Oszillierende-fed-batch-Technik bei der Cellulasegewinnung

From different fungal genera some mutant strains were selected which in cellulase formation exhibit reduced catabolite-repression related to several soluble carbon sources. The cellulase production by these mutant strains on the basis of soluble carbon sources is possible if a fed-batch-technique is used for feeding the substrate. The optimum procedure is an oscillating-fed-batch-technique (OFB) with feed-back-controlled intermittent addition of the substrate. The substrate concentration in the medium is adjusted in such a manner to realize oscillations between a limitation for mycelium growth and non-limiting conditions under a substrate concentration which is yet below the repressing concentration for cellulase formation. A suitable feed-back-parameter for the control of substrate addition is the specific CO₂-formation of the mycelium. Using OFB the growth in cellulase activity is nearly proportional to the feeded substrate whereas the growth in mycelium is reduced. The productivity of cellulase formation is enhanced in comparison to continuous substrate addition as well as under limiting and non-limiting conditions for growth of mycelium.     

源自不同寄主的灰葡萄孢生物学特性的比较研究

本研究以分离自番茄、辣椒、草莓、葡萄的灰葡萄孢Botrytis cinerea为供试菌株,从生长温度、pH适应性、碳源、氮源营养利用等方面对不同寄主来源的灰葡萄孢菌株的生物学性状进行了比较研究。结果表明,5个不同寄主来源的灰葡萄孢菌株的菌丝生长温度范围相同,均为0-35℃;但它们的最适生长温度和分生孢子致死温度存在差异,来自和县番茄菌株HX12最适生长温度为20℃,分生孢子致死温度为47℃ 10min,其余最适生长温度均为25℃,分生孢子致死温度均为48℃ 10min;不同菌株在相同温度下的生长速率有显著差异。pH对不同寄主来源灰葡萄孢菌株菌丝生长的影响存在差异,来自长丰辣椒的菌株LJ菌丝在pH2-9的范围内均能生长,以在pH3-6.5时生长较快,pH6时最快;其余4个菌株在pH2-12的范围内均能生长,以在pH3-9时生长较快,pH6左右最快。不同碳源、氮源营养对灰葡萄孢菌株菌丝生长和分生孢子产生均有显著影响,不同寄主来源的菌株间在碳源、氮源营养利用差异均极显著。在相同碳源、氮源营养条件下,不同寄主来源的菌株的线性生长、菌丝干重和分生孢子产量均有显著差异。     

水葫芦黑斑病菌Alternaria alternata的生物学特性研究

在不同试验条件下培养水葫芦黑斑病菌Alternaria alternata菌株,探讨其主要的生物学特性,结果表明：该菌株生长的最佳培养基为PSA,最佳C源为葡萄糖,弱碱性和中性N源对该菌菌丝生长具有明显的促进作用,而酸性N源对其具有抑制作用。菌株生长的最佳pH值为pH7,最适温度为27℃。湿度越大,对菌株生长越有利。     

马铃薯干腐病菌硫色镰孢的生物学特性

从碳源、氮源、酸碱度及生长温度等方面对引起马铃薯干腐病的硫色镰孢Fusarium sulphureum的生物学特性进行了研究。结果表明,该病原菌在不同发育阶段对营养和环境条件的要求存在差异。在固体培养基上,菌落生长最佳碳源为葡萄糖、麦芽糖,最佳氮源为蛋白胨,pH8?为最佳;在液体培养基中,菌丝体生长以麦芽糖为最佳碳源,以硝酸钠为最佳氮源,pH6?为最佳;在分生孢子萌发阶段,在以羧甲基纤维素钠、蛋白胨和谷氨酸为碳、氮源的营养液中,分生孢子萌发率最高,最适pH 6–8。该病菌最适生长温度为25℃,分生孢子致死     

大白口蘑菌丝的培养优化

从大白口蘑子实体中分离得到菌种,并进行不同营养条件对大白口蘑菌丝生长的影响实验。结果表明,最佳氮源为酵母粉;最佳碳源为果糖;能明显促进菌丝生长的矿质元素为磷酸二氢钾;最佳生长调节因子为吲哚乙酸;最适温度为28－32℃;最适pH4.0－5.0。     

