Strategic considerations on the configuration of free flaps and their vascular pedicles combined with Ilizarov distraction in the lower extremity

For the injury of the lower leg associated with both bone and soft-tissue defect, the combined free flap and the Ilizarov distraction method were described as a useful treatment modality. During the procedure of distraction, however, revisions were frequently needed to change the pin position or to change the flap configuration. In case of flap ischemia, distraction should be delayed or abandoned. Then, a vascularized bone transfer might be necessary. To avoid these complications and achieve safe distraction, the configuration of the flap with its vascular pedicle should be carefully planned in terms of the future bony lengthening procedures and the concomitant soft-tissue changes of the lower leg. According to the response of local tissue to the distraction process, the lower limb can be divided into four compartments (active mobile, passive mobile, receptive, and restrictive). The configuration of the transferred free flap with its vascular pedicle can be classified into five types. To minimize the undue forces to the vascular pedicle and reduce the possibility of vascular compromise, the transferred free flap should have the configuration that its vascular pedicle lies in the territory of the mobile compartment. In performing free-tissue transfer combined with the Ilizarov method in the lower extremity, the configuration of the flap with its vascular pedicle should be carefully planned, and the characteristics of lower leg tissue should be kept in mind during the distraction.     

One-stage reconstruction of composite bone and soft-tissue defects in traumatic lower extremities

Management of bone loss that occurs after severe trauma of open lower extremity fractures continues to challenge reconstructive surgeons. Sixty-one patients who had 62 traumatic open lower extremity fractures and combined bone and composite soft-tissue defects were treated with the following protocol: extensive debridement of necrotic tissues, eradication of infection, and vascularization of osteocutaneous tissue for one-stage bone and soft-tissue coverage reconstruction. The mechanism of injury included 49 motorcycle accidents (80.3 percent), five falls (8.2 percent), three crush injuries (4.9 percent), two pedestrian-automobile accidents (3.3 percent), and two motor vehicle accidents (3.3 percent). The bone defects were located in the tibia in 49 patients (79 percent; one patient had bilateral open tibial fractures), in the femur in seven patients (11.3 percent), in the calcaneus bone in four patients (6.5 percent), and in the metatarsal bones in two patients (3.2 percent). The size of soft-tissue defects ranged from 5 x 9 cm to 30 x 17 cm. The average length of the preoperative bony defect was 11.7 cm. The average duration from injury to one-stage reconstruction was 27.1 days, and the average number of previous extensive debridement procedures was 3.4. Fifty patients had vascularized fibula osteoseptocutaneous flaps, six had vascularized iliac osteocutaneous flaps, and five patients had seven combined vascularized rib transfers with serratus anterior muscle and/or latissimus dorsi muscle transfers. One patient received a second combined rib flap because the first combined rib flap failed. The rate of complete flap survival was 88.9 percent (56 of 63 flaps). Two combined vascularized rib transfers with serratus anterior muscle and latissimus dorsi muscle flaps were lost totally (3.2 percent) because of arterial thrombosis and deep infection, respectively. Partial skin flap losses were encountered in the five fibula osteoseptocutaneous flaps (7.9 percent). Postoperative infection for this one-stage reconstruction was 7.9 percent. Excluding the failed flap and the infected/amputated limb, the primary bony union rate after successful free vascularized bone grafting was 88.5 percent (54 of 61 transfers). The average primary union time was 6.9 months. The overall union rate was 96.7 percent (59 of 61 transfers). The average time to overall union was 8.5 months after surgery. Seven transferred vascularized bones had stress fractures, for a rate of 11.5 percent. Donor-site problems were noted in six fibular flaps, in two iliac flaps, and in one rib flap. The fibular donor-site problems were foot drop in one patient, superficial peroneal nerve palsy in one patient, contracture of the flexor hallucis longus muscle in two patients, and skin necrosis after split-thickness skin grafting in two patients. The iliac flap donor-site problems were temporary flank pain in one patient and lateral thigh numbness in the other. One rib flap transfer patient had pleural fibrosis. Transfer of the appropriate combination of vascularized bone and soft-tissue flap with a one-stage procedure provides complex lower extremity defects with successful functional results that are almost equal to the previously reported microsurgical staged procedures and conventional techniques.     

