The rapid estimation of microbial contamination of raw meat by measurement of adenosine triphosphate (ATP)

Bacteria were separated from raw meat homogenate by a simple three-stage process. Centrifugation (10 s at 2000 g) removed coarse particles; stirring with the cation exchange resin Bio-Rex 70 removed smaller particles and filtration through 0.22 μm membranes removed soluble materials. By this process 70—80% of the microbial populations of meat homogenates were consistently isolated on the filters. A linear relationship was found between log₁₀ microbial ATP and log₁₀ colony count of meat over the range 10⁵—10⁹ cfu/g. The value of ATP/cfu for meat samples was within the range previously reported for pure cultures. These data indicated that ATP extracted from the filters originated from bacteria in the meat samples. Several samples can be analysed simultaneously in an elapsed time of 20—25 min. The variability associated with estimates of both colony counts and ATP levels has been determined.     

Survival of Campylobacter jejuni in chicken meat at frozen storage temperatures

The aim of this study was to determine the survival of Campylobacter jejuni in chicken meat samples at frozen temperatures and given length of incubation and to determine the impact of aerobic bacteria on the survival of C. jejuni. The chicken meat samples were inoculated with C. jejuni NCTC 11351 suspensions and stored in bags at temperatures of -20°C and -70°C. The mean value of C. jejuni from meat samples decreased from 7.52 log10 CFU/g after 30 minutes of incubation at ambient temperature, to 3.87 log10 CFU/g on the eighth week of incubation at -20°C, and to 3.78 log10 CFU/g at incubation at -70°C after the same incubation period. Both freezing temperatures, -20°C and -70°C, decreased the number of campylobacters. The presence of aerobic mesophilic bacteria did not influence the survival of C. jejuni in chicken meet samples. Keeping poultry meat at freezing temperatures is important for the reduction of C. jejuni, which has a strong influence on the prevention of occurrence of campylobacteriosis in humans.     

Safety and quality of some chicken meat products in Al-Ahsa markets-Saudi Arabia

One hundred samples of 10 poultry meat products were collected from AL-Ahsa markets (Kingdom of Saudi Arabia). The samples were ranked from carcass cuts (chilled, frozen, fillet and thigh) to minced meat or further processed products as burger, nuggets, frankfurter and meat paste loaf. Samples were collected in triplicate for sensory, chemical and microbiological analysis to assure their quality and safety.The obtained results revealed variation in chemical composition; some products with high fat percentage had a high thiobarbituric acid value, which resulted in the appearance of an unacceptable flavor.Bacteriological analysis revealed that the mean total bacterial count was ranged from 2.7 × 10⁴ cfu/g for nuggets^A to 3.3 × 10⁷ cfu/g for burger^B and the other products in the range of 10⁵–10⁶ cfu/g. While Staphylococcus aureus mean count ranged from less than 10² cfu/g for all samples, accept 10⁴ and 10⁶ cfu/g for mince^B and frankfurter samples, respectively. Escherichia coli isolated from 70% of the samples and Salmonella arizona was isolated at once from thigh samples. Thirty percentages of samples not comply with Saudi Standards due to sensory unacceptability and 21% of samples nonconforming with bacteriological specifications.     

Comparison of two selective media for the detection and enumeration of Lactobacilli in human faeces

The enumeration of faecal bacteria is an important requirement for many studies of bowel health. One approach is the use of selective culture media for the culture and identification of genera or species from faeces. This study compares the culture of Lactobacilli from dilution series of faecal samples from six healthy human volunteers on two commonly used media, LAMVAB and Rogosa agar. Colonies were counted after a 72-h anaerobic incubation at 37 degrees C, and colony morphology recorded by a single observer. DNA was isolated from a representative number of colonies and genus-specific PCR, single-stranded conformation polymorphism (SSCP) and DNA sequencing performed. Total colony counts ranged from <3.00 to 7.48 log(10) cfu/g of faeces for LAMVAB and 5.09 to 7.66 log(10) cfu/g for Rogosa. For each subject, the total colony count was higher on Rogosa than that obtained with LAMVAB agar. SSCP analysis and DNA sequencing indicated that colony morphology was not an accurate predictor of genus identity. Growth of two species, Lactobacillus acidophilus and Lactobacillus gasseri, was not supported on LAMVAB medium. Rogosa agar was more likely to support growth of non-Lactobacillus species. Therefore, neither medium gave a fully accurate representation of the Lactobacilli species present in human faecal samples.     