Factors Affecting the Production of Extracellular Pectolytic Enzymes by Phytophthora palmivora (Butl.) Butl

The nutritional requirements of Phytophthora palmivora in relationto extracellular pectolytic enzyme production were investigated.These were found to be different from those necessary for mycelialgrowth. The best carbon source for enzyme production was maltose.The best inorganic nitrogen source for enzyme production wascalcium nitrate, the effect of which could not be related solelyto the calcium ions; DL-alanine was the best organic nitrogensource for enzyme production. Evidence was obtained to indicatethat polygalacturonase (PG) and a maceration factor (MF) wereconstitutive, but that -L-arabinofuranosidase (AF) secretionwas induced by arabans present in pectin. The extrinsic factors in relation to growth and enzyme secretionwere also investigated. Both mycelial growth and enzyme productioncould be broadly related to the incubation period, temperature,and the pH of the media. Two peaks of PG and AF activities wererecorded corresponding to the phases of optimum growth and autolysisof the mycelium, respectively. When five isolates were compared,the mycelial growth could not be related to the quality of enzymesproduced.     

Studies on the Production of Digitalis Cardenolides by Plant Tissue Culture III. Effects of Nutrients on Digitoxin Formation by Shoot-Forming Cultures of Digitalis purpurea L. Grown in Liquid Media

Shoot-forming cultures of Digitalis purpurea L. were grown invarious modifications of Murashige-Skoog medium. The effectsof vitamins, natural extracts, plant growth substances, carbonand nitrogen sources and phosphate on their growth and digitoxinformation were investigated. Sucrose, glucose and raffinosewere suitable carbon sources for both growth and digitoxin formation.The optimum concentration of sucrose was 3%. Reduction of thebasal nitrogen concentration by one-third increased the digitoxincontent per unit weight without suppression of growth. The optimalratio of nitrate-nitrogen to ammonium-nitrogen was 2, as providedin the basal medium. A threefold increase in the phosphate concentrationimproved both growth and digitoxin content. Thiamine.HCl andmyo-inositol were required for digitoxin formation, whereasglycine, nicotinic acid and pyridoxine.HCl, usual componentsof the medium, were not required for either growth or digitoxinformation during the three passages examined. Coconut milk improvedgrowth with no reduction in the digitoxin content per unit weight.Gibberellic and abscisic acids at 0.01 to 0.1 mg per liter slightlyimproved digitoxin formation. Kinetin had no clear positiveeffect on either growth or digitoxin formation. (Received March 12, 1982; Accepted August 5, 1982)     

不同碳、氮营养对球孢白僵菌生物学特性和抑菌活性的影响

研究了不同碳营养和氮营养对球孢白僵菌菌丝生长、分生孢子产生量、菌丝生物量及其次生代谢产物的抑菌活性.结果表明,球孢白僵菌对单糖、双糖、多糖等碳营养及有机氮和无机氮等氮营养均能够利用,但利用程度存在一定差异.其中,球孢白僵菌的菌丝生长以白砂糖和蛋白胨最快,以甘露醇和硫酸铵最慢;分生孢子产生量以白砂糖和硝酸钾最多,以甘露醇...     

Semi-defined Medium for in vitro Cultivation of the Fastidious Insect Pathogenic Fungus Cordyceps unilateralis

Cordyceps unilateralis is a fastidious fungal pathogen affecting ants. Up to now, only the complex and expensive Grace’s insect cell culture medium has been used for in vitro cultivation (as blastospores and mycelium) of this fungus. To obtain an inexpensive and less complicated medium, the effects of carbon and nitrogen sources, salt solution and carbon-to-nitrogen (C:N) ratio on the growth of this fungus were examined. Glucose was the most important factor for blastospore formation, and yeast extract could be used as a nitrogen source for blastospore formation and mycelial growth. A suitable C:N ratio (glucose: yeast extract) was 33.3:1. As a result, a new semi-defined medium was achieved, composed of 26.68 g L⁻¹ glucose, 3.3 g L⁻¹ yeast extract and salt solution. This medium supported blastospore formation and mycelial growth of all tested C. unilateralis isolates.     

