Comparison of ethanol production by Zymomonas mobilis from sugar beet substrates

Summary The potential of four sugar beet substrates from the sugar industry [syrup (S), crystallizer effluent 1 (CE1), crystallizer effluent 2 (CE2) and molasses (M)] were compared for ethanol production using an osmotolerant mutant strain of the bacterium Zymomonas mobilis. Sucrose of the substrates was enzymatically hydrolysed to avoid levan formation during fermentation. Nutrient supplementation experiments have shown that reproducible growth and ethanol production could be obtained on the four substrates supplemented only with magnesium sulphate (CE2 and M) or additionally with ammonium sulphate (S and CE1). Thus, addition of costly yeast extract could be avoided. All 20% (w/v) substrates showed nearly complete sugar conversion (>94.9%), good growth (0.16 h^–1) and ethanol production (>40 g 1^–1). However, sorbitol formation reduced the ethanol yield (73–79% of the theoretical value) significantly. Batch kinetic parameters and studies of instantaneous parameters showed that enhanced osmolality of substrates (SZ. mobilis with appropriate supplementation. Offprint requests to: J. Baratti     

Batch fermentation kinetics of sugar beet molasses by Zymomonas mobilis

A new osmotolerant mutant strain of Zymomonas mobilis was successfully used for ethanol production from beet molasses. Addition of magnesium sulfate to hydrolyzed molasses allowed repeated growth without the need of yeast extract addition. The kinetics and yields parameters of fermentation on media with different molasses concentrations were calculated. The anabolic parameters (specific growth rate, mu, and biomass yield, Y(X/S)) were inhibited at elevated molasses concentrations while the catabolic parameters (specific ethanol productivity, q(p), and ethanol yield, Y(p/s)) were not significantly affected. In addition to ethanol and substrate inhibition, osmotic pressure effects can explain the observed results.     

Production of ethanol from sugar cane molasses by Zymomonas mobilis

Summary Zymomonas mobilis strains were compared with each other and with a Saacharomyces cerevisiae strain for the production of ethanol from sugar cane molasses in batch fermentations. The effect of pH and temperature on ethanol production by Zymomonas was studied. The ability of Z. mobilis to produce ethanol from molasses varied from one strain to another. At low sugar concentrations Zymomonas compared favourably with S. cerevisiae. However, at higher sugar concentrations the yeast produced considerably more ethanol than Zymomonas.     

Continuous ethanol production from sugar beet molasses using an osmotolerant mutant strain of Zymomonas mobilis

A laboratory process was established for ethanol production by fermentation of sugar beet molasses with the bacterium Zymomonas mobilis. Sucrose in the molasses was hydrolyzed enzymatically to prevent levan formation. A continuous system was adopted to reduce sorbitol formation and a two-stage fermentor was used to enhance sugar conversion and the final ethanol concentration. This two-stage fermentor operated stably for as long as 18 d. An ethanol concentration of 59.9 g/l was obtained at 97% sugar conversion and at high ethanol yield (0.48 g/g, 94% of theoretical). The volumetric ethanol productivity (3.0 g/l·h) was superior to that of batch fermentation but inferior to that of a single-stage continuous system with the same medium. However, the thanol concentration was increased to a level acceptable for economical recovery. The process proposed in this paper is the first report of successful fermentation of sugar beet molasses in the continuous mode using the bacterium Z. mobilis.     

