Feasibility study of a cyclic anoxic/aerobic two-stage MBR for treating ABS resin manufacturing wastewater

This study investigated the feasibility and the treatment efficiency of a cyclic anoxic/aerobic two-stage MBR for treating polymeric industrial wastewater. The anoxic/aerobic hybrid MBR was operated without sludge withdrawal except sampling during the study. The results showed that the highest COD organic loading rate of 8.7 kg COD/m³ day from bioreactor was obtained at phase 3. The system achieved 97% BOD₅ and 89% COD removal. It also revealed that 93% of COD removal was contributed by bioreactor at phase 3 and the similar results happened to phases 1 and 2. The highest TN and TKN removals for each phase were 60, 74, 80% and 61, 74, 81%, respectively and limited by nitritation step. SEM images of nascent and fouled membranes were offered to evaluate the cleaning method. The system was operated for 174 days, resulting in high degradation rate, flexibility towards influent fluctuations and limited sludge production.     

16S rDNA-RFLP分析六氯苯好氧降解菌群的结构及其多样性

从某化工厂排水沟底泥中取样,经2个月的富集驯化得到六氯苯好氧降解菌群。通过测定该微生物菌群在降解六氯苯过程中累积耗氧量、微生物生长曲线及Cl-浓度的变化,证明在好氧条件下该微生物菌群能够以六氯苯为唯一碳源和能源生长。当培养温度为30℃,pH为7.0时,该菌群能在18d内将无机盐培养基中浓度为4.5mg/L的六氯苯降解55%以上,降解速率达到137.5μg/(L.d)。对降解菌群提取总DNA,选择性扩增细菌16S rDNA片段,建立克隆文库。通过限制性内切酶(限制性内切酶HaeⅢ和RsaⅠ)分析,得到9种不同的谱型,其中3种谱型是主要谱型。对主要谱型的克隆子测序,结果表明,它们分别与Alcaligenes和Azospirillum菌属相似性最高。该菌群在去除环境中难降解的有机氯污染物方面具有应用前景。     

Performance and spatial community succession of an anaerobic baffled reactor treating acetone-butanol-ethanol fermentation wastewater

An anaerobic baffled reactor with four compartments (C1-C4) was successfully used for treatment of acetone-butanol-ethanol fermentation wastewater and methane production. The chemical oxygen demand (COD) removal efficiency was 88.2% with a CH₄ yield of 0.25 L/(g COD_removed) when organic loading rate (OLR) was 5.4 kg COD m⁻³ d⁻¹. C1 played the most important role in solvents (acetone, butanol and ethanol) and COD removal. Community structure of C2 was similar to that in C1 at stage 3 with higher OLR, but was similar to those in C3 and C4 at stages 1-2 with lower OLR. This community variation in C2 was consistent with its increased role in COD and solvent removal at stage 3. During community succession from C1 to C4 at stage 3, abundance of Firmicutes (especially OTUs ABRB07 and ABRB10) and Methanoculleus decreased, while Bacteroidetes and Methanocorpusculum became dominant. Thus, ABRB07 coupled with Methanoculleus and/or acetogen (ABRB10) may be key species for solvents degradation.     

Microbial community analysis of a biogas-producing completely stirred tank reactor fed continuously with fodder beet silage as mono-substrate

The bioconversion of renewable raw material to biogas by anaerobic microbial fermentation processes in completely stirred tank reactors (CSTR) is a valuable alternative resource of energy especially for rural areas. However, knowledge about the microorganisms involved in the degradation of plant biomass is still poor. In this study, a first analysis of the biogas-forming process within a CSTR fed continuously with fodder beet silage as mono-substrate is presented in the context of molecular data on the microbial community composition. As indicated by the conventional process parameters like pH value, content of volatile fatty acids, N:P ratio and the biogas yield, the biogas-forming process within the CSTR occurred with a stable and efficient performance. The average biogas yield based on volatile solids was 0.87m(3)kg(-1) at an organic loading rate of 1.2-2.3kgm(-3)d(-1). This amounts to 94% of the theoretical maximum. In order to identify microorganisms within the CSTR, a 16S rDNA clone library was constructed by PCR amplification applying a prokaryote-specific primer set. One hundred and forty seven clones were obtained and subsequently characterized by amplified rDNA restriction analysis (ARDRA). The sequences of 60 unique ARDRA patterns were estimated in a length of approximately 800-900bp each. Four of them were assigned to the domain Archaea and 56 to the domain Bacteria. Within the domain Archaea, all clones showed a close relationship to methanogenic species. Major bacterial groups represented in the clone library were the class Clostridia of the phylum Firmicutes (22% of all 16S rDNA clones), the class Deltaproteobacteria of the phylum Proteobacteria (24%), the class Bacilli of the phylum Firmicutes (22%) and members of the phylum Bacteroidetes (21%). Within these major groups, the highest biodiversity was found within the class Clostridia (35% of all operational taxonomic units). Members of the phyla Actinobacteria and Spirochaetes were represented only by 5 and 2 clonal sequences, respectively.     

