Isoprene formation in Bacillus subtilis: a barometer of central carbon assimilation in a bioreactor?

Isoprene (2-methyl-1,3-butadiene) is a volatile hydrocarbon of uncertain function in Bacillus subtilis, and we hypothesized that it is an overflow metabolite produced during excess carbon utilization. Here we tested this idea for phase 2 of isoprene release, a phase that occurs during extracellular acetoin accumulation and its reassimilation. Phase 2 isoprene formation could be disrupted in three different ways, all related to acetoin metabolism. Disruption of a gene essential for acetoin biosynthesis (acetolactic acid synthase, alsS) blocked acetoin formation and led to cessation of phase 2 isoprene formation as well as a variety of pleiotropic effects related to loss of pH control. Growth of the alsS mutant with external pH control reversed most of these effects. Disruption of acetoin catabolism (acetoin dehydrogenase, acoA), also eliminated phase 2 isoprene formation and caused cells to transition directly from phase 1 to phase 3; the latter is attributed to amino acid catabolism. A third alteration of acetoin metabolism was detected in the widely used strain 168 (trpC2) but not in strain MS175, a trpC mutant constructed in the Marburg strain genetic background. Strain 168 exhibited slow acetoin assimilation compared to that of MS175 or the parental strain, with little or no isoprene formation during this growth phase. These findings support the idea that isoprene release occurs primarily when the rate of carbon catabolism exceeds anabolism and that this volatile hydrocarbon is a product of overflow metabolism when precursors are not required for higher isoprenoid biosynthesis. It is suggested that isoprene release might serve as a useful barometer of the rise and fall of central carbon fluxes during the growth of Bacillus strains in industrial bioreactors.     

Biotin synthase of Bacillus subtilis shows less reactivity than that of Escherichia coli in in vitro reaction systems

The biotin synthases of Bacillus subtilis and Escherichia coli were compared in a physiological reduction system using cell-free extracts and in a artificial reduction system using photo-reduced deazariboflavin. The biotin synthase of B. subtilis was less active than that of E. coli in both reaction systems and showed at least ten-fold less biotin-forming activity than that of E. coli in the artificial reduction system. The physiological reduction system using the biotin synthases and cell-free extracts of B. subtilis and E. coli showed species specificity. The results suggest that the activity of the physiological reduction system of B. subtilisis weaker than that of E. coli. Addition of excess dethiobiotin inhibited biotin formation by growing cells of B. subtilis, but not by E. coli.     

Enhancing isoprene production by genetic modification of the 1-deoxy-d-xylulose-5-phosphate pathway in Bacillus subtilis

To enhance the production of isoprene, a volatile 5-carbon hydrocarbon, in the Gram-positive spore-forming rod-shaped bacterium Bacillus subtilis, 1-deoxy-d-xylulose-5-phosphate synthase (Dxs) and 1-deoxy-d-xylulose-5-phosphate reductoisomerase (Dxr) were overexpressed in B. subtilis DSM 10. For the strain that overexpresses Dxs, the yield of isoprene was increased 40% over that by the wild-type strain. In the Dxr overexpression strain, the level of isoprene production was unchanged. Overexpression of Dxr together with Dxs showed an isoprene production level similar to that of the Dxs overproduction strain. The effects of external factors, such as stress factors including heat (48°C), salt (0.3 M NaCl), ethanol (1%), and oxidative (0.005% H(2)O(2)) stress, on isoprene production were further examined. Heat, salt, and H(2)O(2) induced isoprene production; ethanol inhibited isoprene production. In addition, induction and repression effects are independent of SigB, which is the general stress-responsive alternative sigma factor of Gram-positive bacteria.     

