Protective Effect of Administration of Skim Milk on Exogenous and Endogenous Infection in Mice

In order to minimize the denaturation of proteins in milk, normal cow's milk was pasteurized at 61 C for 20 min. The protective effects of the thus prepared skim milk (low-heat skim milk) on exogenous and endogenous infection were examined as compared with conventional skim milk which was pasteurized at 121 C for 2 sec. The antibody titers to Listeria monocytogenes and Escherichia coli of low-heat skim milk were almost equal to that of raw milk, while no antibody was detected in the conventional skim milk. When mice were given low-heat skim milk or conventional skim milk, the incidence of the translocation of orally inoculated Listeria monocytogenes to the spleen was lower in the low-heat skim milk group than that in the conventional skim milk group. The life span of 7 Gy X-ray irradiated mice given low-heat skim milk was significantly prolonged in comparison to that of mice given conventional skim milk. However, there were no differences in the number of bacteria in the feces or IgA production by Peyer's patch cells between the two groups. These results suggest that antibodies in low-heat skim milk, which still have reactivity to exogenous or indigenous bacteria, may contribute to the protective effects against bacterial infection.     

Potential application of the nisin Z preparation of Lactococcus lactis W8 in preservation of milk

Aims: The aim of the study is to evaluate the effectiveness of the preparation of nisin Z from Lactococcus lactis W8‐fermented milk in controlling the growth of spoilage bacteria in pasteurized milk. Methods and Results: Spoilage bacteria isolated from pasteurized milk at 8 and 15°C were identified as Enterococcus italicus, Enterococcus mundtii, Enterococcus faecalis, Bacillus thuringiensis, Bacillus cereus, Lactobacillus paracasei, Acinetobacter sp., Pseudomonas fluorescens and Enterobacter aerogenes. These bacteria were found to have the ability to survive pasteurization temperature. Except Enterobacter aerogenes, the spoilage bacteria were sensitive to the nisin Z preparation of the L. lactis W8. Addition of the nisin Z preparation to either the skim milk or fat milk inoculated with each of the spoilage bacteria reduced the initial counts (about 5 log CFU ml^?1) to an undetectable level within 8–20 h. The nisin Z preparation extended the shelf life of milk to 2 months under refrigeration. Conclusions: The nisin Z preparation from L. lactis W8‐fermented milk was found to be effective as a backup preservative to counteract postpasteurization contamination in milk. Significance and Impact of the Study: A rapid inhibition of spoilage bacteria in pasteurized skim and fat milk with the nisin Z preparation of L. lactis W8 is more significant in comparison with the commercially available nisin (nisin A). The nisin Z preparation can be used instead of commercial nisin, which is not effective in fat milk.     

Classification of the spoilage flora of raw and pasteurized bovine milk, with special reference to Pseudomonas and Bacillus

Eighty-one bacterial strains isolated from refrigerated raw milk, 124 from pasteurized milk and cream stored at 5°C and 7°C, and 19 type and reference strains of Pseudomonas spp. and Bacillus spp. were characterized by numerical phenotypic analysis. Data were processed with simple matching ( S _SM) and Jaccard ( S _J) coefficients, and UPGMA clustering. Fourteen clusters of Gram-negative bacteria were formed at S _J= 79% ( S _SM= 90%). Raw milk was exclusively spoilt by Gram-negative bacteria, the majority of which were Pseudomonas fluorescens biovar I, Ps. fragi, Ps. lundensis and Ps. fluorescens biovar III. Minor groups in raw milk included Enterobacteriaceae spp. and Acinetobacter spp. Pasteurized milk was spoilt by essentially the same Gram-negative organisms in 65% (5°C) and 50% (7°C) of the cases. The phenotypic characteristics of Gram-negative bacteria are given. Bacillus polymyxa (both temperatures) and B. cereus (only at 7°C) were responsible for 77% of samples spoiled by the Gram-positive organisms. Minor milk spoilage groups included other Bacillus spp. and lactic acid bacteria. All Bacillus spp. grew fermentatively in milk, and most strains denitrified. It is suggested that: (i) industrial recontamination tests of pasteurized milk are directed against Pseudomonas; (ii) milk is stored at 5°C or lower to avoid growth of B. cereus ; and (iii) the significance of gas-producing and nitrate/nitrite-reducing Bacillus strains is recognized in cheese production.     