焦化废水工业处理装置和实验室装置硝化菌群的分子比较

反应器的群落结构分析有助于对工业装置的故障原因进行诊断。为了解决某焦化废水处理装置硝化功能低下的故障,构建了一套相似的实验室装置作为参照系统,该装置的硝化功能良好。通过工业装置和实验室装置好氧池生物膜16SrDNA克隆文库的比较,分析了它们之间硝化菌群的组成差异。实验室装置克隆文库的构成说明Nitrosomonas europaea-Nitrosoccus mobilis类群和Nitrospira属Ⅰ亚区系分别是该工艺条件下优势的氨氧化菌和亚硝酸氧化菌,但工业装置的克隆文库中却没有找到任何与硝化菌序列相近的克隆,这说明工业装置中硝化菌的多度较低。进一步使用Taqman荧光探针实时定量PCR测定了样品中Nitrospira属的多度,实验室装置中Nitrospira属16S rDNA的拷贝数达到3.4×106个/微克基因组DNA,而工业装置的测定值不到实验室装置的1/300。这些试验结果都表明工业装置好氧池微生物群落中缺少适当的硝化菌群是造成其硝化能力低下的重要原因。提高菌群中Nitrosomonas属和Nitrospira属的多度是解决工业装置硝化能力低下的关键。     

Microbial diversity and community structure in Fynbos soil

The Fynbos biome in South Africa is renowned for its high plant diversity and the conservation of this area is particularly important for the region. This is especially true in the case of endangered vegetation types on the lowlands such as Sand Fynbos, of which only small fragments remain. The question is thus whether the diversity of the above‐ground flora is mirrored in the below‐ground microbial communities. In order to determine the relationship of the above‐ and below‐ground communities, the soil community composition of both fungal and bacterial groups in Sand Fynbos was characterized over space and time. A molecular approach was used based on the isolation of total soil genomic DNA and automated ribosomal intergenic spacer analysis of bacterial and fungal communities. Soil from four different sites was compared to resolve the microbial diversity of eubacterial and fungal groups on a local (alpha diversity) scale as well as a landscape scale (beta diversity). The community structures from different sites were compared and found to exhibit strong spatial patterns which remained stable over time. The plant community data were compared with the fungal and the bacterial communities. We concluded that the microbial communities in the Sand Fynbos are highly diverse and closely linked to the above‐ground floral communities.     

新疆泥火山细菌群落PCR-SSCP 分析

采用单链构象多态性(SSCP)技术, 以16S rDNA 基因的V3 区为靶对象, 分析泥火山细菌多样性及其群落结构。通过对泥火山不同月份的不同深度土样DNA 提取后, 针对16S rDNA 进行PCR 扩增出236 bp 大小片段, 通过SSCP 电泳对泥火山细菌进行季节性多样性分析, 并对主要条带进行克隆分析。结果显示: 新疆泥火山细菌不同季节多态性明显, 而且这种多态性容易受生态和气候的影响; 假单胞菌属是泥火山土壤优势菌群, 在泥火山区土壤中广泛分布, 受生态和气候环境影响较小。     

