Optimisation and scale-up of α-glucuronidase production by recombinant Saccharomyces cerevisiae in aerobic fed-batch culture with constant growth rate

α-Glucuronidase (EC 3.2.1.139) of family GH 115 from Scheffersomyces stipitis is a valuable enzyme for the modification of water-soluble xylan into insoluble biopolymers, due to its unique ability to act on polymeric xylans. The influence of growth rate on the production of α-glucuronidase by recombinant Saccharomyces cerevisiae MH1000pbk10D-glu in glucose-limited fed-batch culture was studied at 14 and 100 L scale. At and below the critical specific growth rate (μ_crit) of 0.12 h⁻¹ at 14 L scale, the biomass yield coefficient (Y_x/s) remained constant at 0.4 g g⁻¹ with no ethanol production, whereas ethanol yields relative to biomass (k_eth/x) of up to 0.54 g g⁻¹ and a steady decrease in Y_x/s were observed at μ > 0.12 h⁻¹. Production of α-glucuronidase was growth associated at a product yield (k_α-glu/x) of 0.45 mg g⁻¹, with the highest biomass (37.35 g/L) and α-glucuronidase (14.03 mg/L) concentrations, were recorded during fed-batch culture at or near to μ_crit. Scale-up with constant k_La from 14 to 100 L resulted in ethanol concentrations of up to 2.5 g/L at μ = 0.12 h⁻¹. At this scale, α-glucuronidase yield could be maximised at growth rates below μ_crit, to prevent localised high glucose concentration pockets at the feed entry zone that would induce oxido-reductive metabolism. This is the first report where recombinant production of α-glucuronidase (EC 3.2.1.139) by S. cerevisiae was optimised for application at pilot scale.     

The effect of glycerol mixed substrate on the heterologous production of a Rhizopus oryzae lipase in Pichia pastoris system

A recombinant Rhizopus oryzae lipase producing Mut^s Pichia pastoris strain was used as a model organism to study the effect of mixed substrates (glycerol and methanol) on the specific product productivity. Different fed-batch cultivations were performed under three constant specific growth rates (0.02, 0.05 and 0.1 h⁻¹), maintaining a constant methanol concentration of 2 g l⁻¹.At the lowest μ tested (0.02 h⁻¹), the specific productivity was 1.23 and 1.61 fold higher and the specific methanol consumption rate (q_sMeOH) was 3 and 3.5 fold higher than values obtained when μ was 0.05 and 0.1 h⁻¹, respectively. This implies a relation between the q_sMeOH and the specific productivity, yielding higher specific productivities whenever the consumption of methanol is higher. Although glycerol was maintained under limiting conditions in all μ tested, when the relation between the μ_Gly and μ_MeOH was larger than 4, an important decrease on the maximal activity value was observed.Finally, a comparison under the same conditions using glycerol or sorbitol as co-substrates was also performed, obtaining better specific productivity when sorbitol was used. In addition, protease activity was detected when glycerol was used as co-substrate.     

Seasonal variations in photosynthetic irradiance response curves of macrophytes from a Mediterranean coastal lagoon

The main photosynthesis and respiration parameters (dark respiration rate, light saturated production rate, saturation irradiance, photosynthetic efficiency) were measured on a total of 23 macrophytes of the Thau lagoon (2 Phanerogams, 5 Chlorophyceae, 10 Rhodophyceae and 6 Phaeophyceae). Those measurements were performed in vitro under controlled conditions, close to the natural ones, and at several seasons. Concomitantly, measurements of pigment concentrations, carbon, phosphorous and nitrogen contents in tissues were performed. Seasonal intra-specific variability of photosynthetic parameters was found very high, enlightening an important acclimatation capacity. The highest photosynthetic capacities were found for Chlorophyceae (e.g. Monostroma obscurum thalli at 17 °C, 982 μmol O₂ g⁻¹ dw h⁻¹ and 9.1 μmol O₂ g⁻¹ dw h⁻¹/μmol photons m⁻² s⁻¹, respectively for light saturated net production rate and photosynthetic efficiency) and Phanerogams (e.g. Nanozostera noltii leaves at 25 °C, 583 μmol O₂ g⁻¹ dw h⁻¹ and 2.6 μmol O₂ g⁻¹ dw h⁻¹/μmol photons m⁻² s⁻¹ respectively for light saturated net production rate and photosynthetic efficiency). As expected, species with a high surface/volume ratio were found to be more productive than coarsely branched thalli and thick blades shaped species. Contrary to R_d (ranging 6.7–794 μmol O₂ g⁻¹ dw h⁻¹, respectively for Rytiphlaea tinctoria at 7 °C and for Dasya sessilis at 25 °C) for which a positive relationship with water temperature was found whatever the species studied, the evolution of P/I curves with temperature exhibited different responses amongst the species. The results allowed to show summer nitrogen limitation for some species (Gracilaria bursa-pastoris and Ulva spp.) and to propose temperature preferences based on the photosynthetic parameters for some others (N. noltii, Zostera marina, Chaetomorpha linum).     

