Oxalic acid production by Aspergillus niger

Aspergillus niger is able to produce a quite high concentration of oxalic acid using sucrose as carbon and energy source. Operating at pH higher than 6 and an enriched N and P medium is necessary in order to conduct the fermentation towards oxalic acid production. A pH?shift technique, operating at acid pH?in the first two days and then setting pH?to 6, allowed the productivity to slightly increase in shaking flasks cultures up to 3.0?kg/m³?·?d, with a final oxalic acid concentration of 29?kg/m³. When operating at more controlled conditions, in a stirred tank, both productivity and oxalic acid concentration were improved (4.1?kg/m³?·?d and 33.8?kg/m³, respectively). However the main drawback of this fermentation is the low yield attained (about 0.3?kg oxalic acid/kg sucrose) because most of glucose, resulting from the hydrolysis of sucrose by the extracellular enzymes secreted at the beginning of the fermentation, is very quickly oxidised to gluconic acid, a process which is favoured at a pH?close to 6. Milk whey was proved to be a very good substrate as it allows oxalic acid to be produced with a similar productivity (2.5?kg/m³?·?d in shaking flasks) giving excellent yields of almost 0.6?kg oxalic acid/kg lactose.     

Potential of the waste from beer fermentation broth for bio-ethanol production without any additional enzyme, microbial cells and carbohydrates

The potential of the waste from beer fermentation broth (WBFB) for the production of bio-ethanol using a simultaneous saccharification and fermentation process without any extra additions of saccharification enzymes, microbial cells or carbohydrate was tested. The major microbial cells in WBFB were isolated and identified. The variations in compositions of WBFB with stock time were investigated. There was residual activity of starch hydrolyzing enzymes in WBFB. The effects of reaction modes e.g. static and shaking on bio-ethanol production were studied. After 7 days of cultivation using the supernatant of WBFB at 30 °C the ethanol concentration reached 103.8 g/L in shaking culture and 91.5 g/L in static culture. Agitation experiments conducted at a temperature-profile process in which temperature was increased from 25 to 67 °C shortened the simultaneous process time. The original WBFB was more useful than the supernatant of WBFB in getting the higher concentration of ethanol and reducing the fermentation time. From this whole study it was found that WBFB is a cheap and suitable source for bio-ethanol production.     

Chronic Toxoplasmosis Modulates the Induction of Contact Hypersensitivity by TNCB in Mouse Model

Mouse models of chronic toxoplasmosis and atopic dermatitis (AD) were combined to clarify the effect of opportunistic Toxoplasma gondii infection on the development of AD. AD was induced as a chronic contact hypersensitivity (CHS) with repeated challenge of 2,4,6-trinitro-1-chlorobenzene (TNCB) on the dorsal skin of mice. TNCB induced skin thickness increases in both normal and toxoplasmic mice. The changing patterns were different from the sigmoidal which saturated at 20 days in normal mice to the convex saturated at 12 days in toxoplasmic mice with the crossing at 18 days. Compared to normal mice, toxoplasmic mice presented CHS more severely in earlier times and then moderately in later times. These data suggest that host immune modification by T. gondii infection enhances CHS in early times of atopic stimulation but soothes the reaction of CHS in later times in mouse model.     

固定化桔青霉产生核酸酶P_1的研究

利用吸附固定在多孔聚酯载体上的桔青霉(Penicillium citrinum)菌丝细胞,在摇瓶中以分批发酵方式合成核酸酶P_1.试验结果表明:在固定化细胞产酶的条件下,培养液中葡萄糖和蛋白胨的最适浓度分别为10g/L和1g/L,摇瓶转速以180~200r/min为宜.固定化细胞经过48h的产酶周期,培养液中的核酸酶P_1活力可高达513.3U/ml,其产酶效率是游离菌丝的3.6倍,而葡萄糖和蛋白胨的用量仅为游离菌丝产酶的五分之一.在重复分批发酵试验中,固定化菌丝细胞形状稳定,连续28批(共56d)的产酶结果基本一致,每批的平均酶活力为507.4U/ml,在经济上和工艺上均显示了明显的优越性.     

