Adsorption of the antibiotic, nisin, to Streptococcus lactis cells

Nizin is produced by Str. lactis, strain MSU. During biosynthesis it is excreted into the fermentation broth and gradually adsorbed on the organism cells. This was confirmed by experiments with an inactive variant of Str. lactis IIa. The cells of this culture adsorbed nizin from "active" fermentation broth. Adsorption of nizin depended on pH of the medium; at pH 2,3 the cells did not adsorbe the antibiotic and at pH 6.6 the amount of the antibiotic adsorbed by the cells was maximum.     

Nisin inactivation in a culture of the producer Streptococcus lactis strain MGU

The intensive biosynthesis of nizin on the glucose-yeast medium is observed during the logarithmic and early lag phases of the staphylococcal growth. The ratio of nizin in the fermentation broth (free nazin) and that bound with the cells depended on pH of the medium. When pH was maintained at 6.6-6.8, the amount of nazin in the cells during and growth logarithmic phase was equal to its amount in the fermentation broth filtrate. During the lag phase marked inactivation of nizin was noted. periodical feeding of casein prevented the nizin inactivation. The preliminary data are indicative of the enzymatic nature of the antibiotic.     

Effect of the initial pH value of the medium on the growth of Streptococcus lactis and the biosynthesis of nisin]

The effect of the initial pH value of the medium within 4.0 to 6.6 on the growth of Str. lactis and biosynthesis of nicin was studied. It was found that at the initial pH 4.0--4.5 of the medium the growth of the culture was poor, i.e. 11--14% of the control (initiral pH 6.6). With an increase in the value of the initial pH at least to 5.0 the growth of Str. lactis also increased. At the initial pH 4.0 no biosynthesis of nicin was observed. Under the experimental conditions the antibiotic synthesis by tr. lactic started at the initial pH being equal to 4.5 and reached its maximum at pH 6.6.     

Studies concerning Swedish ropy milk

Summary Str. lactis longi has been found to possess inhibitory properties against Staphylococcus aureus, Escherichia coli, and a Clostridium strain. The composition of the slime produced by Str. lactis longi has been studied.Professor Dr. Dr. h. c. A. Rippel zum 70. Geburtstag.     

Hydrolysis of lactose by immobilized microorganisms.

Cells of Lactobacillus bulgaricus, Escherichia coli, and Kluyveromyces (Saccharomyces) lactis immobilized in polyacrylamide gel beads retained 27 to 61% of the beta-galactosidase activity of intact cells. Optimum temperature and pH and thermostability of these microbial beta-galactosidases were negligibly affected by the immobilization. Km values of beta-galactosidase in immobilized cells of L. bulgaricus, E. coli, and K. lactis toward lactose were 4.2, 5.4, and 30 mM, respectively. Neither inhibition nor activation of beta-galactosidase in immobilized L. bulgaricus and E. coli appeared in the presence of galactose, but remarkable inhibition by galactose was detected in the case of the enzyme of immobilized K. lactis. Glucose inhibited noncompetitively the activity of three species of immobilized microbial cells. These kinetic properties were almost the same as those of free beta-galactosidase extracted from individual microorganisms. The activity of immobilized K. lactis was fairly stable during repeated runs, but those of E. coli and L. bulgaricus decreased gradually. These immobilized microbial cells, when introduced into skim milk, demonstrated high activity for converting lactose to monosaccharides. The flavor of skim milk was hardly affected by treatment with these immobilized cells, although the degree of sweetness was raised considerably.     

Hydrolysis of lactose by immobilized microorganisms.

Cells of Lactobacillus bulgaricus, Escherichia coli, and Kluyveromyces (Saccharomyces) lactis immobilized in polyacrylamide gel beads retained 27 to 61% of the beta-galactosidase activity of intact cells. Optimum temperature and pH and thermostability of these microbial beta-galactosidases were negligibly affected by the immobilization. Km values of beta-galactosidase in immobilized cells of L. bulgaricus, E. coli, and K. lactis toward lactose were 4.2, 5.4, and 30 mM, respectively. Neither inhibition nor activation of beta-galactosidase in immobilized L. bulgaricus and E. coli appeared in the presence of galactose, but remarkable inhibition by galactose was detected in the case of the enzyme of immobilized K. lactis. Glucose inhibited noncompetitively the activity of three species of immobilized microbial cells. These kinetic properties were almost the same as those of free beta-galactosidase extracted from individual microorganisms. The activity of immobilized K. lactis was fairly stable during repeated runs, but those of E. coli and L. bulgaricus decreased gradually. These immobilized microbial cells, when introduced into skim milk, demonstrated high activity for converting lactose to monosaccharides. The flavor of skim milk was hardly affected by treatment with these immobilized cells, although the degree of sweetness was raised considerably.     