珠江口沉积物好氧反硝化细菌的筛选及鉴定

研究首次于珠江口沉积物中分离出多株好氧反硝化细菌,从中筛选出一株反硝化性能最强的菌株A14-1。综合其生理生化及分子生物学鉴定的结果确定此菌株为红球菌属Rhodococcus aetherivorar。此菌株可在48 h内将培养基中的硝酸盐含量从157.91mg·L^-1降低至32.07mg·L^-1,反硝化效率高达26.20 mg·L^-1·h^-1,且不会产生亚硝酸盐的明显积累。以细菌总基因组DNA为模板成功扩增出亚硝酸还原酶基因nirS,说明亚硝酸还原酶可能参与了此菌株的好氧反硝化过程,将亚硝酸盐进一步还原,从而不会造成水体亚硝酸盐的积累。菌株A14-1在珠江口多个站点均有分布,环境适应能力强,且不会对环境造成危害,因此有望应用于污水的生物脱氮处理中。     

Integration of aerobic granular sludge and membrane bioreactors for wastewater treatment

Environmental deterioration together with the need for water reuse and the increasingly restrictive legislation of water quality standards have led to a demand for compact, efficient and less energy consuming technologies for wastewater treatment. Aerobic granular sludge and membrane bioreactors (MBRs) are two technologies with several advantages, such as small footprint, high-microbial density and activity, ability to operate at high organic- and nitrogen-loading rates, and tolerance to toxicity. However, they also have some disadvantages. The aerobic granular sludge process generally requires post-treatment in order to fulfill effluent standards and MBRs suffer from fouling of the membranes. Integrating the two technologies could be a way of combining the advantages and addressing the main problems associated with both processes. The use of membranes to separate the aerobic granules from the treated water would ensure high-quality effluents suitable for reuse. Moreover, the use of granular sludge in MBRs has been shown to reduce fouling. Several recent studies have shown that the aerobic granular membrane bioreactor (AGMBR) is a promising hybrid process with many attractive features. However, major challenges that have to be addressed include how to achieve granulation and maintain granular stability during continuous operation of reactors. This paper aims to review the current state of research on AGMBR technology while drawing attention to relevant findings and highlight current limitations.     

焦化废水O/H/O生物处理工艺二级好氧生物反应器的微生物结构和功能

【背景】焦化废水O/H/O生物处理工艺的二级好氧生物反应器O₂具有剩余污染物矿化和完全硝化功能,对废水的达标排放有重要作用。【目的】阐明O₂生物反应器的微生物结构和功能。【方法】利用16S rRNA基因测序,研究O₂生物反应器的微生物多样性和组成并进行功能预测,揭示其共现性特征和环境影响因子。【结果】O₂的优势菌门以变形菌门(Proteobacteria)、拟杆菌门(Bacteroidetes)、绿菌门(Chlorobi)为主。主要菌属中红游动菌属(Rhodoplanes)、溶杆菌属(Lysobacter)、硫杆菌属(Thiobacillus)等参与化学需氧量(chemical oxygen demand,COD)、酚类(phenols)和硫氰酸盐(thiocyanate,SCN^-)等剩余污染物的去除,亚硝化弧菌属(Nitrosovibrio)和硝化螺菌属(Nitrospira)分别作为氨氧化细菌(ammonia-oxidizing bacteria,AOB)和主要的亚硝酸盐氧化细菌(nitrite-oxidizing bacteria,NOB)。功能预测结果显示苯甲酸酯降解、氨基苯甲酸酯降解、氯烷烃和氯烯烃的降解、氟代苯甲酸酯降解和硝基甲苯降解是外源物质生物降解和代谢的前五大通路,广泛分布在主要菌属中,验证了微生物降解剩余污染物的作用。基因pmoA/B/C-amoA/B/C、hao和nxrA/B编码相关的酶,组成了完整的硝化途径。共现网络结果揭示溶杆菌属、Candidatus Solibacter和红游动菌属在O₂生态中的重要地位。通过冗余分析(redundancy analysis,RDA)表明COD和NH₃是影响O₂微生物群落的主要因素。【结论】红游动菌属和溶杆菌属是O₂中最核心的功能菌属,在污染物矿化和维持群落生态稳定上有重要作用。亚硝化弧菌属和硝化螺菌属是硝化作用的核心菌属。O₂中的代谢通路以剩余污染物矿化和完全硝化为主,微生物群落主要受COD和NH₃的影响。本研究阐明了O₂的微生物结构与功能,为焦化废水O/H/O生物处理工艺的改进提供了微生物学上的依据。     

