Effect of bacitracin on growth and monoclonal antibody production by tobacco hairy roots and cell suspensions

Hairy roots and suspended cells of transformedNicotiana tabacum were used to produce full length murine IgG₁ monoclonal antibody. The maximum amount of antibody accumulated per g dry weight in the hairy root cultures was 6.5 times that in the suspension cultures. Up to 48% of the antibody in the suspension cultures was found extracellularly, while a maximum of only 17% was recovered from the hairy root medium. The amount of assembled antibody in the root and suspension cultures was significantly reduced by intracellular and/or extracellular antibody degradation soon after the end of the exponential growth phase. Bacitracin, a polypeptide antibiotic, has been shown in previous work to prevent degradation of peptides and hormones in plant and mammalian systems. Treatment of hairy roots and cell suspensions with 100 μg/mL bacitracin was not sufficient to prevent loss of antibody from the cultures, but improved the specific growth rates by up to 53%. At concentrations of 250 μg/mL and above, bacitracin had a toxic effect on hairy roots, which may limit the application of this peptide in plant tissue culture.     

A differential response to chemical elicitors in Catharanthus roseus in vitro cultures

The effects of methyl jasmonate, salicylic acid and ethylene on alkaloid accumulation in in vitro cell suspension, hairy roots and rootless shoot cultures of Catharanthus roseus were analyzed. Ajmalicine, but not catharanthine, accumulation was promoted by jasmonate and ethylene treatments in cell suspensions. In hairy roots, jasmonate induced the accumulation of both alkaloids, whereas ethylene only induced catharanthine accumulation. In shoot cultures, positive effects of jasmonate and ethylene were recorded only in vindoline accumulation. Ethylene diminished catharanthine accumulation in these cultures. No effect of salicylic acid was observed in any of the studied in vitro culture systems. Electronic supplementary material  The online version of this article (doi:) contains supplementary material, which is available to authorized users.     

Production of higher levels of trigonelline by cell cultures of Trigonella foenum-graecum than by the differentiated plant

Callus cultures of Trigonella foenum-graecum contained 3 to 4 times more trigonelline than the seeds of this plant and 12 to 13 times more than the roots and shoots. Even higher levels of this alkaloid were produced by suspension cultures. This high productivity was maintained during successive subculturing of calli and cell suspensions for eight months. Thus, trigonelline is to be added to the group of the few metabolites whose synthesis in cell cultures exceeds its production in the differentiated plants. Media that had supported the growth of suspension cultures contained one third or more of the total alkaloid, whereas media of callus cultures contained about one tenth of this substance. Trigonelline accumulated in callus and suspension cultures with aging. Raising the level of nicotinic acid in the nutrient medium resulted in some increase of trigonelline production by the culture.Abbreviations 2.4 D 2.4-dichlorophenoxyacetic acid - IAA indoleacetic acid - IPA indolepropionic acid - NAA -naphthaleneacetic acid - GA Gibberellic acid - K kinetin     

Polyacetylenes accumulation in <Emphasis Type="Italic">Ambrosia maritima</Emphasis> hairy root and cell cultures after elicitation with methyl jasmonate

Three lines of hairy root culture of Ambrosia maritima induced by Agrobacterium rhizogenes ATCC15834 were established. Thiarubrine A, thiarubrine A epoxide, thiarubrine A diol and their precursor pentayneene were produced by the hairy roots after elicitation with methyl jasmonate, the common signal molecule in the plant defense and development. Thiarubrine A diol was the main form detected in the medium. Maximum yield was achieved when the 13-day-old hairy root cultures were exposed to 40 M methyl jasmonate for 72 h. Callus and cell suspension cultures were established and maintained on Murashige and Skoog medium supplied with -naphthylacetic acid (NAA) and kinetin. When the cell suspension cultures were elicited with methyl jasmonate, pentayneene was the only polyacetylene produced. The yield of pentayneene in hairy root cultures was much higher (9.6 times) than that of cell suspension cultures.     

