The Effect of High Sugar Concentrations on the Heat Resistance of Vegetative Micro-organisms

S ummary . The effect of sucrose or mixtures of sucrose and glucose, in the heating menstruum, on the heat resistance of 4 organisms, Salmonella senftenberg, Salm. typhimurium, Saccharomyces rouxii and Torulopsis globosa , was investigated and the results have been expressed in terms of D and z values against water activity ( a_w ). The effect on the cell of sucrose solutions, both with and without heat, was also investigated. Measurements of cell volume obtained from phase contrast micrographs and of O.D. showed that as the sucrose concentration increased, the volume of the cell decreased. The increased heat resistance exhibited by cells in sucrose solutions of low a_w is thought to be the result of a dehydration of the cell together with a reduction in the pore size of the cell wall.     

Water relations of solute accumulation in Pseudomonas fluorescens

When Pseudomonas fluorescens was grown in a glucose salts medium adjusted with NaCl to a water activity (a_w) value of 0.980, the intracellular glutamic acid concentration increased 23-fold and comprised 90% of the total amino acid pool. This increase was not observed when the a_w of the medium was reduced to 0.980 with sorbitol. Sorbitol was taken up rapidly over a 30 min period and accumulated intracellularly to a level approximately two-fold greater than the concentration in the growth medium. In continuous culture, the specific rate of glutamic acid production and glucose uptake was greater at 0.980 (NaCl) than at 0.997 a_w. The maintenance coefficients for glucose uptake were similar at both a_w values but were 2.4-fold greater for glutamic acid production at 0.980 (NaCl) than at 0.997 a_w.     

Combined Effects of Water Activity, pH and Temperature on the Growth and Spoilage Potential of Fungi

S ummary . An arbitrary parameter 'rejection time', i.e. the time required for a fungal inoculum to form a 2 mm diam. colony, was used to express the shelf life of jam after unsealing and exposure of the contents to airborne contamination. Individual and combined effects of water activity ( a_w ), pH value and temperature on rejection time of low sugar jam were estimated from the radial growth on agar of colonies of 9 fungi. The decreases in a_w (0·94–0·90) and temperature (25–15°) practicable for low sugar jam were more effective in increasing rejection time than the feasible decrease in pH value (3·7–2·9). The interaction between a_w and temperature was significant. The effect of the changes in a_w , temperature and pH on rejection time was broadly similar for media adjusted by either sucrose or glycerol. At a given a_w , moulds were slightly more tolerant of glycerol than sucrose but yeasts, except for the osmophile Saccharomyces rouxii , were markedly more tolerant of glycerol than sucrose.     

Water relations and metabolism of propionate in two yeasts from hay

Many yeasts and bacteria were isolated from moist hays (>30% water content) treated with up to 3% propionic acid-based preservatives. Predominant yeasts were Candida guilliermondii var. guilliermondii and Hyphopichia burtonii. Growth of both species was decreased more than 50% in liquid medium containing 54 mmol/l ammonium propionate but some still occurred in 135 mmol/l propionate. Both metabolized between 80 and 85% of 27 mmol/l ammonium propionate in 1% malt broth within four weeks at 25°C. Growth on solid malt extract agar containing ammonium propionate was decreased by decreasing the water availability (water activity, a_w) in the medium. Growth rates were slightly greater when glycerol rather than NaCl was used to alter a_w in the range 0.995 to 0.93. At both 0.995 and 0.95 a_w optimum growth was at pH 6. The significance of these findings with regard to the preservation of moist hay is discussed.     

The Effect of Water Activity on the Growth and Respiration of Pseudomonas fluorescens

The growth rate of Pseudomonas fluorescens was greater and continued at lower water activity ( a _w) values when glycerol controlled the a _w of glucose minimal medium than when the a _w was controlled by NaCl and sucrose. Growth was not observed below 0·945, 0·970 and 0·964 a _w when glycerol, sucrose and NaCl respectively controlled the a _w. The catabolism of glucose, Na lactate and DL-arginine as measured by respirometry was completely inhibited at a _w values greater than the minimum for growth when the a _w was controlled with NaCl. When the a _w was controlled with glycerol, catabolism of the three substrates continued at a _w values significantly below the a _w for growth on glucose. Catabolism of glucose in the presence of sucrose occurred at a level below the minimum growth a _w but catabolism of the other two substrates ceased at a _w values greater than the minimum growth a _w. Arrhenius plots between 10° and 34°C of the growth rate in glucose minimal medium at 0·98 a _w showed that the order of inhibition was sucrose > NaCl > glycerol. The order of inhibition differed when Arrhenius plots of catabolism of glucose was examined between 10° and 34 °C, namely NaCl > sucrose > glycerol. The mechanism of action of solutes controlling a _w is discussed.     