Microbiological condition and shelf life of meat from hunted game birds

Hunted game birds (eight partridges, nine wood pigeons, 25 quails, 16 chilled and 16 frozen–thawed pheasants) were processed according to “Good Manufacturing Practice” rules. Microflora of skin, intestinal content and meat cuts (breast and thigh, both fresh and stored in vacuum package) was analysed. Listeria monocytogenes, Salmonella sp. and Campylobacter sp. were not recovered from any sample. Log microbial numbers on skin or in intestines were not significantly related to those on meat cuts. With the exception of pigeons, microbial numbers of the two meat cuts did not differ significantly (p > 0.05), and no significant increase in microbial numbers in vacuum-stored meat was found; the same applied to frozen–thawed compared to chilled pheasants. On meat, average total viable counts were <4.00 log cfu/cm² with a maximum of 6.48 log cfu/cm². Median Escherichia coli numbers were <2.00 log cfu/cm², maximum was 4.48 log cfu/cm². Meat cuts obtained from partridges, quails and pheasants demonstrated a shelf life of 1 week, provided they were kept vacuum-packaged at 0°C to 1°C.     

Incidence and identification of mesophilic Aeromonas spp. from retail foods

Sixty-eight food samples were examined for the presence of mesophilic Aeromonas species both qualitatively and quantitatively. Aeromonads were isolated from 26% of the vegetable samples, 70% of the meat and poultry samples and 72% of the fish and shrimps. Numbers of motile aeromonads present in the food samples varied from <10(2) cfu g(-1) to >10(5) cfu g(-1). GLC analysis of FAMEs was used to identify a selection of presumptive Aeromonas colonies to fenospecies or genomic species level. Aeromonas strains belonging to the Aer. caviae complex, which also includes the potentially pathogenic genospecies HG4, were mostly isolated from vegetables but were also found in meat, poultry and fish. In addition, three strains of the virulent taxon Aer. veronii biovar sobria HG8 were isolated from poultry and minced meat. All members of the Aer. hydrophila complex, predominant in the fish, meat and poultry samples, were classified in the non-virulent taxon HG3. Although the significance of Aeromonas in foods remains undefined, the isolation of Aeromonas HG4 and HG8 strains from a variety of retail foods may indicate that these products can act as possible vehicles for the dissemination of food-borne Aeromonas gastroenteritis.     

Post-processing microflora and the shelf stability of gari marketed in Port Harcourt

Gari was examined for its post-processing microbial content. Aerobic mesophilic bacteria and fungi were isolated from all samples. The total viable bacterial counts ranged from 2.0 X 10(2) to 8.0 X 10(4) cfu/g. Fungal counts ranged from 1.0 X 10(2) to 1.5 X 10(4) cfu/g. The total viable counts of fresh samples were much lower than those of market and packaged samples. Bacillus, Micrococcus and Proteus spp. were the bacteria isolated, Aspergillus niger, Aspergillus flavus and Penicillium spp. the fungi. Food borne parasites and pathogens such as Staph. aureus and Clostridium perfringens were not found. The gari samples were quite stable, having a shelf life of 3-6 months. The water activities of the samples ranged from 0.52 to 0.68. Based on the microbial counts of the samples, the critical upper limit for the safety of gari was set at 10(4) cfu/g dry sample.     

Removal of pathogen and indicator microorganisms from liquid swine manure in multi-step biological and chemical treatment

