絮凝选择载体的构建及β葡萄糖苷酶基因在酿酒酵母中的表达

从强絮凝酿酒酵母(Saccharomyces cerevisiae)ABXL-1D菌株中用PCRA-法扩增到絮凝基因(Flocculation gene,FLO1),构建以絮凝基因作选择标记的酿酒酵母表达栽体：用该栽体表达Bacillus polymyxa的β-葡萄糖苷酶基因,转化子可直接从沉淀中筛选。摇瓶培养细胞得到的β-葡萄糖苷酶比活力为3．91u／mg蛋白。在发酵葡萄糖和纤维二糖混合底物时,转化子的葡萄糖残存量明显低于受体菌。这将有利于利用纤维素发酵生产酒精。     

酿酒酵母和克鲁维酵母发酵菊芋生产燃料乙醇

为获得菌株发酵菊芋生产燃料乙醇的最佳方案,首先选取实验室保存的重组菌株R32对其产酶条件进行优化,其最高产菊粉酶活性为298.8 U· mL-1,此时的最佳培养基配方为:YPG培养基为酵母粉1％ (w/v),蛋白胨2％ (w/v),甘油0.5％ (v/v);YPM培养基为酵母粉1％ (w/v),蛋白胨2％ (w/v),甲醇1％(v/v);培养基pH为自然初始pH.然后选取酿酒酵母S.c和克鲁维酵母Klu,比较是否在添加重组菌株R32粗酶液条件下,两株酵母菌分别进行单独发酵和混合发酵时的产乙醇能力,以获得最佳的发酵组合.结果表明,酿酒酵母S.c和克鲁维酵母Klu在未添加重组菌株R32粗酶液时,混合一步发酵获得的乙醇含量较高,发酵84 h时乙醇含量为11.37％.添加重组菌株R32粗酶液进行两步发酵时,2株酵母菌混合发酵72 h时,乙醇含量为11.43％.2种发酵组合的最高乙醇含量以及各个发酵参数基本相同,虽然一步法发酵时间延长,但节省成本,操作简单,更适宜工业生产应用.最后对其进行正交试验优化,培养条件为菊粉浓度225 g· L-1,脲素浓度40 g·L-1,接种量15％,pH为5时,酿酒酵母菌S.c和克鲁维酵母Klu混合一步发酵法的最高乙醇体积比达11.82％.     

一个外切菊粉酶基因的克隆表达及酶学性质

从马克斯克鲁维酵母（Kluyveromycesmarxianus）DSM5418中克隆出外切菊粉酶（INU）的成熟肽编码区域,在毕赤酵母（Pichiapastoris）GS115中实现了高效分泌表达,体积酶活力达到15．27U／mL,进一步对重组酶进行了纯化与表征。经过（NH4）2SO4沉淀、透析和分子筛过滤后,得到了纯度大于95％的纯化重组酶,SDS-PAGE分析发现INU的表观相对分子质量为9．0×10^4,大于理论预测值6．0×10^4。纯化酶液的表征结果表明,INU的最适温度和最适pH分别为55℃和5．0,在此条件下INU对菊粉的K。值和比酶活分别为1．90mmol／L和433．86U／mg,对蔗糖的K。值和比酶活分别为27．81mmol/L和1249．49U／mg,I/S值为0．34;HPLC分析表明,INU酶解菊粉的产物由果糖和葡萄糖组成;金属离子Mn2＋、Fe3｜、K｜和Co2＋对酶有促进作用,而Zn2＋、Cu2＋、Ni2＋、SDS和EDTA对酶活力有不同程度的抑制作用。     

菊粉酶高活力菌株的筛选及其产酶研究

利用透明圈法从３０个菊粉酶活力菌株中筛选出两个高活力菌株Ｈ_８和Ｍ_８９,两菌株均鉴定为黑曲霉。Ｈ_８和Ｍ_８９产酶的最佳碳源是菊粉,Ｈ_８最适氮源是（ＮＨ_４）_２ＳＯ_４,Ｍ_８９以草酸胺最好,（ＮＨ_４）_２ＳＯ_４仅次于草酸胺。两菌株产酶的环境条件有一定差异,Ｈ     

