Characterization of Ethanol Production from Xylose and Xylitol by a Cell-Free Pachysolen tannophilus System

Whole cells and a cell extract of Pachysolen tannophilus converted xylose to xylitol, ethanol, and CO₂. The whole-cell system converted xylitol slowly to CO₂ and little ethanol was produced, whereas the cell-free system converted xylitol quantitatively to ethanol (1.64 mol of ethanol per mol of xylitol) and CO₂. The supernatant solution from high-speed centrifugation (100,000 × g) of the extract converted xylose to ethanol, but did not metabolize xylitol unless a membrane fraction and oxygen were also present. Fractionation of the crude cell extract by gel filtration resulted in an inactive fraction in which ethanol production from xylitol was fully restored by the addition of NAD⁺ and ADP. The continued conversion of xylose to xylitol in the presence of fluorocitrate, which inhibited aconitase, demonstrated that the tricarboxylic acid cycle was not the source of the electrons for the production of xylitol from xylose. Therefore, the source of the electrons is indirectly identified as an oxidative pentose-hexose cycle.     

Fermentation behavior of an osmotolerant yeast D. hansenii for Xylitol production

Realizing the importance of xylitol as a high‐valued compound that serves as a sugar substitute, a new, one step thin layer chromatographic procedure for quick, reliable, and efficient determination of xylose and xylitol from their mixture was developed. Two hundred and twenty microorganisms from the laboratory stock cultures were screened for their ability to produce xylitol from D ‐xylose. Amongst these, an indigenous yeast isolate no.139 (SM‐139) was selected and identified as Debaryomyces hansenii on the basis of morphological and biochemical characteristics and (26S) D1/D2 r DNA region sequencing. Debaryomyces hansenii produced 9.33 gL^?1 of xylitol in presence of 50.0 gL^?1 of xylose in 84 h at pH 5.5, 30°C, 200 rpm. In order to utilize even higher concentrations of xylose for maximum xylitol production, a xylose enrichment technique was developed. The strain of Debaryomyces hansenii was obtained through xylose enrichment technique in a statistically optimized medium containing 0.3% yeast extract, 0.2% peptone, 0.03% MgSO₄.7H₂O along with 1% methanol. The culture was inoculated with 6% inoculum and incubated at 30°C and 250 rpm. A yield of 0.6 gg^?1 was obtained with a xylitol volumetric productivity of 0.65 g/L h^?1 in the presence of 200 gL^?1 of xylose although up to 300 gL^?1 of xylose could be tolerated through batch fermentation. Through this technique, even higher concentrations of xylose as substrate could be potentially utilized for maximum xylitol production. © 2012 American Institute of Chemical Engineers Biotechnol. Prog., 2012     

Xylose fermentation by Saccharomyces cerevisiae

We have performed a comparative study of xylose utilization in Saccharomyces cerevisiae transformants expressing two key enzymes in xylose metabolism, xylose reductase (XR) and xylitol dehydrogenase (XDH), and in a prototypic xylose-utilizing yeast, Pichia stipitis. In the absence of respiration (see text), baker's yeast cells convert half of the xylose to xylitol and ethanol, whereas P. stipilis cells display rather a homofermentative conversion of xylose to ethanol. Xylitol production by baker's yeast is interpreted as a result of the dual cofactor dependence of the XR and the generation of NADPH by the pentose phosphate pathway. Further limitations of xylose utilization in S. cerevisiae cells are very likely caused by an insufficient capacity of the non-oxidative pentose phosphate pathway, as indicated by accumulation of sedoheptulose-7-phosphate and the absence of fructose-1,6-bisphosphate and pyruvate accumulation. By contrast, uptake at high substrate concentrations probably does not limit xylose conversion in S. cerevisiae XYL1/XYL2 transformants. Correspondence to: M. Ciriacy     

Fed-batch fermentation of xylose by a fast-growing mutant of xylose-assimilating recombinant Saccharomyces cerevisiae