Rapid Enumeration of Bacteria in Heat-treated Milk and Milk Products Using a Membrane Filtration-Epifluorescent Microscopy Technique

A rapid direct epifluorescent filter technique (DEFT), taking ca. 20 min to complete, was used to enumerate bacteria in heat-treated milk and milk-products. The DEFT count could detect as few as 5750 bacteria/ml in pasteurized and skim milk, pasteurized cream, whey and sweet cream butter and was in agreement with the standard plate count. The technique was also used to determine the sterility of cartoned ultra heat-treated milk after incubation at 37°C. The agreement between the DEFT and plate count was poor for evaporated and condensed milks, some reconstituted skim milk powders, pasteurized whey and ripened cream butter. Possible reasons for this are discussed.     

Effect of commercial-scale high-temperature, short-time pasteurization on the viability of Mycobacterium paratuberculosis in naturally infected cows' milk

Raw cows' milk naturally infected with Mycobacterium paratuberculosis was pasteurized with an APV HXP commercial-scale pasteurizer (capacity 2,000 liters/h) on 12 separate occasions. On each processing occasion, milk was subjected to four different pasteurization treatments, viz., 73 degrees C for 15 s or 25 s with and without prior homogenization (2,500 lb/in(2) in two stages), in an APV Manton Gaulin KF6 homogenizer. Raw and pasteurized milk samples were tested for M. paratuberculosis by immunomagnetic separation (IMS)-PCR (to detect the presence of bacteria) and culture after decontamination with 0.75% (wt/vol) cetylpyridinium chloride for 5 h (to confirm bacterial viability). On 10 of the 12 processing occasions, M. paratuberculosis was detectable by IMS-PCR, culture, or both in either raw or pasteurized milk. Overall, viable M. paratuberculosis was cultured from 4 (6.7%) of 60 raw and 10 (6.9%) of 144 pasteurized milk samples. On one processing day, in particular, M. paratuberculosis appeared to have been present in greater abundance in the source raw milk (evidenced by more culture positives and stronger PCR signals), and on this occasion, surviving M. paratuberculosis bacteria were isolated from milk processed by all four heat treatments, i.e., 73 degrees C for 15 and 25 s with and without prior homogenization. On one other occasion, surviving M. paratuberculosis bacteria were isolated from an unhomogenized milk sample that had been heat treated at 73 degrees C for 25 s. Results suggested that homogenization increases the lethality of subsequent heat treatment to some extent with respect to M. paratuberculosis, but the extended 25-s holding time at 73 degrees C was found to be no more effective at killing M. paratuberculosis than the standard 15-s holding time. This study provides clear evidence that M. paratuberculosis bacteria in naturally infected milk are capable of surviving commercial high-temperature, short-time pasteurization if they are present in raw milk in sufficient numbers.     

An advanced PCR method for the specific detection of viable total coliform bacteria in pasteurized milk