An interchangeable system of hairy root and cell suspension cultures ofCatharanthus roseus for indole alkaloid production

Hairy roots ofCatharanthus roseus obtained by co-cultivation of hypocotyl segments withAgrobacterium rhizogenes, and cultured in SH (Schenk and Hildebrandt) basal medium, formed two types of calli when subcultured in SH medium with 1 mg/1 -naphthaleneacetic acid and 0.1 mg/l kinetin. One of them, a compact callus, when re-subcultured in SH basal medium gave rise to hairy roots again. A rhizogenic cell suspension culture was established from this type of callus. When cultured in SH medium with growth regulators, the rhizogenic callus produced catharanthine at a level of 41% of the level in the initial hairy roots. Upon transfer to SH basal medium, regenerated hairy roots produced this alkaloid at the original level of 1.5 mg/g dry wt. Using this cell/hairy root interchange system a new management system for hairy root culture in bioreactors has been devised and examined involving production of biomass in the form of a cell suspension in medium supplemented with growth regulators, and catharanthine production by hairy roots regenerated from these cells in medium without growth regulators.Abbreviations NAA -naphthaleneacetic acid - SH Schenk and Hildebrandt - SHNK SH medium + 1 mg 1^–1 NAA + 0.1 mg 1^–1 kinetin     

Characteristics of growth and tropane alkaloid production in Hyoscyamus albus hairy roots transformed with Agrobacterium rhizogenes A4

Summary Hairy root culture of Hyoscyamus albus was established by transformation with Agrobacterium rhizogenes strain A4. The growth and production of five tropane alkaloids were investigated under various culture conditions. Among the four basal culture media tested, Woody Plant medium was the best for growth of the hairy roots, but a high amount of tropane alkaloids was obtained with Gamborg's B5 medium. Sucrose concentration in B5 medium had little effect on the growth, while 3% sucrose was suitable for the alkaloid production. Addition of KNO₃ to Woody Plant medium affected the growth, whereas the alkaloid content was not markedly improved. Supplement of some metal ions to B5 medium stimulated the alkaloid production. In particular, Cu²⁺ remarkably enhanced both the growth and the alkaloid yield. The hairy roots cultured under 16 h/day light survived for more than 32 days compared with those cultured in the dark.Abbreviations EDTA ethylenediaminetetraacetic acid - HPLC high performance liquid chromatography - MeOH methanol - MS medium Murashige and Skoog medium - WP medium McCown's Woody Plant medium - B5 medium Gamborg B5 medium - wt weight     

Production of indole alkaloids by selected hairy root lines of Catharanthus roseus

Hairy root cultures of Catharanthus roseus were established by infection of seedlings with Agrobacterium rhizogenes 15834. Approximately 150 transformants from four different. C. roseus cultivars were screened for desirable traits in growth and indole alkaloid production. Five hairy root clones grew well in liquid culture with doubling times similar to those reported for cell suspensions. Fast growing clones had similar morphologies, characterized by thin, straight, and regular branches with thin tips. The levels of key alkaloids, ajmalicine, serpentine, and catharanthine, in these five clones, also compared well with literature data from cell suspensions, yet HPLC and GC-MS data indicate the presence of vindoline in two clones at levels over three orders of magnitude greater than the minute amounts reported in cell culture. These results suggest that further optimization may result in hairy roots as a potential source of vindoline and catharanthine, the two monomers necessary to synthesize that antineoplastic drug, vinblastine. (c) 1993 John Wiley & Sons, Inc.     

Catharanthus roseus: micropropagation and in vitro techniques

Different methods of in vitro culture of Catharanthus roseus provide new sources of plant material for the production of secondary metabolites such as indole alkaloids. Callus, cell suspension, plantlets, and transgenic roots cultured in the bioreactor are used in those experiments. The most promising outcomes include the production of the following indole alkaloids: ajmalicine in unorganised tissue, catharanthine in the leaf and cell culture in the shake flask and airlift bioreactor, and vinblastine in shoots and transformed roots. What is very important, enzymatic coupling of monomeric indole alkaloids, vindoline and catharanthine, is possible to form vinblastine in cell cultures. The method of catharanthine and ajmalicine production in the suspension culture in bioreactors has been successful. In this method, elicitation may be used acting on different metabolic pathways. Also of interest is the method of obtaining arbutin from the callus culture of C. roseus conducted with hydroquinone. The transformed root culture seems to be the most promising for alkaloid production. The genetically transformed roots, obtained by the infection with Agrobacterium rhizogenes, produce higher levels of secondary metabolites than intact plants. Also, whole plants can be regenerated from hairy roots. The content of indole alkaloids in the transformed roots was similar or even higher when compared to the amounts measured in studies of natural roots. The predominant alkaloids in transformed roots are ajmalicine, serpentine, vindoline and catharanthine, found in higher amounts than in untransformed roots. Transformed hairy roots have been also used for encapsulation in calcium alginate to form artificial seeds.     

