红树林微生物DH-2胞外蛋白酶的性质及产酶条件优化

从大亚湾红树林土壤样品中分离得到产蛋白酶菌株,鉴定所产胞外蛋白酶的酶学性质以及菌株的最佳发酵培养条件。采用平板透明圈法筛选菌株,福林酚显色法测定蛋白酶的酶活,通过单因素和正交试验确定其最佳发酵培养基以及发酵条件。从壤样品中分离得到一株产蛋白酶的枯草芽孢杆菌DH-2,该菌株分泌的蛋白酶最适反应pH和温度分别为8.0和65℃,50℃保温处理60 min后,剩余酶活仍保留80%以上。该蛋白酶对多种金属离子、有机溶剂及表面活性剂均有较好的耐受性。确定该菌株产蛋白酶的最适条件:1%(m/V,下同)可溶性淀粉,1%胰蛋白胨、1%NaCl,初始pH 5.5及7%的接种量,40℃培养36 h。在最适条件下测得其发酵液的酶活为236.30 U/mL,约为初筛时的酶活的8倍。该蛋白酶具有较为广阔的作用温度和pH范围,金属离子、有机溶剂及表面活性剂耐受性好,酶的性质比较稳定。     

一株地衣芽孢杆菌碱性蛋白酶的研究Ⅱ.

曾分离到一株产碱性蛋白酶的地衣芽孢杆菌011 ,命名为地衣芽孢杆菌砀山亚种。酶的最适作用条件 :pH9 0 ,6 0℃。对该菌株进行连续 4次不同的物理、化学方法的诱变处理。诱变剂为紫外线、亚硝酸、和低能N⁺离子 ,其处理方式包括单独或复合处理两种。最后获得一株高产碱性蛋白酶的变异株 (C₃₀₃)菌株产酶活力从 725u/mL提高到 12425u/mL。该突变株的最适产酶条件为起始pH8.0～9.0 ,培养温度 32℃～37℃ ,振荡培养时间 44～ 48h。     

枯草芽胞杆菌甲壳素脱乙酰酶的筛选及酶学性质*

从海洋泥土中分离出产甲壳素脱乙酰酶菌株,确定该菌株为产碱属芽孢杆菌,其产酶适宜培养条件为：pH4．0,添加金属离子Ca^2 ,培养时间为80h,温度为350℃。所得甲壳素脱乙酰酶作用的最适温度为40℃～50℃,最适pH为4．5-5．0之间。     

一株产高温蛋白酶嗜热菌A-2的筛选鉴定及酶学特性分析

本研究为从云南腾冲热泉中分离纯化得到一株产高温蛋白酶的菌株并对其进行驯化培养,用以探究该菌株的生长条件及酶学特性,通过选择培养基筛选能够分解脱脂奶粉产蛋白酶的菌株,应用常规方法液体培养菌体,探究温度、pH、碳源、氮源对菌株生长情况的影响,并采用福林酚法测蛋白酶活性。并提取蛋白酶液对酶的最适pH、温度以及热稳定性、pH稳定性进行研究。结果发现通过含脱脂奶粉的固体培养基筛选得到一株产蛋白酶菌株A-2,经过生理生化试验和16S rDNA鉴定知该菌种属于Aneurinibacillus属。酵母粉、葡萄糖、55℃、pH值7.5分别为菌株生长的最适氮源、碳源、温度和pH。此外该菌株所产的蛋白酶最适温度为60℃,在pH值7~9具有较好的酶活性。因此,该菌株为嗜热芽孢杆菌,所产的碱性蛋白酶具有较高的耐受温度和pH稳定性,为进一步开发利用提供参考的价值。     

高温蛋白酶产生菌的筛选及其产酶条件和酶学性质分析

从徂徕山温泉附近土样中分离到9株产高温蛋白酶菌株,选取一株碱性蛋白酶高产菌株L7为出发菌株,进行显微形态、16S rRNA基因序列分析,将其初步鉴定为短芽孢杆菌(Brevibacillus sp.)。研究该菌株发酵条件,确定产酶的最佳培养基组成为葡萄糖40 g/L,蛋白胨20 g/L,磷酸氢二钠1.4 g/L,氯化钙0.6 g/L,硫酸镁0.4 g/L,通过培养基优化,酶活达到103.08 U/mL。最佳培养条件为250 mL三角烧瓶中装液量50 mL、pH8.0、培养温度为55℃、培养时间为24 h。对该菌株酶学性质研究,L7菌株所产高温蛋白酶的最适温度为55℃,最适pH为10,并且具有良好的温度稳定性和pH稳定性,酶活性受PMSF强烈抑制。     