菊粉酶基因的异源表达、分离纯化及酶学性质

为进一步提高菊粉酶在生物技术领域的应用,研究了来源于马克斯克鲁维酵母Kluyveromyces marxianus YX01的菊粉酶性质。通过在毕赤酵母GS115宿主细胞中异源表达该菊粉酶基因(inu),获得了一种外切型菊粉酶,经聚丙烯酰胺凝胶电泳(SDS-PAGE)验证其分子量为86.0 k Da。进一步在该菊粉酶上增加6个His标签,采用聚乙二醇(PEG)20 000透析浓缩和Ni-NTA Agarose静态亲和吸附作用的方法,完成菊粉酶的分离纯化,纯化倍数和酶回收率分别为3.6和33.1%。比较发现粗酶液与纯酶的酶学性质相似,且菊粉酶的最适反应温度为60℃,最适p H值为4.62,并测得该酶的Km和Vmax值,以菊粉为底物时,Km和Vmax值分别为80.53 g/L和4.49 g/(L·min);以蔗糖底物时,Km和Vmax值分别为183.10 g/L和20.20 g/(L·min)。金属离子Mn2+、Ca2+、Cu2+、Zn2+和Fe2+对酶活力具有不同程度的抑制作用,其中Cu2+、Zn2+和Fe2+的抑制作用最为显著。这些研究为进一步提高菊粉酶在工业化的应用奠定了基础。     

通气量和菊粉浓度对克鲁维酵母乙醇发酵的影响

马克斯克鲁维酵母能够利用集成生物加工技术发酵菊芋生产乙醇,具有非粮燃料乙醇生产潜力.文中研究了该技术中的两个关键因素(通气量和底物浓度)对于K.marxinaus YX01乙醇发酵过程和菊粉酶活性的影响.研究结果表明,底物浓度对乙醇得率影响不大,底物浓度为250 g/L时,发酵终点乙醇浓度为84.74 g/L,但乙醇得率由低浓度50 g/L的86.4％(理论值),降为84.7％.通气能够加速K.marxinaus YX01的乙醇发酵过程,但降低了乙醇得率,当底物浓度为250 g/L时,乙醇得率由不通气的84.7％降为1.0 vvm时的73.3％.随底物浓度的升高及通气量的降低,K.marxinaus YX01分泌的菊粉酶活力表现出降低的趋势.在不通气及底物浓度为250 g/L时,菊粉酶的活性为6.59 U/mL,而底物浓度50 g/L,通气量1.0 vvm时的酶活力为21.54 U/mL.乙醇发酵过程中的副产物甘油随通气量的降低及底物浓度的升高而增大,而乙酸的浓度随通气量的增大及底物浓度的升高而升高.     

酿酒酵母GAL基因的表达调控

酵母菌一直是人们进行遗传分析的理想材料,对许多酵母基因的表达调节途径人们也已有了较深人的了解。酵母中研究最多的基因表达调节途径是GAL基因表达调节过程,它不仅为比较研究原核和真核生物的协同表达调节机制提供了可能性,而且由于酵母GAL基因表达可以被生长条件所控制,所以GAL基因区域对外源基因在酵母中的克隆表达也具有潜在的应用价值I‘,‘］。现在就酵母GAL基因的表达调节做一概述。IGAL基因组成及转录调节模型半乳糖是通过转化为6一磷酸葡萄糖后进人糖解途径而被酵母利用的。其中至少有五种基因产物参与从半乳糖的运…     

