Induction of xylulose-5-phosphate phosphoketolase in a variety of yeasts grown ond-xylose: the key to efficient xylose metabolism

Activity of a pentulose (xylulose 5-phosphate) phosphoketolase was detected in 20 out of 25 yeasts examined. No significant activity was detected in any yeast grown with glucose, and the enzyme was induced by up to 70-fold when the yeasts were grown on xylose as sole carbon source. Biomass yields from xylose were greater than, or approximately equal to, those from glucose in 15 of the 19 yeasts which possessed phosphoketolase activity. The molar yield of C₂ units from xylose, by metabolism via the pentose phosphate pathway, can be calculated to be insufficient to account for the high yields of biomass and ethanol obtained from xylose. We have shown that the presence of a phosphoketolase system can account for such yields by producing 2 mol C₂ from 1 mol C₅. This pathway must therefore be regarded as a major route of pentose dissimilation in such yeasts.     

Metabolic characterization and transformation of the non‐dairy Lactococcus lactis strain KF147, for production of ethanol from xylose

The non‐dairy lactic acid bacterium Lactococcus lactis KF147 can utilize xylose as the sole energy source. To assess whether KF147 could serve as a platform organism for converting second generation sugars into useful chemicals, the authors characterized growth and product formation for KF147 when grown on xylose. In a defined medium KF147 was found to co‐metabolize xylose and arginine, resulting in bi‐phasic growth. Especially at low xylose concentrations, arginine significantly improved growth rate. To facilitate further studies of the xylose metabolism, the authors eliminated arginine catabolism by deleting the arcA gene encoding the arginine deiminase. The fermentation product profile suggested two routes for xylose degradation, the phosphoketolase pathway and the pentose phosphate pathway. Inactivation of the phosphoketolase pathway redirected the entire flux through the pentose phosphate pathway whereas over‐expression of phosphoketolase increased the flux through the phosphoketolase pathway. In general, significant amounts of the mixed‐acid products, including lactate, formate, acetate and ethanol, were formed irrespective of xylose concentrations. To demonstrate the potential of KF147 for converting xylose into useful chemicals the authors chose to redirect metabolism towards ethanol production. A synthetic promoter library was used to drive the expression of codon‐optimized versions of the Zymomonas mobilis genes encoding pyruvate decarboxylase and alcohol dehydrogenase, and the outcome was a strain producing ethanol as the sole fermentation product with a high yield corresponding to 83% of the theoretical maximum. The results clearly indicate the great potential of using the more metabolically diverse non‐dairy L. lactis strains for bio‐production based on xylose containing feedstocks.     

d-Xylose catabolism in Bacteroides xylanolyticus X5-1

The xylose metabolism of Bacteroides xylanolyticus X5-1 was studied by determining specific enzyme activities in cell free extracts, by following ¹³C-label distribution patterns in growing cultures and by mass balance calculations. Enzyme activities of the pentose phosphate pathway and the Embden-Meyerhof-Parnas pathway were sufficiently high to account for in vivo xylose fermentation to pyruvate via a combination of these two pathways. Pyruvate was mainly oxidized to acetyl-CoA, CO₂ and a reduced cofactor (ferredoxin). Part of the pyruvate was converted to acetyl-CoA and formate by means of a pyruvate-formate lyase. Acetyl-CoA was either converted to acetate by a combined action of phosphotransacetylase and acetate kinase or reduced to ethanol by an acetaldehyde dehydrogenase and an ethanol dehydrogenase. The latter two enzymes displayed both a NADH- and a NADPH-linked activity. Cofactor regeneration proceeded via a reduction of intermediates of the metabolism (i.e. acetyl-CoA and acetaldehyde) and via proton reduction. According to the deduced pathway about 2.5 mol ATP are generated per mol of xylose degraded.Abbreviations PPP Pentose phosphate pathway - PKP phosphoketolase pathway     

Metabolic flux analysis of Candida tropicalis growing on xylose in an oxygen-limited chemostat

We have studied the metabolism of xylose by Candida tropicalis in oxygen-limited chemostat. In vitro enzyme assays indicated that glycolytic and gluconeogenetic enzymes are expressed simultaneously facilitating substrate cycling. Enhancing the redox imbalance by cofeeding of formate increased xylose and oxygen consumption rates and ethanol, xylitol, glycerol and CO2 production rates at steady state. Metabolic flux analysis (MFA) indicated that fructose 6-phosphate is replenished from the pentose phosphate pathway in sufficient amounts without contribution of the gluconeogenetic pathway. Substrate cycling between pyruvate kinase, pyruvate carboxylase and phospho-enol-pyruvate kinase increased ATP turnover. Cofeeding of formate increased the ATP yield. The ATP yields of xylose and xylose-formate cultivation were 6.9 and 8.7 mol ATP/C-mol CDW, respectively, as calculated from the MFA.     

