Long-term perfusion culture of hybridoma: a "grow or die" cell cycle system

In order to elucidate the hybridoma life cycle and the limiting factors in perfusion systems, we performed cultures in a stirred tank bioreactor, coupled to an external tangential flow filtration unit. Cell density and antibody production in perfusion were consistent with previous studies. The average life span of the cells (2.1-2.2 days), antibody, productivity per cell produced (30-38 mg/10(9) cells) and cell size diameter evolution appeared similar to values observed in batch cultures. These observations highly suggest a similar "grow or die" life cycle. Cell and antibody production, strictly related to the medium perfusion rate, seem to be under the control of the nutrient availability. A hypothesis to explain such a life cycle of hybridoma cells in perfusion systems and a model for viable and dead cell density is proposed.     

The effects of culture conditions on the glycosylation of secreted human placental alkaline phosphatase produced in Chinese hamster ovary cells

The effects of different culture conditions, suspension and microcarrier culture and temperature reduction on the structures of N-linked glycans attached to secreted human placental alkaline phosphatase (SEAP) were investigated for CHO cells grown in a controlled bioreactor. Both mass spectrometry and anion-exchange chromatography were used to probe the N-linked glycan structures and distribution. Complex-type glycans were the dominant structures with small amounts of high mannose glycans observed in suspension and reduced temperature cultures. Biantennary glycans were the most common structures detected by mass spectrometry, but triantennary and tetraantennary forms were also detected. The amount of sialic acid present was relatively low, approximately 0.4 mol sialic acid/mol SEAP for suspension cultures. Microcarrier cultures exhibited a decrease in productivity compared with suspension culture due to a decrease in both maximum viable cell density (15-20%) and specific productivity (30-50%). In contrast, a biphasic suspension culture in which the temperature was reduced at the beginning of the stationary phase from 37 to 33 degrees C, showed a 7% increase in maximum viable cell density, a 62% increase in integrated viable cell density, and a 133% increase in specific productivity, leading to greater than threefold increase in total productivity. Both microcarrier and reduced temperature cultures showed increased sialylation and decreased fucosylation when compared to suspension culture. Our results highlight the importance of glycoform analysis after process modification as even subtle changes (e.g., changing from one microcarrier to another) may affect glycan distributions.     

Hybridoma perfusion systems: a comparison study

The efficiency of lgM production by hybridoma cells (1) cultured in suspension; (2) entrapped in alginate beads; or (3) packed in hollowfiber cartridge bioreactors, were compared in long-term perfusion cultures. The results showed that steady-state cell concentration and antibody production, per liter of perfused medium per day, were similar when cells were either entrapped in alginate beads of maintained in suspension. These values were also similar whether cells were maintained at high density in a hollowfiber cartridge bioreactro, or at low density in suspension. This work points out that cell behavior and antibody yield are comparable overall in the various perfusion systems currently used. However, a significant reduction of antibody production appeared whenever a part of the viable cells was lost in the filtrate. The reduction was due both to a decrease of viable cell yield and a decline of lgM productivity on a percell basis. This result is well in agreement with the previously presented model of "grow or die" cell cycle system of hybridoma, which proposes that the ratio of arrested to proliferating cells in perfusion cultures, should be increased in proportion to cell retention in the bioreactor, with a concomitant increase of lgM productivity.     

Transient production of recombinant proteins by Chinese hamster ovary cells using polyethyleneimine/DNA complexes in combination with microtubule disrupting anti-mitotic agents

We have developed a simple and robust transient expression system utilizing the 25 kDa branched cationic polymer polyethylenimine (PEI) as a vehicle to deliver plasmid DNA into suspension-adapted Chinese hamster ovary cells synchronized in G2/M phase of the cell cycle by anti-mitotic microtubule disrupting agents. The PEI-mediated transfection process was optimized with respect to PEI nitrogen to DNA phosphate molar ratio and the plasmid DNA mass to cell ratio using a reporter construct encoding firefly luciferase. Optimal production of luciferase was observed at a PEI N to DNA P ratio of 10:1 and 5 mug DNA 10(6) cells(-1). To manipulate transgene expression at mitosis, we arrested cells in G2/M phase of the cell cycle using the microtubule depolymerizing agent nocodazole. Using secreted human alkaline phosphatase (SEAP) and enhanced green fluorescent protein (eGFP) as reporters we showed that continued inclusion of nocodazole in cell culture medium significantly increased both transfection efficiency and reporter protein production. In the presence of nocodazole, greater than 90% of cells were eGFP positive 24 h post-transfection and qSEAP was increased almost fivefold, doubling total SEAP production. Under optimal conditions for PEI-mediated transfection, transient production of a recombinant chimeric IgG4 encoded on a single vector was enhanced twofold by nocodazole, a final yield of approximately 5 microg mL(-1) achieved at an initial viable cell density of 1 x 10(6) cells mL(-1). The glycosylation of the recombinant antibody at Asn297 was not significantly affected by nocodazole during transient production by this method.     

