微生物燃料电池中假单胞菌F026的产电性能研究

基于微生物燃料电池的反应装置,从污水处理厂曝气池的污泥中通过富集,筛选和基于16S rRNA基因序列的系统发育分析等手段驯化出1株高效产电假单胞菌F026。以F026为阳极产电菌制作微生物燃料电池,考察了底物种类、温度和p H值等因素对微生物燃料电池产电性能的影响。结果表明,F026最适合在以可溶性淀粉为底物,p H为中性偏碱性,温度在30~35℃的环境下生长。在此条件下,微生物燃料电池的最高电压达到500 m V,体积功率密度达到2 W/m3。     

Production of Electricity and Butanol from Microalgal Biomass in Microbial Fuel Cells

Chlorella vulgaris (a freshwater microalga) and Dunaliella tertiolecta (a marine microalga) were grown for bulk harvest, and their biomass was tested as feedstock for electricity production in cubic two-chamber microbial fuel cells (MFCs) at 37°C. The anode inoculum was anaerobic consortium from a municipal sewage sludge digester, enriched separately for the two microalgal biomass feedstocks. After repeated subculturing of the two anaerobic enrichments, the maximum power density obtained in MFCs was higher from C. vulgaris (15.0 vs. 5.3 mW m^?2) while power generation was more sustained from D. tertiolecta (13 vs. 9.8 J g^-1 volatile solids). Anolytes of algal biomass-fed MFCs also contained substantial levels of butanol (8.7–16 mM with C. vulgaris and 2.5–7.0 mM with D. tertiolecta), which represents an additional form of utilizable energy. Carryover of salts from the marine D. tertiolecta biomass slurry resulted in gradual precipitation of Ca and Mg phosphates on the cathode side of the MFC. Polymerase chain reaction-denaturing gradient gel electrophoresis profiling and sequencing of bacterial communities demonstrated the presence of Wolinella succinogenes and Bacteroides and Synergistes spp. as well as numerous unknown bacteria in both enrichments. The D. tertiolecta enriched consortium contained also Geovibrio thiophilus and Desulfovibrio spp. Thus, the results indicate potential for combining fermentation and anaerobic respiration for bioenergy production from photosynthetic biomass.     

3D Macroporous Nitrogen‐Enriched Graphitic Carbon Scaffold for Efficient Bioelectricity Generation in Microbial Fuel Cells

Microbial fuel cell (MFC) can generate electricity based on oxidation of organic compounds by exoelectogens, giving rise to a promising potential for recovering electrical energy from organic wastewater. The structure and property of anode materials have inherent impact to extracellular electron transfer (EET), an interfacial process that greatly limits bioelectricity production of MFC. Herein, a three dimensional (3D) macroporous nitrogen‐enriched graphitic carbon (NGC) scaffold is fabricated from commercially available melamine foam using facile pyrolysis method. The NGC electrode is demonstrated to promote EET ef?ciently, achieving a power density of 750 mW m^?2 based on pure cultured Shewanella oneidensis MR‐1 in acetate‐feeding MFC. The unique 3D open‐cell structure not only offers habitats for colonization of electroactive bio?lm up to a maximal density but also provides macroporous architecture for internal mass transfer without concern of bio‐blocking and bio‐fouling. Additionally, nitrogen incorporation also plays a signi?cant role in enhancing EET, where pyrrolic nitrogen is much more active than graphitic and pyridinic nitrogen as indicated by density functional theory calculation. This work provides a proof‐of‐concept demonstration of a high‐ef?ciency, cost‐effective, easily scaling‐up, and environmentally friendly anode material of bioelectrochemical systems for electricity generation, hydrogen production, and pollutant degradation.     

微生物燃料电池中产电微生物的系统发育分析及筛选

对污水处理厂曝气池的产电微生物进行富集并利用纯培养法筛选,采用基于16S rRNA基因序列的系统发育分析方法研究了产电微生物的生物多样性,并基于三电极体系绘制出的循环伏安曲线鉴别出产电性能较强的纯菌株。结果表明,菌株F003、F042和F050与其系统发育关系最密切的有效发表种的典型菌株的16S rRNA基因序列存在较大差异,分别代表新的分类单元。之后又对所获得的38株菌株进行电化学测试活性,得出4株活性较强的菌株,其中菌株F010和F017的电化学活性比菌株F007和F051更为显著。     

