Color removal ability of <Emphasis Type="Italic">Phanerochaete chrysosporium</Emphasis> in relation to lignin peroxidase and manganese peroxidase produced in molasses wastewater

Decolorization of molasses wastewater (MWW) from an ethanolic fermentation plant by Phanerochaete chrysosporium was studied. By diluting MWW properly (10%v/v) and incubating it with an appropriate concentration of the spores (2.5 × 10⁶/ml), extensive decolorization occurred (75%) on day 5 of the incubation. The colour removal ability was found to be correlated to the activity of ligninolytic enzyme system: lignin peroxidase (LiP) activity was 185 U/l while manganese peroxidase (MnP) activity equaled 25 U/l. Effects of some selected operating variables were studied: manganese(II), veratryl alcohol (VA), glucose as a carbon source and urea and ammonium nitrate, each as a source of nitrogen. Results showed that the colour reduction and LiP activity were highest (76% and 186 U/l, respectively) either when no Mn(II) was added or added at the lowest level tested (0.16 mg/l to provide 0.3 mg/l). Activity of MnP was highest (25 U/l) when Mn(II) added to the diluted MWW at the highest level (100 ppm) while activity of LiP was lowest (7.1 U/l) at this level of added Mn(II). The colour reduction in the presence of the added VA was shown to be little less than in its absence (70 vs. 75%). When urea as an organic source of nitrogen for the fungus, was added to the MWW, the decolorizing activity of P. chrysosporium decreased significantly (15 vs. 75%) and no activities were detected for LiP and MnP. Use of ammonium nitrate as an inorganic source of nitrogen did not show such a decelerating effects, although no improvements in the metabolic behavior of the fungus (i.e., LiP and MnP activities) deaccelerating was observed. Effects of addition of glucose was also discussed.     

Improvement of sludge digestate biodegradability by thermophilic bioaugmentation

The sludge digestate stabilized by mesophilic anaerobic digestion was further degraded through thermophilic anaerobic digestion using 0–10 % (v/v) of thermophilic, proteolytic Coprothermobacter proteolyticus, and/or methanogenic granular sludge. The results demonstrated that the temperature shift to thermophilic condition promoted abiotic solubilization of proteins and reactivated the fermentative bacteria and methanogens indigenous in the sludge digestate, resulting in a final methane yield of 6.25 mmol-CH₄/g-volatile suspended solid (VSS) digestate. The addition of C. proteolyticus accelerated the hydrolysis and fermentation of proteins and polysaccharides in the digestate during the early stage of thermophilic anaerobic digestion and stimulated methane production by syntrophic cooperation with methanogenic granular sludge. In the treatment with granular sludge and inoculated with 10 % (v/v) of C. proteolyticus, a final methane yield of 7 mmol-CH₄/g-VSS digestate was obtained, and 48.4 % proteins and 27.0 % polysaccharides were degraded. The dissolved proteins were contributed by abiotic factor, C. proteolyticus, and indigenous digestate bacteria, respectively, by around 16, 28, and 56 %.     

Improved β-carotene production by oxidative stress in Blakeslea trispora induced by liquid paraffin

When 3 % (v/v) liquid paraffin was added to the medium, β-carotene production increased from 397 to 715 mg l^?1 in mated cultures of Blakeslea trispora. Liquid paraffin also enhanced the oxygen concentration and induce high oxidative stress, as observed by the increase in activities of superoxide dismutase (SOD), catalase (CAT) and peroxidase (POD). After 84 h of cultivation in the presence of liquid paraffin, the activities of SOD, CAT and POD in B. trispora increased 77, 52.5 and 76.6 %, respectively.     

