C) sulfate-reducing processes was investigated in three lab-scale upflow anaerobic sludge bed (UASB) reactors fed with either methanol or formate as the sole substrates and inoculated with mesophilic granular sludge previously not exposed to high temperatures. Full methanol and formate degradation at temperatures up to, respectively, 70 and 75 degrees C, were achieved when operating UASB reactors fed with sulfate rich (COD/SO4(2-)=0.5) synthetic wastewater. Methane-producing archaea (MPA) outcompeted sulfate-reducing bacteria (SRB) in the formate-fed UASB reactor at all temperatures tested (65-75 degrees C). In contrast, SRB outcompeted MPA in methanol-fed UASB reactors at temperatures equal to or exceeding 65 degrees C, whereas strong competition between SRB and MPA was observed in these reactors at 55 degrees C. A short-term (5 days) temperature increase from 55 to 65 degrees C was an effective strategy to suppress methanogenesis in methanol-fed sulfidogenic UASB reactors operated at 55 degrees C. Methanol was found to be a suitable electron donor for sulfate-reducing processes at a maximal temperature of 70 degrees C, with sulfide as the sole mineralization product of methanol degradation at that temperature.     

Thermophilic anaerobic treatment of sulphur rich forest industry wastewater

Thermophilic anaerobic treatment of sulphur-rich paper mill wastewater (0.8-3.1 gCOD/l, 340–850 mgSO₄/l; COD:SO₄ 3.4-5.3) was studied in three laboratory-scale, upflow anaerobic sludge blanket (UASB) reactors and in bioassays. The reactors were inoculated with non-adapted thermophilic granular sludge. In the bioassays, no inhibition of the inoculum was detected and about 62% COD removal (sulphide stripped) was obtained. About 70 to 80% of the removed COD was methanised. In the reactors, up to 60–74% COD removal (effluent sulphide stripped) was obtained at loading rates up to 10–30 kgCOD/m³d and hydraulic retention times down to 6 to 2 hours. The effluent total sulphide was up to 150–250 mg/l. Sulphide inhibition could not be confirmed from the reactor performances. The results from bioassays suggested that both the inoculum and sludge from the UASB reactor used acetate mainly for methane production, while sulphide was produced from hydrogen or its precursors.     

Microbial characteristics of methanogenic sludge consortia developed in thermophilic U ASB reactors

The effect of temperature on granulation and microbial interaction of anaerobic sludges grown in thermophilic upflow anaerobic sludge bed (UASB) reactors was investigated at two different temperatures, 55°C (Run 1) and 65°C (Run 2). Each run consisted of two phases. Phase 1 was conducted by feeding acetate for a period of 200 days. In Phase 2, both reactors were fed a mixture of acetate and sucrose for a further 100 days. During Phase 1, no granulation occurred in the sludge of either run. Microscopic observation revealed that the predominant methanogen was Methanothrix in Run 1, whereas Methanobacterium-like bacteria existed to a significant extent in Run 2. The acetate-utilizing methanogenic activity of both sludges increased with increasing test temperature in the range 55–65°C. Since the acetate-grown sludges exhibited far higher H₂-utilizing methanogenic activity than acetate-utilizing methanogenic activity, it is suggested that a syntrophic association of acetate-oxidizing bacteria with hydrogenotrophic methanogens was responsible for a considerable portion of the overall acetate elimination in thermophilic anaerobic sludge. During Phase 2, granules coated with either filamentous bacteria or cocci-type bacteria (both presumably acid-forming bacteria) were successfully established in Run 1 and Run 2, respectively. Since the acetate-utilizing methanogenic activities of the granular sludges were four to five times higher than those of the acetate-grown sludges (Phase 1), the co-existence of these coating bacteria appeared to contribute to the enclosing of acetate consumers inside granules. Correspondence to: S. Uemura     

Thermophilic (55 degrees C) conversion of methanol in methanogenic-UASB reactors: influence of sulphate on methanol degradation and competition