Physiological response of Pseudomonas putida S12 subjected to reduced water activity

Abstract The effect of osmotic stress, given as decreased water activity (a_w), on growth and the accumulation of potassium and the compatible solute betaine by Pseudomonas putida S12 was investigated. Reduced a_w was imposed by addition of sodium chloride, sucrose, glycerol or polyethylene glycol to the growth medium. Accumulation of potassium and betaine was established when sodium chloride and sucrose were used to cause osmotic stress. No accumulation of these solutes was found in the presence of glycerol. Addition of polyethylene glycol to the medium strongly decreased the growth rate in comparison with the other osmolytes tested at the corresponding a_w. Although polyethylene glycol did decrease the a_w, neither potassium nor betaine was accumulated by the cells.     

The Effect of Water Activity and aw-Controlling Solute on Sporulation of Bacillus cereus

The influence of water activity (aw) on the formation of phase bright, heat stable, and dipicoiir.ic acid-containing spores of Bacillus cereus T from stage III to stage IV forespores has beer. investigated. Decreasing a_w levels reduced the rate of sporulation and the number of forespores which lysed was determined by the a_w-controlling solute used. The limiting a_w value for ir.e formation of mature spores was about 0·95 for glucose, sorbitol and NaCl whereas it was about 0·91 for glycerol. The development of refractility. the synthesis of dipicolinic acid, and acquisition of heat stability were affected equally by decrease in a_w during sporulation. With the range of a_w value where spores could be formed NaCl and glycerol had no signifcant: influence on the D value of the resulting spores whereas at all a_w levels, when sorbitol was use: as the a_w-controlling solute, the heat resistance was greater than in the basal medium. It Is suggested that the a_w of the sporulation medium determines the quantity of spores rather than. the spore properties.     

The Effect of Sugars and Polyols on the Heat Resistance of Salmonellae

S ummary . The heat resistance at 65° of 3 strains of salmonellae in solutions of sugars or polyols was enhanced as the concentration of the solutes increased. There was no linear relationship between heat resistance and water activity ( a_w ), but for all solutes except glycerol there was a linear relationship between log D ₆₅ and concentration (% w/w) of solute. Comparison of D ₆₅ at a particular a_w or percentage (w/w) solute concentration showed that the value decreased in the order: sucrose > glucose > sorbitol > fructose > glycerol. In glycerol, D ₆₅ values were always very much lower than in any other solute. With sucrose–glycerol or sucrose–glucose mixtures, heat resistance depended both on the total concentration (% w/w) of solutes present and also on the a_w of the solution.     

The enumeration of sublethally injured populations of Staphylococcus aureus in foods

Substantiating earlier investigations, pure cultures of Staphylococcus aureus were found to be equally well recovered on Baird-Parker agar at 37°C as at 42°C, whereas Micrococcus spp. are suppressed at the latter temperature to an extent exceeding 5 log₁₀ cycles. It was also established that egg yolk dissimilation by Staph. aureus is intensified at 42°C. Heat treated (60°C) populations of Staph aureus were quantitatively recovered on Baird-Parker agar at 42°C, though acid-injured populations were not. Acid-injury (2% lactic acid at 37°C) could be completely restored by solid medium repaiar during at least 6 h at 23°C on tryptone soya peptone yeast extract egg yolk pyruvate agar. Pure culture studies were confirmed in surveys on trade samples of foods.     