中性内切型纤维素酶在毕赤酵母中高水平表达的研究

中性内切型纤维素酶在纺织及造纸工业具有重要的应用,为了进一步提高从我国草菇中克隆的一种新的中性内切型纤维素酶(EG1)在Pichiapastoris中的表达水平,我们进行了提高基因拷贝数及高密度发酵等多种手段实现其高水平表达的研究。在前期研究的基础上,利用对已整合eg1的重组子再转化的方法,从含有2000μgLZeocin的YPDSZ平板上筛选到高抗Zeocin转化子,在摇瓶培养条件下,该转化子表达量比原来提高了3.8倍,在pH4～8条件下均有稳定表达,接种量(OD600=5.0)表达水平最好,提高甲醇的诱导浓度对表达有显著的促进作用。用3.2L发酵罐进行了高密度发酵,甲醇诱导95.5h后达到最高值,比摇瓶培养再提高了6.4倍,因此利用高抗Zeocin转化子及高密度发酵的手段,使EG1的表达水平提高了34倍,蛋白表达量达8.80mgmL,EG1酶活达到543.36IUmL,实现了中性内切纤维素酶的高水平表达,本研究将大大促进建立我国纺织用纤维素酶大规模高效生产技术。     

Freezing injury in onion bulb cells: I. Evaluation of the conductivity method and analysis of ion and sugar efflux from injured cells

Onion (Allium cepa L.) bulbs were frozen to −4 and −11 C and kept frozen for up to 12 days. After slow thawing, a 2.5-cm square from a bulb scale was transferred to 25 ml deionized H₂O. After shaking for standard times, measurements were made on the effusate and on the effused cells. The results obtained were as follows.     

Fermentation of sunflower seed hull hydrolysate to ethanol by Pichia stipitis

Ethanol production from sunflower seed hull hydrolysate was evaluated using Pichia stipitis NRRL Y-7124. The hydrolysate prepared with 0.7 M H2SO4 at 90 degrees C was fermented as substrate in shaking bath experiments at 30 degrees C. In a group of experiments, the influence of various detoxification methods on the fermentability of hydrolysate was investigated at pH 6. Even though the ability of all employed pretreatments to enhance fermentation performance was close, the sequential application of overliming with sodium sulfite addition was the best detoxification method. Additional experiments were performed with detoxified hydrolysate to investigate the effect of shaking rate (70-130 rpm) and initial pH (5.5-7) on the fermentation. The highest ethanol level 11 gL(-1) was achieved at initial pH of 6 and 100 rpm shaking rate from a hydrolysate containing 48 gL(-1) total reducing sugar. The corresponding alcohol yield and volumetric productivity were 0.32 gg(-1) and 0.065 gL(-1)h(-1).     

Optimisation of the biological pretreatment of wheat straw with white-rot fungi for ethanol production

The biological pretreatment of lignocellulosic biomass for the production of bioethanol is an environmentally friendly alternative to the most frequently used process, steam explosion (SE). However, this pretreatment can still not be industrially implemented due to long incubation times. The main objective of this work was to test the viability of and optimise the biological pretreatment of lignocellulosic biomass, which uses ligninolytic fungi (Pleurotus eryngii and Irpex lacteus) in a solid-state fermentation of sterilised wheat straw complemented with a mild alkali treatment. In this study, the most important parameters of the mechanical and thermal substrate conditioning processes and the most important parameters of the fungal fermentation process were optimised to improve sugar recovery. The largest digestibilities were achieved with fermentation with I. lacteus under optimised conditions, under which cellulose and hemicellulose digestibility increased after 21 days of pretreatment from 16 to 100 % and 12 to 87 %, respectively. The maximum glucose yield (84 %) of cellulose available in raw material was obtained after only 14 days of pretreatment with an overall ethanol yield of 74 % of the theoretical value, which is similar to that reached with SE.     

