Studies on the Polymorphism of l-Glutamic Acid

The effects on the polymorphic crystallization of l-glutamic acid were examined of many substances including amino acids, inorganic salts, surface active agents, and sodium salt or hydrochloride of l-glutamic acid, when contained in the mother liquor.

The co-existence of amino acids, especially of l-aspartic acid, l-phenylalanine, l-tyrosine, l-lcucine and l-cystine contributed to the crystallization of l-glutamic acid in α-form, and these amino acid showed an inhibitory action on the transition of α-crystals as the solid phase in the aqueous solution, to β-crystals.

In the presence of a large amount of l-glutamate or the hydrochloride at the time of nucleation of l-glutamic acid, mostly β-crystals appeared even in the presence of the amino acids named above.     

Protective Actions of l-Aspartate from Acid or Proteolytic Inactivation

1. l-Aspartate was found to replace l-asparagine in the protective action from acid inactivation of l-asparaginase (EC 3.5.1.1) produced by Escherichia coli A–1–3 and at the same time to inhibit the proteolytic inactivation by α-chymotrypsin.

2. l-Asparaginase changed in its chromatographic properties in the presence of l-aspartate and became to be absorbed on the CM Sephadex column.

3. The sedimentation patterns of l-asparaginase at pH 3.5 were identical either in the presence or absence of l-aspartate, showing partial dissociation. But the reversibility to the active state was observed only in the enzyme dissolved in the solution containing l-aspartate.

4. l-Aspartate did not prevent the enzyme either from the dissociation into subunits or from decrease in the activity by urea.

5. High concentration of l-aspartate was shown to inhibit the l-asparagine hydrolysis reaction.

6. l-Aspartate was suggested from ORD measurements to cause changes in the higher structure as well as the ionic properties or proteolytic inactivation.

     

Studies on the Formation of the Cheese-like Flavor

Solution containing l-leucine and l-methionine cultured by Aspergillus flavus were found to develop cheese-like flavor.

α-Keto-isocaproic acid was isolated and identified from the culture of l-leucine and α-keto-β-methylmercaptobutyric acid from that of l-methionine. The flavor was also developed from the mixture of the synthetic sample of α-ketoisocaproic acid and α-keto-β-methylmercaptobutyric acid.     

Elimination,Replacement and Isomerization Reactions by Intact Cells Containing Tyrosine Phenol Lyase

Tyrosine phenol lyase catalyzes a series of α,β-elimination, β-replacement and racemization reactions. These reactions were studied with intact cells of Erwinia herbicola ATCC 21434 containing tyrosine phenol lyase.

Various aromatic amino acids were synthesized from l-serine and phenol, pyrocatechol, resorcinol or pyrogallol by the replacement reaction using the intact cells. l(d)-Tyrosine, 3,4-dihydroxyphenyl-l(d)-alanine (l(d)-dopa), l(d)-serine, l-cysteine, l-cystine and S-methyl-l-cysteine were degraded to pyruvate and ammonia by the elimination reaction. These amino acids could be used as substrate, together with phenol or pyrocatechol, to synthesize l-tyrosine or l-dopa via the replacement reaction by intact cells. l-Serine and d-serine were the best amino acid substrates for the synthesis of l-tyrosine or l-dopa. l-Tyrosine and l-dopa synthesized from d-serine and phenol or pyrocatechol were confirmed to be entirely l-form after isolation and identification of these products. The isomerization of d-tyrosine to l-tyrosine was also catalyzed by intact cells.

Thus, l-tyrosine or l-dopa could be synthesized from dl-serine and phenol or pyrocatechol by intact cells of Erwinia herbicola containing tyrosine phenol lyase.     

2-Keto-l-gulonic Acid Fermentation

l-Sorbose metabolism in Pseudomonas aeruginosa IFO 3898 was studied. When the strain was cultivated in l-sorbose medium, l-idonic and 2-keto-l-gulonic acids were detected in the culture broth.

From the results on the metabolism of various sugars and sugar acids with the cell suspension and the metabolites accumulated, the following pathway was proposed for the l-sorbose metabolism in Ps. aeruginosa IFO 3898.

l-Sorbose → l-idose → l-idonic acid → 2-keto-l-gulonic acid.     