酿酒酵母乙醇脱氢酶2(ADH2)基因的克隆表达及活性验证

为了从酿酒酵母Saccharomyces cerevisiae中克隆出乙醇脱氢酶2(Alcoholdehy drogenase2,ADH2)基因并使之在大肠杆菌中高效表达。以酿酒酵母细胞中提取的总RNA为模板,通过反转录获得酿酒酵母乙醇脱氢酶2基因,连接到表达载体pTAT上,得到重组表达质粒pTAT-ADH2,将此重组质粒转化到大肠杆菌BL21中,重组工程菌株经IPTG诱导表达得到ADH2蛋白。将该蛋白纯化后,在体外进行活性检测和小鼠体内进行毒理试验,检测ADH2的酶活性。测序结果表明克隆的基因与GenBank中所报道的adh2基因序列有90%的同源性,经SDS-PAGE电泳分析,目的蛋白得到了有效表达,蛋白条带扫描分析表明,表达量占总蛋白的50%左右,纯化得到的蛋白在小鼠体内进行毒理试验,显示出一定的活性。酿酒酵母adh2基因的克隆正确,不仅在大肠杆菌中进行了高效表达而且表现出了较好的酶活性。     

Ethanol fermentation with Kluyveromyces marxianus from Jerusalem artichoke grown in salina and irrigated with a mixture of seawater and freshwater

Aims: To study fuel ethanol fermentation with Kluyveromyces marxianus ATCC8554 from Jerusalem artichoke (Helianthus tuberosus) grown in salina and irrigated with a mixture of seawater and freshwater. Methods and Results: The growth and ethanol fermentation of K. marxianus ATCC8554 were studied using inulin as substrate. The activity of inulinase, which attributes to the hydrolysis of inulin, the main carbohydrate in Jerusalem artichoke, was monitored. The optimum temperatures were 38°C for growth and inulinase production, and 35°C for ethanol fermentation. Aeration was not necessary for ethanol fermentation with the K. marxianus from inulin. Then, the fresh Jerusalem artichoke tubers grown in salina and irrigated with 25% and 50% seawater were further examined for ethanol fermentation with the K. marxianus, and a higher ethanol yield was achieved for the Jerusalem artichoke tuber irrigated with 25% seawater. Furthermore, the dry meal of the Jerusalem artichoke tubers irrigated with 25% seawater was examined for ethanol fermentation at three solid concentrations of 200, 225 and 250 g l^?1, and the highest ethanol yield of 0·467, or 91·5% of the theoretical value of 0·511, was achieved for the slurry with a solid concentration of 200 g l^?1. Conclusions: Halophilic Jerusalem artichoke can be used for fuel ethanol production. Significance and Impact of the Study: Halophilic Jerusalem artichoke, not competing with grain crops for arable land, is a sustainable feedstock for fuel ethanol production.     

混合糖发酵重组酿酒酵母的菌株构建和菊芋秸秆同步糖化发酵研究

【目的】构建可用于纤维素乙醇高效生产的混合糖发酵重组酿酒酵母菌株,并利用菊芋秸秆为原料进行乙醇发酵。【方法】筛选在木糖中生长较好的酿酒酵母YB-2625作为宿主菌,构建木糖共代谢菌株YB-2625 CCX。进一步通过r DNA位点多拷贝整合的方式,以YB-2625 CCX为出发菌株构建木糖脱氢酶过表达菌株,并筛选得到优势菌株YB-73。采用同步糖化发酵策略研究YB-73的菊芋秸秆发酵性能。【结果】YB-73菌株以90 g/L葡萄糖和30 g/L木糖为碳源进行混合糖发酵,乙醇产量比出发菌株YB-2625 CCX提高了13.9%,副产物木糖醇产率由0.89 g/g降低至0.31 g/g,下降了64.6%。利用重组菌YB-73对菊芋秸秆进行同步糖化发酵,48 h最高乙醇浓度达到6.10%(体积比)。【结论】通过转入木糖代谢途径以及r DNA位点多拷贝整合过表达木糖脱氢酶基因可有效提高菌株木糖发酵性能,并用于菊芋秸秆的纤维素乙醇生产。这是首次报道利用重组酿酒酵母进行菊芋秸秆原料的纤维素乙醇发酵。     