Kinetic control of ethanol production by Zymomonas mobilis

Summary Zymomonas mobilis UQM 2716 was grown anaerobically in continuous culture (D = 0.1/h; 30° C) 3nder glucose or nitrogen limitation at pH 6.5 or 4.0. The rates of glucose consumption and ethanol production were lowest during glucose-limited growth at pH 6.5, but increased during growth at pH 4.0 or under nitrogen limitation, and were highest during nitrogen-limited growth at pH 4.0. The uncoupling agent CCCP substantially increased the rate of glucose consumption by glucose-limited cultures at pH 6.5, but had much less effect at pH 4.0. Washed cells also metabolised glucose rapidly, irrespective of the conditions under which the original cultures were grown, and the rates were variably increased by low pH and CCCP. Broken cells exhibited substantial ATPase activity, which was increased by growth at low pH. It was concluded that the fermentation rates of cultures growing under glucose or nitrogen limitation at pH 6.5, or under glucose limitation at pH 4.0, are determined by the rate at which energy is dissipated by various cellular activities (including growth, ATP-dependent proton extrusion for maintenance of the protonmotive force and the intracellular pH, and an essentially constitutive ATP-wasting reaction that only operates in the presence of excess glucose). During growth under nitrogen limitation at pH 4.0 the rate of energy dissipation is sufficiently high for the fermentation rate to be determined by the inherent catalytic activity of the catabolic pathway.Abbreviations CCCP carbonyl cyanide p-trifluoromethoxyphenylhydrazone - qG rate of glucose consumption (g glucose/g dry wt cells/h) - qE rate of ethanol production (g ethanol/g dry wt cells/h) - Y growth yield (g dry wt cells/g glucose) - D dilution rate Offprint requests to: C. W. Jones     

Fermentation pattern of sucrose to ethanol conversions by Zymomonas mobilis

General patterns of sucrose fermentation by two strains of Zymomonas mobilis, designated Z7 and Z10, were established using sucrose concentrations from 50 to 200 g/liter. Strain Z7 showed a higher invertase activity than Z10. Strain Z10 showed a reduced specific growth rate at high sucrose concentration while Z7 was unaffected. High sucrose hydrolyzing activity in strain Z7 lead to glucose accumulation in the medium at high sucrose concentrations. Ethanol production and fermentation time depend on the rate of catabolism of the products of sucrose hydrolysis, glucose and fructose. The metabolic quotients for sucrose utilization, q_s, and ethanol production, q_p (g/g·hr), are unsuitable for describing sucrose utilization by Zymomonas mobilis, as the logarithmic phase of growth precedes the phase of highest substrate utilization (g/liter·hr) and ethanol production (g/liter·hr) in batch culture.     

Fermentation of molasses by Zymomonas mobilis: effects of temperature and sugar concentration on ethanol production

Fermentations utilizing strains of Zymomonas mobilis, in place of the traditional yeasts, have been proposed due their ethanol yields being close to theoretical. Ethanol production from sugar cane molasses was analyzed under different culture conditions using Z. mobilis in batch fermentation. The total reducing sugars (TRS) concentrations in the molasses, temperature, agitation and culture time effects were studied simultaneously through factorial design. The best conditions for ethanol production were 200 g L(-1) of total reducing sugars in the molasses, temperature of 30 degrees C and static culture and time of fermentation of 48 h, achieving 55.8 g L(-1). The pH of the medium was kept constant during the experiments, showing that molasses presents a buffering effect.     

The inhibitory effect of ethanol on ethanol production by Zymomonas mobilis

Summary In an effort to establish the reasons for the limitations in the final ethanol concentration of Zymomonas mobilis fermentation, the effects of CO₂ and ethanol on the fermentation were investigated using continuous and fed-batch cultivation systems. The nucleation and stripping out of CO₂ from the fermenter using diatomaceous earth or nitrogen gas or both exhibited a profound effect on the glucose uptake rate during the early stages of fed-batch fermentation, but did not improve final ethanol yields. The addition of ethanol together with above mentioned experiments confirmed conclusively that ethanol inhibition is responsible for the final ethanol concentration obtainable during Zymomonas mobilis fermentation. The final concentration lies between 90 and 110 gl⁻¹ or approximately 12–15% (v/v) ethanol.     

