Production of thermostable pectinase and xylanase for their potential application in bleaching of kraft pulp

A very high level of alkalophilic and thermostable pectinase and xylanase has been produced from newly isolated strains of Bacillus subtilis and Bacillus pumilus respectively. Enzyme production for pectinase was carried out under SSF using combinations of cheap agricultural residues while xylanase was produced under submerged fermentation using wheat bran as substrate to minimize the cost of production of these enzymes Among the various substrates tested, the highest yield of pectinase production was observed by using combination of WB + CW (6592 U/g of dry substrate) supplemented with 4% yeast extract when incubated at 37 °C for 72 h using deionized water of pH 7.0 as moistening agent. The biobleaching effect of these cellulase free enzymes on kraft pulp was determined. Both xylanase and pectinase showed stability over a broad range of pH from 6 to 10 and temperature from 55 to 70 °C. The bleaching efficiency of the pectinase and xylanase on kraft pulp was maximum after 150 min at 60 °C using enzyme dosage of 5 IU/ml of each enzyme at 10% pulp consistency with about 16% reduction in kappa number and 84% reduction in permanganate number. Enzyme treated pulp when subjected to CDED₁D₂ steps, 25% reduction in chlorine consumption and upto 19% reduction in consumption of chlorine dioxide was observed for obtaining the same %ISO brightness. Also an increase of 22 and 84% in whiteness and fluorescence respectively and a decrease of approximately 19% in the yellowness of the biotreated pulp were observed by pretreatment of the pulp with our enzymatic mixture.     

Production of Cellulase-Free Xylanase from Bacillus megaterium by Solid State Fermentation for Biobleaching of Pulp

Xylanase production from B. megaterium was enhanced using solid state fermentation with respect to the use of solid substrate, moistening solution, moisture content, inoculum, sugars, soyabean meal, amino acids, and extraction with surfactant. An increase of ≈423-fold in xylanase production and complete suppression of CMCase production was achieved over submerged liquid fermentation. Biobleaching using this cellulase-free xylanase, 8 U/g of oven dried pulp of 10% consistency, showed 8.12% and 1.16% increase in brightness and viscosity, 13.67% decrease in kappa number, and 31% decrease in chlorine consumption at the CD stage.     

Xylanase production under solid-state fermentation and its characterization by an isolated strain of <Emphasis Type="Italic">Aspergillus foetidus</Emphasis> in India

Summary A locally isolated strain of Aspergillus foetidus MTCC 4898 was studied for xylanase (EC 3.2.1.8) production using lignocellulosic substrates under solid state fermentation. Corncobs were found as the best substrates for high yield of xylanases with poor cellulase production. The influence of various parameters such as temperature, pH, moistening agents, moisture level, nitrogen sources and pretreatment of substrates were evaluated with respect to xylanase yield, specific activity and cellulase production. Influence of nitrogen sources on protease secretion was also examined. Maximum xylanase production (3065 U/g) was obtained on untreated corncobs moistened with modified Mandels and Strenberg medium, pH 5.0 at 1 5 moisture levels at 30 °C in 4 days of cultivation. Submerged fermentation under the same conditions gave higher yield (3300 U/g) in 5 days of cultivation, but productivity was less. Ammonium sulphate fractionation yielded 3.56-fold purified xylanase with 76% recovery. Optimum pH and temperature for xylanase activity were found to be 5.3 and 50 °C respectively. Kinetic parameters like K_m and V_max were found to be 3.58 mg/ml and 570 μmol/mg/min. Activity of the enzyme was found to be enhanced by cystiene hydrochloride, CoCl₂, xylose and Tween 80, while significantly inhibited by Hg⁺⁺, Cu⁺⁺ and glucose. The enzyme was found to be stable at 40 °C. The half life at 50 °C was 57.53 min. However thermostability was enhanced by glycerol, trehalose and Ca⁺⁺. The crude enzyme was stable during lyophilization and could be stored at less than 0 °C.     

Comprehensive studies on optimization of cellulase and xylanase production by a local indigenous fungus strain via solid state fermentation using oil palm frond as substrate

The high cost of cellulases remains the most significant barrier to the economical production of bio-ethanol from lignocellulosic biomass. The goal of this study was to optimize cellulases and xylanase production by a local indigenous fungus strain (Aspergillus niger DWA8) using agricultural waste (oil palm frond [OPF]) as substrate. The enzyme production profile before optimization indicated that the highest carboxymethyl cellulose (CMCase), filter paper (FPase), and xylanase activities of 1.06 U/g, 2.55 U/g, and 2.93 U/g were obtained on day 5, day 4, and day 5 of fermentation, respectively. Response surface methodology was used to study the effects of several key process parameters in order to optimize cellulase production. Of the five physical and two chemical factors tested, only moisture content of 75% (w/w) and substrate amount of 2.5 g had statistically significant effect on enzymes production. Under optimized conditions of 2.5 g of substrate, 75% (w/w) moisture content, initial medium of pH 4.5, 1 × 10⁶ spores/mL of inoculum, and incubation at ambient temperature (±30°C) without additional carbon and nitrogen, the highest CMCase, FPase, and xylanase activities obtained were 2.38 U/g, 2.47 U/g, and 5.23 U/g, respectively. Thus, the optimization process increased CMCase and xylanase production by 124.5 and 78.5%, respectively. Moreover, A. niger DWA8 produced reasonably good cellulase and xylanase titers using OPF as the substrate when compared with previous researcher finding. The enzymes produced by this process could be further use to hydrolyze biomass to generate reducing sugars, which are the feedstock for bioethanol production.     

