Intracellular reaction rates,enzyme activities and biomass yields in Methylomonas L3: growth rate and substrate composition effects

Summary The effects of specific growth rate and medium feed composition on the metabolic reactions of methanol incorporation and oxidation have been studied in carbon-limited, chemostatic cultures of Methylomonas L3. An in situ radioisotopic tracer technique was employed. The in vivo rates of substrate-carbon flow and the corresponding steady-state levels of several key RuMP-type methylotrophic enzymes were determined over a range of dilution rates from 0.19 to 0.41 h^-1 on methanol and methanol/formaldehyde substrates. It was determined that an absolute correlation does not exist between the in vivo specific carbon flux and the in vitro specific activity of any of the key enzymes studied. Oxidation of substrate-carbon via 6-phosphogluconate dehydrogenase is not stringently regulated in this methylotroph and the extent of its operation may be dependent on kinetic factors which make immediate cellular detoxification of formaldehyde imperative. As such, the cyclic oxidation mechanism in this methylotroph does not appear to be coupled to efficient energy utilization, since it was observed that high levels of the cyclic oxidation flux are commensurate with depressed biomass yields.     

Metabolism of monocarbon compounds during biological purification of sewage waters]

Pathways and rates of metabolism of three 14C1-compounds (methanol, formaldehyde, and formic acid) were investigated by means of the heterogeneous population of activated sludge microorganisms. For the above microbial population formaldehyde was the primary or preferential substrate. During an hour aeration it was processed by activated sludge 6 times faster than by sodium formiate and 2 times faster than by methanol. The basic pathways of its transformation were oxidation via formiate to CO2 with its partial reutilization and direct incorporation into the sludge biomass via the primary formation of serine. An addition of methanol increased the incorporation of 14C-formadehyde into biomass and decreased the formation of free 14CO2. The main mechanism of the transformation of 14C-formiate in activated sludge was its oxidation to CO2. An addition of methanol and formaldehyde induced no essential changes in the rate or pattern of their metabolism.     

Direct measurement of carbon substrate oxidation and incorporation patterns in RuMP-type methylotrophs: Chemostatic cultures of Methylomonas L3

A technique using C-14 isotope tracers to probe the branching of carbon flow in methylotrophic bacteria has been devised and applied to continuous steady-state cultures. Methylomonas L3, a strain which utilizes the KDPG/TA variant of the ribulose monophosphate cycle for carbon fixation, was employed in the experimental studies. The actual in vivo rates of substrate-carbon incorporation into biomass, both direct and via CO(2), and of the two carbon oxidation schemes were determined in three different steady-state cultures. The results show that the carbon substrate is oxidized predominantly via formate (the linear oxidation scheme), and that the cyclic scheme of oxidation is minimally, if at all, utilized. The carbon incorporation and oxidation patterns appear to vary considerably with the dilution rate and the inoculum history. The experimental accuracy of the new technique is discussed in detail.     

Core pathways operating during methylotrophy of Bacillus methanolicus MGA3 and induction of a bacillithiol‐dependent detoxification pathway upon formaldehyde stress

Bacillus methanolicus MGA3 is a model facultative methylotroph of interest for fundamental research and biotechnological applications. Previous research uncovered a number of pathways potentially involved in one‐carbon substrate utilization. Here, we applied dynamic ¹³C labeling to elucidate which of these pathways operate during growth on methanol and to uncover potentially new ones. B. methanolicus MGA3 uses the assimilatory and dissimilatory ribulose monophosphate (RuMP) cycles for conversion of the central but toxic intermediate formaldehyde. Additionally, the operation of two cofactor‐dependent formaldehyde oxidation pathways with distinct roles was revealed. One is dependent on tri‐ and tetraglutamylated tetrahydrofolate (THF) and is involved in formaldehyde oxidation during growth on methanol. A second pathway was discovered that is dependent on bacillithiol, a thiol cofactor present also in other Bacilli where it is known to function in redox‐homeostasis. We show that bacillithiol‐dependent formaldehyde oxidation is activated upon an upshift in formaldehyde induced by a substrate switch from mannitol to methanol. The genes and the corresponding enzymes involved in the biosynthesis of bacillithiol were identified by heterologous production of bacillithiol in Escherichia coli. The presented results indicate metabolic plasticity of the methylotroph allowing acclimation to fluctuating intracellular formaldehyde concentrations.     