Selection and characterization of a newly isolated thermotolerant Pichia kudriavzevii strain for ethanol production at high temperature from cassava starch hydrolysate

Pichia kudriavzevii DMKU 3-ET15 was isolated from traditional fermented pork sausage by an enrichment technique in a yeast extract peptone dextrose (YPD) broth, supplemented with 4 % (v/v) ethanol at 40 °C and selected based on its ethanol fermentation ability at 40 °C in YPD broth composed of 16 % glucose, and in a cassava starch hydrolysate medium composed of cassava starch hydrolysate adjusted to 16 % glucose. The strain produced ethanol from cassava starch hydrolysate at a high temperature up to 45 °C, but the optimal temperature for ethanol production was at 40 °C. Ethanol production by this strain using shaking flask cultivation was the highest in a medium containing cassava starch hydrolysate adjusted to 18 % glucose, 0.05 % (NH₄)₂SO₄, 0.09 % yeast extract, 0.05 % KH₂PO₄, and 0.05 % MgSO₄·7H₂O, with a pH of 5.0 at 40 °C. The highest ethanol concentration reached 7.86 % (w/v) after 24 h, with productivity of 3.28 g/l/h and yield of 85.4 % of the theoretical yield. At 42 °C, ethanol production by this strain became slightly lower, while at 45 °C only 3.82 % (w/v) of ethanol, 1.27 g/l/h productivity and 41.5 % of the theoretical yield were attained. In a study on ethanol production in a 2.5-l jar fermenter with an agitation speed of 300 rpm and an aeration rate of 0.1 vvm throughout the fermentation, P. kudriavzevii DMKU 3-ET15 yielded a final ethanol concentration of 7.35 % (w/v) after 33 h, a productivity of 2.23 g/l/h and a yield of 79.9 % of the theoretical yield.     

Preparation of Curcumin Loaded Egg Albumin Nanoparticles Using Acetone and Optimization of Desolvation Process

In this study, acetone was used as a desolvating agent to prepare the curcumin-loaded egg albumin nanoparticles. Response surface methodology was employed to analyze the influence of process parameters namely concentration (5–15 %w/v) and pH (5–7) of egg albumin solution on solubility, curcumin loading and entrapment efficiency, nanoparticles yield and particle size. Optimum processing conditions obtained from response surface analysis were found to be the egg albumin solution concentration of 8.85 %w/v and pH of 5. At this optimum condition, the solubility of 33.57 %, curcumin loading of 4.125 %, curcumin entrapment efficiency of 55.23 %, yield of 72.85 % and particles size of 232.6 nm were obtained and these values were related to the values which are predicted using polynomial model equations. Thus, the model equations generated for each response was validated and it can be used to predict the response values at any concentration and pH.     

Rhamnolipid biosurfactant production by Pseudomonas nitroreducens immobilized on Ca2+ alginate beads and under resting cell condition

Pseudomonas nitroreducens MILB-8054A isolated from petroleum-contaminated soil, immobilized on calcium alginate beads, and under resting cell condition, produced biosurfactants. Immobilized cells gave a best yield of 5.6 g rhamnolipid l^?1 using sucrose as carbon source. Time course study using resting cells showed that 2 % v/v of palm oil (preculture carbon source) and 10 % diesel (carbon source) gave the best rhamnolipid yield of 5.1 g l^?1 at pH 8 and temperature of 30 °C. Carbon utilization by resting cells was compared with that of growing cells. The best biosurfactant recovery procedure was acetone extraction.     

A novel moderately halophilic bacterium for decolorizing azo dye under high salt condition

Halomonas sp strain GTW was newly isolated from coastal sediments contaminated by chemical wastewater and was identified to be a member of the genus Halomonas by 16S rDNA sequence analysis and physical and biochemical tests. The optimal decolorization conditions were as follows: temperature 30°C, pH 6.5.0–8.5, NaCl 10–20% (w/v) and the optimal carbon source was yeast exact. The results of experiments demonstrated that the bacteria could decolorize different azo dyes under high salt concentration conditions, and the decolorization rate of five tested azo dyes could be above 90% in 24 h. The exploitation of the salt-tolerant bacteria in the bio-treatment system would be a great improvement of conventional biological treatment systems and the bio-treatment concept.     

