An energetic model for oxygen-limited metabolism

Microbial production of 2,3-butanediol by Klebsiella oxytoca occurs under conditions of an oxygen limitation. The extent to which substrate is oxidized to 2,3-butanediol and its coproducts, (acetic acid, acetoin, and ethanol) and the relative flow rates of substrate to energetic and biosynthetic pathways are controlled by the degree of oxygen limitation. Two energetic relationships which describe the response to an oxygen limitation have been derived. The first relationship describes the coupling between growth and energy production observed under oxygen-limited conditions. This allows calculation of energetic parameters and modeling of the cell mass and substrate profiles in terms of the degree of oxygen limitation only. The second relationship describes the average degree of oxidation and the rate of the end-product flow. The model has been tested with both batch and continuous culture. During these kinetic studies, two phases of growth have been observed: energy-coupled growth, which was described above; and, energy-uncoupled growth, which arises when the degree of oxygen limitation reaches a critical value. Optimal culture performance with respect to 2,3-butanediol productivity occurs during energy-coupled growth. (c) 1993 John Wiley & Sons, Inc.     

Control of respiration and metabolism in growing Klebsiella aerogenes. The role of adenine nucleotides

1. A rapid-sampling technique was used to obtain perchloric acid extracts of cells growing in a chemostat culture, so that meaningful values for ATP content could be obtained in spite of the fact that the turnover time for the total ATP content was about 1sec. 2. For steady-state growth, it was found that, in a glucose-limited chemostat culture, the ATP/ADP concentration ratio was approximately constant with changes in dissolved-oxygen tensions above the critical value, but fell when the culture was grown under oxygen-limited conditions and was at a minimum in anaerobically grown cultures. The steady-state ATP content was lower in cells growing under nitrogen-limited conditions with glucose in excess than in glucose-limited cells. The steady-state ATP content was independent of growth rate at growth rates over 0.1hr.(-1). 3. When the respiration rate of the cells was stimulated by lowering the oxygen tension the ATP content did not increase, indicating either an increased turnover rate of ATP or a fall in the P/O ratio. The sudden addition of extra glucose or succinate to a glucose-limited culture increased the respiration rate of the cells, but the ATP content quickly returned to the steady-state value after initial perturbations. This control over ATP content is explained in terms of regulation by adenine nucleotides of the catabolism and anabolism of glucose. An exception to this control over ATP content was found when the respiration rate was stimulated by addition of an antifoam.     

Utilization of poly-β-hydroxybutyrate in free-living cultures of Rhizobium ORS571

Abstract The effect of carbon starvation on growth and poly-β-hydroxybutyrate (PHB) utilization in oxygen-limited chemostat cultures of Rhizobium ORS571 was studied. Under oxygen-limited growth conditions PHB was not degraded. When in a nitrogen-fixing oxygen-limited culture, after stopping the medium supply, the dissolved oxygen concentration was maintained at 10 μM, a slow breakdown of PHB was observed. Addition of ammonia and air to a nitrogen-fixing oxygen-limited culture after the medium supply had been stopped, resulted in the simultaneous utilization of PHB and succinate. The possible use of the energy derived from PHB degradation in Rhizobia bacteria and bacteroids is discussed.     

Energy metabolism and ATP balance in animal cell cultivation using a stoichiometrically based reaction network

