Cascade bioreactor with submerged biofilm for aerobic treatment of Tunisian landfill leachate

A bioreactor cascade with a submerged biofilm is proposed to treat young landfill leachate of jbel chakir landfill site south west from capital Tunis, Tunisia. The prototype was run under different organic loading charges varying from 0.6 to 16.3 kg TOC m⁻³ day⁻¹. Without initial pH adjustment total organic carbon (TOC) removal rate varied between 65% and 97%. The total reduction of COD reached 92% at a hydraulic retention time of 36 h. However, the removal of total kjeldahl nitrogen for loading charges of 0.5 kg N m⁻³ day⁻¹ reached 75%. The adjustment of pH to 7.5 improved nitrogen removal to a rate of 85% for loading charge of 1 kg N m⁻³ day⁻¹. The main bacterial groups responsible for a simultaneous removal of organic carbon and nitrogen belonged to Bacillus, Actinomyces, Pseudomonas and Burkholderia genera. These selected isolates showed a great capacity of degradation at different leachate concentrations of total organic carbon.     

Leachate treatment and greenhouse gas emission in subsurface horizontal flow constructed wetland

Organic and nitrogen removal efficiencies in subsurface horizontal flow wetland system (HSF) with cattail (Typha augustifolia) treating young and partially stabilized solid waste leachate were investigated. Hydraulic loading rate (HLR) in the system was varied at 0.01, 0.028 and 0.056 m³/m² d which is equivalent to hydraulic retention time (HRT) of 28, 10 and 5 d. Average BOD removals in the system were 98% and 71% when applied to young and partially stabilized leachate at HLR of 0.01 m³/m² d. In term of total kjeldahl nitrogen, average removal efficiencies were 43% and 46%. High nitrogen in the stabilized leachate adversely affected the treatment performance and vegetation in the system. Nitrogen transforming bacteria were found varied along the treatment pathway. Methane emission rate was found to be highest at the inlet zone during young leachate treatment at 79–712 mg/m² d whereas CO₂ emission ranged from 26–3266 mg/m² d. The emission of N₂O was not detected.     

Effects of hydraulic loading rate on pollutants removal by a deep subsurface wastewater infiltration system

The subsurface wastewater infiltration (SWI) system proved to be an effective and low-cost technique for decentralized sewage treatment in areas without adequate domestic treatment facilities. Field-scale experiments were conducted through a deep SWI system, with effective depth of 1.5 m, under hydraulic loading rates of 0.040, 0.065, 0.081 and 0.10 m³/m² d. Taking the hydraulic and treatment efficiencies into consideration, the hydraulic loading rate of 0.081 m³/m² d was recommended. Under this condition, NH₃-N, TN, and COD removal efficiencies were 86.2 ± 3.0, 80.7 ± 1.9 and 84.8 ± 2.1%, respectively. In the effluent, NH₃-N concentration declined to 2.3-4.4 mg/L, accounting for 63.2-65.6% of TN. NO₃-N concentration increased from 0.2 to 0.3 mg/L in the influent to 2.0-2.5 mg/L in the effluent. The nitrifying bacteria number declined with increased depth, while the amount of denitrifying bacteria increased. The analysis of results about the nitrifying and denitrifying bacteria distribution indicated that the most effective ranges for nitrification and denitrification process were 0.3-0.7 m and 0.7-1.5 m, respectively.     

Enhanced denitrification and organics removal in hybrid wetland columns: comparative experiments

This study investigated three lab-scale hybrid wetland systems with traditional (gravel) and alternative substrates (wood mulch and zeolite) for removing organic, inorganic pollutants and coliforms from a synthetic wastewater, in order to investigate the efficiency of alternative substrates, and monitor the stability of system performance. The hybrid systems were operated under controlled variations of hydraulic load (q, 0.3-0.9 m³/m² d), influent ammoniacal nitrogen (NH₄-N, 22.0-80.0 mg/L), total nitrogen (TN, 24.0-84.0 mg/L) and biodegradable organics concentration (BOD₅, 14.5-102.0 mg/L). Overall, mulch and zeolite showed promising prospect as wetland substrates, as both media enhanced the removal of nitrogen and organics. Average NH₄-N, TN and BOD₅ removal percentages were over 99%, 72% and 97%, respectively, across all three systems, indicating stable removal performances regardless of variable operating conditions. Higher Escherichia coli removal efficiencies (99.9%) were observed across the three systems, probably due to dominancy of aerobic conditions in vertical wetland columns of the hybrid systems.     