Changes in some anti-oxidative enzymes and physiological indices among sesame genotypes (Sesamum indicum L.) in response to soil water deficits under field conditions

A field experiment was conducted to evaluate the response of ten sesame genotypes to different levels of soil water in terms of contents of proline, soluble carbohydrates, carotenoids, and activities of catalase (CAT), peroxidase (POX) and ascorbate peroxidase (APX). Plants were grown under three irrigation levels, including irrigation at 55 % (control), 75, and 85 % depletion of soil available water. Field test plots were a two-way factorial arranged in a randomized complete block design with three replications. Under control level of irrigation, the most and the least grain yields were achieved for genotypes Ultan (2,519 kg/ha) and Isfahan1 (1,311 kg/ha), respectively. Grain yield was decreased in some genotypes under 75 % and in all genotypes under 85 % depletion of available water. Based on percentage reduction in grain yield under both 75 and 85 % depletion of soil available water, Isfahan4, Borazjan, Isfahan1, Ahvaz, Ardestan, and Shiraz were recognized as relatively tolerant and Ultan, Shahreza, Kal, and Markazi were identified as relatively sensitive to water stress. The activities of antioxidant enzymes and the contents of carotenoids, proline, and soluble carbohydrates in leaves were increased in most genotypes under stress conditions, and the magnitudes of the increases were greater in the tolerant than in the sensitive genotypes. The results of this experiment showed that the stress-induced increase of antioxidant enzymes and the contents of the compatible solutes in leaves were related to the tolerance of sesame genotypes.     

Asymmetric reduction of 4-hydroxy-2-butanone to (R)-1,3-butanediol with absolute stereochemical selectivity by a newly isolated strain of Pichia jadinii

In this study, a novel strain of Pichia jadinii, HBY61, capable of the biocatalysis of 4-hydroxy-2-butanone (4H2B) to (R)-1,3-BD was isolated. HBY61 produced (R)-1,3-BD with high activity and absolute stereochemical selectivity (100 % e.e). Glucose and beef extract were found to be the key factors governing the fermentation, and their optimal concentrations were determined to be 84.2 and 43.7 g/L, respectively. The optimal bioconversion conditions of 4H2B catalyzed by HBY61 were pH 7.4, 30 °C, and 250 rpm with 6 % (v/v) glucose as the co-substrate. Accordingly, when 45 g/L of 4H2B was divided into three equal parts and added successively into the system at set time intervals, the maximum (R)-1,3-BD concentration reached 38.3 g/L with high yield (85.1 %) and strict 100 % enantioselectivity. Compared with previously reported yields for the biocatalytic production of (R)-1,3-BD, the use of strain HBY61 provided a high yield with excellent stereoselectivity.     

Selective oxidation of UDP-glucose to UDP-glucuronic acid using permeabilized <Emphasis Type="Italic">Schizosaccharomyces pombe</Emphasis> expressing human UDP-glucose 6-dehydrogenase

Objectives

To use permeabilized cells of the fission yeast, Schizosaccharomyces pombe, that expresses human UDP-glucose 6-dehydrogenase (UGDH, EC 1.1.1.22), for the production of UDP-glucuronic acid from UDP-glucose.

Results

In cell extracts no activity was detected. Therefore, cells were permeabilized with 0.3 % (v/v) Triton X-100. After washing away all low molecular weight metabolites, the permeabilized cells were directly used as whole cell biocatalyst. Substrates were 5 mM UDP-glucose and 10 mM NAD⁺. Divalent cations were not added to the reaction medium as they promoted UDP-glucose hydrolysis. With this reaction system 5 mM UDP-glucose were converted into 5 mM UDP-glucuronic acid within 3 h.

Conclusions

Recombinant permeabilized cells of S. pombe can be used to synthesize UDP-glucuronic acid with 100 % yield and selectivity.