CDP-2,3-Di-O-geranylgeranyl-sn-glycerol:L-serine O-archaetidyltransferase (archaetidylserine synthase) in the methanogenic archaeon Methanothermobacter thermautotrophicus

CDP-2,3-di-O-geranylgeranyl-sn-glycerol:L-serine O-archaetidyltransferase (archaetidylserine synthase) activity in cell extracts of Methanothermobacter thermautotrophicus cells was characterized. The enzyme catalyzed the formation of unsaturated archaetidylserine from CDP-unsaturated archaeol and L-serine. The identity of the reaction products was confirmed by thin-layer chromatography, fast atom bombardment-mass spectrum analysis, and chemical degradation. The enzyme showed maximal activity in the presence of 10 mM Mn2+ and 1% Triton X-100. Among various synthetic substrate analogs, both enantiomers of CDP-unsaturated archaeols with ether-linked geranylgeranyl chains and CDP-saturated archaeol with ether-linked phytanyl chains were similarly active toward the archaetidylserine synthase. The activity on the ester analog of the substrate was two to three times higher than that on the corresponding ether-type substrate. The activity of D-serine with the enzyme was 30% of that observed for L-serine. A trace amount of an acid-labile, unsaturated archaetidylserine intermediate was detected in the cells by a pulse-labeling experiment. A gene (MT1027) in M. thermautotrophicus genome annotated as the gene encoding phosphatidylserine synthase was found to be homologous to Bacillus subtilis pssA but not to Escherichia coli pssA. The substrate specificity of phosphatidylserine synthase from B. subtilis was quite similar to that observed for the M. thermautotrophicus archaetidylserine synthase, while the E. coli enzyme had a strong preference for CDP-1,2-diacyl-sn-glycerol. It was concluded that M. thermautotrophicus archaetidylserine synthase belongs to subclass II phosphatidylserine synthase (B. subtilis type) on the basis of not only homology but also substrate specificity and some enzymatic properties. The possibility that a gene encoding the subclass II phosphatidylserine synthase might be transferred from a bacterium to an ancestor of methanogens is discussed.     

Cloning, sequencing, and expression in Escherichia coli of the Bacillus subtilis gene for phosphatidylserine synthase.

The Bacillus subtilis pss gene encoding phosphatidylserine synthase was cloned by its complementation of the temperature sensitivity of an Escherichia coli pssA1 mutant. Nucleotide sequencing of the clone indicated that the pss gene encodes a polypeptide of 177 amino acid residues (deduced molecular weight of 19,613). This value agreed with the molecular weight of approximately 18,000 observed for the maxicell product. The B. subtilis phosphatidylserine synthase showed 35% amino acid sequence homology to the yeast Saccharomyces cerevisiae phosphatidylserine synthase and had a region with a high degree of local homology to the conserved segments in some phospholipid synthases and amino alcohol phosphotransferases of E. coli and S. cerevisiae, whereas no homology was found with that of the E. coli counterpart. A hydropathy analysis revealed that the B. subtilis synthase is very hydrophobic, in contrast to the hydrophilic E. coli counterpart, consisting of several strongly hydrophobic segments that would span the membrane. A manganese-dependent phosphatidylserine synthase activity, a characteristic of the B. subtilis enzyme, was found exclusively in the membrane fraction of E. coli (pssA1) cells harboring a B. subtilis pss plasmid. Overproduction of the B. subtilis synthase in E. coli cells by a lac promoter system resulted in an unusual increase of phosphatidylethanolamine (up to 93% of the total phospholipids), in contrast to gratuitous overproduction of the E. coli counterpart. This finding suggested that the unusual cytoplasmic localization of the E. coli phosphatidylserine synthase plays a role in the regulation of the phospholipid polar headgroup composition in this organism.     

Light-Dependent Isoprene Emission (Characterization of a Thylakoid-Bound Isoprene Synthase in Salix discolor Chloroplasts)

Isoprene synthase is an enzyme that is responsible for the production of the volatile C5 hydrocarbon, isoprene, in plant leaves. Isoprene formation in numerous C3 plants is interesting because (a) large quantities of isoprene are emitted, 5 x 1014 g of C annually, (b) a plant may release 1 to 8% of its fixed C as isoprene, and (c) the function of plant isoprene production is unknown. Because of the dependence of foliar isoprene emission on light, the existence of a plastidic isoprene synthase has been postulated. To pursue this idea, a method to isolate chloroplasts from Salix discolor was developed and shows a plastidic isoprene synthase that is tightly bound to the thylakoid membrane and accessible to trypsin inactivation. The thylakoid-bound isoprene synthase has catalytic properties similar to known soluble isoprene synthases; however, the relationship between these enzymes is unknown. The discovery of a thylakoid-bound isoprene synthase with a stromal-facing domain places it in the chloroplast, where it may be subject to numerous direct and indirect light-mediated effects. Implications for the light-dependent regulation of foliar isoprene production and its function are presented.     