The vascularized pig fibula bone flap model: effect of segmental osteotomies and internal fixation on blood flow

The free fibular flap is the flap of choice for reconstruction of complex mandibular defects, although two or more osteotomies may be required to recreate the normal mandibular contour. The effect of these surgical manipulations on the fibula has not been adequately investigated. This study was designed to study the effect of multiple segmental osteotomies and internal fixation techniques on blood flow in the vascularized pig fibula bone flap model. The hindlimbs of 15 Yorkshire pigs were randomized into 1 of 5 groups (n = 6 fibulae per group) consisting of: (1) a nonoperated, in situ fibula; (2) an elevated fibula flap; (3) an elevated fibula flap with two segmental osteotomies; (4) an elevated fibula with two segmental closing osteotomies rigidly fixed with 2-mm miniplates; (5) an elevated fibula with two segmental closing osteotomies rigidly fixed with 2-mm lag screws. Total and gradient blood flow was measured in the bone and soft-tissue components of these flaps using the 15-microm radioactive microsphere technique. The creation of two segmental osteotomies in the vascularized pig fibula bone flap model resulted in a significant decrease (p<0.05) in the gradient blood flow in the segment of bone distal to the second osteotomy. Application of miniplates or lag screws across closing osteotomies resulted in a significant decrease (p<0.05) in total and gradient blood flow to the bone component of the fibulae, as compared with the elevated and osteotomized fibulae groups. An increase in blood flow suggesting a hyperemic response was noted in the bone and soft tissue in the elevated and osteotomized flap groups as compared with the in situ, nonoperated controls. This study established the validity of the pig fibula as a suitable model for investigating the pathophysiology of blood flow changes in the face of standard surgical maneuvers necessary for the restoration of mandibular form and function. The results demonstrated that the creation of multiple segmental osteotomies and the application of internal fixation significantly decreases (p<0.05) blood flow to the distal portion of the flap. The effects of segmental osteotomies and internal fixation on healing and growth of the pig fibula bone flap model are investigated in a separate study.     

Osteocutaneous posterior interosseous flap for reconstruction of the metacarpal bone and soft-tissue defects in the hand

A vascularized bone segment of the ulna together with a posterior interosseous fasciocutaneous flap is harvested, including a cuff of the extensor pollicis longus muscle. The authors treated five male patients with metacarpal bone and soft-tissue defects of the hand using a distally based island osteocutaneous posterior interosseous flap. Their ages at the time of surgery ranged from 15 to 37 years (mean, 24 years). The bone defects were in the first metacarpal in three cases, the fourth metacarpal in one, and the fifth metacarpal in one. The length of the donated ulna ranged from 3 to 7 cm (mean, 5 cm). The follow-up period ranged from 5 to 92 months (mean, 39 months). All flaps survived completely. The posterior interosseous flap provides thin skin of good texture, together with vascularized bone, for a one-stage reconstruction of the metacarpal bone and soft-tissue defects in the hand.     

The segmental rectus abdominis free flap for ankle and foot reconstruction.

The reconstruction of soft-tissue defects of the ankle and foot usually requires free-tissue transfer. Although certain local flaps have been described for the reconstruction of these injuries, their utility may be compromised by significant crush injury or the size and location of the defect. Part of the rectus abdominis muscle, the segmental rectus abdominis free flap, is ideally suited for this use because of the muscle's versatility, reliability, and negligible donor deformity when harvested through a low transverse abdominal incision. Seven patients reconstructed with this flap are presented, and the technique is discussed. All patients have been successfully reconstructed with preservation of the ankle and foot. At present, all patients are fully or partially weight-bearing. The segmental rectus abdominis free flap is recommended for the reconstruction of such wounds.     

The role of free-tissue transfers in lower-extremity reconstruction

Eighty-five free flaps were performed in 76 patients for defects in the lower extremity. A new classification of lower-extremity defects was devised to help define the role of free-tissue transfers: group 1, soft-tissue defects; group 2, soft-tissue and bone loss less than 8 cm; group 3, massive soft-tissue and bone loss greater than 8 cm; and group 4, bone defect only. Each group was further divided into clean (A) and infected (B) wounds. Our overall results include resolution of the presenting problem in 82 percent; there were 17 flap losses (20 percent), persistent osteomyelitis in 8, and 10 amputations. This review has prompted us to limit our indications for limb salvage, particularly in group 3B, in patients with compound injuries that include loss of plantar sensation, and in patients with large segments of infected bone.     