Growth characteristics of a thermotolerant methylotrophic Bacillus sp. (NCIB 12522) in batch culture

Summary This contribution deals with problems associated with the culture of a thermotolerant methylotrophic Bacillus sp. The results reported clearly demonstrate why conventional enrichment/isolation procedures have, in the past, failed to allow such microbes to assert themselves. The catastrophic effect of carbon substrate (methanol) exhaustion on such cultures is clearly evidenced, but the effects of other nutrient exhaustion or limitations are demonstrated to be markedly less stringent. The failure of such cultures to complete the sporulation process when growing on methanol has important consequences with respect to their survival characteristics.     

Regulation of alcohol oxidase synthesis in Hansenula polymorpha: Oversynthesis during growth on mixed substrates and induction by methanol

The regulation of the synthesis of alcohol oxidase, catalase, formaldehyde dehydrogenase and formate dehydrogenase was investigated in the methanol-utilizing yeast Hansenula polymorpha. The organism was found to synthesize immunologically identical alcohol oxidases during growth on glycerol and methanol. Growth on glycerol, however, was not dependent on the alcohol oxidase, as was shown with a mutant without alcohol oxidase protein. Similarly it was shown with a catalase activity negative mutant that high catalase activity during growth on glycerol was not a prerequisite for the utilization of this substrate, though absolutely required for growth on methanol.Experiments were conducted with mixed substrates to study the influence of methanol on alcohol oxidase synthesis. In batch cultures, growth on ribose plus methanol resulted in an enhanced rate of alcohol oxidase synthesis as compared to ribose alone. In continuous cultures, (D=0.1 h^-1) addition of methanol to glycerol-, glucose-, or sorbose-limited cultures gave rise to increased alcohol oxidase activity of up to 20 U/mg, which is about by 2 times higher than the specific activity used for growth on methanol alone. The increase in specific activity of the dissimilatory enzymes on the mixed substrates is partly due to methanol per se, as was shown by a mutant unable to dissimilate or assimilate methanol.     

New Obligate Methylotroph

A new and unique obligate methylotroph was isolated from enrichment cultures with methanol as the sole source of carbon and energy. The organism grows only on methanol and methylamine and not on methane. It does not have a complex intracellular membrane system. (14)C-acetate was assimilated by growing cultures and cell suspensions but was incorporated into only a limited number of cell constituents. (14)C-acetate incorporation was strictly dependent on the oxidation of methanol or methylamine as a source of energy. Extracts had relatively low levels of enzymes of the tricarboxylic acid cycle, and alpha-ketoglutarate dehydrogenase was not detected. Comparisons were made with a facultative methylotroph isolated from the same enrichment cultures. The new obligate methylotroph contained hexose phosphate synthetase, a key enzyme in the ribose phosphate cycle of methyl metabolism.     

Reactions of direct formaldehyde oxidation to CO2 are non-essential for energy supply of yeast methylotrophic growth

Mutants of the methylotrophic yeast Hansenula polymorpha deficient in NAD-dependent formaldehyde or formate dehydrogenases have been isolated. They were more sensitive for exogenous methanol but retained the ability for methylotrophic growth. In the medium with methanol the growth yields of the mutant 356–83 deficient in formaldehyde dehydrogenase and of the wild-type strain were identical (0.34 g cells/g methanol) under chemostat cultivation. These results indicate that enzymes of direct formaldehyde oxidation are not indispensable for methylotrophic growth. At the same time inhibition of tricarboxylic acid cycle has resulted in suppression of growth in the media with multicarbon nonfermentable substrates such as glycerol, succinate, ethanol and dihydroxyacetone as well as with methanol, but not with glucose. In the experiments with the wild-type strain H. polymorpha it has been shown that citrate and dihydroxyacetone inhibit the radioactivity incorporation from ¹⁴C-methanol into CO₂. All obtained data indicate that for the dissimilation of methanol and the supplying of energy for methylotrophic growth, the functioning of tricarboxylic acid cycle reactions as oppossed to those of direct formaldehyde oxidation is essential.     