Hierarchy in Pentose Sugar Metabolism in Clostridium acetobutylicum

Bacterial metabolism of polysaccharides from plant detritus into acids and solvents is an essential component of the terrestrial carbon cycle. Understanding the underlying metabolic pathways can also contribute to improved production of biofuels. Using a metabolomics approach involving liquid chromatography-mass spectrometry, we investigated the metabolism of mixtures of the cellulosic hexose sugar (glucose) and hemicellulosic pentose sugars (xylose and arabinose) in the anaerobic soil bacterium Clostridium acetobutylicum. Simultaneous feeding of stable isotope-labeled glucose and unlabeled xylose or arabinose revealed that, as expected, glucose was preferentially used as the carbon source. Assimilated pentose sugars accumulated in pentose phosphate pathway (PPP) intermediates with minimal flux into glycolysis. Simultaneous feeding of xylose and arabinose revealed an unexpected hierarchy among the pentose sugars, with arabinose utilized preferentially over xylose. The phosphoketolase pathway (PKP) provides an alternative route of pentose catabolism in C. acetobutylicum that directly converts xylulose-5-phosphate into acetyl-phosphate and glyceraldehyde-3-phosphate, bypassing most of the PPP. When feeding the mixture of pentose sugars, the labeling patterns of lower glycolytic intermediates indicated more flux through the PKP than through the PPP and upper glycolysis, and this was confirmed by quantitative flux modeling. Consistent with direct acetyl-phosphate production from the PKP, growth on the pentose mixture resulted in enhanced acetate excretion. Taken collectively, these findings reveal two hierarchies in clostridial pentose metabolism: xylose is subordinate to arabinose, and the PPP is used less than the PKP.     

Construction of a constitutively expressed homo-fermentative pathway in Lactobacillus brevis

Lactobacillus brevis is a promising lactic acid producing strain that simultaneously utilizes glucose and xylose from lignocellulosic hydrolysate without carbon catabolic repression and inhibition. The production of by-products acetic acid and ethanol has been the major drawback of this strain. Two genes, pfkA (fructose-6-phosphate kinase [PFK]) and fbaA (fructose-1,6-biphosphate aldolase [FBA]), that encode the key enzymes of the EMP/glycolytic pathway from Lactobacillus rhamnosus, were fused to the downstream of the strong promoter P32 and expressed in L. brevis s3f4 as a strategy to minimize the formation of by-products. By expressing the two enzymes, a homo-fermentative pathway for lactic acid production was constructed. The lactic acid yields achieved from glucose in the transformants were 1.12 and 1.16 mol/mol, which is higher than that of the native strain (0.74 mol/mol). However, the lactic acid yield from xylose in the transformants stayed the same as that of the native strain. Enzyme assay indicated that the activity of the foreign protein FBA in the transformants was much higher than that of the native strains, but was ten times lower than that in L. rhamnosus. This result was consistent with the metabolic flux analysis, which indicated that the conversion efficiency of the expressed PFK and FBA was somewhat low. Less than 20 % of the carbons accumulated in the form of fructose-6-phosphate were converted into glyceraldehyde-3-phosphate (GAP) by the expressed PFK and FBA. Metabolic flux analysis also indicated that the enzyme phosphoketolase (XPK) played an important role in splitting the carbon flow from the pentose phosphate pathway to the phosphoketolase pathway. This study suggested that the lactic acid yield of L. brevis could be improved by constructing a homo-fermentative pathway.     