Free fibula osteoseptocutaneous-pedicled pectoralis major myocutaneous flap combination in reconstruction of extensive composite mandibular defects

Lateral composite mandibular defects resulting from excision of advanced oral carcinoma often require mandible, intra-oral lining, external face, and soft-tissue bulk reconstruction. Ignorance of importance soft-tissue deficit in those patients may cause significant morbidity and functional loss. Such defects, therefore, can be reconstructed best with a double free flap technique. However, this procedure may not be feasible for every patient or surgeon. An alternative procedure is a free fibula osteoseptocutaneous flap combined with a pedicled pectoralis major myocutaneous flap. This combination was used in reconstruction of extensive composite mandibular defects in 14 patients with T3/T4 oral squamous cell carcinoma. All patients were men, and the average age was 54.3 years. The septocutaneous paddle of the fibula flap was used for the mucosal lining of the defects while the bony part established the rigid mandibular continuity. The pectoralis major flap then covered the external skin defect in the face and cheek, and the dead spaces left by the extirpated masticator muscles, buccal fat, and parotid gland. One free fibula flap failed totally, and one pectoralis major flap developed marginal necrosis. At the time of final evaluation, nine patients (64.3 percent) were alive, surviving an average of 25.7 months. All patients eventually regained their oral continence and an acceptable cosmetic appearance. In conclusion, the fibula osteoseptocutaneous flap plus regional myocutaneous flap choice is a successful and technically less demanding alternative to the double free flap procedures in reconstruction of extensive lateral mandibular defects.     

Free-flap salvage of a traumatic below-knee amputation

A traumatic below-knee amputation with extensive soft-tissue loss and tibial bone exposure was salvaged by employing microsurgical free-tissue transfer to obtain stable soft-tissue coverage. The free flap covering the bony stump and knee function have done well with over 1 year follow-up.     

The free thoracoumbilical flap for resurfacing large soft-tissue defects of the lower extremity

Both cadavers and living patients were studied regarding a method to resolve large skin defects with bone exposure in the leg, with long-distance thrombosis of the anterior tibial vessels or posterior tibial vessels resulting from traumatic lesions. Forty-six casting mold specimens of cadaveric legs were investigated. There were rich communication branches among the anterior tibial artery, posterior tibial artery, and fibular artery in the foot and ankle, which complemented each other well. Twenty-six patients with large skin defects with bone exposure in the proximal or middle segment of the leg were admitted to the authors' hospital. Among those patients, 19 demonstrated long-distance thrombosis of the anterior tibial vessels or posterior tibial vessels resulting from traumatic lesions. During treatment, a thoracoumbilical flap based on the inferior epigastric vessels was anastomosed to the distal stump of the anterior tibial vessels or the posterior tibial vessels, with reversed flow. All defects were successfully repaired, with good color and texture matches of the flaps. This method can be used for patients with normal anterior tibial vessels or posterior tibial vessels, normal distal stumps of the injured blood vessels, and good reversed flow. The method has the advantages of dissecting blood vessels in the recipient area during the débridement, not affecting the blood circulation of the injured leg, not sacrificing blood vessels of the opposite leg, and not fixing the patient in a forced posture. The muscles are less bulky in the distal one-third of the leg, and the blood vessels are shallow and can be dissected and anastomosed easily. When the flap is used for reconstruction in the proximal two-thirds of the leg, the blood vessel pedicle of the free flap is at a straight angle, without kinking.     