The effects of microcarrier culture on recombinant CHO cells under biphasic hypothermic culture conditions

A Chinese hamster ovary (CHO) cell line, producing recombinant secreted human placental alkaline phosphatase (SEAP) was investigated under three different culture conditions (suspension cells, cells attached to Cytodex 3 and Cytopore 1 microcarriers) in a biphasic culture mode using a temperature shift to mild hypothermic conditions (33 °C) in a fed-batch bioreactor. The cell viability in both the suspension and the Cytodex 3 cultures was maintained for significantly longer periods under hypothermic conditions than in the single-temperature cultures, leading to higher integrated viable cell densities. For all culture conditions, the specific productivity of SEAP increased after the temperature reduction; the specific productivities of the microcarrier cultures increased approximately threefold while the specific productivity of the suspension culture increased nearly eightfold. The glucose and glutamine consumption rates and lactate and ammonia production rates were significantly lowered after the temperature reduction, as were the yields of lactate from glucose. However, the yield of ammonia from glutamine increased in response to the temperature shift.     

Regulated overexpression of the survival factor bcl-2 in CHO cells increases viable cell density in batch culture and decreases DNA release in extended fixed-bed cultivation

Using multicistronic expression technology we generated a stable Chinese hamster ovary (CHO) cell line (MG12) expressing a model secreted heterologous glycoprotein, the secreted form of the human placental alkaline phosphatase (SEAP), and bcl-2, best known as an apoptosis inhibitor, in a tetracycline-repressible dicistronic configuration. In batch cultivations in serum-containing medium, MG12 cells reached twice the final viable cell density when Bcl-2 was overexpressed (in the absence oftetracycline) compared to MG12 populations culturedunder tetracycline-containing conditions (bcl-2repressed). However, bcl-2-expressing MG12 cellsshowed no significant retardation of the decline phasecompared to batch cultures in which the dicistronicexpression unit was repressed.Genetic linkage of bcl-2 expression with the reporter protein SEAP in our multicistronic construct allowed online monitoring of Bcl-2 expression over an extended, multistage fixed-bed bioreactor cultivation. The cloned multicistronic expression unit proved to be stable over a 100 day bioreactor run. CHO MG12 cells in the fixed-bed reactor showed a drastic decrease in the release of DNA into the culture supernatant under conditions of reduced tetracycline (and hencederepressed SEAP and bcl-2 overexpression). This observation indicated enhanced robustness associated with bcl-2 overexpression, similar to recent findings for constitutive Bcl-2-overexpressing hybridoma cells under the same bioprocess conditions. These findings indicate, in these serum-containing CHO cell cultures, that overexpression of Bcl-2 results in desirable modifications in culture physiology.     

The response of virally infected insect cells to dissolved oxygen concentration: recombinant protein production and oxidative damage

The effects of dissolved oxygen (DO) concentration on virally infected insect cells were investigated in 3-L bioreactor culture. Specifically, cultures of Spodoptera frugiperda Sf-9 (Sf-9) and Trichoplusia ni BTI-Tn-5B1-4 (Tn-5B1-4) were infected with Autographa californica multiple nucleopolyhedrovirus expressing secreted alkaline phosphatase (SEAP). Following infection at a DO concentration of 50% air saturation, the DO concentration was adjusted to a final value of either 190%, 50%, or 10% air saturation. Recombinant SEAP production, cell viability, protein carbonyl content, and thiobarbituric acid reactive substances (TBARS) content were monitored. The increases in protein carbonyl and TBARS contents are taken to be indicators of protein oxidation and lipid oxidation, respectively. DO concentration was found to have no noticeable effect on SEAP production or cell viability decline in the Sf-9 cell line. In the Tn-5B1-4 cell line, cells displayed an increased peak SEAP production rate for 190% air saturation and displayed an increased rate of viability decline at increased DO concentration. Protein carbonyl content showed no significant increase in the Sf-9 cell line by 72 h postinfection (pi) at any DO concentration but showed a twofold increase at 10% and 50% DO concentration and a threefold increase at 190% DO concentration by 72 h pi in Tn-5B1-4 cells. TBARS content was found to increase by approximately 50% in Sf-9 cells and by approximately twofold in Tn-5B1-4 cells by 72 h pi with no clear relationship to DO concentration. It is hypothesized that oxygen uptake changes due to the viral infection process may bear a relation to the observed increases in protein and lipid oxidation and that lipid oxidation may play an important role in the death of virally infected insect cells.     

