木质素酶及其生产菌的筛选育种

木质素酶降解木质纤维素材料中的木质素,使木质素-半纤维素-纤维素结构解体,纤维素得以暴露出来供后续步骤处理.它广泛应用于生物制浆、生物漂白、废水处理等工业过程中.由于近年利用可再生木质纤维素材料用酶法水解生产酒精成了研究热点,因而作为纤维素材料生物转化工艺预处理过程中的关键角色,木质素酶也极大地唤起人们的研究兴趣.本文介绍了木质素与白腐真菌(Phanerochaete chrysosporium)木质素降解酶系的特征以及锰过氧化物酶、木质素过氧化物酶、漆酶等3种木质素酶的催化作用机理,归纳了目前流行的木质素酶产生菌的筛选方法及近年来从自然界筛选木质素酶高产菌的种类,并对产木质素酶野生菌株的诱变育种与基因工程改造的进展进行了阐述.     

平菇(Pleurotus ostreatus)对稻草中木质素的生物降解及降解产物分析

变色圈试验证明平菇可以选择性优先降解稻草中的木质素,培养15d后,平菇对稻草中的木质素降解率为17.86%,对综纤维素降解率为2.44%,选择性指数为9.79。生料栽培平菇后,稻草中的木质素被降解50.24%。用气—质色谱(GC/MS)和红外光谱(IR)对木质素降解产物分析结果表明,平菇对稻草中木质素的降解效果十分明显,降解产物中检测出了大量含有苯环的小分子,证明木质素聚合体的降解首先发生在单体的侧链及单体间的连键上,发生Cα-Cβ、β-O-4等断裂,形成了单体。在进一步的降解过程中,平菇表现了其自身特有的降解机制,取代苯环单体上的甲氧基为甲基,而后发生苯环的开裂,这与报道的白腐菌降解过程有所不同。红外光谱分析中,平菇对木质素的降解明显,降解产物中含有很多木质素单体所特有的基团,如紫丁香基、愈创木基等,说明木质素的降解首先发生的是侧链的氧化反应。     

超高压对灵芝生长及其漆酶合成的影响

研究了超高压处理对灵芝生长及其漆酶合成的影响,试验结果表明:灵芝致死率随处理压力的增大而增加,在150MPa下处理30min获得了一株生物量和漆酶产量都大幅增加的菌株G1502,其最大生物量及酶活分别比出发菌株提高了19.34%和282.67%,发酵时间也缩短了1d。     

中药提取液对灵芝深层发酵的影响

我国中医药历史悠久 ,中药资源丰富 ,为保证广大人们的身体健康起到巨大作用。但近几十年来 ,我国在中药现代化方面进展缓慢 ,其中原因之一就是中药加工技术陈旧[1] ,近来有学者提出了中药发酵制药技术[1,2 ] 。药用真菌是中药的组成部分 ,它们中的许多种类都能以液体发酵进行生产[3] ,以适当的中药为培养基或在培养基中添加适量的中药 ,利用它们强大的分解转化能力 ,不仅可对中药中的纤维、糖类和蛋白等物质加以利用 ,而且在代谢过程中可能对中药中的一些成分进行转化 ,从而提高中药活性成分在复合制剂中的比例及效价 ;另外中药中的某些成…     

较高温度对灵芝培养特性及灵芝酸产量的影响

灵芝具有重要的药用价值,培养条件的优化可提高灵芝中各种活性成分的含量。探讨了较高温度对灵芝发酵过程中的生理指标及灵芝酸产量的影响。结果表明,较高的发酵温度虽然降低了灵芝生物量,但提高了淀粉酶﹑漆酶﹑纤维素酶的酶活。发酵第4天,36℃培养条件下淀粉酶酶活达到最大值,比30℃发酵条件下的酶活提高了22.61%。发酵第10天,34℃培养条件下的漆酶酶活﹑纤维素酶酶活﹑可溶性糖含量和灵芝酸产量都达到最大值,相对于30℃的培养条件,分别提高了51.12%、30.41%、13.21%和45.23%。结果表明较高温度发酵有利于酶活和灵芝酸含量的提高,该研究为灵芝的高温发酵提供了新的思路和理论指导。     

