耐铵型产琥珀酸放线杆菌的选育及铵离子对其生长代谢的影响

经硫酸二乙酯(DES)诱变,在含61～242mmol/LNH4+梯度平板中,筛选到一株耐铵型突变株YZ25,该菌株在含121mmol/LNH4+发酵培养基中,琥珀酸产量达32.68g/L,转化率为65.4%,比出发菌提高了180.5%。进一步考察了不同形态铵盐对YZ25生长的影响,结果表明添加少量铵盐能够提高突变菌的生长速率,但当超过一定量后菌株生长受到抑制,不同铵盐对菌株的抑制程度不同,硫酸铵、碳酸氢铵、氯化铵和硝酸铵对突变株YZ25的半抑制浓度分别为:215mmol/L、265mmol/L、235mmol/L、210mmol/L。为了考察铵离子对YZ25发酵产琥珀酸的影响过程,在3.0L发酵罐以氨水作为pH的调控剂发酵,结果表明在稳定期前菌株生长基本不受铵离子抑制,生物量能够达到正常水平,但是进入稳定期后铵离子抑制作用越来越明显,导致菌株生长提前结束,耗糖不完全,产酸受阻。最后结合产琥珀酸放线杆菌Actinobacillus succinogenes代谢途径分析了铵离子对菌株抑制作用的机理。     

响应面优化产琥珀酸放线杆菌生产丁二酸

丁二酸是一种重要的C4化合物平台,可以合成一系列重要化合物。文中对产琥珀酸放线杆菌Actinobacillus succinogenes GXAS137发酵生产丁二酸培养基成分进行优化。通过单因素和Plackett-Burman试验设计筛选出影响丁二酸发酵的重要参数,采用最陡爬坡实验逼近最大丁二酸生产区域后,利用Box-Behnken设计确定重要参数的最佳水平。筛选结果表明,影响丁二酸产量的重要参数是葡萄糖、酵母提取物和碱式碳酸镁浓度。最佳条件为(g/L)：葡萄糖70.00,酵母提取物9.20,碱式碳酸镁58.10。优化后丁二酸产量达到47.64 g/L。与初始条件 (36.89 g/L) 相比,丁二酸浓度提高了30 %。在最佳工艺条件下得到的试验结果与模型预测值很吻合,说明建立的模型是有效的。     

耐铵型产琥珀酸放线杆菌的选育

以Actinobacillus succinogenes NJ113为出发菌株,经硫酸二乙酯(DES)诱变,在含8～20 g/L硫酸铵平板中筛选到一株耐铵型突变株YZ25,该菌株在含8 g/L硫酸铵培养基中厌氧发酵,琥珀酸产量达32.68 g/L,比出发菌提高了180.5%,对葡萄糖收率达65.4%,副产物乙酸、甲酸产量分别下降3.5%、28.7%,琥珀酸/乙酸比值由0.63提高到2.5。在7.5 L发酵罐中,用氨水调节pH分批实验,发酵34 h琥珀酸产量达27.13 g/L,较出发菌株提高了85.3%。     

琥珀酸放线杆菌发酵培养基的优化

对琥珀酸放线杆菌(Actinobacillus succinogenes)CGMCC1593发酵产生琥珀酸培养基的主要成分,及其含量进行优化。通过单因素试验,得出发酵培养基中葡萄糖、酵母膏和玉米浆的含量对产生琥珀酸有显著影响;采用响应面法(RSM),得出多元二次回归方程拟合的三种因素与琥珀酸含量间的函数关系,并根据优化结果与实验,CGMCC1593产琥珀酸达到41.69g/L。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

环境因素对琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593发酵生产丁二酸的影响

琥珀酸放线杆菌是发酵生产有应用前景的生物基原料-丁二酸的微生物。本研究室从牛瘤胃中筛选获得一株琥珀酸放线杆菌Actinobacillus succinogenes CGMCC 1593, 分析了环境气体、pH、氧化还原电位(ORP)环境因素对琥珀酸放线杆菌A. succinogenes CGMCC 1593发酵生产丁二酸的影响。结果表明: CO2不仅提供了A. succinogenes CGMCC 1593发酵生产丁二酸的最佳气体环境, 也是发酵生产丁二酸的底物之一; MgCO3是A. succinogenes CGMCC 1593发酵过程较好的pH调节剂, 发酵过程维持pH7.1~6.2, 可满足菌体生长与产酸的要求; 发酵液初始ORP过低, 不利于菌体生长, ORP在-270 mV时对丁二酸产生有利。在菌体对数生长期结束时, 通过Na2S·9H2O降低发酵液ORP到-270 mV, 发酵48 h时可产丁二酸37 g/L, 摩尔产率达到129%。这对深入研究A. succinogenes CGMCC 1593发酵生产丁二酸具有参考价值。     