Mutants of xylose-assimilating recombinant Saccharomyces cerevisiae carrying the xylose reductase and xylitol dehydrogenase genes on plasmid pEXGD8 were selected, after ethyl methanesulfonate treatment, for their rapid growth on xylose medium. The fastest growing strain (strain IM2) showed a lower activity of xylose reductase but a higher ratio of xylitol dehydrogenase to xylose reductase activities than the parent strain, as well as high xylulokinase activity. Southern hybridization of the chromosomal DNA indicated that plasmid pEXGD8 was integrated into the chromosome of mutant IM2, resulting in an increase in the stability of the cloned genes. In batch fermentation under O₂ limitation, the yield and production rate of ethanol were improved 1.6 and 2.7 times, respectively, compared to the parent strain. In fed-batch culture with slow feeding of xylose and appropriate O₂ supply at a low level, xylitol excreted from the cells was limited and the ethanol yield increased 1.5 times over that in the batch culture, with a high initial concentration of xylose, although the production rate was reduced. The results suggested that slow conversion of xylose to xylitol led to a lower level of intracellular xylitol, resulting in less excretion of xylitol, and an increase in the ethanol yield. It was also observed that the oxidation of xylitol was strongly affected by the O₂ supply.Correspondence to: T. Yoshida     

Optimization of fed-batch fermentation for xylitol production by Candida tropicalis

Xylitol, a functional sweetener, was produced from xylose by biological conversion using Candida tropicalis ATCC 13803. Based on a two-substrate fermentation using glucose for cell growth and xylose for xylitol production, fed-batch fermentations were undertaken to increase the final xylitol concentration. The effects of xylose and xylitol on xylitol production rate were studied to determine the optimum concentrations for fed-batch fermentation. Xylose concentration in the medium (100 g l⁻¹) and less than 200 g l⁻¹ total xylose plus xylitol concentration were determined as optimum for maximum xylitol production rate and xylitol yield. Increasing the concentrations of xylose and xylitol decreased the rate and yield of xylitol production and the specific cell growth rate, probably because of an increase in osmotic stress that would interfere with xylose transport, xylitol flux to secretion to cell metabolism. The feeding rate of xylose solution during the fed-batch mode of operation was determined by using the mass balance equations and kinetic parameters involved in the equations in order to increase final xylitol concentration without affecting xylitol and productivity. The optimized fed-batch fermentation resulted in 187 g l⁻¹ xylitol concentration, 0.75 g xylitol g xylose⁻¹ xylitol yield and 3.9 g xylitol l⁻¹ h⁻¹ volumetric productivity. Journal of Industrial Microbiology & Biotechnology (2002) 29, 16–19 doi:10.1038/sj.jim.7000257 Received 15 October 2001/ Accepted in revised form 30 March 2002     

Xylitol Production from D‐Xylose at Different Oxygen Transfer Coefficients in a Batch Bioreactor

Conversion of D‐xylose to xylitol by Candida boidinii NRRL Y‐17213 was studied under anaerobic and oxygen limited conditions by varying the oxygen transfer coefficient k_La. Shake flask experiments were used to provide the preliminary information required to perform experiments in a bioreactor. The yeast did not grow under fully anaerobic conditions, but anaerobic formations of xylitol, ethanol, ribitol, and glycerol were observed as well as D‐xylose assimilation of 11 %. In shake flasks, with an initial D‐xylose concentration of 50 g/L, an increase in k_La from 8 to 46 h^–1 resulted in a faster growth, higher rate of substrate uptake and lower yields of products. The highest xylitol productivity (0.052 g/L h) was attained at k_La = 8 h^–1. At k_La = 46 h^–1, 98.6 % of D‐xylose was consumed and mainly converted to biomass. Using 130 g/L D‐xylose, k_La was varied in the fermenter from 26 to 78 h^–1. The percentage of consumed D‐xylose increased from 31 % at k_La = 26 h^–1 to 93–94 % at all other aeration levels. Biomass yield increased with k_La, whereas ethanol, ribitol, and glycerol yields exhibited an opposite dependence on the oxygenation level. The most favorable oxygen transfer coefficient for xylitol formation, in the fermenter, was k_La = 47 h^–1 when its concentration (57.5 g/L) surpassed ethanol accumulation by 3.6‐fold, and the glycerol plus ribitol by 10‐fold. Concurrently, xylitol yield and productivity reached 0.45 g/g and 0.26 g/L h, respectively. The volumetric xylitol productivity was affected more by changes in the aeration than the corresponding yield.     