Laccase production and simultaneous decolorization of synthetic dyes in unique inexpensive medium by new isolates of white rot fungus

Morphological and biochemical analysis of the newly isolated white rot fungal (WRF-1) strain has ability to secrete laccase in the economical medium consisted of synthetic dyes, groundnut shell (GNS) and cyanobacterial biomass (algal bloom) under submerged shaking condition at pH 5.0 and 30 °C ± 2 °C temperature. WRF-1 strain was found to decolorize synthetic dyes efficiently at pH 5.0 and 30 °C ± 2 °C temperature. The laccase activity of strain was purified to homogeneity by chromatography with yield up to 70%. The molecular mass of laccase was found to be 70 kDa by SDS-PAGE and isoelectric point was 4.8. Biotransformation of the dyes was followed spectrophotometrically and dyes were found to decolorize completely after 6 days of fermentation. LC-MS studies were used to decipher the degradation profile of synthetic dyes by WRF-1. Indigo carmine gets degraded to isatin sulfonic acid and 4-amino-3-methylbenzenesulphonic acid whereas methyl orange degraded metabolites were identified as p-N,N′-dimethylamine phenyldiazine and p-hydroxybenzene sulfonic acid. Thus the study would give a road map for the production and application of laccase enzyme on a larger scale using low cost substrate.     

Efficient mosquitocidal toxin production by Bacillus sphaericus using cheese whey permeate under both submerged and solid state fermentations

Whey permeate (WP) was used efficiently for production of mosquitocidal toxin by Bacillus sphaericus 2362 (B. sphaericus 2362) and the Egyptian isolate, B. sphaericus 14N1 (B. sphaericus 14N1) under both submerged and solid state fermentation conditions. Under submerged fermentation, high mosquitocidal activity was produced by B. sphaericus 2362 and B. sphaericus 14N1 at 50-100% and 25-70% WP, respectively. Initial pH of WP was a critical factor for toxin production by both tested organisms. The highest toxicity was obtained at initial pH 7. Egyptian isolate, B. sphaericus 14N1 was tested for growth and toxin production under solid state fermentation conditions (SSF) by using WP as moistening agent instead of distilled water. The optimum conditions for production of B. sphaericus 14N1 on wheat bran-WP medium were 10 g wheat bran/250 ml flask moistened with 10-70% WP at 50% moisture content, inoculum size ranged between 17.2 × 10⁷ and 34.4 × 10⁷ and 6 days incubation under static conditions at 30 °C. Preliminary pilot-scale production of B. sphaericus 14N1 under SSF conditions in trays proved that wheat bran-WP medium was efficient and economic for industrial production of mosquitocidal toxin by B. sphaericus.     

Impacts of main factors on bioethanol fermentation from stalk juice of sweet sorghum by immobilized Saccharomyces cerevisiae (CICC 1308)

In order to attain a higher ethanol yield and faster ethanol fermentation rate, orthogonal experiments of ethanol fermentation with immobilized yeast from stalk juice of sweet sorghum were carried out in the shaking flasks to investigate the effect of main factors, namely, fermentation temperature, agitation rate, particles stuffing rate and pH on ethanol yield and CO(2) weight loss rate. The range analysis and analysis of variance (ANOVA) were applied for the results of orthogonal experiments. Results showed that the optimal condition for bioethanol fermentation should be A(4)B(3)C(3)D(4), namely, fermentation temperature, agitation rate, particles stuffing rate and pH were 37 degrees C, 200rpm, 25% and 5.0, respectively. The verification experiments were carried out in shaking flasks and 5L bioreactor at the corresponding parameters. The results of verification experiments in the shaking flasks showed that ethanol yield and CO(2) weight loss rate were 98.07% and 1.020gh(-1), respectively. The results of ethanol fermentation in the 5L bioreactor showed that ethanol yield and fermentation time were 93.24% and 11h, respectively. As a result, it could be concluded that the determined optimal condition A(4)B(3)C(3)D(4) was suitable and reasonable for the ethanol fermentation by immobilized Saccharomyces cerevisiae. The conclusion in the research would be beneficial for application of ethanol fermentation by immobilized S. cerevisiae from stalk juice of sweet sorghum.     