不同pH调节剂对产琥珀酸放线杆菌NJ113发酵产丁二酸的影响

在3L发酵罐中分别采用不同的碱性物质作为pH调节剂,考察其对产琥珀酸放线杆菌Actinobacillus succinogenes NJ113厌氧发酵制备丁二酸的影响。结果表明:Ca2+、NH4+调节剂对菌体生长代谢有较大阻碍作用,丁二酸产量较低;采用含Na+调节剂,在发酵中后期菌体出现絮凝现象严重,且产丁二酸能力骤降;采用含Mg2+调节剂,整个发酵过程菌体代谢旺盛,发酵效果较佳。根据各碱性物质的调节能力以及对菌体生长代谢的影响,选择NaOH、Mg(OH)2和Na2CO3、Mg(OH)2分别作为混合碱组分调节pH,并对两组混合碱中各物质的质量比例进行优化。结果表明,以NaOH、Mg(OH)2混合,两者质量比为1:1时,发酵效果最好,丁二酸质量浓度高达到69.8g/L,质量收率74.5%。该种混合碱配比可有效替代碱式MgCO3调节pH,既达到高产丁二酸的目的,又可降低生物制备丁二酸的成本。     

Actinobacillus succinogenes 130Z厌氧发酵产丁二酸条件初步研究

对Actinobacillus succinogenes130Z厌氧发酵产丁二酸的培养条件进行了初步研究。研究了不同有机氮源,不同碳、氮源浓度配比、CO2供体、培养温度,培养基起始pH值对菌株生长和产酸的影响,并在5 L发酵罐中进行了放大试验。结果表明最佳培养基配方为(g/L):葡萄糖10,酵母膏5,NaHCO310,Na2HPO40.3,NaH2PO4.2H2O 9.6,K2HPO43,MgCl20.2,MnCl20.2,NaCl 0.1;pH7.0。在最佳条件下,血清瓶37℃培养24 h,丁二酸产量达到8.3 g/L,在5 L发酵罐中培养,葡萄糖质量浓度分别为10和100 g/L时,丁二酸产量分别达到8.2和45.6 g/L,收率分别为80%和65%。     

发酵法生产丁二酸的化学合成培养基的筛选

以产琥珀酸放线杆菌Actinobacillus succinogenes NJ113 为出发菌株,针对该菌株筛选出含有关键生长因子的化学合成培养基,其关键因子为谷氨酸（Glu）、蛋氨酸（Met）和生物素（VH）和烟酸（VPP）。结合原发酵培养基中的磷酸缓冲盐成分,最终得到的化学合成培养基配方（g/L）： CH3COONa 1.36,NaCl 1.0,MgCl2 0.2,CaCl2 0.2,Na2HPO4 0.31,NaH2PO4 1.6, KH2PO4 3,NH4HCO3 1.57,Glu 0.87,Met 0.11,VH 0.010,VPP 0.025。在3 L发酵罐上进行验证实验,50 g/L初始葡萄糖发酵70 h,丁二酸的质量浓度为45.2 g/L,丁二酸收率达到90.4%。与之前的半合成培养基发酵制备丁二酸相比,丁二酸的收率提高了25.2%,副产物也有很大幅度的减少。     

产琥珀酸放线杆菌发酵生产琥珀酸的研究进展

近年来,因瘤胃微生物产琥珀酸放线杆菌Actinobacillus succinogenes具有高的琥珀酸产量,并能够利用多种碳源进行发酵等优点,在利用发酵法生产琥珀酸领域具有广泛的应用前景和商业化价值,因而其代谢途径和发酵工艺等基础研究成为国内外研发的热点。近年来,人们在产琥珀酸放线杆菌的代谢途径、琥珀酸发酵动力学模型、新型经济培养基以及高产菌株选育等方面的研究取得了很大进展,对研发琥珀酸发酵工艺、降低生产成本和节能减耗等具有重要的理论意义。     