Variation in the behaviour of enterotoxigenic Staphylococcus aureus after heat stress in milk

The survival of several strains of Staphylococcus aureus after heat stress in different menstrua was not logarithmic and F-values were determined to express their resistance to heat. Of the strains tested, Staph, aureus 234 (enterotoxin B) was the most heat resistant and Staph. aureus 790 (enterotoxin E) was the most heat sensitive. Buffalo milk gave the best protection to all the strains of Staph. aureus against heat, followed by cow's milk; phosphate-buffered saline gave the least protection. Soyabean casein digest agar gave maximum recovery of survivors followed by brain heart infusion and Baird-Parker medium. At 50°C there was no marked variation in coagulase production by the surviving strains but at 55 and 62–5dE C there was complete loss of coagulase activity. There was a decreased deoxyribonuclease (DNase) production by all the strains of Staph. aureus after heat stress. Heat-treatment at 55 and 62mD5dE C resulted in loss of enterotoxin production by all the survivors except S₆ and 234, the surviving cells of which still prodused enterotoxin B after heat treatment at 55dE C. Most of the survivors regained lost characteristics such as coagulase, DNase and enterotoxin production after four to five passages through BHI which suggests that subculture of Staph. aureus recovered from heat-processed milk is necessary to avoid false results.     

Water Relations of Glucose-catabolizing Enzymes in Pseudomonas fluorescens

Examination of the catabolism of glucose via the Entner-Doudoroff pathway by standard enzyme assays showed that the activity of glucose-6-phosphate dehydrogenase, glucokinase and 2-ketoglu-conokinase plus phosphoketogluconate reductase was completely inhibited at a _w values less than 0.965, 0.98 and 0.96 respectively when NaCl was used to adjust the a _w. The other glucose-catabolizing enzymes were inhibited to a lesser degree. When sucrose was used to control a _w, glucokinase and glucose-6-phosphate dehydrogenase were inhibited at 0.92 a _w but the other enzymes remained active below 0.86 a _w. Enzymes were relatively active at reduced a _w when adjusted with glycerol and most remained active even at 0.80 a _w. When a _w was controlled by potassium glutamate, the activity of glucokinase and glucose-6-phosphate dehydrogenase was markedly less inhibited than by NaCl at similar a _w. Possible reasons for the variation in activity by glucose-catabolizing enzymes in response to a _w controlled by various solutes could be location of the enzyme in the cell, ability of the solute to penetrate the cell and ability to withstand high salt and sucrose concentrations. When the a _w of the growth medium was reduced to 0.98 by glycerol, NaCl and polyethylene glycol 400, levels of glucokinase were significantly reduced while higher levels of glucose dehydrogenase and gluconate dehydrogenase were induced. This suggests that reduction in a _w could regulate the routes of catabolism in the Entner-Doudoroff pathway. When sucrose was used to control a _w of the growth medium high levels of most enzymes were induced, suggesting catabolism of the sucrose by the organism.     

The Effect of Water Activity and the aw Controlling Solute on Spore Germination of Bacillus stearothermophilus

The germination of spores of Bacillus stearothermophilus was studied in nutrient broth in relation to the water activity ( a _w) of the medium, the nature of the a _w controlling solutes glycerol, sucrose, KCl, and NaCl, and temperature. Quantitation of germination was based on the change of the phase-bright spore to phase-dark. Activation of spores was by exposure to 100°C/10 min in a medium of the same composition as that used for germination.
Of the four solutes used, sucrose proved most inhibitory to germination, especially in the upper part of the temperature range 38-75°C, glycerol was the most favourable whereas KCl and NaCl, whose effect was almost identical, occupied an intermediate place. The glycerol effect became more pronounced as the a _w of the medium decreased towards 0.960, becoming inhibitory thereafter.
The solute effect on spore germination followed a pattern that related to the class of solute, i.e. electrolyte or non-electrolyte, and its cell penetration characteristics.
Solute penetration during heat activation and germination was considered as the major germination factor and was associated with the osmoregulation mechanism within the spore proposed recently as the basis of spore dormancy and resistance.     