Concern has greatly increased about the potential for contamination of water, food, and air by pathogens present in manure. We evaluated pathogen reduction in liquid swine manure in a multi-stage treatment system where first the solids and liquid are separated with polymer, followed by biological nitrogen (N) removal using nitrification and denitrification, and then phosphorus (P) extraction through lime precipitation. Each step of the treatment system was analyzed for Salmonella and microbial indicators of fecal contamination (total coliforms, fecal coliforms, and enterococci). Before treatment, mean concentrations of Salmonella, total coliforms, fecal coliforms, and enterococci were 3.89, 6.79, 6.23 and 5.73 log(10) colony forming units (cfu)/ml, respectively. The flushed manure contained 10,590 mg/l TSS, 8270 mg/l COD, 688 mg/l TKN and 480 mg/l TP, which were reduced >98% by the treatment system. Results showed a consistent trend in reduction of pathogens and microbial indicators as a result of each step in the treatment system. Solid-liquid separation decreased their concentrations by 0.5-1 log(10). Additional biological N removal treatment with alternating anoxic and oxic conditions achieved a higher reduction with average removals of 2.4 log(10) for Salmonella and 4.1-4.5 log(10) for indicator microbes. Subsequent P treatment decreased concentration of Salmonella and pathogen indicators to undetectable level (<0.3 log(10) cfu/ml) due to elevated process pH (10.3). Our results indicate that nitrification/denitrification treatment after solids separation is very effective in reducing pathogens in liquid swine manure and that the phosphorus removal step via alkaline calcium precipitation produces a sanitized effluent which may be important for biosecurity reasons.     

Survival of Salmonella in peanut butter and peanut butter spread

In 1996, the first documented outbreak of salmonellosis associated with the consumption of peanut butter was reported. This study was undertaken to determine survival characteristics of high (5.68 log10 cfu g(-1)) and low (1.51 log10 cfu g(-1)) inocula of a five-serotype mixture of Salmonella in five commercial peanut butters and two commercial peanut butter spreads. Populations in samples inoculated with 5.68 log10 cfu g(-1) and stored for 24 weeks at 21 or 5 degrees C decreased 4.14-4.50 log10 cfu g(-1) and 2.86-4.28 log10 cfu g(-1), respectively, depending on the formulation. The order of retention of viability was: peanut butter spreads > traditional (regular) and reduced sugar, low-sodium peanut butters > natural peanut butter. Differences in rates of inactivation are attributed to variation in product composition as well as size and stability of water droplets in the colloidal matrix, which may influence nutrient availability. With the exception of natural peanut butter, products initially inoculated with 1.51 log10 cfu of Salmonella g(-1) (32 cfu g(-1)) were positive for the pathogen after storage for 24 weeks at 5 degrees C. At 21 degrees C, however, with the exception of one peanut butter spread, all products were negative for Salmonella after storage for 24 weeks. Post-process contamination of peanut butter and spreads with Salmonella may to result in survival in these products for the duration of their shelf life at 5 degrees C and possibly 21 degrees C, depending on the formulation.     

Development of a surface adhesion immunofluorescent technique for the rapid isolation of Listeria monocytogenes and Listeria innocua from meat

The use of a novel surface adhesion technique to isolate Listeria monocytogenes and Listeria innocua from an enrichment meat system was developed. Minced beef samples inoculated with L. monocytogenes (10 cfu g(-1)) were incubated at 30 degrees C for 14-18 h in a suitable enrichment broth. Listeria monocytogenes cells were isolated from the enriched meat sample by surface adhesion onto a polycarbonate membrane which was attached to a glass microscope slide. The Listeria cells on the membrane were subsequently visualized using an immunofluorescent microscopy procedure. The antibody used in this technique reacts with L. monocytogenes and L. innocua. The technique was demonstrated to have a detection level of log10 3.11 cfu ml(-1). There was excellent correlation (r2 = 0.98) between the counts obtained by this surface adhesion immunofluorescent (SAIF) technique and counts obtained using traditional methods, i.e. plate counts on PALCAM. When the regression equation relating the rapid and standard methods was validated using the data from 50 retail beef mince samples, an rsd value of +/- 0.25 was obtained. No false-negative or false-positive results were recorded for L. monocytogenes or L. innocua species using the SAIF technique.     