Generation of Electricity and Analysis of Microbial Communities in Wheat Straw Biomass-Powered Microbial Fuel Cells

Electricity generation from wheat straw hydrolysate and the microbial ecology of electricity-producing microbial communities developed in two-chamber microbial fuel cells (MFCs) were investigated. The power density reached 123 mW/m² with an initial hydrolysate concentration of 1,000 mg chemical oxygen demand (COD)/liter, while coulombic efficiencies ranged from 37.1 to 15.5%, corresponding to the initial hydrolysate concentrations of 250 to 2,000 mg COD/liter. The suspended bacteria found were different from the bacteria immobilized in the biofilm, and they played different roles in electricity generation from the hydrolysate. The bacteria in the biofilm were consortia with sequences similar to those of Bacteroidetes (40% of sequences), Alphaproteobacteria (20%), Bacillus (20%), Deltaproteobacteria (10%), and Gammaproteobacteria (10%), while the suspended consortia were predominately Bacillus (22.2%). The results of this study can contribute to improving understanding of and optimizing electricity generation in microbial fuel cells.Wheat straw is one of the most abundant renewable resources. According to the Food and Agriculture Organization of the United Nations, approximately 1.9 × 10⁹ tons of wheat straw annually are produced worldwide, accompanied by 6.2 × 10⁸ tons of wheat production. Wheat straw is composed of 35 to 45% cellulose and 20 to 30% hemicelluloses with a relatively low lignin content (<20%) (42). The hemicellulose fraction of the straw is easily hydrolyzed to its constituent sugars by a hydrothermal treatment process, forming a carbohydrate-enriched liquid hydrolysate (46). Chemical and biological approaches to sustainable energy production from the liquefied hydrolysates to energy carriers, such as methane, ethanol, and H₂, have been developed. However, many of these approaches encounter technical and economical hurdles (10, 12, 15, 16). An alternative strategy is direct conversion of wheat straw biomass to electrical energy in microbial fuel cells (MFCs).MFCs are bioelectrochemical reactors in which microorganisms mediate the direct conversion of chemical energy stored in organic matter or bulk biomass into electrical energy (12, 15, 16, 40). Various substrates, such as simple carbohydrates, low-molecular-weight organic acids, starch, amino acids, chitin, cellulose, domestic wastewater, food-processing wastewater, recycled paper wastewater, and marine sediment organic matter, have been successfully utilized for power generation in MFCs (16-18, 27, 30, 33). To understand the microbial constraints on various fuel-powered MFCs, microbial communities have been characterized by several groups. Microbial communities from various systems are very different and often diverse, ranging from well-known metal- and anode-reducing bacteria to unknown exoelectrogens (1, 20, 21). It has been found that parameters such as the substrates used as fuels and the inocula used for starting up the MFCs can influence the anode bacterial communities in an MFC, which subsequently influence the efficiency of the MFCs (3, 14, 22, 38, 44). Different pure substrates, such as acetate, glucose, and lactate, were used as fuel to compare the microbial communities that developed in the MFCs. Regardless of the different substrates, all anode communities contained sequences closely affiliated with Geobacter sulfurreducens (>99% similarity) and an uncultured bacterium clone belonging to the family Bacteroidaceae (99% similarity). Firmicutes were only found in glucose-fed MFCs (20). Microbial-community analyses of MFCs powered with complex substrates have also been performed by several researchers, and their results were very diverse. The microbial community in starch wastewater-powered MFC was dominated by unidentified bacteria (35.9%), followed by Betaproteobacteria (25.0%), Alphaproteobacteria (20.1%), and the Cytophaga/Flexibacter/Bacteroides group (19.0%) (21). The anode-attached consortia in a cellulose-powered MFC were related to Clostridium spp., while Comamonas spp. were abundant in the suspended consortia (13). Although many studies have reported the microbial compositions of MFCs, it is still unclear which microbial communities develop as a function of the external parameters.Wheat straw biomass constitutes a large source for bioenergy production and shows promising prospects for electricity generation in MFCs. Therefore, wheat straw biomass was used to study the microbial communities that develop during the operation of an MFC in order to better understand the microbial electrochemical roles and potentially improve MFC performance.The objectives of this study were to (i) test wheat straw hydrolysate as a potential fuel in an MFC for electricity generation and (ii) study the microbial composition and evolution of electricity-producing communities in a two-chamber MFC system. Phylogenetic-diversity analysis of the enriched consortia was conducted to verify the presence of hydrolytic and respiratory anaerobes that could couple hydrolysate oxidation with proton reduction in the anode chamber. This is the first report of exploiting microbial communities for direct conversion of wheat straw hydrolysate to electrical energy in an MFC.     