Modeling of ethanol fermentation using Zymomonas mobilis ATCC 10988 grown on the media containing glucose and fructose

A model of ethanol fermentation by Zymomonas mobilis ATCC 10988 on the medium containing glucose and fructose is proposed. This model was developed on the basis of metabolic analysis and many experimental findings. When glucose was used as the substrate, the dependence of the carbon fraction (α) assimilating to biomass on the specific growth rate (μ) could be well correlated to α = 0.25μ + 0.012. This correlation resulted in a novel equation for specific glucose uptake rate, which could describe the Z. mobilis fermentation in both batch and continuous modes. When fructose and glucose were both presented in the liquid medium, the model could predict the uptake of glucose and fructose as well as the formation of biomass, ethanol and sorbitol by Z. mobilis. All parameters used in the model were independently evaluated on the basis of various experimental findings. Good agreement was found between the model predictions and data of Z. mobilis fermentation on media containing both glucose and fructose. The proposed model could also describe the behavior of ethanol fermentation on sucrose medium supplemented with immobilized invertase.     

Light acclimation of photosynthesis in three charophyte species

The main aim of this study was to investigate if the charophyte species Chara baltica, Chara canescens (two populations from the Baltic Sea (BS) and the Gulf of Korinth, Greece (GK)), and Lamprothamnium papulosum exhibit different acclimation capacities to irradiance. Growth, photosynthesis and pigment content were examined in the laboratory under six irradiance conditions (35–500 μmol photons m⁻² s⁻¹). Growth experiments showed increasing growth rates from 35 μmol photons m⁻² s⁻¹ (∼10 mg fresh weight (FW)) up to 70 μmol photons m⁻² s⁻¹ (∼20 mg FW) in C. baltica, from 35 μmol photons m⁻² s⁻¹ (∼15 mg FW) up to 380 μmol photons m⁻² s⁻¹ (∼145 mg FW) in C. canescens (BS), and up to the highest growth irradiance in algae of L. papulosum (35 μmol: ∼5 mg FW; 500 μmol: ∼20 mg FW). The species were tested for their ability to acclimate to different growth irradiances (E_g) by calculating P_max (maximum photosynthesis rate at saturating irradiances), α (the efficiency of light utilization at limiting irradiance), and E_k (the light saturation point of photosynthesis, P_max/α). All species exhibited increasing P_max with increasing E_g. Whereas both populations of C. canescens increased α with increasing E_g, L. papulosum and C. baltica did not acclimate α at all. E_k, the irradiance at which photosynthesis ceased to be light-limited, was constant for all Chara species within the range of irradiances tested. Chl a/Chl b ratios of all species were constant over the whole range of E_g. Chl a/carotenoid ratios were constant in C. baltica, whereas Chl a/carotenoid ratios in L. papulosum and C. canescens (BS) decreased from 250 and 70 μmol photons m⁻² s⁻¹ upwards, respectively. Pigmentation analysis showed that Chl a/carotenoid acclimation was mainly caused by species-specific capacity to raise the content of lutein and carotene (C. canescens (BS), C. canescens (GK)) and xanthophyll cycle pigments (XCP; L. papulosum). The non-photochemical quenching (NPQ) capacities of L. papulosum, C. canescens (BS), and C. canescens (GK) were dependent from preacclimation status of algae, whereas NPQ of C. baltica was independent from growth irradiance.Our results indicate that C. baltica and C. canescens (BS) were light saturated within the chosen irradiances, whereas C. canescens (GK) and L. papulosum did not reach their limits of high-light acclimation. The photosynthetic pigments lutein, α- and β-carotene are suggested to act as photo-protective pigments in L. papulosum and C. canescens.     