     

Tea stalks – a novel agro-residue for the production of tannase under solid state fermentation by Aspergillus niger JMU-TS528

A novel agro-residue, tea stalks, was tested for the production of tannase under solid-state fermentation (SSF) using Aspergillus niger JMU-TS528. Maximum yield of tannase was obtained when SSF was carried out at 28 °C, pH 6.0, liquid-to-solid ratio (v/w) 1.8, inoculum size 2 ml (1?×?10⁸ spores/ml), 5 % (w/v) ammonium chloride as nitrogen source and 5 % (w/v) lactose as additional carbon source. Under optimum conditions, tannase production reached 62 U/g dry substrate after 96 h of fermentation. Results from the study are promising for the economic utilization and value addition of tea stalks.     

Selective and efficient extraction of recombinant proteins from the periplasm of Escherichia coli using low concentrations of chemicals

Experiments were conducted to determine chemicals at low concentrations, which can be utilized for selective release of periplasmic proteins. It was revealed that 80–100 % of the activity of alpha-amylase, beta-lactamase, and Fab D1.3 was retained in the presence of 0.05 and 0.1 % Triton X-100, 0.1 % Tween 20, 0.1 % DOC, 0.01 % BAC, 0.01 % CTAB, 10 mM EDTA, 1 mM and 10 mM DEA, 10 mM NTA, 0.1 and 1 % SHMP, 200 mM urea, 100–500 mM GndCl, and 1 % solvents (hexane, xylene, toluene, benzene, pyridine and isoamyl alcohol). Performance of these chemicals, recognized as generally safe, for selective release of proteins from the periplasm of Escherichia coli was investigated. DOC was a general and very efficient agent, and at concentrations as low as 0.05, 0.1, and 0.025 %, released beta-lactamase, alpha-amylase, and Fab D1.3 selectively with yield factors of 2.7, 2.3, and 3.6 times greater than osmotic shock procedure, respectively. EDTA (1 and 10 mM) discharged Fab D1.3 with efficiency more than osmotic shock (target protein yield of 110 and 138 %, correspondingly). Isoamyl alcohol (10 % v/v) was effective for periplasmic release of alpha-amylase and particularly Fab D1.3, with target protein yields of 75 and 168 %, respectively.     

A simple colorimetric method for determination of hydrogen peroxide in plant tissues

A simple colorimetric method for determination of hydrogen peroxide in plant materials is described. The method is based on hydrogen peroxide producing a stable red product in reaction with 4-aminoantipyrine and phenol in the presence of peroxidase. Plant tissues was ground with trichloroacetic acid (5% w/v) and extracts were adjusted to pH 8.4 with ammonia solution. Activated charcoal was added to the homogenate to remove pigments, antioxidants and other interfering substances. The colorimetric reagent (pH 5.6) consisted of 4-aminoantipyrine, phenol, and peroxidase. With this method, we have determined the hydrogen peroxide concentration in leaves of eight species which ranged from 0.2 to 0.8 μmol g⁻¹ FW. Changes in hydrogen peroxide concentration of Stylosanthes guianensis in response to heat stress are also analyzed using this method.     

Effects of intercropping sugarcane and soybean on growth, rhizosphere soil microbes, nitrogen and phosphorus availability

The effects of sugarcane plantation intercropped with soybean on plant growth, yield, enzyme activity, nitrogen and phosphorus contents, the microbe quantity of rhizosphere soil were investigated. Results showed that dry weight of biomass and yield under sugarcane/soybean intercropping were increased by 35.44 and 30.57 % for sugarcane, and decreased by 16.12 and 9.53 % (100-grain weight) for soybean, respectively. The nitrogenase activity of intercropping soybean nodule was significantly increased by 57.4 % as compared with that in monoculture models. The urease activities of intercrops sugarcane and soybean were promoted by 89 and 81 % as compared to that of the monoculture models, respectively. The effective nitrogen and phosphorus contents of rhizospheric soil of intercrops sugarcane and soybean were increased by 66 and 311.7 %, respectively, as compared to those in the monoculture system. Microbe number of rhizosphere soil in the intercropping pattern increased significantly as compared to those in the monoculture models. The quantities of bacteria, fungi, and actinomyces increased by 42.62, 14.5 and 78.5 % in the intercropping sugarcane, while the intercropping soybean increased by 188, 183 and 73 %, respectively. Therefore, growing sugarcanes in combination with soybean can be considered a good agriculture management practice, helping to promote plant growth, yield and increase soil nutrients.     