A three-stage experimental constructed wetland for treatment of domestic sewage: First 2 years of operation

Hybrid constructed wetland systems have recently been used to treat wastewaters where high demand for removal of ammonia is required. However, these systems have not been used too often for small on-site treatment systems. This is because in many countries ammonia is not limited in the discharge from small systems. Hybrid systems have a great potential to reduce both ammonia and nitrate concentrations at the same time. In our study we employed a three-stage constructed wetland system consisting of saturated vertical-flow (VF) bed (2.5 m², planted with Phragmites australis), free-drained VF bed (1.5 m², planted with P. australis) and horizontal-flow (HF) bed (6 m², planted with Phalaris arundinacea) in series. All wetlands were originally filled with crushed rock (4-8 mm). However, nitrification was achieved only after the crushed rock was replaced with sand (0-4 mm) in the free-drain wetland. Also, original size of crushed rock proved to be too vulnerable to clogging and therefore, in the first wetlands the upper 40 cm was replaced by coarser fraction of crushed rock (16-32 mm) before the second year of operation started. The system was fed with mechanically pretreated municipal wastewater and the total daily flow was divided into two batches 12 h apart. The evaluation of the results from the period 2007 to 2008 indicated that such a system has a great potential for oxidation of ammonia and reduction of nitrate. The ammonia was substantially reduced in the free-drained VF bed and nitrate was effectively reduced in the final HF bed. The inflow mean NH₄-N concentration of 29.9 mg/l was reduced to 6.5 mg/l with the average removal efficiency of 78.3%. At the same time the average nitrate-N concentration rose from 0.5 to only 2.7 mg/l at the outflow. Removal of BOD₅ and COD amounted to 94.5% and 84.4%, respectively, with respective average outflow concentrations of 10 and 50 mg/l. Phosphorus was removed efficiently despite the fact that the system was not aimed at P removal and therefore no special media were used. Phosphorus removal amounted in 2008 to 65.4%, but the average outflow concentration of 1.8 mg/l is still high. The results of the present study indicate very efficient performance of the hybrid constructed wetlands, but optimal loading parameters still need to be adjusted. The capital cost of the experimental system is comparable to the conventional on-site treatment plant but the operations and maintenance costs are about one third of the conventional plant.     

Ammonia removal from a waste air stream using a biotrickling filter packed with polyurethane foam through the SND process

This paper presents the results of a bench-scale biotrickling filter (BTF) on the removal of ammonia gas from a waste stream using a simultaneous nitrification/denitrification (SND) process. It was found that the developed BTF could completely remove 100 ppm ammonia from a waste stream, with an empty bed retention time of 60 s and 98.4% nitrogen removal through the SND process under the tested conditions. It was elucidated that both autotrophic and heterotrophic bacteria were involved in the nitrogen removal trough the SND process in the BTF. Additionally, the elimination capacity of total nitrogen by the BTF increased from 3.5 to 18.4 g N/m³ h with an inlet load of 20.6 g N/m³ h (73.6%). The findings of this study suggest that the BTF can be operated to attain complete ammonia removal through the SND process, thereby making the treatment of ammonia-laden gas streams both short and cost-effective.     

Performance and bacterial compositions of aged refuse reactors treating mature landfill leachate

Aged landfill leachates become more refractory over time and difficulty to treat. Recently, aged refuse bioreactors show great promise in treating leachates. In this study, aged refuse bioreactors were constructed to simulate landfill leachate degradation process. The characteristics of leachate were: COD_cr, ∼2200 mg/L; BOD₅, ∼280 mg/L; total nitrogen, ∼2030 mg/L; and ammonia, ∼1900 mg/L. Results showed that bioreactor could remove leachate pollutants effectively at hydraulic loading of 20 L/m³ d. The removal rate reduced when hydraulic loading doubled or temperature lowered. Effluent recirculation could alleviate the temperature effect. Combining aged refuse and slag biofilters could treat leachate more efficiently. Pyrosequencing analysis indicated that bacteria from Pseudomonas, Lysobacter, Bacillus and δ-proteobacter, Flexibacteraceae were more abundant in the samples. The Shannon index decreased at lower temperature, while evenness and equitability increased with recirculation. We suggest that filter medium and temperature may be the main factors for shaping bacterial community structure.     