Two upflow sludge bed reactors (UASB) were operated for 80 days at 55 degrees C with methanol as the substrate with an organic loading rate (OLR) of about 20 g CODl(-1) per day and a hydraulic retention time (HRT) of 10 h. One UASB was operated without sulphate addition (control reactor-R1) whereas the second was fed with sulphate at a COD:SO4(2-) ratio of 10 (sulphate-fed reactor-R2), providing an influent sulphate concentration of 0.6 g l(-1). For both reactors, methanogenesis was the dominant process with no considerable accumulation of acetate. The methanol removal averaged 93% and 83% for R1 and R2, respectively, and total sulphate removal was achieved in the latter. The pathway of methanol conversion for both sludges was investigated by measuring the fate of carbon in the presence and absence of bicarbonate or specific inhibitors for a sludge sample collected at day 72. In both sludges, about 70% of the methanol was syntrophically converted to methane and/or sulphide, via the intermediate H2/CO2. A strong competition between methanogens and sulphidogens took place in the R2 sludge with half of the methanol-COD being used by methane-producing bacteria and the other half by sulphate-reducing bacteria. Acetate was not an important intermediate for both sludges, and played a slightly more important role for the sulphate-adapted sludge (R2), sustained by the higher amount of bicarbonate produced during sulphate-reduction. The pathway study indicates that, although acetate does not represent an important intermediate, the system is susceptible to its accumulation.     

Growth of Rhizobium japonicum Strains at Temperatures Above 27°C

A study was conducted to examine the growth responses of different Rhizobium japonicum strains to increasing temperatures, determine the degree of variability among strains in those responses, and identify temperature-related growth characteristics that could be used to select temperature-tolerant strains. Each of 42 strains was grown in liquid culture for 96 h at 19 incubation temperatures ranging from 27.4 to 54.1°C in a temperature gradient apparatus. Growth was estimated by measuring the change in optical density over time. Strains differed in their responses to increasing temperatures. Three characteristic temperatures were determined for each strain: the temperature giving the maximum optical density at 96 h (optimum temperature), the maximum temperature allowing a continuous increase in optical density during the 96-h period (maximum permissive temperature), and the maximum temperature allowing growth of the cultures after they were transferred to a uniform incubation temperature of 28°C (maximum survival temperature). The three characteristic temperatures varied among strains and had the following ranges: optimum temperature, from 27.4 to 35.2°C; maximum permissive temperature, from 29.8 to 38.0°C; and maximum survival temperature, from 33.7 to 48.7°C. Significant positive correlations were found between maximum permissive temperature and optimum temperature and between maximum permissive temperature and maximum survival temperature. Eight strains which had the highest maximum permissive temperature, optimum temperature, and maximum survival temperature were considered tolerant of high temperatures and were able to grow at temperatures higher than those previously reported for the most tolerant R. japonicum strains. The strains were of diverse geographical origin, but the response to high temperatures was not related to their origin. Evaluation of the temperature responses in pure culture may be useful in the search for R. japonicum strains better suited to environments in which high soil temperature is a limiting factor.     

Acetate treatment in 70°C upflow anaerobic sludge-blanket (UASB) reactors: start-up with thermophilic inocula and the kinetics of the UASB sludges

This study focused on the use of thermophilic anaerobic granulae in the start-up of 70°C acetate-fed upflow anaerobic sludge-blanket (UASB) reactors and the kinetics of granulae grown at 70°C. In the UASB reactors, chemical oxygen demand removal commenced within 48 h of the start-up. The maximum reduction in chemical oxygen demand was 84% with the feed containing yeast and 71% without a yeast supplement. In the bioassays, the yeast-grown sludge converted 98% of the acetate consumed to methane as compared to 92% for the sludge grown without yeast. The highest initial specific methane production rate (µ_{CH 4}) of the UASB sludges grown at 70°C was 0.088 h^–1 at an acetate concentration of 4.6 mM. The higher initial acetate concentration was found to prolong the lag-phase in methane production significantly and to decrease the µ_{CH 4}. The half-saturation constant (K _s), the inhibition constant (K _i), the inhibition response coefficient (n), and the µ_{CH 4} ^max, calculated according to a modified Haldane equation, were 1.5 mM, 2.8 mM, 0.8, and 0.28 h^–1, respectively. The prolonged starvation of the 70°C sludge (15 days) decreased the µ_{CH 4} from about 0.022 h^–1 to 0.011 h^–1 and increased the lag phase in methane production from 6 h to 24 h as compared to non-starved sludge.     