基因组改组技术选育耐酸性琥珀酸放线杆菌

以琥珀酸产生菌Actinobacillus succinogenes CGMCC 1593为出发菌,分别经过紫外线-甲基磺酸乙酯(UV-EMS)和紫外线-硫酸二乙酯(UV-DES)诱变处理,得到7株耐酸性有所提高的突变株.以此作为候选菌库,经3轮原生质体递进融合,筛选获得4株可以在pH 5.6下生长的改组菌株.其中改组菌株F3-21在pH 5.6的完全液体培养基中生长的OD值是原始菌的7倍,在pH 5.2条件下仍能生长;其摇瓶发酵48h琥珀酸产量较原始菌株提高48%.在5L发酵罐中进行分批发酵,当控制pH在较低值(5.6～6.0)时,F3-21厌氧发酵48h积累琥珀酸38.1g/L,较出发菌株提高了45%;当控制pH在6.5～7.0时,F3-21厌氧发酵32h积累琥珀酸40.7g/L.F3-21在5L发酵罐中进行补料分批发酵,厌氧发酵72h,产琥珀酸达67.4g/L.结果说明基因组改组技术能够改进琥珀酸放线菌的耐酸性能及其琥珀酸的产量.     

A complete industrial system for economical succinic acid production by Actinobacillus succinogenes

An industrial fermentation system using lignocellulosic hydrolysate, waste yeast hydrolysate, and mixed alkali to achieve high-yield, economical succinic acid production by Actinobacillus succinogenes was developed. Lignocellulosic hydrolysate and waste yeast hydrolysate were used efficiently as carbon sources and nitrogen source instead of the expensive glucose and yeast extract. Moreover, as a novel method for regulating pH mixed alkalis (Mg(OH)₂ and NaOH) were first used to replace the expensive MgCO₃ for succinic acid production. Using the three aforementioned substitutions, the total fermentation cost decreased by 55.9%, and 56.4 g/L succinic acid with yield of 0.73 g/g was obtained, which are almost the same production level as fermentation with glucose, yeast extract and MgCO₃. Therefore, the cheap carbon and nitrogen sources, as well as the mixed alkaline neutralize could be efficiently used instead of expensive composition for industrial succinic acid production.     

外源添加代谢中间体对产琥珀酸放线杆菌厌氧发酵制备丁二酸的影响

考察了外源添加中间代谢产物对菌体生长及发酵产酸的影响,结果表明添加0.5g/L磷酸烯醇式丙酮酸(PEP)时丁二酸产量最高。围绕产琥珀酸放线杆菌NJ113厌氧发酵产丁二酸的代谢网络进行代谢通量分析,发现添加PEP后己糖磷酸途径(HMP)与糖酵解途径(EMP)的通量比由39.4∶60.3提高至76.8∶22.6,解决了丁二酸合成过程中还原力不足的矛盾,导致PEP生成草酰乙酸的通量提高了23.8%,丁二酸代谢通量从99.8mmol/(gDCW·h)增至124.4mmol/(gDCW·h),而副产物乙酸及甲酸的代谢通量分别降低了22.9%、15.4%;关键酶活分析结果表明,添加0.5g/LPEP后PEP羧化激酶比酶活达到1910U/mg,与对照相比提高了74.7%,而丙酮酸激酶的比酶活降低了67.5%。最终丁二酸浓度为29.1g/L,收率达到76.2%,比未添加PEP时提高了11.0%。     

产琥珀酸放线杆菌的原生质体制备与再生

基因组重组技术是一项重要的菌种改造技术,原生质体制备和再生是进行基因组重组的前提和基础。目前少有关于产琥珀酸放线杆菌(Actinobacillus succinogenes)CGMCC2650原生质体研究的报道。为了优化该菌的原生质体制备和再生条件,及利用基因组重组技术构建优良菌种提供参考,研究了甘氨酸预处理,菌龄,酶浓度,作用时间,温度对产琥珀酸放线杆菌原生质体制备和再生的影响,并考察了不同渗透压稳定剂对其再生的影响。结果表明,菌体在添加了0.6mg/ml甘氨酸的TSB培养基中培养5h后收集,用SMM稀释到OD660=1.0,用0.025mg/ml溶菌酶在37℃下酶解45min制备原生质体,将原生质体涂布于含0.3mol/L蔗糖的再生培养基中,再生率最大,达到40.9%。确定了产琥珀酸放线杆菌原生质体制备和再生的最佳条件,所用的原生质体制备的方法对琥珀酸的产生没有影响,这为进一步开展该菌的原生质体诱变及基因组重组等研究奠定了基础。     

Economical succinic acid production from cane molasses by Actinobacillus succinogenes

In this work, production of succinic acid by Actinobacillus succinogenes CGMCC1593 using cane molasses as a low cost carbon source was developed. In anaerobic bottles fermentation, succinic acid concentration of 50.6+/-0.9 g l(-1) was attained at 60 h using an optimum medium containing molasses pretreated with sulfuric acid, resulting in a succinic acid yield of 79.5+/-1.1% and sugar utilization of 97.1+/-0.6%. When batch fermentation was carried out in a 5-l stirred bioreactor with pretreated molasses, 46.4 g l(-1) of succinic acid was attained at 48 h and faster cells growth was also observed. Fed batch fermentation was performed to minimize the substrate (sugar) inhibition effect, giving 55.2 g l(-1) of succinic acid and 1.15 g l(-1)h(-1) of productivity at 48 h. The present study suggests that the inexpensive cane molasses could be utilized for the economical and efficient production of succinic acid by A. succinogenes.     

