Ferrous iron oxidation and uranium extraction by Thiobacillus ferrooxidans

The microbiological oxidation of ferrous iron in batch and continuous systems has been investigated in relation to uranium extraction from a low-grade ore by Thiobacillus ferrooxidans. The influence of the parameters, agitation, and aeration on oxygen saturation concentration, rate of oxygen mass transfer, and rate of ferrous iron oxidation was demonstrated. The kinetic values, V_max and K were determined using an adapted Monod equation for different dilution rates and initial concentrations of ferrous iron. The power requirements for initial leaching conditions were also calculated. Uranium extraction as high as 68% has been realized during nine days of treatment. Regrinding the leach residue and its subsequent leaching yielded 87% uranium solubilization.     

Bioextraction Dynamics of Potassium from Feldspar by Heterotrophic Microorganisms Isolated from Ceramic and Rhizospheric Soil

Bioleaching of potassium from feldspar was optimized for five fungal and two bacterial isolates for carbon, nitrogen, agitation, pH and incubation time. Fungal isolates SDS_R and SDS₃ and bacterial isolate SDS₁ released 34, 42 and 28 ppm K in sucrose-amended medium, respectively. Isolate SDS₃ took 10 days for the highest K solubilization, whereas SDS_R required 15 days under 150 rpm shaking condition. The pH of medium was found to decrease from 7.0 to 2.05 after the growth of the organisms. High-performance liquid chromatography analysis of the filtrate showed the presence of citric, tartaric and maleic acid, which could be responsible for the solubilization of potassium.     

Bioreactor leaching of uranium from a low grade Indian silicate ore

Bio-leaching studies were carried out in a 2 L bioreactor- BIOSTAT-B^® equipped with a PLC based controller at 20–40% (w/v) pulp density using enriched culture of A.ferrooxidans for Turamdih uranium ore (Jharkhand, India). With the enriched culture of A.ferrooxidans adapted on Fe(II) at pH 2.0, 35 °C and 20% (w/v) pulp density, a 98.3% uranium recovery was recorded in 14 days. The leaching of uranium in the bioreactor improved the dissolution rate by reducing the time from 40 days in shake flask as per our earlier studies to 14 days. While investigating the importance of biogenic Fe(III) in the bio-leaching process a maximum recovery of 84.7% U₃O₈ was observed at pH 2.0 and 20% (w/v) pulp density in 10 h as compared to the uranium leaching of 38.3% in the control experiments. On raising the pulp density to 30%, uranium bio-recovery increased to 87.6% in 10 h at pH 2.0 with <76 μm size material. This showed a distinct advantage because of better mixing of slurry in the bioreactor with auto-controlled conditions that improved the kinetics.     

Isolation and analyses of uranium tolerant <Emphasis Type="Italic">Serratia marcescens</Emphasis> strains and their utilization for aerobic uranium U(VI) bioadsorption

Enrichment-based methods targeted at uranium-tolerant populations among the culturable, aerobic, chemo-heterotrophic bacteria from the subsurface soils of Domiasiat (India’s largest sandstone-type uranium deposits, containing an average ore grade of 0.1 % U₃O₈), indicated a wide occurrence of Serratia marcescens. Five representative S. marcescens isolates were characterized by a polyphasic taxonomic approach. The phylogenetic analyses of 16S rRNA gene sequences showed their relatedness to S. marcescens ATCC 13880 (≥99.4% similarity). Biochemical characteristics and random amplified polymorphic DNA profiles revealed significant differences among the representative isolates and the type strain as well. The minimum inhibitory concentration for uranium U(VI) exhibited by these natural isolates was found to range from 3.5–4.0 mM. On evaluation for their uranyl adsorption properties, it was found that all these isolates were able to remove nearly 90–92% (21–22 mg/L) and 60–70% (285–335 mg/L) of U(VI) on being challenged with 100 μM (23.8 mg/L) and 2 mM (476 mg/L) uranyl nitrate solutions, respectively, at pH 3.5 within 10 min of exposure. his capacity was retained by the isolates even after 24 h of incubation. Viability tests confirmed the tolerance of these isolates to toxic concentrations of soluble uranium U(VI) at pH 3.5. This is among the first studies to report uranium-tolerant aerobic chemoheterotrophs obtained from the pristine uranium ore-bearing site of Domiasiat.     