Bacterial Activity at −2 to −20°C in Arctic Wintertime Sea Ice

Arctic wintertime sea-ice cores, characterized by a temperature gradient of −2 to −20°C, were investigated to better understand constraints on bacterial abundance, activity, and diversity at subzero temperatures. With the fluorescent stains 4′,6′-diamidino-2-phenylindole 2HCl (DAPI) (for DNA) and 5-cyano-2,3-ditoyl tetrazolium chloride (CTC) (for O₂-based respiration), the abundances of total, particle-associated (>3-μm), free-living, and actively respiring bacteria were determined for ice-core samples melted at their in situ temperatures (−2 to −20°C) and at the corresponding salinities of their brine inclusions (38 to 209 ppt). Fluorescence in situ hybridization was applied to determine the proportions of Bacteria, Cytophaga-Flavobacteria-Bacteroides (CFB), and Archaea. Microtome-prepared ice sections also were examined microscopically under in situ conditions to evaluate bacterial abundance (by DAPI staining) and particle associations within the brine-inclusion network of the ice. For both melted and intact ice sections, more than 50% of cells were found to be associated with particles or surfaces (sediment grains, detritus, and ice-crystal boundaries). CTC-active bacteria (0.5 to 4% of the total) and cells detectable by rRNA probes (18 to 86% of the total) were found in all ice samples, including the coldest (−20°C), where virtually all active cells were particle associated. The percentage of active bacteria associated with particles increased with decreasing temperature, as did the percentages of CFB (16 to 82% of Bacteria) and Archaea (0.0 to 3.4% of total cells). These results, combined with correlation analyses between bacterial variables and measures of particulate matter in the ice as well as the increase in CFB at lower temperatures, confirm the importance of particle or surface association to bacterial activity at subzero temperatures. Measuring activity down to −20°C adds to the concept that liquid inclusions in frozen environments provide an adequate habitat for active microbial populations on Earth and possibly elsewhere.     

Survival of Clinical and Poultry-Derived Isolates of Campylobacter jejuni at a Low Temperature (4°C)

Campylobacter jejuni is a leading cause of bacterial gastroenteritis in humans, and contamination of poultry has been implicated in illness. The bacteria are fastidious in terms of their temperature requirements, being unable to grow below ca. 31°C, but have been found to be physiologically active at lower temperatures and to tolerate exposure to low temperatures in a strain-dependent manner. In this study, 19 field isolates of C. jejuni (10 of clinical and 9 of poultry origin) were studied for their ability to tolerate prolonged exposure to low temperature (4°C). Although substantial variability was found among different strains, clinical isolates tended to be significantly more likely to remain viable following cold exposure than poultry-derived strains. In contrast, the relative degree of tolerance of the bacteria to freezing at −20°C and freeze-thawing was strain specific but independent of strain source (poultry versus clinical) and degree of cold (4°C) tolerance.     

Start-up of a thermophilic upflow anaerobic sludge bed (UASB) reactor with mesophilic granular sludge

Summary Fast start-up of thermophilic upflow anaerobic sludge bed (UASB) reactors was achieved at process temperatures of 46, 55 and 64° C, using mesophilic granular sludge as inoculum and fatty acid mixtures as feed. The start-up was brought about by increasing the temperature of mesophilic UASB reactors in a single step, which initially led to a sharp drop in the methane production rate. Thereafter, stable thermophilic methanogenesis was achieved within a period of 1 or 2 weeks depending on the temperature of operation. Mesophilic granules functioned initially as effective carrier material for thermophilic organisms. However, long-term operation led to disintegration of the granules, resulting in wash-out of thermophilic biomass. The temperature optima for acetotrophic methanogenic activity of the sludges cultivated at 46, 55 and 64° C, were similar, but differed significantly from the temperature optimum of the mesophilic inoculum. All the sludges examined were dominated by Methanothrix-like rods. These could be distinguished by antigenic fingerprinting into two subpopulations, one predominant at 36° C and the other predominant at 46° C and above. Offprint requests to: J. B. van Lier     

Conjugal Transfer of R-Plasmid R1drd-19 in Escherichia coli Below 22°C

The conjugal transfer of R-plasmids is known to occur at temperatures above 22°C. We found that R1drd-19 is transferable below 22°C, and we discuss this finding in the context of plasmid transfer in environmental waters.     