Xylose metabolism by Pichia stipitis: the effect of ethanol

Summary Pichia stipitis Y7124 was grown anaerobically on d-xylose in the presence of an initial ethanol concentration (E₀) varying from 0 to 40 g/l. When E₀ increased, the yield of xylitol increased linearly, reaching a value of 0.20 mol xylitol/mol xylose at E₀=40 g/l. When a hydrogen acceptor (acetoin) was added to the cultures, the cylitol yield decreased with the contaminant stoichiometric reduction of acetoin to 2,3-butanediol. Furthermore, it was demonstrated that xylitol dehydrogenase and acetoin reductase activities from cell-free extracts of P. stipitis Y7124 were NAD⁺ and NADH₂-linked, respectively. A hypothesis is put forward explaining that the xylitol yield is dependent on the ethanol concentration. It is suggested that ethanol may cause a disturbed NAD⁺/NADH₂ balance during anaerobic xylose metabolism by P. stipitis. Metabolic mechanisms are proposed and their validity is discussed. Offprint requests to: J. P. Delgenes     

Xylitol production from D-xylose byCandida guillermondii: Fermentation behaviour

Summary The ability ofCandida guillermondii to produce xylitol from xylose and to ferment individual non xylose hemicellulosic derived sugars was investigated in microaerobic conditions. Xylose was converted into xylitol with a yield of 0,63 g/g and ethanol was produced in negligible amounts. The strain did not convert glucose, mannose and galactose into their corresponding polyols but only into ethanol and cell mass. By contrast, fermentation of arabinose lead to the formation of arabitol. On D-xylose medium,Candida guillermondii exhibited high yield and rate of xylitol production when the initial sugar concentration exceeded 110 g/l. A final xylitol concentration of 221 g/l was obtained from 300 g/l D-xylose with a yield of 82,6% of theoretical and an average specific rate of 0,19 g/g.h.Nomenclature Q_p average volumetric productivity of xylitol (g xylitol/l per hour) - q_p average specific productivity of xylitol (g xylitol/g of cells per hour) - So initial xylose concentration (g/l) - tf incubation time (hours) - Y_P/S xylitol yield (g of xylitol produced/g of xylose utilized) - Y_E/S ethanol yield (g of ethanol produced/g of substrate utilized) - Y_X/S cells yield (g of cells/g of substrate utilized) - specific growth rate coefficient (h^–1) - _max maximum specific growth rate coefficient (h^–1)     

Fed-batch xylitol production with recombinantXYL-1-expressingSaccharomyees cerevisiae using ethanol as a co-substrate

The bioconversion of xylose into xylitol in fed-batch fermentation with a recombinantSaccharomyces cerevisiae strain, transformed with the xylose-reductase gene ofPichia stipitis, was studied. When only xylose was fed into the fermentor, the production of xylitol continued until the ethanol that had been produced during an initial growth phase on glucose, was depleted. It was concluded that ethanol acted as a redox-balance-retaining co-substrate. The conversion of high amounts of xylose into xylitol required the addition of ethanol to the feed solution. Under O₂-limited conditions, acetic acid accumulated in the fermentation broth, causing poisoning of the yeast at low extracellular pH. Acetic acid toxicity could be avoided by either increasing the pH from 4.5 to 6.5 or by more effective aeration, leading to the further metabolism of acetic acid into cell mass. The best xylitol/ethanol yield, 2.4 gg^–1 was achieved under O₂-limited conditions. Under anaerobic conditions ethanol could not be used as a co-substrate, because the cell cannot produce ATP for maintenance requirements from ethanol anaerobically. The specific rate of xylitol production decreased with increasing aeration. The initial volumetric productivity increased when xylose was added in portions rather than by continuous feeding, due to a more complete saturation of the transport system and the xylose reductase enzyme.     

Isolation and Characterization of Xylitol-Producing Yeasts from the Gut of Colleopteran Insects

A total of 35 yeasts were isolated from the gut of beetles collected from Hyderabad city, India. Twenty of these yeasts utilized xylose as a sole carbon source but only 12 of these converted xylose to xylitol. The ability to convert xylose to xylitol varied among the isolates and ranged from 0.12 to 0.58 g/g xylose. Based on the phenotypic characteristics and phylogenetic analysis of the D1/D2 domain sequence of 26S rRNA gene, these isolates were identified as members of Pichia, Candida, Issatchenkia, and Clavispora. Strain YS 54 (CBS 10446), which was phylogenetically similar to Pichia caribbica and which formed hat-shaped ascospore characteristics of the genus Pichia, was the best xylitol producer (0.58 g xylitol/g xylose). YS 54 was also capable of producing xylitol from sugarcane bagasse hydrolysate and the efficiency of conversion was 0.32 g xylitol/g xylose after 20 cycles of adaptation in medium containing sugarcane bagasse hydrolysate.     

