Effects of long- and short-term passage of insect cells in different culture media on baculovirus replication

Two insect cell lines that had been maintained in both serum-free (SFM) and serum-containing (SCM) media for over 5 years were each tested for their ability to replicate baculovirus. The gypsy moth cell line, IPLB-LdEIta (Ld), produced similar (not statistically different) amounts of gypsy moth nucleopolyhedrovirus (LdMNPV) occlusion bodies (OBs) in the two media (serum-free Ex-Cell 400 and TC-100 with 9% (v/v) fetal bovine serum, SCM(1)) but produced more of the Autographa californica nucleopolyhedrovirus (AcMNPV) OBs in SFM than in SCM(1). When Ld cells normally grown in SCM(1) were switched to SFM, production of OBs from both viruses improved and, after three passages, reached higher levels of AcMNPV production than in cells normally maintained in that medium. Alternatively, cells switched from SFM to SCM(1) initially produced as much (in the case of LdMNPV) or higher (in the case of AcMNPV) levels of virus OBs than cells normally maintained in SCM(1) but productivity dropped off over subsequent passages such that after five passages in SCM(1), cells produced substantially fewer OBs of both viruses. A fall armyworm cell line (IPLB-SF21AE; Sf) showed slightly different effects from long- and short-term passage in SFM (Ex-Cell 400) or SCM(2) (TMN-FH). Cells maintained in SFM produced about 20 times more AcMNPV OBs than cells maintained long-term in SCM. Sf cells switched from SFM to SCM maintained the level of production of that seen in SFM at the first passage, but quickly dropped off OB production levels to that normally seen in SCM. Alternatively, SCM-maintained Sf cells produced higher levels at the first passage in SFM and, within five passages in SFM, reached levels found in cells maintained for long term in this medium. Under the conditions in which these two cell lines were infected, the highest levels of AcMNPV OB production in Ld cells were about five times that of Sf cells. In a separate series of experiments, cells normally grown in SFM were passaged over five times in Ex-Cell 400 to which serum was added; both cell lines produced as much virus as that in SFM. These results suggest that it is not the serum per se but rather some other components which differ between the SFM and the SCM formulations that are responsible for the varied virus production obtained in these studies. The results of these studies suggest that a maintenance and virus production protocol can be developed with Ld cells which could improve overall efficiency of virus production. These studies also suggest that long-term maintenance of cells in SFM was not detrimental to their ability to produce baculoviruses.     

Lepidopteran cell lines after long-term culture in alternative media: Comparison of growth rates and baculovirus replication

Summary Three insect cell lines, IPLB-LdFB and IPLB-LdEIta from gypsy moth fat body and embryos and UFL-AG-286 from velvetbean caterpillar embryos, have been concurrently maintained for 1 to 12 yr on two media formulations, modified TC-100 containing 9% fetal bovine serum and Ex-cell 400, a commercial serum-free medium (SFM). Cells grown in each medium were tested for susceptibility to and productivity of various multiply embedded nucleopolyhedroviruses. The three lines chosen for these experiments fall into three categories of relative growth in SFM versus TC-100: LdFB cells grew similarly in each medium, LdEIta grew better in Ex-Cell than in TC-100, and AG-286 grew better in TC-100 than in Ex-Cell. The susceptibility of cells to infection also varies, although without any apparent correlation to which medium was best for supporting growth. Endpoint assays suggested that LdFB cells grown in serum-containing medium are more susceptible to virus infection than their SFM counterparts, while the opposite is true for LdEIta cells. Production of virus, based on numbers of occlusion bodies, showed fewer differences with only AcMNPV production with AG-286 in TC-100 being statistically higher than production of the same virus in Ex-cell 400. These studies suggest that long-term passage in alternative media may impact the ability of cells to support virus infection and replication, but the effects on each cell line and virus system need to be determined.     