Ability of a perfluoropolymer membrane to tolerate by-products of ethanol fermentation broth from dilute acid-pretreated rice straw

A perfluoropolymer (PFP) membrane has been prepared for use in vapor permeation to separate aqueous ethanol mixtures produced from rice straw with xylose-assimilating recombinant Saccharomyces cerevisiae. PFP membranes commonly have been used for dehydration process and possess good selectivity and high permeances. The effects of by-products during dilute acid pretreatment, addition of yeast extract, and ethanol fermentation on PFP membrane performance were investigated. While feeding mixtures of ethanol (90 wt%) in water, to which individual by-products (0.1–2 g/L) were added, the PFP membrane demonstrated no clear change in permeation rate (439–507 g m⁻² h⁻¹) or separation factor (14.9–23.5) from 2 to 4 h of the process. The PFP membrane also showed no clear change in permeation rate (751–859 g m⁻² h⁻¹) or separation factor (12.5–13.8) while feeding the mixture (final ethanol conc.: 61 wt%) of ethanol and distillation of the fermentation broth using a suspended fraction of dilute acid-pretreated rice straw for 20 h. These results suggest that the PFP membrane can tolerate actual distillation liquids from ethanol fermentation broth obtained from lignocellulosic biomass pretreated with dilute acid.     

The effects of light intensity on the growth of Japanese Gambierdiscus spp. (Dinophyceae)

Marine toxic dinoflagellates of the genus Gambierdiscus are the causative agents of ciguatera fish poisoning (CFP), a form of seafood poisoning that is widespread in tropical, subtropical and temperate regions worldwide. The distributions of Gambierdiscus australes, Gambierdiscus scabrosus and two phylotypes of Gambierdiscus spp. type 2 and type 3 have been reported for the waters surrounding the main island of Japan. To explore the bloom dynamics and the vertical distribution of these Japanese species and phylotypes of Gambierdiscus, the effects of light intensity on their growth were tested, using a photoirradiation-culture system. The relationship between the observed growth rates and light intensity conditions for the four species/phylotypes were formulated at R > 0.92 (p < 0.01) using regression analysis and photosynthesis-light intensity (P-L) model. Based on this equation, the optimum light intensity (L_max) and the semi-optimum light intensity range (L_s-opt) that resulted in the maximum growth rate (μ_max) and ≥80% μ _max values of the four species/phylotypes, respectively, were as follows: (1) the L_max and L_s-opt of G. australes were 208 μmol photons m⁻² s⁻¹ and 91–422 μmol photons m⁻² s⁻¹, respectively; (2) those of G. scabrosus were 252 and 120–421 μmol photons m⁻² s⁻¹, respectively; (3) those of Gambierdiscus sp. type 2 were 192 and 75–430 μmol photons m⁻² s⁻¹, respectively; and (4) those of Gambierdiscus sp. type 3 were ≥427 and 73–427 μmol photons m⁻² s⁻¹, respectively. All four Gambierdiscus species/phylotypes required approximately 10 μmol photons m⁻² s⁻¹ to maintain growth. The light intensities in coastal waters at a site in Tosa Bay were measured vertically at 1 m intervals once per season. The relationships between the observed light intensity and depth were formulated using Beer’s Law. Based on these equations, the range of the attenuation coefficients at Tosa Bay site was determined to be 0.058–0.119 m⁻¹. The values 1700 μmol photons m⁻² s⁻¹, 500 μmol photons m⁻² s⁻¹, and 200 μmol photons m⁻² s⁻¹ were substituted into the equations to estimate the vertical profiles of light intensity at sunny midday, cloudy midday and rainy midday, respectively. Based on the regression equations coupled with the empirically determined attenuation coefficients for each of the four seasons, the ranges of the projected depths of L_max and L_s-opt for the four Gambierdiscus species/phylotypes under sunny midday conditions, cloudy midday conditions, and rainy midday conditions were 12–38 m and 12–54 m, 1–16 m and 1–33 m, and 0 m and 0–16 m, respectively. These results suggest that light intensity plays an important role in the bloom dynamics and vertical distribution of Gambierdiscus species/phylotypes in Japanese coastal waters.     

Diurnal exchanges of CO2 and CH4 across the water–atmosphere interface in a water chestnut meadow (Trapa natans L.)