Continuous ethanol production by immobilized cells of Zymomonas mobilis

Summary Studies have been carried out with a highly productive strain of Zymomonas mobilis in an immobilized cell reactor using both Ca alginate and -carrageenan as supporting matrices. Productivities above 50 g/l/h have been found at ethanol concentrations in excess of 60 g/l. With immobilized cells of Z. mobilis, there was a decline of approximately 30s% in activity after 800 h operation.     

Effect of temperature on sucrose to ethanol conversion by Zymomonas mobilis strains

Summary Two strains of Zymomonas mobilis were tested for their ability to ferment sucrose to ethanol at elevated temperatures (30–42.5°C). The optimal temperature for efficient sucrose to ethanol conversion was 35°C with 22–27 h fermentation time and 75% conversion efficiency. Increases in magnesium concentration improved one of the strains at 40°C from 38 to 76% ethanol yield efficiency.     

Continuous ethanol production by a flocculent strain of Zymomonas mobilis

Summary Cell retention and ethanol production using the flocculent bacterium Zymomonas mobilis NRRL B-12526 were studied in three bioreactor configurations. The flocculent growth characteristic of this strain and a special reactor design were combined to achieve relatively high cell concentrations in a continuous bioreactor for the conversion of glucose to ethanol.Research sponsored by the Office of Energy Research, U.S. Department of Energy, under contract W-7405-eng-26 with the Union Carbide Corporation.     

Transcriptome profiling of Zymomonas mobilis under ethanol stress

Biodiesel is a promising alternative, and renewable, fuel. As its production increases, so does production of the principle co-product, crude glycerol. The effective utilization of crude glycerol will contribute to the viability of biodiesel. In this review, composition and quality factors of crude glycerol are discussed. The value-added utilization opportunities of crude glycerol are reviewed. The majority of crude glycerol is used as feedstock for production of other value-added chemicals, followed by animal feeds.     

The route of ethanol formation in Zymomonas mobilis

1. Enzymic evidence supporting the operation of the Entner-Doudoroff pathway in the anaerobic conversion of glucose into ethanol and carbon dioxide by Zymomonas mobilis is presented. 2. Cell extracts catalysed the formation of equimolar amounts of pyruvate and glyceraldehyde 3-phosphate from 6-phosphogluconate. Evidence that 3-deoxy-2-oxo-6-phosphogluconate is an intermediate in this conversion was obtained. 3. Cell extracts of the organism contained the following enzymes: glucose 6-phosphate dehydrogenase (active with NAD and NADP), ethanol dehydrogenase (active with NAD), glyceraldehyde 3-phosphate dehydrogenase (active with NAD), hexokinase, gluconokinase, glucose dehydrogenase and pyruvate decarboxylase. Extracts also catalysed the overall conversion of glycerate 3-phosphate into pyruvate in the presence of ADP. 4. Gluconate dehydrogenase, fructose 1,6-diphosphate aldolase and NAD-NADP transhydrogenase were not detected. 5. It is suggested that NAD is the physiological electron carrier in the balanced oxidation-reduction involved in ethanol formation.     

Ethanol production by Zymomonas mobilis CP4 from sugar cane chips

Summary The fermentation of large sugar cane chips (1.0–1.5 in) to ethanol by Zymomonas mobilis CP4 (Z. mobilis) was studied in two glass fermentors operating with culture circulation for agitation (the EX-FERM type): a. A laboratory scale(2.5 liter) cylindrical vessel; b. A bench scale (8 liter) wide vessel. Z. mobilis cultures consumed 89–96% of the cane sucrose, converting it to ethanol by 90–97% of the theoretical yield in the laboratory scale fermentor and by 83–90% in the bench scale fermentor culture. Comparative Saccharomyces spp. cultures in laboratory fermentor consumed 96–98% of the cane sucrose, with ethanol conversion of only 75–79% of the theoretical yield.These preliminary results indicated that sucrose in agricultural size sugar cane chips was ethanol fermentable as compared to small size sugar cane chips or to sugar cane juice. Z. mobilis CP4 cultures converted sucrose more efficiently to ethanol than Saccharomyces spp. as shown in the laboratory scale fermentor studies.The ethanol yields in a wide bench scale fermentor cultures were slightly lower than in a laboratory fermentor.     