High-Efficiency Carbohydrate Fermentation to Ethanol at Temperatures above 40°C by Kluyveromyces marxianus var. marxianus Isolated from Sugar Mills

A number of yeast strains, isolated from sugar cane mills and identified as strains of Kluyveromyces marxianus var. marxianus, were examined for their ability to ferment glucose and cane syrup to ethanol at high temperatures. Several strains were capable of rapid fermentation at temperatures up to 47°C. At 43°C, >6% (wt/vol) ethanol was produced after 12 to 14 h of fermentation, concurrent with retention of high cell viability (>80%). Although the type strain (CBS 712) of K. marxianus var. marxianus produced up to 6% (wt/vol) ethanol at 43°C, cell viability was low, 30 to 50%, and the fermentation time was 24 to 30 h. On the basis of currently available strains, we suggest that it may be possible by genetic engineering to construct yeasts capable of fermenting carbohydrates at temperatures close to 50°C to produce 10 to 15% (wt/vol) ethanol in 12 to 18 h with retention of cell viability.     

Methanosarcinaceae and Acetate-Oxidizing Pathways Dominate in High-Rate Thermophilic Anaerobic Digestion of Waste-Activated Sludge

This study investigated the process of high-rate, high-temperature methanogenesis to enable very-high-volume loading during anaerobic digestion of waste-activated sludge. Reducing the hydraulic retention time (HRT) from 15 to 20 days in mesophilic digestion down to 3 days was achievable at a thermophilic temperature (55°C) with stable digester performance and methanogenic activity. A volatile solids (VS) destruction efficiency of 33 to 35% was achieved on waste-activated sludge, comparable to that obtained via mesophilic processes with low organic acid levels (<200 mg/liter chemical oxygen demand [COD]). Methane yield (VS basis) was 150 to 180 liters of CH₄/kg of VS_added. According to 16S rRNA pyrotag sequencing and fluorescence in situ hybridization (FISH), the methanogenic community was dominated by members of the Methanosarcinaceae, which have a high level of metabolic capability, including acetoclastic and hydrogenotrophic methanogenesis. Loss of function at an HRT of 2 days was accompanied by a loss of the methanogens, according to pyrotag sequencing. The two acetate conversion pathways, namely, acetoclastic methanogenesis and syntrophic acetate oxidation, were quantified by stable carbon isotope ratio mass spectrometry. The results showed that the majority of methane was generated by nonacetoclastic pathways, both in the reactors and in off-line batch tests, confirming that syntrophic acetate oxidation is a key pathway at elevated temperatures. The proportion of methane due to acetate cleavage increased later in the batch, and it is likely that stable oxidation in the continuous reactor was maintained by application of the consistently low retention time.     

Effect of Temperature and Retention Time on Methane Production from Beef Cattle Waste

The effect of temperature and retention time on the rate of methane production from waste of beef cattle fed a finishing diet was investigated by using continuously mixed 3-liter working volume anaerobic fermentors. The temperatures ranged from 30 to 65°C with 5°C increments between fermentors. The fermentors were fed once per day with 6% volatile solids (organic matter). Retention time for each temperature was varied from 18 to 2.5 days. After 3-volume turnovers, samples were obtained on 4 consecutive days. The highest methane production rate (liters/liter of fermentor per day) and methane yield at that rate (liters/gram of volatile solids) were 1.27 and 0.19 at 9 days and 30°C, 1.60 and 0.16 at 6 days and 35°C, 2.28 and 0.23 at 6 days and 40°C, 2.42 and 0.24 at 6 days and 45°C, 2.83 and 0.14 at 3 days and 50°C, 2.75 and 0.14 at 3 days and 55°C, 3.18 and 0.14 at 2.5 days and 60°C, and 1.69 and 0.17 at 6 days and 65°C. Volatile solids degradation at these retention times and temperatures was between 46 and 54%. The concentrations of volatile acids in the 30 to 55°C fermentors were generally below 2,000 mg/liter, with the exception of the 3-day retention time. The 60 and 65°C fermentors were usually above this level for all retention times. These studies indicate potential rates of methane production from the fermentation of untreated waste of beef cattle fed high-grain finishing diets. This information should serve as preliminary guidelines for various kinetic analyses and aid in economic evaluations of the potential feasibility of fermenting beef cattle waste to methane.     