Cu(II)对一株镰刀菌形态发育及木质素酶系活性的影响

本试验采用室内摇瓶培养,通过添加不同浓度的Cu(II),研究了Cu(II)对降解菌Fusarium sp. ZH-H2形态发育及木质素酶系活性的影响,以期诱导提高木质素酶系的活性。结果表明,当Cu(II)浓度为0.50mmol/L时,菌丝生物量最高达0.38g,菌丝团呈洁白平滑球状且数量最多,此浓度下木质素过氧化物酶（lignin peroxidase,LiP）活性峰值也达到最高,为28 315.41U/L,当Cu(II)浓度为2.00mmol/L时,有利于诱导锰过氧化物酶（manganese peroxidase,MnP）和漆酶（laccase,Lac）的代谢,最高峰值分别为1 612.90U/L、7 829.12U/L,并且明显缩短了峰值的形成时间,浓度过高或过低则对3种木质素酶系活性产生抑制效应,为下一步分子生物学研究奠定了基础。     

灵芝悬浮培养中添加微颗粒Talc对灵芝酸产生的影响

灵芝酸是灵芝中重要的药理活性物质,其低产量限制了它的广泛应用和深入研究,高效提高液体发酵中灵芝酸的含量十分必要。以CGMCC 5.65为材料,在悬浮培养条件下,研究添加微颗粒Talc对灵芝酸产生的影响。结果表明,微颗粒Talc添加显著减小了灵芝细胞粒径,对照组为(3.33±0.16)mm,15g/L微颗粒Talc添加组为(2.04±0.12)mm。灵芝细胞中单体灵芝酸和总灵芝酸的含量在微颗粒Talc添加条件下也显著提高。15g/L微颗粒Talc添加组的总灵芝酸含量达到(1.51±0.02)mg/100mg细胞干重,GA-Mk、GA-T和GA-Me的含量最高为(6.02±0.29)、(5.08±0.14)和(1.71±0.09)μg/100mg细胞干重,分别是对照的1.6、4、1.9和1.4倍。另外,15g/L微颗粒Talc添加条件下鲨烯和羊毛甾醇的最大积累量分别为(3.69±0.23)和(34.86±6.41)μg/100mg细胞干重,是对照的2.6和4.2倍;灵芝酸生物合成途径关键基因fps和cyp-5150l8的表达量最高为对照的2.35和1.53倍。     

碳源和氮源对彩绒革盖菌Coriolus versicolor木质纤维素酶和木质素酶分泌的影响

研究了彩绒草盖菌在不同碳源和氮源培养基中生长时,对纤维素酶、半纤维素酶、木质素酶（漆酶、多酚氧化酶、愈创木酚氧化酶）分泌的影响。结果表明不同碳源和氮源对酶类的分泌影响很大,富含淀粉的物质能明显促进木质素酶的分泌,而专一性底物（纤维素和半纤维素）对纤维素酶和半纤维素酶有诱导作用,麸皮也能诱导半纤维素酶的产生。     

灵芝EIM-40漆酶的分离纯化及酶学性质

采用冻干浓缩、（NH4）2S04盐析、HiTrapphenyl（FF）疏水层析和QSepharose FastFlow离子交换层析对灵芝EIM-40发酵液进行分离纯化,获得纯化漆酶,纯化倍数为14．6,回收率为5．3％。SDS-PAGE银染的结果为单一条带,相对分子质量约为6．53×104。以愈创木酚和2,2-联氮-二（3-乙基-苯并噻唑-6-磺酸）二铵盐（ABTS）为催化底物进行酶学性质研究,最适pH分别为4．8和4．5,最适温度分别为55和50℃,2种底物在pH4．0。5．0范围内,温度低于50℃时,酶的稳定性都很好。以愈创木酚为底物,Km=645．0umol／L;以ABTS为底物,Km=22．2txmol／L。Cu2＋对该酶起激活作用,Fe2＋、Ca2＋、Ba2＋则完全抑制酶的活性。     

百草枯对木质素降解菌产酶及其生物化学变化的影响

为研究外源活性氧对木质素降解菌的影响,本实验对外源百草枯诱导下的杂色云芝(Coriolus versicolor)产酶及其生物化学过程进行了研究。将一定浓度的百草枯加入培养7 d的杂色云芝菌培养液中,连续培养148 h,测定其胞外木质素降解酶、胞内抗氧化酶的活性及生物化学参数的变化。与对照相比,30μmol/L的百草枯能够显著促进杂色云芝锰依赖过氧化物酶(MnP)、木质素过氧化物酶(LiP)和漆酶(Lac)的活性,3种酶活性分别提高了1.3、7和2.5倍;在连续培养的前48 h,30μmol/L的百草枯促进了胞内超氧化物歧化酶(SOD)、过氧化氢酶(CAT)的活性。百草枯对于胞外木质素降解酶活性的促进作用比对胞内抗氧化酶活性的促进作用明显。百草枯的加入促进了胞外酚类化合物与甲醛的浓度的增加,而丙二醛的浓度在培养的前24 h内增加,随后下降。结果表明,百草枯的加入对白腐菌产生了氧化胁迫,但菌株的抗氧化系统能够有效地进行氧化剂的清除,从而阻止氧化剂对机体的氧化伤害。百草枯作为外源氧化胁迫剂,可以增加木质素降解酶活性,有利于木质素的降解。     