Bioleaching of uranium from low grade black schists by <Emphasis Type="Italic">Acidithiobacillus ferrooxidans</Emphasis>

Summary The feasibility of bacterial recovery of uranium from the low grade black schists occurring in the Okcheon district, South Korea, was investigated. Following the introduction of Acidithiobacillus ferrooxidans, 80% of the uranium could be extracted from the schists, which contain 0.01% U₃O₈ by weight, within 60 h at a pulp density of 100 g-ore/l. Only 18% of the uranium was extracted without microbial activity. The uranium-leaching efficiency was not greatly affected by the addition of Fe²⁺ in the range of 5–9 g/l, and the leaching efficiency of uranium from the schists by A. ferrooxidanscould be efficiently maintained at high pulp densities (up to 500 g-ore/l).     

Effect of Microorganisms on In Situ Uranium Mining

The extraction of some metal values, e.g., uranium or copper, may be accomplished by using solutions to remove metals from ore bodies without practicing conventional mining. This process is referred to as in situ leaching and has been used industrially to recover uranium. The growth of microbial populations during in situ leaching is believed to be one of the causes of flow path plugging in the ore body, which results in decreased uranium production. Leach solution and solid samples from well casings and submersible pumps were collected from an in situ mining operation experiencing plugging problems. Bacillus sp., Micrococcus sp., pseudomonads, and xanthomonads were isolated from these samples in concentrations of 10⁵ CFU ml⁻¹. A mixed culture of these organisms was inoculated into a uranium core specimen in the laboratory to assess the role of microbes in the plugging problem. A one-third decrease in permeability was effected in 16 days. Hydrogen peroxide (0.2 g liter⁻¹) killed the microorganisms in the core and alleviated the plugging problem. Periodically injecting hydrogen peroxide into the ore body through the production wells may reduce microbial plugging problems.     

Isolation and Characterization of Iron and Sulfur-Oxidizing Bacteria from Maiduk Copper Mine at Shahrbabk Province in Iran

Microbial oxidation of iron and sulfur are important steps in biogeochemical cycles in mining environments. The aim of this study was the enrichment and identification of two important groups of bacteria that are involved in bioleaching of copper ores. Some soil samples were collected from the Maiduk copper mine. Iron-oxidizing bacteria were enriched in 9K medium containing ferrous sulfate, and sulfur oxidizers were enriched in 9K medium containing powdered sulfur instead of ferrous sulfate as energy source. After three subcultures, autotrophic bacteria were isolated on 9K agarose medium with appropriate energy sources. The autotrophic bacteria from the enrichments were identified by amplification of 16S rRNA gene and sequencing. Bioleaching experiments were performed in 100 ml of 9K medium containing 5 g of low-grade copper ore instead of ferrous sulfate. Twelve different iron and sulfur-oxidizing bacteria were isolated from the collected soil samples of Maiduk copper mine. Molecular identification indicated that two prevalent strains in the ore enrichments could be assigned to the Acidithiobacillus ferooxidans strain HGM and the Thiobacillus thioparus strain HGE. These two strains reached their logarithmic phase of growth after 8 days of incubation in their respective media at 30°C. Of these two cultures, strain HGM leached more copper ore (300 ppm) from the Maiduk copper ore than did strain HGE (200 ppm). Application of these two strains to the Maiduk copper ore in situ and to ore heaps should improve the leaching process.     

Microbiological leaching of a low-grade uranium ore byThiobacillus ferrooxidans

Summary The microbiological leaching of low-grade uranium ore has been investigated using a pure strain ofThiobacillus ferrooxidans. It has been shown that only minute quantities of iron are required to achieve a maximum effect on uranium release. The ore sample contained enough iron (3.23%) to produce this effect, consequently, very little influence has been observed on uranium solubilization by addition of either ferrous sulfate or pyrite to the leach suspensions. The highest uranium extraction rate derived in this study (57.1 mg/l/day) was realized with a 40% pulp density suspension containing 9.0 g/l of ferrous ion. The highest yield (100.0%) was obtained with a 5% pulp density suspension (initial mean particle diameter: 0.64 mm) and without addition of iron after ten days of treatment. The applicability of this method to industrial scale is proposed.     

Quality control of portuguese uranium concentrates

The analytical chemistry of uranium concentrates implies, as is well known, an accurate determination of U₃O₈ as well as the various impurities. This paper presents the analytical diagram used routinely in our laboratory for the quality control of concentrates.The schema includes gravimetric, potentiometric and spectroscopic methods. Uranium was separated from metallic impurity elements by solvent extraction Fluoride was separated from the matrix element by a Dowex 50W-X8 ion exchanger on a 0.24M nitric acid medium and determined potentiometrically by a standard addition method.     