Conditions for nisin adsorption by Streptococcus lactis cells

Some conditions for absorption of nisin, a polypeptide antibiotic by the cells of Str. lactis were studied. The amounts of nisin adsorbed by the cells depended on the culture age: at the late stationary phase the adsorption level was 2 times higher than that at the logarithmic phase. The cells grown on a "poor" medium adsorbed 85-90 per cent of nisin added to the solution, while the cells grown on the "rich" medium adsorbed 50 per cent of the antibiotic. The adsorption level of nisin by the cells subjected to a thermal shock was higher than that by the live cells. Desorption of nisin from the cells with acid ethanol and bivalent cation solutions was insignificant. Nisin is adsorbed by the cells of other microorganisms, the adsorption levels by the cells of Bac. brevis being the same as those by the streptococcal cells, while the levels adsorbed by Bac. polymyxa being 4 times lower.     

Influence of products of thermophilous methane fermentation on the mixed lactic acid bacterial culture]

The effect of products resulting from thermophilous methane fermentation on the accumulation and ratio of different lactic acid bacteria (Str. lactis, Str. cremoris, Str. diacetilactis, Str. diacetil. var. acetoinicus, Leuc. citrovorum8 L. plantarum) was investigated upon their combined cultivation in milk and serum. In combined cultivation of the streptococcal culture the rate of growth of a single strain differed from that in separate cultivation. Str. cremoris was accumulated with the highest rate during its separate cultivation and with the lowest rate during its combined cultivation. An addition of products of thermophilous methane fermentation to the combined culture of streptococci of different strains increased the growth rate and accumulation of each strain. At the same time the products influenced differently the quantitative ratios of various strains in the resulting biomass. For instance, the relative content of Str. cremoris and Leuc. citrovorum decreased insignificantly and that of Str. lactis and Str. diacetil. var. acetoin.increased. The combined cultivation of the five streptococcal strains with L. plantarum in the medium containing no additions of thermophilous methane fermentation products increased the relative content of L. plantarum from the beginning of fermentation. In the medium containing the additions of this parameter varied sinusoidally with a minimum of 6 to 9 hours. Possible mechanisms of these changes are discussed.     

THE HEAT DISINFECTION OF STREPTOCOCCUS FAECALIS AND STREPTOCOCCUS LACTIS

SUMMARY: The heat resistance of a number of strains of Streptococcus lactis and Str. faecalis at 60° in Ringer's solution and separated milk has been determined and the Decimal Reduction Times (D.R.T.) calculated.
Heating in separated milk at 60° enabled Str. lactis to be sharply differentiated in most cases from Str. faecalis. The latter gave D.R.T. values usually much above 3 min. while the former gave values usually under 1 min. and certainly less than 3 min. Single tests might give misleading results with certain strains.
The log. survivor-time graphs of both species were not always straight lines over all their length. A preliminary period of slow death was frequently observed.     

Nisin adsorption on silica adsorbents

It has been shown that silica adsorbents can be used for adsorption of nizin from solutions obtained after centrifugation of the fermentation broth. The optimal structure of the adsorbent pores has been determined. Silica with pores 50 to 75 nm in size provided the highest adsorption rates. The value of silica adsorption of nizin depended on the medium pH. The maximum adsorption rates were observed at pH 6.5--7. At pH 3.5 the level of nizin adsorption was low.     

pH-controlled cell release and biomass distribution of alginate-immobilized Lactococcus lactis subsp. lactis

AIMS: To investigate the growth and release of Lactococcus lactis subsp. lactis in gel beads and to affect rates of cell release by changing the growth conditions. METHODS AND RESULTS: The rate of release and the distribution of immobilized L. lactis subsp. lactis in alginate beads were studied in continuous fermentations for 48 h. A change in operating pH from 6.5 to 9.25 initially reduced the ratio of the rates of cell release to lactate production by almost a factor of 105. Compared with fermentations at pH 6.5, growth at pH 9.25 also increased the final internal bead biomass concentration by a factor of 5 and increased the final rate of lactate production by 25%. After 48 h, the ratio of the rates of cell release to lactate production was still 10 times lower than in fermentations at pH 6.5. CONCLUSIONS: A change in the operating pH from 6.5 to 9.25 reduced rates of cell release throughout 48 h of fermentation and increased the final rates of lactate production and internal bead biomass concentration. SIGNIFICANCE AND IMPACT OF THE STUDY: These data illustrate that diffusional limitations and corresponding pH gradients can be exploited in affecting the distribution of immobilized growing cells and their concomitant release.     