Psoralen production in hairy roots and adventitious roots cultures of Psoralea coryfolia

Psoralea corylifolia is an endangered plant producing various compounds of medical importance. Adventitious roots and hairy roots were induced in cultures prepared from hypocotyl explants. Psoralen content was evaluated in both root types grown either in suspension cultures or on agar solidified medium. Psoralen content was ~3 mg g⁻¹ DW in suspension grown hairy roots being higher than in solid grown hairy roots and in solid and suspension-grown adventitious roots.     

Induction of alkaloid diversity in hybrid plant cell cultures

 The treatment of Rauwolfia serpentina x Rhazya stricta somatic hybrid cell suspension culture with 100 μM of methyl jasmonate led to a general increase in indole alkaloid content and to qualitative changes in the alkaloid pattern. The content of Six alkaloids were investigated with respect to their content in both the cell biomass and nutrition medium. Intracellular 17-O-acetyl-norajmaline content on the 5th day after treatment had increased about 40-fold compared with the control culture. The respective concentrations of the other alkaloids increased by a factor of two to five. In total 26 indole alkaloids were identified in extracts of the methyl jasmonate-treated culture by TLC, UV, MS and NMR data and comparison with reference alkaloids. The identification of macrophylline, yohimbine oxindole and yohimbine pseudoindoxyl has not been reported before in Rauwolfia serpentina or Rhazya stricta plants nor in cell cultures derived from these plants. Received: 17 June 1998 / Accepted: 7 December 1998     

The effect of nitrate and ammonium concentrations on growth and alkaloid accumulation of Atropa belladonna hairy roots

The growth, the alkaloid production, as well as the scopolamine/hyoscyamine ratio of two clones of belladonna hairy roots were studied. The effects of nitrate and ammonium concentrations on these cultures were investigated. A rise in ammonium concentration caused the decline of the hairy roots, while nitrate had a marked effect on the alkaloid content. The alkaloid production obtained with 15.8 mM of NO3- and 20.5 mM of NH4+ was 1.2-1.4 times higher than that obtained when the roots were grown in the standard Murashige and Skoog medium (MS medium, 39.5 mM of NO3- and 20.5 mM of NH4+). The nitrate and ammonium concentrations in the culture medium also had a strong influence on the scopolamine/hyoscyamine ratio. When nitrate or ammonium concentrations were raised, that ratio also was increased 2-3-fold. The hairy root clones originating from transformations with two distinct strains of Agrobacterium had similar responses.     

Hairy root induction of<Emphasis Type="Italic"> Papaver somniferum</Emphasis> var.<Emphasis Type="Italic"> album</Emphasis>, a difficult-to-transform plant,by<Emphasis Type="Italic"> A. rhizogenes</Emphasis> LBA 9402

Two strains of Agrobacterium rhizogenes (15834, LBA 9402) and one Agrobacterium tumefaciens strain [GV 3101 (PMP90RK, p35SGUS-2)] and four culture media were tested and compared for their ability to induce hairy root formation on wounded Papaver somniferum L. hypocotyls. Five weeks after the infection with A. rhizogenes LBA 9402, hairy roots appeared on 80% of the hypocotyls maintained in the hormone-free liquid medium. Six hairy-root cultures were established. Transformation was confirmed by polymerase chain reaction analysis. One clone was analysed for its alkaloid production. The total alkaloid content was higher in the transformed roots (0.46±0.06% DW) than in the untransformed roots (0.32±0.05% DW). The transformed roots accumulated three times more codeine (0.18±0.02% DW) than intact roots (0.05±0% DW). Moreover, morphine (0.255±0.03% DW) and sanguinarine (0.014±0% DW) were found in the liquid culture medium.Abbreviations 2,4-D 2,4-Dichlorophenoxyacetic acid - LS Linsmaier and Skoog     