丁鳜肠道中枯草芽孢杆菌蛋白酶的生理生化性质的研究

目的:为改良丁鳜饲料成分,研究了从丁鳜肠道中分离的枯草芽孢杆菌(Bacillus subtilis)蛋白酶的生理生化性质.方法及结果:枯草芽孢杆菌经发酵培养,破碎细胞,通过45%～85%饱和度的硫酸铵沉淀分离得到了一种碱性蛋白酶,SDS～PAGE显示该蛋白酶分子量为59kD;最适温度为40℃;温度的稳定性范围在50℃以下;最适pH9.8.低浓度的EDTA对该酶无明显抑制作用;Ca2+和Co2+完全抑制该酶的活性,Pb2+对酶活力有一定抑制作用.结论:新分离出的这种蛋白酶有助于进一步开发含有添加蛋白酶制剂的鱼饲料.     

土壤中高产蛋白酶菌株产酶条件及酶学性质

【背景】微生物蛋白酶已经成为工业用蛋白酶的主要来源,筛选具有特殊环境适应性的微生物成为生物酶资源的开发热点。【目的】通过对青藏高原土壤微生物产蛋白酶菌株的筛选、优化及相关特性研究,寻找新的蛋白酶资源,为高原菌种资源利用提供科学依据。【方法】采用形态学和分子生物学对筛选菌株进行菌种鉴定,利用单因素试验和正交试验对菌株进行发酵条件优化及酶学性质的探究。【结果】筛选出一株高产蛋白酶菌株XC2,经鉴定菌株XC2为枯草芽孢杆菌(Bacillus subtilis)。XC2最优产酶条件:可溶性淀粉4.0%,牛肉膏1.0%,K~+0.6%,培养温度34°C、初始pH 7.0、接种量2.0%的条件下200 r/min振荡培养13 h,所产蛋白酶活力最高为638.5 U/mL。XC2所产蛋白酶最适反应温度60°C,最适pH9.0;40-50°C、pH8.0-10.0条件下酶活稳定性较高;Mn~(2+)对酶活力有明显激活作用,而Zn~(2+)、Cu~(2+)、Fe~(2+)、Fe3+对酶活力有明显抑制作用。【结论】枯草芽孢杆菌XC2有较强的产碱性蛋白酶的能力,具有较好的应用前景。     

枯草芽孢杆菌β-甘露聚糖酶补料发酵及其特性研究

采用正交实验设计对枯草芽孢杆菌产 β-甘露聚糖酶的培养基组成和培养条件进行优化 ,在此基础上进行摇瓶补料发酵 ,酶活达223.47U/mL ,较未补料的酶活提高了 32 90 %。酶反应的最适pH为 6 5 ,最适温度为 70℃ ;该酶在pH 5.0～10.0和 70℃以下稳定。水解魔芋胶产物主要为二糖以上低聚糖。     

碱性过氧化氢酶高产菌的筛选、鉴定及发酵条件优化

从纺织厂的车间污水分离获得菌株WSHDZ-01,其产过氧化氢酶酶活为600U/mL,酶活的pH范围为5.0~12.0。根据对该过氧化氢酶生产菌的形态和生理生化特征的分析和16SrDNA序列分析,鉴定该菌为枯草芽孢杆菌。通过对该菌株发酵培养基中碳氮源的优化,其最佳碳源为10g/L的葡萄糖,氮源为5g/L的NaNO3,在此条件下产酶达3258U/mL。此外,该菌株所产过氧化氢酶的最适反应pH为11.0,最适温度为55℃,在pH11.0和50℃下保持15min后,剩余酶活仍达98%以上。     

碱性蛋白酶产生菌的筛选及发酵条件考查

从土壤中分离到的167株芽胞杆菌中选出一株高产、稳产碱性蛋白酶菌株A4－3（嗜碱性枯草芽胞杆菌）。该菌株最适产酶条件为（g／100ml）：蔗糖6．0;豆饼水解液10.0;Na2CO31．0;起始pH9．5。在该条件下,经37℃振荡培养48h,酶活力达2612u／ml。     