Structures, spectroscopic and thermodynamic properties of U2On (n = 0 ∼ 2, 4) molecules: a density functional theory study

The equilibrium structures, spectroscopic and thermodynamic parameters [entropy (S), internal energy (E), heat capacity (C _p)] of U₂, U₂O, U₂O₂ and U₂O₄ uranium oxide molecules were investigated systematically using density functional theory (DFT). Our computations indicated that the ground electronic state of U₂ is the septet state and the equilibrium bond length is 2.194 Å; the ground electronic state of U₂O and U₂O₂ were found to be $ {\tilde{X}}^3\varPhi $ and $ {\tilde{X}}^3{\sum}_{\mathrm{g}} $ with stable C _∞v and D _∞h linear structures, respectively. The bridge-bonded structure with D _2h symmetry and $ {\tilde{X}}^3{\mathrm{B}}_{1\mathrm{g}} $ state is the most stable configuration for the U₂O₄ molecule. Mulliken population analyses show that U atoms always lose electrons to become the donor and O atoms always obtain electrons as the acceptor. Molecular orbital analyses demonstrated that the frontier orbitals of the title molecules were contributed mostly by 5f atomic orbitals of U atoms. Vibrational frequencies analyses indicate that the maximum absorption peaks stem from the stretching mode of U–O bonds in U₂O, U₂O₂ and U₂O₄. In addition, thermodynamic data of U₂O_n (n?=?0?～?4) molecules at elevated temperatures of 293.0 K to 393.0 K was predicted.     

Alterations in surfaces and textures of minerals during the bacterial leaching of a complex sulfide ore

Abstract

The purpose of the work was to characterize changes in surface textures of minerals during the biological leaching of a complex sulfide ore. The ore contained pyrrhotite (Fe_I__xS), pyrite (FeS₂), sphalerite (ZnS), pentlandite [(Ni,Fe,Co)₉S₈], and chalcopyrite (CuFeS₂). Several mixed cultures were initially screened using the ore material as the sole substrate. Shake flask leaching experiments showed no major differences among test cultures, which were all derived by enrichment techniques using environmental samples collected from a mine site. Leached pyrrhotite surfaces were invariably surrounded by a dark rim of elemental S. A reaction zone was also associated with leached sphalerite grains. Chemical analyses of leach solutions indicated that the relative ranking of biological leaching of the sulfide minerals was Zn > Ni > Co > Cu. Microscopic observations were in keeping with this rankin     

Bioleaching of a Spanish uranium ore

Abstract: The bioleaching of a low-grade uranium ore in shaker and columns using natural, pure and mixed cultures has been studied. Initially, a chemical and microscopical characterization of the mineral was carried out. Orbital shaker experiments were performed to quickly obtain the best bacterial leaching conditions. Afterwards, small columns were used to determine other variables related to percolation leaching. Finally, an uranium ore from the F6 mine (Ciudad Rodrigo, Spain) was leached in the presence of bacteria using large columns (24 cm diameter and 275 cm height). The most important results were: (i) the ore contains sufficient pyrite in order for uranium bioleaching to take place under optimum conditions; (ii) shaker experiments showed that temperature, pH and type of inoculum are the most important variables in bioleaching; (iii) two different ores were attacked in the columns: altered and non-altered. In the first case, the extraction rate of uranium was higher. However, in both cases the final efficiency was very similar (95%).     

Chemical constituents and antibacterial activity of the leaf essential oil of <Emphasis Type="Italic">Feronia limonia</Emphasis>

Bioleaching of uranium was carried out with Turamdih ore sample procured from Uranium Corporation of India Limited, Jaduguda. The bacterial strain that was used in the leaching experiments was isolated from the Jaduguda mine water sample. Efficiency of bioleaching was studied by varying parameters like pulp density and initial ferrous concentration as source of energy. It is observed that the efficiency of bioleaching was 49% at 10% pulp density (w/v) and initial pH 2.0. Addition of external has no effect on efficiency of bioleaching showing domination of direct leaching mechanism over indirect.     

Effect of anions on selective solubilization of zinc and copper in bacterial leaching of sulfide ores

Bacterial leaching of sulfide ores using Thiobacillus ferrooxidans, Thiobacillus thiooxidans, or a combination of the two was studied at various concentrations of specific anions. Selective zinc and copper solubilization was obtained by inhibiting iron oxidation without affecting sulfur/sulfide oxidation. Phosphate reduced iron solubilization from a pyrite (FeS(2))-sphalerite (ZnS) mixture without significantly affecting zinc solubilization. Copper leaching from a chalcopyrite (CuFeS(2))-sphalerite mixture was stimulated by phosphate, whereas chloride accelerated zinc extraction. In a complex sulfide ore containing pyrite, chalcopyrite, and sphalerite, both phosphate and chloride reduced iron solubilization and increased copper extraction, whereas only chloride stimulated zinc extraction. Maximum leaching obtained was 100% zinc and 50% copper. Time-course studies of copper and zinc solubilization suggest the possibility of selective metal recovery following treatment with specific anions.     