Pasteurized milk is a complex food that contains various inhibitors of polymerase chain reaction (PCR) and may contain a large number of dead bacteria, depending on the milking conditions and environment. Ethidium monoazide bromide (EMA)-PCR is occasionally used to distinguish between viable and dead bacteria in foods other than pasteurized milk. EMA is a DNA-intercalating dye that selectively permeates the compromised cell membranes of dead bacteria and cleaves DNA. Usually, EMA-PCR techniques reduce the detection of dead bacteria by up to 3.5 logs compared with techniques that do not use EMA. However, this difference may still be insufficient to suppress the amplification of DNA from dead Gram-negative bacteria (e.g., total coliform bacteria) if they are present in pasteurized milk in large numbers. Thus, false positives may result. We developed a new method that uses real-time PCR targeting of a long DNA template (16S-23S rRNA gene, principally 2,451?bp) following EMA treatment to completely suppress the amplification of DNA of up to 7?logs (10(7)?cells) of dead total coliforms. Furthermore, we found that a low dose of proteinase K (25?U/ml) removed PCR inhibitors and simultaneously increased the signal from viable coliform bacteria. In conclusion, our simple protocol specifically detects viable total coliforms in pasteurized milk at an initial count of ≥1?colony forming unit (CFU)/2.22?ml within 7.5?h of total testing time. This detection limit for viable cells complies with the requirements for the analysis of total coliforms in pasteurized milk set by the Japanese Sanitation Act (which specifies <1?CFU/2.22?ml).     

Real-time PCR detection of Paenibacillus spp. in raw milk to predict shelf life performance of pasteurized fluid milk products

Psychrotolerant sporeformers, specifically Paenibacillus spp., are important spoilage bacteria for pasteurized, refrigerated foods such as fluid milk. While Paenibacillus spp. have been isolated from farm environments, raw milk, processing plant environments, and pasteurized fluid milk, no information on the number of Paenibacillus spp. that need to be present in raw milk to cause pasteurized milk spoilage was available. A real-time PCR assay targeting the 16S rRNA gene was designed to detect Paenibacillus spp. in fluid milk and to discriminate between Paenibacillus and other closely related spore-forming bacteria. Specificity was confirmed using 16 Paenibacillus and 17 Bacillus isolates. All 16 Paenibacillus isolates were detected with a mean cycle threshold (C(T)) of 19.14 ± 0.54. While 14/17 Bacillus isolates showed no signal (C(T) > 40), 3 Bacillus isolates showed very weak positive signals (C(T) = 38.66 ± 0.65). The assay provided a detection limit of approximately 3.25 × 10(1) CFU/ml using total genomic DNA extracted from raw milk samples inoculated with Paenibacillus. Application of the TaqMan PCR to colony lysates obtained from heat-treated and enriched raw milk provided fast and accurate detection of Paenibacillus. Heat-treated milk samples where Paenibacillus (≥1 CFU/ml) was detected by this colony TaqMan PCR showed high bacterial counts (>4.30 log CFU/ml) after refrigerated storage (6°C) for 21 days. We thus developed a tool for rapid detection of Paenibacillus that has the potential to identify raw milk with microbial spoilage potential as a pasteurized product.     

Antimicrobial Action of Some Citrus Fruit Oils on Selected Food-Borne Bacteria

The antimicrobial properties of essential oils, terpineol, and orange oil, in particular, varied according to the type of bacteria tested. Terpineol and other terpeneless fractions of citrus oils appeared to have greater inhibitory effect on food-borne bacteria than the other citrus oils or derivatives. Gram-positive bacteria were, in general, more sensitive to essential oils than gram-negative bacteria. Terpineol extended the shelf life of commercially pasteurized skim milk, low-fat milk, and whole milk for more than 56 days at 4 C. Orange oil extended the shelf life of skim milk and low-fat milk for the same period.     

THE RATES OF GROWTH OF SOME THERMODURIC BACTERIA IN PURE CULTURE AND THEIR EFFECTS ON TESTS FOR THE KEEPING QUALITY OF MILK

SUMMARY: The growth rates of eleven representative thermoduric bacteria, comprising 3 aerobic spore formers, 3 streptococci, 1 Corynebacterium lacticum and 4 micrococci, have been determined in glucose broth and sterile pasteurized milk at 37·5°, 26° and 15°. The spore formers and streptococci were generally not affected by the presence of inhibitory factors in pasteurized milk. When multiplication of micrococci and C. lacticum occurred in milk this was only after a lag period. One micrococcus showed an unusual series of growth phases in glucose broth at 37·5°, possibly due to the appearance of mutants or to adaptation of the organism to growth at that temperature. This was not observed in pasteurized milk. C. lacticum died off when incubated in glucose broth at 37·5°.
None of the keeping quality tests was more effective than any other in detecting these organisms in milk. The micrococci and C. lacticum had little effect on the keeping quality of pasteurized milk within the period of 'commercial life'. Some of the spore formers and streptococci showed marked differences in the end-points with the clot-on-boiling and the alcohol precipitation tests.     