鹰嘴豆孢克鲁维酵母利用菊芋原料同步糖化与发酵生产乙醇

菊芋含有大量的菊粉多糖,且种植简单、产量高,是极具开发价值的替代玉米等粮食作物生产燃料乙醇的原料。文中研究了鹰嘴豆孢克鲁维酵母Y179利用菊芋原料同步糖化与发酵生产乙醇。鹰嘴豆孢克鲁维酵母Y179具有高效分泌菊粉酶的能力,摇瓶试验显示Y179酵母能够利用完全由菊芋原料配制而成的培养基良好生长并发酵产生乙醇。通气及温度对乙醇产量影响明显,相对厌氧环境对Y179酵母发酵产乙醇具有促进作用,30℃发酵温度相对37℃和42℃更有利于乙醇产量提高。种子液培养时间及接种量对乙醇产量影响较小。在5 L发酵罐中以10%(V/V)量接入预培养36 h的Y179种子液,发酵液完全由菊芋干粉配制而成,总糖含量22%(W/V),30℃不通气,300 r/min搅拌,发酵144 h时,乙醇浓度达到12.3%(V/V),糖醇转化效率86.9%,糖利用率大于93.6%。初步研究结果显示鹰嘴豆孢克鲁维酵母Y179在利用菊芋原料生产乙醇方面具有良好应用前景。     

Use of Zymomonas mobilis and Saccharomyces cerevisiae mixed with Kluyveromyces fragilis for improved ethanol production from Jerusalem artichoke tubers

Jerusalem artichoke mashed tubers were fermented using single yeasts and a bacterium as well as mixed culture of microorganisms. Kluyveromyces fragilis, a yeast with an active inulinase, was used together with either a commercial distillery yeast, Saccharomyces cerevisiae, or the bacterium Zymomonas mobilis. After batch fermentation the best ethanol concentration of 0.48 g g(-1) for the mixed population and 0.46 g g(-1) for the single population can be obtained. The theoretical yield of the mixed cultures was 2-12% higher than for the single microorganism.     

Simultaneous saccharification of inulin and ethanol fermentation by recombinantSaccharomyces cerevisiae secreting inulinase

VariousSaccharomyces cerevisiae strains were transformed with a 2 μ-based multicopy expression plasmid, pYIGP, carryingKluyveromyces marxianus inulinase gene under the control ofGAPDH promoter. Among them two strains, SEY2102 and 2805, showed high levels of cell growth and inulinase expression, and were selected to study their fermentation properties on inulin. Jerusalem artichoke inulin was more effective for cell growth (10∼11 g-dry wt./L at 48 hr) and inulinase expression (1.0 units/mL with SEY2102/pYIGP and 2.5 units/mL with 2805/pYIGP) than other inulin sources such as dahlia and chicory. It was also found that maximal ethanol production of 9 g/L was obtained from Jerusalem artichoke inulin at the early stationary phase (around 30 hr), indicating that recombinantS. cerevisiae cells secreting exoinulinase could be used for the simultaneous saccharification of inulin and ethanol fermentation.     

一步法发酵菊芋生产乙醇

利用马克斯克鲁维酵母(Kluyveromyces marxianus)YX01具有菊粉酶生产能力且乙醇发酵性能良好的特点,直接发酵菊粉生成乙醇.在摇瓶中考察了该菌株最适发酵温度,进而在2.5L发酵罐中考察了通气量和底物浓度的影响.实验结果表明:该菌株最适发酵温度为35℃;在通气量为50 mL/min和100 mL/min时菌体生长加快,发酵时间缩短,但在不通气条件下糖醇转化率明显提高;在菊粉浓度235 g/L时,发酵终点乙醇浓度达到92.2 g/L,乙醇对糖的得率为0.436,为理论值的85.5%.在此基础上,使用近海滩涂种植海水灌溉收获的菊芋为底物,以批式补料方式直接发酵菊芋干粉浓度为280 g/L的底物,发酵终点乙醇浓度为84.0 g/L,乙醇对糖的得率为0.405,为理论值的80.0%.这些研究工作,为以菊芋为原料的燃料乙醇技术开发奠定了基础.     