CMP activates reversal of phosphatidylinositol synthase and base exchange by distinct mechanisms in rat pituitary GH3 cells.

CMP is known to activate phosphatidylinositol (PtdIns)/inositol (Ins) base exchange and has been reported to activate reversal of PtdIns synthase also. Because it is possible that PtdIns synthase acting in the reverse direction, followed by re-incorporation of ambient Ins, could be responsible for base-exchange activity, we characterized these processes in rat pituitary GH3 cells. In permeabilized GH3 cells prelabelled with [3H]Ins and incubated in buffer with LiCl but without added Ins, CMP stimulated rapid accumulation of [3H]Ins and decreases in [3H]PtdIns; the Km for CMP was 1.7 mM. CDP and CTP were less effective, whereas 2'-CMP, 3'-CMP, other nucleoside monophosphates and cytidine did not influence this process. In permeabilized cells prelabelled to isotopic equilibrium with [3H]Ins and [32P]Pi, CMP stimulated decreases in both the 32P and 3H labelling of PtdIns, but did not increase that of [32P]phosphatidic acid. These findings demonstrate that in the absence of added Ins the effect of CMP is not via activation of base exchange nor via a phospholipase D, but by reversal of PtdIns synthase. In permeabilized cells prelabelled with [3H]Ins and [32P]Pi, unlabelled Ins inhibited loss of 32P labelling of PtdIns caused by CMP while markedly stimulating loss of 3H labelling of PtdIns and release of [3H]Ins. These data demonstrate that Ins inhibits reversal of PtdIns synthase, but stimulates base exchange. We conclude that in GH3 cells reversal of PtdIns synthase and PtdIns/Ins base exchange are both stimulated by CMP, but are distinct processes.     

Isoprene synthesis in plants: lessons from a transgenic tobacco model

Isoprene is a highly reactive gas, and is emitted in such large quantities from the biosphere that it substantially affects the oxidizing potential of the atmosphere. Relatively little is known about the control of isoprene emission at the molecular level. Using transgenic tobacco lines harbouring a poplar isoprene synthase gene, we examined control of isoprene emission. Isoprene synthase required chloroplastic localization for catalytic activity, and isoprene was produced via the methyl erythritol (MEP) pathway from recently assimilated carbon. Emission patterns in transgenic tobacco plants were remarkably similar to naturally emitting plants under a wide variety of conditions. Emissions correlated with photosynthetic rates in developing and mature leaves, and with the amount of isoprene synthase protein in mature leaves. Isoprene synthase protein levels did not change under short-term increase in heat/light, despite an increase in emissions under these conditions. A robust circadian pattern could be observed in emissions from long-day plants. The data support the idea that substrate supply and changes in enzyme kinetics (rather than changes in isoprene synthase levels or post-translational regulation of activity) are the primary controls on isoprene emission in mature transgenic tobacco leaves.     

异戊二烯合成酶研究进展

异戊二烯(Isoprene)的排放具有特殊的生物学功能,对大气环境具有重要影响,另外,异戊二烯也是一种具有广泛用途的化合物。在生物体内,异戊二烯是由异戊二烯合成酶(Isoprene synthase,Isps)催化烯丙基二磷酸(Dimethylallyl diphosphate,DMAPP)脱去焦磷酸(Pyrophosphate)而生成的。因此,作为异戊二烯合成过程中的关键酶,Isps在异戊二烯的自然排放和生物合成过程都发挥着重要的作用,对Isps的研究具有非常重要的意义。到目前为止,已经在多种植物中发现了该酶,研究表明,来源于不同生物的异戊二烯合成酶具有保守的结构特征和相似的生化性质。文中就Isps的最新研究进展进行综述,包括比较分析不同生物来源Isps的生化特征和结构特征,探讨催化机制,并对该酶在生物工程领域的应用进行展望。     

Permeabilization of Bacillus subtilis to chemotaxis methyltransferase II.