Purification of waste gas containing high concentration trimethylamine in biotrickling filter inoculated with B350 mixed microorganisms

A biotrickling filter packed with ceramic particles and seeded with B350 microorganisms was applied to remove trimethylamine (TMA) from gaseous waste. A 100% removal efficiency (RE) was obtained when the empty bed residence time (EBRT) was larger than 110 s at an inlet concentration of 0.30 mg/L. Maximum elimination capacity (EC) was 13.13 g m⁻³ h⁻¹ (RE = 64.7%) at 55 s of EBRT. TMA concentrations <0.20 mg/L at 83 s of EBRT did not affect the REs (100%). Maximum EC was 13.95 g m⁻³ h⁻¹ (RE = 78.1%) at a TMA concentration of 0.42 mg/L. Approximately 53.1% of the carbon in TMA was completely mineralized. Bacterial community analysis in the bioreactor revealed more than 21 species in a stable state. Based on all these results, biotrickling filter inoculated with B350 microorganisms is deemed highly capable of ridding waste gas of TMA.     

Reduction of ammonia and volatile organic compounds from food waste-composting facilities using a novel anti-clogging biofilter system

The performance of a pilot-scale anti-clogging biofilter system (ABS) was evaluated over a period of 125 days for treating ammonia and volatile organic compounds emitted from a full-scale food waste-composting facility. The pilot-scale ABS was designed to intermittently and automatically remove excess biomass using an agitator. When the pressure drop in the polyurethane filter bed was increased to a set point (50 mm H₂O m⁻¹), due to excess biomass acclimation, the agitator automatically worked by the differential pressure switch, without biofilter shutdown. A high removal efficiency (97-99%) was stably maintained for the 125 days after an acclimation period of 1 week, even thought the inlet gas concentrations fluctuated from 0.16 to 0.55 g m⁻³. Due the intermittent automatic agitation of the filter bed, the biomass concentration and pressure drop in the biofilter were maintained within the ranges of 1.1-2.0 g-DCW g PU⁻¹ and below 50 mm H₂O m⁻¹, respectively.     

Long term operation of pilot-scale biological nutrient removal process in treating municipal wastewater

The performance of a pilot-scale biological nutrient removal process has been evaluated for 336 days, receiving the real municipal wastewater with a flowrate of 6.8 m³/d. The process incorporated an intermittent aeration reactor for enhancing the effluent quality, and a nitrification reactor packed with the porous polyurethane foam media for supporting the attached-growth of microorganism responsible for nitrification. The observation shows that the process enabled a relatively stable and high performance in both organics and nutrient removals. When the SRT was maintained at 12 days, COD, nitrogen, and phosphorus removals averaged as high as 89% at a loading rate of 0.42–3.95 kg COD/m³ d (corresponding to average influent concentration of 304 mg COD/L), 76% at the loading rate of 0.03–0.27 kg N/m³ d (with 37.1 mg TN/L on average), and 95% at the loading rate of 0.01–0.07 kg TP/m³ d (with 5.4 mg TP/L on average), respectively.     

Co-digestion of intermediate landfill leachate and sewage sludge as a method of leachate utilization

This study examines the co-digestion of intermediate landfill leachate and sewage sludge from a municipal wastewater treatment plant. Application of leachate as a co-fermentation component increased the concentrations of soluble organic compounds (expressed as total organic carbon), ammonium nitrogen, and alkalinity in the digester influents.The biogas yield obtained from the co-fermentation of a 20:1 sewage sludge: intermediate leachate mixture was 1.30 m³ per kg of removed volatile solids (VS), while that from a 10:1 mixture was 1.24 m³ per kg of removed VS. These values exceeded the biogas yield for the sludge alone by 13% and 8%, respectively. The leachate addition influenced the proportion of methane to a minor extent. Increased methane yields of 16.9% and 6.2% per kg of removed VS were found for the two sewage sluge:intermediate leachate mixtures, respectively.     