Altered fermentative metabolism in Chlamydomonas reinhardtii mutants lacking pyruvate formate lyase and both pyruvate formate lyase and alcohol dehydrogenase

Chlamydomonas reinhardtii, a unicellular green alga, often experiences hypoxic/anoxic soil conditions that activate fermentation metabolism. We isolated three Chlamydomonas mutants disrupted for the pyruvate formate lyase (PFL1) gene; the encoded PFL1 protein catalyzes a major fermentative pathway in wild-type Chlamydomonas cells. When the pfl1 mutants were subjected to dark fermentative conditions, they displayed an increased flux of pyruvate to lactate, elevated pyruvate decarboxylation, ethanol accumulation, diminished pyruvate oxidation by pyruvate ferredoxin oxidoreductase, and lowered H(2) production. The pfl1-1 mutant also accumulated high intracellular levels of lactate, succinate, alanine, malate, and fumarate. To further probe the system, we generated a double mutant (pfl1-1 adh1) that is unable to synthesize both formate and ethanol. This strain, like the pfl1 mutants, secreted lactate, but it also exhibited a significant increase in the levels of extracellular glycerol, acetate, and intracellular reduced sugars and a decrease in dark, fermentative H(2) production. Whereas wild-type Chlamydomonas fermentation primarily produces formate and ethanol, the double mutant reroutes glycolytic carbon to lactate and glycerol. Although the metabolic adjustments observed in the mutants facilitate NADH reoxidation and sustained glycolysis under dark, anoxic conditions, the observed changes could not have been predicted given our current knowledge of the regulation of fermentation metabolism.     

Phosphoketolase Pathway for Xylose Catabolism in Clostridium acetobutylicum Revealed by 13C Metabolic Flux Analysis

Solvent-producing clostridia are capable of utilizing pentose sugars, including xylose and arabinose; however, little is known about how pentose sugars are catabolized through the metabolic pathways in clostridia. In this study, we identified the xylose catabolic pathways and quantified their fluxes in Clostridium acetobutylicum based on [1-(13)C]xylose labeling experiments. The phosphoketolase pathway was found to be active, which contributed up to 40% of the xylose catabolic flux in C. acetobutylicum. The split ratio of the phosphoketolase pathway to the pentose phosphate pathway was markedly increased when the xylose concentration in the culture medium was increased from 10 to 20 g liter(-1). To our knowledge, this is the first time that the in vivo activity of the phosphoketolase pathway in clostridia has been revealed. A phosphoketolase from C. acetobutylicum was purified and characterized, and its activity with xylulose-5-P was verified. The phosphoketolase was overexpressed in C. acetobutylicum, which resulted in slightly increased xylose consumption rates during the exponential growth phase and a high level of acetate accumulation.     

Crystal Structures of Phosphoketolase: THIAMINE DIPHOSPHATE-DEPENDENT DEHYDRATION MECHANISM*

Thiamine diphosphate (ThDP)-dependent enzymes are ubiquitously present in all organisms and catalyze essential reactions in various metabolic pathways. ThDP-dependent phosphoketolase plays key roles in the central metabolism of heterofermentative bacteria and in the pentose catabolism of various microbes. In particular, bifidobacteria, representatives of beneficial commensal bacteria, have an effective glycolytic pathway called bifid shunt in which 2.5 mol of ATP are produced per glucose. Phosphoketolase catalyzes two steps in the bifid shunt because of its dual-substrate specificity; they are phosphorolytic cleavage of fructose 6-phosphate or xylulose 5-phosphate to produce aldose phosphate, acetyl phosphate, and H₂O. The phosphoketolase reaction is different from other well studied ThDP-dependent enzymes because it involves a dehydration step. Although phosphoketolase was discovered more than 50 years ago, its three-dimensional structure remains unclear. In this study we report the crystal structures of xylulose 5-phosphate/fructose 6-phosphate phosphoketolase from Bifidobacterium breve. The structures of the two intermediates before and after dehydration (α,β-dihydroxyethyl ThDP and 2-acetyl-ThDP) and complex with inorganic phosphate give an insight into the mechanism of each step of the enzymatic reaction.     