CH₄ and CO₂ fluxes across the water–atmosphere interface were measured over a 24 h day–night cycle in a shallow oxbow lake colonized by the water chestnut (Trapa natans L.) (Lanca di Po, Northern Italy). Only exchanges mediated by macrophytes were measured, whilst gas ebullition was not considered in this study. Measurements were performed from 29 to 30 July 2005 with short incubations, when T. natans stands covered the whole basin surface with a mean dry biomass of 504 ± 91 g m⁻². Overall, the oxbow lake resulted net heterotrophic with plant and microbial respiration largely exceeding carbon fixation by photosynthesis. The water chestnut stand was a net sink of CO₂ during the day-light period (−60.5 ± 8.5 mmol m⁻² d⁻¹) but it was a net source at night (207.6 ± 6.1 mmol m⁻² d⁻¹), when the greatest CO₂ efflux rate was measured across the water surface (28.2 ± 2.4 mmol m⁻² h⁻¹). The highest CH₄ effluxes (6.6 ± 1.8 mmol m⁻² h⁻¹) were determined in the T. natans stand during day-time, whilst CH₄ emissions across the plant-free water surface were greatest at night (6.8 ± 2.1 mmol m⁻² h⁻¹). Therefore, we assumed that the water chestnut enhanced methane delivery to the atmosphere. On a daily basis, the oxbow lake was a net source to the atmosphere of both CO₂ (147.1 ± 10.8 mmol m⁻² d⁻¹) and CH₄ (116.3 ± 8.0 mmol m⁻² d⁻¹).     

The effects of NH4+ and NO3− on growth,resource allocation and nitrogen uptake kinetics of Phragmites australis and Glyceria maxima

The effects of NH₄⁺ or NO₃⁻ on growth, resource allocation and nitrogen (N) uptake kinetics of two common helophytes Phragmites australis (Cav.) Trin. ex Steudel and Glyceria maxima (Hartm.) Holmb. were studied in semi steady-state hydroponic cultures. At a steady-state nitrogen availability of 34 μM the growth rate of Phragmites was not affected by the N form (mean RGR = 35.4 mg g⁻¹ d⁻¹), whereas the growth rate of Glyceria was 16% higher in NH₄⁺-N cultures than in NO₃⁻-N cultures (mean = 66.7 and 57.4 mg g⁻¹ d⁻¹ of NH₄⁺ and NO₃⁻ treated plants, respectively). Phragmites and Glyceria had higher S/R ratio in NH₄⁺ cultures than in NO₃⁻ cultures, 123.5 and 129.7%, respectively.Species differed in the nitrogen utilisation. In Glyceria, the relative tissue N content was higher than in Phragmites and was increased in NH₄⁺ treated plants by 16%. The tissue NH₄⁺ concentration (mean = 1.6 μmol g fresh wt⁻¹) was not affected by N treatment, whereas NO₃⁻ contents were higher in NO₃⁻ (mean = 1.5 μmol g fresh wt⁻¹) than in NH₄⁺ (mean = 0.4 μmol g fresh wt⁻¹) treated plants. In Phragmites, NH₄⁺ (mean = 1.6 μmol g fresh wt⁻¹) and NO₃⁻ (mean = 0.2 μmol g fresh wt⁻¹) contents were not affected by the N regime. Species did not differ in NH₄⁺ (mean = 56.5 μmol g⁻¹ root dry wt h⁻¹) and NO₃⁻ (mean = 34.5 μmol g⁻¹ root dry wt h⁻¹) maximum uptake rates (V_max), and V_max for NH₄⁺ uptake was not affected by N treatment. The uptake rate of NO₃⁻ was low in NH₄⁺ treated plants, and an induction phase for NO₃⁻ was observed in NH₄⁺ treated Phragmites but not in Glyceria. Phragmites had low K_m (mean = 4.5 μM) and high affinity (10.3 l g⁻¹ root dry wt h⁻¹) for both ions compared to Glyceria (K_m = 6.3 μM, affinity = 8.0 l g⁻¹ root dry wt h⁻¹). The results showed different plasticity of Phragmites and Glyceria toward N source. The positive response to NH₄⁺-N source may participates in the observed success of Glyceria at NH₄⁺ rich sites, although other factors have to be considered. Higher plasticity of Phragmites toward low nutrient availability may favour this species at oligotrophic sites.     