Treatment of Bacillus subtilis with 0.4% (vol/vol) toluene renders cells permeable not only to small molecules but also apparently to proteins as large as 30,000 daltons. Methyl-accepting chemotaxis proteins and two smaller polypeptides were methylated when B. subtilis methyltransferase II was added to permeabilized cells.     

Isoprene synthase activity and its relation to isoprene emission in Quercus robur L. leaves

Pedunculate oak ( Quercus robur L.) is known as a strong isoprene (2-methyl-1,3-butadiene) emitter. Diurnal changes in isoprene emission were determined by branch enclosure measurements. In contrast to the diurnal cycle in emission rates, specific isoprene synthase activity in the leaves remained unchanged. Based on in vitro enzyme activity and its temperature dependency, an isoprene synthesis capacity at specific leaf temperatures was calculated. The comparison of these 'leaf temperature-dependent enzyme capacities' and the measured emission rates revealed that the enzyme activity of isoprene synthase is comparable to the observed isoprene emission rates. In addition, variation in the isoprene synthase activity of the leaves due to changes in light intensity during leaf development was investigated. A 50% reduction of light intensity by shading of single branches reduced isoprene synthase activity by ≈ 60% compared with full sunlight. The calculation of isoprene synthesis capacities based on enzymatic data obtained under optimum reaction conditions, corrected for actual leaf temperature and related to leaf surface area, provides a sound basis for predicting the isoprene emission potential of plants.     

Effect of temperature on postillumination isoprene emission in oak and poplar

Isoprene emission from broadleaf trees is highly temperature dependent, accounts for much of the hydrocarbon emission from plants, and has a profound effect on atmospheric chemistry. We studied the temperature response of postillumination isoprene emission in oak (Quercus robur) and poplar (Populus deltoides) leaves in order to understand the regulation of isoprene emission. Upon darkening a leaf, isoprene emission fell nearly to zero but then increased for several minutes before falling back to nearly zero. Time of appearance of this burst of isoprene was highly temperature dependent, occurring sooner at higher temperatures. We hypothesize that this burst represents an intermediate pool of metabolites, probably early metabolites in the methylerythritol 4-phosphate pathway, accumulated upstream of dimethylallyl diphosphate (DMADP). The amount of this early metabolite(s) averaged 2.9 times the amount of plastidic DMADP. DMADP increased with temperature up to 35°C before starting to decrease; in contrast, the isoprene synthase rate constant increased up to 40°C, the highest temperature at which it could be assessed. During a rapid temperature switch from 30°C to 40°C, isoprene emission increased transiently. It was found that an increase in isoprene synthase activity is primarily responsible for this transient increase in emission levels, while DMADP level stayed constant during the switch. One hour after switching to 40°C, the amount of DMADP fell but the rate constant for isoprene synthase remained constant, indicating that the high temperature falloff in isoprene emission results from a reduction in the supply of DMADP rather than from changes in isoprene synthase activity.     

First isolation of an isoprene synthase gene from poplar and successful expression of the gene in Escherichia coli

For the first time, the complete functional gene for isoprene synthase has been isolated from poplar (Populus alba x Populus tremula). The gene was quite similar to known limonene and other monoterpene synthases, but was found to specifically catalyze the formation of isoprene from the precursor dimethylallyl diphosphate with only a marginal activity for the formation of the monoterpene limonene from geranyl diphosphate as compared with limonene synthases. Omitting the part of the gene that putatively encoded the signal peptide necessary for transport into the chloroplast led to an enhanced rate of isoprene formation by the recombinant protein.     