High-yield production of tropane alkaloids by hairy-root cultures of aDatura candida hybrid

Hairy root cultures were obtained following inoculation of the stems of sterile plantlets of aDatura candida hybrid withAgrobacterium rhizogenes. The scopolamine and hyoscyamine content was quantified by HPLC and compared with the non-transformed plants. The alkaloid yield (0.68% dry weight) obtained with the hairy roots was 1.6 and 2.6 times the amount found in the aerial parts and in the roots of the parent plants, respectively. Only a small proportion of alkaloids was released into the growth medium. Scopclamine was the principal alkaloid and the scopolamine/hyoscyamine ratio of ca. 5:1 makes these hairy roct cultures worthy of consideration as a source of scopolamine.     

Transformation of Gynostermma pentaphyllum by Agrobacterium rhizogenes and Saponin Production in Hairy Root Cultures

Authors report here the establishment of an efficient transformation system for Gynosternrna pentaphyllum (Thunb.) Makino using Agrobacteriurn rhizogenes R1600. Hairy roots appeared on leaf explants 10 days after inoculation with the bacteria . Frequency of the explants transformed by R1600 was up to 94%. Transformation was confirmed by Southern analysis. Biomass of hairy root cultures suspended in hormone-free MS medium increased 9 times after 20 days of incubation. There was no callus formation on the hairy roots during suspension culture. Saponin content in the hairy root cultures was about 2 times as much as in the natural roots, saponins of the hairy root cultures were also released into growth medium as well.     

Stable transformation of Lithospermum erythrorhizon by Agrobacterium rhizogenes and shikonin production of the transformants

Seedling hypocotyls of Lithospermum erythrorhizon were infected with Agrobacterium rhizogenes (strain 15834) harboring a binary vector with an intron-bearing the β-glucuronidase (GUS) gene driven by cauliflower mosaic virus (CaMV) 35S promoter as well as the hygromycin phosphotransferase (HPT) gene as the selection marker. About 20% of the hairy roots isolated were hygromycin resistant and had co-integrated GUS and HPT genes in their Lithospermum genomic DNA. Because GUS activity was detected in almost all the hygromycin-resistant root tissues, the CaMV 35S promoter seems to be ubiquitously active in L. erythrorhizon hairy roots. In pigment production medium M9, the hairy root cultures had shikonin productivity similar to that of cell suspension cultures of Lithospermum. They also showed light-dependent inhibition of shikonin biosynthesis similar to that of Lithospermum cell cultures. These findings suggest that this hairy root system transformable with A. rhizogenes is a suitable model system for molecular characterization of shikonin biosynthesis via reverse genetics. Received: 2 March 1998 / Revision received: 25 May 1998 / Accepted: 8 July 1998     

Indole alkaloid production by transformed and non-transformed root cultures ofCatharanthus roseus

Summary Ten transformed and two non-transformed root lines ofCatharanthus roseus were established. A systematic study of the growth kinetics and alkaloid content was performed over a culture cycle and showed significant differences between transformed and non-transformed cultures. Mean doubling times for transformed and normal root lines were 2.8 and 19.5 days, respectively. Alkaloid content in hairy roots was from two- to threefold higher than in the non-transformed tissues. The established transformed root lines produced a wide variety of indole alkaloids as can be observed from their complex thin layer chromatography patterns. A large quantity of serpentine was determined in two of the transformed root cultures. Alkaloid content, both quantitatively and qualitatively, has been stable in the hairy root cultures for more than 2 yr of subculturing.     

