D-泛解酸内酯水解酶产生菌的筛选及产酶条件研究

筛选到一株产D 泛解酸内酯水解酶的菌株 ,经鉴定为串珠镶孢霉菌 (Fusariummonili forme)SW 90 2。产酶条件研究表明 ,用甘油作碳源 ,蛋白胨作氮源 ,初始pH8 0 ,温度 2 6℃ ,摇瓶培养 3d ,产酶量最高。在 6 0L发酵罐中通风发酵 45h ,产菌丝体生物量 7 1 8g干菌体 L ,D 泛解酸内酯水解酶酶活力达到 0 92IU g干菌体     

微生物酶拆分方法生产D-泛酸的手性中间体D-泛解酸内酯

筛选到一株产D－泛解酸内酯水解酶的串珠镰孢霉菌（Fusarium moniliforme SW-902)。产酶条件研究表明,用甘油作碳源,蛋白胨作氮源,初始pH8.0,温度26℃,摇瓶培养3d,产酶量最高。在60L和1000L发酵罐中通风发酵45－47h,产酶量为6－8g干菌体／L,D－泛解酸内酯水解酶酶活力达到0．87－0．92IU／g干菌体。该酶的最适反应温度为55℃,最适反应pH为7．0－7．5。在酶不对称水解泛解酸内酯过程中,对溶液加酶量5％－10％,底物浓度10％－20％,控制水解率20％－30％,水解效果最好。     

D-泛解酸内酯水解酶的定向进化

易错PCR结合DNA改组方法向D-泛解酸内酯水解酶基因中引入突变,并构建突变体库。利用酶的催化特点和产物特性建立了基于平板初筛和高效液相复筛的两步法D-泛解酸内酯水解酶活性筛选系统。用该筛选系统以酶活力和pH稳定性为指标对突变体库进行筛选,最终获得一株酶活力高且在低pH条件下稳定性好的突变体Mut E-861。该突变体的酶活力是野生型酶的5.5倍。对突变体和野生型酶在pH 6.0和pH 5.0条件下的残余酶活进行对比,在这两种pH条件下,突变体酶的酶活残留分别为75%和50%,而野生型酶只能保持原来的40%和20%。通过软件对突变体Mut E-861酶基因和野生型酶基因进行分析对比,发现突变体Mut E-861酶基因发生了三处点突变,其中突变使两处氨基酸取代,另一处为沉默突变,未引起氨基酸的变化。     

固定化细胞拆分DL-泛解酸内酯的初步研究

用卡拉胶包埋串珠镰孢霉菌Fusarium moniliforme SW-902菌丝体,得到D－泛解酸内酯水解酶活力较高的固定化细胞。与游离细胞相比较,固定化细胞酶活随pH变化的范围以及对温度适应的范围大致与游离细胞相仿。用固定化细胞进行反复分批酶水解30批,每天一批,酶活稳定,平均水解率28．0％。固定化细胞冰箱（4℃）贮存8周,酶活未见下降。     

串珠镰孢霉D-泛解酸内酯水解酶基因的克隆及在大肠杆菌中的表达

利用D_泛解酸内酯水解酶N末端序列,并根据NCBI中公布的D_泛解酸内酯水解酶cDNA序列设计了一个特异引物,该引物结合Oligo(dT) 1 5,以串珠镰孢霉(Fusariummoniliforme)CGMCC 0 5 36mRNA反转录得到的总cDNA为模板进行扩增,获得约1 5kb左右的片段,将其克隆到T载体上进行测序,对测得的序列进行分析,重新设计了一对引物,并在引物两端分别加上限制酶EcoRⅠ和SalⅠ的识别位点序列,利用热启动PCR成功地扩增出了D_泛解酸内酯水解酶基因,基因片段长度为114 6bp ,该序列同来源于尖镰孢霉菌(F .oxysporum)AKU 370 2菌株的编码D_泛解酸内酯水解酶cDNA结构基因的同源性为90 0 6 %。将所得片段定向克隆到pTrc99a载体中,转化至JM10 9感受态细胞,筛选出了阳性克隆。经IPTG诱导阳性菌,进行SDS_PAGE电泳,检测出在约4 0kD处有一蛋白表达带。对两株重组基因工程菌的比活力进行测定,结果分别为37U和4 1U。     

吸附-交联法固定D-泛解酸内酯水解酶的研究

选择6种吸附树脂和离子交换树脂对D-泛解酸内酯水解酶进行固定化,筛选出了固定化效果较好的大孔弱碱性丙烯酸系阴离子交换树脂D-380为载体,用先吸附后交联的方法固定化。通过实验对固定化条件进行了优化,得出最佳的固定化条件为：加酶量6U／g树脂、吸附pH7．5、吸附时间4h、吸附温度30℃、交联剂戊二醛终浓度0．1％、交联时间2h。实验表明在此条件下制得的固定化酶有很好的稳定性：固定化酶在连续20次的底物水解反应后,剩余酶活达到71％。当温度达到80℃时游离酶几乎失去酶活,而固定化酶剩余酶活为60％以上。游离酶的pH稳定性范围为pH7～8,而固定化酶为pH6．5～8．5。     