Electricity Generation in Microbial Fuel Cells Using Neutral Red as an Electronophore

Neutral red (NR) was utilized as an electron mediator in microbial fuel cells consuming glucose to study both its efficiency during electricity generation and its role in altering anaerobic growth and metabolism of Escherichia coli and Actinobacillus succinogenes. A study of chemical fuel cells in which NADH, NR, and ferricyanide were the electron donor, the electronophore, and the electron acceptor, respectively, showed that electrical current produced from NADH was proportional to the concentration of NADH. Fourfold more current was produced from NADH in chemical fuel cells when NR was the electron mediator than when thionin was the electron mediator. In microbial fuel cells in which E. coli resting cells were used the amount of current produced from glucose when NR was the electron mediator (3.5 mA) was 10-fold more than the amount produced when thionin was the electron mediator (0.4 mA). The amount of electrical energy generated (expressed in joules per mole of substrate) and the amount of current produced from glucose (expressed in milliamperes) in NR-mediated microbial fuel cells containing either E. coli or A. succinogenes were about 10- and 2-fold greater, respectively, when resting cells were used than when growing cells were used. Cell growth was inhibited substantially when these microbial fuel cells were making current, and more oxidized end products were formed under these conditions. When sewage sludge (i.e., a mixed culture of anaerobic bacteria) was used in the fuel cell, stable (for 120 h) and equivalent levels of current were obtained with glucose, as observed in the pure-culture experiments. These results suggest that NR is better than other electron mediators used in microbial fuel cells and that sludge production can be decreased while electricity is produced in fuel cells. Our results are discussed in relation to factors that may improve the relatively low electrical efficiencies (1.2 kJ/mol) obtained with microbial fuel cells.     

利用异化金属还原菌构建含糖微生物燃料电池

环境中的一些微生物通过还原金属氧化物进行无氧呼吸,而石墨电极与金属氧化物相似,也可以作为这类微生物呼吸作用的最终电子受体,利用这类微生物构建微生物燃料电池,以糖类物质为燃料,对电池产电情况、产电原理进行研究。实验结果表明,以Rhodoferaxferrireducens为产电微生物,在外接电阻510Ω条件下,以葡萄糖为燃料,常温下产生的电流密度达158mAm2(平台电压为0.46V,电极有效接触表面积为57cm2),且循环性能良好。更换燃料为其它糖,发现微生物可以利用多种糖进行产电;通过SEM观察发现大量微生物吸附在石墨电极上,用Bradford法对运行20d后电池的细胞量进行定量,测得悬浮细胞蛋白浓度为140mgL,吸附在电极上的生物量为1180mgm2。通过数据采集分析和细菌还原实验,发现吸附在电极上的微生物对电压的产生贡献最大,具有电化学和生物学活性;悬浮细胞对产电贡献很小,不具有电化学和生物学活性。     

关于微生物燃料电池底物的研究进展

近年来,微生物燃料电池已引起了广泛关注,它将低能量废水和木质纤维素生物质等有机废物转化为电能。在将来,微生物电能将成为一种重要的生物能源,因为微生物燃料电池提供了一种复合有机物和可再生生物能源中提取电能的可行性。人们研究了许多物质,以考察其是否能作为微生物电能转化的底物。这些物质包括人工的和天然废物,以及木质纤维素生物质。尽管现在微生物燃料电池提供的电流和功率较低,但是随着技术的发展和对微生物燃料电池系统的深入了解,微生物燃料电池转化的电流和电力将极大增加,从而向世人提供了一种可以将纤维素生物质和废水直接转化为有用能源的有效方法。本文介绍了迄今为止在微生物燃料电池中用到的各种反应底物,并对它们的应用效率和存在的不足进行了分析。     