Influence of culture medium supplementation of tobacco NT1 cell suspension cultures on the N-glycosylation of human secreted alkaline phosphatase

We report for the first time that culture conditions, specifically culture medium supplementation with nucleotide-sugar precursors, can alter significantly the N-linked glycosylation of a recombinant protein in plant cell culture. Human secreted alkaline phosphatase produced in tobacco NT1 cell suspension cultures was used as a model system. Plant cell cultures were supplemented with ammonia (30 mM), galactose (1 mM) and glucosamine (10 mM) to improve the extent of N-linked glycosylation. The highest levels of cell density and active extracellular SEAP in supplemented cultures were on average 260 g/L and 0.21 U/mL, respectively, compared to 340 g/L and 0.4 U/mL in unsupplemented cultures. The glycosylation profile of SEAP produced in supplemented cultures was determined via electrospray ionization mass spectrometry with precursor ion scanning and compared to that of SEAP produced in unsupplemented cultures. In supplemented and unsupplemented cultures, two biantennary complex-type structures terminated with one or two N-acetylglucosamines and one paucimannosidic glycan structure comprised about 85% of the SEAP glycan pool. These three structures contained plant-specific xylose and fucose residues and their relative abundances were affected by each supplement. High mannose structures (6-9 mannose residues) accounted for the remaining 15% glycans in all cases. The highest proportion (approximately 66%) of a single complex-type biantennary glycan structure terminated in both antennae by N- acetylglucosamine was obtained with glucosamine supplementation versus only 6% in unsupplemented medium. This structure is amenable for in vitro modification to yield a more human-like glycan and could serve as a route to plant cell culture produced therapeutic glycoproteins.     

On-line estimation of viable cells in a hybridoma culture at various DO levels using ATP balancing and redox potential measurement

Two on-line methods for the estimation of viable cell number in hybridoma cultivation were investigated. One used an empirical correlation between redox potential and animal cell density. The other was based on an ATP balance with ATP steady-state assumption. Oxygen uptake rate measurement provided the amount of ATP which was produced by oxidation of NADH. Oxygen uptake rate was measured either by stationary liquid phase balance with surface aeration or by gas balance during bubble aeration with headspace flushing with an inert gas. The amount of ATP produced through the glycolysis was estimated based on the amount of lactate produced. In cultures, in which pH was controlled via manipulation of the gas phase composition, the flow of CO(2) was linearly correlated with the lactate concentration. At constant dissolved oxygen levels, the viable cell density was proportional to the estimated ATP production rate, during exponential growth and during later phases. The estimated specific ATP production rate, however, varied from 2.2 pmol cell(-1) h(-1) at 10% air saturation to 4.5 pmol cell(-1) h(-1) at 100% air saturation. Specific rates of glutamine, glucose, and lactate followed the shape of the specific ATP production rate, whereas the specific oxygen uptake rate was minimal at around 50% air saturation. (c) 1996 John Wiley & Sons, Inc.     

High cell density fed batch and perfusion processes for stable non-viral expression of secreted alkaline phosphatase (SEAP) using insect cells: comparison to a batch Sf-9-BEV system