Studies on the Synthesis of l-Amino Acids

l-Homoserine was prepared by the reduction of l-aspartic acid β-methyl ester with sodium borohydride in water solution without any racemization. The yield of l-homoserine was about 25% of the theoretical amount, and no product other than l-homoserine, l-aspartic acid and l-aspartic acid β-methyl ester was present in the reaction mixture. The low yield of l-homoserine was ascribed to the hydrolysis of the ester.

l-Azetidine-2-carboxylic acid could not be detected in the reaction mixture. In contrast with the reduction of l-glutamic acid γ-esters, the reduction of l-aspartic acid β-ester was not accompanied by the cyclization.     

Fermentative Production of l-Arginine

Most of the bacteria, which were examined for the sensitivity to l-arginine analogs (l-canavanine, l-homoarginine, d-arginine and arginine hydroxamate), were insensitive to the analogs at a concentration of 8 mg/ml. Corynebacterium glutamicum DSS-8 isolated as d-serine-sensitive mutant from an isoleucine auxotroph KY 10150, was found to be sensitive to d-arginine and arginine hydroxamate. Furthermore, DSS-8 produced l-arginine in a cultural medium. l-Arginine analog-resistant mutants were derived from DSS-8 by N-methyl-N′-nitro-N-nitrosoguanidine (NTG) treatment. Most of them were found to produce a large amount of l-arginine. An isoleucine revertant from one of these mutants produced 19.6 mg/ml of l-arginine in the medium containing 15% (as sugar) of molasses.

The mechanism of the sensitivity to l-arginine analogs and that of the production of l-arginine in the d-serine-sensitive mutant, DSS-8, were investigated. DSS-8 seems to be a mutant having increased permeability to d- and l-arginine.     

Studies on the Photolysis of l-Cysteine and l-Cystine

In the presence and absende of riboflavin, the aqueous solutions of l-cysteine and l-cystine were exposed to sunlight. The solutions in the presence of riboflavin developed the typical flavor of cooked rice. Hydrogen sulfide, ammonia, carbon dioxide and acetaldeohyde were found from the solutions that formed the flavor.

The component responsible for the flavor was not a single one but consisted of three compounds, such as hydrogen sulfide, ammonia and acetaldehyde. An aqueous solution of the mixture containing these three compounds developed organoleptically the typical flavor of cooked rice. These compounds were also present in the vapor of cooked rice.     

Branched Chain Amino Acid Aminotransferase of Pseudomonas sp

Branched chain amino acid aminotransferase was partially purified from Pseudomonas sp. by ammonium sulfate fractionation, aminohexyl-agarose and Bio-Gel A-0.5 m column chromatography.

This enzyme showed different substrate specificity from those of other origins, namely lower reactivity for l-isoleucine and higher reactivity for l-methionine.

Km values at pH 8.0 were calculated to be 0.3 mm for l-leucine, 0.3 mm for α-ketoglutarate, 1.1 mm for α-ketoisocaproate and 3.2 mm for l-glutamate.

This enzyme was activated with β-mercaptoethanol, and this activated enzyme had different kinetic properties from unactivated enzyme, namely, Km values at pH 8.0 were calculated to be 1.2 mm for l-leucine, 0.3 mm for α-ketoglutarate.

Isocaproic acid which is the substrate analog of l-leucine was competitive inhibitor for pyridoxal form of unactivated and activated enzymes, and inhibitor constants were estimated to be 6 mm and 14 mm, respectively.     