Fungal Assciations: II. Cultural Studies on Rhizoctonia solani Kuhn, Fusariutn solani Snyder and Hansen, and Other Fungi, and Their Interactions

Several types of interaction between Rhizoctonia solani, Fusariumsolani, and Phoma foveata were found when these fungi were grownon potato-dextrose agar. After being used by Rhizoctonia a potatomash medium gave better growth of Rizoctonia and Fusarium thanit did when the medium was initially used by Fusarium; and thiswas so whether the reaction of the spent medium was readjustedor not. It is suggested that potato mash medium used by Fusariumcontains a thermostable factor(s) affecting the subsequent growthof Rhizoctonia or Fusarium. The range of pH values suitable for Rhizoctonia growth was narrowerthan that for Fusarium, optimum values being approximately 5•9for the former and 7•8 for the latter. In mixed culturesof the two fungi on potato-dextrose agar adjusted to differentpH values, the fungus for which the reaction of the medium wasmore suitable usually became visually predominant after sometime. A study of various carbon sources showed that poor growth ofRhizoctonia was obtained when pectin was used as the sole sourceof carbon. On a pectin-agar medium, the rate of growth of aRhizoctonia colony increased on the sector which lay towardsan adjacent Fusarium colony; also, after the two fungi camein contact, there was more rapid growth of Rhizoctonia roundthe Fusarium colony than elsewhere. On a synthetic liquid mediumwith pectin as the carbon source better Rhizoctonia growth wasobtained when Fusarium-spent medium was added to it than whenRMzoctoma-spent medium was added. Rhizoctonia showed partial deficiencies in thiamine, biotin,and inositol. Both the extract of Fusarium mycelium, grown onvitamin-free medium, and the Fusarium-spent medium, stimulatedthe growth of Rhizoctonia on vitamin-free medium.     

Growth morphology of Streptomyces akiyoshiensis in submerged culture: influence of pH, inoculum, and nutrients.

Most media in which the growth of shaken submerged cultures of Streptomyces akiyoshiensis was examined did not support the formation of well-dispersed mycelial suspensions. Investigation of the culture conditions promoting dispersed growth showed the pH of the culture medium to be of critical importance; an initial value of 5.5 minimized aggregation of the mycelium while supporting adequate biomass production. In cultures started at this pH, spore inocula gave better mycelial dispersal than did vegetative inocula; with spore inocula, growth morphology was also less affected by inoculum size. The composition of the nutrient solution influenced the extent of mycelial dispersal; slow growth was often associated with clumping but no clear correlation was observed between pellet formation and the ability of carbon or nitrogen sources to support rapid growth. Increasing the phosphate concentration from 0.5 to 15 mM caused a modest decrease in mycelial aggregation. Conditions promoting a well-dispersed mycelium suitable for studying the physiological control of secondary metabolism also supported the formation of 5-hydroxy-4-oxonorvaline by S. akiyoshiensis.     

培养基和培养条件对栀子悬浮细胞合成多糖的影响

对栀子悬浮细胞合成多糖的调控因子研究表明 :B5为最适培养基 ;5～10d继代周期的细胞可以保持良好的生长状态和多糖的合成能力 ;80g L的鲜细胞的接种量有利于栀子细胞的生长和多糖的合成 ;使用单一碳源时 ,葡萄糖比蔗糖对细胞生长更有益 ,但葡萄糖成本高 ,因而混合碳源 45g L(葡萄糖 :蔗糖 =1∶1)是最佳配方 ;氮源种类对细胞生长和多糖合成没有明显的影响 ,但氮源浓度是主要因素 ,40～50mmol L是最佳浓度 ,同时运用悬浮细胞生产栀子多糖可以通过在不同时间收获的细胞来避免提取时黄色素的干扰 ,具有很好的实际意义。     