The development of insect cells expressing recombinant proteins in a stable continuous manner is an attractive alternative to the BEV system for recombinant protein production. High cell density fed batch and continuous perfusion processes can be designed to maximize the productivity of stably transformed cells. A cell line (Sf-9SEAP) expressing high levels of the reporter protein SEAP stably was obtained by lipid-mediated transfection of Sf-9 insect cells and further selection and screening. The expression of the Sf-9SEAP cells was compared with the BEVS system. It was observed that, the yield obtained in BEVS was similar to the batch Sf-9SEAP at 8 and 7 IU/mL, respectively. The productivity of this foreign gene product with the stable cells was enhanced by bioprocess intensification employing the fed-batch and perfusion modes of culture to increase the cell density in culture. The fed batch process yielded a maximum cell density of 28 x 10(6) cells/mL and 12 IU/mL of SEAP. Further improvements in the productivity could be made using the perfusion process, which demonstrated a stable production rate for extended periods of time. The process was maintained for 43 days, with a steady-state cell density of 17-20 x 10(6) cells/mL and 7 IU/mL SEAP. The total yield obtained in the perfusion process (394 IU) was approximately 22 and 8 times higher than that obtained in a batch (17.6 IU) and fed batch (46.1 IU) process, respectively.     

Specific effects of synthetic oligopeptides on cultured animal cells

Synthetic oligopeptides, tri- to pentaglycine and tri- and tetraalanine, were found to enhance viable cell density and culture viability when applied at concentrations higher than milllimolar to the cultures of a model hybridoma line. Oligoalanines, in addition, enhanced monoclonal antibody yields. Oligoglycines promoted solely the cell growth, unless the batch culture was fed with a medium concentrate. Examination of the effects of various tripeptides composed of glycine, alanine, serine, threonine, lysine, and histidine showed that some of the peptides promoted the growth of the culture, while other peptides suppressed the growth and enhanced the monoclonal antibody yield. Determination of the levels of amino acids and peptides in culture media indicated that the observed changes of culture parameters were caused by intact peptide molecules, rather than by amino acids liberated from the peptides by enzymic cleavage.     

Optimization of monoclonal antibody production: combined effects of potassium acetate and perfusion in a stirred tank bioreactor

To increase the yield of monoclonal antibody in a hybridoma culture, it is important to optimize the combination of several factors including cell density, antibody productivity per cell, and the duration of the culture. Potassium acetate enhances the production of antibodies by cells but sometimes depresses cell density. The production of anti-(human B-type red blood cell surface antigen) antibody by Cp9B hybridoma was studied. In batch cultures, potassium acetate inhibited Cp9B cells growth and decreased the maximal cell density but the productivity of antibody per cell was increased. The balance of the two effects resulted in a slight decline of antibody production. In a stirred tank bioreactor, the inhibitory effect of potassium acetate on cell density was overcome by applying the perfusion technique with the attachment of a cell-recycling apparatus to the bioreactor. In such a reactor, potassium acetate at 1 g l^-1 did not cause a decrease in the cell density, and the antibody concentration in the culture supernatant was increased from 28 μg ml^-1 to 38 μg ml^-1. Potassium acetate also suppressed the consumption of glucose and the accumulation of lactate in batch cultures, but the glucose and lactate levels were kept stable by applying the perfusion technique in the stirred tank bioreactor. This revised version was published online in July 2006 with corrections to the Cover Date.     

Hyperosmotic hbridoma cell cultures: Increased monoclonal antibody production with addition of glycine betaine

When mouse hybridoma cells were grown in culture media which were made hyperosmotic through the addition of NaCl or sucrose, the specific rate of antibody production increased with medium osmolality, reaching approx. 1.9 times the level obtained at physiological osmolality. However, due to a simultaneous reduction of the maximal cell density in the hyperosmotic media, the effect of the increased production rate did not give significant increases in the maximum antibody titer obtained in the cultures. When the osmoprotective compound, glycine betaine, was included in the NaCl- or sucrose-stressed cultures, the specific antibody production rate wasincreased up to 2.6-fold and maximum antibody titer up to twofold over that obtained in the control culture (physiological osmolality). A similar pattern of response was observed when other osmoprotective compounds (sarcosine, proline, glycine) were added to NaCl-stressed hybridoma cell cultures. For the present experiments, the results suggest that medium osmolality, rather than growth rate, will determine the specific antibody production rate by hybridoma cell line 6H11 growing in hyperosmotic culture media. (c) 1994 John Wiley & Sons, Inc.     