The Remediation of Chromium (VI)-Contaminated Soils Using Microbial Fuel Cells

Chromium (VI) is a priority pollutant in soil and water and poses serious threats to the environment. Microbial fuel cells (MFCs), as a sustainable technology, have been applied to treat heavy-metal-contaminated wastewater. To study MFC application in soil remediation, red clay soil and fluvo-aquic soil were spiked with Cr(VI) and packed into a cathode chamber of MFCs, which were then operated at external resistances of 100 and 1000 Ω for 16 days, with open circuit condition as a control treatment. After the operation, the concentration of dissolved Cr(VI) in supernatant and total Cr(VI) in soil was decreased. Soil type and external resistance significantly affected the current, removal efficiency of Cr(VI), and cathode efficiency. Reducing external resistance improved the removal efficiency. The red soil generated a higher current of MFCs, but showed a lower removal efficiency and cathode efficiency than fluvo-aquic soil, implying that the red soil may contain more electron acceptors that competed with Cr(VI) reduction reaction. Our study demonstrated that MFC-based technology has the potential to remediate Cr(VI)-contaminated soil; the efficiency varied between soil types and can be improved with high current.     

沉积型海底微生物燃料电池构建及其影响因素研究

海底微生物燃料电池具有底物丰富、可长期运行、维护成本低和环境友好等特点,具有很好的研究价值和广阔的发展前景。但由于其低的功率密度输出和长期运行的不稳定性,使海底微生物燃料电池尚未得到广泛地实际应用。选取海底沉积泥用于实验室构建的海底微生物燃料电池装置中,比较了在不同阳极材料、阴阳极面积比、阳极修饰、阳极泥下深度条件下海底微生物燃料电池的功率密度输出及其电化学性能,得出最佳的海底微生物燃料电池阳极材料为碳毡;阴极及电极最佳面积比为1∶1;最佳阳极修饰为氨水浸渍;最佳阳极泥下深度为2 cm。     

微生物燃料电池发展态势分析

随着世界经济的高速发展和人口的不断增长,能源短缺和环境污染问题日益成为制约发展的瓶颈。微生物燃料电池(microbial fuel cell,MFC)能将污染物中蕴含的化学能直接转化为电能,实现同步污水处理和电能回收,是一种极具前景的可持续污水处理技术。同时,MFC在污泥处理、生物修复、环境监测、海水淡化等方面也展示了诱人的前景。基于科睿唯安Web of Science数据库和德温特专利检索分析平台(Derwent Innovation, DI),对MFC领域1990~2018年的论文和专利数据进行统计分析,得出全球MFC领域的发展趋势、国际分布、研发热点和技术格局。在此基础上,对未来MFC领域的发展做出了展望,对中国MFC产业化发展提出了思考和建议。     

Biomass Production from Electricity Using Ammonia as an Electron Carrier in a Reverse Microbial Fuel Cell

The storage of renewable electrical energy within chemical bonds of biofuels and other chemicals is a route to decreasing petroleum usage. A critical challenge is the efficient transfer of electrons into a biological host that can covert this energy into high energy organic compounds. In this paper, we describe an approach whereby biomass is grown using energy obtained from a soluble mediator that is regenerated electrochemically. The net result is a separate-stage reverse microbial fuel cell (rMFC) that fixes CO₂ into biomass using electrical energy. We selected ammonia as a low cost, abundant, safe, and soluble redox mediator that facilitated energy transfer to biomass. Nitrosomonas europaea, a chemolithoautotroph, was used as the biocatalyst due to its inherent capability to utilize ammonia as its sole energy source for growth. An electrochemical reactor was designed for the regeneration of ammonia from nitrite, and current efficiencies of 100% were achieved. Calculations indicated that overall bioproduction efficiency could approach 2.7±0.2% under optimal electrolysis conditions. The application of chemolithoautotrophy for industrial bioproduction has been largely unexplored, and results suggest that this and related rMFC platforms may enable biofuel and related biochemical production.     

微生物燃料电池中产电微生物的研究进展

产电微生物是微生物燃料电池系统的核心组成, 本文从生物学角度介绍了几种产电微生物的分类学地位、形态特征、生理生化特征及在微生物燃料电池中的产电机理和产电能力, 分析了利用产电微生物进行废水处理同时生物发电的应用前景, 提出产电微生物在MFC系统中的进一步研究方向为微生物的富集、驯化、改造和多种菌种优化组合等。     