Studies of the Sunlight Flavor of Beer

The recent findings^1~3) that prenylmercaptan (3-methyl-2-butene-1-thiol) is the major component of the sunlight flavor of beer has led us to investigate the pathway of its evolution. S-Prenyl-l-cysteine, S-(3-methyl-2-butenyl)-l-cysteine, was synthesized according to the general outline of A. Stoll et al.⁴⁾ from l-cyteine and prenylbromide, since it was considered as one of the precursors of the sunlight flavor of beer. S-Prenyl-l-cysteine was a colorless and odorless crystal, but this compound generated prenylmercaptan when the aqueous solution was exposed to sunlight. The addition of a small amount of riboflavin to the solution as a photosensitizer increased the mercaptan evolution. Prenylmercaptan formed by sunlight was isolated as its 2,4-dinitrophenyl derivative and identified by the comparison of melting point, chromatographic behavior and infrared spectrum with an authentic sample and by its elemental analysis.     

l-Isoleucine Production by Analog-resistant Mutants Derived from Threonine-producing Strain of Corynebacterium glutamicum

A thiaisoleucine-resistant mutant, ASAT–372, derived from a threonine producer of Corynebacterium glutamicum, KY 10501, produced 5 mg/ml each of l-isoleucine and l-threonine. l-Isoleucine productivity of ASAT–372 was improved stepwise, with concurrent decrease in threonine production, by successively endowing it with resistivity to such substances as ethionine, 4-azaleucine and α-aminobutyric acid. The mutant strain finally selected, RAM–83, produced 9.7 mg/ml of l-isoleucine with a medium containing 10% (as sugar) molasses.

l-Isoleucine production was significantly affected by the concentration of ammonium sulfate in the fermentation medium. At 4% ammonium sulfate l-isoleucine production was enhanced whereas l-threonine production was suppressed. At 2% ammonium sulfate l-threonine production was stimulated while l-isoleucine production decreased.     

On the Mechanism of l-Prolyl Diketopiperazine Formation by Streptomyces

Since l-prolyl diketopiperazines, l-prolyl-l-valine anhydride and l-leucyl-l-proline anhydride, had been isolated from the culture filtrate of Streptomyces sp. S-580, the mechanism of l-prolyl diketopiperazine formation by Streptomyces has been studied. These two l-prolyl diketopiperazines were not formed from their constituent amino acids incubated with intact cell or cell free homogenate of this strain in buffered salt solution containing energy source. However, from milk casein, poly peptone or gelatin, the former two were components of the culture medium of this strain, hydrolyzed with the pure streptomyces-protease, these l-prolyl diketopiperazines were obtained (only from gelatin, glycyl-l-proline anhydride were obtained in addition to these two). Furthermore, in hydrolysis of some synthetic l-prolyl peptides with this enzyme, l-prolyl diketopiperazine formation were also studied, and as the result, glycyl-l-proline anhydride was obtained from glycyl-l-prolyl-l-leucine but no l-prolyl diketopiperazine was formed from l-prolyl-l-leucyl-glycine. From these evidences, the possible route of l-prolyl diketopiperazine formation by Streptomyces has been discussed.     

Purification,Crystallization and Properties of Tryptophanase from Proteus rettgeri

An inducible tryptophanase was crystallized from the cell extract of Proteus rettgeri grown in a medium containing l-tryptophan. The purification procedure included ammonium sulfate fractionation, heat treatment, DEAE-Sephadex and hydroxylapatite column chromatographies. Crystals were obtained from solutions of the purified enzyme by the addition of ammonium sulfate.

The crystalline enzyme preparation was homogeneous by the criteria of ultracentrifugation and zone electrophoresis. The molecular weight was determined to be approximately 210,000.

The crystalline enzyme catalyzed the degradation of l-tryptophan into indole, pyruvate and ammonia in the presence of added pyridoxal phosphate. The enzyme also catalyzed pyruvate formation from 5-hydroxy-l-tryptophan, 5-methyl-l-tryptophan, S-methyl-l-cysteine and l- cysteine. l-, d-Alanine, l-phenylalanine and indole inhibited pyruvate formation from these substrates.     

Genetic Changes of Regulatory Mechanisms Occurred in Leucine and Valine Producing Mutants Derived from Brevibacterium lactofermentum 2256

The regulatory mechanisms in branched-chain amino acid synthesis were compared between 2-thiazolealanine (2-TA) resistant l-leucine and l-valine producing mutants and the 2-TA sensitive original strains of Brevibacterium lactofermentum 2256.