Influence of baculovirus-host cell interactions on complex N-linked glycosylation of a recombinant human protein

The conditions required for mammalian-type complex N-linked glycosylation of human proteins produced in insect cells with the baculovirus expression vector system were investigated. Marked alterations to N-linked glycosylation of human placental secreted alkaline phosphatase (SEAP) were observed with different baculovirus species, insect cell lines, and cell culture media. When a recombinant Autographa californica nucleopolyhedrovirus (AcMNPV) was used to produce SEAP in Trichoplusia ni (Tn-4h) cells cultured in serum-free medium, structural analyses indicated <1% hybrid and no complex oligosaccharides attached to SEAP, a typical result with the baculovirus expression vector system. However, when fetal bovine serum was added to the culture medium, 48 +/- 4% of the oligosaccharides were hybrid or complex (but asialylated) glycans. When a recombinant T. ni nucleopolyhedrovirus (TnSNPV) was similarly used to express SEAP in Tn-4h cells cultured in serum-containing medium, only 24 +/- 3% of the glycans contained terminal N-acetylglucosamine and/or galactose residues. In contrast, SEAP produced in Sf9 cells grown in serum-containing medium with AcMNPV contained <1% hybrid oligosaccharides and no complex oligosaccharides. The results illustrate that baculovirus type, host cell type, and the growth medium all have a strong influence on the glycosylation pathway in insect cells, resulting in significant alterations in structures and relative abundance of N-linked glycoforms. Although the addition of sialic acid residues to the SEAP glycans was not detected, possible approaches to obtain sialylated glycans are discussed.     

Two new cell lines originated from the embryos of <Emphasis Type="Italic">Clostera anachoreta</Emphasis> (Lepidoptera: Notodontidae): characterization and susceptibility to baculoviruses

Two cell lines designated CAF-Clan I and CAF-Clan II have been established from embryos of Clostera anachoreta (Lepidoptera: Notodontidae) in TNM-FH medium containing 10% inactivated fetal bovine serum. CAF-Clan I consists of a mixture of three cell types: spherical cells, spindle-shaped cells, and giant cells. Most of the cultured cells formed a suspension in the medium and were subcultured more than 60 passages. CAF-Clan II mainly consists of spindle-shaped and spherical cells which attached to the culture surface and have undergone more than 40 passages. The cell population doubling time at 27°C of CAF-Clan I at passage 22 and CAF-Clan II at passage 24 was about 68.5 and 38.2 h, respectively. The chromosome number of both cell lines at passage 15 varied from 62 to 100 in the majority of cells, though a few cells exceeded 260 (n = 30). DNA amplification fingerprinting–polymerase chain reaction analysis confirmed that the origination of the two cell lines was C. anachoreta. The susceptibility of the cell lines to baculoviruses was tested. The results showed that CAF-Clan II was susceptible to infection of Autographa californica nucleopolyhedrovirus (AcMNPV) and Ecotropis oblique nucleopolyhedrovirus (EoNPV). Occlusion bodies (OBs) production was 129 ± 4 OBs/cell and 124 ± 15 OBs/cell for AcMNPV and EoNPV, respectively. CAF-Clan I was less susceptible to AcMNPV compared with CAF-Clan II, while non-permissive to EoNPV.     

Expression of the green fluorescent protein carried by Autographa Californica multiple nucleopolyhedrovirus in insect cell lines