Improvement of trans-sialylation versus hydrolysis activity of an engineered sialidase from Trypanosoma rangeli by use of co-solvents

Biocatalytic trans-sialylation is relevant for the design of biomimetic oligosaccharides such as human milk oligosaccharides. t-Butanol and ionic liquids, EAN (ethylammonium nitrate), [MMIm][MeSO₄] (1,3-dimethylimidazolium methyl sulfate), and [C₂OHMIm][PF₆] (1-(2-hydroxyethyl)-3-methylimidazolium hexafluorophosphate), were examined as co-solvents for the improvement of the synthesis versus hydrolysis ratio in the trans-sialylation of lactose, catalysed by an engineered sialidase from Trypanosoma rangeli. The use of 25 % (v/v) t-butanol as co-solvent significantly increased 3′-sialyllactose production by 40 % from 1.04 ± 0.09 to 1.47 ± 0.01 mM. The synthesis versus hydrolysis ratio increased correspondingly by 1.2-times. 1–2.5 % (v/v) EAN or [C₂OHMIm][PF₆] improved the synthesis versus hydrolysis ratio up to 2.5-times but simultaneously decreased the 3′-sialyllactose yield, probably due to enzyme inactivation caused by the ionic liquid. [MMIm][MeSO₄] had a detrimental effect on the trans-sialylation yield and on the ratio between synthesis and hydrolysis.     

Production of laccase and manganese peroxidase by Pleurotus pulmonarius in solid-state cultures and application in dye decolorization

The production of ligninolytic enzymes (laccase and Mn-dependent peroxidase) by the white-rot fungus Pleurotus pulmonarius (FR.) Quélet was studied in solid-state cultures using agricultural and food wastes as substrate. The highest activities of laccase were found in wheat bran (2,860?±?250 U/L), pineapple peel (2,450?±?230 U/L), and orange bagasse (2,100?±?270 U/L) cultures, all of them at an initial moisture level of 85 %. The highest activities of Mn peroxidase were obtained in pineapple peel cultures (2,200?±?205 U/L) at an initial moisture level of 75 %. In general, the condition of high initial moisture level (80–90 %) was the best condition for laccase activity, while the best condition for Mn peroxidase activity was cultivation at low initial moisture (50–70 %). Cultures containing high Mn peroxidase activities were more efficient in the decolorization of the industrial dyes remazol brilliant blue R (RBBR), Congo red, methylene blue, and ethyl violet than those containing high laccase activity. Also, crude enzymatic extracts with high Mn peroxidase activity were more efficient in the in vitro decolorization of methylene blue, ethyl violet, and Congo red. The dye RBBR was efficiently decolorized by both crude extracts, rich in Mn peroxidase activity or rich in laccase activity.     

Cell growth stimulating effect of <Emphasis Type="Italic">Ganoderma lucidum</Emphasis> spores and their potential application for Chinese hamster ovary K1 cell cultivation

In this work, water-soluble extracts of Ganoderma lucidum spores (Gls), a Chinese medicinal herb that possesses cell growth stimulating function, were found to be an effective growth factor for Chinese hamster ovary (CHO) cell cultivation. The Gls extract was prepared and supplemented to CHO K1 cell culture media with various serum levels. Our results obtained from both the static culture and the spinner-flask suspension culture showed that use of small-amount Gls extract effectively promoted cell growth and suppressed cell apoptosis induced by serum deprivation with normal cell cycle maintained in a low-serum medium. The low-serum medium containing 1 % (v/v) fetal bovine serum (FBS) and 0.01 % (w/v) Gls extract showed a comparable performance on both cell growth and fusion protein productivity with the conventional CHO culture medium containing 10 % (v/v) FBS and a commercial serum-free medium. This is the first study of the potential of Gls extracts for use as an alternative cell growth factor and nutrient for CHO cells. The findings have presented a new approach to economic cultivation of CHO cells for therapeutic protein production.     