Evolution of the isoprene biosynthetic pathway in kudzu

Isoprene synthase converts dimethylallyl diphosphate, derived from the methylerythritol 4-phosphate (MEP) pathway, to isoprene. Isoprene is made by some plants in substantial amounts, which affects atmospheric chemistry, while other plants make no isoprene. As part of our long-term study of isoprene synthesis, the genetics of the isoprene biosynthetic pathway of the isoprene emitter, kudzu (Pueraria montana), was compared with similar genes in Arabidopsis (Arabidopsis thaliana), which does not make isoprene. The MEP pathway genes in kudzu were similar to the corresponding Arabidopsis genes. Isoprene synthase genes of kudzu and aspen (Populus tremuloides) were cloned to compare their divergence with the divergence seen in MEP pathway genes. Phylogenetic analysis of the terpene synthase gene family indicated that isoprene synthases are either within the monoterpene synthase clade or sister to it. In Arabidopsis, the gene most similar to isoprene synthase is a myrcene/ocimene (acyclic monoterpenes) synthase. Two phenylalanine residues found exclusively in isoprene synthases make the active site smaller than other terpene synthase enzymes, possibly conferring specificity for the five-carbon substrate rather than precursors of the larger isoprenoids. Expression of the kudzu isoprene synthase gene in Arabidopsis caused Arabidopsis to emit isoprene, indicating that whether or not a plant emits isoprene depends on whether or not it has a terpene synthase capable of using dimethylallyl diphosphate.     

Implications of secondary structure prediction and amino acid sequence comparison of class I and class II phosphoribosyl diphosphate synthases on catalysis, regulation, and quaternary structure

Spinach 5-phospho-D-ribosyl alpha-1-diphosphate (PRPP) synthase isozyme 4 was synthesized in Escherichia coli and purified to near homogeneity. The activity of the enzyme is independent of P(i); it is inhibited by ADP in a competitive manner, indicating a lack of an allosteric site; and it accepts ATP, dATP, GTP, CTP, and UTP as diphosphoryl donors. All of these properties are characteristic for class II PRPP synthases. K(m) values for ATP and ribose 5-phosphate are 77 and 48 microM, respectively. Gel filtration reveals a molecular mass of the native enzyme of approximately 110 kD, which is consistent with a homotrimer. Secondary structure prediction shows that spinach PRPP synthase isozyme 4 has a general folding similar to that of Bacillus subtilis class I PRPP synthase, for which the three-dimensional structure has been solved, as the position and extent of helices and beta-sheets of the two enzymes are essentially conserved. Amino acid sequence comparison reveals that residues of class I PRPP synthases interacting with allosteric inhibitors are not conserved in class II PRPP synthases. Similarly, residues important for oligomerization of the B. subtilis enzyme show little conservation in the spinach enzyme. In contrast, residues of the active site of B. subtilis PRPP synthase show extensive conservation in spinach PRPP synthase isozyme 4.     

Biocontrol of Bacillus subtilis against infection of Arabidopsis roots by Pseudomonas syringae is facilitated by biofilm formation and surfactin production

Relatively little is known about the exact mechanisms used by Bacillus subtilis in its behavior as a biocontrol agent on plants. Here, we report the development of a sensitive plant infection model demonstrating that the bacterial pathogen Pseudomonas syringae pv tomato DC3000 is capable of infecting Arabidopsis roots both in vitro and in soil. Using this infection model, we demonstrated the biocontrol ability of a wild-type B. subtilis strain 6051 against P. syringae. Arabidopsis root surfaces treated with B. subtilis were analyzed with confocal scanning laser microscopy to reveal a three-dimensional B. subtilis biofilm. It is known that formation of biofilms by B. subtilis is a complex process that includes secretion of surfactin, a lipopeptide antimicrobial agent. To determine the role of surfactin in biocontrol by B. subtilis, we tested a mutant strain, M1, with a deletion in a surfactin synthase gene and, thus, deficient in surfactin production. B. subtilis M1 was ineffective as a biocontrol agent against P. syringae infectivity in Arabidopsis and also failed to form robust biofilms on either roots or inert surfaces. The antibacterial activity of surfactin against P. syringae was determined in both broth and agar cultures and also by live-dead staining methods. Although the minimum inhibitory concentrations determined were relatively high (25 microg mL(-1)), the levels of the lipopeptide in roots colonized by B. subtilis are likely to be sufficient to kill P. syringae. Our results collectively indicate that upon root colonization, B. subtilis 6051 forms a stable, extensive biofilm and secretes surfactin, which act together to protect plants against attack by pathogenic bacteria.     