The effects of the oxygen transfer coefficient and substrate concentration on the xylose fermentation by Debaryomyces hansenii

Relevant production of xylitol by Debaryomyces hansenii requires semiaerobic conditions since in aerobic conditions the accumulated reduced adenine dinucleotide coenzyme is fully reoxidized leading to the conversion of xylitol into xylulose. For oxygen transfer coefficient values from 0.24 to 1.88 min^-1, in shake flasks experiments, biomass formation increased proportionally to the aeration rate as shown in the oxygen transfer coefficient and xylose concentration isoresponse contours. The metabolic products under study, xylitol and ethanol were mainly growth associated. However, for oxygen transfer coefficient above 0.5 min^-1 higher initial xylose concentration stimulated the rate of production of xylitol. This fact was less evident for ethanol production. The direct relationship between increased biomass and products formation rate, indicated that the experimental domain in respect to the aeration rate was below the threshold level before the decreasing in metabolic production rates reported in literature for xylose-fermenting yeasts. The fact that ethanol was produced, albeit in low levels, throughout the experimental design indicated that the semiaerobic conditions were always attained. Debaryomyces hansenii showed to be an important xylitol producer exhibiting a xylitol/ethanol ratio above four and a carbon conversion of 54% for xylitol.Abbreviations K_La oxygen transfer coefficient - DO(T) dissolved oxygen (tension) - OUR oxygen uptake rate - NAD(H) oxidised (reduced) nicotinamide adenine dinucleotide - NADP(H) oxidised (reduced) nicotinamide adenine dinucleotide phosphate - CRC catabolic reduction charge - C oxygen concentration in the culture medium - C^* oxygen concentration at saturation conditions - Y_i response from experiment i - parameters of the polynomial model - x experimental factor level (coded units) - R² coefficient of multiple determination - t time     

Acetone stimulation of ethanol production from d-xylose by Pachysolen tannophilus

Summary Pachysolen tannophilus, a homothallic yeast, converts xylose to ethanol at a yield of 0.3 (g/g xylose). Concomitant with ethanol production, xylitol accumulates in the culture medium at similar yields (0.3 g/g xylose). The addition of the hydrogen-accepting compound, acetone, increases the amount of ethanol produced by this organism by 50–70%. The increase in ethanol is directly correlated with a decrease in xylitol secreted. The results indicate that conversion of acetone to 2-propanol by the cells provides the NAD⁺ used as a cofactor by xylitol dehydrogenase, the enzyme responsible for converting xylitol to xylulose.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U. S. Department of Agriculture over other firms or similar products not mentioned.     

Conversion of d-xylose into xylitol by immobilized cells of Candida pelliculosa and Methanobacterium sp. HU

The enzymatic conversion of d-xylose into xylitol by the immobilized cells of Candida pelliculosa (NADP⁺ dependent xylose reductase) coupled with the immobilized cells of Methanobacterium sp. HU (hydrogenase and F₁₂₀-NADP⁺ oxidoreductase) was done using hydrogen as an electron donor of NADP⁺. Benzene treatment of the co-immobilized cells with a photo-crosslinkable resin prepolymer, ENT 4000, increased the permeability of NADP (H) into the cells. Besides, treatments with glutaraldehyde and hexamethylenediamine to the immubilized cells were done to enhance the stability of immobilized-cell activity. Thus, the continuous production of xylitol in a column reactor packed with the co-immobilized cells could operate stably for 2 weeks.     