Foliage type specific susceptibility to ozone in Picea abies,Pinus cembra and Larix decidua at treeline: A synthesis

Cumulative ozone uptake (COU, mmol m⁻²) and O₃ flux (FO₃, nmol m⁻² s⁻¹) were related to physiological, morphological and biochemical characteristics of field-grown mature evergreen Norway spruce [Picea abies (L.) Karst.], Cembran pine [Pinus cembra L.], and deciduous European larch [Larix decidua Mill.] trees at treeline. The threshold COU causing a statistically significant decline in photosynthetic capacity (A_max) ranged between 19.6 mmol m⁻² in current-year needles of evergreen conifers and 22.0 6 mmol m⁻² in short-shoot needles of deciduous L. decidua subjected to exposure periods of ≥84 and ≥43 days, respectively. The higher O₃ sensitivity of deciduous L. decidua than of evergreen P abies and P. cembra was associated with differences in FO₃ and specific leaf area (SLA), both being significantly higher in L. decidua. FO₃ was 5.9 nmol m⁻² s⁻¹ in L. decidua and 2.7 nmol m⁻² s⁻¹ in evergreen conifers. Species-dependent differences were also related to detoxification capacity expressed through total surface area based concentrations of reduced ascorbate and α-tocopherol that both increased with SLA. Findings suggest that differences in O₃ sensitivity between evergreen and deciduous conifers can be attributed to foliage type specific differences in SLA, the latter determining physiological and biochemical characteristics of the treeline conifers.     

Effect of nutrient pulses on photosynthesis of Chaetomorpha linum from a shallow Mediterranean coastal lagoon

The influence of nitrogen and phosphorus pulses on Chaetomorpha linum (Muller) Kutzing growth and photosynthesis was studied in laboratory experiments. Photosynthesis and growth of C. linum from Tancada lagoon seems limited by both nitrogen and phosphorus, as indicated by the high rate (4.7–11.6 mg O₂ g⁻¹ dry weight h⁻¹) of light-saturated photosynthesis (P_m) and growth rates observed under nitrogen plus phosphorus enrichment in relation to enrichment by nitrogen alone (2.9–7.6 mg O₂ g⁻¹ dry weight h⁻¹). Significant increase in nitrogen and phosphorus content as percentage of dry weight was observed in C. linum fertilized with a single nutrient or with nitrogen plus phosphorus. In Tancada lagoon, when availability of nitrogen to primary producers is by pulses, an increase of nitrate concentration in the water column (from 6 to 100 μM) has a greater effect on growth of C. linum (growth rate: 0.13 day⁻¹) than an increase in ammonium concentration (from 20 to 100 μM and growth rate: 0.11 day⁻¹). For a given thallus nitrogen content (0.6–1.4% N), both P_m and the photosynthetic efficiency (α) normalized to dry weight were correlated (r² = 0.73, p < 0.005) indicating that variations in electron transport were coupled to variations in C-fixation capacity. Optimizing both α and P_m may be a general characteristic of thin-structured opportunistic algae in more variable estuarine environments.     

Effects of flooding on photosynthesis and root respiration in saltcedar (Tamarix ramosissima), an invasive riparian shrub

The introduced shrub Tamarix ramosissima invades riparian zones, but loses competitiveness under flooding. Metabolic effects of flooding could be important for T. ramosissima, but have not been previously investigated. Photosynthesis rates, stomatal conductance, internal (intercellular) CO₂, transpiration, and root alcohol dehydrogenase (ADH) activity were compared in T. ramosissima across soil types and under drained and flooded conditions in a greenhouse. Photosynthesis at 1500 μmol quanta m⁻² s⁻¹ (A₁₅₀₀) in flooded plants ranged from 2.3 to 6.2 μmol CO₂ m⁻² s⁻¹ during the first week, but A₁₅₀₀ increased to 6.4–12.7 μmol CO₂ m⁻² s⁻¹ by the third week of flooding. Stomatal conductance (g_s) at 1500 μmol quanta m⁻² s⁻¹ also decreased initially during flooding, where g_s was 0.018 to 0.099 mol H₂O m⁻² s⁻¹ during the first week, but g_s increased to 0.113–0.248 mol H₂O m⁻² s⁻¹ by the third week of flooding. However, photosynthesis in flooded plants was reduced by non-stomatal limitations, and subsequent increases indicate metabolic acclimation to flooding. Root ADH activities were higher in flooded plants compared to drained plants, indicating oxygen stress. Lower photosynthesis and greater oxygen stress could account for the susceptibility of T. ramosissima at the onset of flooding. Soil type had no effect on photosynthesis or on root ADH activity. In the field, stomatal conductance, leaf water potential, transpiration, and leaf δ¹³C were compared between T. ramosissima and other flooded species. T. ramosissima had lower stomatal conductance and water potential compared to Populus deltoides and Phragmites australis. Differences in physiological responses for T. ramosissima could become important for ecological concerns.     