Summary A recombinant AcMNPV containing the green fluorescent protein (gfp) gene under the polyhedrin promoter (polh) was used to investigate the expression of the gfp gene as well as the production of recombinant extracellular virus in 14 continuous insect cell lines, including Heliothis virescens (BCIRL-HV-AM1), Helicoverpa zea (BCIRL-HZ-AM1), Anticarsia gemmatalis (BCIRL-AG-AM1), Trichoplusia ni (TN-CL1), Spodoptera frugiperda (IPLB-SF21), Spodoptera exigua (BCIRL/AMCY-Se-E1 and BCIRL/AMCY-Se-E5), Bombyx mori (BMN), Sf9 (a clone of IPLB-SF21), and five cell line clones of BCIRL-HV-AM1. The susceptibility of the cell lines to the recombinant virus (AcMNPV.GFP) was ascertained by calculating the mean percentage number of green light-emitting cells as well as by TCID₅₀ titration of extracellular virus with fluorescence as a sign of infection. Of the 14 cell lines tested, all were permissive with varying degrees to Ac-MNPV.GFP, except BCIRL-HV-AMCL2 and BCIRL-HZ-AM1, both grown in serum-containing medium, and BMN, grown in serum-free medium, which were nonpermissive to the virus. Except for BCIRL/AMCY-Se-E1, IPLB-SF21, and four of the five BCIRL-HV-AM1 clones, all the other cell lines (BCIRL-HV-AM1, BCIRL-AG-AM1, TN-CL1, Se-E5, and Sf9) expressed detectable levels of GFP by 48 h postinoculation. The BCIRL/AMCY-Se-E1 and IPLB-SF21 cells, grown in serum-free medium (Ex-Cell 401), expressed detectable levels of GFP at 72 h postinoculation. By contrast, in BCIRL/AMCY-Se-E1 in serum-containing medium (Ex-Cell 401+10% FBS [fetal bovine serum]), GFP was detected at 48 h postinoculation. Furthermore, TN-CL1 cells produced the largest mean percentage number of fluorescent (76.6%) cells in both serum-containing and serum-free medium (64.8%) at 120 h postinoculation. All the BCIRL-HV-AM1 clones showed no GFP expression until 96 h postinoculation, and only then about 1% of the cell population fluoresced. The mean extracellular virus (ECV) production at 120 h postinoculation was highest in BCIRL/AMCY-Se-E5 cells grown in Ex-Cell 401+10% FBS (37.8×10⁶ TCID₅₀/ml) followed by BCIRL-HV-AM1 in TC199-MK (33.4×10⁶ TCID₅₀/ml). Only the BCIRL-HV-AMCL3 clone produced any substantial level of ECV at 120 h postinoculation (16.9×10⁶ TCID₅₀/ml). However, there was no significant correlation between ECV production and the mean percentage number of fluorescent cells. This study provides further information on the susceptibility of 14 insect cell lines to a recombinant AcMNPV containing the green fluorescent protein gene. This information might avail researchers with information to facilitate decisions as to what other cell lines are available for in vitro studies of the gfp gene.     

A new nucleopolyhedrovirus strain (LdMNPV-like virus) with a defective fp25 gene from Lymantria xylina (Lepidoptera: Lymantriidae) in Taiwan

A new multiple nucleopolyhedrovirus strain was isolated from casuarina moth, Lymantria xylina Swinhoe, (Lepidoptera: Lymantriidae) in Taiwan. This Lymantria-derived virus can be propagated in IPLB-LD-652Y and NTU-LY cell lines and showed a few polyhedra (occlusion bodies) CPE in the infected cells. The restriction fragment length polymorphism (RFLP) profiles of whole genome indicated that this virus is distinct from LyxyMNPV and the virus genome size was approximately 139 kbps, which was smaller than that of LyxyMNPV. The molecular phylogenetic analyses of three important genes (polyhedrin, lef-8 and lef-9) were performed. Polyhedrin, LEF-8 and LEF-9 putative amino acid analyses of this virus revealed that this virus belongs to Group II NPV and closely related to LdMNPV than to LyxyMNPV. The phylogenetic distance analysis was further clarified the relationship to LdMNPV and this virus provisionally named LdMNPV-like virus. A significant deletion of a 44 bp sequence found in LdMNPV-like virus was noted in the fp25k sequences of LdMNPV and LyxyMNPV and may play an important role in the few polyhedra CPE. In ultrastructural observations, the nuclei of the infected LD host cells contained large occlusion bodies (OBs), and few OBs, which presented as one or two OBs in a nucleus that was otherwise filled with free nuclocapsids and virions. We concluded that this LdMNPV-like virus is a new LdMNPV strain from L. xylina.     

Production of recombinant proteins by baculovirus-infected gypsy moth cells.