High efficiency ethanol fermentation by entrapment of Zymomonas mobilis into LentiKats

AIMS: To examine the potential of Zymomonas mobilis entrapped into polyvinylalcohol (PVA) lens-shaped immobilizates in batch and continuous ethanol production. METHODS AND RESULTS: Cells, free or immobilized in PVA hydrogel-based lens-shaped immobilizates - LentiKats, were cultivated on glucose medium in a 1 l bioreactor. In comparison with free cell cultivation, volumetric productivity of immobilized batch culture was nine times higher (43.6 g l(-1) h(-1)). The continuously operated system did not improve the efficiency (volumetric productivity of the immobilized cells 30.7 g l(-1) h(-1)). CONCLUSIONS: We demonstrated Z. mobilis capability, entrapped into LentiKats, in the cost-efficient batch system of ethanol production. SIGNIFICANCE AND IMPACT OF THE STUDY: The results reported here emphasize the potential of bacteria in combination with suitable fermentation technology in industrial scale. The innovation compared with traditional systems is characterized by excellent long-term stability, high volumetric productivity and other technological advantages.     

Simultaneous ethanol and bacterial ice nuclei production from sugar beet molasses by a Zymomonas mobilis CP4 mutant expressing the inaZ gene of Pseudomonas syringae in continuous culture

AIM: The aim of this work was to construct a Zymomonas mobilis mutant capable of simultaneous ethanol and ice nuclei production from agricultural by-product such as sugar beet molasses, in steady-state continuous culture. METHODS AND RESULTS: A sucrose-hypertolerant mutant of Z. mobilis strain CP4, named suc40, capable of growing on 40% (w/v) sucrose medium was isolated following N-methyl-N'-nitro-N-nitrosoguanidine treatment. Plasmid pDS3154 carrying the inaZ gene of Pseudomonas syringae was conjugally transferred and expressed in suc40. The potential for simultaneous ethanol and bacterial ice nuclei production was assessed in steady-state continuous cultures over a range of dilution rates from 0.04 to 0.13 h(-1). In addition, the fatty acid and phospholipid profile of the three strains was also investigated. Ethanol production up to 43 g l(-1) was achieved at dilution rates below 0.10 h(-1) in sugar beet molasses. Ice nucleation activity gradually increased with increasing dilution rate and the greatest activity, -3.4 log (ice nuclei per cell), was observed at the highest dilution rate (0.13 h(-1)). Both mutant strains displayed a different fatty acid and phospholipid profile compared with the wild-type strain. CONCLUSIONS: The ability of the mutant and recombinant plasmid-containing strains to grow on high sugar concentrations and in high osmotic pressure environments (molasses) can be attributed to their phospholipid and fatty acid contents. SIGNIFICANCE AND IMPACT OF THE STUDY: Taking into account that sugar beet molasses is a low cost agricultural by-product, the simultaneous ethanol and bacterial ice nucleation production achieved under the studied conditions is considered very promising for industrial applications.     

Characteristics of Zymomonas mobilis immobilized by photo-crosslinkable resin in ethanol fermentation

Zymomonas mobilis, an ethanol-producing bacterium, was immobilized in hydrophilic photo-crosslinked resin gels to form a biocatalyst. The molecular structure of the photo-crosslinkable resin could be modulated so as to minimize a disadvantage of this bacterium—poor-tolerance to salts in molasses. Characteristics of Z. mobilis immobilized by photo-crosslinkable resin gel, such as fermentability, cell growth in gel, the potential of gel materials, diffusion of materials, and salt distribution are discussed. ENTG-3800 photo-crosslinkable resin was selected as the most suitable entrapping material for Z. mobilis, especially in using molasses.