Screening of Pleurotus ostreatus isolates for their ligninolytic properties during cultivation on natural substrates

Thirteen basidiospore-derived isolates of Pleurotus ostreatus f6 strain differing in the level of ligninolytic enzyme production and other characteristics (mycelium extension rate, colony morphology) from the parental strain were cultivated on natural substrates. Under these conditions ligninolytic enzyme activity, loss of organic mass, polycyclic aromatic hydrocarbons (PAHs) degradation and colonization of sterile and nonsterile soil were studied. The activity of ligninolytic enzymes was substantially higher in straw than in liquid culture, although the differences between the isolates were less pronounced on this substrate. Some of the isolates showed a very good ability to decompose the lignocellulosic substrate (straw) and a relatively high loss of organic mass was found after 50 days of cultivation in these strains. The original strain f6 and isolates B13 and B26 successfully degraded all seven tested PAH compounds present in experimental soil samples, but the higher or lower ligninolytic enzyme production of isolates tested had no substantial effect on the extent of the degradation. In our screening, six basidiospore-derivedisolates growing well in nonsterile soil were found, whichcould be suitable for the prospective biotechnological exploitation.     

菌草灵芝与段木灵芝的功效成分的比较研究

测定并比较菌草灵芝和不同产地的段木灵芝中的粗多糖、三萜类物质和孢子油中三萜类物质的含量和孢子油得率的差异。结果表明,菌草灵芝和不同产地的段木灵芝中的粗多糖、三萜类物质和孢子油中三萜类物质的含量和孢子油得率存在着差异,菌草灵芝中的粗多糖、三萜类物质和孢子油中三萜类物质的含量和孢子油得率都高于段木灵芝。     

Laccase production in solid‐state and submerged fermentation by Pleurotus ostreatus

A solid‐state fermentation (SSF) system for production of an industrially important enzyme laccase by Pleurotus ostreatus was developed by using potato dextrose yeast extract medium and polyurethane foam as a supporting material. The maximum laccase production in the SSF system was as high as 3×10⁵ U/L. Addition of inducers, such as copper and ferulic acid, further enhanced the laccase production in SSF. Moreover, the time required for the maximum laccase production was reduced to 6 days compared to 10 days reported earlier. The improvement achieved by the SSF system was investigated by comparing it to a submerged fermentation system (SmF), both experimentally and by using a standard theoretical model along with a parameter sensitivity analysis. Laccase production in SSF was found to be twice of that in SmF. One of the main reasons for higher laccase production in SSF compared to SmF was possibly due to the presence of higher proteolytic activity in SmF. Strong proteolytic activity in SmF presumably caused subsequent laccase degradation, which lowered the ultimate laccase production in SmF compared to SSF.     

磷酸氢二铵对糙皮侧耳菌丝生长及基质降解酶活性的影响

氮源种类和浓度均会对糙皮侧耳Pleurotus ostreatus菌丝长势、生长速率以及代谢产生影响,而氮匮乏与氮过量积累都会对糙皮侧耳的生长产生不利影响。为了研究氮源对糙皮侧耳菌丝生长和基质降解酶活性的影响,本研究选取磷酸氢二铵[(NH4)2HPO4]作为唯一氮源,通过在培养基中添加不同浓度的磷酸氢二铵检测糙皮侧耳菌丝生长速率和木质纤维素降解酶的活性,筛选出糙皮侧耳生长的最适磷酸氢二铵浓度。结果表明,当磷酸氢二铵的添加浓度区间为10–20 mmol/L时菌丝长势最好。以缺氮时的酶活作为对照,当磷酸氢二铵的添加浓度为10 mmol/L时,羧甲基纤维素酶的活力最强,显著高于对照组(P<0.05);当添加浓度为5 mmol/L时,滤纸纤维素酶的活力最强,显著高于对照组(P<0.05),而10 mmol/L浓度下的酶活力比5 mmol/L时稍有下降,但二者之间无显著性差异(P>0.05);当添加浓度为40 mmol/L时,木聚糖酶的活力最强,显著高于对照组(P<0.05);当添加浓度为10mmol/L时,漆酶的活力最强,显著高于对照组(P<0.05)。基质降解酶...     