An experimental study was undertaken to evaluate alternative insect cell lines to Sf9 [from Spodoptera frugiperda (fall armyworm)] for the production of recombinant proteins. Insect cell lines from two different organisms were considered: IPLB-LdEIta (LdEIta) from Lymantria dispar (gypsy moth) and IPLB-HvT1 (HvT1) from Heliothis virescens (tobacco budworm). Both LdEIta and HvT1 produced higher total activity levels of recombinant beta-galactosidase in monolayer culture than Sf9 after infection with the Autographa californica nuclear polyhedrosis virus (AcMNPV). However, only LdEIta generated a product yield (activity per milligram of total protein) which exceeded that of Sf9 (by 25%), so its growth and production characteristics were investigated in depth. LdEIta generated production levels and yields of a recombinant rotaviral protein, VP4, which exceeded those of Sf9 by 84 and 38%, respectively. In suspension culture, the LdEIta cells grew as aggregates with a doubling time several hours longer than Sf9, but the recombinant product yields of LdEIta were still higher than Sf9 by 38% in this culture environment. beta-Galactosidase expression rates and cell death rates suggested that the difference in productivity between the two hosts was due to the ability of LdEIta to survive the baculovirus infection and produce recombinant proteins longer than Sf9. The presence of LdEIta aggregates in suspension culture may be used as a method to separate live cells from dead cells, labile product, and spent medium in recombinant protein production processes.     

ANALYSIS OF HELICOVERPA ARMIGERA SINGLE NUCLEOPOLYHEDROVIRUS IMMEDIATE EARLY 1 (IE‐1) GENE*

Abstract A 6.12 kb Xbal‐H fragment of the Helicoverpa armigem single nucleopolyhedrovirus (HaSNPV) gemone was cloned and the complete sequence of this fragment was sequenced by random sequencing method. Sequence comparison and analysis revealed an ORF13 which was homologous to ie‐1 of Auiographa California nucleopolyhedrovirus (AcMNPV). The homologous encoding gene is ie‐1. The total length of the encoding region of HaSNPV gene was 1986 bp and was predicted to encode 661 amino acid protein(IE‐1) with molecular weight of 76.5 kD. The alingment of putative HaSNPV IE‐1 amino acid sequence with those of other 9 reported baculoviruses IE‐Is showed that the HaSNPV IE‐1 was most closely related to Helicoverpa zea nucleopolyhedrovirus (HzNPV) IE‐1, with 97% amino acid identidy. But it showed a low degree of sequence similarity to those of AcMNPV, Bombyx mori nucleopolyhedrovirus (BmNPV), Choristoneura fumiferana nucleopolyhedrovirus (CfMNPV), Lymantria dispar nucleopolyhedrovirus (LdMNPV), Orgyia pseudotsugata nucleopolyhedrovirus (OpMNPV), Spodoptera exigua nucleopolyhedrovirus (SeMNPV), Plutella xylostella granulovirus(PxGV) and Xestia c‐nigrum granulovirus (XcGV), with 23%, 23%, 23%, 25%, 23%, 14%, 27% and 7% amino acid identity, respectively. A phylogenetic tree of ten baculoviruses IE‐1 was also given.     

Development of embryonic chick insulin cells in culture: Beneficial effects of serum-free medium, raised nutrients, and biomatrix

Summary A previous finding that insulin cells do not survive or differentiate in explants of embryonic avian pancreas cultured in collagen gel with a serum-containing medium has provided a model system for identification of conditions favorable for development of these cells. To this end, we here modify the substrate and the medium. The epithelial component of dorsal pancreatic buds of 5-d chick embryos was cultured for 7 d on Matrigel in serum-containing and in serum-free medium, the latter incorporating insulin, transferrin, and selenium, Endocrine cell types were distinguished by immunocytochemistry; insulin cell counts were expressed as a proportion of insulin plus glucagon cells. With serum-containing medium, Matrigel stimulated a significant increase in this proportion as compared with collagen gel—3.1% as against 0.2%; the serum-free medium further increased this proportion to 17.3%. Raising the level of essential amino acids approximately fivefold increased the latter figure somewhat (to 18.9%), but it was more than doubled (to 37.4%) by raising the glucose concentration from 10 mM to 20 mM. Raising the levels of amino acids and glucose simultaneously yielded a lesser increase (to 31.8%). Some cultures grown in collagen gel and serum-containing medium for 7 d were transferred to Matrigel and serum-free medium for a further 7 d. Insulin cell development recovered, indicating that progenitor cells had survived and were stimulated to develop by the improved conditions. This study indicates that components of the biomatrix and the medium (in particular, a raised glucose concentration) are important for the survival and differentiation of embryonic insulin cells.     