An attempt to improve the flavour of 'nono' by the use of starter cultres

Three close-fitting lid fermenters were incubated at 27 ± 2°C for 120 h. 'A' served as a control and contained 100 ml raw goats' milk; 'B' contained 50 ml 48-h-old nono as starter culture plus 50 ml pasteurized milk; and 'C' contained 100 ml pasteurized milk only. The pH and lactic acid contents were determined at intervals. Fermenter 'B' gave the best results in that the milk reached the lowest pH values and the highest lactic acid contents, and this resulted in a more appetizing and bitter product.     

The cytochrome c oxidase test for the rapid detection of psychrotrophic bacteria in milk

A new, rapid, simple and cheap method for the detection of the predominant psychrotrophic bacteria in raw and pasteurized milks is described, using tetramethyl- p -phenylene-diamine dihydrochloride to detect cytochrome c oxidase which in general is not present in the non-psychrotrophic bacterial milk flora. The test is sensitive to samples containing over 10⁴ organisms/ml. Correlation coefficients of 0.92 and 0.84 between dye oxidation and viable counts for pasteurized and raw milk samples, respectively, were found.     

Use of the Direct Epifluorescent Filter Technique for predicting the keeping quality of pasteurized milk within 24 hours

The keeping quality (KQ) of pasteurized milk stored at 5°C and 11°C was predicted within 24 h by pre-incubating samples and counting bacteria by the Direct Epifluorescent Filter Technique (DEFT). For samples from 5°C storage, 0.03% (w/v) benzalkonium chloride and 0.002% (w/v) crystal violet (final concentration) were added to inhibit the growth of Gram positive bacteria during pre-incubation. The samples from milk stored at 11°C were pre-incubated without the addition of inhibitors. After pre-incubation there was a satisfactory relationship between the DEFT count and the KQ of milks at both 5°C and 11°C. The DEFT count following pre-incubation correctly classified > 80% of pasteurized milks on the basis of KQ.     

Anti-hypertensive activity of fermented dairy products containing biogenic peptides

A considerable amount of research has been conducted to study the health benefits of fermented milks. One possible mechanism for the beneficial effects is the involvement of biogenic compounds, which are produced by the action of microorganisms and make the products directly beneficial without the need for live bacteria. Research on the health effects of a pasteurized sour milk, which is fermented by a starter culture containing Lactobacillus helveticus as the predominant microorganism, indicated clear evidence for the involvement of biogenic compounds. In this paper, beneficial effects of sour milk are reviewed with special attention to the effect on anti-hypertension and angiotensin-I converting enzyme inhibitory peptides identified in sour milk.     

Use of the Direct Epifluorescent Filter Technique for predicting the keeping quality of pasteurized milk within 24 hours

The keeping quality (KQ) of pasteurized milk stored at 5 degrees C and 11 degrees C was predicted within 24 h by pre-incubating samples and counting bacteria by the Direct Epifluorescent Filter Technique (DEFT). For samples from 5 degrees C storage, 0.03% (w/v) benzalkonium chloride and 0.002% (w/v) crystal violet (final concentration) were added to inhibit the growth of Gram positive bacteria during pre-incubation. The samples from milk stored at 11 degrees C were pre-incubated without the addition of inhibitors. After pre-incubation there was a satisfactory relationship between the DEFT count and the KQ of milks at both 5 degrees C and 11 degrees C. The DEFT count following pre-incubation correctly classified greater than 80% of pasteurized milks on the basis of KQ.     