In the original strains, sensitive to 2-TA, α-isopropylmalate (IPM) synthetase, the initial enzyme specific for l-leucine synthesis, is sensitive to feedback inhibition and to repression by l-leucine, and α-acetohydroxy acid (AHA) synthetase, the common initial enzyme for synthesis of l-isoleucine, l-valine as well as l-leucine, is sensitive to feedback inhibition by each one of these amino acids, and to repression by them all. In strain No. 218, a typical l-leucine producer resistant to 2-TA, IPM synthetase was found to be markedly desensitized and derepressed, and AHA synthetase remained unaltered. On the contrary, in strain No. 333, l-valine producer resistant to 2-TA, AHA synthetase was found to be desensitized and partially derepressed, and IPM synthetase remained unaltered.

The genetic alteration of these regulatory mechanisms was discussed in connection with the accumulation pattern of amino acids.     

Monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic Acid,a Radical Product from the Reaction of Dehydro-l-ascorbic Acid with an α-Amino Acid

One of the radical species produced by the reaction of dehydro-l-ascorbic acid with an α-amino acid gave a very characteristic hyperfine structure in its electron spin resonance spectrum. The same spectrum was also obtained when l-scorbamic acid was oxidized with some oxidants, indicating the formation of the radical via the oxidation of l-scorbamic acid. From the results of deuterium exchange experiments, simulation spectra and the reduction of 2,2′-nitrilodi-2(2′)-deoxy-l-ascorbic acid monoammonium salt, the radical was concluded to be monodehydro-2,2′-iminodi-2(2′)-deoxy-l-ascorbic acid. Possible formation mechanism of the radical was also discussed.     

Mechanism of l-Threonine and l-Lysine Production by Analog-resistant Mutants of Corynebactemum glutamicum

Homoserine dehydrogenases and aspartokinases in l-threonine- or l-threonine and l-lysine-producing mutants derived from Corynebacterium glutamicum KY 9159 (Met^?) were studied with respect to the sensitivity to the inhibition by end products, l-threonine and l-lysine. The activities of homoserine dehydrogenases in the mutants which produced l-threonine or l-threonine and l-lysine were slightly less susceptible to the inhibition by l-threonine than the activity in the parent strain, KY 9159. The aspartokinases in the threonine-producing mutants, KY 10484 and KY 10230, which were resistant to α-amino-β-hydroxylvaleric acid (AHV, a threonine analog) and more sensitive to thialysine (a lysine analog) than the parent, were sensitive to the concerted feedback inhibition by l-lysine and l-threonine by about the same degree as KY 9159. The aspartokinase in an AHV- and thialysine-resistant mutant, KY 10440, which was derived from KY 10484 and produced about 14 mg/ml of l-threonine in a medium containing 10% glucose was less susceptible to the concerted feedback inhibition than KY 10484 or KY 9159, although the activity was still under the feedback control. In the parent strain, l-threonine activated aspartokinase activity in the absence of ammonium sulfate, an activator of the enzyme, but partially inhibited the activity in the presence of the salt. On the other hand, the enzyme of KY 10440 was activated by l-threonine either in the presence or in the absence of the salt. In another AHV- and thialysine-resistant mutant, KY 10251, which was derived from KY 10230 and produced both 9 mg/ml of l-threonine and 5/5 mg/ml of l-lysine, l-threonine and l-lysine simultaneously added hardly inhibited the activity of aspartokinase.

Implications of these results are discussed in relation to l-threonine or l-lysine production, AHV or thialysine resistance and regulation of l-threonine biosynthesis in these mutants.     

Purification,Crystallization and Properties of Tyrosine Phenol Lyase from Erwinia herbicola

Crystalline tyrosine phenol lyase was prepared from the cell extract of Erwinia herbicola grown in a medium supplemented with l-tyrosine. The crystalline enzyme was homogeneous by the criteria of ultracentrifugation and acrylamide gel electrophoresis. The molecular weight was determined to be approximately 259,000. The crystalline enzyme catalyzed the conversion of l-tyrosine into phenol, pyruvate and ammonia, in the presence of added pyridoxal phosphate. The enzyme also catalyzed pyruvate formation from d-tyrosine, S-methyl-l-cysteine, 3, 4-dihydroxyphenyl-l-alanine, l- and d-serine, and l- and d-cysteine, but at lower rates than from l-tyrosine. l-Phenyl-alanine, l-alanine, phenol and pyrocatechol inhibited pyruvate formation from l-tyrosine.