Adaptation of the Spodoptera exigua Se301 insect cell line to grow in serum-free suspended culture. Comparison of SeMNPV productivity in serum-free and serum-containing media

Spodoptera exigua Se301 cells have been successfully adapted to two different commercial serum-free media (SFM; Ex-Cell 420 and Serum-Free Insect Medium-1) by gradually reducing the 10 %-added serum-containing medium content from 100 % to 0 % (v/v) in suspended cultures. Both direct adaptation to a serum-free medium and cell growth in the absence of protective additives against fluid dynamic stress [polyvinyl pyrrolidone and polyvinyl alcohol] and disaggregation [dextran sulfate] proved impossible. Cells grew reproducibly in both SFMs once the serum had been completely removed, although the use of Ex-Cell 420 resulted in higher growth rates and cell densities. Turbulence was sufficiently high to reduce growth rates and final cell densities at the highest Reynolds number investigated, although no clear influence of agitation was observed on virus productivity. Both attached and suspended Se301 cell cultures were successfully infected with the SeMNPV baculovirus. Cells adapted to different conditions (attached or suspended culture, serum-containing or serum-free medium) showed different occlusion bodies productivities at the two multiplicities of infection assayed (0.1 and 0.5).     

Serum-free production of recombinant proteins and adenoviral vectors by 293SF-3F6 cells

This article describes the step-wise approach undertaken to select a serum-free medium (SFM) for the efficient production of a recombinant adenoviral vectors expressing beta-galactosidase (Ad5 CMV-LacZ), in the complementing human embryonic kidney 293S cells. In the first step, a 293S-derived transfectoma, secreting a soluble epidermal growth factor receptor sEGFr (D2-22), was used to estimate the potential of selected serum-free formulations to support the production of a recombinant protein as compared to serum-containing medium. Assays showed that only one among six commercial serum-free formulations could support both sEGFr production and cell growth in static or suspension culture. In commercially available calcium-containing serum-free formulations, the cell aggregates reached up to 3 mm in diameter. In the second step, 293S cells were gradually adapted to a low-calcium version of the selected medium (LC-SFM). Cells were cloned, then screened according to their ability to grow at a rate and an extent comparable to parental cells in serum-containing medium (standard) as single cells or small aggregates. The 293SF-3F6 clone, first adapted to and then cloned in the selected serum-free medium, was selected for further experiments. Bioreactor run performed with the 293SF-3F6 clone showed similar growth curve as in the shake-flask controls. In the final step, the recombinant viral vector productivity of the 293S cells and the 293SF-3F6 clone was tested. The 293SF-3F6 cells infected by Ad5 CMV-LacZ in 3 L-scale bioreactor maintained the specific productivities of both beta-galactosidase and adenoviral vector equivalent to the shake-flask controls in suspension culture. Results from this study clearly demonstrate that the 293SF-3F6 cell line thus selected may be used either for establishing stable transfected cell line or for the production of adenoviral vectors required for gene therapy studies.     