Partial nitritation and anammox of a livestock manure digester liquor and analysis of its microbial community

A swim-bed reactor for partial nitritation with polymeric coagulant treatment and an UASB reactor for anammox were applied to the treatment of livestock manure digester liquor. The partial nitritation was maintained for 32 days under a 1.6 kg N/m³/d nitrogen loading rate (NLR) with an average conversion efficiency of 51%, and achieved 1.65 kg N/m³/d of the maximum nitrite production rate under 2.58 kg N/m³/d of NLR. Although 200 mg/L of TOC remained in the effluent of the partial nitritation reactor, the anammox nitrogen removal rate was not significantly decreased and a relatively high rate of 2.0 kg N/m³/d was obtained under a NLR of 2.2 kg N/m³/d. 16S rRNA gene analysis showed that Nitrosomonas and KSU-1 were dominant in the partial nitritation and anammox reactor, respectively. The results of this study demonstrated that the partial nitritation-anammox process has possibility of applying to the nitrogen removal of livestock manure digester liquor.     

Nitrogen transformation in two subsurface infiltration systems at pilot scale

Nitrogen removal and transformations were studied in two pilot-scale combinations of a special configuration of a subsurface wastewater infiltration system with vertical flow named symbiotic treatment^®. Both pilot-scale combinations operated in parallel and each one consists of four stages in series, one of them with a vertical distribution of stages and the other one with a horizontal distribution. The main differences between them were the separation between stages (presence (the horizontal distribution)/absence (the vertical distribution) of filtration between steps), the hydraulic load (0.113 m³/m² h and 0.082 m³/m² h for the horizontal and the vertical distribution, respectively) and the depth of the soil filters (1 m each stage in the horizontal distribution whereas the depths in the vertical distribution ranges from 20 cm to 40 cm). Results of both configurations showed elevated dissolved oxygen concentration, and high removal of organic matter and total suspended solids (with mean removal values of 96% for COD for both plants and 90% and 98% for TSS for the vertical and the horizontal distribution, respectively). High total Kjeldahl nitrogen removals were obtained in both configurations (mean removals of 70% and 90% for the vertical and the horizontal distribution, respectively). Whereas the nitrification potential was higher in the configuration with horizontal distribution which includes pumping and filtering between stages and higher depth of the soil filters, both tested configurations showed promise for nitrification of wastewater, ammonia nitrogen was efficiently transformed to nitrate.     

An innovative combined on-site process for the remote rural solid waste treatment--a pilot scale case study in China

The aim of this study was to find a feasible method for the treatment of solid waste generated in the remote rural, where the transportation costs are prohibitive and the resources to construct and maintain conventional treatment plants are not available. This process, consisted of two types of simulated bioreactor landfill (one was recirculated bioreactor landfill, and the other was comprised of fresh and aged refuse reactor) and a soil infiltration system, was operated in ambient temperature for 180 days all together. After treated by the system of fresh and aged refuse reactor, the refuse and leachate reached a strongly degraded and stable state. The remaining leachate can be treated by the soil infiltration system, and 87.5 ± 2.1%, 98.6 ± 1.0% and 95.7 ± 1.7% were achieved by 60 cm soil depths for organic matter, ammonium nitrogen and total nitrogen removal, respectively.     

Diversity and activity of methanotrophs in landfill cover soils with and without landfill gas recovery systems

Aerobic CH₄ oxidation plays an important role in mitigating CH₄ release from landfills to the atmosphere. Therefore, in this study, oxidation activity and community of methanotrophs were investigated in a subtropical landfill. Among the three sites investigated, the highest CH₄ concentration was detected in the landfill cover soil of the site (A) without a landfill gas (LFG) recovery system, although the refuse in the site had been deposited for a longer time (∼14–15 years) compared to the other two sites (∼6–11 years) where a LFG recovery system was applied. In April and September, the higher CH₄ flux was detected in site A with 72.4 and 51.7 g m⁻² d⁻¹, respectively, compared to the other sites. The abundance of methanotrophs assessed by quantification of pmoA varied with location and season. A linear relationship was observed between the abundance of methanotrophs and CH₄ concentrations in the landfill cover soils (R = 0.827, P < 0.001). The key factors influencing the methanotrophic diversity in the landfill cover soils were pH, the water content and the CH₄ concentration in the soil, of which pH was the most important factor. Type I methanotrophs, including Methylococcus, Methylosarcina, Methylomicrobium and Methylobacter, and type II methanotrophs (Methylocystis) were all detected in the landfill cover soils, with Methylocystis and Methylosarcina being the dominant genera. Methylocystis was abundant in the slightly acidic landfill cover soil, especially in September, and represented more than 89% of the total terminal-restriction fragment abundance. These findings indicated that the LFG recovery system, as well as physical and chemical parameters, affected the diversity and activity of methanotrophs in landfill cover soils.     