Crystalline tyrosine phenol lyase from Erwinia herbicola is inactive in the absence of added pyridoxal phosphate. Binding of pyridoxal phosphate to the apoenzyme is accompanied by pronounced increase in absorbance at 340 and 425 mμ. The amount of pyridoxal phosphate bound to the apoenzyme was determined by equilibrium dialysis to be 2 moles per mole of enzyme. Addition of the substrate, l-tyrosine, or the competitive inhibitors, l-alanine and l-phenyl-alanine, to the holoenzyme causes appearance of a new absorption peak near 500 mμ which disappears as the substrate is decomposed but remains unchanged in the presence of the inhibitor.     

Separation of l-Leucine-pyruvate and l-Leucine-α-ketoglutarate Transaminases in Acetobacter suboxydans and Identification of Their Reaction Products

l-Leucine-pyruvate and l-leucine-α-ketoglutarate(α-KGA) transaminases were separated by DEAE-cellulose column chromatography and partially purified to 200- and 50-fold, respectively, from the cell-free extract of Acetobacter suboxydans (Gluconobacter suboxydans IFO 3172). The optimum pH range of the former was 5.0~5.5 and that of the latter was 8.5~9.0. l-Leucine, l-citrulline, and l-methionine were the most effective amino donors for the l-leucine-pyruvate transaminase. Basic amino acids as well as aromatic amino acids were able to be amino donors for the transamination with pyruvate. α-KGA was effective as an amino acceptor for this enzyme. The l-leucine-α-KGA transaminase had the typical properties of the branched-chain amino acid transaminase in its substrate specificity.

The reaction products of the transaminations were identified. l-Alanine was formed from pyruvate and l-glutamate from α-KGA. α-Keto acids formed from various amino acids by the l-leucine-pyruvate transaminase were also identified.     

Production of l-allose and d-talose from l-psicose and d-tagatose by l-ribose isomerase

l-ribose isomerase (L-RI) from Cellulomonas parahominis MB426 can convert l-psicose and d-tagatose to l-allose and d-talose, respectively. Partially purified recombinant L-RI from Escherichia coli JM109 was immobilized on DIAION HPA25L resin and then utilized to produce l-allose and d-talose. Conversion reaction was performed with the reaction mixture containing 10% l-psicose or d-tagatose and immobilized L-RI at 40 °C. At equilibrium state, the yield of l-allose and d-talose was 35.0% and 13.0%, respectively. Immobilized enzyme could convert l-psicose to l-allose without remarkable decrease in the enzyme activity over 7 times use and d-tagatose to d-talose over 37 times use. After separation and concentration, the mixture solution of l-allose and d-talose was concentrated up to 70% and crystallized by keeping at 4 °C. l-Allose and d-talose crystals were collected from the syrup by filtration. The final yield was 23.0% l-allose and 7.30% d-talose that were obtained from l-psicose and d-tagatose, respectively.     

Formations of Oligopeptides from Dipeptides by the Protease from Streptomyces cellulosae

The protease from Streptomyces cellulosae formed more turbidity in a 16% soybean protein hydrolysate in the initial stage of the reaction than α-chymotrypsin did, when the proteolytic activity of the protease was same as that of α-chymotrypsin. In highly concentrated solutions (2.5%) of various dipeptides, oligopeptides were produced by condensation by the protease. The oligopeptides formed were (l-Leu-Gly)₂ and (l-Leu-Gly)₃ from l-Leu-Gly, (l-Phe-l-Val)₂ from l-Phe-l-Val, (l-Val-l-Phe)₂ and (l-Val-l-Phe)₃ from l-Val-l-Phe, and (l-Leu-l-Met)₂ and (l-Leu-l-Met)₃ from l-Leu-l-Met.