Optimizing l-(+)-lactic acid production by thermophile Lactobacillus plantarum As.1.3 using alternative nitrogen sources with response surface method

The effects of five alternative nitrogen sources, namely, malt sprout (MS), corn steep liquor (CSL), NH₄Cl, NH₄NO₃ and diamine citrate (DC) were investigated on the l-(+)-lactic acid (LA) production by thermophile Lactobacillus plantarum As.1.3. Through the statistical analysis of the results by three steps of response surface methodology (RSM) design, MS and CSL were found to have significant effects on the LA production and their optimal concentrations in the medium should be 16.0 g/L and 12.0 g/L, respectively. The verification of the optimized medium showed that the maximum specific growth rate (μ_m) was 1.09 h⁻¹, the cell yield coefficient (Y_X/S) and the l-(+)-lactic acid yield coefficient (Y_P/S) were 0.233 (OD₆₂₀/g) and 0.98 (g/g), and the maximum volumetric productivity and the average volumetric productivity were 13.0 g/L h and 3.20 g/L h, respectively. The results indicate that the LA production can also be enhanced with the inexpensive nitrogen source alternatives.     

Construction of recombinant Escherichia coli for enhanced bioconversion of colchicine into 3-demethylated colchicine at 70 l bioreactor level

A recombinant strain of Escherichia coli with CYP102A1 gene was developed for the demethylation of colchicine into their derivatives. The CYP102A1 gene responsible for demethylation was isolated from Bacillus megaterium ACBT03 and amplified using suitable primers. The amplified product was cloned into pET28a+ expression vector using host E. coli BL21(DE3) cells. The CYP3A4 (product of CYP102A1 gene) protein expression and other parameters like substrate toxicity, product toxicity and enzyme activity were optimized in shake flasks; and further scaled-up to 5 l bioreactor with 3 l working volume. In 5 l bioreactor, dissolved oxygen (DO) was optimized for maximum specific growth and enhanced 3-demethylated colchicine (3-DMC) production. The optimized conditions from shake flasks were scaled-up to 70 l bioreactor and resulted into ∼80% conversion of 20 mM colchicine in 48 h with a volumetric productivity of 6.62 mg l⁻¹ h⁻¹. Scale-up factors were measured as volumetric oxygen transfer coefficient (k_La) i.e., 56 h⁻¹ and impeller tip velocity (V_tip) i.e., 7.065 m s⁻¹, respectively. The kinetic parameters K_m, k_cat, and k_cat/K_m of the CYP3A4 enzyme using colchicine as the substrate were determined to be 271 ± 30 μM, 8533 ± 25 min⁻¹, and 31.49 μM min⁻¹, respectively, when IPTG induced recombinant E. coli culture was used.     

Investigation on the properties and kinetics of glucose-fed aerobic granular sludge

Aerobic granulation is a process in which suspended biomass aggregate and form discrete well-defined granules in aerobic systems. To investigate the properties and kinetics of aerobic granular sludge, aerobic granules were cultivated with glucose synthetic wastewater in a series of sequencing batch reactors (SBR). The spherical shaped granules were observed on 8th day with the mean diameter of 0.1 mm. With the organic loading rate (OLR) being increased to 4.0 g COD L⁻¹ d⁻¹, aerobic granules grew matured with spherical shape. The size of granules ranged from 1.2 to 1.8 mm, and the corresponding settling velocity of individual granule was 24.2–36.4 m h⁻¹. The oxygen utilization rate (OUR) of mature granules was 41.90 g O₂ kg MLSS⁻¹ h⁻¹, which was two times higher than that of activated sludge (18.32 g O₂ kg MLSS⁻¹ h⁻¹). The experimental data indicated that the substrate utilization and biomass growth kinetics generally followed Monod's kinetics model. The corresponding kinetic coefficients of k (maximum specific substrate utilization rate), K_s (half velocity coefficient), Y (growth yield coefficient) and K_d (decay coefficient) were determined as follows, k_c = 23.65 d⁻¹, K_c = 3367.05 mg L⁻¹, K_N = 0.038 d⁻¹, K_N = 29.65 mg L⁻¹, Y = 0.1927–0.2022 mg MMLS (mg COD)⁻¹ and K_d = 0.00845–0.0135 d⁻¹, respectively. Those properties of aerobic granules made aerobic granules system had a short setup period, high substrate utilization rate and low sludge production.     