Distribution and sources of microbial contamination on beef carcasses

Three beef dressing lines of different capacity (160, 440 and 800 head d(-1)) were investigated with respect to contamination associated with carcass/hide and carcass/faeces contacts, the distribution of microbial contamination on carcasses and the antimicrobial efficacy of cold water carcass washes. Swab samples were taken from up to 17 sites for determination of Aerobic Plate Counts at 37 degrees C (APC 37 degrees C) and Escherichia coli enumeration using the Petrifilm procedure. The three beef dressing systems produced virtually identical patterns of microbial contamination. High contamination was found at those sites associated with opening cuts and/or subject to hide contact during hide removal. Where contamination is intermittent, the use of mean microbial data tended to obscure evidence of faecal or hide contact. Consequently, worst-case results, as represented by the 95th percentile value, were used to identify probable instances and sources of contact contamination. Sites not subject to faecal contamination or hide contact typically had swab sample APC (37 degrees C) values of less than log 2.00 cfu cm(-2) accompanied by the occasional detection of E. coli at levels below log 1.00 cfu cm(-2). Sites contacted by 'clean' hide typically had APC (37 degrees C) counts of log 3.00 cfu cm(-2) or greater accompanied by occasional E. coli counts not exceeding log 2.00 cfu cm(-2). Sites contaminated by direct faecal contact or contact with faecally contaminated hides typically had APC (37 degrees C) counts equal to, or greater than, log 4.00 cfu cm(-2) accompanied by E. coli counts exceeding log 2.00 cfu cm(-2). Cold water carcass washing was ineffective in removing microbial contamination and tended to bring about a posterior to anterior redistribution, resulting in increased counts at forequarter sites.     

侗族传统发酵肉的微生物特性

目的：对侗族传统发酵肉的微生物生态系的构成进行分析。方法：稀释平板法,结果：乳酸细菌在发酵30d达到最大值,4个处理的logCFU/g值均在8.2以上;280个MRS平板分离物中,米酒乳杆菌占37.91%,片球菌占20.71%。MSA平板培养物在发酵全过程中,均呈上升趋势;60d后,4个处理的logCFU/g值平均为5.5,增加了2.0;腐生葡萄球菌、肉葡萄球菌和木糖葡萄球菌是其优势菌群。酵母菌的数量在发酵过程中未见明显增加,发酵完毕,菌数的logCFU/g值在5.7左右,鉴定结果表明主要是德巴利酵母和球拟酵母。革兰阴性的肠细菌群发酵50d后,其logCFU/g值在2.0以下,结论：对发酵肉品微生态系的不断了解和肉品发酵技术不断完善,将为人们提供新颖、营养、安全的食品。     

COMPARISON OF LUMINOL CHEMILUMINESCENCE WITH ATP BIOLUMINESCENCE FOR THE ESTIMATION OF TOTAL BACTERIAL LOAD IN PURE CULTURES

A rapid chemiluminescent assay of total bacterial load that is based on the oxidation of luminol (5-amino-2,3-dihydro-1,4-phthalazinedione) as catalyzed by bacterial iron protoporphyrins is described and compared to the ATP bioluminescent assay of microbial biomass. An assay format that elicits linear light output response to a range of analyte concentrations of model compounds such as hematin and various heme-containing enzymes within the dynamic range of a BioOrbit 1251 luminometer is presented. When the assay was applied to eight pure bacterial cultures, the sensitivity was typically in the range of 10⁴-10⁵ cfu/ml, and was comparable to that obtained by the ATP assay. Similar levels of sensitivity can be derived from estimates of average values of 2.8 × 10^-18 mole of heme/cfu and 1 × 10^-19 mole of ATP/cfu. The potential of the luminal assay as an alternative rapid test for the estimation of total bacterial count in food and environmental samples is discussed.     

An acute osteomyelitis model in traumatized rat tibiae involving sand as a foreign body, thermal injury, and bimicrobial contamination

The multfactorial nature of bone injuries in modern warfare and emergency trauma patients warrants enhancement of existing models. To develop a more appropriate model, rat tibiae (n = 195) were mechanically injured, divided into 2 groups (with or without thermal injury), and contaminated with a range of Staphylococcus aureus (Cowan 1) inocula. In some experiments, S. aureus inocula also contained Escherichia coli or foreign bodies (sand or soil). The primary outcome measure was the amount of S. aureus remaining in the tibia (tibial bacterial load) 24 h after contamination, reported as log10 cfu/g bone. S. aureus showed ID50 and ID95 values of 72 and 977 cfu, respectively. Values were lower than seen previously by using S. aureus strain SMH. S. aureus tibial bacterial loads were higher in tibiae with mechanical and thermal injury (log10 4.15 +/- 0.27 cfu/g) versus mechanical injury alone (log10 3.1 +/- 0.47 cfu/g, P = 0.028). The addition of E. coli to the S. aureus inoculum had no effect on tibial bacterial loads (S. aureus only, log10 4.24 +/- 0.92 cfu/g; S. aureus + E. coli, log10 4.1 +/- 1.0 cfu/g, P = 0.74). Sand, added as a foreign body, increased tibial bacterial load. Combined mechanical and thermal trauma of the tibia is associated with increased S. aureus tibial bacterial loads, increasing the risk of acute osteomyelitis. Understanding the interplay of mechanical and thermal injuries, bimicrobial contamination, and foreign bodies may improve our understanding of traumatic bone injuries and the pathogenesis of osteomyelitis.     