Long-term adaptation of the Bombyx mori BmN4 cell line to grow in serum-free culture

Bombyx mori ovary-derived BmN4 cells have been successfully adapted to a commercial serum-free medium (SFM; SF900-II) by gradually reducing the serum-containing TC-100 medium content from 100 to 0% (v/v). The BmN4 cells adapted to the SFM (BmN-SFM) adhered strongly to the culture flask and showed altered cell morphology. The BmN-SFM was subcultured 200 times, and the population doubling time was 4.70 d. Infection studies showed that BmN-SFM cells were easily susceptible to B. mori nucleopolyhedrovirus (BmNPV), and both the multiplication of budded virus and the promoter activity of the polyhedrin gene in BmN-SFM cells were almost the same as those in BmN4 cells before adaptation. Additionally, mouse interleukin-3 expressed by a recombinant BmNPV was normally secreted and modified with N-linked glycans in BmN-SFM cells. These findings indicate that BmN-SFM is particularly useful for a BmNPV-based baculovirus expression vector system with serum-free conditions.     

Factors involved in supporting the growth and steroidogenic functions of bovine adrenal cortical cells maintained on extracellular matrix and exposed to a serum-free medium

Bovine adrenal cortex cells maintained on extracellular matrix (ECM)-coated dishes will proliferate actively when serum is replaced by HDL (25 micrograms protein/ml), insulin (10 ng/ml), and FGF (100 ng/ml). The cells have an absolute requirement for HDL in order to survive and grow. The omission of insulin, FGF, or both results in a slower growth rate and lower final cell density of the cultures. A requirement for transferrin (1 microgram/ml) becomes apparent only when cells have been grown for at least four generations in the absence of serum. Early passage (P1-P3) bovine adrenal cortex cells cultured in serum-free medium responded to ACTH (10(-8)M) with increased 11-deoxycortisol production; this effect was not observed in later passage cells (P7-P15). The cells' ability to utilize LDL-derived cholesterol and to respond to db cAMP (1mM) by increased steroid release was preserved in cells cultured for over 60 generations in the serum-free medium. HDL, although also able to increase steroid production in early-passage cultures exposed to ACTH or to ACTH and dibutyryl cyclic AMP (db cAMP), was 10 fold less potent than LDL. It did not support steroidogenesis in cultures not exposed to these trophic agents. The life span of bovine adrenal cortex cells grown in the serum-free medium on fibronectin (FN)- versus ECM-coated dishes was compared. Cells seeded in serum-containing medium and grown in serum-free medium had a life span of 34 versus 60 generations when maintained on fibronectin- or ECM-coated dishes, respectively. Cells seeded in the complete absence of serum in the serum-free medium on ECM- or fibronectin-coated dishes could be passaged for 26 or 13 generations, respectively. While FGF was an absolute requirement for cells cultured on fibronectin-coated dishes, it was not required when cells were maintained on ECM. These observations demonstrate the influence of the ECM not only in promoting cell growth and differentiation but also on the life span of cultured cells.     

Rabbit chondrocytes maintained in serum-free medium : I. Synthesis and secretion of hydrodynamically-small proteoglycans

The biosynthesis of sulfated proteoglycan in vitro by rabbit articular chondrocytes in first passage monolayer culture maintained in fetal bovine serum (FBS) or in serum-free conditions was compared. Neosynthesized proteoglycan in the culture medium in the most dense fraction of an associative CsCl density gradient (fraction dAl) declined with increasing time under serum-free conditions, but not when cells were maintained in the presence of serum. After one day, the major peak of incorporated 35SO4 in medium fraction dAl eluted as a retarded peak (Kav 0.28) on Sepharose CL-2B, whether cells were maintained under serum-free or serum-containing conditions. The hydrodynamic size of proteoglycan monomer fraction dAlDl obtained after one day of exposure to serum-free culture media was smaller than dAlDl from serum-containing cultures. The hydrodynamic size of dAlDl obtained from serum-free culture media became even progressively smaller after 2 and 3 days' exposure to these conditions. Hydrodynamically small sulfated proteoglycans were identified in the cell-associated dAlDl fraction as early as one day after switching chondrocytes from serum-containing to serum-free medium. Culture medium fraction dAlDl from serum-free culture medium aggregated poorly when incubated with human hyaluronic acid (HA) in the presence of bovine link protein or when dialysed against bovine nasal cartilage proteoglycan aggregate. Proteoglycan monomer from serum-containing medium reaggregated more efficiently under both conditions. No change in the size of glycosaminoglycan chains was seen in the smaller proteoglycan subpopulations, nor was there any indication of marked changes in the glycosaminoglycan types.     

