Development of high-molar-mass cellobiase complex by spontaneous protein-protein interaction in the culture filtrate ofTermitomyces clypeatus

The 450 kDa cellobiase fromTermitomyces clypeatus which migrates as a single band on IEF, PAGE and SDS-PAGE, was found to possess appreciable sucrase activity. The fungus produced sucrase and cellobiase constitutively in different media but with different activity ratios. The kinetics of secretion of the two enzymes was similar underin vivo andin vitro conditions. HPGPLC analysis of the culture filtrates indicated the presence of both sucrase and cellobiase in the same protein fractions of different molar mass, even in the 30-kDa protein fraction. No free sucrase or cellobiase could be detected in the culture filtrates. It was also observed that fractionation of cellobiase by (NH₄)₂SO₄ precipitation was different with different amounts of associated sucrase activity present in the culture filtrate. The (NH₄)₂SO₄-precipitated cellobiase fraction also contained cellobiases in proteins of widely varied molar mass ranges. However, none of the low-molar mass proteins other than the 450-kDa enzyme could be purified, as all low-molar-mass fractions spontaneously aggregated to the 450-kDa enzyme. Hydrophobic chromatography of the (NH₄)₂SO₄-precipitated fractions followed by HPGPLC of the eluted active fraction yielded both cellobiase-free sucrase and a very low sucrase-containing cellobiase fraction. The cellobiase fraction, homogeneous in PAGE, was also a high-molar-mass protein complex dissociating into a number of protein bands on SDS-PAGE. It was suggested that the 450-kDa cellobiase was not liberated by the fungus as a preformed enzyme complex but that the complex developed through interaction of cellobiase with sucrase underin vitro conditions and the possibility of the involvement of other proteins in the aggregation cannot be excluded.     

Increased enzyme secretion by 2-deoxy-d-glucose in presence of succinate by suppression of metabolic enzymes in Termitomyces clypeatus

Regulatory mode of secretion of proteins was detected for the industrial glycosidase, cellobiase, under secreting conditions (in presence of TCA cycle intermediates like succinate etc.) in the filamentous fungus Termitomyces clypeatus. The titers of key metabolic enzymes were investigated under secreting and non-secreting conditions of growth and compared to the corresponding production of intra and extracellular levels of cellobiase. Results were compared in presence of 2-deoxy-d-glucose, a potent glycosylation inhibitor in the secreting media. Inclusion of 2-deoxy-d-glucose in presence of succinate caused about 10 to 100 times decrease in titers of the metabolic enzymes hexokinase, fructose-1,6-bisphosphatase, isocitrate lyase and malate dehydrogenase leading to increased secretion of cellobiase by more than 100 times. The intracellular concentration of cAMP (86-fold decrease in presence of 2-deoxy-d-glucose under secreting conditions) and turnover rate of proteins also dropped significantly. In this suppressed metabolic state, a 10-fold increase in the titer of the secreted cellobiase was noticed. The results indicated elucidation of carbon catabolite repression like phenomenon in the fungus under secreting conditions which was more pronounced by 2-deoxy-d-glucose. The interdependence between secretion and regulation of metabolic enzymes will help in better understanding of the physiology of these highly adapted organisms for increasing their secretion potential of glycosidases like cellobiase with high industrial value.     

Regulation (alteration) of activity and conformation of sucrase by coaggregation with cellobiase in culture medium of Termitomyces clypeatus

Extracellular sucrase (S) of Termitomyces clypeatus was aggregated with cellobiase (C) in culture filtrate and coaggregates of sucrase to cellobiase with different activity ratios (S/C) were obtained during purification. Specific activity of the enzyme decreased significantly, after purification of sucrase free from cellobiase. Purified sucrase was characterized as a glycoprotein of molar mass around 55kDa as indicated by SDS-PAGE and HPGPLC. K(m) and V(max) of the purified enzyme were determined as 34.48 mM and 13.3 U/mg, respectively, at optimum temperature (45 degrees C) and pH (5.0). Substrate affinity and reaction velocity of the purified enzyme, free from cellobiase, was lowered by approximately 3.5 and 55 times, respectively, than that of the enzyme obtained from culture filtrate. The instant regain of sucrase activity up to the extent of 41% was obtained on in vitro addition of cellobiase (free from sucrase) to the enzyme in incubation mixture. Conformation of the enzyme free from cellobiase appeared to be significantly different from that of the coaggregate, as analyzed by circular dichroic and light scattering spectroscopy. It was concluded that activity and conformation of sucrase is regulated (altered) by heteroaggregation with cellobiase in the fungus.     