环氧化物水解酶产生菌的筛选及产酶条件研究

手性环氧化物至少含有一个手性碳,通过选择性开环和官能团转换,可以方便地合成许多有价值的手性化合物,在制药、农药、香料、精细化学品工业上有着极其重要的应用价值[1]。因此,手性环氧化物的合成一直是一个重要的研究课题。     

复合诱变筛选变细胞壁水解酶木霉素株及产酶条件的优化

利用复合诱变技术,筛选到一株产几丁质酶和钱聚糖酶能力较强的绿色木霉菌株（Trichodermaviride)LD-18。并对其产酶条件进行了优化,发现在麸皮：诱导物：麦秸粉＝2：2：7的固体培养基上,以4g/L(NH4)2SO4为氮源,起始pH8.0经25摄氏度培养72h,产生的真菌细胞壁水解酶,用以溶解食用菌,黑曲霉等丝状菌丝体的细胞壁,制备原生质体,效果较优。     

产植酸酶菌株的筛选及产酶条件的研究

通过初筛和复筛,得到一株产植酸酶较高的黑曲霉AN00101菌株,并对该菌种的产酶条件进行了研究.结果表明:配制加水量为35%的麸皮固体培养基,在37℃培养114h,用3%CaCl2进行提取,每g固体发酵物酶活高达1.3×104IU.经L9(34)正交实验表明,硫酸铵和硫酸镁对产酶有显著的促进作用,适宜添加量分别为4%和0.3%.     

碱性木聚糖酶产生菌的筛选与产酶条件

从某造纸厂分别采集排水沟及厂区附近的土样,用透明圈法筛选到了40株产木聚糖酶的细菌,经过复筛得到1株产酶稳定性及酶活性都较高的细菌HNX01。其产酶的最适条件为：6%玉米芯、1%麸皮、0.1%NH4Cl、0.1%NaNO3、1%K2HPO4、0.2%土温80、5mmol/LFeCl3、pH8.0、接种最为3%、250ml三角瓶装50ml。在上述培养基中37℃、220r/min培养24h,木聚糖酶酶活力可达198.4IU/ml。     

串珠镰刀菌产生毒素条件研究

从培养基种类和培养方法等方面对串珠镰刀菌产生毒素条件进行了较系统的研究。结果表明串珠镰刀菌的最佳产生毒素条件为马铃薯 葡萄糖培养液、pH 91、2 h光暗交替、25℃、培养10 d。     

抗菌肽Fengycins抑制串珠镰刀菌的初步机制

Fengycins是枯草芽孢杆菌非核糖体合成的环状脂肽类抗生素,本文从其特性入手,研究了其抑制串珠镰刀菌的初步作用机制。普通显微观察结果显示,Fengycins处理能使部分串珠镰刀菌菌丝顶端破裂,进一步通过PI染色与荧光显微观察发现,Fengycins处理会导致串珠镰刀菌菌丝膜的损伤。在添加几丁质、壳聚糖、β-1,3葡聚糖、甾醇、胆固醇的平板内,Fengycins的抑菌活性没有受到太大影响;而在添加卵磷脂的平板,Fengycins的抑菌活性受到明显的拮抗。这些结果说明卵磷脂很可能是Fengycins在膜上的作用靶标。此外,研究还发现Fengycins能够抑制串珠镰刀菌分泌的磷脂酶A2的活性,该性质很可能也在Fengycins的抑菌活性中起到了一定作用。     

Trichoderma harzianum and its Metabolite 6-Pentyl-alpha-pyrone Suppress Fusaric Acid Produced by Fusarium moniliforme

The interaction of the pathogen Fusarium moniliforme and two antagonistic Trichoderma harzianum isolates was studied especially with respect to their secondary metabolites fusaric acid (FA) and 6‐pentyl‐alpha‐pyrone (6PAP). Among 10 isolates of F. moniliforme screened for FA production on maize kernels, the isolate 8 accumulated the highest amount of FA (678 μg/g). Mycelial growth and production of FA by isolate 8, determined in different liquid media revealed that the highest biomass and FA were produced in Czapek Dox Broth (CDB) followed by Richard’s solution. The amount of FA per gram mycelial dry weight reached its maximum in CDB and Richard’s solution after 14 days of incubation. Mycelial growth and conidia production of both Trichoderma isolates (T16 and T23) were retarded by increasing concentrations of FA in agar medium. At FA concentration of 300 mg/ml the radial mycelial growth of the isolates T16 and T23 were retarded by 32.5% and 45%, respectively. Conidia production was diminished in a similar extent as mycelial growth. Both T. harzianum isolates were capable to degrade FA in potato dextrose broth medium, particularly when lower doses of FA were present. In the presence of 50 mg/ml FA in the culture medium, the isolates T23 and T16 reduced FA by 51.4% and 88.4%, respectively, 9 days post‐inoculation. The antifungal metabolite 6PAP, isolated from T. harzianum T23 cultures, was introduced at different concentrations into 2‐day‐old cultures of F. moniliforme. After further 5 days of incubation of F. moniliforme in the presence of 6PAP, the FA contents per gram mycelial dry weight were significantly decreased compared to control cultures where 6PAP was absent. Dosages of 300 and 400 mg/l of 6PAP in the cultures retarded FA accumulations by 62.5% and 77.2%, respectively. The current results, however, provided the first evidence for activity of 6PAP, as a Trichoderma secondary metabolite, on degrading/synthesis suppression of the Fusarium toxin FA.     

