Production of 3,4-Dihydroxyphenyl-L-alanine (L-DOPA) and Its Derivatives by Vibrio tyrosinaticus

Six strains of bacteria belonging to Vibrio and Pseudomonas were selected as good producers of L-DOPA from L-tyrosine out of various bacteria. The condition for the formation of L-DOPA by Vibrio tyrosinaticus ATCC 19378 was examined and the following results were obtained. (1) Intermittent addition of L-tyrosine in small portions gave higher titer of L-DOPA than single addition of L-tyrosine. (2) Higher amount of L-DOPA was produced in stationary phase of growth than in logarithmic phase. (3) Addition of antioxidant, chelating agent or reductant such as L-ascorbic acid, araboascorbic acid, hydrazine, citric acid and 5-ketofructose increased the amount of L-DOPA formed. (4) L-Tyrosine derivatives such as N-acetyl-L-tyrosine amide, N-acetyl-L-tyrosine, L-tyrosine amide, L-tyrosine methyl ester and L-tyrosine benzyl ester were converted to the corresponding L-DOPA derivatives.

In the selected condition about 4 mg/ml of L-DOPA was produced from 4.3 mg/ml of L-tyrosine.     

Crystallization and Characterization of Polyamine Oxidase from Aspergillus terreus

A thin-layer flow cell system for the determination of l-ascorbic acid by an ascorbate electrode was constructed and several components of this system were investigated. The most preferable conditions for optimum operation of the system were as follows: injection volume 150 μ1, delay coil length 60 cm, flow rate 1 ml/min, temperature 20°C, cell spacer thickness 0.2 mm. The linear response region was 0.2-3.0 mm and 0.02-0.5 mm (original l-ascorbic acid concentration) in the cases of pure oxygen and atmospheric oxygen bubbling, respectively. The relative standard variation at 1.5 mm l-ascorbic acid was 3.1 % for 20 successive assays. The measuring time was 2–3 min for each of these assays.     

Occurrence of 3-Hydroxy-3-methyl-glutaryl Coenzyme A Reductase in Sweet Potato

Illumination of the dark-grown Euglena gracilis, both the wild-green type and a permanently bleached mutant, for 4 hr at 2,000 lux caused about 6-fold increase of the cellular content of total l-ascorbic acid. The increase was mainly due to an increase of reduced-form l-ascorbic acid. From the action spectrum only blue light was found to be effective for the increase. Darkening stopped the increase and reillumination started a renewed increase. The activity of l-gulono-γ-lactone dehydrogenase, catalyzing the last step of l-ascorbic acid biosynthesis, was also increased two fold by illumination for 2 hr, and was changed in parallel to that of the cellular content of l-ascorbic acid depending on the presence or absence of illumination. The augmentation of l-ascorbic acid formation was markedly inhibited by various inhibitors and uncouplers, but not by dichlorophenyldimethylurea. The results in sum suggest that the light-dependent increase of l-ascorbic acid formation in E. gracilis is not primarily associated with photosynthesis, but is apparently related to the adaptation of the dark-grown cells to the illuminated state.     

The Contribution of Arabidopsis Homologs of L-Gulono-1,4-lactone Oxidase to the Biosynthesis of Ascorbic Acid

To clarify the involvement of seven Arabidopsis homologs of rat L-gulono-1,4-lactone (L-GulL) oxidase, AtGulLOs, in the biosynthesis of L-ascorbic acid (AsA), transgenic tobacco cells overexpressing the various AtGulLOs were generated. Under treatment with L-GulL, the levels of total AsA in three transgenic tobacco cell lines, overexpressing AtGulLO2, 3, or 5, were significantly increased as compared with those in control cells.     

Production of L-Threonine by Mutants Resistant to Both α-Amino-β-hydroxyvaleric Acid and S-(2-Aminoethyl)-L-cysteine Derived from Brevibacterium flavum