Bacterial leaching of uranium ore from Figueira—PR, Brazil, at laboratory and pilot scale

Abstract: A bacterial leaching program was carried out in order to evaluate the potential of applying this process to leach uranium from the ore of Figueira-PR, Brazil. The experiments were carried out in shake flasks, column percolation (laboratory and scmipilot scale)and in heap leaching. In shake flasks and in column percolation experiments at laboratory scale, bacterial activity on Ihe ore was confirmed: approximately 60% of uranium was leached, against around 30% in sterilized controls. Colunm percolation experiments at semipilot scale and heap leaching (850 tons of ore) showed uranium extractions of approximately 50%. In both experiments, a complementary sulfuric acid attack, after the bacterial leaching phase, was neccssaw to reach this level of uranium extraction.     

Characterization and bioleaching of nickel laterite ore using Bacillus subtilis strain

There are two principal types of nickel (Ni) deposits: sulfide and laterite ores. Interest in low-grade Ni-laterite ores has increased in recent years as high-grade Ni-sulfide deposits are being quickly depleted. However, processing of Ni laterites has proven technically difficult and costly, and the development of alternative low-cost biotechnologies for Ni solubilization has been encouraged. In this context, by the first time, a sample of Brazilian Ni-laterite ore was analyzed mineralogically and subjected to bioleaching tests using a heterotrophic Bacillus subtilis strain. SEM-analysis indicated that the primary Ni carrier mineral is goethite. Chemical analysis of different grain size fractions indicated a homogeneous distribution of Ni. XRF-analysis showed that the ore consists mainly in lizardite (32.6% MgO) and contains1.0% NiO (0.85% Ni). Bioleaching batch experiments demonstrated that about 8.1% Ni (0.7 mg Ni/g ore) were solubilized by the B. subtilis after 7 days. Application of microwave heating as a Ni-laterite pretreatment was also tested. This pretreatment increased the bioextraction of Ni from 8% to 26% (2.3 mg Ni g⁻¹ ore).     

Isolation of Phosphate Solubilizing Bacteria from Maize Rhizosphere and Their Potential for Rock Phosphate Solubilization–Mineralization and Plant Growth Promotion

Phosphate solubilizing bacteria (PSB) play a significant role in plant P nutrition by their effect on soil P dynamics and their subsequent ability to make P available to plants via solubilization and mineralization processes. This study aimed to evaluate the effect of separate and combined use of indigenous PSB, poultry manure (PM) and compost on solubilization and mineralization of rock phosphate (RP) and their subsequent effect on growth and P accumulation of maize (Zea mays L.). A group of fifty seven bacteria were isolated from the rhizosphere/rhizoplane of maize that had been grown in soils collected from varying altitudes (655–2,576 m) of the mountain region of Rawalakot, Azad Jammu and Kashmir, Pakistan. After screening, the capacity of eleven isolates to solubilize mineral phosphate was quantitatively evaluated using insoluble Ca₃(PO₄)₂ in culture medium as a time course study through spectrometer. The growth hormone producing (IAA) capacity of the isolates was also determined. Furthermore, five potential isolates were tested for their ability to increase P release capacity (mineralization) of insoluble RP in an incubation study. The effect of PSB inoculation on maize was determined in a completely randomized greenhouse experiment where root and shoot biomass and P accumulation in plants were assessed. The P solubilization index of selected isolates varied from 1.94 to 3.69, while the P solubilization efficiency ranged between 94.1% and 269.0%. The isolates MRS18 and MRS27 displayed the highest values. The P solubilization in the liquid medium was maximum at 6 and 9 days of incubation ranging between 9.91 and 44.04 µgmL^?1 and the isolates MRS27 and MRS34 exhibited the highest solubilization. Six isolates showed additional capability of producing IAA ranging between 2.66 and 28.41 µgmL^?1. Results of the incubation study indicated that P release capacity (P mineralization) of RP-amended soil varied between 6.0 and 11.8 µgPg^?1 that had been significantly increased to 30.6–36.3 µgPg^?1 (maximum value) when PSB were combined with RP. The combined application of PSB and organic amendments (PM, compost) with RP further increased P mineralization by releasing a maximum of 37.7 µgPg^?1 compared with separate application of RP (11.8 µgPg^?1) and organic amendments (21.5 and 16.5 µgPg^?1). The overall effect of PSB (as a group) with RP over RP alone on maize growth showing a relative increase in shoot length 21%, shoot fresh weight 42%, shoot dry weight 24%, root length 11%, root fresh weight 59%, root dry weight 35% and chlorophyll content 32%. This study clearly indicates that use of PSB, and organic amendments with insoluble RP could be a promising management strategy to enhance P availability in soil pool and improve plant growth in intensive cropping systems.     