FURTHER NOTES ON THE GROWTH AND CHLOROPHYLL FORMATION OF CHLORELLA PROTOTHECOIDES

1. Using area of a fixed concentration as a nitrogen source,cells of Chlorella protothecoides were grown in the presenceof various carbon compounds. Magnitudes of growth of the cellswere widely different depending on the carbon sources used;glucose and fructose being most favourable substrates and galactose,glycerol and acetate coming next. But the amounts of chlorophyllformed in the cells during the experimental period were almost,the same irrespective of the different carbon sources, withsome exceptions. The similarity of the chlorophyll level observedin these experiments seemed to indicate that the formation ofchlorophyll was limited largely by the nitrogen source but notby the carbon source. 2. Strong bleaching effect was recognized with glucose and fructoseat their high concentration, which produced totally chlorophyll-lesscells. On the other hand, a stimulating effect on chlorophyllformation was observed with galactose at the different concentrationsexamined. 3. Effects of glycine and ammonium carbonate as the nitrogensource on the algal growth and pigmentation were studied insome details. The results were similar to those previously obtainedwith urea, confirming our previous conclusion that the algalpigmentation is profoundly affected by the concentration balancebetween glucose and nitrogen source. ¹Present address: Tokyo Research Laboratories, Tanabe SeiyakuCo., Toda-machi, Saitama.     

黄精褐斑病的病原生物学特性

为明确发生在贵州省施秉县的黄精叶斑类病害的病原菌,通过形态学和分子生物学方法对病原菌进行了鉴定,并对其生物学特性进行了初步研究。形态特征及rDNA-ITS、β-tubulin和tef1多基因序列分析表明,该病原菌为棕榈拟盘多毛孢Pestalotiopsis trachicarpicola。生物学特性研究结果表明,该菌菌丝体适宜生长温度为15-30℃,最适温度为28℃;最适pH值为5;以葡萄糖为碳源、酵母浸膏为氮源比较适合菌丝体的生长;菌丝体生长的最佳培养基为PDA;光照对菌丝体生长无明显影响;菌丝体致死温度为45℃。     

Growth and mycelial strand production of Rigidoporus lignosus with various nitrogen and carbon sources

Growth and differentiation of mycelial strands in Rigidoporus lignosus have been shown to depend on suitable combinations of the pH of the media and the nature of the nitrogen and carbon sources. Amino acids as sole nitrogen sources gave rise to vegetative mycelium. At pH 4.5, growth and mycelial strand differentiation required asparagine, as the fungus failed to grow in the absence of this amino acid. However, at pH 6, differentiation of strands occurred appreciably in asparagine-deficient media, suggesting a close balance between pH and amino acid requirements. Ammonium was required for strand differentiation, while nitrate, as a sole nitrogen source, maintained the fungus undifferentiated. Of the carbohydrates tested, only glucose, fructose and mannose supported strand differentiation. Starch was found to be particularly effective in promoting growth of vegetative mycelium. Strand differentiation required more specific conditions than growth of the vegetative mycelium.     

Exopolysaccharide production and mycelial growth in an air-lift bioreactor using Fomitopsis pinicola

For effective exopolysaccharide production and mycelial growth by a liquid culture of Fomitopsis pinicola in an air-lift bioreactor, the culture temperature, pH, carbon source, nitrogen source, and mineral source were initially investigated in a flask. The optimal temperature and pH for mycelial growth and exopolysaccharide production were 25degrees C and 6.0, respectively. Among the various carbon sources tested, glucose was found to be the most suitable carbon source. In particular, the maximum mycelial growth and exopolysaccharide production were achieved in 4% glucose. The best nitrogen sources were yeast extract and malt extract. The optimal concentrations of yeast extract and malt extract were 0.5 and 0.1%, respectively. K2HPO4 and MgSO4 x 7H2O were found to be the best mineral sources for mycelial growth and exopolysaccharide production. In order to investigate the effect of aeration on mycelial growth and exopolysaccharide production in an air-lift bioreactor, various aerations were tested for 8 days. The maximum mycelial growth and exopolysaccharide production were 7.9 g/l and 2.6 g/l, respectively, at 1.5 vvm of aeration. In addition, a batch culture in an air-lift bioreactor was carried out for 11 days under the optimal conditions. The maximum mycelial growth was 10.4 g/l, which was approximately 1.7-fold higher than that of basal medium. The exopolysaccharide production was increased with increased culture time. The maximum concentration of exopolysaccharide was 4.4 g/l, which was about 3.3-fold higher than that of basal medium. These results indicate that exopolysaccharide production increased in parallel with the growth of mycelium, and also show that product formation is associated with mycelial growth. The developed model in an air-lift bioreactor showed good agreement with experimental data and simulated results on mycelial growth and exopolysaccharide production in the culture of F pinicola.     