氧化还原电位对Actinobacillus succinogenes厌氧发酵生产丁二酸的影响

为提高琥珀酸放线菌Actinobacillus succinogenes CGMCC1593厌氧发酵产丁二酸的水平。研究了以葡萄糖为C源,发酵液中不同氧化还原电位（VORP）对A．succirtogenes CGMCC1593生长和代谢产物分布的影响。结果表明：菌体生长和丁二酸积累的较佳VORP分别为-220mV和-270mV;利用代谢流分析法,比较VORP在-220mV和-270mV时发酵对数生长期（8h）和稳定期（20h）的代谢通量分布,以及发酵过程中磷酸烯醇式丙酮酸（PEP）、丙酮酸（Pyr）节点,NADH通量分配的变化,由此得出在VORP为-270mV时,NADH总通量和丁二酸方向代谢通量增幅明显。在发酵过程中,通过降低VORP至-270mV,使丁二酸的产率从70％提高到85％。     

Fermentative production of succinic acid from straw hydrolysate by Actinobacillus succinogenes

In this work, straw hydrolysates were used to produce succinic acid by Actinobacillus succinogenes CGMCC1593 for the first time. Results indicated that both glucose and xylose in the straw hydrolysates were utilized in succinic acid production, and the hydrolysates of corn straw was better than that of rice or wheat straw in anaerobic fermentation of succinic acid. However, cell growth and succinic acid production were inhibited when the initial concentration of sugar, which was from corn straw hydrolysate (CSH), was higher than 60 g l^?1. In batch fermentation, 45.5 g l^?1 succinic acid concentration and 80.7% yield were attained after 48 h incubation with 58 g l^?1 of initial sugar from corn straw hydrolysate in a 5-l stirred bioreactor. While in fed-batch fermentation, concentration of succinic acid achieved 53.2 g l^?1 at a rate of 1.21 g l^?1 h^?1 after 44 h of fermentation. Our work suggested that corn straw could be utilized for the economical production of succinic acid by A. succinogenes.     

Adaptive evolution improves acid tolerance and succinic acid production in Actinobacillus succinogenes

Fermentation at low pH is an efficient way to improve the competitiveness of biological succinic acid-producing process. Actinobacillus succinogenes shows good performance of succinic acid production under anaerobic conditions, but its succinic acid production capability at the low-pH is inefficient due to the poor acid resistance. Herein, a mutant A. succinogenes BC-4 with improved cell growth and succinic acid production under weak acid conditions was obtained by adaptive evolution. The specific growth rate and succinic acid production of BC-4 reached 0.13 g/L/h and 20.77 g/L, which were increased by 3.25- and 2.95- fold, respectively compared with the parent strain under anaerobic condition at pH 5.8. The activities of specific enzymes with ATP generation were significantly enhanced under weak acidic conditions, resulting in 1.28-fold increase in the maximum ATP level. Membrane fatty acid composition analysis demonstrated that the ratio of saturated to unsaturated fatty acids was decreased from 1.62 to 1.44 in mutant BC-4, leading to improved intracellular pH homeostasis. Furthermore, the change from long-chain to median-chain fatty acid might lower the permeability of H⁺ into cytoplasm for survival under acid stress. These results indicated that A. succinogenes BC-4 is a promising candidate for succinic acid production under weak acid condition.     

Bioreactors for succinic acid production processes

Succinic acid (SA) has been recognized as one of the most important bio-based building block chemicals due to its numerous potential applications. Fermentation SA production from renewable carbohydrate feedstocks can have the economic and sustainability potential to replace petroleum-based production in the future, not only for existing markets, but also for new larger volume markets. Design and operation of bio-reactors play a key role. During the last 20 years, many different fermentation strategies for SA production have been described in literature, including utilization of immobilized biocatalysts, integrated fermentation and separation systems and batch, fed-batch, and continuous operation modes. This review is an overview of different fermentation process design developed over the past decade and provides a perspective on remaining challenges for an economically feasible succinate production processes. The analysis stresses the idea of improving the efficiency of the fermentation stage by improving bioreactor design and by increasing bioreactor performance.