Growth of Brevibacterium flavum FA-1-30 and FA-3-115, L-lysine producers derived from Br. flavum No. 2247 as S-(2-aminoethyl)-L-cysteine (AEC) resistant mutants, was inhibited by α-amino-β-hydroxyvaleric acid (AHV), and this inhibition was reversed by L-threonine. All the tested AHV resistant mutants derived from FA-1-30 accumulated more than 4 g/liter of L-threonine in media containing 10% glucose, and the best producer, FAB-44, selected on a medium containing 5 mg/ml of AHV produced about 15 g/liter of L-threonine. Many of AHV resistant mutants selected on a medium containing 2 mg/ml of AHV accumulated L-lysine as well as L-threonine, AHV resistant mutants derived from FA-3-115 produced 10.7 g/liter of L-threonine maximally. AEC resistant mutants derived from strains BB–82 and BB–69, which were L-threonine producers derived from Br. flavum No. 2247 as AHV resistant mutants, did not produce L-threonine more than the parental strains, and moreover, many of them did not accumulate L-threonine but L-lysine. Homoserine dehydrogenases of crude extracts from L-threonine producing AHV resistant mutants derived from FA–1–30 and FA–3–115 were insensitive to the inhibition by L-threonine, and those of L-threonine and L-lysine producing AHV resistant mutants from FA–1–30 were partially sensitive.

Correlation between L-threonine or L-lysine production and regulations of enzymatic activities of the mutants was discussed.     

Structure of Rugulovasine A,B and their Derivatives

Culture conditions for the preparation of cells containing high tyrosine phenol lyase activity were studied with Erwinia herbicola ATCC 21434. Adding pyridoxine to the medium enhanced enzyme formation, suggesting that it was utilized as a precursor of the coenzyme, pyridoxal phosphate. Glycerol plus succinic acid; amino acids, such as, DL-methionine, DL-alanine and glycine; and metallic ion, ferrous ion promoted enzyme formation as well as cell growth. Adding L-tyrosine, as inducer, to the culture medium was essential for enzyme formation. However, when large amounts of L-tyrosine were added, the enzyme formation was repressed by the phenol liberated from L-tyrosine. In fact, formation of the enzyme was enhanced by removing phenol during cultivation. L(D)-Phenylalanine or phenylpyruvic acid had a synergistic effect on the induction of enzyme by L-tyrosine.

Cells with high enzyme activity were prepared by growing cells at 28°C for 28 hr in a medium containing 0.2% L-tyrosine, 0.2% KH₂PO₄, 0.1% MgSO₄7H₂O, 0.001% FeSO_4·7H₂O, 0.01% pyridoxine-HC1, 0.6% glycerol, 0.5% succinic acid, 0.1% DL-methionine, 0.2% DL-alanine, 0.05% glycine, 0.1% L-phenylalanine and 120 ml/liter hydrolyzed soybean protein in tap water with the pH controlled at 7.5 throughout cultivation.     

Monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic Acid,a Radical Product from the Reaction of Dehydro-l-ascorbic Acid with an α-Amino Acid

One of the radical species produced by the reaction of dehydro-l-ascorbic acid with an α-amino acid gave a very characteristic hyperfine structure in its electron spin resonance spectrum. The same spectrum was also obtained when l-scorbamic acid was oxidized with some oxidants, indicating the formation of the radical via the oxidation of l-scorbamic acid. From the results of deuterium exchange experiments, simulation spectra and the reduction of 2,2′-nitrilodi-2(2′)-deoxy-l-ascorbic acid monoammonium salt, the radical was concluded to be monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic acid. Possible formation mechanism of the radical was also discussed.     

New Resolving Agents

Seven optical active 2-benzylamino alcohols were synthesized by reduction of N-benzoyl derivatives of L-alanine, L-valine, L-leucine, L-phenylalanine, L-aspartic acid, L-glutamic acid and L-lysine and applied for the resolution of (±)-trans-chrysanthemic acid. d-trans-Chrys-anthemic acid was obtained by resolution via the salts of 2-benzylamino alcohols derived from L-valine and L-leucine, while (?)-trans-chrysanthemic acid was prepared through the salts of the amino alcohols derived from L-alanine and L-phenylalanine.     

Effects of Acetylation with Acetic Anhydricle

1. L-Asparaginase (EC 3.5.1.1) from Escherichia coli A–l–3 was acetylated using acetic anhydride as a modifying chemical. The fully acetylated L-asparaginase retained 60% of the activity of the unmodified L-asparaginase.

2. The acetylated L-asparaginase hydrolyzed D-asparagine and L-glutamine as well as L-asparagine in the same ratio as the unmodified L-asparaginase did.

3. However, the effects of pH on the activity of the acetylated L-asparaginase showed very interesting differences from that of L-asparaginase. On the other hand, both L-asparaginase and the acetylated L-asparaginase exhibited similar pH activity curves on L-glutamine hydrolysis.

4. The acetylated L-asparaginase was found to become more stable against acid or heat in the presence of L-aspartate than in its absence in the same manner as L-asparaginase was.