固定化乳酸乳球菌连续生产Nisin的研究

以海藻酸钙为材料 ,固定乳酸乳球菌 (Lactococcuslactissubsp .lactis)SM5 2 6 ,研究不同条件对Nisin合成的影响。结果表明 ,利用 2 %海藻酸钠在 1 0mmol LCaCl2 条件下 ,得到的固定化细胞颗粒稳定性较好 ,可维持 90h无破裂 ;在发酵过程中SYS3培养基中的无机盐成分尤其磷酸盐对固定化颗粒有破坏作用 ;用mSYS3培养基代替SYS3 ,通过 72h三批次循环的半连续培养 ,Nisin活性为 85 0IU mL ,无明显的细胞渗漏现象。连续化生产 70h ,Nisin活性达 1 1 5 0IU mL ,相当于游离细胞的发酵水平。     

Increased stress tolerance of Bifidobacterium longum and Lactococcus lactis produced during continuous mixed-strain immobilized-cell fermentation

AIMS: The effect of immobilization and long-term continuous culture was studied on probiotic and technological characteristics of lactic acid and probiotic bacteria. METHODS AND RESULTS: A continuous culture in a two-stage system was carried out for 17 days at different temperatures ranging from 32 to 37 degrees C, with a first reactor containing Bifidobacterium longum ATCC 15707 and Lactococcus lactis subsp. lactis biovar. diacetylactis MD immobilized separately in gel beads, and a second reactor operated with free cells released from the first reactor. The tolerance of free cells from both strains produced in the effluent medium of both reactors to hydrogen peroxide, simulated gastric and intestinal juices, antibiotics and nisin, and freeze-drying markedly increased with culture time and was generally higher after 6 days than that of stationary-phase cells produced during free-cell batch fermentations. The reversibility of the acquired tolerance of B. longum, but not L. diacetylactis, to antibiotics was shown during successive free-cell batch cultures. CONCLUSIONS: Free cells produced from continuous immobilized-cell culture exhibited altered physiology and increased tolerance to various chemical and physico-chemical stresses. SIGNIFICANCE AND IMPACT OF THE STUDY: Continuous culture with immobilized cells could be used to produce probiotic and lactic acid bacteria with enhanced technological and probiotic characteristics.     

The effect of long-term preservation of microbial cells immobilized in poly(vinyl alcohol) cryogel on their viability and biosynthesis of target metabolites

The effect of cell storage at -18 degrees C for 18-24 months on reproductive capacity was investigated for various microorganisms (gram-positive and gram-negative bacteria, yeasts, and filamentous fungi) immobilized in poly(vinyl alcohol) cryogel. To examine the viability of immobilized cells after defrosting, the bioluminescent method of intracellular ATP determination was used. A high level of metabolic activity of immobilized cells after various periods of storage was recorded for Streptomyces anulatus, Rhizopus orvzae, and Escherichia coli, which are producers of the antibiotic aurantin, L(+)-lactic acid, and the recombinant enzyme organophosphate hydrolase, respectively. It was shown that the initial concentration of immobilized cells in cryogel granules plays an important role in the survival of Str. anulatus and Pseudomonas putida after 1.5 years of storage. It was found that, after slow defrosting in the storage medium at 50C for 18 h of immobilized cells of the yeast Saccharomvces cerevisiae that had been stored for nine months, the number of reproductive cells increased due to the formation of ascospores.     

Continuous production of lacticin 3147 and nisin using cells immobilized in calcium alginate

Bacteriocinogenic strains, Lactococcus lactis subsp. lactis DPC 3147 and L. lactis DPC 496, producing lacticin 3147 and nisin, respectively, were immobilized in double-layered calcium alginate beads. These beads were inoculated into MRS broth at a ratio of 1:4 and continuously fermented for 180 h. Free cells were used to compare the effect of immobilization on bacteriocin production. After equilibrium was reached, a flow rate of 580 ml h(-1) was used in the immobilized cell (IC), and 240 ml h(-1) in free-cell (FC) bioreactors. Outgrowth from beads was observed after 18 h. Bacteriocin production peaked at 5120 AU ml(-1) in both IC and FC bioreactors. However, FC production declined after 80 h to 160 AU ml(-1) at the end of the fermentation. Results of this study indicate that immobilization offers the possibility of a more stable and long-term means of producing lacticin 3147 in laboratory media than with free cells.     