Ilizarov method in combination with autologous mesenchymal stem cells from iliac crest shows improved outcome in tibial non-union

Autologous bone grafting and ilizarov technique are the preferred mode of treatment for bone nonunion, studies suggest that bone marrow derived mesenchymal stem cells can be effective in treatment of tibial non-union where there is length of bone defect. The current study investigates the beneficial clinical outcome of combining the ilizarov procedure with intraosseous injection of autologous mesenchymal stem cells. The open-label study enrolled 25 patients with infected tibial non-union at the Shanghai Fengxian District Central Hospital, Shanghai, China between April 2010 and July 2014. Patients were randomised to undergo the ilizarov procedure with (n = 11) or without (n = 13) intraosseous injection of bone marrow derived mesenchymal stem cells. All participants were followed prospectively until union was achieved (primary end point). The mean length of the bone defect in the Ilizarov group and Ilizarov group plus MSC group was 6.09 and 5.84 cm respectively. The mean time from the original injury to the time of the treatment for tibial non-union was 5–22 months (mean 13.5 months) for the Ilizarov group and 6–21 months (mean 13.5 months) for Ilizarov plus MSc group. All 24 patients were followed up for 12–34 months (mean 16 months). Both groups achieved the primary endpoint of stable union of the tibial fracture. No adverse events were observed in any of the group. Our study demonstrates that using autologous bone marrow derived mesenchymal stem cell as an add-on therapy to the ilizarov procedure shows significant clinical benefit in fixation of tibial non-union.     

Reconstruction of Achilles tendon and calcaneus defects with skin-aponeurosis-bone composite free tissue from the groin region

Eight patients had reconstructive surgery for soft-tissue, associated Achilles tendon, and calcaneus defects on the posterior aspect of the ankle. In group A, those patients with skin, soft-tissue, and Achilles tendon loss were treated with free groin flaps that included sheets of the external oblique aponeurosis based on the superficial circumflex iliac vessel. The groin flap provided skin coverage, and the aponeurosis was rolled to form a tendon-like structure to replace the Achilles tendon. In group B, those patients with an additional calcaneus bone loss were treated with free iliac osteocutaneous flaps, together with the external oblique aponeurosis based on the deep circumflex iliac vessel. The iliac bone was then utilized to reconstruct the calcaneus defect. All composite free tissue transfers were successful, except in two group B patients who suffered partial skin loss. The advantages of this technique are (1) a single, one-stage procedure, (2) faster wound healing with fewer adhesions of the reconstructed Achilles tendon, and (3) good cosmesis and minimal morbidity at the donor site.     

Vascularized rib for facial reconstruction

The reconstruction of maxillectomy defects is a complex problem encountered in plastic surgery. Defects can range in size and complexity from small defects requiring only soft tissue to complete maxillectomies requiring large tissue bulk, bone, and one or more skin paddles. The most difficult defects involve the skull base and orbit. The reconstructive surgeon is faced with the challenge of isolating the nasopharynx from the dura and globe while simultaneously restoring the bony framework of the maxilla and orbit to support the soft tissue of the cheek. The authors present a series of six reconstructions using a rectus abdominis muscle flap with associated vascularized rib for reconstruction of complex maxillectomy defects. This flap provides large soft-tissue bulk as well as bony support and a long vascular pedicle. A skin island can be taken with the flap, and the donor-site morbidity is comparable to that seen with a vertical rectus abdominis myocutaneous flap. Six flaps were used in five patients over a 20-month period. All patients had stable support of the orbit at follow-up with adequate soft-tissue coverage, and there were no incidences of visual changes.     

Fibula free flap: a new method of mandible reconstruction

The fibula was investigated as a donor site for free-flap mandible reconstruction. It has the advantages of consistent shape, ample length, distant location to allow a two-team approach, and low donor-site morbidity. It can be raised with a skin island for composite-tissue reconstruction. Twelve segmental mandibular defects (average 13.5 cm) were reconstructed following resection for tumor, most commonly epidermoid carcinoma. Five defects consisted of bone alone, and four others had only a small amount of associated intraoral soft-tissue loss. Eleven patients underwent primary reconstructions. At least two osteotomies were performed on each graft, and miniplates were used for fixation in 11 patients. Six patients received postoperative radiation, and two patients received postoperative chemotherapy. The flaps survived in all patients. All osteotomies healed primarily. The septocutaneous blood supply was generally not adequate to support a skin island for intraoral soft-tissue replacement. The aesthetic result of the reconstruction was excellent in most patients, particularly in "bone only" defects. There was no long-term donor-site morbidity.     