     

Current studies on the enzymatic preparation 2-O-α-d-glucopyranosyl-l-ascorbic acid with cyclodextrin glycosyltransferase

2-O-α-d-glucopyranosyl-l-ascorbic acid (AA-2G) is one of the most important l-ascorbic acid derivatives because of its resistance to reduction and oxidation and its easy degradation by α-glucosidase to release l-ascorbic acid and glucose. Thus, AA-2G has commercial uses in food, medicines and cosmetics. This article presents a review of recent studies on the enzymatic production of AA-2G using cyclodextrin glycosyltransferase. Reaction mechanisms with different donor substrates are discussed. Protein engineering, physical and biological studies of cyclodextrin glycosyltransferase are introduced from the viewpoint of effective AA-2G production. Future prospects for the production of AA-2G using cyclodextrin glycosyltransferase are reviewed.     

Determination Method for l-Ascorbic Acid in Foods with Immobilized Ascorbate Oxidase

Pumpkin (Cucurbita moschata) ascorbate oxidase was entrapped within 6% (w/v) Ca-alginate gel beads, and then the beads were treated with 1% (w/v) glutaraldehyde for 20 hr at 4°C. The immobilized ascorbate oxidase was much more stable than the free form. Under the optimum conditions, the immobilized enzyme remained fully active for 3 months and after 50 assays. A linear relationship was found between immobilized ascorbate oxidase activity and l-ascorbic acid concentration in the range of 2 ~ 20 μg/ml. The immobilized preparation could be employed for the simple and rapid determination of l-ascorbic acid in foods.     

Studies on the the Isoleucine Fermentation

Accumulation of L-isoleucine and L-valine was studied on 14 genera, 47 species and 110 strains of aerobic bacteria using bacterial type cultures. A large amount of L-isoleucine and a small amount of L-valine accumulated when 1% of DL-α-aminobutyric acid was added to the culture medium. As a rule, facultative aerobes such as Aerobacter, Erwinia, Serratia and Bacillus showed good accumulation. In the absence of α-aminobutyric acid, powerful L-isoleucine accumulators produced a large amount of L-valine, although the accumulation of L- isoleucine was scarcely observed under that condition. In the presence of α-aminobutyric acid, the accumulation of L-valine was generally suppressed, but in several strains, on the contrary, the accumulation increased as well as that of L-isoleucine. When DL-threonine was used instead of α-aminobutyric acid, the amount of L-isoleucine accumulated was not as high as that with α-aminobutyric acid in almost all strains except Serratia marcescens. It was concluded that a distinct relationship between bacterial genera or species and accumulation of L-isoleucine did not exist, that is, powerful accumulators were limited to special strains, and that the addition of α-aminobutyric acid was necessary for the accumulation of a large amount of L-isoleucine.     

Preparation of Optically Active Allothreonine by Separating from a Diastereoisomeric Mixture with Threonine

A simple procedure is described to obtain D- and L-allothreonine (D- and L-aThr). A mixture of N-acetyl-D-allothreonine (Ac-D-aThr) and N-acetyl-L-threonine (Ac-L-Thr) was converted to a mixture of their ammonium salts and then treated with ethanol to precipitate ammonium N-acetyl-L-threoninate (Ac-L-Thr·NH₃) as the less-soluble diastereoisomeric salt. After separating Ac-L-Thr·NH₃ by filtration, Ac-D-aThr obtained from the filtrate was hydrolyzed in hydrochloric acid to give D-aThr of 80% de, recrystallized from water to give D-aThr of >99% de. L-aThr was obtained from a mixture of the ammonium salts of Ac-L-aThr and Ac-D-Thr in a similar manner.     

Isolation and Characterization of Thermotolerant Gluconobacter Strains Catalyzing Oxidative Fermentation at Higher Temperatures