Evaluation of the effects of light intensity on growth of the benthic dinoflagellate Ostreopsis sp. 1 using a newly developed photoirradiation-culture system and a novel regression analytical method

Benthic dinoflagellates of the genus Ostreopsis are found all over the world in temperate, subtropical, and tropical coastal regions. Our recent studies revealed that a putative “cryptic” species of Ostreopsis ovata is present widely along Japanese coasts. This organism, Ostreopsis sp. 1, possesses palytoxin analogs and thus its toxic blooms may be responsible for potential toxification of marine organisms. To evaluate the bloom dynamics of Ostreopsis sp. 1, the present study examined the growth responses of Ostreopsis sp. 1 strain s0716 to various light intensities (photon flux densities: μmol photons m⁻² s⁻¹) using a newly devised photoirradiation-culture system. This novel system has white light-emitting diodes (LEDs) capable of more closely simulating the wavelength spectrum of light entering the oceanic water column than do fluorescent tubes and halogen lamps. In this system, the light intensity of the white LEDs was reduced through two polarizing filters by varying the rotation angles of the filters. Thereby, the new system was capable of culturing microalgae under well-controlled light intensity conditions. Ostreopsis sp. 1 grew proportionally when light intensity was increased from 49.5 to 199 μmol photons m⁻² s⁻¹, but its growth appeared to be inhibited slightly at ≥263 μmol photons m⁻² s⁻¹. The relationship between observed growth rates and light intensity was calculated at R > 0.99 (P < 0.01) using a regression analysis with a modified equation of the photosynthesis-light intensity (P-L) model. The equation determined the critical light intensities for growth of Ostreopsis sp. 1 and the organism's growth potential as follows: (1) the threshold light intensity for growth: 29.8 μmol photons m⁻² s⁻¹; (2) the optimum light intensity (L_m) giving the maximum growth rate (μ_max = 0.659 divisions day⁻¹): 196 μmol photons m⁻² s⁻¹; (3) the optimum light intensity range (L_opt) giving ≥95% μ_max: 130–330 μmol photons m⁻² s⁻¹; (4) the semi-optimum range (L_sopt) giving ≥80% μ_max: 90 to over 460 μmol photons m⁻² s⁻¹. The L_sopt represents 4.5–23% ambient light intensity present in surface waters off of a temperate region of the Japanese coast, Tosa Bay; putatively, this semi-optimum range of light intensity appears at depth of 12.9–27.8 m. Considering these issues, our data indicate that Ostreopsis sp. 1 in coastal environments may form blooms at ca. ∼28 m depth in regions along Japanese coasts.     

Effects of feed sugar concentration on continuous ethanol fermentation of cheese whey powder solution (CWP)

Cheese whey powder (CWP) solution with different CWP or sugar concentrations was fermented to ethanol in a continuous fermenter using pure culture of Kluyveromyces marxianus (DSMZ 7239). Sugar concentration of the feed CWP solution varied between 55 and 200 g l⁻¹ while the hydraulic residence time (HRT) was kept constant at 54 h. Ethanol formation, sugar utilization and biomass formation were investigated as functions of the feed sugar concentration. Percent sugar utilization and biomass concentrations decreased and the effluent sugar concentration increased with increasing feed sugar concentrations especially for the feed sugar contents above 100 g l⁻¹. Ethanol concentration and productivity (DP) increased with increasing feed sugar up to 100 g l⁻¹ and then decreased with further increases in the feed sugar content. The highest ethanol concentration (3.7%, v v⁻¹) and productivity (0.54 gE l⁻¹ h⁻¹) were obtained with the feed sugar content of 100 g l⁻¹ or 125 g l⁻¹. The ethanol yield coefficient (Y_P/S) was also maximum (0.49 gE gS⁻¹) when the feed sugar was between 100 and 125 g l⁻¹. The growth yield coefficient (Y_X/S) decreased steadily from 0.123 to 0.063 gX gS⁻¹ when the feed sugar increased from 55 to 200 g l⁻¹ due to adverse effects of high sugar contents on yeast growth. The optimal feed sugar concentration maximizing the ethanol productivity and sugar utilization was between 100 and 125 g l⁻¹ under the specified experimental conditions.     

Purification and characterization of cyanogenic β-glucosidase from wild apricot (Prunus armeniaca L.)