A metabolic reaction network is developed for the estimation of the stoichiometric production of adenosine triphosphate (ATP) in animal cell culture. By using the material balance data from fed-batch and batch cultures of hybridoma cells, the stoichiometric ATP productions are determined with estimated effective P/O ratios of 2 for NADH and 1.2 for FADH(2). A significant percentage of the ATP requirement (16-41%) in hybridoma cells is generated directly from free energy release without the participation of oxygen. The oxidative phosphorylation of NADH accounts for about 60% of the total ATP production in the fed-batch cultures and about 47% in the batch culture. The oxidative phosphorylation of FADH(2) accounts for less then 20% of the total ATP production in all cases.A fractional model is devised to analyze the contribution of each nutrient to the ATP production. Results show that a majority of the ATP is produced from glucose metabolism (60-76%). Less than 30% of the ATP is derived from glutamine, and less than 11% is derived from other essential amino acids. The analysis also shows that the glycolytic pathway generates more ATP in the batch (41%) than in the fed-batch (<27%) cultures. The TCA cycle provides 51-68% of the total ATP production. The calculated stoichiometric oxygen consumption differs among the batch and fed-batch cultures, depending on the glucose concentration. This result suggests that the relationship between the oxygen uptake rate (OUR) and cell growth may change with the culture conditions. However, the calculated respiratory quotient (RQ) is relatively constant in all cases.A linear relationship is obtained between the specific ATP production rate and the specific cell growth rate. The maximum ATP yield and the maintenance ATP requirement are determined based on this linear relationship. The biosynthetic ATP demand estimated from the dry cell weight and cell composition is significantly lower than that calculated from the maximum ATP yield, indicating that the non-growth-associated ATP demand may contain other factors than what is considered in the estimation of the biosynthetic ATP demand. (c) 1996 John Wiley & Sons, Inc.     

Transient responses of hybridoma cells to nutrient additions in continuous culture: I. Glucose pulse and step changes

Glucose and glutamine are the main nutrients used by mammalian cells in culture. Each provides unique biosynthetic precursors but are complementary for production of other metabolites and energy. The transient and steady-state responses of hybridoma growth and metabolism to glucose pulse and step changes have been examined. Metabolic quotients are reported for oxygen, glucose, lactate, ammonia, glutamine, alanine, and other amino acids. The glucose consumption rate increased by 100-200% immediately after glucose was added to the reactor, and the increased glycolytic ATP production appears to be responsible for the concurrent rapid decrease in the oxygen consumption rate. The effects on glutamine consumption were delayed, probably due to buffering by the TCA cycle and interrelated pathways. A period of increased biosynthetic activity, as evidenced by an increase in the estimated specific ATP production rate and lower by-product yields from glutamine, preceded the increase in cell concentration after the glucose step change. The biosynthetic yield of cells from ATP was calculated, and it was estimated that maintenance accounted for about 60% of the energy used by the cells at a specific growth rate of 0.66 day(-1). The estimated 22% ATP production due to glycoysis was twice as great as that before the step change.     

Influence of oxygen availability on physiology, verocytotoxin expression and adherence of Escherichia coli O157

A strain of Escherichia coli serotype O157 was grown in steady state chemostat culture under aerobic, oxygen-limited and anaerobic conditions. The growth and metabolic efficiency of oxygen-limited and anaerobic cultures was impaired, with biomass yield and the molar growth yield for glucose, Yglucose, reduced markedly in comparison with aerobic cultures. Steady state cells were typically short rods 2-3 microns long, and were encapsulated by a layer of extracellular material. The majority of cells were non-flagellated and fimbriae were not observed. Chemostat-grown cells were significantly more adhesive for HEp-2 monolayers than cells grown in aerobic batch culture. Furthermore, oxygen-limited and anaerobic cultures were significantly more adhesive for Hep-2 cells when compared with cells grown in aerobic chemostat culture, possibly reflecting increased pathogenicity associated with the induction of novel adhesins. Type 1 pili were not responsible for increased adherence. Verocytotoxins, VT1 and VT2, were expressed constitutively and were not influenced by oxygen availability. This study demonstrates that E. coli O157 is a versatile micro-organism, which responds to environmental conditions likely to be encountered during infection by inducing a phenotype which is more adhesive for human epithelial cells.     

