Factors affecting the heat resistance of Escherichia coli O157 : H7

Escherichia coli O157 : H7 has been reported as being not particularly heat resistant. However, several factors which might increase its heat resistance have been investigated in this study using five strains. Increase in growth temperature to 40 °C, as found in the cow gut, heat-shock at sub-lethal temperatures of 42, 45, 48 and 50 °C, and variable heating rate (1 °C min⁻¹ to 23 °C min⁻¹) had no dramatic effect on heat resistance. Growth phase had a marked impact on heat resistance ; late stationary phase cells were more heat-resistant than were log phase cells. The difference in heat resistance between the two phases of growth became more pronounced when cells were resuspended in fresh nutrient broth ; heat resistance of late stationary phase cells increased dramatically whereas no such effect was observed with log phase cells. The addition of polyphosphates to the heating medium did not increase heat resistance. A reduction in water activity of the heating medium from 0·995 to levels between 0·980 and 0·960 also resulted in a marked increase in heat resistance. This effect was more pronounced under conditions of extremely low water activity created by resuspending late stationary phase cells in sunflower oil. Survivors were detected even after a heat treatment at 60 °C for 1 h or 70 °C for 5 min. It can be confirmed that this serotype has no unusual heat resistance and that the heating environment markedly affects resistance.     

Heat resistance of Listeria monocytogenes in dairy products as affected by the growth medium

Listeria monocytogenes strains 1151 and Scott A were grown in broth at 30 °C and transferred to half cream, double cream and butter stored at 5 °C to determine the influence of dairy product composition on heat resistance at 52, 56, 60, 64 and 68 °C. Strain 1151 showed a higher heat resistance than strain Scott A. The heat resistance of both strains was higher in the dairy products than in broth, particularly at lower temperatures. A significant difference was observed between log 10 of the D -values in the different dairy products. The D -values obtained for both strains resuspended in all the dairy products would result in efficient elimination of the pathogen at 72·7 °C for 15 s. The highest D -value was 11·30 s at 68 °C and by using a z -value of 6·71 °C it can be determined that at 72·7 °C the D -value would be 1·5 s. The 15 s process would therefore achieve 10 log reductions. The effect of growth conditions on the heat resistance at 60 °C of L. monocytogenes Scott A was also investigated. When the cells were grown in the dairy products themselves, and particularly butter, the heat resistance of Scott A was enhanced; for example, the D -values were 7·15 times higher than in broth. Further studies are required to investigate if this protection against heating exists at higher temperatures, in which case the efficiency of pasteurization treatments or other heat treatments would be considerably lowered.     

Heat shock protein synthesis and thermotolerance in Salmonella typhimurium

The resistance of stationary phase Salmonella typhimurium to heating at 55°C was greater in cells grown in nutritionally rich than in minimal media, but in all media tested resistance was enhanced by exposing cells to a primary heat shock at 48°C. Chloramphenicol reduced the acquisition of thermotolerance in all media but did not completely prevent it in any.
The onset of thermotolerance was accompanied by increased synthesis of major heat shock proteins of molecular weight about 83, 72, 64 and 25 kDa. When cells were shifted from 48°C to 37°C, however, thermotolerance was rapidly lost with no corresponding decrease in the levels of these proteins. There is thus no direct relationship between thermotolerance and the cellular content of the major heat shock proteins. One minor protein of molecular weight about 34 kDa disappeared rapidly following a temperature down-shift. Its presence in the cell was thus correlated with the thermotolerant state.     

Influence of the sporulation temperature upon the heat resistance of Bacillus subtilis

The influence of different sporulation temperatures (30, 37, 44 and 52°C) upon heat resistance of Bacillus subtilis was investigated.
Heat resistance was greater after higher sporulation temperatures. Relation of heat resistance and temperature of sporulation was not linear over all the range of temperatures tested. Heat resistance increased about tenfold in the range of 30–44°C. Sporulation at 52°C did not show any further increase in heat resistance.
This effect was constant over all the range of heating temperatures tested (100–120°C). z value remained constant ( z = 9°C).
Greater heat resistances at higher temperatures of sporulation were not due to selection of more heat resistant cells by a higher sporulation temperature. Spores obtained from cells incubated at 32 or 52°C always possessed heat resistances that corresponded to the sporulation temperature regardless of the incubation temperature of their vegetative cells.     