Consolidated bioprocessing strategy for ethanol production from Jerusalem artichoke tubers by Kluyveromyces marxianus under high gravity conditions

Aims: Developing an innovative process for ethanol fermentation from Jerusalem artichoke tubers under very high gravity (VHG) conditions. Methods and Results: A consolidated bioprocessing (CBP) strategy that integrated inulinase production, saccharification of inulin contained in Jerusalem artichoke tubers and ethanol production from sugars released from inulin by the enzyme was developed with the inulinase‐producing yeast Kluyveromyces marxianus Y179 and fed‐batch operation. The impact of inoculum age, aeration, the supplementation of pectinase and nutrients on the ethanol fermentation performance of the CBP system was studied. Although inulinase activities increased with the extension of the seed incubation time, its contribution to ethanol production was negligible because vigorously growing yeast cells harvested earlier carried out ethanol fermentation more efficiently. Thus, the overnight incubation that has been practised in ethanol production from starch‐based feedstocks is recommended. Aeration facilitated the fermentation process, but compromised ethanol yield because of the negative Crabtree effect of the species, and increases the risk of contamination under industrial conditions. Therefore, nonaeration conditions are preferred for the CBP system. Pectinase supplementation reduced viscosity of the fermentation broth and improved ethanol production performance, particularly under high gravity conditions, but the enzyme cost should be carefully balanced. Medium optimization was performed, and ethanol concentration as high as 94·2 g l^?1 was achieved when 0·15 g l^?1 K₂HPO₄ was supplemented, which presents a significant progress in ethanol production from Jerusalem artichoke tubers. Conclusions: A CBP system using K. marxianus is suitable for efficient ethanol production from Jerusalem artichoke tubers under VHG conditions. Significance and Impact of the Study: Jerusalem artichoke tubers are an alternative to grain‐based feedstocks for ethanol production. The high ethanol concentration achieved using K. marxianus with the CBP system not only saves energy consumption for ethanol distillation, but also significantly reduces the amount of waste distillage discharged from the distillation system.     

Optimization of simultaneously enzymatic fructo- and inulo-oligosaccharide production using co-substrates of sucrose and inulin from Jerusalem artichoke

Prebiotic substances are extracted from various plant materials or enzymatic hydrolysis of different substrates. The production of fructo-oligosaccharide (FOS) and inulo-oligosaccharide (IOS) was performed by applying two substrates, sucrose and inulin; oligosaccharide yields were maximized using central composite design to evaluate the parameters influencing oligosaccharide production. Inulin from Jerusalem artichoke (5–15% w/v), sucrose (50–70% w/v), and inulinase from Aspergillus niger (2–7 U/g) were used as variable parameters for optimization. Based on our results, the application of sucrose and inulin as co-substrates for oligosaccharide production through inulinase hydrolysis and synthesis is viable in comparative to a method using a single substrate. Maximum yields (674.82?mg/g substrate) were obtained with 5.95% of inulin, 59.87% of sucrose, and 5.68 U/g of inulinase, with an incubation period of 9?hr. The use of sucrose and inulin as co-substrates in the reaction simultaneously produced FOS and IOS from sucrose and inulin. Total conversion yield was approximately 67%. Our results support the high value-added production of oligosaccharides using Jerusalem artichoke, which is generally used as a substrate in prebiotics and/or bioethanol production.     

Cyclic AMP phosphodiesterase from dormant tubers of Jerusalem artichoke

An enzyme, which hydrolyzes 3′,5′-cyclic AMP to 3′-AMP and 5′-AMP, has been isolated from dormant tubers of Jerusalem artichoke and purified 850 × with a recovery of 15% of total activity. The partially purified enzyme differs greatly from both animal and bacterial phosphodiesterases in terms of pH optimum, substrate specificity, cation dependence and sensitivity to methylxanthines. The plant hormones are without effect, whereas ATP, 5′-AMP, 3′-AMP, inorganic phosphate and pyrophophosphate are inhibitors. The enzyme seems to be greatly inhibited in vivo by inorganic phosphate during dormancy.