Accumulation of carbohydrate by Escherichia coli B/r/1 during growth at low water activity

The carbohydrate content of Escherichia coli B/r/1, grown in a glucose or arabinose-limited salts medium in a chemostat, increased by a factor of 2–4 when the water activity (a_w) of the medium was reduced to 0.986 by addition of NaCl, KCl or sucrose. The biomass decreased by 30–45%. The sucrose system resulted in the lowest biomass and carbohydrate content. The monosaccharide part of the accumulated carbohydrate consisted of glucose or glucose and arabinose in the cultures fed glucose and arabinose, respectively, and accounted for 50% or more of the total carbohydrate in the NaCl and KCl systems and 16.79% in the sucrose system. In addition, the K⁺ content depended on the solute and related inversely to the monosaccharide content, being highest in the sucrose system. The combined molarity of the monosaccharide and K⁺ was deduced to be far in excess of that required for osmotic equilibration of the cultures, especially in the sucrose system. These observations are discussed in the context of osmoregulation, the effects of solutes on glucose metabolism and the morphological changes that occur in cultures at low a_w.     

Resistance of food spoilage yeasts to sorbic acid

Beauveria bassiana, Metarhizium anisopliae and Paecilomyces farinosus were grown on Sabouraud Dextrose Agar (SDA) modified with KCl to give a range of water activity (a_w) from 0.938 to 0.998. Growth of all three species was optimal at 0.983 a_w and growth occurred over the a_w range tested. Acyclic sugar alcohol (polyol) and trehalose content of conidia was determined by HPLC and found to vary with species and a_w. Conidia of B. bassiana and P. farinosus were found to contain totals of 1.5% and 2.3% polyols respectively at 0.998 a_w, and double these amounts at <0.950 a_w. Conidia of M. anisopliae contained from 5.7% to 6.8% polyols at each a_w tested. In conidia of all three species the predominant polyol was mannitol. The lower molecular weight polyols, arabitol and erythritol, were found to accumulate at reduced a_w. Small amounts of glycerol were present in conidia of each species; <15% total polyols. Conidia of B. bassiana and M. anisopliae contained about 0.5% trehalose from 0.970 to 0.998 a_w, but only trace amounts below 0.950 a_w. Conidia of P. farinosus contained 2.1% trehalose at 0.998 a_w and this decreased to <0.1% below 0.950 a_w. Potential to manipulate the endogenous reserves of conidia of these biological control agents to enhance viability and desiccation toierance is discussed     

Behaviour of Staphylococcus aureus strains, producers of enterotoxins C1 or C2, during the manufacture and storage of Burgos cheese

Burgos cheese was manufactured from pasteurized ewes milk inoculated with Staphylococcus aureus strains FRI 137 and FRI 361, at levels of ca 10³ and 10⁵ cfu/ml and stored at 4°, 10° and 15°C and at room temperature (10°-15°C). Populations of Staph. aureus and mesophilic aerobes, pH, and production of thermonuclease and enterotoxins C₁ and C₂ were investigated. Aerobic counts increased during cheese-making and storage. With both test strains, important growth was observed only during the storage period, the larger levels corresponding to the higher temperatures. Although Staph. aureus strains attained populations of over 10⁸ cfu/g, no enterotoxin was detected. Strain FRI 361 reached 10⁷ cfu/g without production of a detectable amount of thermonuclease. With strain FRI 137, the minimal population associated with enzyme activity was influenced by the inoculum size. Staphylococcus aureus counts are better indicators of staphylococcal growth in Burgos cheese than the thermonuclease test.     

Interactive effects of solutes, potassium sorbate and incubation temperature on growth, heat resistance and tolerance to freezing of Zygosaccharomyces rouxii

The interactive effects of solutes, potassium sorbate and incubation temperature on growth, heat resistance and tolerance to freezing of Zygosaccharomyces rouxii were investigated. Growth rates in media supplemented with glucose, sucrose or NaCl to a _w 0.93 were more rapid than in unsupplemented media ( a _w 0.99). Although growth in unsupplemented medium was lower at 35°C, incubation at 21°C or 35°C had little effect on growth in media supplemented with glucose and sucrose. The addition of 300 μg potassium sorbate/ml to media resulted in reduced growth rates, particularly at 35°C. Heat resistance of Z. rouxii was substantially greater in cultures previously incubated at 35°C than in cultures incubated at 21° in media both with and without 300 μg potassium sorbate/ml. Zygosaccharomyces rouxii was tolerant to freezing at - 18°C for up to 120 d in all test media supplemented with glucose, sucrose or NaCl. The addition of 300 μg potassium sorbate/ml to sucrose-supplemented media resulted in increased resistance to freezing in cultures previously incubated at 21°C. Sensitivity to freezing increased when cultures were incubated at 21°C in media not supplemented with solutes. Glucose and sucrose provided the best protection against inactivation by heating and freezing, regardless of the presence of potassium sorbate in growth media.     