Metabolic Engineering of a Phosphoketolase Pathway for Pentose Catabolism in Saccharomyces cerevisiae

Low ethanol yields on xylose hamper economically viable ethanol production from hemicellulose-rich plant material with Saccharomyces cerevisiae. A major obstacle is the limited capacity of yeast for anaerobic reoxidation of NADH. Net reoxidation of NADH could potentially be achieved by channeling carbon fluxes through a recombinant phosphoketolase pathway. By heterologous expression of phosphotransacetylase and acetaldehyde dehydrogenase in combination with the native phosphoketolase, we installed a functional phosphoketolase pathway in the xylose-fermenting Saccharomyces cerevisiae strain TMB3001c. Consequently the ethanol yield was increased by 25% because less of the by-product xylitol was formed. The flux through the recombinant phosphoketolase pathway was about 30% of the optimum flux that would be required to completely eliminate xylitol and glycerol accumulation. Further overexpression of phosphoketolase, however, increased acetate accumulation and reduced the fermentation rate. By combining the phosphoketolase pathway with the ald6 mutation, which reduced acetate formation, a strain with an ethanol yield 20% higher and a xylose fermentation rate 40% higher than those of its parent was engineered.     

Pyruvate formate lyase and acetate kinase are essential for anaerobic growth of Escherichia coli on xylose

During anaerobic growth of bacteria, organic intermediates of metabolism, such as pyruvate or its derivatives, serve as electron acceptors to maintain the overall redox balance. Under these conditions, the ATP needed for cell growth is derived from substrate-level phosphorylation. In Escherichia coli, conversion of glucose to pyruvate yields 2 net ATPs, while metabolism of a pentose, such as xylose, to pyruvate only yields 0.67 net ATP per xylose due to the need for one (each) ATP for xylose transport and xylulose phosphorylation. During fermentative growth, E. coli produces equimolar amounts of acetate and ethanol from two pyruvates, and these reactions generate one additional ATP from two pyruvates (one hexose equivalent) while still maintaining the overall redox balance. Conversion of xylose to acetate and ethanol increases the net ATP yield from 0.67 to 1.5 per xylose. An E. coli pfl mutant lacking pyruvate formate lyase cannot convert pyruvate to acetyl coenzyme A, the required precursor for acetate and ethanol production, and could not produce this additional ATP. E. coli pfl mutants failed to grow under anaerobic conditions in xylose minimal medium without any negative effect on their survival or aerobic growth. An ackA mutant, lacking the ability to generate ATP from acetyl phosphate, also failed to grow in xylose minimal medium under anaerobic conditions, confirming the need for the ATP produced by acetate kinase for anaerobic growth on xylose. Since arabinose transport by AraE, the low-affinity, high-capacity, arabinose/H+ symport, conserves the ATP expended in pentose transport by the ABC transporter, both pfl and ackA mutants grew anaerobically with arabinose. AraE-based xylose transport, achieved after constitutively expressing araE, also supported the growth of the pfl mutant in xylose minimal medium. These results suggest that a net ATP yield of 0.67 per pentose is only enough to provide for maintenance energy but not enough to support growth of E. coli in minimal medium. Thus, pyruvate formate lyase and acetate kinase are essential for anaerobic growth of E. coli on xylose due to energetic constraints.     

Control of the shift from homolactic acid to mixed-acid fermentation in Lactococcus lactis: predominant role of the NADH/NAD+ ratio.

During batch growth of Lactococcus lactis subsp. lactis NCDO 2118 on various sugars, the shift from homolactic to mixed-acid metabolism was directly dependent on the sugar consumption rate. This orientation of pyruvate metabolism was related to the flux-controlling activity of glyceraldehyde-3-phosphate dehydrogenase under conditions of high glycolytic flux on glucose due to the NADH/NAD+ ratio. The flux limitation at the level of glyceraldehyde-3-phosphate dehydrogenase led to an increase in the pool concentrations of both glyceraldehyde-3-phosphate and dihydroxyacetone-phosphate and inhibition of pyruvate formate lyase activity. Under such conditions, metabolism was homolactic. Lactose and to a lesser extent galactose supported less rapid growth, with a diminished flux through glycolysis, and a lower NADH/NAD+ ratio. Under such conditions, the major pathway bottleneck was most probably at the level of sugar transport rather than glyceraldehyde-3-phosphate dehydrogenase. Consequently, the pool concentrations of phosphorylated glycolytic intermediates upstream of glyceraldehyde-3-phosphate dehydrogenase decreased. However, the intracellular concentration of fructose-1,6-bisphosphate remained sufficiently high to ensure full activation of lactate dehydrogenase and had no in vivo role in controlling pyruvate metabolism, contrary to the generally accepted opinion. Regulation of pyruvate formate lyase activity by triose phosphates was relaxed, and mixed-acid fermentation occurred (no significant production of lactate on lactose) due mostly to the strong inhibition of lactate dehydrogenase by the in vivo NADH/NAD+ ratio.     