Xeno-free proliferation of human bone marrow mesenchymal stem cells

The proliferation of human bone marrow mesenchymal stem cells (MSCs) employing xeno-free materials not containing fetal calf serum (FCS) and porcine trypsin was investigated for the regenerative medicine of cartilage using MSCs. Four sequential subcultivations of MSCs using a medium containing 10% FCS and recombinant trypsin (TrypLESelect™) resulted in cell growth comparable to that with porcine trypsin. There was no apparent difference in the cell growth and morphology between two kinds of MSC stored in liquid nitrogen using 10% FCS plus DMSO or serum-free TC protector™. MSCs were isolated from human bone marrow cells, stored in liquid nitrogen, and sequentially subcultivated four times employing conventional materials that included FCS, porcine trypsin, and DMSO, or xeno-free materials that included serum-free medium (MesenCult-XF™), TC protector™ and TrypLESelect™. Cells in the culture using the xeno-free materials maintained typical fibroblast-like morphology and grew more rapidly than the cells in the culture using the conventional materials, while the cell surface markers of MSCs (CD90 and CD166) were well maintained in both cultures. Chondrogenic pellet cultures were carried out using these subcultivated cells and a medium containing TGFβ3 and IGF1. The pellet culture using cells grown with the xeno-free materials showed an apparently higher gene expression of aggrecan, a chondrocyte marker, than the pellet culture using cells grown with the conventional materials. Consequently, MSCs that are isolated, stored, and grown using the xeno-free materials including the serum-free medium (MesenCult-XF™), TC protector™, and recombinant trypsin (TrypLESelect™) might be applicable for regenerative medicine of cartilage.     

The establishment of heliothine cell lines and their susceptibility to two baculoviruses

Summary A total of eight cell lines were established from Helicoverpa armigera (3) and H. punctigera (5) embryos and ovaries. Cell lines were established and grown in TC100 and/or TC199-MK containing 10% fetal bovine serum. The serum-free medium ExCell™ 400 was also used, with and without 10% supplemental fetal bovine serum, but failed to generate cell lines from fat bodies, embryos, or ovarian tissues. Cell lines consisted of heterogenous cell types ranging from oval to fibroblast-like. This is the first report on the successful establishment of cell lines from H. punctigera. Cell lines from the two species were distinguishable from each other by DAF-PCR, and noticeable differences in minor bands were observed among cell lines from the same species. All of the established cell lines from both species were susceptible to HzSNPV but did not replicate more virus than that of a H. zea cell line (BCIRL-HZ-AM1-A11). However, an H. punctigera cell line (HP1) replicated AcMNPV to the highest titer (1.0×10⁸ 50% tissue culture infective dose/ml), and only one of the H. armigera cell lines (HA1) was susceptible to this virus.     

Continuous production of human erythropoietin by immobilized recombinant L-929 cells

Recombinant L-929 cells transfected with the human erythropoietin (EPO) gene were immobilized in a macroporous cellulosic support and its derivatives in which charged groups or cell attachment factors were introduced. The immobilized cells were cultured in serum-containing and serum-free media. Comparable production of EPO was observed even in the serum-free medium when a support modified by polyethyleneimine was used for immobilization. The cells immobilized on the supports were cultured in fluidized-bed and inner-loop type air-lift bioreactors for continuous production of EPO. A high cell density of more than 2 × 10⁷ cells/cm³-support and high EPO productivity were achieved and maintained for 50 d through the use of the inner-loop type air-lift bioreactor. The productivity was 13.4-fold higher than that of conventional static cultures in petri-dishes.     

Identification of baculovirus gene that promotes Autographa californica nuclear polyhedrosis virus replication in a nonpermissive insect cell line.