Electricity generation in single-chamber microbial fuel cells using a carbon source sampled from anaerobic reactors utilizing grass silage

Production of electricity from samples obtained during anaerobic digestion of grass silage was examined using single-chamber air-cathode mediator-less microbial fuel cells (MFCs). The samples were obtained from anaerobic reactors at start-up conditions after 3 and 10 days of operation under psychrophilic (15 °C) and mesophilic (37 °C) temperatures. Electricity was directly produced from all samples at a concentration of 1500 mg COD L⁻¹. Power density obtained from the samples, as a sole carbon source, ranged from 56 ± 3 W m⁻³ to 31 ± 1 W m⁻³ for the mesophilic and psychrophilic samples, respectively. Coulombic efficiencies ranged from 18 ± 1% to 12 ± 1% for the same samples. The relationship between the maximum voltage output and initial COD concentration appeared to follow saturation kinetics at the external resistance of 217 Ω. Chemical oxygen demand (COD) removal was over 90% and total phenolics removal was in the range of 30-75% for all samples tested, with a standard amount of 60 mg L⁻¹ total phenolics removed for every sample. Our results indicate that generating electricity from solution samples of anaerobic reactors utilizing grass silage is possible, opening the possibility for combination of anaerobic digestion with MFC technology for energy generation.     

Evaluation of a lab-scale tidal flow constructed wetland performance: Oxygen transfer capacity, organic matter and ammonium removal

Oxygen transfer capacity and removal of ammonium and organic matter were investigated in this study to evaluate the performance of a lab-scale tidal flow constructed wetland. Average oxygen supply under tidal operation (350 g m⁻² d⁻¹) was much higher than in conventional constructed wetlands (<100 g m⁻² d⁻¹), resulting in enhanced removal of BOD₅ and NH₄⁺. Theoretical oxygen demand from BOD₅ removal and nitrification was approximately matched by the measured oxygen supply, which indicated aerobic consumption of BOD₅ and NH₄⁺ under tidal operation. When BOD₅ removal increased from 148 g m⁻² d⁻¹ to 294 g m⁻² d⁻¹, neither exhausted oxygen from the aggregate matrix during feeding period (111 g m⁻² d⁻¹) nor effluent dissolved oxygen (DO) concentration (2.8 mg/L) changed significantly, demonstrating that the oxygen transfer potential of the treatment system had not been exceeded. However, even though DO had not been exhausted, inhibition of nitrification was observed under high BOD loading. The loss of nitrification was attributed to excessive heterotrophic biofilm growth believed to induce oxygen transfer limitations or oxygen competition in thickened biofilms.     

Novel engineering controls to increase leachate contaminant degradation by refuse: From lab test to in situ engineering application

Here we provide direct evidence through a series laboratory and field-scale experiments using different age refuse to treat landfill leachate that aged refuse exhibits increased leachate contaminants removal ability with refuse stabilization time addition. Ten-years aged refuse showed best contaminant removal in a laboratory-scale test, removing 70.0% (8340.0-2540.0 mg/L) chemical oxygen demand (COD) and 75.0% (910.0-215.0 mg/L) ammonium-N, as well as removing 61.5-67.0% COD and 50.4-58.1% ammonium-N with variable COD (9948.0-12286.0 mg/L) and NH₃-N (780.0-1184.0 mg/L) in a field-scale test, respectively. When the 10-years aged refuse was disinfected by 20% NaClO (wt%), COD, biochemical oxygen demand (BOD₅), total nitrogen (TN), and ammonium-N removal showed a dramatic decrease throughout operation time from 84.4-86.2% to 15.2-34.5%, 94.4-99.8% to 26.2-54.4%, 31.2-33.9% to 2.1-10.1%, and 88.5-90.1% to 1.5-14.5%, respectively, suggesting biodegradation is the dominant contaminant removal. Based on this finding, a 3-stages (8 years) age refuse bioreactor (ARB) was constructed to treat leachate and ARB efficiently reduced chemical oxygen demand (COD) from 5478.0-10842.0 mg/L to 261.0-1020 mg/L (87.8-96.2% removal), ammonium-N from 811.4-1582.0 mg/L to 8.5-43.3 mg/L (96.9-99.4%), respectively, in 18 months running. In summary, the present studies suggest that increased leachate contaminant biodegradation ability of aged refuse could be used directly to create an engineering approach to treat leachate with operational and economic advantages.