Reduced oxidative pentose phosphate pathway flux in recombinant xylose-utilizing Saccharomyces cerevisiae strains improves the ethanol yield from xylose

In recombinant, xylose-fermenting Saccharomyces cerevisiae, about 30% of the consumed xylose is converted to xylitol. Xylitol production results from a cofactor imbalance, since xylose reductase uses both NADPH and NADH, while xylitol dehydrogenase uses only NAD(+). In this study we increased the ethanol yield and decreased the xylitol yield by lowering the flux through the NADPH-producing pentose phosphate pathway. The pentose phosphate pathway was blocked either by disruption of the GND1 gene, one of the isogenes of 6-phosphogluconate dehydrogenase, or by disruption of the ZWF1 gene, which encodes glucose 6-phosphate dehydrogenase. Decreasing the phosphoglucose isomerase activity by 90% also lowered the pentose phosphate pathway flux. These modifications all resulted in lower xylitol yield and higher ethanol yield than in the control strains. TMB3255, carrying a disruption of ZWF1, gave the highest ethanol yield (0.41 g g(-1)) and the lowest xylitol yield (0.05 g g(-1)) reported for a xylose-fermenting recombinant S. cerevisiae strain, but also an 84% lower xylose consumption rate. The low xylose fermentation rate is probably due to limited NADPH-mediated xylose reduction. Metabolic flux modeling of TMB3255 confirmed that the NADPH-producing pentose phosphate pathway was blocked and that xylose reduction was mediated only by NADH, leading to a lower rate of xylose consumption. These results indicate that xylitol production is strongly connected to the flux through the oxidative part of the pentose phosphate pathway.     

Physiological characterization of recombinant Saccharomyces cerevisiae expressing the Aspergillus nidulans phosphoketolase pathway: validation of activity through 13C-based metabolic flux analysis

Several bacterial species and filamentous fungi utilize the phosphoketolase pathway (PHK) for glucose dissimilation as an alternative to the Embden-Meyerhof-Parnas pathway. In Aspergillus nidulans, the utilization of this metabolic pathway leads to increased carbon flow towards acetate and acetyl CoA. In the first step of the PHK, the pentose phosphate pathway intermediate xylulose-5-phosphate is converted into acetylphosphate and glyceraldehyde-3-phosphate through the action of xylulose-5-phosphate phosphoketolase, and successively acetylphosphate is converted into acetate by the action of acetate kinase. In the present work, we describe a metabolic engineering strategy used to express the fungal genes of the phosphoketolase pathway in Saccharomyces cerevisiae and the effects of the expression of this recombinant route in yeast. The phenotype of the engineered yeast strain MP003 was studied during batch and chemostat cultivations, showing a reduced biomass yield and an increased acetate yield during batch cultures. To establish whether the observed effects in the recombinant strain MP003 were due directly or indirectly to the expression of the phosphoketolase pathway, we resolved the intracellular flux distribution based on (13)C labeling during chemostat cultivations. From flux analysis it is possible to conclude that yeast is able to use the recombinant pathway. Our work indicates that the utilization of the phosphoketolase pathway does not interfere with glucose assimilation through the Embden-Meyerhof-Parnas pathway and that the expression of this route can contribute to increase the acetyl CoA supply, therefore holding potential for future metabolic engineering strategies having acetyl CoA as precursor for the biosynthesis of industrially relevant compounds.     

Conversion of xylose to ethanol by recombinant Saccharomyces cerevisiae: importance of xylulokinase (XKS1) and oxygen availability.