Analysis and optimization of a two-substrate fermentation for xylitol production using Candida tropicalis

Xylitol, a functional sweetener, was produced from xylose using Candida tropicalisATCC 13803. A two-substrate fermentation was designed in order to increase xylitol yield and volumetric productivity. Glucose was used initially for cell growth followed by conversion of xylose to xylitol without cell growth and by-product formation after complete depletion of glucose. High glucose concentrations increased volumetric productivity by reducing conversion time due to high cell mass, but also led to production of ethanol, which, in turn, inhibited cell growth and xylitol production. Computer simulation was undertaken to optimize an initial glucose concentration using kinetic equations describing rates of cell growth and xylose bioconversion as a function of ethanol concentration. Kinetic constants involved in the equations were estimated from the experimental results. Glucose at 32 g L⁻¹ was estimated to be an optimum initial glucose concentration with a final xylose concentration of 86 g L⁻¹ and a volumetric productivity of 5.15 g-xylitol L⁻¹ h⁻¹. The two-substrate fermentation was performed under optimum conditions to verify the computer simulation results. The experimental results were in good agreement with the predicted values of simulation with a xylitol yield of 0.81 g-xylitol g-xylose⁻¹ and a volumetric productivity of 5.06 g-xylitol L⁻¹ h⁻¹. Received 16 June 1998/ Accepted in revised form 28 February 1999     

Expression of protein engineered NADP<Superscript>+</Superscript>-dependent xylitol dehydrogenase increases ethanol production from xylose in recombinant <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

A recombinant Saccharomyces cerevisiae strain transformed with xylose reductase (XR) and xylitol dehydrogenase (XDH) genes from Pichia stipitis has the ability to convert xylose to ethanol together with the unfavorable excretion of xylitol, which may be due to cofactor imbalance between NADPH-preferring XR and NAD⁺-dependent XDH. To reduce xylitol formation, we have already generated several XDH mutants with a reversal of coenzyme specificity toward NADP⁺. In this study, we constructed a set of recombinant S. cerevisiae strains with xylose-fermenting ability, including protein-engineered NADP⁺-dependent XDH-expressing strains. The most positive effect on xylose-to-ethanol fermentation was found by using a strain named MA-N5, constructed by chromosomal integration of the gene for NADP⁺-dependent XDH along with XR and endogenous xylulokinase genes. The MA-N5 strain had an increase in ethanol production and decrease in xylitol excretion compared with the reference strain expressing wild-type XDH when fermenting not only xylose but also mixed sugars containing glucose and xylose. Furthermore, the MA-N5 strain produced ethanol with a high yield of 0.49 g of ethanol/g of total consumed sugars in the nonsulfuric acid hydrolysate of wood chips. The results demonstrate that glucose and xylose present in the lignocellulosic hydrolysate can be efficiently fermented by this redox-engineered strain.     

Enhanced Xylitol Production by Precultivation of Candida guilliermondii Cells in Sugarcane Bagasse Hemicellulosic Hydrolysate

The present work evaluated the key enzymes involved in xylitol production (xylose reductase [XR] and xylitol dehydrogenase [XDH]) and their correlation with xylose, arabinose, and acetic acid assimilation during cultivation of Candida guilliermondii FTI 20037 cells in sugarcane bagasse hemicellulosic hydrolysate. For this purpose, inocula previously grown either in sugarcane bagasse hemicellulosic hydrolysate (SBHH) or in semidefined medium (xylose as a substrate) were used. The highest xylose/acetic acid consumption ratio (1.78) and the lowest arabinose consumption (13%) were attained in the fermentation using inoculum previously grown in semidefined medium (without acetic acid and arabinose). In this case, the highest values of XR (1.37 U mg prot⁻¹) and XDH (0.91 U mg prot⁻¹) activities were observed. The highest xylitol yield (∼0.55 g g⁻¹) and byproducts (ethanol and glycerol) formation were not influenced by inoculum procedure. However, the cell previously grown in the hydrolysate was effective in enhancing xylitol production by keeping the XR enzyme activity at high levels (around 0.99 U·mg_prot⁻¹), reducing the XDH activity (34.0%) and increasing xylitol volumetric productivity (26.5%) with respect to the inoculum cultivated in semidefined medium. Therefore, inoculum adaptation to SBHH was shown to be an important strategy to improve xylitol productivity.     