Electricity generation using chocolate industry wastewater and its treatment in activated sludge based microbial fuel cell and analysis of developed microbial community in the anode chamber

Feasibility of using chocolate industry wastewater as a substrate for electricity generation using activated sludge as a source of microorganisms was investigated in two-chambered microbial fuel cell. The maximum current generated with membrane and salt bridge MFCs was 3.02 and 2.3 A/m², respectively, at 100 Ω external resistance, whereas the maximum current generated in glucose powered MFC was 3.1 A/m². The use of chocolate industry wastewater in cathode chamber was promising with 4.1 mA current output. Significant reduction in COD, BOD, total solids and total dissolved solids of wastewater by 75%, 65%, 68%, 50%, respectively, indicated effective wastewater treatment in batch experiments. The 16S rDNA analysis of anode biofilm and suspended cells revealed predominance of β-Proteobacteria clones with 50.6% followed by unclassified bacteria (9.9%), α-Proteobacteria (9.1%), other Proteobacteria (9%), Planctomycetes (5.8%), Firmicutes (4.9%), Nitrospora (3.3%), Spirochaetes (3.3%), Bacteroides (2.4%) and γ-Proteobacteria (0.8%). Diverse bacterial groups represented as members of the anode chamber community.     

16S rDNA sequence diversity of a culture-accessible part of an anaerobic digestor bacterial community

A bacterial culture-based inventory with 16S rDNA identification of the isolates was carried out on an anaerobic digestor microbial ecosystem to compare to the 16S rDNA sequences directly retrieved from the ecosystem by a molecular inventory previously made in our laboratory. Twenty OTUs (Operational Taxonomic Units) belonging to five of the major bacterial groups were identified from 338 isolated colonies. The sequences of 13 of the 20 OTUs were not closely related to any hitherto published sequences (less than 96% sequence identity). Six OTUs out of 20 were found to have sequences similar to sequences of the molecular inventory. Despite the biases expected to be associated with the molecular and culture-based methods, the distribution of the isolated OTUs into the different bacterial phyla was similar to that of the molecular OTUs.     

焦化废水中4株苯酚高效降解菌的分离及鉴定

目的:从焦化废水中筛选苯酚高效降解菌并进行鉴定.方法:在100～1000 mg/L的苯酚为惟-碳源的无机盐培养基上分离出单菌落,测定各菌株的生长曲线以及对苯酚的降解效牢;利用 16S rDNA序列分析结合菌株的形态特征确定各菌株的分类地位.结果:筛选获得4株苯酚降解菌,均能够以苯酚为惟一碳源,在30℃、pH7.0、摇床转速130 r/min、2%的接种量条件下,24h内能将1 000mg/L的苯酚降解91%以上;4株菌可初步鉴定为芽孢杆菌属(ZL1)、产碱杆菌属(ZL2、ZL4)、沙雷氏菌属(ZL3).其中,从焦化废水中分离出高效降解苯酚的沙雷氏菌未见报道.结论:从焦化废水中获得4株苯酚高效降解细菌,对高浓度含酚废水的生物降解具有潜在的应用前景.     

Comparison of bacterial populations and chemical composition of dairy wastewater held in circulated and stagnant lagoons

AIMS: This study compared the chemical, physical and bacterial composition of circulated and stagnant dairy wastewaters. METHODS AND RESULTS: Samples taken from circulated and stagnant wastewater lagoons, over a 1-year period, were analysed for 10 chemical (total N, NH3, NO3, NO2, Na, Ca, HCO3, Fe, P and K) and six physical (biological oxygen demand, chemical oxygen demand, dissolved solids, electrical conductivity, pH and sodium absorption ratio) parameters and were found to be similar. The 16S rDNA genes from the samples were amplified, cloned and BLAST analysed. In total, 996 stagnant and 1052 circulated wastewater derived sequences were obtained, comprising 294 and 362 operational taxonomic units (OTUs) from the circulated and stagnant wastewaters respectively. Coverage estimates of the OTUs identified were 72.1% for the stagnant, and 63.6% for the circulated wastewater libraries. The greatest difference between the two wastewaters was a c. sixfold greater number of sequences representative of the family Chromatiaceae in the circulated wastewater derived library and a c. fivefold greater number of sequences representative of the phylum Chloroflexi in the stagnant wastewater derived library. CONCLUSIONS: Circulation of dairy wastewater does not affect any of the chemical or physical parameters tested; however, circulation does alter the bacterial community structure. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides evidence that circulation of dairy wastewater promotes the growth of bacteria within the family Chromatiaceae and that stagnant systems promote the growth of the phylum Chloroflexi.     