Effect of culture age, pre-incubation at low temperature and pH on the thermal resistance of Aeromonas hydrophila

S. CONDON, M.L. GARCIA, A. OTERO AND F.J. SALA. 1992. The thermal resistance of Aeromonas hydrophila strain NCTC 8049 was determined within the range 48°-65°C with a thermoresistometer TR-SC and McIlvaine buffer. The effects of culture age, pre-incubation at 7°C and the pH of the heating menstruum were evaluated. The pattern of thermal death was dependent on culture age. Cells heated in the late logarithmic growth phase (15 h at 30°C) were twice as resistant as those in the early stage (5 h at 30°C), and the maximum D -value was obtained after 72 h incubation (5.5 total increase). The age of the cells did not affect z -values significantly. The heat resistance of cells incubated for 48 h at 30°C increased (twice) after holding at 7°C for 72 h. Pre-incubation at low temperature of older cultures (72 h, 30°C) did not influence their D -values. Maximum heat resistance was found at pH 6.0 and minimal at pH 4.0. Decreasing the pH from 6.0 4.0 reduced D -values by a factor of 5. Although the strain studied was heat-sensitive ( D _55°C= 0.17 min; z = 5.11°C), survivor curves of cultures older than 50 h showed a significant tailing. Organisms surviving in the tails were only slightly more resistant than were the original population.     

Heat resistance of Listeria: strain differences and effects of meat type and curing salts

The heat resistances of 27 strains of Listeria monocytogenes and two strains of L. innocua were compared in broth heated at 57°C. No strain was exceptionally resistant. The heat resistance of a representative isolate of L. monocytogenes was compared in fresh and cured beef and chicken, and an equation was derived to predict the time necessary to achieve a '7D' inactivation at temperatures between 50 and 70°C.     

Survival of Listeria monocytogenes in sea water and effect of exposure on thermal resistance

Survival, recoverability and sublethal injury of two strains of Listeria monocytogenes , Scott A and an environmental strain KM, on exposure to sea water at 12·8 or 20·8 °C was determined using in situ diffusion chambers. Plate counts were used to assess recoverability and injury while 5-cyano-2,3-ditolyl tetrazolium chloride (CTC) reduction was used to determine respiratory activity. T₉₀ values (times for 10-fold decreases in numbers of recoverable cells) on non-selective medium (trypticase soya agar with 0·6% yeast extract) at 12·8 and 20·8 °C were 61·7 and 69·2 h for L. monocytogenes Scott A, and 103·0 and 67·0 h for L. monocytogenes KM, respectively. On selective medium (Oxford agar), T₉₀ values at 12·8 and 20·8 °C were 60·6 and 56·9 h for L. monocytogenes Scott A, and 83·0 and 65·9 h for L. monocytogenes KM, respectively. With Scott A, the percentage of sublethally injured cells at 12·8 and 20·8 °C was 1·7 and 17·7%, respectively, while for KM the values were 19·0 and 1·6%, respectively. The fraction of cells reducing CTC but which were not recoverable on plating progressively increased on exposure to sea water. Listeria monocytogenes KM challenged at 58 °C showed an apparent increase in heat resistance after exposure to sea water at 20·8 °C for 7 d ( D ₅₈= 2·64 min) compared with before exposure ( D ₅₈= 1·24). This increase in thermal resistance was not apparent at temperatures greater than 63 °C, and analysis of the best-fit regression lines fitted to the thermal data obtained from the two cell populations indicated that their thermal resistance was not significantly different ( P > 0·05) over the temperature range tested (58–62 °C).     