The role of oxygen limitation in the formation of poly-β-hydroxybutyrate during batch and continuous culture of Azotobacter beijerinckii

Azotobacter beijerinckii was grown in ammonia-free glucose-mineral salts media in batch culture and in chemostat cultures limited by the supply of glucose, oxygen or molecular nitrogen. In batch culture poly-beta-hydroxybutyrate was formed towards the end of exponential growth and accumulated to about 74% of the cell dry weight. In chemostat cultures little poly-beta-hydroxybutyrate accumulated in organisms that were nitrogen-limited, but when oxygen limited a much increased yield of cells per mol of glucose was observed, and the organisms contained up to 50% of their dry weight of poly-beta-hydroxybutyrate. In carbon-limited cultures (D, the dilution rate,=0.035-0.240h(-1)), the growth yield ranged from 13.1 to 19.8g/mol of glucose and the poly-beta-hydroxybutyrate content did not exceed 3.0% of the dry weight. In oxygen-limited cultures (D=0.049-0.252h(-1)) the growth yield ranged from 48.4 to 70.1g/mol of glucose and the poly-beta-hydroxybutyrate content was between 19.6 and 44.6% of dry weight. In nitrogen-limited cultures (D=0.053-0.255h(-1)) the growth yield ranged from 7.45 to 19.9g/mol of glucose and the poly-beta-hydroxybutyrate content was less than 1.5% of dry weight. The sudden imposition of oxygen limitation on a nitrogen-limited chemostat culture produced a rapid increase in poly-beta-hydroxybutyrate content and cell yield. Determinations on chemostat cultures revealed that during oxygen-limited steady states (D=0.1h(-1)) the oxygen uptake decreased to 100mul h(-1) per mg dry wt. compared with 675 for a glucose-limited culture (D=0.1h(-1)). Nitrogen-limited cultures had CO(2) production values in situ ranging from 660 to 1055mul h(-1) per mg dry wt. at growth rates of 0.053-0.234h(-1) and carbon-limited cultures exhibited a variation of CO(2) production between 185 and 1328mul h(-1) per mg dry wt. at growth rates between 0.035 and 0.240h(-1). These findings are discussed in relation to poly-beta-hydroxybutyrate formation, growth efficiency and growth yield during growth on glucose. We suggest that poly-beta-hydroxybutyrate is produced in response to oxygen limitation and represents not only a store of carbon and energy but also an electron sink into which excess of reducing power can be channelled.     

透明颤菌血红蛋白基因调控与功能的研究

透明颤菌(Vitreoscila)血红蛋白(VHB)是一种氧调节、氧结合蛋白。其基因(vgb)已被克隆及表达。Vgb基因表达在转录水平上受氧控制．FNR蛋白作为厌氧激活于介入该调节过程。VHb可与氧结合参与细胞代谢过程,使细胞适应贫氧环境。Vgb基因的氧调控启动子和VHb蛋白的生理功能在基因工程和发酵工程具有良好的应用前景。     

Xylose metabolism in Debaryomyces hansenii UFV-170. Effect of the specific oxygen uptake rate

The new yeast Debaryomyces hansenii UFV-170 was tested in this work in batch experiments under variable oxygenation conditions. To get additional information on its fermentative metabolism, a stoichiometric network was proposed and checked through a bioenergetic study performed using the experimental data of product and substrate concentrations. The yeast metabolism resulted to be practically inactive under strict oxygen-limited conditions (qO2 = 12.0 mmol(O2) C-mol(DM)(-1) h(-1)), as expected by the impossibility of regenerating NADH2+. Significant fractions of the carbon source were addressed to both respiration and biomass growth under excess oxygen levels (qO2 > or = 55.0 mmol(O2) C-mol(DM)(-1) h(-1)), thus affecting xylitol yield (Y(P/S) = 0.41-0.52 g g(-1)). Semi-aerobic conditions (qO2 = 26.8 mmol(O2) C-mol(DM)(-1) h(-1)) were able to ensure the best xylitol production performance (Pmax = 76.6 g L(-1)), minimizing the fractions of the carbon source addressed either to respiration or biomass production and increasing Y(P/S) up to 0.73 g g(-1). An average P/O ratio of about 1.0 mol(ATP) mol(O)(-1) allowed estimation of the main kinetic-bioenergetic parameters of the biosystem. The overall ATP requirements of biomass were found to be particularly high and dependent on the oxygen availability in the medium as well as on the physiological state of the culture. Under semi-aerobic and aerobic conditions, they varied in the ranges 13.5-15.4 and 9.74-10.2 mol(ATP) C-mol(DM)(-1), respectively, whereas during the best semi-aerobic bioconversion they progressively increased from 5.68 to 24.7 mol(ATP) C-mol(DM)(-1). After a starting phase of adaptation to the medium, the cell achieved a phase of decelerated growth during which its excellent xylose-to-xylitol capacity kept almost constant after 112 h up to the end of the run.     