Immobilization of tomato (Lycopersicon esculentum) pectinmethylesterase in calcium alginate beads and its application in fruit juice clarification

Clarity of fruit juices is desirable to maintain an aesthetically pleasing quality and international standards. The most commonly used enzymes in juice industries are pectinases. A partially-purified pectinmethylesterase from tomato was entrapped in calcium alginate beads and used for juice clarification. The activity yield was maximum at 1 % (w/v) CaCl₂ and 2.5 % (w/v) alginate. The immobilized enzyme retained ~55 % of its initial activity (5.7 × 10^?2 units) after more than ten successive batch reactions. The K_m, pH and temperature optima were increased after immobilization. The most effective clarification of fruit juice (%T₆₂₀ ~60 %) by the immobilized enzyme was at 4 °C with a holding time of 20 min. The viscosity dropped by 56 % and the filterability increased by 260 %. The juice remains clear after 2 months of storage at 4 °C.     

Lactobacillus plantarum 299v Prevents Caspase-Dependent Apoptosis In Vitro

Selective microbes used as probiotics can enhance epithelial cell protection. We have previously shown that a Lactobacillus plantarum strain 299v (Lp299v) has the ability to induce mucin genes. In the current study, we utilized a cytokine model of inflammation in cell culture to study the modulation of apoptosis by this probiotic. HT-29 cells were pre-incubated with the Lp299v or L. plantarum strain adh- (Lpadh-), a non-adherent derivative of Lp299v. Cells were challenged with a mixture of cytokines (TNF-α, IFN-γ, and IL-1a) to imitate conditions of inflammation. To assess for cell death, we evaluated TUNEL, multi-caspase, and caspase-3 and caspase-7 activity assays. There was a marked decrease in apoptosis as measured by TUNEL⁺ cells in samples pre-treated with Lp299v (18.7 ± 4.1%, p < 0.01) and Lpadh- (16.6 ± 3.2%, p < 0.05) prior to cytokine exposure when compared to cells (43.6 ± 6.2%) exposed to the cytokine mixture. Lp299v pre-incubation with HT-29 cells reduced caspase⁺ cells in the multi-caspase activity assay (3.6 ± 0.6%, p < 0.05) compared to cells exposed to cytokines (68.9 ± 5.1%) whereas Lpadh- did not (46.8 ± 17.5%, p > 0.05). Similarly, caspase-3, caspase-7 activity was also reduced by Lp299v. Selected probiotics may confer an exogenous protective effect at the mucosal–luminal interface for intestinal epithelial cells via alteration of caspase-dependent apoptotic pathways.     

Production of 10-hydroxy-12,15(Z,Z)-octadecadienoic acid from α-linolenic acid by permeabilized cells of recombinant Escherichia coli expressing the oleate hydratase gene of Stenotrophomonas maltophilia

Recombinant Escherichia coli, expressing the oleate hydratase gene of Stenotrophomonas maltophilia, was permeabilized by sequential treatments with 0.125 M NaCl and 2 mM EDTA. The optimal conditions for the production of 10-hydroxy-12,15(Z,Z)-octadecadienoic acid from α-linolenic acid by permeabilized cells were 35 °C and pH 7.0 with 0.1 % (v/v) Tween 40, 50 g permeabilized cells l^?1, and 17.5 g α-linolenic acid l^?1. Under these conditions, permeabilized cells produced 14.3 g 10-hydroxy-12,15(Z,Z)-octadecadienoic acid l^?1 after 18 h, with a conversion yield of 82 % (g/g) and a volumetric productivity of 0.79 g l^?1 h^?1. These values were 17 and 168 % higher than those obtained by nonpermeabilized cells, respectively. The concentration, yield, and productivity of 10-hydroxy-12,15(Z,Z)-octadecadienoic acid obtained by permeabilized cells are the highest reported thus far.