Effects of Fusarium moniliforme culture extracts and fumonisin B1 on DNA,RNA and protein synthesis by baby hamster kidney cells

Baby hamster kidney cells (BHK-21) were exposed to culture filtrates of 4 Fusarium moniliforme isolates containing varying levels of fumonisin B1 (FMB1) and the effects upon RNA, DNA and protein synthesis were monitored. Cells were also grown on medium amended with FMB1 only for comparison. After 24 h incubation FMB1 (100 μg/100 ml medium) reduced protein synthesis by 4% and by 18% after 48 h. Culture filtrates containing the highest levels of FMB1 also caused the greatest inhibition in protein synthesis after 24 h but after 48 h protein synthesis levels were the same as controls even though the FMB1 level was 360 μg/100 ml. Only FMB1 reduced DNA synthesis, by 8% after 24 h but after 48 h DNA levels had increased by 40 % over controls. The culture filtrates containing the highest levels of FMB1 (360 μg/100 ml) reduced DNA synthesis more than 50% after 24 h and 48 h. Culture filtrates containing lesser amounts of FMB1 in some instances stimulated DNA synthesis and inhibited it in others. There was also no correlation in the level of FMB1 with the inhibition of RNA synthesis by BHK cells. It appears that metabolites other than fumonisin produced by F. moniliforme in culture can affect and both stimulate and inhibit RNA, DNA and protein synthesis by BHK cells. This revised version was published online in June 2006 with corrections to the Cover Date.     

Dimorphic fungus characteristic of fumonisin-producing strains of Fusarium moniliforme from Zhejiang

Fusarium moniliforme and its fumonisins have been shown to be carcinogenic in lab animals and have been linked to high incidences of human esophageal cancer. In this study we report the dimorphic fungus characteristic of fumonisin-producing strains of F. moniliforme from foodstuffs in Zhejiang, China. All of the twenty strains of F. moniliforme shown produce fumonisin B₁ 475.9–6322.2 μg/g in corn medium. These strains of F. moniliforme form yeast-like colonies in Sabouraud's agar plates contained 9% NaCl at 37 °C incubator and shows mostly budding reproduction. In blood agar plates these strains of F. moniliforme appear grass-green haemolytic reactions. This is the first report that yeast-like growth, dimorphic pathogenic fungus feature is found in F. moniliforme. These results suggest that it is also important to program epidemiological surveys of F. moniliforme as a primary pathogenic fungus, while proceeding to produce mycotoxins of F. moniliforme in food hygiene. This revised version was published online in August 2006 with corrections to the Cover Date.     

Ice Nucleus Production of Fusarium moniliforme var. subglutinans in Relation to Its Growth Characteristics

The effects of culture conditions on the ice nucleus production of Fusarium moniliforme var. subglutinans isolated from the gut of larvae of the rice stem borer (Chilo suppressalis Walker) were examined. The ice nucleus production was only affected by cultivation temperature and pH: the optimum temperature and pH were 15°C to 20°C and 4.0 to 6.0, respectively.     

In vitro studies on the potential for biological control of Aspergillus flavus and Fusarium moniliforme by Trichoderma species

Culture filtrates of Trichoderma viride and Trichoderma harzianum were inhibitory of Fusarium moniliforme and, to a lesser extent, Aspergillus flavus. The degree of inhibition was, however, dependent on the carbon or nitrogen source incorporated into the medium. Scanning electron microscopy revealed the development of abnormal fruiting structures on exposure to some Trichoderma culture filtrate, while macroscopically, growth restriction and, in the case of A. flavus, altered colony colouration were observed. Based on the results of inverted colony culture, it would appear that some isolates of Trichoderma produce inhibitory volatile compounds. The production of possible antibiotics was also demonstrated. The aggressive behaviour (towards A. flavus and F. moniliforme) demonstrated by Trichoderma spp. may be partly explained by the liberation of extracellular enzymes by these fungi. An isolate of T. viride exhibited amylolytic, pectinolytic, proteolytic and cellulolytic activity. Based on the results of the present investigation, Trichoderma spp. are potential candidates for biocontrol of some mycotoxin-producing fungi, but there exists some doubt as to their osmotolerance within the air-dry seed. This revised version was published online in August 2006 with corrections to the Cover Date.