Continuous mixed strain mesophilic lactic starter production in supplemented whey permeate medium using immobilized cell technology

The aim of this work was to study a new process for the continuous production of mixed-strain lactic acid bacteria starters using immobilized cells. Three strains of Lactococcus (two Lactococcus lactis subsp. lactis: KB and KBP, and one Lactococcus lactis subsp. lactis biovar diacetylactis: MD) were immobilized separately in kappa-carrageenan-locust bean gum gel beads. Continuous fermentations were carried out in a 1 L pH-controlled stirred tank reactor with a 30% (v/v) bead inoculum (strain ratio 1:1:1), continuously fed with a whey UF permeate medium, supplemented with 1.5% yeast extract and 0.1M KCl. The effects of three parameters-pH, temperature (T), dilution rate (D), and their interactions on the composition and activity of the culture in the effluent at pseudosteady state were studied according to a rotatable central composite design, during a 53-day fermentation. The process showed a high biological stability and no strain became dominant, or was eliminated from the bioreactor. The statistical analysis showed that the three strains were differently affected by the studied parameters, and that a large range of effluent starter composition can be achieved by varying D, pH, and T. However, the acidifying characteristics were not affected by the culture conditions. A cross-contamination from other strains of the mixed culture was observed in gel beads entrapping a pure culture at the fermentation onset, and led to a biomass redistribution within the beads. However, the strain ratio (KB:KBP:MD) observed after the 53-day experiment (1:2:2) was close to the initial bead ratio (1:1:1). The beads demonstrated a high mechanical stability throughout the 53-day continuous fermentation. (c) 1997 John Wiley & Sons, Inc. Biotechnol Bioeng 56: 502-516, 1997.     

Mass transfer analysis for immobilized cells of Lactococcus lactis sp. using both simulations and in-situ pH measurements

Mathematical modeling and in-situ pH measurements were used to characterize the effects of the microenvironment on alginate gel beads immobilized cells of Lactococcus lactis. Mass transfer limitations led to a progressive pH acidification within gel beads which determined both the cell distribution and the cellular activity of entrapped cells. The dynamics of the system is discussed in relation to the overall activity of the immobilized cell reactor.     

A comparative study of the formation of 2-keto-D-gluconic acid by free and immobilized cells of Pseudomonas putida

The effect of glucose, oxygen and 2-keto-D-gluconic acid (2KG) concentrations on the 2KG production by free and immobilized cells of Pseudomonas putida was studied. The effect of these factors was found to be similar in case of both free and immobilized cells, but the rate of the 2KG production by the free cells was a little higher as compared to the immobilized cells.     

Quantitative determination of the spatial distribution of pure- and mixed-strain immobilized cells in gel beads by immunofluorescence

A new method was developed to detect and quantify two strains, Lactococcus lactis subsp. lactis biovar. diacetylactis MD and Bifidobacterium longum ATCC 15707, immobilized separately and co-immobilized in gel beads, using specific polyclonal antibodies and confocal laser-scanning microscopy. The establishment of biomass concentration profiles for each strain was measured during colonization of beads using successive pH-controlled batch fermentations. Growth occurred preferentially in 200- and 300-microm peripheral layers of the beads for L. diacetylactis and B. longum, respectively. Repeated-batch cultures with immobilized cells permitted the production of a mixed culture containing a non-competitive strain of bifidobacteria, as a result of immobilized-cell growth and high cell-release activity from the beads. During co-immobilized fermentations, there were no apparent interactions between the strains.     

Continuous production of bacteriocins, brevicin, nisin and pediocin, using calcium alginate-immobilized bacteria

Bacteriocins including brevicin 286, nisin and pediocin PO2 have been produced successfully with immobilized cells of Lactobacillus brevis VB286, Lactococcus lactis subsp. lactis and Pediococcus acidilactici PO2 respectively encapsulated in calcium alginate beads. The beads encapsulating the bacteriocin-producing cells were loaded into a column, and continuously supplied with fresh medium at a flow rate of 1 bed volume per 20 min. The concentrations of the three bacteriocins produced in the eluents were at least as high as those obtained from conventional free-cell batch fermentations.