番茄青枯病拮抗菌筛选鉴定及其发酵条件初探

从健康番茄根系采样,筛选出4株对番茄青枯病有较强拮抗作用的菌株,在NA培养基上抑菌圈直径>9 mm。其中拮抗菌株YB6抑菌活性最强且拮抗效果稳定,通过形态学观察及部分生理生化特征测定,初步确定为节杆菌属。通过单因素试验进行了发酵条件初步研究,得到适宜的发酵条件为:发酵时间3 d,培养温度30°C,初始pH值9.0,接种量3%,转速100 r/min,碳源蔗糖,氮源酵母浸膏。通过初步优化后拮抗菌株抑菌活性明显增强,最终对青枯病菌SST-Y和G2M1.70抑菌圈直径与NB培养基相比增加了76.72%和81.14%,差异显著。     

In Vitro Stimulation of Forage Fiber Degradation by Ruminal Microorganisms with Aspergillus oryzae Fermentation Extract

Aspergillus oryzae fermentation extract (Amaferm) was evaluated for its ability to influence degradation of brome grass and switchgrass fiber fractions by mixed ruminal microorganisms in vitro. Addition of Amaferm at a concentration of 0.067 mg/ml, which is approximately the concentration found in the rumen ecosystem (0.06 mg/ml), increased the degradation of brome grass neutral detergent fiber (NDF) by 28% after fermentation for 12 h (P < 0.01), but had no effect after fermentation for 24 or 48 h. The levels of degradation of both the cellulose and hemicellulose fractions were increased after fermentation for 12 h (P < 0.01). Additions of 0.08 and 8% (vol/vol) Amaferm filtrate (12.5 g/100 ml) stimulated degradation of switchgrass NDF by 12 and 24% (P < 0.01), respectively, after fermentation for 12 h; when 80% filtrate was added, degradation was decreased by 38%. The concentrations of total anaerobes in culture tubes containing 80% filtrate were 5 times greater than the concentrations in the controls; however, the concentrations of cellulolytic organisms were 3.5 times lower than the concentrations in the controls (P < 0.05). These results suggested that the filtrate contained high concentrations of soluble substrate which did not allow the cellulolytic organisms to compete well with other populations. The remaining concentrations of esterified p-coumaric and ferulic acids were lower at 12 h in NDF residues obtained from fermentation mixtures supplemented with Amaferm. Because the total anaerobes were not inhibited in fermentation mixtures containing Amaferm, antibiotics are unlikely to be involved as a mode of action for increasing NDF degradation. The possibility that Amaferm contains enzymes (possibly esterases) that may play a role in stimulating the rate of fiber degradation by mixed ruminal microorganisms by removal of plant cell wall phenolic acid esters is discussed.     

重组大肠杆菌BL21(pUC19-Hyp)产羟脯氨酸的补料分批培养

利用自主构建的组成型重组大肠杆菌BL21(pUC19-Hyp)为出发菌株,运用间歇流加、指数流加和恒速流加3种流加C源的方式进行补料分批培养。结果表明:在装液量为4 L的7 L发酵罐中,以0.30 g/min恒速流加为最优,在发酵44 h时,羟脯氨酸的质量浓度达到最高,为42.50 g/L,脯氨酸转化率为81%,此时细胞干质量为21.33g/L,残糖质量浓度为0.17 g/L。L-羟脯氨酸含量与摇瓶发酵时的1.39 g/L相比,提高了大约30倍,比日本株式会社的发酵产量提高了1.50 g/L,发酵过程中糖酸转化率约为4.0∶1。发酵液中的氨基酸分析结果表明,除脯氨酸、羟脯氨酸外的其他氨基酸质量浓度均低于0.1 g/L,发酵液中主要氨基酸为脯氨酸和羟脯氨酸。     