β-Glucosidase catalyzes the sequential breakdown of cyanogenic glycosides in cyanogenic plants. The β-glucosidase from Prunus armeniaca L. was purified to 8-fold, and 20% yield was obtained, with a specific activity of 281 U/mg protein. The enzyme showed maximum activity in 0.15 M sodium citrate buffer, pH 6, at 35 °C with p-nitrophenylglucopyranoside as substrate. The β-glucosidase from wild apricot was used successfully for the saccharification of cellobiose into D-glucose. This enzyme has a V_max of 131.6 μmol min⁻¹ mg⁻¹ protein, K_m of 0.158 mM, K_cat of 144.8 s⁻¹, K_cat/K_m of 917.4 mM⁻¹ s⁻¹, and K_m/V_max of 0.0012 mM min mg μmole⁻¹, using cellobiose as substrate. The half-life, deactivation rate coefficient, and activation energy of this β-glucosidase were 12.76 h, 1.509 × 10⁻⁵ s⁻¹, and 37.55 kJ/mol, respectively. These results showed that P. armeniaca is a potential source of β-glucosidase, with high affinity and catalytic capability for the saccharification of cellulosic material.     

Hydrogen sulphide removal from air by biotrickling filter using open-pore polyurethane foam as a carrier

A study was conducted on H₂S removal in a biotrickling filter packed with open-pore polyurethane foam. Thiobacillus denitrificans was used as inoculum and a mixed culture population was developed during the process. The inhibitory effect of sulphate concentration (1.8–16.8 g L⁻¹), pH (6.9–8.6), trickling liquid velocity (TLV, 9.1–22.8 m h⁻¹), H₂S inlet concentration (20–157 ppmv) and the empty bed residence time (EBRT, 9–57 s) on the H₂S removal efficiency (RE) were thoroughly investigated. An increase in pH from 6.9 to 8.5 led to a corresponding increase in H₂S removal. In addition, an inhibitory effect of sulphate concentration was observed from 16.8 g L⁻¹ and the maximum elimination capacity was found to be 22 gS m⁻³ h⁻¹ (RE 98%). The RE was constant (98.8 ± 0.30%) for EBRT ≥ 16 s, but a decrease in the EBRT from 16 to 9 s led to a corresponding decrease in RE from 98.2 to 89.6% for a TLV of 9.1 m h⁻¹ and from 97.9 to 94.9% for a TLV of 22.8 m h⁻¹ (inlet load of 11.0 ± 0.2 gS m⁻³ h⁻¹). The sulphur oxidation capacity in the biotrickling filter was not diminished by the presence of other bacteria.     

Sex-specific light acclimation of Chara canescens (Charophyta)

Bisexual populations of the charophyte Chara canescens (Desv. et Loisel. in Loisel., 1810) containing male and female individuals are rarely found. Two experiments were carried out to study whether male and female algae from the same site exhibit different physiological capacities, especially with respect to light acclimation.Algae from two different shore levels and from laboratory cultures acclimated to six irradiance conditions (35–500 μmol photons m⁻² s⁻¹) were compared. Field measurements showed that both female and male algae of C. canescens are able to acclimate to daily changes in solar irradiance. The quantum yield of Photosystem II (PSII) decreased with increasing irradiance in the morning and increased with decreasing irradiance in the afternoon. Growth experiments showed increasing growth rates from 35 μmol photons m⁻² s⁻¹ (∼7 mg FW) up to 500 μmol photons m⁻² s⁻¹ (∼27 mg FW) in female and male C. canescens. The irradiance saturation point for photosynthesis (E_k) was about 140 μmol m⁻² s⁻¹ for both sexes within the whole range of acclimation irradiances. The maximum photosynthesis rate at saturating irradiances (P_max) of male algae was highest at E_k, whereas P_max of female algae was highest at 500 μmol photons m⁻² s⁻¹. The photosynthetic efficiency in the light-limited range (α) increased in female C. canescens and decreased in male C. canescens. The ratio of the non-photochemical quenching parameter (NPQ) to the relative electron transport rates rETR_(MT) increased in both sexes with irradiance, but showed a steeper increase in male than in female algae. Pigment analysis showed similar acclimation pattern for male and female C. canescens. Chl a/Chl b ratios of both sexes were constant over the whole range of E_g, whereas Chl a/carotenoid ratios in male and female C. canescens decreased from 70 μmol photons m⁻² s⁻¹ upwards. Pigment analysis pointed out that the carotenes α-, β- and γ-carotene were more prominent in male than in female algae.Our results indicate that female C. canescens are more efficient in light acclimation than male algae from the same site. Nevertheless, further investigations of bisexual C. canescens populations resolving CO₂-uptake mechanisms and/or genetic differences are needed.