In situ reversible aggregation of extracellular cellobiase in the filamentous fungus Termitomyces clypeatus

Cellobiase (E.C. 3.2.1.21), is a widely exploited industrial glycosidase with a major role in biofuel industry. Its stability and shelf life are major bottlenecks in achieving a superior formulation for industry. In the filamentous fungus Termitomyces clypeatus, the enzyme is secreted in a co-aggregated form with sucrase; the separation of this co-aggregation results in substantial loss of the enzyme??s activity. The aim of the present study was to examine the mode of aggregation of the secreted cellobiase-sucrase coaggregate and its role in the stabilization of cellobiase. Transmission electron microscopy and dynamic light scattering of purified co-aggregates revealed reversible, concentration driven self-aggregation of the extracellular enzymes to form larger entities. However, the intracellular enzyme aggregates were rigid, non-interacting, and possessed a higher percentage of disulphide bonds. Circular dichroic spectra of the two coaggregates indicated no significant difference in secondary structures. Self-association increased the stability of extracellular aggregates towards heat by 1.5 fold, SDS by 4 ?? 7 fold, and chaotropic agents, by 1.5 ?? 2 fold, than the intracellular counterpart. The K_m of extracellular aggregate varied between 0.29 and 0.45 mM as a result of spontaneous aggregation and disaggregation, whereas that of intracellular aggregate was 0.22 mM irrespective of its concentration status. In situ detection of cellobiase in native PAGE revealed two activity bands of the extracellular enzyme, which indicated a minimum of two active dissociated aggregate species, as compared to a single band for the intracellular enzyme. These studies are believed to improve the understanding of aggregation of the fungal glycosidases, which remains to be a blackbox, to increase the efficacy of these enzymes.     

Increased enzyme secretion by 2-deoxy-D-glucose in presence of succinate by suppression of metabolic enzymes in Termitomyces clypeatus

Regulatory mode of secretion of proteins was detected for the industrial glycosidase, cellobiase, under secreting conditions (in presence of TCA cycle intermediates like succinate etc.) in the filamentous fungus Termitomyces clypeatus. The titers of key metabolic enzymes were investigated under secreting and non-secreting conditions of growth and compared to the corresponding production of intra and extracellular levels of cellobiase. Results were compared in presence of 2-deoxy-D-glucose, a potent glycosylation inhibitor in the secreting media. Inclusion of 2-deoxy-D-glucose in presence of succinate caused about 10 to 100 times decrease in titers of the metabolic enzymes hexokinase, fructose-1,6-bisphosphatase, isocitrate lyase and malate dehydrogenase leading to increased secretion of cellobiase by more than 100 times. The intracellular concentration of cAMP (86-fold decrease in presence of 2-deoxy-D-glucose under secreting conditions) and turnover rate of proteins also dropped significantly. In this suppressed metabolic state, a 10-fold increase in the titer of the secreted cellobiase was noticed. The results indicated elucidation of carbon catabolite repression like phenomenon in the fungus under secreting conditions which was more pronounced by 2-deoxy-D-glucose. The interdependence between secretion and regulation of metabolic enzymes will help in better understanding of the physiology of these highly adapted organisms for increasing their secretion potential of glycosidases like cellobiase with high industrial value.     

Cellobiase from Termitomyces clypeatus: activity and secretion in presence of glycosylation inhibitors

In presence of the glycosylation inhibitors, 2-deoxy-d-glucose (1 mg/ml), tunicamycin (30 μg/ml), 1-deoxynojirimycin (30 μg/ml) and d-glucono-δ-lactone (1 mg/ml), total cellobiase activity, in the extracellular, intracellular and cell bound fractions, of the fungus Termitomyces clypeatus grown in 20 ml cellobiose medium (1%, w/v) increased by 50-, 1.8-, 2.4-, 1.3-fold, respectively, with respect to control medium (16.3 U). The inhibitors also stimulated secretion of 95% of the total protein in culture medium, except d-glucono-δ-lactone which released 60% of the total protein. 2-Deoxy-d-glucose (1 mg/ml) led to production of extracellular cellobiase up to 40 U/ml, whereas in absence of the inhibitors only 0.59 U/ml enzyme was detected.     