Amino acid supplementation, controlled oxygen limitation and sequential double induction improves heterologous xylanase production by Pichia stipitis

Heterologous endo-beta-1,4-xylanase was produced by Pichia stipitis under control of the hypoxia-inducible PsADH2-promoter in a high-cell-density culture. After promoter induction by a shift to oxygen limitation, different aeration rates (oxygen transfer rates) were applied while maintaining oxygen-limitation. Initially, enzyme production was higher in oxygen-limited cultures with high rates of oxygen transfer, although the maximum xylanase activity was not significantly influenced. Amino acid supplementation increased the production of the heterologous endo-beta-1,4-xylanase significantly in highly aerated oxygen-limited cultures, until glucose was depleted. A slight second induction of the promoter was observed in all cultures after the glucose had been consumed. The second induction was most obvious in amino acid-supplemented cultures with higher oxygen transfer rates during oxygen limitation. When such oxygen-limited cultures were shifted back to fully aerobic conditions, a significant re-induction of heterologous endo-beta-1,4-xylanase production was observed. Re-induction was accompanied by ethanol consumption. A similar protein production pattern was observed when cultures were first grown on ethanol as sole carbon source and subsequently glucose and oxygen limitation were applied. Thus, we present the first expression system in yeast with a sequential double-inducible promoter.     

Monoclonal antibody productivity and the metabolic pattern of perfusion cultures under varying oxygen tensions

The metabolic pattern and cell culture kinetics of high-cell-density perfusion cultures were compared under two different oxygen transfer conditions: oxygen limiting and not limiting. When oxygen was a limiting factor during perfusion culture, both specific glucose uptake and lactate production rates increased, compared to non-oxygen-limited condition, by about 60% and 30%, respectively. The specific glutamine uptake rate under oxygen-limited conditions was almost 4.0 times higher than that under non-oxygen-limited conditions. The activity of lactate dehydrogenase (LDH) released into the medium by the dead cells can be used as an indicator for the metabolic and physiological conditions related to oxygen limitation. There was a 3.2 times higher specific rate of LDH activity released by dead cells in oxygen-limited cultures than those in non-oxygen-limited cultures. The specific production rate of monoclonal antibody was not significantly affected by the oxygen transfer conditions during the rapid cell growth period, but it rapidly increased toward the end of perfusion cultures. The higher perfusion rate may have limited further cell growth during high-cell-density perfusion culture, because cell damage was caused by the hydrodynamic shear within a hollow fiber microfiltration cartridge installed to withdraw the spent medium and the waste metabolites. (c) 1993 John Wiley & Sons, Inc.     

Growth of Trichosporon cutaneum under oxygen limitation: kinetics of oxygen uptake

The relationship between oxygen concentration and growth rate in the yeast Trichosporon cutaneum was studied. In order to establish the conditions for purely oxygen-limited growth, the cells were first grown in a carbon-limited chemostat, and kinetic parameters determined. The cells were then grown in an oxygen-limited chemostat at different dilution rates yielding different oxygen uptake rates. The steady-state dissolved oxygen tension was found at each dilution rate and the corresponding equilibrium dissolved oxygen tension was found at each dilution rate and the corresponding equilibrium dissolved oxygen concentration determined in the effluent medium. The relationship between oxygen concentration and growth rate followed Monod-type kinetics with an apparent K(O) of 4.38 x 10(-6)M.     