Prevalence of Campylobacter spp. in turkey meat from a slaughterhouse and in turkey meat retail products

One hundred and forty-four samples of chilled turkey meat from six flocks, taken directly from the slaughterhouse, and 100 samples of turkey meat retail products were examined. Over one-quarter (29.2%) of the tested samples from the slaughterhouse were Campylobacter positive, showing high variability in the flocks. The lowest percentage of Campylobacter-positive samples was found in flocks I and III (8.3%), whereas, in flock VI, 91.7% of the samples were Campylobacter positive. Turkey meat retail products showed a prevalence of 34% for Campylobacter. Heat-treated meat was negative for Campylobacter. Quantitative studies of the samples taken at the slaughterhouse revealed a mean log range of 1.9-2.5 CFU g(-1)Campylobacter spp. Results from the quantification of retail products gave a mean log value of 2.1 CFU g(-1).     

Survival of Campylobacter jejuni on beef trimmings during freezing and frozen storage

AIMS: To investigate the survival of two animal isolates of Campylobacter jejuni on beef trimmings during freezing and frozen storage. METHODS AND RESULTS: Meat packs inoculated with 10(3) or 10(6) cfu g(-1) of either strain of C. jejuni were frozen to -18 degrees C, and sampled at regular intervals over 112 d storage to determine Campylobacter numbers and sublethal injury. For both strains and inoculation levels the numbers of Campylobacter decreased in the first 7 d of storage by ca. 0.6-2.2 log cfu g(-1) and then remaining constant over the remainder of the storage trial, with neither isolate exhibiting sublethal injury. CONCLUSIONS: Despite an initially significant decrease in number, these pathogens were able to survive standard freezing conditions in meat, but did not exhibit sublethal injury. SIGNIFICANCE AND IMPACT OF THE STUDY: Strict hygiene and/or the implementation of decontamination technologies are recommended as a means to assure the safety of meat with respect to this pathogen.     

The microbial association of Greek taverna sausage stored at 4 and 10 degrees C in air, vacuum or 100% carbon dioxide, and its spoilage potential

Strains of the Lactobacillus sakei/curvatus group, mainly non-slime-producing Lact. sakei, dominated the microbial flora of industrially manufactured taverna sausage, a traditional Greek cooked meat, stored at 4 degrees C and 10 degrees C in air, vacuum and 100% CO2. Atypical, arginine-positive and melibiose-negative strains of this group were isolated. The isolation frequency of Lact. sakei/curvatus from sausages stored anaerobically was as high as 92-96%, while other meat spoilage organisms were practically absent. Conversely, in air-stored sausages, leuconostocs, mainly Leuconostoc mesenteroides ssp. mesenteroides, had a considerable presence (14-21%), whereas Brochothrix thermosphacta, pseudomonads and Micrococcaceae grew, but failed to increase above 10(5) cfu g(-1) in all samples during storage. Only yeasts were able to compete against LAB and reached almost 10(7) cfu g(-1) after 30 d of aerobic storage at 10 degrees C. The great dominance (> 10(8) cfu g(-1)) of LAB caused a progressive decrease of pH and an increase of the concentration of L-lactate, D-lactate and acetate in all sausage packs. The growth of LAB and its associated chemical changes were more pronounced at 10 degrees C than 4 degrees C. At both storage temperatures, L-lactate and acetate increased more rapidly and to a higher concentration aerobically, unlike D-lactate, which formed in higher amounts anaerobically. Storage in air was the worst packaging method, resulting in greening and unpleasant off-odours associated with the high acetate content of the sausages. Carbon dioxide had no significant effect on extending shelf-life. The factors affecting the natural selection of Lact. sakei/curvatus in taverna sausage are discussed. Moreover, it was attempted to correlate the metabolic activity of this group with the physicochemical changes and the spoilage phenomena occurring in taverna sausage under the different storage conditions.     