A gene that promotes Autographa californica M nuclear polyhedrosis virus (AcMNPV) replication in IPLB-Ld652Y cells, a cell line that is nonpermissive for AcMNPV, was identified in Lymantria dispar M nuclear polyhedrosis virus (LdMNPV). Cotransfection of AcMNPV DNA and a plasmid carrying the LdMNPV gene into IPLB-Ld652Y cells results in AcMNPV replication. The gene maps between 43.3 and 43.8 map units on the 162-kbp genome of LdMNPV. It comprises a 218-codon open reading frame and encodes a polypeptide with a predicted molecular mass of 25.7 kDa. The predicted polypeptide is glutamic acid and valine rich and negatively charged, with a pI of 4.61. No protein sequence motifs were identified, and no matches with known nucleotide or peptide sequences were found in the AcMNPV genome or database searches that suggest how this gene might function. A recombinant AcMNPV bearing the LdMNPV gene overcomes a block in protein synthesis observed in AcMNPV-infected IPLB-Ld652Y cells. Using Southern blotting techniques, we were unable to identify a homolog in Orgyia pseudotsugata M nuclear polyhedrosis virus, a baculovirus that is routinely propagated in IPLB-Ld652Y cells. This suggests that the LdMNPV host range is unique among the baculoviruses studied to date. We named this gene hrf-1 (for host range factor 1).     

棉铃虫单粒包埋型核型多角体病毒极早期基因(ie-1)分析(英文)

克隆了棉铃虫Helicoverpaarmigera单粒包埋型核型多角体病毒 (HaSNPV)C1株基因组DNA ,并通过随机测序的方法测定了经XbaI酶切后的H片段的核苷酸全序列。序列比较和分析发现该片段中ORF1 3与苜蓿丫纹夜蛾Autographacalifornica多粒包埋型核型多角体病毒 (AcMNPV)基因组ORF1 47(ie 1 )同源。ie 1基因编码区全长 1 986bp ,根据推测的氨基酸序列 ,可编码 6 6 1个氨基酸残基组成的多肽 ,预计分子量为 76 .5kD。将所推导的HaSNPVIE 1氨基酸序列与其它已知的杆状病毒IE 1氨基酸序列进行比较 ,结果表明 ,HaSNPV和谷实夜蛾H .zea单粒包埋型核型多角体病毒IE 1氨基酸序列最为相似 ,同源性高达 98%。与AcMNPV、家蚕Bombyxmori核型多角体病毒 (BmNPV)、云杉卷叶蛾Choristoneurafu miferana多粒包埋型核型多角体病毒 (CfMNPV)、舞毒蛾Lymantriadispar多粒包埋型核型多角体病毒(LdMNPV)、黄杉毒蛾Orgyiapseudotsugata多粒包埋型核型多角体病毒 (OpMNPV)、甜菜夜蛾Spodopteraex igua多粒包埋型核型多角体病毒 (SeMNPV)、小菜蛾Plutellaxylostella颗粒体病毒 (PxGV)和Xestiac ni grum颗粒体病毒 (XcGV)的IE 1氨基酸序列同源性较低 ,分别为 2 3 %、2 3 %、2 3 %、2 5 %、2 3 %、1 4%、2 7%和 7%。根据氨基酸序列由GENETYX     

Characterization of proliferation and differentiation of opossum kidney cells in a serum-free defined medium

Summary Proliferation and differentiation of opossum kidney cells in a serum-free defined medium was investigated and compared to that under conditions in which fetal bovine serum FBS (10%) was employed. Monolayers were grown in Dulbecco's modified Eagle's medium-Ham's F12 nutrient mixture containing insulin (10 μg/ml), bovine serum albumin fraction V (1 mg/ml) and fetuin (1 mg/ml). Cells in serum-free medium seeded at 1×10⁴ per cm² grew to confluency within 6 to 8 d and formed hemicysts or domes at a frequency equivalent to those in serum-containing medium. Electron microscopy of cultures grown in serum-free medium revealed polarized monolayers with the presence of microvilli and tight junctions. The differentiated characteristics, including sodium-dependent phosphate transport, the inhibition of this transport by parathyroid hormone (PTH), and the generation of cyclic AMP in response to PTH, were preserved in opossum kidney cells grown in serum-free medium.