红树林土壤细菌群落16S rDNA V3片段PCR产物的DGGE分析

从土壤中抽提微生物总DNA ,直接扩增 16SrDNAV3片段 ,应用变性梯度凝胶电泳 (DGGE)和分子克隆技术分析 16SrDNAV3片段的多态性 ,发现地域因素和红树品种都是影响土壤细菌群落结构的因素。通过对杯萼海桑土壤 16SrDNAV3片段PCR产物两个DGGE条带进行分子克隆、序列测定和Blast分析 ,发现每个DGGE条带包含着许多不同的 16SrDNAV3片段 ,并且其中多数为NCBI未收录的序列。这表明DGGE和克隆技术相结合的方法是研究土壤微生物群落结构的一种可行方法。     

京津冀区域市政污水厂活性污泥种群结构的多样性及差异

【背景】活性污泥中微生物的种群结构影响着污水生物处理的高效性及稳定性,是有效保证污水处理效果的关键。【目的】研究活性污泥中细菌的群落结构组成及多样性,并分析相应菌群的主要功能,旨在更好地发挥细菌的净化作用、保持污水处理过程的稳定及提高污水的处理效率。【方法】以京津冀区域内典型市政污水厂活性污泥为研究对象,通过IlluminaMiSeq高通量测序及实时定量PCR技术,对5个污水厂活性污泥的微生物种群结构特征进行了详细解析,研究不同工艺参数下活性污泥中优势种群及脱氮菌群丰度的差异。【结果】5个污水厂活性污泥种群结构具有一定差异,其中Hengshui (HS)厂污泥的群落结构受温度的影响最大,而Shahe (SH)、Daoxianghu (DXH)、Nangong(NG)厂活性污泥群落结构则受总氮、总磷与氨氮的共同影响,氨氮对SH厂活性污泥种群结构影响最大。DXH、NG和HS厂污泥中优势菌均为Anaerolineaceae,而SH和Hejian (HJ)厂的优势菌则为Saprospiraceae与Lactobacillus。活性污泥中反硝化菌丰度最高的为HJ厂,丰度最低的为HS厂,反硝化功能基因nirS比nirK分布更为广泛。【结论】对于不同污水厂,影响其活性污泥群落结构组成的环境因素也是不同的,并且特殊的进水水质也会对污泥菌群组成和生物多样性产生影响。     

产氢菌的分离鉴定及其产氢特性研究

从河底污泥中分离到一株产氢菌,通过16S rDNA序列和系统发育分析,鉴定为克雷伯氏菌属,命名为Klebsiella sp. HQ-3.运用单因子试验考察了摇瓶发酵培养基中碳源、氮源、无机盐等因素对克雷伯氏菌HQ-3发酵产氢的影响,并对其产氢特性做了初步研究.结果表明,克雷伯氏HQ-3在葡萄糖浓度为24 g/L,蛋白胨为18 g/ L,KH2PO4为 8g/ L时具有较高产氢量,其最佳产氢初始pH为8.0左右.     

Microbial identification of the Nichupte-Bojorquez coastal lagoon in Cancun,Mexico

The microbial community of the Nichupte-Bojorquez lagoon system located in Cancun, Mexico was evaluated using surface-water samples that were collected before and after the hurricane Wilma impacted the area on October 2005. The analysis was done using a culture-independent molecular approach involving Amplified Ribosomal DNA Restriction Analysis, and CLuster ANalysis of Sequences. A total of 61 16S ribosomal RNA genes were differentially selected and screened. The results show a bacterial profile dominated by Cytophaga-Flavobacteria/Flexibacter-Bacteroidetes group; the Bacteroidetes group in particular. The second most abundant group was assigned to the Proteobacteria group and a minor proportion of bacteria that belongs to the Cyanobacteria and Bacilli classes. Our study gives the first insight into the bacterial community adapted to this heavily polluted but occasional oligotrophic coastal lagoon; no substantial differences were, however, found.