Changes in the growth and enzyme level of Zymomonas mobilis under oxygen-limited conditions at low glucose concentration

Zymomonas mobilis growing aerobically with 20 g glucose^–1 (carbon-limited) in a chemostat exhibited an increase in both the molar growth yield (Y_x/s) and the maximum molar growth yield (Y_x/s ^max) and a decrease in both the specific substrate consumption rate (q_s) and the maintenance energy consumption rate (m_e). Stepwise increase in the input oxygen partial pressure showed that anaerobic-to-aerobic transitional adaptation occurred in four stages: anaerobic (0 mm HgO₂), oxygen-limited (7.6– 230 mm HgO₂), intermediate (273 mm HgO₂), and oxygen excess (290 mm HgO₂). The steady-state biomass concentration, Y_x/s, and intracellular ATP content increased between oxygen partial pressures of 7.6 and 120 mm HgO₂, accompanied by a decrease in the q_s and the specific acid production rate. The membrane ATPase activity decreased with increasing oxygen partial pressure and reached its lowest levels at 273 mm HgO₂, which was the highest input oxygen partial pressure where steady-state conditions were possible. Glucokinase, glucose-6-phosphate dehydrogenase, glyceraldehyde-3-phosphate dehydrogenase, and alcohol dehydrogenase activities also decreased when the oxygen partial pressure was increased above 15 mm Hg, whereas pyruvate decarboxylase was unaffected by aeration. Growth inhibition at 290 mm HgO₂ was characterised by a drastic reduction in the pyruvate kinase activity and a collapse in the intracellular ATP pool. The growth and enzyme data suggest that at low glucose concentrations and oxygen-limited conditions, the increase in biomass yields is a reflection of a redirection of ATP usage rather than a net increase in energy production. Received: 14 August 1996 / Accepted: 31 January 1997     

Intrinsic oxygen use kinetics of transformed plant root culture

Root meristem oxygen uptake, root tip extension rate, and specific growth rate are assessed as a function of dissolved oxygen level for three transformed root cultures. The influence of hydrodynamic boundary layer was considered for all measurements to permit correlation of oxygen-dependent kinetics with the concentration of oxygen at the surface of the root meristem. Oxygen uptake rate is shown to be saturated at ambient conditions, and a saturation level of approximately 300 micromole O2/(cm(3) tissue.hr) was observed for all three of these morphologically diverse root types. In nearly all cases, the observation of a minimum oxygen pressure, below which respiration, extension, or root growth would not occur, could be accounted for as a boundary layer mass transfer resistance. The critical oxygen pressure below which respiration declines is below saturated ambient oxygen conditions. In contrast, critical oxygen pressures for root tip extension were much higher; extension was nearly linear for the two thicker root types (Hyoscyamus muticus, henbain; Solanum tuberosum, potato) above ambient oxygen levels. The performance of the thinnest root, Brassica juncea (Indian mustard) was consistent with reduced internal limitations for oxygen transport. Extension rates did not correlate with biomass accumulation. The fastest growing henbain culture micro = 0.44 day(-)(1)) displayed the slowest extension rate (0.16 mm/hr), and the slowest growing mustard culture (micro = 0.22 day(-)(1)) had the fastest tip extension rate (0.3 mm/hr). This apparent paradox is explained in terms of root branching patterns, where the root branching ratio is shown to be dependent upon the oxygen-limited mersitem extension rate. The implications of these observations on the performance of root culture in bioreactors is discussed.     

Synthesis of poly[(R)-3-hydroxybutyric acid) in the cytoplasm of Pichia pastoris under oxygen limitation

We have constructed a tandem gene expression cassette containing three Ralstonia eutropha poly[(R)-3-hydroxybutyrate] (PHB) synthesis genes under the control of the Pichia pastoris glyceraldehyde-3-phosphate promoter and the green fluorescent protein (Gfp) under the control of the P. pastoris alcohol oxidase promoter. The inducible Gfp reporter protein has been used to rapidly isolate transformed strains with two copies of the entire expression cassette. The isolated strain exhibits Gfp induction kinetics that is twice as fast as that of the strains isolated without cell sorting. In addition, the sorted strains exhibited higher PHB contents in preliminary screening experiments. PHB synthesis was characterized in more detail in the sorted strain and was found to be dependent on culture conditions. It was observed that the specific PHB synthesis rate was dependent on the carbon source utilized and that the conditions of oxygen stress lead to increased fractional PHB content. When this strain is cultivated on glucose under oxygen-limited conditions, the cultures accumulated ethanol during the initial growth phase and then consumed the ethanol for the accumulation of PHB and biomass. While PHB was not synthesized during initial growth on glucose, significant levels of PHB were synthesized when ethanol was subsequently consumed. PHB was also synthesized under aerobic conditions when ethanol was the only carbon source. During growth on ethanol, the specific growth rate of the culture was reduced under oxygen-limited conditions but the specific PHB synthesis rate was relatively unaffected. Thus, the high accumulation of PHB which exceeded 30% of the cell dry weight appears to be the consequence of the decreased biomass growth rate under severe oxygen limitation.     