High temperature effects on RuBP carboxylase and carbonic anhydrase activity in two tomato cultivars

The effects of temperature on ribulose bisphosphate carboxylase activity were studied in two tomato ( Lycopersicon esculentum Mill.) cultivars which differed in sensitivity to high temperatures. The heat tolerant cultivar, Saladette, had a smaller reduction in photosynthesis and a smaller increase in mesophyll resistance then the sensitive cultivar Roma VF, after 24 h at 35 to 40°C. One hour in vitro treatments at 50°C decreased the activity of ribulose bisphosphate carboxylase extracted from Roma VF by 75%, while Saladette was not affected. Heat stress to the entire plant caused greater inhibition of ribulose bisphosphate carboxylase in the heat sensitive cultivar. Ribulose bisphosphate carboxylase activity in both cultivars decreased with heat treatment but recovered under normal temperatures. Ribulose bisphosphate oxygenase activity decreased similarly in both cultivars under 37/18°C day/night temperatures, which resulted in an apparent change in the relative carboxylase/oxygenase activity of the two cultivars. Carbonic anhydrase activity was slightly greater in Saladette than in Roma VF but no significant decrease in activity was observed in plants exposed to high temperatures.     

Heat resistance of different serovars of Listeria monocytogenes

Twelve Listeria monocytogenes strains representing seven serovars were heat-treated in physiological saline by a glass capillary tube method. Five strains were treated at 58°, 60° and 62°C, three at 60°, 62° and 64°C and four at 60°C. Heat-treated bacteria were recovered on blood agar in two ways: (1) incubation at 37°C for 7 d; and (2) preincubation at 4°C for 5 d, followed by incubation at 37°C for 7 d. D and z values were determined. Better average recovery and higher D values were obtained when the preincubation procedure was used. The final evaluations of the heat resistance properties of the strains were therefore based on values for preincubated samples. D values recorded at 58°, 60°, 62° and 64°C for preincubated samples were 1.7–3.4, 0.72–3.1, 0.30–1.3 and 0.33–0.68 min, respectively. z values determined were 5.2–6.9°C. D values were compared statistically. Significant differences in heat resistance were noted both between serovars and between strains belonging to the same serovar.     

The effect of recovery conditions on the apparent heat resistance of Bacillus cereus spores

The effect of recovery media and incubation temperature on the apparent heat resistance of three ATCC strains (4342, 7004 and 9818) of Bacillus cereus spores were studied. Nutrient Agar (NA), Tryptic Soy Agar (TSA), Plate Count Agar (PCA) and Milk Agar (MA) as the media and temperatures in the range of 15–40°C were used to recover heated spores. Higher counts of heat injured spores were obtained on PCA and NA. The optimum subculture temperature was about 5°C below the optimum temperature for unheated spores. No significant differences in heat resistance were observed with the different recovery conditions except for strains 4342 and 9818 when MA was used as plating medium.
Large differences in D -values were found among the strains ( D ₁₀₀=0·28 min for 7004; D ₁₀₀=0·99 min for 4342; D ₁₀₀= 4·57 min for 9818). The 7004 strain showed a sub-population with a greater heat resistance. The z values obtained for the three strains studied under the different recovery conditions were similar (7·64°C 0·25).     

Enumeration of two competing Erwinia carotovora populations in potato tubers by a membrane filter-immunofluorescence procedure

Relative increases in cell populations of specific Erwinia carotovora strains injected into potato tubers either singly or in combination of two strains were determined by depositing tissue extracts on membrane filters and staining cells of individual strains by immunofluorescence. The population increase of an Erw. carotovora subsp. atroseptica (Eca) strain was, in general, not affected by the presence of an Erw. carotovora subsp. carotovora (Ecc) strain. However, the increase of an Ecc strain was inhibited by the presence of an Eca strain, especially at incubation temperatures of 5° and 15°C but not at 26°C. One Ecc strain consistently increased in population over another Ecc strain at a greater rate when they were inoculated together at the same loci in comparison to when they were inoculated separately at different loci.     