Rock phosphate solubilization by four yeast strains

The solubilization of rock phosphate (RP) by four yeast strains, Rhodotorula sp., Candida rugosa, Saccharomyces cerevisiae and Saccharomyces rouxii, which were isolated from wheat rhizospheric soils, was investigated in this study. The yeast isolates demonstrated diverse levels of soluble phosphate releasing abilities in modified Pikovskaya liquid medium containing RP as sole phosphate source. C. rugosa was the most effective solubilizer under different conditions, followed by Rhodotorula sp., S. rouxii and S. cerevisiae. Acidification of the broth seemed to be the major mechanism for RP solubilization by the yeast isolates, and the increase in soluble phosphate released was correlated significantly with an increase in titratable acidity and a drop in pH. The optimal composition for the solubilization of RP by the yeast isolates in the broth was 20 g L^?1 glucose, 1 g L^?1 yeast extract, 0.5 g L^?1 (NH₄)₂SO₄, and 5 g L^?1 RP, respectively. The yeast isolates were able to solubilize RP at wide range of temperature and initial pH, with the maximum percentage of soluble phosphate released being recorded at 30–35 °C and pH 5–6, respectively.     

Column bioleaching of uranium embedded in granite porphyry by a mesophilic acidophilic consortium

A mesophilic acidophilic consortium was enriched from acid mine drainage samples collected from several uranium mines in China. The performance of the consortium in column bioleaching of low-grade uranium embedded in granite porphyry was investigated. The influences of several chemical parameters on uranium extraction in column reactor were also investigated. A uranium recovery of 96.82% was achieved in 97 days column leaching process including 33 days acid pre-leaching stage and 64 days bioleaching stage. It was reflected that indirect leaching mechanism took precedence over direct. Furthermore, the bacterial community structure was analyzed by using Amplified Ribosomal DNA Restriction Analysis. The results showed that microorganisms on the residual surface were more diverse than that in the solution. Acidithiobacillus ferrooxidans was the dominant species in the solution and Leptospirillum ferriphilum on the residual surface.     

Phosphate solubilization potential and modeling of stress tolerance of rhizobacteria from rice paddy soil in northern Iran

The purposes of this study were to evaluate the phosphate solubilization activity of bacteria isolated from the rhizosphere of rice paddy soil in northern Iran, and to study the effect of temperature, NaCl and pH on the growth of these isolates by modeling. Three of the most effective strains from a total of 300 isolates were identified and a phylogenetic analysis was carried out by 16S rDNA sequencing. The isolates were identified as Pantoea ananatis (M36), Rahnella aquatilis (M100) and Enterobacter sp. (M183). These isolates showed multiple plant growth-promoting attributes such as phosphate solubilization activity and indole-3-acetic acid (IAA) production. The M36, M100 and M183 isolates were able to solubilize 172, 263 and 254 µg ml^?1 of Ca₃(PO₄)₂ after 5 days of growth at 28 °C and pH 7.5, and to produce 8.0, 2.0 and 3.0 μg ml^?1 of IAA when supplemented with l-tryptophan (1 mg ml^?1) for 72 h, at 28 °C and pH 7.0, respectively. The solubilization of insoluble phosphate was associated with a drop in the pH of the culture medium and there was an inverse relationship between pH and solubilized P (r = ?0.98, P < 0.0952). There were no significant differences among isolates in terms of acidity tolerance based on their confidence limits as assessed by segmented model analysis and all isolates were able to grow at pH 4.3–11 (with optimum at 7.0–7.5). Based on a sigmoidal trend of a three-parameter logistic model, the salt concentration required for 50 % inhibition was 8.15, 6.30 and 8.23 % NaCl for M36, M100 and M183 isolates, respectively. Moreover, the minimum and maximum growth temperatures estimated by the segmented model were 5.0 and 42.75 °C for M36, 12.76 and 40.32 °C for M100, and 10.63 and 43.66 °C for M183. The three selected isolates could be deployed as inoculants to promote plant growth in an agricultural environment.