Reconstruction of composite through-and-through mandibular defects with a double-skin paddle fibular osteocutaneous flap

Microsurgical reconstruction of composite through-and-through defects of the oral cavity involving mucosa, bone, and external skin has often required two free flaps or double-skin paddle scapular or radial forearm flaps for successful functional and aesthetic outcomes. A safe, reliable technique using a double-skin paddle fibular osteocutaneous flap to restore the intraoral lining, mandibular bone, and external skin is described. A large elliptical or rectangular skin paddle is designed 90 degrees to the longitudinal axis of the fibula, over the junction of the middle and distal thirds of the lower leg, based only on the posterolateral septocutaneous perforators. This skin flap can be draped anteriorly and posteriorly over the fibular bone to reconstruct both the intraoral defect and the external skin defect. The area between the two skin islands of the intraoral flap and the external flap is deepithelialized and left as a dermal bridge between the two skin islands, as opposed to the creation of two separate vertical skin paddles, each based on a septocutaneous perforator. The transverse dimension of the flap can be as great as 14 cm, extending to within 1 to 2 cm of the tibial crest anteriorly and as far as the midline posteriorly, and with a length of up to 26 cm, this flap should be more than sufficient for reconstruction of most through-and-through defects. This technique has allowed the successful reconstruction of large composite defects, with missing intraoral lining, mandibular bone, and external skin, for 16 patients, with 100 percent survival of both skin islands in all cases and without the development of any orocutaneous fistulae.     

Experimental study and clinical use of the fasciosteal flap

Thirty-seven domestic rabbits, 4 dogs, and 2 freshly amputated human limbs were divided into three groups as three different models of fasciosteal flaps that were taken from the distal radii or the tibiae. Through the methods of histology, fluorochrome bone labeling, and perfusing stain, it was confirmed that viability of the bone graft can be maintained by blood flow by means of the fascial route. This technique was used for treating eight patients with nonunion of such different fractured sites as the scaphoid, the talus, and so forth or with osteomyelitic tibial defects or both skin and tibial defects. With 8 to 15 months of follow-up, the osteomyelitis cleared uneventfully and the fracture healed. Patients recovered their normal function. We think that there are at least three routes for the blood supply from deep fascia to bone: direct blood supply, blood supply by means of bone membrane, and blood supply by means of the intermuscular septum. We feel that the fasciosteal flap is an ideal random-pattern vascularized bone graft.     

Free fibula long bone reconstruction in orthopedic oncology: a surgical algorithm for reconstructive options

The fibula free flap became popular in orthopedic oncology for limb-sparing long bone tumor resection. It is particularly suitable for intercalary or resection arthrodesis options. In the present series, a surgical reconstruction algorithm was used, enabling each patient to receive a personalized technique. During the years 1998 to 2002, 30 patients underwent limb-sparing surgery for long bone sarcoma. There were 18 males and 12 females. Their mean age was 23 years (range, 9 to 70 years). The diagnoses were Ewing's sarcoma (11 patients), osteogenic sarcoma (eight patients), chondrosarcoma (five patients), giant cell tumor of bone (three patients), high-grade soft-tissue sarcoma (two patients), and leiomyosarcoma of bone (one patient). The majority of tumors where located in the lower extremity (23 patients), mostly in the femur (15 patients with four tumors in the proximal femoral shaft, five tumors in the distal femoral shaft, five tumors in the whole femoral shaft, and one tumor in the proximal femoral head). In seven patients, the upper extremity was involved; in six patients, the radius was involved; and in one patient, the humerus was involved. The free fibula flap was used in three types of approaches: vascularized fibula as an osseous flap only (18 patients), a combination of a vascularized fibula flap in conjunction with an allograft (Capanna's technique; 10 patients), and a free double-barreled fibula (two patients). All flaps survived. Postoperatively, all patients were monitored clinically, radiologically, and by radioisotope bone scan studies. Callus formation and union were shown 2.6 to 8 months postoperatively. Patients who underwent lower extremity reconstruction were nonweightbearing for 3 to 9 months, with a transition period in which they used a brace and gradually increased weightbearing until full weightbearing was achieved. Eight patients had 11 recipient-site complications. Two patients (6.7 percent) had hematomas, and three patients (10 percent) had infection and dehiscence of the surgical wound with bone exposure in one patient; all complications resolved with conservative treatment only. Failure of the hardware fixation system occurred in two patients, mandating surgical correction. No fibula donor-site complications were recorded. In intercalary resections, the use of the vascularized fibula flap as an isolated osseous flap might be insufficient. Different body sites have different stress loads to carry, depending on the age of the patient and on his individual physical status. To achieve initial strength in the early period, the authors combined the free fibula flap with an allograft (Capanna's method) or augmented it as a double-barreled fibula. They propose a surgical algorithm to assist the surgeon with the preferred method for reconstruction of various long bone defects in different body locations at childhood or adulthood. Long bone reconstruction using a vascularized fibula flap, alone or in combination with an allograft, autogenous bone graft, or double-barreled fibula for limb-sparing surgery, is a safe and reliable method with a predictable bony union, good functional outcome, and a low complication rate.     