Characterization of a novel low molecular weight sucrase from filamentous fungus Termitomyces clypeatus

An extracellular sucrase from the culture filtrate of filamentous basidiomycota Termitomyces clypeatus grown on high sucrose (5%, w/v) was purified by gel filtration chromatography, ion exchange chromatography and HPGPLC. The biochemical properties, molecular weight and conformation of sucrase produced were significantly different from the sucrase earlier purified from sucrose (1%, w/v) medium in the fungus. Purified sucrase was characterized as a low molecular weight protein of 13.5 kDa as approximated by SDS-PAGE and HPGPLC and exhibited predominantly random coil conformation in far-UV CD spectra. The enzyme was optimally active at 47 °C and pH 5.0. K_m and catalytic activity of the enzyme for sucrose were found to be 3.5 mM and 1.06 U/mg/mM, respectively. The enzyme was maximally active towards sucrose than to raffinose and sucrase activity was significantly inhibited by bivalent metal ions and reducing group agents. The results indicated that due to changes in aggregation pattern, molecular organization of purified sucrase, produced in high sucrose medium, was altered and was different from the previously reported enzyme. This is the first report of a sucrase of such low size showing activity.     

The influence of cultural medium composition on the proteolytic enzyme secretion of fungus <Emphasis Type="Italic">Rhizoctonia solani</Emphasis>

It was shown that change of medium growth composition of photopathogenic fungus Rhizoctonia solani Kühn, especially accessible sources of nutrition, leads to change of both quantity of produced proteinases and their action specificity. The mineral source of nitrogen suppressed the fungus proteinase secretion on cultivatiin medium containing potato thermostable proteins but an organic source of nitrogen accelerated mycelium growth and increased proteinase secretion. On the basis of an analysis of a fungus extracellular proteinase substrate-specificity, it is established that the presence of thermostable proteins of a potato in the cultural liquid induces the secretion of trypsin-like proteinases mainly, and the addition of yeast extract to this growth medium induces the secretion of subtilisin-like ones, thus suppressing the trypsin-like enzymes production. This fact can indicate that mycelium of fungus R. solani loses pathogenic properties and becomes saprophytes when the growth medium was enriched by an organic source of nitrogen.     

Enhanced activity and stability of cellobiase (β-glucosidase: EC 3.2.1.21) produced in the presence of 2-deoxy-d-glucose from the fungus Termitomyces clypeatus

Generally less glycosylation or deglycosylation has a detrimental effect on enzyme activity and stability. Increased production and secretion of cellobiase was earlier obtained in the presence of the glycosylation inhibitor 2-deoxy-d-glucose in filamentous fungus Termitomyces clypeatus [Mukherjee, S.; Chowdhury, S.; Ghorai, S.; Pal, S.; Khowala, S. Biotechnol. Lett.2006, 28, 1773-1778]. In this study the enzyme was purified from the culture medium by ultrafiltration and gel-permeation, ion-exchange and high-performance liquid chromatography, and its catalytic activity was six times higher compared to the control enzyme. K_m and V_max of the purified enzyme were measured as 0.187 mM and 0.018 U mg⁻¹, respectively, using pNPG as the substrate. The enzyme had temperature and pH optima at 45 °C and pH 5.4, respectively, and retained full activity in a pH range of 5-8 and temperatures of 30-60 °C. Interestingly less glycosylated cellobiase was resistant towards proteolytic as well as endoglycosidase-H digestion and showed higher stability than native enzyme due to increased aggregation of the protein. The enzyme also showed higher specific activity in the presence of cellobiose and pNPG and less susceptibility towards salts and different chemical agents. The β-glucosidase can be considered as a potentially useful enzyme in various food-processing, pharmaceutical and fermentation industries.     

Production and characterization of a highly active cellobiase from Aspergillus niger grown in solid state fermentation

Summary Aspergillus niger produced extracellular cellobiase when grown on different lignocellulosic substrates in solid state fermentation. The enzyme activity and yield were variable according to the carbon source. In Vogel’s medium, the cellobiase productivity was significantly higher on wheat bran, followed by Leptochloa fusca (kallar grass) straw augmented with corn steep liquor. Maximum yield of cellobiase/g wheat bran was significantly higher than the values reported on other potent fungi, bacteria and recombinants, harboring heterologous gene for cellobiase. This enzyme in the presence and absence of Trichoderma reesei and celluloclast, saccharified the biomass and the percentage saccharification as well as glucose yield from lignocellulosic biomass was doubled in its presence. The partially purified enzyme was thermotolerant as evidenced by melting temperature, activation energy demand for active catalysis, enthalpy and entropy of activation for reversible or irreversible thermal inactivation.     