Analysis of kinetic,stoichiometry and regulation of glucose and glutamine metabolism in hybridoma batch cultures using logistic equations

Batch cultures were carried out to study the kinetic, stoichiometry, and regulation of glucose and glutamine metabolism of a murine hybridoma line. Asymmetric logistic equations (ALEs) were used to fit total and viable cell density, and nutrient and metabolite/product concentrations. Since these equations were analytically differentiable, specific rates and yield coefficients were readily calculated. Asymmetric logistic equations described satisfactorily uncontrolled batch cultures, including death phase. Specific growth rate showed a Monod-type dependence on initial glucose and glutamine concentrations. Yield coefficients of cell and lactate from glucose, and cell and ammonium from glutamine were all found to change dramatically at low residual glucose and glutamine concentrations. Under stoichiometric glucose limitation, the glucose-to-cell yield increased and glucose-to-lactate yield decreased, indicating a metabolic shift. Under stoichiometric glutamine limitation the glutamine-to-cell and glutamine-to-ammonium yields increased, but also glucose-to-cell yield increased and the glucose-to-lactate yield decreased. Monoclonal antibody production was mainly non-growth associated, independently of glucose and glutamine levels.     

Characterization and fed-batch culture of hybridoma overexpressing apoptosis suppressing gene bcl-2

Mouse hybridoma 2E3 transfected with human bcl-2 gene survived longer with increasing expression level of bcl-2 when cultured in DME medium supplemented with 9% serum. One of the transfectants, 2E3BCMGbcl-2, overexpressed bcl-2 and could maintain viable cell density higher than the initial density for more than four days at a low 0.5% serum concentration. In comparison a mock transfectant 2E3BCMG remained viable for only one day. However, both hybridomas died out within a day in serum-free medium. These results suggested that bcl-2 needed a small amount of some serum components to suppress apoptosis of the hybridoma. Overexpression of bcl-2 also suppressed apoptosis of the hybridoma induced by glutamine deprivation. When hybridoma 2E3BCMGbcl-2 was inoculated in DME medium supplemented with 9% serum and cultured for 10 d with additional 2% serum feed at day 4 of the culture, viable cell density increased 2-fold and antibody produced 3-fold, in comparison with mock transfected 2E3 cultured in the same manner. The mock transfectant with additional feed of serum at day 4 of the culture showed no difference in viable cell density and antibody production. These results suggested that the mock transfectant committed to apoptosis before day 4 of the culture and the additional serum at day 4 could not reverse the commitment. This revised version was published online in July 2006 with corrections to the Cover Date.     

Overexpression of bcl-2, apoptosis suppressing gene: Prolonged viable culture period of hybridoma and enhanced antibody production

Human bcl-2 DNA was introduced into mouse hybridoma 2E3 cells and expressed at a high level by using BCMGSneo vector, which reportedly amplifies as multiple copies in the cells independently of their chromosomes. The high expression of bcl-2 in BCMGSneo-bcl-2 transfectants was confirmed by western blotting. In batch cultures, the overexpression of bcl-2 raised the maximum viable cell density by 45%, delayed the initiation of apoptosis by 2 days, and prolonged the viable culture period by 4 days. The delayed initiation of apoptosis was detected by emergence of the ladder pattern on DNA electrophoresis and increase of the dead cell number. The bcl-2 transfectants produced lgG(1) fourfold per batch culture in comparison with 2E3 cells transfected with BCMGSneo but not with bcl-2: a little less than twofold due to the improved survival of the cells and more than twofold due to the enhanced lgG(1) production rate per cell of the bcl-2 transfectants. The method to engineer hybridoma cells genetically with bcl-2 using BCMGSneo vector for increasing viability and productivity would be widely applied for improving antibody productivity of hybridoma cultures. (c) 1995 John Wiley & Sons, Inc.     

An investigation of cell density effects on hybridoma metabolism in a homogeneous perfusion reactor