Simultaneous reconstruction of cervical soft tissue and esophagus with a gastro-omental free flap

A microvascular transfer of gastric tube and omentum was used to simultaneously reconstruct cervical soft-tissue and esophageal defects in five patients. All patients had previous high-dose radiation and multiple flap reconstructions. The largest esophageal and soft-tissue defects were 10 cm and 160 cm2, respectively. All wounds healed primarily except for one orocutaneous fistula. There was one death from an intraoperative stroke. The gastro-omental flap is useful in cases where the reconstructive surgeon is faced with both esophageal and soft-tissue defects--particularly in heavily irradiated patients who have few reconstructive options.     

The influence of muscle flap coverage on the repair of devascularized tibial cortex: an experimental investigation in the dog

Segments (2 cm) of canine tibial diaphyseal bone were devascularized and internally fixed with a plate. The medial cortex of the devascularized tibia was covered with skin in one experimental group (n = 7) and a local muscle flap in the other (n = 6). The animals were given intravenous fluorochrome dye and killed 42 days postoperatively. Enveloping callus formed around the cortex which was repaired by the formation of resorptive cavities on its external surface. New bone formation occurred within the resorptive cavities. Muscle flap coverage was associated with a sixfold increase in cortical porosity (p less than 0.005) and a fourfold increase in the area of enveloping callus (p less than 0.05). The area of intracortical new bone formation was greater in the cortex with muscle flap coverage (p less than 0.05). The maximum depth of intracortical new bone formation increased from 0.46 +/- 0.14 mm with skin coverage to 0.95 +/- 0.14 mm with muscle flap coverage (p less than 0.001). This study demonstrates that muscle flaps are superior to skin coverage in initiating the repair of devascularized cortical bone.     

Free dorsoulnar perforator flap transfers for the reconstruction of severely injured digits

The aim of this study was to investigate the feasibility of transferring the free dorsoulnar perforator flap nourished by the cutaneous perforator branched dorsoulnar artery to reconstruct severely injured fingers under upper arm anesthesia. Between April of 2001 and April of 2002, 13 free dorsoulnar perforator flaps were used in 13 patients. There were 11 men and two women ranging in age from 18 to 64 years, with an average age of 38 years. The affected fingers were one thumb, four index fingers, five middle fingers, two ring fingers, and one little finger. All cases were performed under upper arm anesthesia combined with intravenous local anesthesia. The operative time ranged from 103 to 140 minutes, with an average time of 120 minutes. The flap size ranged from 1 x 3 to 3 x 4 cm, and was transferred from the same forearm of the injured finger. All donor sites were closed primarily without a skin graft. The aim of reconstruction for fingers was to repair a traumatic defect (five cases), partial necrosis following replantation (two cases), and soft-tissue defects resulting from resection of a scar (three cases) and to revascularize ischemic fingers (three cases). All flaps survived completely. After repair of the flow-through circulation of the common digital artery and ischemic finger, a postoperative angiogram showed the vascular patency and hypervascularity of the reconstructed fingers, and the patients' complaints were reduced. The free dorsoulnar perforator flap under regional anesthesia is first reported; it may become one valuable option as a very small flap for the treatment of repairing intercalated or segmental defects as a flow-through flap for soft-tissue defects and ischemic fingers.