Comparative studies on extracellular protease secretion and glucoamylase production by free and immobilized <Emphasis Type="Italic">Aspergillus niger</Emphasis> cultures

The effects of cell immobilization on the secretion of extracellular proteases and glucoamylase production by Aspergillus niger were investigated under a variety of immobilization techniques and culture conditions. Immobilization was achieved by means of cell attachment on metal surfaces or spore entrapment and subsequent growth on porous Celite beads. Free-suspension cultures were compared with immobilized mycelium under culture conditions that included growth in shake flasks and an airlift bioreactor. Cell attachment on metal surfaces minimized the secretion of proteases while enhancing glucoamylase production by the fungus. Growth on Celite beads in shake-flask cultures reduced the specific activity of the secreted proteases from 128 to 61 U g⁻¹, while glucoamylase specific activity increased from 205 to 350 U g⁻¹. The effect was more pronounced in bioreactor cultures. A reduction of six orders of magnitude in protease specific activities was observed when the fungus grew immobilized on a rolled metal screen, which served as the draft tube of an airlift bioreactor. Received 29 October 2001/ Accepted in revised form 14 June 2002     

Secretion of cellobiase is mediated via vacuoles in Termitomyces clypeatus

The majority of cellobiase activity in Termitomyces clypeatus was localized in vacuolar fractions of the fungus under secretory and nonsecretory conditions of growth. Activities of marker proteins for subcellular organelles, e.g., vacuoles, cytosol, ER, and mitochondria, in mycelial extracts from the secreting conditions increased by approximately 20, 12, 5, and 2.5 times, respectively, as compared to those obtained from mycelium grown in nonsecreting conditions. The average size and concentration of vacuoles visualized by electron microscopy were also increased in secreting conditions in the fungus. The specific activity of cellobiase in vacuoles isolated in Ficoll-sucrose gradient, as obtained from mycelial growth in secretory medium, was more than 40 times higher in comparison to that found from nonsecretory medium. The results indicated that subcellular localization of cellobiase in vacuoles is regulated by the cellular signaling prevailing in the fungus. Mycelial extraction of intracellular proteins by hand grinding and by bead-beater from cells frozen in the presence or absence of liquid nitrogen was also compared. Maximum recovery of intracellular protein was obtained with the bead-beater under aerobic conditions in the absence of nitrogen. Highest recovery of vacuoles up to 85% was obtained by single-step ultracentrifugation of the mycelial extract of the fungus in Ficoll-sucrose gradient. The method appeared to be useful for separation of other subcellular organelles in filamentous fungi.     

Nascent synthesis and secretion of cellobiase inNeocallimastix frontalis EB188

De novo synthesis and the secretion of cellobiase fromNeocallimastix frontalis EB188 were studied. Cellobiase was secreted rapidly in cellulose switch cultures. Chemical inhibition of protein synthesis and radiotracer studies suggested secretion was dependent on nascent protein synthesis. Inhibitors of protein glycosylation also inhibited secretion. An 85,000 dalton protein (and several others) represented the principal differences in de novo synthesis between cellulose- and glucose-switched cultures. Concentrations of the 85,000 daltons protein increased with culture incubation time and ultimately accounted for 7% of the total protein secreted. This protein was purified by gel electrophoresis separations and was determined to be a cellobiase. Secretion of this cellobiase was correlated with its radiolabeling. The possibility of cellobiase induction representing a specialized gene control system inNeocallimastix frontalis EB188 is discussed.     

The fetal and postnatal development of small intestinal disaccharidases in the rabbit

The development of small intestinal enzymes (lactase, acid- and hetero beta-galactosidases, cellobiase, maltase, trehalase, and sucrase) was studied from 18 days after conception until birth in 24 rabbit fetuses, and during the postnatal period in 15 newborn, juvenile, and adult rabbits. Lactase, acid- and hetero beta-galactosidases, cellobiase, and trehalase activities increased significantly during the fetal stage, while changes in sucrase and maltase activities were not substantial. In the postnatal period, lactase and cellobiase activities decreased significantly whereas maltase, sucrase, and trehalase activities increased significantly to reach adult values by 30 days of age. The acid- and hetero beta-galactosidases remained unchanged.     

Pair-dependent co-aggregation behavior of non-flocculating sludge bacteria

Two strains of non-flocculating sewage sludge bacteria (Xanthomonassp. S53 and Microbacterium esteraromaticum S51) showed 91% and 77% co-aggregation, respectively, with Acinetobacter johnsonii S35 using a spectrophometric assay. The co-aggregates in case of Xanthomonas sp. S53 and A. johnsonii S35 were above 100 m and stable against EDTA (2 mM) and a commercial protease (0.2 mg ml^–1). Protease/periodate pretreatment of the partners did not affect this co-aggregation. On the other hand, co-aggregates of M. esteraromaticum S51 and A. johnsonii S35 (50–70 m) were deflocculated by EDTA or protease. Protease pretreatment of M. esteraromaticum S51 and periodate pretreatment of A. johnsonii S35 prevented their co-aggregation with respective untreated partners. The potential co-aggregation mechanisms of A. johnsonii S35 varied depending upon the other partner involved.     