Energetics of tobacco cells,Nicotiana tabacum L., growing on sucrose medium

Summary Batch cultures of tobacco cells induced from Nicotiana tabacum L. cv. Bright Yellow-2 were carried out under oxygen-limited conditions using sucrose as the sole carbon source. Maintenance coefficients for sugar, m, and for oxygen, m_O, were 0.02 mmol glucose/g cell dry weight/h and 0.09 mmol O₂/g cell dry weight/h, and true growth yields for sugar, Y_G, and for oxygen, Y_GO, were 107 g cell dry weight/mol glucose and 61 g cell dry weight/mol O₂, respectively.Balance equations based on electrons available from the culture suggested that the carbon-substrate consumed by the cells might be metabolized mainly in biosynthetic processes without the excretion of extracellular products.     

Metabolic flux analysis of Candida tropicalis growing on xylose in an oxygen-limited chemostat

We have studied the metabolism of xylose by Candida tropicalis in oxygen-limited chemostat. In vitro enzyme assays indicated that glycolytic and gluconeogenetic enzymes are expressed simultaneously facilitating substrate cycling. Enhancing the redox imbalance by cofeeding of formate increased xylose and oxygen consumption rates and ethanol, xylitol, glycerol and CO2 production rates at steady state. Metabolic flux analysis (MFA) indicated that fructose 6-phosphate is replenished from the pentose phosphate pathway in sufficient amounts without contribution of the gluconeogenetic pathway. Substrate cycling between pyruvate kinase, pyruvate carboxylase and phospho-enol-pyruvate kinase increased ATP turnover. Cofeeding of formate increased the ATP yield. The ATP yields of xylose and xylose-formate cultivation were 6.9 and 8.7 mol ATP/C-mol CDW, respectively, as calculated from the MFA.     

Effects of carbon and oxygen limitations and calcium concentrations on biofilm removal processes

Bacterial biofilm removal processes due to shear and catastrophic sloughing have been investigated in a turbulent flow system under conditions of carbon versus oxygen substrate limitations and varying aqueous phase calcium concentrations. Biofilm cellular and extracellular polymer carbon, total biofilm carbon and mass, and biofilm calcium concentrations are measured for pure culture biofilms of the facultative aerobe, Pseudomonas putida ATCC 11172. Results indicate oxygen-limited biofilms reach a higher steady-state biofilm organic carbon level than carbon-limited biofilms. Oxygen-limited biofilms also exhibit (1) a higher extracellular polymer-carbon: cell-carbon ratio throughout biofilm development and (2) a higher biofilm calcium content than carbon-limited biofilms. Increasing aqueous phase calcium concentrations increase the amount of biofilm calcium in both cases; the rate of calcium accumulation in oxygen-limited biofilms increases with increasing liquid phase calcium concentrations over the entire range studied while the rates of calcium accumulation in carbon-limited biofilms appear independent of aqueous phase calcium concentrations above 11.0 mg/L. Oxygen-limited biofilms with their higher extracellular polymer and calcium content exhibit shear removal rates that are 20-40% of those observed for carbon-limited biofilms. However, it is the oxygen-limited biofilms that experience catastrophic sloughing events. The carbon-limited biofilms studied here never sloughed even if subjected to intentional long-term deprivation of all nutrients. Reduced shear removal and the susceptibility to sloughing of the oxygen-limited biofilms are attributed to their more cohesive structure bought about by their relatively greater extracellular polymer production.