嗜热菌Anoxybacillus sp．DL3产蛋白酶条件及其酶学性质研究

目的：对Anoxybacillussp．DL3的产蛋白酶条件及其酶学性质进行研究,为下一步进行蛋白酶基因的克隆、表达提供依据。方法：应用常规方法液体培养细菌,研究温度、pH、培养基中碳源、氮源对菌株产蛋白酶的影响,硫酸铵盐析的方法提取酶液,并采用Folin法测酶活性。用紫外分光光度计在OD680hi／1测吸光值。并对提取的蛋白酶液进行酶的最适温度、pH以及酶的热稳定性和pH稳定性研究,向酶液中添加金属离子和EDTA、PMSF,研究其对酶活性的影响。结果：在培养基初始pH是6．5,培养温度为40℃时菌株产酶酶活性最大;培养基中以乳糖为碳源,酵母膏和硫酸铵为氮源,碳源与氮源的比例为1：2时,酶活最大。酶学性质研究结果显示：该酶的最适反应温度是55℃,最适反应pH是7．0;在50℃保温20min-80min内,酶活力下降幅度较小。60℃保温60min后,仍保持约60％的酶活。70℃保温60min后,残余酶活为30％。该酶在pH为6．0～8．0范围内,相对酶活差别不是很大,下降趋势大致相同。在强碱条件下,相对酶活下降很明显。Fe2＋、Cu2＋和Hg2＋对酶活性有明显的抑制作用;Ca2＋、Mg^2＋、Mn2＋等金属离子对酶活性有明显的促进作用;乙二胺四乙酸（EDTA）和苯甲基磺酰氟（PMSF）对酶活性也有一定抑制作用。结论：Anoxybacillussp．DL3所产的蛋白酶为嗜热中性蛋白酶,此酶具有较好的热稳定性和pH耐受性,该菌株具有进一步开发、利用的价值。     

枯草芽孢杆菌ZC-7中性蛋白酶的分离纯化及酶学性质研究

枯草芽孢杆菌ZC-7的发酵液,经离心分离得到粗酶液,再经硫酸铵盐析、中空纤维膜除盐浓缩、DEAE-Sepharose Fast Flow离子交换层析、Sephadex G-75柱层析等步骤获得电泳纯的中性蛋白酶。SDS-PAGE测得其分子量大约为42KDa。以酪蛋白为底物时,该酶的Km为5×10-3,Vmax为2.5×104ug/min,酶的最适作用pH为7.0,最适反应温度为55℃,在pH6.5～8.0, 40℃以下较稳定,对1mol/L H2O2具有一定的耐受性。EDTA、异丙醇和乙醇对该酶有抑制作用,Ca2+、Mg2+和Li+离子对其具有保护作用。     

地衣芽孢杆菌D-1产碱性蛋白酶培养条件的优化

为了对产碱性蛋白酶的地衣芽孢杆菌D-1的培养条件进行优化,利用10 L发酵罐,采用正交设计19(34)试验,对培养温度、pH值、搅拌转速、通气量4条件进行优化,得到地衣芽孢杆菌D-1发酵产碱性蛋白酶的最优培养条件为:培养温度37.0℃,pH值7.5,通气量4L/min,搅拌转速300r/min.利用最优条件组合进行验证...     

Dissolution and Degradation of Bacillus thuringiensis delta-Endotoxin by Gut Juice Protease of the Silkworm Bombyx mori

The dissolution and degradation of dagger-endotoxin (crystal) of Bacillus thuringiensis subsp. kurstaki strain HD-1 were investigated. Crystals were dissolved in 0.1 M phosphate-carbonate-NaOH buffer at pH > 12. Swelling of crystals occurred in the buffer between pH 10 and 11, and crystals dissolved in the same buffer supplemented with gut juice protease of the silkworm Bombyx mori. The proteolytic dissolution of crystals occurred after a time lag of several minutes in 0.1 M carbonate-NaOH buffer, pH 10.2. The time lag was not observed when crystals were suspended in the buffer for 30 min before the addition of protease. After the dissolution of the crystals and further degradation of the solubilized protein, the appearance of a toxic protein with a molecular weight of 59,000, designated P-59, was observed. Lower-molecular-weight peptides (less than 40,000) showed no toxicity to the silkworm larvae on feeding. Digestion of the 120,000-dalton subunit of the crystal by gut juice protease also produced P-59. These observations suggest the occurrence of a similar process in vivo, i.e., the swelling of crystals due to the alkalinity of gut juice and the production of P-59, dependent on the hydrolysis of swollen crystals by gut juice protease.     