Scanning electron microscopy of biofilm development in anaerobic fixed-bed reactors: Influence of the inoculum

Summary Scanning electron microscopy was applied to evaluate the influence of inoculum on efficiency of initial biofilm formation and reactor performance. Five anaerobic fixed-bed reactors were inoculated with anaerobic sludges from different sources and operated in parallel under identical conditions with defined wastewater and acetate, propionate and butyrate as constituents In all sludges Methanothrix sp. was the predominant acetotroph. The reactors inoculated with anaerobic sludge adapted to the wastewater achieved the highest space loading with 21.0 g COD/l·d after 58 days. The inoculation with granular sludge from an upflow anaerobic sludge blanket (UASB) reactor resulted in significantly less reactor efficiency. Time course of biofilm formation and biofilm thickness (ranging from 20–200 m) depended on the type of inoculum.     

Solid Medium for Culturing Black Smoker Bacteria at Temperatures to 120°C

A solid, highly thermostable medium, based on the new gelling agent GELRITE, was devised to facilitate the culturing of extremely thermophilic microorganisms from submarine hydrothermal vents. The medium remained solid at temperatures to 120°C at vapor pressures and hydrostatic pressures to 265 atm. It proved useful to its maximum tested limits in isolating colonies of black smoker bacteria from hydrothermal fluids recently collected at the Juan de Fuca Ridge in the Pacific Ocean.     

Adaptation of Phytoplankton-Degrading Microbial Communities to Thermal Reactor Effluent in a New Cooling Reservoir

In water column and sediment inocula from a nuclear reactor cooling reservoir, natural phytoplankton substrate labeled with ¹⁴C was used to determine aerobic and anaerobic mineralization rates for a range of temperatures (25, 40, 55, and 70°C) expected during reactor operation. For experiments that were begun during reactor shutdown, aerobic decomposition occurred at temperatures of <55°C. After 2 months of reactor operation, aerobic rates increased substantially at 55 and 70°C, although maximum rates were observed at temperatures of ≤40°C. The temperature range for which maximum anaerobic mineralization (i.e., the sum of CH₄ and CO₂) was observed was 25 to 40°C when the reactor was off, expanding to 25 to 55°C during reactor operation. Increased rates at 55°C, but not 70°C, correlated with an increase in the ratio of cumulative methane to carbon dioxide produced over 21 days. When reduced reactor power lowered the maximum temperature of the reservoir to 42°C, aerobic decomposition at 70°C was negligible, but remained substantial at 55°C. Selection for thermophilic decomposers occurred rapidly in this system in both aerobic and anaerobic communities and did not require prolonged exposure to elevated temperatures.     

Cultivation Techniques for Hyperthermophilic Archaebacteria: Continuous Culture of Pyrococcus furiosus at Temperatures near 100°C

A system which allows continuous cultivation of hyperthermophilic archaebacteria at temperatures approaching 100°C has been developed. Continuous cultivation of the hyperthermophile Pyrococcus furiosus was carried out with this system; the resulting dilution rate and gas production profiles are discussed.     

The Rejoining Time of Chromatid Breaks Induced by Gamma Radiation in Vicia faba Root Tips at 3 °C

The observation was made previously that the reduction in radiosensitivity in Vicia faba (as measured by postirradiation root growth) by prolonging the exposure time from about 10 minutes to 24 hours is much less marked at 3°C. than at 19°C. If chromosome damage is mainly responsible for the reduced root growth, this observation might be explained by a smaller drop in the "two-hit" aberration component, resulting from an increased time for which breaks are available for rejoining at 3°C. This hypothesis was tested by comparing chromatid aberration frequencies in root meristem cells produced by 105 rads of ⁶⁰Co γ rays, given at dose rates of 19.4 and 0.073 rads per minute. Beans were maintained in aerated water at 2°C. prior to and during irradiation, and at this temperature the rate of development of cells was such that the two different exposure times both occupied a period during which the cell sensitivity was approximately constant. Immediately subsequent to irradiation, the roots were returned to 19°C. and examined cytologically. All chromatid aberrations were less frequent after low dose rate treatment, but only the chromatid interchange reduction was significant. The average time for which breaks are available for reunion, calculated from Lea's G function, was found to be 12 hours (95 per cent C.L. 6 to 24 hours).