Electrocatalysts for PEM Fuel Cells

Degradation phenomena of electrocatalysts for proton‐exchange membrane fuel cells and their mechanisms are reviewed. Platinum dissolution and redeposition, carbon‐support corrosion, inhomogeneity during start‐up and cell reversal are discussed as factors that influence the degradation of electrocatalysts with relation to electrode potential. Early research findings at the National Institute of Advanced Industrial Science and Technology (AIST), Japan, are mainly used as a basis of discussion. The development of highly durable electrocatalysts using an oxide support based on the results of degradation studies to suppress electrocatalyst degradation is summarized with a main focus on Pt‐deposited Ti₄O₇ catalysts developed at AIST. The development of high‐CO‐concentration durable anode electrocatalysts is also reviewed. In particular, an electrocatalyst that uses an organic complex as a co‐electrocatalyst with a platinum ruthenium alloy anode electrocatalyst developed at AIST is included as a novel high‐CO‐concentration durable anode electrocatalyst.     

Flexible and Stretchable Biobatteries: Monolithic Integration of Membrane‐Free Microbial Fuel Cells in a Single Textile Layer

The fabrication and performance of a flexible and stretchable microbial fuel cell (MFC) monolithically integrated into a single sheet of textile substrate are reported. The single‐layer textile MFC uses Pseudomonas aeruginosa (PAO1) as a biocatalyst to produce a maximum power of 6.4 µW cm^?2 and current density of 52 µA cm^?2, which are substantially higher than previous textile‐MFCs and are similar to other flexible paper‐based MFCs. The textile MFC demonstrates a stable performance with repeated stretching and twisting cycles. The membrane‐less single‐chamber configuration drastically simplifies the fabrication and improves the performance of the MFC. A conductive and hydrophilic anode in a 3D fabric microchamber maximizes bacterial electricity generation from a liquid environment and a silver oxide/silver solid‐state cathode reduces cathodic overpotential for fast catalytic reaction. A simple batch fabrication approach simultaneously constructs 35 individual devices, which will revolutionize the mass production of textile MFCs. This stretchable and twistable power device printed directly onto a single textile substrate can establish a standardized platform for textile‐based biobatteries and will be potentially integrated into wearable electronics in the future.     

土壤微生物量测定方法概述

土壤微生物量是土壤生态系统研究的重要参数之一。常用的土壤微生物量的测定方法主要包括:直接镜检法、熏蒸系列方法、底物诱导系列方法、成分分析法和比色法。对这些具体测定方法、原理及其优缺点进行了简要的评述,并指出了应用这些方法须注意的问题和今后的研究方向。     

The Nature of Proton Shuttling in Protic Ionic Liquid Fuel Cells

It has been proposed previously that protic ionic liquids (PILs) such as diethylmethylammonium triflate could be used as the electrolytes in nonhumidified, intermediate temperature H₂ fuel cells, potentially offering the prospect of high conductivity and performance, even under anhydrous conditions. In this contribution, a combination of electroanalytical chemistry and fuel‐cell polarization analyses is used to demonstrate for the first time that the pure PILs cannot support proton shuttling between the electrodes of fuel cells. Only through the inclusion of dissolved acidic or basic proton shuttles can viable protic ionic fuel cells be fabricated, which has major consequences for the use of these neoteric electrolytes in fuel cells.     

Metagenomic Analyses Reveal the Involvement of Syntrophic Consortia in Methanol/Electricity Conversion in Microbial Fuel Cells

Methanol is widely used in industrial processes, and as such, is discharged in large quantities in wastewater. Microbial fuel cells (MFCs) have the potential to recover electric energy from organic pollutants in wastewater; however, the use of MFCs to generate electricity from methanol has not been reported. In the present study, we developed single-chamber MFCs that generated electricity from methanol at the maximum power density of 220 mW m⁻² (based on the projected area of the anode). In order to reveal how microbes generate electricity from methanol, pyrosequencing of 16S rRNA-gene amplicons and Illumina shotgun sequencing of metagenome were conducted. The pyrosequencing detected in abundance Dysgonomonas, Sporomusa, and Desulfovibrio in the electrolyte and anode and cathode biofilms, while Geobacter was detected only in the anode biofilm. Based on known physiological properties of these bacteria, it is considered that Sporomusa converts methanol into acetate, which is then utilized by Geobacter to generate electricity. This speculation is supported by results of shotgun metagenomics of the anode-biofilm microbes, which reconstructed relevant catabolic pathways in these bacteria. These results suggest that methanol is anaerobically catabolized by syntrophic bacterial consortia with electrodes as electron acceptors.