The effect of rabbit age on in vitro caecal fermentation of starch, pectin, xylan, cellulose, compound feed and its fibre

In vitro gas production kinetics of six different substrates, pectin (PEC), xylan (XYL), starch (STA), cellulose (CEL), commercial compound feed (FEED; 201 g crude protein per kg, 155 g crude fibre per kg, 334 g neutral-detergent fibre (NDF) per kg and 190 g acid-detergent fibre (ADF) per kg) and an NDF prepared from commercial compound feed (NDF_FEED) were determined using the caecum contents of weaned rabbits (36 days of age) and of rabbits at slaughter age (78 days of age) as inoculums. The cumulated gas production over 96 h of incubation was modelled with Gompertz model, and the kinetic parameters compared. The total potential gas production (parameter ‘B’ of the Gompertz model) was not affected (P>0.05) by the inoculum source, except with STA, where rabbits at slaughter weight had significantly higher total potential fermentability (314 ml/g dry matter (DM)) than those at weaning age (189 ml/g DM). Intensities of fermentation (maximum fermentation rate; MFR) of PEC (32.2 ml/h) and XYL (24.4 ml/h) were significantly greater in rabbits at weaning, while that of STA (45 ml/h) was significantly lower than at slaughter age (23.0, 14.3 and 14.0 ml/h for PEC, XYL and STA, respectively). The MFRs of CEL and NDF_FEED were very similar between inoculum sources. In the first 10 h of fermentation which correspond to the normal retention time of the substrates in the caecum, the highest amount of gas was produced from PEC, followed by FEED and XYL. These substrates had a time of maximum fermentation rate (TMFR) at both rabbit ages short enough (8.0 and 9.5 h for PEC, 9.5 and 6.6 h for FEED, 13.7 and 14.2 h for XYL at weaning and at slaughter age, respectively) to be almost completely fermented in vivo.     

Optimization of the fermentation parameters for the production of Ganoderma lucidum immunomodulatory protein by Pichia pastoris

Abstract

In order to obtain a better fermentation parameter for the production of recombinant Ganoderma lucidum immunomodulatory protein (rFIP-glu), an engineered Pichia pastoris GS115 was investigated on the fermentation time, temperature, methanol concentration and initial pH of media, while immunomodulatory activities of the rFIP-glu was confirmed. L₉(3³) orthogonal experiment were firstly employed to optimize various fermentation parameters in the shake-flask level. The optimized fermentation parameters were subsequently verified in a 5?L fermenter. Biological activities including cell viability and tumor necrosis factor-alpha (TNF-α) mRNA of the rFIP-glu were evaluated on murine macrophage RAW264.7 cells. The results showed that the yield of rFIP-glu was up to 368.71?μg/ml in the shake-flask, and 613.47?μg/ml in the 5?L fermenter, when the Pichia pastoris was incubated in basic media with the methanol concentration 1.0% and initial pH 6.5, and with constant shaking at 280?rpm for 4?days at 26?°C. In vitro assays of biological activity indicated that rFIP-glu had significant toxicity against RAW264.7 cells, and possessed the ability to induce TNF-α mRNA expression in macrophage RAW264.7 cells. In conclusion, engineered P. pastoris showed a good fermentation property under the optimum fermentation parameters. It could be a candidate industrial strain for further study.     

Production of the antifungal peptide antibiotic,iturin by Bacillus subtilis NB22 in solid state fermentation

Production of iturin, an antifungal peptide effective at suppressing phytopathogens, by Bacillus subtilis NB22 was investigated in solid state fermentation (SSF) using soy bean curd residue (okara). In scale-up from 15 g to 3 kg, aeration, temperature, and moisture content were controlling factors for the efficient production of iturin. It was found that solid state fermentation was 6–8 times more efficient with respect to iturin productivity than submerged fermentation on the basis of unit wet weight. Higher productivity in selective production of specific components of iturin which are stronger inhibitors of plant pathogens was also confirmed in SSF.     