Effects of carbon and nitrogen sources on Pleurotus ostreatus ligninolytic enzyme activity

Summary The effect of various carbon and nitrogen sources on laccase, manganese-dependent peroxidase (MnP), and peroxidase production by two strains of Pleurotus ostreatus was investigated. The maximal laccase yield of P. ostreatus 98 and P. ostreatus 108 varied depending upon the carbon source from 5 to 62 U l⁻¹ and from 55 to 390 U l⁻¹, respectively. The highest MnP and peroxidase activities were revealed in medium supplemented by xylan. Laccase, MnP, and peroxidase activities of mushrooms decreased with supplementation of defined medium by inorganic nitrogen sources. Peptone followed by casein hydrolysate appeared to be the best nitrogen sources for laccase accumulation by both fungi. However, their positive effects on enzyme accumulation were due to a higher biomass production. The secretion of MnP and peroxidase by P. ostreatus 108 was stimulated with supplementation of casein hydrolysate to the control medium since the specific MnP and peroxidase activities increased 15-fold and 3.5-fold, respectively.     

不同栽培基质对糙皮侧耳不同发酵方式下产漆酶活性的影响

为了比较糙皮侧耳栽培种在不同常规栽培基质上的漆酶活性,分析更适合糙皮侧耳生长的栽培基质,以1株糙皮侧耳Pleurotus ostreatus栽培菌株为研究材料,研究在固态和液态发酵条件下添加木屑、玉米芯和棉籽壳这3种栽培基质后,对其产漆酶活性的影响。结果表明,不同栽培基质对糙皮侧耳漆酶活性具有极显著的影响（P<0.001）;不同发酵方法对糙皮侧耳漆酶活性也具有极显著的影响（P<0.001）,仅第2天差异不显著。固体发酵与液体发酵条件下,糙皮侧耳在棉籽壳培养基上所检测到的漆酶活性均高于在木屑或者玉米芯培养基上,表明棉籽壳对提高糙皮侧耳漆酶活性的诱导能力更强。此外,糙皮侧耳在棉籽壳培养基上能够快速分泌漆酶,表明棉籽壳对缩短糙皮侧耳漆酶分泌时间的诱导能力更强。     

Effects of fermentation products of Ganoderma lucidum on growth performance and immunocompetence in weanling pigs

The purpose of this study was to test fermentation, for its products of a Chinese medicinal mushroom, Ganoderma lucidum, cultured by submerged fermentation for its effect on growth performance and immunocompetence in weanling piglets. In Experiment 1, 72 weanling piglets were allotted to one of four treatments receiving these fermentation products (GLF, expressed as amount of β-glucans) at 0 (control), 50, 100, and 150 mg/kg feed for 4 weeks. The results showed that at a supplementation level of 50 mg/kg feed, GLF caused the best growth performance, the highest pseudorabies antibody titre, and a decrease of blood glucose level. It was also demonstrated that GLF up-regulated the cell-mediated immune response related cytokines (IL-2, IFN-γ, and TNF-α) expression in different lymphoid tissues. After challenging with porcine circovirus (PCV) type 2 (Experiment 2), a supplementation with 50 mg GLF per kg feed also inhibited PCV-2 virus amplification, and ameliorated lymphocyte depletion in different lymphoid tissues. Conclusively, feed supplemented with GLF at 50 mg/kg could be beneficial to counteract the physiological stress in weanling piglets.     

富硒平菇干粉对小鼠的脏器指数与抗氧化能力的影响

目的探讨富硒平菇干粉对小鼠的脏器指数与抗氧化能力的影响。方法将60只20g左右的健康昆明种小鼠随机分为6组。1组为对照组;2组为亚硒酸钠组;3组为普通平菇干粉组;4～6组为富硒平菇干粉组,分别在基础日粮中添加低、中、高浓度的富硒平菇干粉。30d后测定小鼠脏器指数与肝脏和血浆中谷胱甘肽过氧化物酶(GSH-Px)、超氧化物歧化酶(SOD)和丙二醛(MDA)含量。结果富硒平菇干粉可显著提高小鼠脾脏、胸腺和肝体指数;可显著提高小鼠肝脏与血浆中GSH-Px、SOD的酶活,降低小鼠肝脏和血浆中MDA含量。结论富硒平菇干粉可显著提高小鼠脏器指数与抗氧化能力。