The yeast Saccharomyces cerevisiae efficiently ferments hexose sugars to ethanol, but it is unable to utilize xylose, a pentose sugar abundant in lignocellulosic materials. Recombinant strains containing genes coding for xylose reductase (XR) and xylitol dehydrogenase (XDH) from the xylose-utilizing yeast Pichia stipitis have been reported; however, such strains ferment xylose to ethanol poorly. One reason for this may be the low capacity of xylulokinase, the third enzyme in the xylose pathway. To investigate the potential limitation of the xylulokinase step, we have overexpressed the endogenous gene for this enzyme (XKS1) in S. cerevisiae that also expresses the P. stipitis genes for XR and XDH. The metabolism of this recombinant yeast was further investigated in pure xylose bioreactor cultivation at various oxygen levels. The results clearly indicated that overexpression of XKS1 significantly enhances the specific rate of xylose utilization. In addition, the XK-overexpressing strain can more efficiently convert xylose to ethanol under all aeration conditions studied. One of the important illustrations is the significant anaerobic and aerobic xylose conversion to ethanol by the recombinant Saccharomyces; moreover, this was achieved on pure xylose as a carbon. Under microaerobic conditions, 5.4 g L(-1) ethanol was produced from 47 g L(-1) xylose during 100 h. In fed-batch cultivations using a mixture of xylose and glucose as carbon sources, the specific ethanol production rate was highest at the highest aeration rate tested and declined by almost one order of magnitude at lower aeration levels. Intracellular metabolite analyses and in vitro enzyme activities suggest the following: the control of flux in a strain that overexpresses XKS1 has shifted to the nonoxidative steps of the pentose phosphate pathway (i.e., downstream of xylose 5-phosphate), and enzymatic steps in the lower part of glycolysis and ethanol formation pathways (pyruvate kinase, pyruvate decarboxylase, and alcohol dehydrogenase) do not have a high flux control in this recombinant strain. Furthermore, the intracellular ATP levels were found to be significantly lower for the XK strain compared with either the control strain under similar conditions or glucose-grown Saccharomyces. The ATP : ADP ratios were also lower for the XK strain, especially under microaerobic conditions (0.9 vs 6.4).     

Reduced Oxidative Pentose Phosphate Pathway Flux in Recombinant Xylose-Utilizing Saccharomyces cerevisiae Strains Improves the Ethanol Yield from Xylose

In recombinant, xylose-fermenting Saccharomyces cerevisiae, about 30% of the consumed xylose is converted to xylitol. Xylitol production results from a cofactor imbalance, since xylose reductase uses both NADPH and NADH, while xylitol dehydrogenase uses only NAD⁺. In this study we increased the ethanol yield and decreased the xylitol yield by lowering the flux through the NADPH-producing pentose phosphate pathway. The pentose phosphate pathway was blocked either by disruption of the GND1 gene, one of the isogenes of 6-phosphogluconate dehydrogenase, or by disruption of the ZWF1 gene, which encodes glucose 6-phosphate dehydrogenase. Decreasing the phosphoglucose isomerase activity by 90% also lowered the pentose phosphate pathway flux. These modifications all resulted in lower xylitol yield and higher ethanol yield than in the control strains. TMB3255, carrying a disruption of ZWF1, gave the highest ethanol yield (0.41 g g⁻¹) and the lowest xylitol yield (0.05 g g⁻¹) reported for a xylose-fermenting recombinant S. cerevisiae strain, but also an 84% lower xylose consumption rate. The low xylose fermentation rate is probably due to limited NADPH-mediated xylose reduction. Metabolic flux modeling of TMB3255 confirmed that the NADPH-producing pentose phosphate pathway was blocked and that xylose reduction was mediated only by NADH, leading to a lower rate of xylose consumption. These results indicate that xylitol production is strongly connected to the flux through the oxidative part of the pentose phosphate pathway.     

Analysis of metabolic pathways and fluxes in a newly discovered thermophilic and ethanol‐tolerant Geobacillus strain