Regulation of Neutral Protease Productivity in Bacillus subtilis: Transformation of High Protease Productivity

A transformable strain of Bacillus subtilis 6160, a derivative of B. subtilis 168, produces three kinds of casein hydrolytic enzymes (alkaline protease, neutral protease, and esterase) in a culture medium. B. natto IAM 1212 produces 15 to 20 times as much total proteolytic activity as does B. subtilis. Extracellular proteases produced by the two strains were separated into each enzyme fraction by diethylaminoethyl-Sephadex A-50 column chromatography. The difference in the total protease activities of extracellular proteases between the two strains was due to the amount of neutral protease. The ratios of neutral protease activity to alkaline protease activity (N/A) were 1.1 in B. subtilis 6160 and 13.0 in B. natto IAM 1212. Enzymological and immunological properties of alkaline protease and neutral protease obtained from the two strains were quite similar or identical, respectively. Specific activities measured by an immunological analysis of the two neutral proteases against casein were also equal. A genetic character of high protease productivity in B. natto IAM 1212 was transferred to B. subtilis 6160 by the deoxyribonucleic acid-mediated transformation. Among 73 transformants that acquired high protease productivity, 69 produced a higher amount of neutral protease and the ratios of N/A were changed to 15 to 60. Three other strains were transformed in the productivity of neutral protease and alpha-amylase simultaneously, and one showed considerable change in the production of alkaline protease and neutral protease. The specific activities (casein hydrolytic activities/enzyme molecules) of neutral proteases from the representative four transformants were equal to those of the two parental strains. These results suggested the presence of a specific gene(s) that participated in the productivity of neutral protease in B. subtilis.     

一株产碱性蛋白酶芽孢杆菌的筛选、鉴定及应用初探

为了筛选碱性蛋白酶产生菌并探讨其对蛋白质饲料的发酵效果,以肉粉厂表层土壤为菌株分离源,利用脱脂牛奶培养基分离和纯化蛋白酶产生菌,通过形态特征、生理生化和16S rRNA基因序列分析确定菌株的分类地位,并采用L9(33)正交设计研究筛选出的优势菌种的接种量(3％、6％和12％)、种子液培养时间(12 h、24h和48 h...     

Skin unhairing proteases of Bacillus subtilis: production andpartial characterization

Proteases able to unhair sheep skins were produced from Bacillus subtilis. Protease activity was increased from 640 to 990 U/mL by using a fed-batch culture with glucose added sequentially up to 10 g/L. The crude enzyme prep-aration was mainly a mixture of metallo- and serine-proteases with optimal pH and temperature for protease activity at 7 and 50-55°C, respectively. At pH 8 and 30°C, protease activity of the crude enzyme was 33% of the maximal value and 97% of the original activity (900 U/mL) was retained after incubation for 4 hours.     

Nucleotide and deduced amino acid sequences of a high-molecular-mass subtilisin from an alkaliphilic Bacillus isolate

A high-molecular-mass subtilisin was found in culture broth of the alkaliphilic Bacillus sp. strain KSM-KP43. The gene encoding the enzyme (FT protease) was determined using a mixed primer designed from the N-terminal amino acid (aa) sequence of the purified enzyme. The determined nucleotide sequence of the gene consisted of a 2427-bp open reading frame (ORF) that encoded a putative prepro-peptide (152 aa) and a mature enzyme (656 aa; 68,506 Da). The deduced aa of the mature enzyme revealed a moderate homology to a subtilisin-type proteinase from Bacillus halodurans and a minor extracellular protease, Vpr, from Bacillus subtilis with 64% and 57% identity, respectively. The molecular mass of the purified recombinant FT protease was approximately 72 kDa as judged by both SDS-polyacrylamide gel electrophoresis (PAGE) and gel filtration. FT protease showed maximal activity toward glutaryl-Ala-Ala-Pro-Leu-p-nitroanilide at pH 10.5 and at 45 degrees C. The enzyme was rapidly inactivated by incubation over 45 degrees C for 15 min at both pH 7 and 10. Calcium ions were slightly protective for thermoinactivation of the enzyme.