Control of foodborne pathogens during sufu fermentation and aging

Control of the foodborne pathogens Escherichia coli O157:H7, Salmonella typhimurium, Staphylococcus aureus, and Listeria monocytogenes during sufu fermentation was evaluated. Before fermentation, pathogens were inoculated onto tofu (substrate for sufu) at 5 log cfu/g or 3 log cfu/g, and starter culture (Actinomucor elegans) was inoculated at 3 log cfu/g. After 2 days of fermentation at 30 degrees C, the four pathogens reached 7 to 9 log cfu/g, and the mold count reached 6 to 7 log cfu/g. After fermentation, sufu samples were aged in a solution of 10% alcohol + 12% NaCl. After 1 month of aging, the total bacterial count was 6 to 7 log cfu/g, but all foodborne pathogens and mold were reduced to nondetectable levels. The total bacterial count decreased after aging for 2 months and 3 months, but the differences were not significant (P > 0.05) compared with the count after 1 month. Microorganism in experimental sufu from different aging periods and in commercial sufu were compared. A total of 270 isolates were purified and identified by the BBL Crystal Identification System. From the experimental sufu samples, 49 Bacillus spp. (20.4%), 167 Enterococcus spp. (69.6%), 6 Shewanella putrefaciens (2.4%), and 18 miscellaneous gram-negative bacilli (7.5%) were identified. From commercial sufu samples, 17 Bacillus spp. (56.7%), 2 Enterococcus durans (6.7%), 5 miscellaneous gram-negative bacilli (16.7%), 5 Corynbacterium aquaticum (16.7%), and 1 Shewanella putrefaciens (3.3%) were obtained. Although the longer aging period did not significantly decrease the total bacterial count, it may help in the development of sufu flavor. This study showed that sufu fermentation and aging can control common foodborne pathogens, so sufu is a safe product even though its preparation does not include pasteurization.     

Quantification of thermophilic <Emphasis Type="Italic">Campylobacter</Emphasis> spp. in broilers during meat processing

Campylobacter spp. is a common cause of gastrointestinal illness. Since animal products, especially poultry meat, are an important source of human outbreaks of campylobacteriosis, tracing back to processing and initial production is of great interest. Samples were collected at a German poultry slaughterhouse for the estimation of the prevalence of Campylobacter at different processing steps. Quantification of Campylobacter in each of the samples was also performed. Out of 99 samples examined, 51 (51.5%) were positive for Campylobacter, with bacterial counts ranging from log(10) 6.5 cfu sample(-1) for carcasses to log 3.6 cfu ml(-1) for scalding water. The Campylobacter isolates (n = 51) were subtyped by pulsed-field gel electrophoresis using SmaI and KpnI restriction enzymes. Molecular typing showed a multitude of strains with different molecular patterns. Strains found in cloacal swabs before processing could also be isolated from carcasses at different processing steps.     

Potential occurrence of adhering living Bacillus spores in milk product processing lines

AIMS: The hygienic risk associated with microbial soil on surfaces of milk processing lines was evaluated, based on experimental results. METHODS AND RESULTS: From a panel of Bacillus spores isolated from milk products, B. cereus CUETM 98/4, was found to be highly resistant to heat (D100=3.32 min in whole milk) and oxidant disinfectant (70% lethality of adherent spores with Ikalin 2%). From adhesion trials, up to 1.1 x 10(7) spores cm(-2) were found to be adherent to solid surfaces when suspended in saline or in custard (10(5) and 10(7) cfu ml(-1)), and over 10% of these adherent spores would resist the cleaning procedure. CONCLUSION: A highly contaminated milk (10(5) cfu ml(-1)) subjected to a current sterilization process (8 log reduction) led to a residual contamination of less than 1 cfu in the representative processing line after a complete production run. SIGNIFICANCE AND IMPACT OF THE STUDY: This study highlighted the fact that under appropriate processing conditions (efficient sterilization and cleaning procedures), even disinfection would be sufficient to eliminate any contamination risk. Conversely, the disinfection procedure becomes an essential step under inappropriate processing conditions.