Resistance of Escherichia coli grown at different temperatures to various environmental stresses

Aims:  To study the influence of growth temperature on the resistance of Escherichia coli to three agents of different nature: heat, pulsed electric field (PEF) and hydrogen peroxide.
Methods and Results:  Escherichia coli cells were grown to stationary phase at 10°C, 20°C, 30°C, 37°C and 42°C. Survival curves to a heat treatment at 57·5°C, to a PEF treatment at 22 kV cm⁻¹ and to 40 mmol l⁻¹ hydrogen peroxide were obtained and fitted to a model based on the Weibull distribution to describe and compare the inactivation. Time to inactivate the first log cycle of the population at 57·5°C of cells grown at 42°C was sixfold higher than that corresponding to cells grown at 10°C. On the contrary, cells grown at 10°C and 20°C were more resistant to PEF and hydrogen peroxide treatments.
Conclusions:  The influence of growth temperature on bacterial resistance depends on the stress applied. Cells grown at higher temperatures were more heat resistant, but more sensitive to PEF and hydrogen peroxide.
Significance and Impact of the Study:  Results obtained in this investigation help in understanding the physiology of bacterial resistance and the inactivation mechanisms of different technologies.     

Heat resistance of Pectinatus sp., a beer spoilage anaerobic bacterium

D. WATIER, I. LEGUERINEL, J.P. HORNEZ, I. CHOWDHURY AND H.C. DUBOURGUIER. 1995. The heat resistance of three strains of Pectinatus (Pectinatus cerevisiiphilus DSM 20466, Pectinatus sp. DSM 20465 and Pectinatus frisingensis ATCC 33332) were measured at different temperatures (50–60°C), different pH (4–6·3), in two media (MRS and wort). Similar D ₆₀ values were obtained for DSM 20465 and ATCC 33332, but DSM 20466 was more resistant in MRS. Moreover the z values were higher in MRS than in wort for the three strains. Thermal destruction at different pH was variable. Results were discussed in relation to factors affecting heat resistance.     

Effects of heat shock upon the expression of developmentally regulated genes in Myxococcus xanthus

Abstract The effects of heat shock upon the expression of several developmentally regulated genes of Myxococcus xanthus were examined. No effects were observed on levels or timing of developmentally regulated β-galactosidase expression in eight randomly selected Tn5lac insertion mutants. However, heat shock significantly affected the fruiting behavior of temperature-sensitive aggregation ( tag ) mutants of M. xanthus . The tag mutant phenotype exhibits the normal aggregation of cells to form fruiting bodies at temperatures < 34°C, but cells fail to aggregate at temperatures ⩾ 34°C. Heat shock administered to tag mutant strains prior to starvation prohibited fruiting body formation at permissive temperatures. Additionally, tag mutant strains were found to be extremely sensitive to killing at 40°C. Heat shock was also found to increase tagA and tagE expression by 22 and 47%, respectively. Mutations in tagA blocked heat shock induced expression of tagE .     

Variation in the behaviour of enterotoxigenic Staphylococcus aureus after heat stress in milk

The survival of several strains of Staphylococcus aureus after heat stress in different menstrua was not logarithmic and F-values were determined to express their resistance to heat. Of the strains tested, Staph, aureus 234 (enterotoxin B) was the most heat resistant and Staph. aureus 790 (enterotoxin E) was the most heat sensitive. Buffalo milk gave the best protection to all the strains of Staph. aureus against heat, followed by cow's milk; phosphate-buffered saline gave the least protection. Soyabean casein digest agar gave maximum recovery of survivors followed by brain heart infusion and Baird-Parker medium. At 50°C there was no marked variation in coagulase production by the surviving strains but at 55 and 62–5dE C there was complete loss of coagulase activity. There was a decreased deoxyribonuclease (DNase) production by all the strains of Staph. aureus after heat stress. Heat-treatment at 55 and 62mD5dE C resulted in loss of enterotoxin production by all the survivors except S₆ and 234, the surviving cells of which still prodused enterotoxin B after heat treatment at 55dE C. Most of the survivors regained lost characteristics such as coagulase, DNase and enterotoxin production after four to five passages through BHI which suggests that subculture of Staph. aureus recovered from heat-processed milk is necessary to avoid false results.     

Strain-dependent induction by heat shock of resistance to ultraviolet light inEscherichia coli

Heat shock induces resistance to killing by ultraviolet light inEscherichia coli JE1011. When cells growing at 30°C were transferred to 42°C, maximum resistance to ultraviolet radition was reached after 30–45 min, but no change in heat resistance occurred. The effect was dependent on growth or protien synthesis. In contrast,E. coli B becomes more sensitive to the radiation and more heat resistant after a similar treatment. Thus, ultraviolet resistance and thermal resistance are not induced together in these two strains and may arise by independent mechanisms. It is also possible that thelon gene is involved in the effect of heat shock on ultraviolet resistance.     