Production and Regulation of Cuticle-Degrading Proteases from <Emphasis Type="Italic">Beauveria bassiana</Emphasis> in the Presence of <Emphasis Type="Italic">Rhammatocerus schistocercoides</Emphasis> Cuticle

Extracellular proteases have been shown to be virulence factors in fungal pathogenicity toward insects. We examined the production of extracellular proteases, subtilisin-like activity (Pr1) and trypsin-like activity (Pr2), by Beauveria bassiana CG425, which is a fungus of interest for control of the grasshopper Rhammatocerus schistocercoides. To access the role of these proteases during infection of R. schistocercoides, we analyzed their secretion during fungus growth either in nitrate-medium or in cuticle-containing medium supplemented with different amino acids. The enhancing effect of cuticle on Pr1 and Pr2 production suggests that these protease types may be specifically induced by components of the grasshopper cuticle. In medium supplemented with methionine a high level of Pr1 was observed. The remaining amino acids tested did not induce the protease to the levels seen with cuticle. The amino acid methionine seems to play a regulatory role in Pr1 secretion by B. bassiana, since both induction and repression seem to be dependent on the concentration of the amino acid present in the culture medium.     

On the mode of action of fungal cellulases

Summary The mode of action of the cellulolytic enzymes of two strong cellulose decomposing fungi, Penicillium oxalicum Curie et Thom and Helminthosporium cyclops Drechsler, was studied. The culture filtrates and enzyme preparations obtained from them showed high cellulase activity and very weak cellobiase activity. The cellulolytic system of both experimental organisms seems to be multicomponent. The cellulase component showed its activity mainly extracellulary and the cellobiase component, mainly intracellulary. It seems, therefore, that during growth of both fungi on a cellulose medium, the extracellular cellulase acts hydrolytically on the cellulose substrate forming cellobiose which is further acted upon by intracellular cellobiase to form glucose. Paper chromatographic assay of the products of the enzymatic reaction sub-stantiated this conclusion.     

Interactions Between Hyphosphere-Associated Bacteria and the Fungus <Emphasis Type="Italic">Cladosporium herbarum</Emphasis> on Aquatic Leaf Litter

We investigated microbial interactions of aquatic bacteria associated with hyphae (the hyphosphere) of freshwater fungi on leaf litter. Bacteria were isolated directly from the hyphae of fungi from sedimented leaves of a small stream in the National Park “Lower Oder,” Germany. To investigate interactions, bacteria and fungi were pairwise co-cultivated on leaf-extract medium and in microcosms loaded with leaves. The performance of fungi and bacteria was monitored by measuring growth, enzyme production, and respiration of mono- and co-cultures. Growth inhibition of the fungus Cladosporium herbarum by Ralstonia pickettii was detected on leaf extract agar plates. In microcosms, the presence of Chryseobacterium sp. lowered the exocellulase, endocellulase, and cellobiase activity of the fungus. Additionally, the conversion of leaf material into microbial biomass was retarded in co-cultures. The respiration of the fungus was uninfluenced by the presence of the bacterium.     

The intracellular sucrase (SacA) of Zymomonas mobilis is not involved in sucrose assimilation

The intracellular sucrase SacA from Zymomonas mobilis was purified to homogeneity from a recombinant E. coli strain containing the SacA gene under an expression system. The protein was monomeric with a molecular mass of 58 kDa. The sucrase activity was maximal at 25 °C and thermal stability of the purified protein was low (50% recovery after 30 min at 46 °C ). The activation energy was low at 33 kJ mol^–1. Maximum activity was at pH 6.5. Activity was strongly inhibited (>99%) by SH blocking reagents and reducing agents slightly (10–60%) increased the activity of purified SacA. The sucrase showed a low K _M (42 mM) and k _cat (125 s^–1) which indicated its very low efficiency for sucrose hydrolysis. A mutant strain of Z. mobilis not able to grow on sucrose was isolated. This strain (ZM4S) lacked the two sucrases SacB and SacC but SacA was present in the intracellular fraction. Therefore, SacA alone is unable to allow growth Z. mobilis on sucrose.