Chrysosporium species, potential spoilage organisms of chocolate

Standard methods of analysing foods for the presence of moulds are inadequate for thedetection of genera such as Chrysosporium which do not grow at the high wateractivities of most mycological media. The use of malt, yeast, 50% glucose agar (MY50G) insealed containers as an enrichment medium allowed time for germination and growth ofheat-stressed spores. Three Chrysosporium spp., C. xerophilum Pitt, C. inops (Carmichael) and C. farinicola (Burnside) Skou, were isolated fromcommercial chocolate bars with a water activity (a _w ) of approximately0·28. Chrysosporium inops was isolated from commercial milk crumb and anew Chrysosporium sp. was isolated from Ghanaian cocoa beans. In chocolates madeby coating MY50G agar (a_w = 0·89) with chocolate (a_w = 0·27) containing C. inops arthroconidia, two types of deterioration were seenafter storage. The first was fat bloom due to recrystallization of the cocoa butter on the outer andinner chocolate surface. The second was growth of C. inops which occurred on theinside chocolate surface adjacent to the MY50G agar filling and on the outside surface afterholding at 92% equilibrium relative humidity (erh) for 12 d. There was some evidence that C. inops could grow on the outside of chocolates held at 5·7% erh after 4months' storage at 25 °C. The appearance of the white fungal growth was not unlikefat bloom to the naked eye but was clearly different with the electron microscope.     

The survival of Staphylococcus aureus during the fermentation and storage of yoghurt

The effect of yoghurt culture R _x on the survival of Staphylococcus aureus CCM 5984 added to milk in various concentrations was observed during the fermentation and storage of yoghurt. The end of the fermentation process (3.5 h) was only accompanied by a slight reduction. During the storage of yoghurt at 4°C a 1-2 log reduction was observed. No Staph. aureus was detected in yoghurt produced from milk contaminated by 10³ Staph. aureus cells 1^-1 after 48 h of cold storage. When a concentration of 10² Staph. aureus cells was used for milk contamination, the pathogen was not recovered from yoghurt during the fermentation and storage. The fermentation and storage of yoghurt was accompanied by increases in lactic acid and titrimetric acidity, as well as by a decrease in pH value.     

Inactivation of Strains of Salmonella senftenberg by Gamma Irradiation

S ummary : Strains of Salmonella senftenberg isolated from Norwegian herring meal and strain 775W were exposed to gamma radiation from a ⁶⁰Co source. When they were irradiated in phosphate buffered saline solution, the average D₁₀ values for all the strains was 19·3 krad. On irradiating strains 56 and 775W in herring meal the D₁₀ values were 192·1 and 188·5 krad, respectively, thus indicating that the suspending medium had a great effect on the radiation resistance of the organisms. Radiation doses of the order of 0·8–1·3 Mrad are recommended for the decontamination of herring meal.     

Heat Resistance of Salmonella: the Uniqueness of Salmonella senftenberg 775W

Of approximately 300 cultures of Salmonella, representing 75 different serotypes, none was found to be as heat-resistant as S. senftenberg 775W. However, S. blockley 2004 was 5 times more heat-resistant and S. senftenberg 775W was 30 times more heat-resistant than S. typhimurium Tm-1, the reference strain in this study. All other strains of Salmonella tested, including 19 strains of S. senftenberg and 7 strains of S. blockley, had decimal reduction times at 57 C of about 1 min, equivalent to that of the reference organism, Tm-1. As observed in other bacterial species, strain 775W is more heat-sensitive in the log phase than in the stationary phase of growth. Cells from cultures grown at 44 C were more heat-resistant than those grown at either 35 or 15 C; the medium of growth, whether minimal or complex, made no appreciable difference in heat resistance. Cells from cultures limited by a carbon source were killed at a much slower rate than those limited by a nitrogen source and exhibited a 1-hr lag at 55 C before a significant rate of kill was attained. For any given set of growth conditions, strain 775W was always more heat-resistant than another strain of S. senftenberg, 197B, which has normal heat resistance.