In this work, metabolite and antibody production kinetics of hybridoma cultures were investigated as a function of cell density and growth rate in a homogeneous perfusion reactor. Hydrophilized hollow fiber polypropylene membranes with a pore size of 0.2 m were used for medium perfusion. Oxygen was supplied to the cells through thin walled silicone tubing. The mouse-mouse hybridoma cells were grown in three identical bioreactors at perfusion rates of 1.1, 2.0, and 3.2/day for a period of eight days during which the viable cell concentrations reached stable values of 2.6×10⁶, 3.5×10⁶, and 5.2×10⁶ cells/ml, respectively. Total cell densities reached values ranging from 8×10⁶ to 1×10⁶ cells/ml. Specific substrate consumption and product formation rates responded differently to changes in cell density and apparent specific growth rate, which were not varied independently. Using multiple regression analysis, the specific glucose consumption rate was found to vary with viable cell density while the specific glutamine uptake and lactate production rates varied with both viable cell density and apparent specific growth rate. These results suggest that cell density dictates the rate of glucose consumption while the cell growth rate influences how glucose is metabolized, i.e., through glycolysis or the TCA cycle. The specific antibody production rate was found to be a strong function of cell density, increasing as cell density increased, but was essentially independent of the specific growth rate for the cell line under study.List of Symbols MAb monoclonal antibody - X _v viable cell density (cells/ml) - X _d nonviable cell density (cells/ml) - specific growth rate (1/day) - k _d specific death rate (1/day) - D dilution rate (1/day) - S _f substrate concentration in feed (g/l or mM) - S substrate concentration (g/l or mM) - P _f product concentration in feed (g/l or g/ml) - P product concentration (g/l or ug/ml) - q _s specific consumption rate of substrate (g/hr/cell or mmol/hr/cell) - q _p specific production rate of product (g/hr/cell) - q _MAb specific production rate of monoclonal antibody (g/hr/cell) This work was supported in part by a grant for the National Science Foundation (BCS-9157851) and by matching funds from Merck and Monsanto. We sincerely thank Mr. Roland Buchele of Akzo Inc. (Germany) for donation of the polypropylene membranes, Dr. Michael Fanger (Dartmouth Medical School) for the hybridoma cell line, Dr. Sadettin Ozturk (Verax Corp., Lebanon, NH) for technical discussions regarding reactor design, and Dr. Derrick Rollins (Iowa State University) for advice on statistical methods.     

Diverse effects of the cyclin-dependent kinase inhibitor bohemine: Concentration- and time-dependent suppression or stimulation of hybridoma culture

An analog of aromatic cytokinins, the 2,6,9-trisubstituted purine derivative bohemine, was applied to cultures of mouse hybridoma cells in order to analyze its capacity of suppressing cell growth and maintaining or enhancing the production of monoclonal antibody. Addition of bohemine at concentrations in the range of1–10 μM resulted in a short-term arrest of growth and of monoclonal antibody production. The short-term suppression of cell functions was followed by a significant temporary increase of specific growth rate and of specific production rate. The steady-state viable cell density values, found in semicontinuous cultures, showed a certain stimulation of cell growth in the range of micromolar concentrations of bohemine, and inhibition of growth at 10 and 30 μM concentrations. The profiles of cell cycle phases indicated that hybridoma cells are retarded both at the G₁/S boundary and at the G₂/M boundary, depending on bohemine concentration. The existence of the sequence of events,from suppression to stimulation, suggests that bohemine probably modulates more than one regulatory pathway in the cell. This revised version was published online in July 2006 with corrections to the Cover Date.     

Effect of Trichoplusia ni BTI-Tn 5B1-4 cell density on human secreted alkaline phosphatase production

Summary The effect of Tn 5B1-4 cell density at infection on the production of human secreted alkaline phosphatase (SEAP) was investigated using a split-flow air-lift bioreactor. Volumetric productivities of SEAP were highest when Tn 5B1-4 cells were infected at about 3 × 10⁵ cells/cm². Cell-to-cell contact inhibition is an important factor responsible for the reduced protein production at high cell densities. Other factors such as oxygen or nutrient limitation, or build up of metabolic inhibitors do not appear to be as important.     

Comparative recombinant protein production of eight insect cell lines

Summary A recombinantAutographa californica baculovirus expressing secreted alkaline phosphatase (SEAP) gene was used to evaluate the expression of a secreted glycoprotein in eight insect cell lines derived fromSpodoptera frugiperda, Trichoplusia ni, Mamestra brassicae andEstigmene acrea. Because cell density was found to influence protein production, SEAP production was evaluated at optimal cell densities for each cell line on both a per cell and per milliliter basis. On a per cell basis, theT. ni-derived BTI-TN-5B1-4 cells produced a minimum of 20-fold more SEAP than theS. frugiperda-derived Sf9 or Sf21 cell lines and a minimum of 9-fold more than any of the other cell lines growing in serum-containing medium. On a per milliliter basis, BTI-TN-5B1-4 cells produced a minimum of fivefold more SEAP than any of the other cell lines tested. Using cell lines that were adapted to serum-free medium, SEAP yields were the same or better than their counterparts in serum-containing medium. At 3 days postinoculation, extracellular SEAP activity ranged from 59 to 85% of total SEAP activity with cell lines grown in serum-free and serum-containing media.