A recently discovered thermophilic bacterium, Geobacillus thermoglucosidasius M10EXG, ferments a range of C5 (e.g., xylose) and C6 sugars (e.g., glucose) and is tolerant to high ethanol concentrations (10%, v/v). We have investigated the central metabolism of this bacterium using both in vitro enzyme assays and ¹³C‐based flux analysis to provide insights into the physiological properties of this extremophile and explore its metabolism for bio‐ethanol or other bioprocess applications. Our findings show that glucose metabolism in G. thermoglucosidasius M10EXG proceeds via glycolysis, the pentose phosphate pathway, and the TCA cycle; the Entner–Doudoroff pathway and transhydrogenase activity were not detected. Anaplerotic reactions (including the glyoxylate shunt, pyruvate carboxylase, and phosphoenolpyruvate carboxykinase) were active, but fluxes through those pathways could not be accurately determined using amino acid labeling. When growth conditions were switched from aerobic to micro‐aerobic conditions, fluxes (based on a normalized glucose uptake rate of 100 units (g DCW)^?1 h^?1) through the TCA cycle and oxidative pentose phosphate pathway were reduced from 64 ± 3 to 25 ± 2 and from 30 ± 2 to 19 ± 2, respectively. The carbon flux under micro‐aerobic growth was directed to ethanol, L ‐lactate (>99% optical purity), acetate, and formate. Under fully anerobic conditions, G. thermoglucosidasius M10EXG used a mixed acid fermentation process and exhibited a maximum ethanol yield of 0.38 ± 0.07 mol mol^?1 glucose. In silico flux balance modeling demonstrates that lactate and acetate production from G. thermoglucosidasius M10EXG reduces the maximum ethanol yield by approximately threefold, thus indicating that both pathways should be modified to maximize ethanol production. Biotechnol. Bioeng. 2009;102: 1377–1386. © 2008 Wiley Periodicals, Inc.     

Enzymes of intermediary carbohydrate metabolism in Ureaplasma urealyticum and Mycoplasma mycoides subsp. mycoides

Cell extracts of Ureaplasma urealyticum and Mycoplasma mycoides were examined for enzymes of intermediary carbohydrate metabolism using a sensitive radiochemical assay procedure. For M. mycoides, the enzyme activities detected were supporting evidence for the existence of a glycolytic pathway giving lactate anaerobically and acetate aerobically. U. urealyticum also had activities of many glycolytic enzymes. Enzymes of the pentose phosphate pathway occurred in both M. mycoides and U. urealyticum. Their presence allowed the proposal of a sequence for the synthesis from glycolytic pathway intermediates of ribose 5-phosphate, and hence phosphoribosyl diphosphate, for the synthesis of nucleotides. Pathways for the further metabolism of deoxyribose 1-phosphate and ribose 1-phosphate produced from nucleoside phosphorylase reactions operated in extracts from both organisms.     

Metabolic engineering of a phosphoketolase pathway for pentose catabolism in Saccharomyces cerevisiae

Low ethanol yields on xylose hamper economically viable ethanol production from hemicellulose-rich plant material with Saccharomyces cerevisiae. A major obstacle is the limited capacity of yeast for anaerobic reoxidation of NADH. Net reoxidation of NADH could potentially be achieved by channeling carbon fluxes through a recombinant phosphoketolase pathway. By heterologous expression of phosphotransacetylase and acetaldehyde dehydrogenase in combination with the native phosphoketolase, we installed a functional phosphoketolase pathway in the xylose-fermenting Saccharomyces cerevisiae strain TMB3001c. Consequently the ethanol yield was increased by 25% because less of the by-product xylitol was formed. The flux through the recombinant phosphoketolase pathway was about 30% of the optimum flux that would be required to completely eliminate xylitol and glycerol accumulation. Further overexpression of phosphoketolase, however, increased acetate accumulation and reduced the fermentation rate. By combining the phosphoketolase pathway with the ald6 mutation, which reduced acetate formation, a strain with an ethanol yield 20% higher and a xylose fermentation rate 40% higher than those of its parent was engineered.     

Fermentation of d-Xylose and l-Arabinose to Ethanol by Erwinia chrysanthemi

Erwinia spp. are gram-negative facultative anaerobes within the family Enterobacteriacae which possess several desirable traits for the conversion of pentose sugars to ethanol, such as the ability to ferment a broad range of carbohydrates and the ease with which they can be genetically modified. Twenty-eight strains of Erwinia carotovora and E. chrysanthemi were screened for the ability to ferment d-xylose to ethanol. E. chrysanthemi B374 was chosen for further study on the basis of its superior (4%) ethanol tolerance. We have characterized the fermentation of d-xylose and l-arabinose by the wild type and mutants which bear plasmids containing the pyruvate decarboxylase gene from Zymomonas mobilis. Expression of the gene markedly increased the yields of ethanol (from 0.7 up to 1.45 mol/mol of xylose) and decreased the yields of formate, acetate, and lactate. However, the cells with pyruvate decarboxylase grew only one-fourth as fast as the wild type and tolerated only 2% ethanol. Alcohol tolerance was stimulated by the addition of yeast extract to the growth medium. Xylose catabolism was characterized by a high saturation constant K(s) (4.5 mM).