Effect of Commercial-Scale High-Temperature, Short-Time Pasteurization on the Viability of Mycobacterium paratuberculosis in Naturally Infected Cows' Milk

Raw cows' milk naturally infected with Mycobacterium paratuberculosis was pasteurized with an APV HXP commercial-scale pasteurizer (capacity 2,000 liters/h) on 12 separate occasions. On each processing occasion, milk was subjected to four different pasteurization treatments, viz., 73°C for 15 s or 25 s with and without prior homogenization (2,500 lb/in² in two stages), in an APV Manton Gaulin KF6 homogenizer. Raw and pasteurized milk samples were tested for M. paratuberculosis by immunomagnetic separation (IMS)-PCR (to detect the presence of bacteria) and culture after decontamination with 0.75% (wt/vol) cetylpyridinium chloride for 5 h (to confirm bacterial viability). On 10 of the 12 processing occasions, M. paratuberculosis was detectable by IMS-PCR, culture, or both in either raw or pasteurized milk. Overall, viable M. paratuberculosis was cultured from 4 (6.7%) of 60 raw and 10 (6.9%) of 144 pasteurized milk samples. On one processing day, in particular, M. paratuberculosis appeared to have been present in greater abundance in the source raw milk (evidenced by more culture positives and stronger PCR signals), and on this occasion, surviving M. paratuberculosis bacteria were isolated from milk processed by all four heat treatments, i.e., 73°C for 15 and 25 s with and without prior homogenization. On one other occasion, surviving M. paratuberculosis bacteria were isolated from an unhomogenized milk sample that had been heat treated at 73°C for 25 s. Results suggested that homogenization increases the lethality of subsequent heat treatment to some extent with respect to M. paratuberculosis, but the extended 25-s holding time at 73°C was found to be no more effective at killing M. paratuberculosis than the standard 15-s holding time. This study provides clear evidence that M. paratuberculosis bacteria in naturally infected milk are capable of surviving commercial high-temperature, short-time pasteurization if they are present in raw milk in sufficient numbers.     

Germination of Spores of Bacillus cereus in Milk and Milk Dialysates: Effect of Heat Treatment

S ummary . The germination of spores of Bacillus cereus was studied in milk and in media consisting of the low M.W. fraction of milk. Dialysates, centrifugates, filtrates and acid whey supported germination to an extent similar to that in the milk from which they were derived. HTST (72° for 15 sec) pasteurized milk or derived media supported appreciable germination whereas raw milk or media derived from it supported little or none. Whey produced by the action of rennet was an exception in that it was equally stimulatory for germination whether derived from raw or pasteurized milk. Heat treatments for 15 see using temperatures between 65–75° rendered the milk most suitable as a germination medium but temperatures > 80° were necessary for spore activation. Of the 2 effects, activation was the more important; at treatment temperatures > 80° germination was increased despite the less favourable medium which resulted. The extent of germination in pasteurized milk varied with different isolates and could be related to their source, those from pasteurized milk germinating the most readily. The practical implications of these findings are discussed together with the preliminary work to examine the nature of the germination factor(s) produced during HTST pasteurization.     

The cytochrome c oxidase test for the rapid detection of psychrotrophic bacteria in milk

A new, rapid, simple and cheap method for the detection of the predominant psychrotrophic bacteria in raw and pasteurized milks is described, using tetramethyl-p-phenylene-diamine dihydrochloride to detect cytochrome c oxidase which in general is not present in the non-psychrotrophic bacterial milk flora. The test is sensitive to samples containing over 10(4) organisms/ml. Correlation coefficients of 0.92 and 0.84 between dye oxidation and viable counts for pasteurized and raw milk samples, respectively, were found.     