Inducer effect of Tween 20 permeabilization treatment used for release of stored tropane alkaloids inDatura innoxia Mill. hairy root cultures

Summary The effects of Tween 20 as permeabilizing agent on tropane alkaloids fromDatura innoxia Mill. hairy root cultures have been studied. The kinetics of the alkaloid release is detailed and shows three different stages: an initial rapid increase of the alkaloid level within the roots and in the culture medium, followed by a slower but higher increase of the alkaloid concentration in the medium. During this phase, the alkaloid concentration within the roots returned to a lower value. Finally, after a longer time, the quantity of hyoscyamine in the medium decreased significantly with a variable rate. According to the total alkaloid content per flask determinations under different conditions, it is clearly demonstrated that Tween treatment permeabilized the roots, but also acted as an inducer.     

Production of solasodine by hairy root,callus, and cell suspension cultures of Solanum aviculare Forst.

The production of the steroidal alkaloid solasodine, an alternative to diosgenin as a precursor for the commercial production of steroid drugs, was studied in hairy root, callus, and cell suspension cultures of Solanum aviculare Forst. through manipulation of culture medium. The individual and combined effects of medium components on the growth index and the production of solasodine were analyzed using factorial analysis of variance. Solasodine content was optimized to 6.2 mg g⁻¹in the hairy root, 1.4 mg g⁻¹callus, and 0.7 mg g⁻¹in cell suspension cultures (dry weight). An improved isocratic reversed phase high performance liquid chromatographic method provided selective determination of the solasodine content of these samples. Analysis of growth and solasodine content of hairy root cultures and callus cultures demonstrated that the production of solasodine was shown to be growth-dependent in hairy root cultures but not in callus cultures. This revised version was published online in June 2006 with corrections to the Cover Date.     

Rosmarinic acid production by <Emphasis Type="Italic">Coleus forskohlii</Emphasis>hairy root cultures

Coleus forskohlii hairy root cultures were found to produce forskolin and rosmarinic acid (RA) as the main metabolites. The growth and RA production by C. forskohlii hairy root cultures in various liquid media were examined. The hairy root cultures showed good growth in hormone-free Murashige and Skoog medium containing 3% (w/v) sucrose (MS medium), and Gamborg B5 medium containing 2% (w/v) sucrose (B5 medium). RA yield reached 4.0 mg (MS medium) and 4.4 mg (B5 medium) after 5 weeks of culture in a 100 ml flask containing 20 ml of each medium. Hairy root growth and RA were also investigated after treatment with various concentrations of yeast extract (YE), salicylic acid (SA) and methyl jasmonic acid (MJA). RA production in a 100 ml flask containing 20 ml B5 medium reached 5.4 mg (1.9 times more than control) with treatment of 0.01 or 1% (w/v) YE, 5.5 mg (2.0 times more than control) with treatment of 0.1 mM SA, and the maximum RA content with 9.5 mg per flask (3.4 times more than control) was obtained in the hairy roots treated with 0.1 mM MJA. These results suggest that MJA is an effective elicitor for production of RA in C. forskohlii hairy root cultures.     

Establishment of <i>Rhodiola quadrifida</i> Hairy Roots and Callus Culture to Produce Bioactive Compounds

Rhodiola quadrifida is a rare mountain medicinal plant whose root extracts are used in traditional Chinese medicine as a hemostatic, antitussive, and tonic in the treatment of gynecological diseases. The aim of the study was to obtain R. quadrifida cultures at different degrees of differentiation in vitro and compare their growth characteristics and the content of salidroside and rosavin. Hairy roots were obtained by incubating cotyledons and hypocotyls in a suspension of Agrobacterium rhizogenes strain A4. The presence of the rolB and rolC genes was proven by polymerase chain reaction. The obtained roots were cultivated in Murashige-Skoog medium (MS). Calluses were obtained from the hairy roots in MS medium with the addition of hormones: 3 mg/L 2,4 D and 0.5 mg/L BAP. The presence of the main secondary metabolites of R. quadrifida, salidroside and rosavin, in calluses and salidroside in hairy roots by HPLC/MS was confirmed. The content of salidroside in callus culture was significantly higher than in hairy roots, 0.158 and 0.047%, respectively. The content of rosavin in callus culture was 0.07%. The content of rosavin and salidroside in callus culture was close to the level of these substances in the rhizomes of R. quadrifida plants growing in vivo, making this culture promising for its possible biotechnological use.