C<Subscript>1</Subscript> compounds as auxiliary substrate for engineered <Emphasis Type="Italic">Pseudomonas putida</Emphasis> S12

The solvent-tolerant bacterium Pseudomonas putida S12 was engineered to efficiently utilize the C₁ compounds methanol and formaldehyde as auxiliary substrate. The hps and phi genes of Bacillus brevis, encoding two key steps of the ribulose monophosphate (RuMP) pathway, were introduced to construct a pathway for the metabolism of the toxic methanol oxidation intermediate formaldehyde. This approach resulted in a remarkably increased biomass yield on the primary substrate glucose when cultured in C-limited chemostats fed with a mixture of glucose and formaldehyde. With increasing relative formaldehyde feed concentrations, the biomass yield increased from 35% (C-mol biomass/C-mol glucose) without formaldehyde to 91% at 60% relative formaldehyde concentration. The RuMP-pathway expressing strain was also capable of growing to higher relative formaldehyde concentrations than the control strain. The presence of an endogenous methanol oxidizing enzyme activity in P. putida S12 allowed the replacement of formaldehyde with the less toxic methanol, resulting in an 84% (C-mol/C-mol) biomass yield. Thus, by introducing two enzymes of the RuMP pathway, co-utilization of the cheap and renewable substrate methanol was achieved, making an important contribution to the efficient use of P. putida S12 as a bioconversion platform host.     

Environmental regulation of alcohol metabolism in thermotolerant methylotrophic Bacillus strains

The thermotolerant methylotroph Bacillus sp. C1 possesses a novel NAD-dependent methanol dehydrogenase (MDH), with distinct structural and mechanistic properties. During growth on methanol and ethanol, MDH was responsible for the oxidation of both these substrates. MDH activity in cells grown on methanol or glucose was inversely related to the growth rate. Highest activity levels were observed in cells grown on the C₁-substrates methanol and formaldehyde. The affinity of MDH for alcohol substrates and NAD, as well as V _max, are strongly increased in the presence of a M _r 50,000 activator protein plus Mg²⁺-ions [Arfman et al. (1991) J Biol Chem 266: 3955–3960]. Under all growth conditions tested the cells contained an approximately 18-fold molar excess of (decameric) MDH over (dimeric) activator protein. Expression of hexulose-6-phosphate synthase (HPS), the key enzyme of the RuMP cycle, was probably induced by the substrate formaldehyde. Cells with high MDH and low HPS activity levels immediately accumulated (toxic) formaldehyde when exposed to a transient increase in methanol concentration. Similarly, cells with high MDH and low CoA-linked NAD-dependent acetaldehyde dehydrogenase activity levels produced acetaldehyde when subjected to a rise in ethanol concentration. Problems frequently observed in establishing cultures of methylotrophic bacilli on methanol- or ethanol-containing media are (in part) assigned to these phenomena.Abbreviations MDH NAD-dependent methanol dehydrogenase - ADH NAD-dependent alcohol dehydrogenase - A1DH CoA-linked NAD-dependent aldehyde dehydrogenase - HPS hexulose-6-phosphate synthase - G6Pdh glucose-6-phosphate dehydrogenase     

Constitutive appearance of peroxisomes in a regulatory mutant of the methylotrophic yeast Hansenula polymorpha

Summary A selection by glucosamine for mutants of Hansenula polymorpha insensitive to glucose repression of methanol assimilation is described. Constitutive synthesis of enzymes is established in standard batch cultures of glucosegrown cells. Upon prolonged glucose metabolism the phenotype is masked by catabolite inactivation and degradation of enzymes. Addition of the substrate methanol remarkably improves constitutive synthesis by preventing catabolite inactivation and delaying degradation. Regular peroxisomes of reduced number are formed in mutant cells under repressed conditions. No constitutive synthesis is detectable using ethanol as a carbon source. In addition, this alcohol is detrimental to growth of the mutants, indicating that H. polymorpha is constrained to repress synthesis of enzymes involved in the C₁-metabolism when ethanol is present as a substrate.     