The effect of temperature and growth rate on the susceptibility of Listeria monocytogenes to environmental stress conditions

R.A. PATCHETT, N. WATSON, P.S. FERNANDEZ AND R.G. KROLL. 1996. The effect of growth temperature and growth rate on the susceptibility to heat and pH stress were investigated in Listeria monocytogenes grown in continuous culture where these two growth variables could be varied independently of each other, and in batch culture. After growth at 30°C or 10°C at constant growth rate, or at 30°C at different growth rates, cells did not differ in their resistance to heat at 55°C. Cells grown at 30°C were more resistant to acid stress at pH 2.5 than cells grown at the same growth rates at 10°C. Cells grown at low growth rate at 30°C gave greater resistance to acid stress than those grown at high growth rate. Growth temperature and growth rate had independent effects on the susceptibility of L. monocytogenes to acid stress conditions. This may have implications for the survival of L. monocytogenes in acidic foods.     

Sporulation of Clostridium perfringens (welchii) in Four Laboratory Media

S ummary . Sporulation of 7 strains of Clostridium perfringens ( welchii ) was investigated in 4 laboratory media. A method to induce rapid and simultaneous sporulation was attempted which involved obtaining a purely vegetative culture to inoculate the test media. Heat resistance of spores produced in the individual media by each of 4 selected strains was investigated. The clean spores for the heating tests were obtained by a special procedure which included chilling to 6° for a minimum of 1 week immediately following the usual incubation period, then centrifuging, resuspending to volume in 0.85% NaCl solution and pasteurizing at 75° for 20 min before subjecting to the heating tests. Morphology of each strain was studied using stained microscopic preparations from the 24 h sporulating cultures.
In the Ellner medium spore counts approaching 10⁷/ml were recorded and this medium appeared to be the most efficient when judged in terms of numbers of spores produced. In other media the counts were in the range 10⁴-10⁵ spores/ml. Cooked meat medium yielded slightly higher spore counts than did either SEC broth or modified Wagenaar & Dack medium, the latter contained in a dialysis sac apparatus. A period of chilling to 6° for a minimum of 1 week following incubation enhanced maturation in all cultures except those grown in SEC broth for 24 h or 15 days and those grown 15 days in the modified Wagenaar & Dack medium.
Considerable heat resistance, expressed as percentage spore survival, was recorded for spores of 4 strains when heated at 80°, and heat resistance generally increased with lengthening of incubation time for the culture. Survival of spores heated at 100° for 10 min was usually less than 0.01% but spores in SEC broth after 15 days showed a somewhat greater heat resistance than the others. In no instance did total destruction of spores occur at 100°.     

Heat shock and thermotolerance of Escherichia coli O157:H7 in a model beef gravy system and ground beef

Duplicate beef gravy or ground beef samples inoculated with a suspension of a four-strain cocktail of Escherichia coli O157:H7 were subjected to sublethal heating at 46 °C for 15–30 min, and then heated to a final internal temperature of 60 °C. Survivor curves were fitted using a linear model that incorporated a lag period (T_L), and D-values and 'time to a 4D inactivation' (T_4D) were calculated. Heat-shocking allowed the organism to survive longer than non-heat-shocked cells; the T_4D values at 60 °C increased 1·56- and 1·50-fold in beef gravy and ground beef, respectively. In ground beef stored at 4 °C, thermotolerance was lost after storage for 14 h. However, heat-shocked cells appeared to maintain their thermotolerance for at least 24 h in ground beef held at 15 or 28 °C. A 25 min heat shock at 46 °C in beef gravy resulted in an increase in the levels of two proteins with apparent molecular masses of 60 and 69 kDa. These two proteins were shown to be immunologically related to GroEL and DnaK, respectively. Increased heat resistance due to heat shock must be considered while designing thermal processes to assure the microbiological safety of thermally processed foods.