Influence of storage conditions on the growth of Pseudomonas species in refrigerated raw milk

The refrigerated storage of raw milk throughout the dairy chain prior to heat treatment creates selective conditions for growth of psychrotolerant bacteria. These bacteria, mainly belonging to the genus Pseudomonas, are capable of producing thermoresistant extracellular proteases and lipases, which can cause spoilage and structural defects in pasteurized and ultra-high-temperature-treated milk (products). To map the influence of refrigerated storage on the growth of these pseudomonads, milk samples were taken after the first milking turn and incubated laboratory scale at temperatures simulating optimal and suboptimal preprocessing storage conditions. The outgrowth of Pseudomonas members was monitored over time by means of cultivation-independent denaturing gradient gel electrophoresis (DGGE). Isolates were identified by a polyphasic approach. These incubations revealed that outgrowth of Pseudomonas members occurred from the beginning of the dairy chain (farm tank) under both optimal and suboptimal storage conditions. An even greater risk for outgrowth, as indicated by a vast increase of about 2 log CFU per ml raw milk, existed downstream in the chain, especially when raw milk was stored under suboptimal conditions. This difference in Pseudomonas outgrowth between optimal and suboptimal storage was already statistically significant within the farm tank. The predominant taxa were identified as Pseudomonas gessardii, Pseudomonas gessardii-like, Pseudomonas fluorescens-like, Pseudomonas lundensis, Pseudomonas fragi, and Pseudomonas fragi-like. Those taxa show an important spoilage potential as determined on elective media for proteolysis and lipolysis.     

Determining the source of Bacillus cereus and Bacillus licheniformis isolated from raw milk, pasteurized milk and yoghurt

Aims:  Strain-specific detection of Bacillus cereus and Bacillus licheniformi s in raw and pasteurized milk, and yoghurt during processing.
Methods and Results:  Randomly selected isolates of Bacillus spp. were subjected to PCR analysis, where single primer targeting to the repetitive sequence Box elements was used to fingerprint the species. The isolates were separated into six different fingerprint patterns. The results show that isolates clustered together at about the 57% similarity level with two main groups at the 82% and 83% similarity levels, respectively. Contamination with identical strains both of B. cereus and B . licheniformis in raw and pasteurized milk was found as well as contaminated with different strains (in the case of raw milk and yoghurt/pasteurized milk and yoghurt). Several BOX types traced in processed milk samples were not discovered in the original raw milk.
Conclusions:  BOX-PCR fingerprinting is useful for characterizing Bacillus populations in a dairy environment. It can be used to confirm environmental contamination, eventually clonal transfer of Bacillus strains during the technological processing of milk.
Significance and Impact of the Study:  Despite the limited number of strains analysed, the two Bacillus species yielded adequately detectable banding profiles, permitting differentiation of bacteria at the strain level and showing their diversity throughout dairy processing.     

The incidence of Yersinia enterocolitica and Yersinia enterocolitica-like organisms in raw and pasteurized milk in Northern Ireland

Yersinia enterocolitica and Y. enterocolitica-like bacteria were frequently isolated from samples of both raw bulked milk (34/150) and farm bottled (raw) milk (5/20). These bacteria were also found to contaminate creamery pasteurized milk (6/100 samples) and farm pasteurized milk (4/50 samples). Although Y. enterocolitica was the most commonly isolated species, Y. intermedia and Y. frederiksenii were also frequently obtained (52, 31 and 15% of isolates, respectively). Also, one atypical strain was identified as Y. aldovae. The Y. enterocolitica strains were largely biotype 1 (20/27) including five strains which could ferment lactose. One third of the Y. enterocolitica strains were not typable, but of those which were, the serotypes were 0:34 (18.5%), 0:5.27 (18.5%), 0:6.3 (15%), 0:4 (11%) and 0:7 (4%). Pre-enrichment in trypticase-soy broth (TSB) (at 22 degrees C for 24 h) followed by selective enrichment in bile-oxalate-sorbose broth (at 22 degrees C for 6 d) allowed the recovery of 92.3% of all isolates, as compared with 15.4% using cold enrichment in TSB at 4 degrees C for 21 d.