The apparent oxidation of NADH by whole cells of the methylotrophic bacterium Methylophilus methylotrophus

Previous reports that whole cells of Methylophilus methylotrophus oxidase exogenous NADH have been investigated. Essentially identical rates of oxygen consumption were observed following the addition of methanol or NADH to whole cells. Both activities were inhibited by EDTA and hydroxylamine, but not by HQNO, and exhibited similar pH optima. Analyses of the reaction stoichiometry with NADH as substrate showed that the expected amount of oxygen was consumed, but also revealed acidification (instead of alkalinisation) and no oxidation of NADH. Further studies showed that commerical NADH is contaminated with ethanol which is oxidised to acetic acid by the low specificity methanol oxidase system present in this organism. The oxidation of exogenous NADH by whole cells of M. methylotrophus reported previously is therefore spurious.Abbreviations EDTA = ethylenediaminetetracetate - HQNO = 2–n-heptyl-4-hydroxy-quinoline-N-oxide - DEAE = diethylaminoethyl     

Continuous culture of Candida boidinii variant 60 growing on methanol

Summary A new variant, Candida boidinii variant 60, which is less sensitive to methanol and formaldehyde shocks was grown in continuous cultures with methanol as sole carbon source. The substrate concentration in the feeding medium was either 1% methanol or 3% methanol. Biomass production, methanol consumption, the formation of formaldehyde and gas exchange were measured at different dilution rates. With low methanol feeding (10 g/l) maximal productivity of 0.44 g biomass/l·h is obtained at a dilution rate of 0.14 h^–1. Maximal specific growth rate is 0.18 h^–1. A yield of 0.32 g biomass/g methanol was obtained and the respiration quotient was determined as 0.55. Independently of initial substrate concentration, biomass decreases if methanol and formaldehyde are accumulating in the culture broth.In the culture with high methanol feeding (30 g/l) cell concentratioon increases up to 9 g/l at D=0.04 h^–1. At higher dilution rates methanol and form-aldehyde appear in the medium. Formaldehyde is then preferably oxidized without energy advantages for the cells. It seems that this enables the cells to overcome toxic effects caused by methanol and formaldehyde.     

Carbon-oxygen bond formation by fungal laccases: cross-coupling of 2,5-dihydroxy-<Emphasis Type="Italic">N</Emphasis>-(2-hydroxyethyl)-benzamide with the solvents water,methanol, and other alcohols

Laccase-catalyzed reactions lead to oxidation of the substrate via a cation radical, which has been described to undergo proton addition to form a quinonoid derivative or nucleophilic attack by itself producing homomolecular dimers. In this study, for the substrate 2,5-dihydroxy-N-(2-hydroxyethyl)-benzamide, we show that, besides the quinonoid form of substrate, all products formed are nonhomomolecular ones. Indeed, without addition of a reaction partner, heteromolecular products are formed from the quinonoid form of the laccase-substrate and the solvents water or methanol present in the incubation assay. Consequently, in laccase catalyzed syntheses performed in aqueous solutions or in the presence of methanol or other alcohols, undesirable heteromolecular coupling reactions between the laccase substrate and solvents must be taken into account. Additionally, it could be shown at the example of methanol and other alcohols that C-O-bound cross-coupling of dihydroxylated aromatic substances with the hydroxyl group of aliphatic alcohols can be catalyzed by fungal laccases.     