Photosynthetic Reduction of Xylose to Xylitol Using Cyanobacteria

Photosynthetic generation of reducing power makes cyanobacteria an attractive host for biochemical reduction compared to cell‐free and heterotrophic systems, which require burning of additional resources for the supply of reducing equivalent. Here, using xylitol synthesis as an example, efficient uptake and reduction of xylose photoautotrophically in Synechococcus elongatus PCC7942 are demonstrated upon introduction of an effective xylose transporter from Escherichia coli (Ec‐XylE) and the NADPH‐dependent xylose reductase from Candida boidinii (Cb‐XR). Simultaneous activation of xylose uptake and matching of cofactor specificity enabled an average xylitol yield of 0.9 g g^?1 xylose and a maximum productivity of about 0.15 g L^?1 day^?1 OD^?1 with increased level of xylose supply. While long‐term cellular maintenance still appears challenging, high‐density conversion of xylose to xylitol using concentrated resting cell further pushes the titer of xylitol formation to 33 g L^?1 in six days with 85% of maximum theoretical yield. While the results show that the unknown dissipation of xylose can be minimized when coupled to a strong reaction outlet, it remains to be the major hurdle hampering the yield despite the reported inability of cyanobacteria to metabolize xylose.     

Simultaneous fermentation and isomerization of xylose

Summary Ethanol was produced from xylose by converting the sugar to xylulose, using commercial xylose isomerases, and simultaneously converting the xylulose to ethanol by anaerobic fermentation using different yeast strains. The process was optimized with the yeast strain Schizosaccharomyces pombe (Y-164). The data show that the simultaneous fermentation and isomerization of 6% xylose can produce final ethanol concentrations of 2.1% w/v within 2 days at temperatures as high as 39°C.Nomenclature SFIX simultaneous fermentation and isomerization of xylose - V _p volumetric production (g ethanol·l^-1 per hour) - Q _p specific rate (g ethanol·g^-1 cells per hour) - Y _s yield from substrate consumed (g ethanol, g^-1 xylose) - ET ethanol concentration (% wt/vol) - XT xylitol concentration (% wt/vol) - Glu glucose - Xyl xylose - --m maximum - --f final     

Fermentation performance of Candida guilliermondii for xylitol production on single and mixed substrate media

Semidefined media fermentation simulating the sugar composition of hemicellulosic hydrolysates (around 85 g l^-1 xylose, 17 g l^-1 glucose, and 9 g l^-1 arabinose) was investigated to evaluate the glucose and arabinose influence on xylose-to-xylitol bioconversion by Candida guilliermondii. The results revealed that glucose reduced the xylose consumption rate by 30%. Arabinose did not affect the xylose consumption but its utilization by the yeast was fully repressed by both glucose and xylose sugars. Arabinose was only consumed when it was used as a single carbon source. Xylitol production was best when glucose was not present in the fermentation medium. On the other hand, the arabinose favored the xylitol yield (which attained 0.74 g g^-1 xylose consumed) and it did not interfere with xylitol volumetric productivity (Q _P=0.85 g g^-1), the value of which was similar to that obtained with xylose alone.     

Xylitol does not inhibit xylose fermentation by engineered <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> expressing <Emphasis Type="Italic">xylA</Emphasis> as severely as it inhibits xylose isomerase reaction in vitro

Efficient fermentation of xylose, which is abundant in hydrolysates of lignocellulosic biomass, is essential for producing cellulosic biofuels economically. While heterologous expression of xylose isomerase in Saccharomyces cerevisiae has been proposed as a strategy to engineer this yeast for xylose fermentation, only a few xylose isomerase genes from fungi and bacteria have been functionally expressed in S. cerevisiae. We cloned two bacterial xylose isomerase genes from anaerobic bacteria (Bacteroides stercoris HJ-15 and Bifidobacterium longum MG1) and introduced them into S. cerevisiae. While the transformant with xylA from B. longum could not assimilate xylose, the transformant with xylA from B. stercoris was able to grow on xylose. This result suggests that the xylose isomerase (BsXI) from B. stercoris is functionally expressed in S. cerevisiae. The engineered S. cerevisiae strain with BsXI consumed xylose and produced ethanol with a good yield (0.31 g/g) under anaerobic conditions. Interestingly, significant amounts of xylitol (0.23 g xylitol/g xylose) were still accumulated during xylose fermentation even though the introduced BsXI might not cause redox imbalance. We investigated the potential inhibitory effects of the accumulated xylitol on xylose fermentation. Although xylitol inhibited in vitro BsXI activity significantly (K _I = 5.1 ± 1.15 mM), only small decreases (less than 10%) in xylose consumption and ethanol production rates were observed when xylitol was added into the fermentation medium. These results suggest that xylitol accumulation does not inhibit xylose fermentation by engineered S. cerevisiae expressing xylA as severely as it inhibits the xylose isomerase reaction in vitro.