High-level expression of Escherichia coli and Bacillus subtilis thymidylate synthases

Procedures are described for the preparation of highly purified thymidylate synthases from Escherichia coli and Bacillus subtilis. The yields in each case are quite high with about 350 mg of pure protein obtained from 1 liter of cells. Basically all that is required to obtain pure enzyme is an induction step from a high-expression vector, followed by a DE-52 column elution. Both enzymes appeared to be fairly stable in that incubation at 43 degrees C for 10 min resulted in the loss of 50% of the E. coli thymidylate synthase activity, while 50 degrees C for 10 min was required to obtain the same effect with the B. subtilis enzyme. In the presence of the substrate, dUMP, each protein was stabilized further by 6 to 7 degrees C, which was increased to 9 to 10 degrees C on addition of dihydrofolate. It was shown also that the E. coli thymidylate synthase could be maintained at 4 degrees C for at least 4 months with little or no loss in activity provided that mercaptoethanol was not present. The presence of the latter led to a progressive loss in activity until little activity could be detected after 18 weeks, which was due, in part, to the formation of a disulfide bond with the active site cysteine. Addition of dithiothreitol restored the enzyme activity to its original state.     

Biochemical Characterization of Stromal and Thylakoid-Bound Isoforms of Isoprene Synthase in Willow Leaves

Isoprene synthase is the enzyme responsible for the foliar emission of the hydrocarbon isoprene (2-methyl-1,3-butadiene) from many C₃ plants. Previously, thylakoid-bound and soluble forms of isoprene synthase had been isolated separately, each from different plant species using different procedures. Here we describe the isolation of thylakoid-bound and soluble isoprene synthases from a single willow (Salix discolor L.) leaf-fractionation protocol. Willow leaf isoprene synthase appears to be plastidic, with whole-leaf and intact chloroplast fractionations yielding approximately equal soluble (i.e. stromal) and thylakoid-bound isoprene synthase activities. Although thylakoid-bound isoprene synthase is tightly bound to the thylakoid membrane (M.C. Wildermuth, R. Fall [1996] Plant Physiol 112: 171–182), it can be solubilized by pH 10.0 treatment. The solubilized thylakoid-bound and stromal isoprene synthases exhibit similar catalytic properties, and contain essential cysteine, histidine, and arginine residues, as do other isoprenoid synthases. In addition, two regulators of foliar isoprene emission, leaf age and light, do not alter the percentage of isoprene synthase activity in the bound or soluble form. The relationship between the isoprene synthase isoforms and the implications for function and regulation of isoprene production are discussed.     

Biochemical characterization and homology modeling of methylbutenol synthase and implications for understanding hemiterpene synthase evolution in plants

2-Methyl-3-buten-2-ol (MBO) is a five-carbon alcohol produced and emitted in large quantities by many species of pine native to western North America. MBO is structurally and biosynthetically related to isoprene and can have an important impact on regional atmospheric chemistry. The gene for MBO synthase was identified from Pinus sabiniana, and the protein encoded was functionally characterized. MBO synthase is a bifunctional enzyme that produces both MBO and isoprene in a ratio of ~90:1. Divalent cations are required for activity, whereas monovalent cations are not. MBO production is enhanced by K(+), whereas isoprene production is inhibited by K(+) such that, at physiologically relevant [K(+)], little or no isoprene emission should be detected from MBO-emitting trees. The K(m) of MBO synthase for dimethylallyl diphosphate (20 mm) is comparable with that observed for angiosperm isoprene synthases and 3 orders of magnitude higher than that observed for monoterpene and sesquiterpene synthases. Phylogenetic analysis showed that MBO synthase falls into the TPS-d1 group (gymnosperm monoterpene synthases) and is most closely related to linalool synthase from Picea abies. Structural modeling showed that up to three phenylalanine residues restrict the size of the active site and may be responsible for making this a hemiterpene synthase rather than a monoterpene synthase. One of these residues is homologous to a Phe residue found in the active site of isoprene synthases. The remaining two Phe residues do not have homologs in isoprene synthases but occupy the same space as a second Phe residue that closes off the isoprene synthase active site.