[1-14C] Acetate assimilation by obligate methylotrophs,Pseudomonas methanica and Methylosinus trichosporium

The oxidation of one carbon compounds (methane, methanol, formaldehyde, formate) and primary alcohols (ethanol, propanol, butanol) supported the assimilation of [1-¹⁴C]acetate by cell suspensions of type I obligate methylotroph; Pseudomonas methanica, Texas strain, and type II obligate methylotroph, Methylosinus trichosporium, strain PG. The amount of oxygen consumed and substrate oxidized correlated with the amount of [1-¹⁴C]acetate assimilated during oxidation of C-1 compounds and primary alcohols.Oxidation of methanol, formaldehyde, and primary alcohols in extracts of Pseudomonas methanica, Texas strain, and Methylosinus trichosporium, strain PG, was catalyzed by a phenazine methosulfate linked, ammonium ion dependent methanol dehydrogenase. The oxidation of aldehydes was catalyzed by a phenazine methosulfate linked, ammonium ion independent aldehyde dehydrogenase. Formate was oxidized by a NAD⁺ linked formate dehydrogenase.Deceased.This work was supported by Grant GB 8173 from the National Science Foundation and by a grant from the Robert A. Welch Foundation.     

The ferrous iron oxidation kinetics of Thiobacillus ferrooxidans in batch cultures

The ferrous iron oxidation kinetics of Thiobacillus ferrooxidans in batch cultures was examined, using on-line off-gas analyses to measure the oxygen and carbon dioxide consumption rates continuously. A cell suspension from continuous cultures at steady state was used as the inoculum. It was observed that a dynamic phase occurred in the initial phase of the experiment. In this phase the bacterial ferrous iron oxidation and growth were uncoupled. After about 16 h the bacteria were adapted and achieved a pseudo-steady state, in which the specific growth rate and oxygen consumption rate were coupled and their relationship was described by the Pirt equation. In pseudo-steady state, the growth and oxidation kinetics were accurately described by the rate equation for competitive product inhibition. Bacterial substrate consumption is regarded as the primary process, which is described by the equation for competitive product inhibition. Subsequently the kinetic equation for the specific growth rate, μ, is derived by applying the Pirt equation for bacterial substrate consumption and growth. The maximum specific growth rate, μ _max, measured in the batch culture agrees with the dilution rate at which washout occurs in continuous cultures. The maximum oxygen consumption rate, q _O2,max, of the cell suspension in the batch culture was determined by respiration measurements in a biological oxygen monitor at excess ferrous iron, and showed changes of up to 20% during the course of the experiment. The kinetic constants determined in the batch culture slightly differ from those in continuous cultures, such that, at equal ferric to ferrous iron concentration ratios, biomass-specific rates are up to 1.3 times higher in continuous cultures. Received: 8 February 1999 / Accepted: 17 February 1999     

Energetics of mixotrophic and autotrophic C1-metabolism by Thiobacillus acidophilus

Although the facultatively autotrophic acidophile Thiobacillus acidophilus is unable to grow on formate and formaldehyde in batch cultures, cells from glucose-limited chemostat cultures exhibited substrate-dependent oxygen uptake with these C₁-compounds. Oxidation of formate and formaldehyde was uncoupler-sensitive, suggesting that active transport was involved in the metabolism of these compounds. Formate- and formaldehyde-dependent oxygen uptake was strongly inhibited at substrate concentrations above 150 and 400 M, respectively. However, autotrophic formate-limited chemostat cultures were obtained by carefully increasing the formate to glucose ratio in the reservoir medium of mixotrophic chemostat cultures. The molar growth yield on formate (Y=2.5 g ·mol^-1 at a dilution rate of 0.05 h^-1) and RuBPCase activities in cell-free extracts suggested that T. acidophilus employs the Calvin cycle for carbon assimilation during growth on formate. T. acidophilus was unable to utilize the C₁-compounds methanol and methylamine. Formate-dependent oxygen uptake was expressed constitutively under a variety of growth conditions. Cell-free extracts contained both dye-linked and NAD-dependent formate dehydrogenase activities. NAD-dependent oxidation of formaldehyde required reduced glutathione. In addition, cell-free extracts contained a dye-linked formaldehyde dehydrogenase activity. Mixotrophic growth yields were higher than the sum of the heterotrophic and autotrophic yields. A quantitative analysis of the mixotrophic growth studies revealed that formaldehyde was a more effective energy source than formate.