Thermotolerant acetic acid bacteria belonging to the genus Gluconobacter were isolated from various kinds of fruits and flowers from Thailand and Japan. The screening strategy was built up to exclude Acetobacter strains by adding gluconic acid to a culture medium in the presence of 1% D-sorbitol or 1% D-mannitol. Eight strains of thermotolerant Gluconobacter were isolated and screened for D-fructose and L-sorbose production. They grew at wide range of temperatures from 10°C to 37°C and had average optimum growth temperature between 30-33°C. All strains were able to produce L-sorbose and D-fructose at higher temperatures such as 37°C. The 16S rRNA sequences analysis showed that the isolated strains were almost identical to G. frateurii with scores of 99.36-99.79%. Among these eight strains, especially strains CHM16 and CHM54 had high oxidase activity for D-mannitol and D-sorbitol, converting it to D-fructose and L-sorbose at 37°C, respectively. Sugar alcohols oxidation proceeded without a lag time, but Gluconobacter frateurii IFO 3264^T was unable to do such fermentation at 37°C. Fermentation efficiency and fermentation rate of the strains CHM16 and CHM54 were quite high and they rapidly oxidized D-mannitol and D-sorbitol to D-fructose and L-sorbose at almost 100% within 24 h at 30°C. Even oxidative fermentation of D-fructose done at 37°C, the strain CHM16 still accumulated D-fructose at 80% within 24 h. The efficiency of L-sorbose fermentation by the strain CHM54 at 37°C was superior to that observed at 30°C. Thus, the eight strains were finally classified as thermotolerant members of G. frateurii.     

Enzymatic Quantification of L-Tartrate in Wines and Grapes by Using the Secondary Activity of D-Malate Dehydrogenase

L-Tartrate in wines and grapes was enzymatically quantified by using the secondary activity of D-malate dehydrogenase (D-MDH). NADH formed by the D-MDH reaction was monitored spectrophotometrically. Under the optimal conditions, L-tartrate (a 1.0 mM sample solution) was fully oxidized by D-MDH in 30 min. A linear relationship was obtained between the absorbance difference and the L-tartrate concentration in the range of a 0.02-1.0 mM sample solution with a correlation coefficient of 0.9991. The relative standard deviation from ten measurements was 1.71% at the 1.0 mM sample solution level. The proposed method was compared with HPLC, and the values determined by both methods were in good agreement.     

Culture Conditions for the Production of l-Glutamic Acid from n-Paraffins by Glycerol Auxotroph GL-21

A novel process for the microbial production of l-glutamic acid on an industrial scale was successfully established by using a glycerol auxotroph.

The most suitable carbon source for producing L-glutamic acid was n-paraffins (C₁₃–C₁₅). The production of L-glutamic acid was not affected by a large amount of biotin or oleic acid in the absence of penicillin, and occurred maximally at the glycerol concentration of 0.02% at pH 6.6. The most effective temperature was 28°C.

Under optimal conditions in a 200 liter fermentor, the mutant produced 72 g/liter of L-glutamic acid. On the other hand, the parent produced 53 g/liter of L-glutamic acid in the presence of penicillin.

It is believed that the low productivity of L-glutamic acid by the parent strain was mainly due to the occurrence of the marked decrease in the viable cell counts at the later phase of the fermentation caused by the action of penicillin added.     

A Novel Synthesis of l-Ascorbic Acid

A three steps synthesis of l-ascorbic acid (I) from d-glucuronolactone (III) is described.     

New Polar Constituents in the Pupae of the Silkworm Bombyx mori L. (II): Developmental Changes of the Constituents

A correlation between the quantitative changes in L-methionine analogs, the ratio of D-serine/L-serine during the pupal stage, and metamorphosis was observed. The glycoside appearing at low blood sugar values during the pupal stage was isolated and characterized as D-glucosyl-L-tyrosine. ¹H-NMR indicated the appearance and increase of this glycoside, and Mirrorcle Ray CV4 equipment was used to take X-ray pictures of the pupal bodies. The results indicate that γ-cyclic di-L-glutamate and L-methionine sulfone might be concerned with ammonia assimilation in the pupae, and that D-glucosyl-L-tyrosine served as a switch for the fatty acid (pupal oil) dissimilation hybrid system.     

Genetic Engineering of Candida utilis Yeast for Efficient Production of L-Lactic Acid

Polylactic acid is receiving increasing attention as a renewable alternative for conventional petroleum-based plastics. In the present study, we constructed a metabolically-engineered Candida utilis strain that produces L-lactic acid with the highest efficiency yet reported in yeasts. Initially, the gene encoding pyruvate decarboxylase (CuPDC1) was identified, followed by four CuPDC1 disruption events in order to obtain a null mutant that produced little ethanol (a by-product of L-lactic acid). Two copies of the L-lactate dehydrogenase (L-LDH) gene derived from Bos taurus under the control of the CuPDC1 promoter were then integrated into the genome of the CuPdc1-null deletant. The resulting strain produced 103.3 g/l of L-lactic acid from 108.7 g/l of glucose in 33 h, representing a 95.1% conversion. The maximum production rate of L-lactic acid was 4.9 g/l/h. The optical purity of the L-lactic acid was found to be more than 99.9% e.e.