碳源种类及碳氮比对眼点拟微绿球藻生长密度、油脂含量和脂肪酸组成的影响

研究了三种碳源Na2CO3、NaHCO3、葡萄糖对眼点拟微绿球藻生长密度和油旨含量的影响,实验结果表明相对于葡萄糖,无机碳源NaHCO3更利于眼点拟微绿球藻的生长.以NaHCO3为碳源,研究了在不同的接种密度、NaNO3浓度下,C/N对眼点拟微绿球藻生长密度和油脂含量的影响.实验结果表明,C/N对眼点拟微绿球藻生长密度的影响与接种密度和NaNO3浓度有关,在高的NaNO3浓度时,C/N对眼点拟微绿球藻生长密度的影响很小;在低的NaNO3浓度时,随着C/N比的增加,微绿球藻的生长密度先增加后下降,存在最佳的C/N比.最佳的C/N比随接种密度而变化,在接种密度为OD440=0.10时,最佳C/N比为3,当接种密度提高到OD440=0.70时,最佳C/N比增加到5.NaNO3浓度和C/N对微藻油脂含量均有较大影响,在不同的接种密度和NaNO3浓度下都表现为C/N=1时最利于微藻油脂的积累,这与卡尔文循环过程中核酮糖-1,5-二磷酸羧化酶/加氧酶的活性有关.本实验的最佳产油培养条件为以NaHCO3为碳源,初始接种密度为OD440=0.70,C/N=1∶1,CNaNO3=0.225g/L,此时油脂产率为56.7 mg/(L·d),EPA产率为6.5 mg/(L·d).     

采自祁连山的冷杉侧耳生物学特性及栽培条件探索

以采自甘肃省祁连山国家级自然保护区菌物保育区的野生侧耳作为试验材料,通过形态学及系统发育分析方法将其鉴定为冷杉侧耳Pleurotus abieticola。对该菌株生物学特性及栽培条件进行初步研究,结果表明：菌丝体最适生长温度为25℃;最适pH为7.0;最适碳源为玉米粉;最适氮源为豆粉;在以棉籽壳、木屑和麸皮为栽培料时,可获得子实体。     

薄皮干酪菌生物学特性及驯化栽培

大型真菌种质资源是国家种质资源库建设重要组成部分,为了充分开发利用大型真菌资源,对采自吉林省寒葱岭的一株野生菌进行分离纯化,并将获取的纯菌株作为实验材料。通过形态学和ITS序列分析,将其鉴定为薄皮干酪菌Tyromyces chioneus。本实验研究了固体培养条件下不同碳源、氮源、pH和温度对其菌丝生长的影响,并从4个单因素实验中选出3个最优水平进行正交实验。同时,在对其菌丝体最适培养条件研究结果的基础上,对其进行驯化栽培研究。结果表明,薄皮干酪菌的最适培养条件为：果糖(20 g/L)、酵母浸粉(2 g/L)、pH 4.0、温度30 ℃。正交实验结果表明,氮源对其菌丝体生长的影响最大,其次是碳源、pH和温度。驯化栽培结果表明,菌丝发菌时间为21 d;空气湿度为85%-95%,适量的散射光,降低温度至18-20 ℃刺激后原基逐步变成菇蕾,将温度、湿度分别提高至24-25 ℃、90%-98%,30 d后子实体成熟。通过本实验的研究为薄皮干酪菌的后续开发利用提供了基础实验数据。     

甘蔗茎内两个内生菌株16S rRNA 序列分析及其生长特性

从两个甘蔗品种GT11和RB86-7515表面灭菌的茎中分离到两株具有固氮活性的菌株,分别编号为B11S和B8S.利用16S rRNA序列分析对其进行鉴定,并对两个菌株的生物学特性进行了比较.结果表明:B11S菌株与Stenotrophomonas maltophili菌株处在同一个分支,其序列与多个Stenotrophomonas maltophili菌株的序列相似性都达到98%以上,菌株B8S与多个土壤杆菌属细菌的序列相似性达到100%;两个菌株在温度31℃、pH为6左右时生长量最高;温度31℃、pH为6.5～7.0时固氮酶活性最高;相同浓度的蔗糖生长量大于葡萄糖,且表达固氮酶活性也最强;添加一定量的氮素有利于细菌生长和固氮酶活性的表达,但随着N含量的增加,抑制作用越来越明显.