Population Diversity of Yeasts and Lactic Acid Bacteria in Pig Feed Fermented with Whey, Wet Wheat Distillers' Grains, or Water at Different Temperatures

The diversity of populations of yeast and lactic acid bacteria (LAB) in pig feeds fermented at 10, 15, or 20°C was characterized by rRNA gene sequencing of isolates. The feeds consisted of a cereal grain mix blended with wet wheat distillers' grains (WWDG feed), whey (W feed), or tap water (WAT feed). Fermentation proceeded for 5 days without disturbance, followed by 14 days of daily simulated feed outtakes, in which 80% of the contents were replaced with fresh feed mixtures. In WWDG feed, Pichia galeiformis became the dominant yeast species, independent of the fermentation temperature and feed change. The LAB population was dominated by Pediococcus pentosaceus at the start of the fermentation period. After 3 days, the Lactobacillus plantarum population started to increase in feeds at all temperatures. The diversity of LAB increased after the addition of fresh feed components. In W feed, Kluyveromyces marxianus dominated, but after the feed change, the population diversity increased. With increasing fermentation temperatures, there was a shift toward Pichia membranifaciens as the dominant species. L. plantarum was the most prevalent LAB in W feed. The WAT feed had a diverse microbial flora, and the yeast population changed throughout the whole fermentation period. Pichia anomala was the most prevalent yeast species, with increasing occurrence at higher fermentation temperatures. Pediococcus pentosaceus was the most prevalent LAB, but after the feed change, L. plantarum started to proliferate. The present study demonstrates that the species composition in fermented pig feed may vary considerably, even if viable cell counts indicate stable microbial populations.     

Improvement of kojic acid production in Aspergillus oryzae B008 mutant strain and its uses in fermentation of concentrated corn stalk hydrolysate

A strain designated M866, producing kojic acid with a high yield, was obtained by combining induced mutation using ion beam implantation and ethyl methane sulfonate treatment of a wild type strain of Aspergillus oryzae B008. The amount of kojic acid produced by the strain M866 in a shaking flask was 40.2 g/L from 100 g/L of glucose, which was 1.7 times higher than that produced by wild strain (23.58 g/L). When the mixture of glucose and xylose was used as carbon source, the resulting kojic acid production was raised with the increasing of glucose ratios in the mixture. With concentrations of glucose at 75 g/L and xylose at 25 g/L mixed in the medium, the production of kojic acid reached 90.8 %, which was slightly lower than with glucose as the sole source of carbon. In addition, the kojic acid fermentation of the concentrated hydrolysate from corn stalk was also investigated in this study, the maximum concentration of kojic acid accumulated at the end of the fermentation was 33.1 g/L and this represents the yield based on reducing sugar consumed and the overall productivity of 0.36 g/g and 0.17 g/L/h, respectively.     

蔗渣发酵菌剂培养基的筛选及发酵条件的优化

采用单因素和正交试验研究了蔗渣高效发酵菌剂(芽孢杆菌B-A、曲霉菌F-A、链霉菌A-B)的摇瓶发酵最佳工艺条件.结果表明:芽孢杆菌B-A的最佳培养基配方:牛肉膏0.3%、蛋白胨1%、葡萄糖1%、NaCl 0.5%、可溶性淀粉0.5%、3.08%浓度的MnSO4溶液0.1;最适发酵条件为pH7、装液量100 ml(250 ml三角瓶)、36℃培养27 h.曲霉F-A的最佳培养基配方:葡萄糖3%、豆饼粉3%、蛋白胨1.2%、酵母膏0.3%、K2HPO4 0.05%、KH2PO40.05%、CaCl20.08%、MgSO40.04%、MnSO40.04%、ZnSO40.02%;最适发酵条件为pH6、装液量50 ml、30℃培养3 d.链霉菌A-B的最佳培养基配方:可溶性淀粉4.5%、蔗糖1%、豆饼粉3%、NaNO30.2%、ZnSO40.01%、KH2PO40.001%;最适发酵条件为pH7、装液量50 ml、30℃培养3 d.