The use of extracellular enzymes from Streptomyces albus ATCC 3005 for the bleaching of eucalyptus kraft pulp

The suitability of culture supernatant from Streptomyces albus ATCC 3005 for use in the biobleaching of eucalyptus kraft pulp was investigated. S. albus was found to grow on a minimal salts medium containing oat spelts xylan and yeast extract as the main carbon and nitrogen sources, respectively. Maximal extracellular xylanase and peroxidase production was detected after 120 h (11.97 U ml(-1)) and 72 h (0.58 U ml(-1)), respectively. Importantly, no cellulase activity could be detected. When the effect of pH on enzyme activity was examined, maximal xylanase and peroxidase activity was obtained at pH 6.5 and pH 9.9, respectively. The optimum hydrogen peroxide (H2O2) concentration for peroxidase activity was found to occur at 20 mM, with peroxidase remaining active at 100 mM H2O2 after 1 h incubation at 53 degrees C; the half-life of the enzyme at that temperature was estimated to be 33 min. Short-term (1 h) biobleaching of eucalyptus kraft pulp with culture supernatant from S. albus in the presence of H2O2 resulted in a significant reduction of kappa number (2.85 units) with no change in viscosity. These results suggest a potential application of cellulase-free culture supernatants from S. albus in biobleaching.     

Some properties of eucalyptus kraft pulp treated with xylanase from Aspergillus niger

An Aspergillus niger isolate produced about 2500nkat xylanase/ml when cultivated in a medium containing 3% xylose. Application of the crude xylanolytic preparation to unbleached eucalyptus kraft pulp resulted in a decreased kappa number and increased brightness. Handsheets made from the xylanase-treated pulp after ECF bleaching retained good structural and mechanical characteristics.     

In vivo enzymatic digestion, in vitro xylanase digestion, metabolic analogues, surfactants and polyethylene glycol ameliorate laccase production from Ganoderma sp. kk-02

AIMS: The effect of in vivo enzymatic digestion (IVED), in vitro xylanase digestion (IVXD), metabolic analogues, surfactants and polyethylene glycol (PEG) on laccase production from Ganoderma sp. kk-02 was studied. METHODS AND RESULTS: An acidic laccase producing Ganoderma sp. kk-02 produced 16.0 U ml(-1) and 365.0 U g(-1) of laccase, when grown under submerged (SmF) and solid state (SSF) fermentation conditions, respectively. Modification of the substrate (wheat bran) molecular architecture by IVED and IVXD increased subsequent laccase production from Ganoderma sp. kk-02 by 1.31-fold (21.0 U ml(-1)) (SmF); 2.21-fold (810.0 U g(-1)) (SSF) and 1.10-fold (18.0 U ml(-1)) (SmF); 1.78-fold (650.0 U g(-1)) (SSF) when compared with untreated wheat bran. Further enhancement in laccase yield under SmF and SSF was obtained when IVED treated wheat bran was used in conjunction with amino acids [DL-tryptophan, 2.66-fold (56.0 U ml(-1)) SmF; 2.86-fold (2324.0 U g(-1)) SSF], vitamins [biotin, 1.71-fold (36.0 U ml(-1)) SmF; 3.06-fold (2483.0 U g(-1)) SSF], surfactants [Tween-40, 1.85-fold (39.0 U ml(-1)) SmF; 2.25-fold (1828.0 U g(-1)) SSF], and PEG [PEG 6000, 1.93-fold (40.0 U ml(-1)) SmF; 1.58-fold (1284.0 U g(-1)) SSF]. CONCLUSIONS: The IVED of substrate (wheat bran) facilitated hyper laccase production in presence of additives from Ganoderma sp. kk-02. SIGNIFICANCE AND IMPACT OF THE STUDY: The study highlights a new methodology viz. IVED for concomitant and economic production of diverse enzymes using the same substrate. The hyper laccase levels obtained could improve the economic competitiveness of environmentally benign processes applied in varied industries. The work also provides an insight into the regulation of complex metabolic pathways governing the expression of extra cellular proteins from white-rot fungi.     

Production of xylanase under solid-state fermentation by <Emphasis Type="Italic">Aspergillus tubingensis</Emphasis> JP-1 and its application

The production of extracellular xylanase by a locally isolated strain of Aspergillus tubingensis JP-1 was studied under solid-state fermentation. Among the various agro residues used wheat straw was found to be the best for high yield of xylanase with poor cellulase production. The influence of various parameters such as initial pH, moisture, moistening agents, nitrogen sources, additives, surfactants and pretreatment of substrates were investigated. The production of the xylanase reached a peak in 8 days using untreated wheat straw with modified MS medium, pH 6.0 at 1:5 moisture level at 30 °C. Under optimized conditions yield as high as 6,887 ± 16 U/g of untreated wheat straw was achieved. Crude xylanase was used for enzymatic saccharification of agro-residues like wheat straw, rice bran, wheat bran, sugarcane bagasse and industrial paper pulp. Dilute alkali (1 N NaOH) and acid (1 N H₂SO₄) pretreatment were found to be beneficial for the efficient enzymatic hydrolysis of wheat straw. Dilute alkali and acid-pretreated wheat straw yielded 688 and 543 mg/g reducing sugar, respectively. Yield of 726 mg/g reducing sugar was obtained from paper pulp after 48 h of incubation.     

Enhanced production of cellulase-free thermostable xylanase by Bacillus pumilus ASH and its potential application in paper industry

A very high level of cellulase-free, thermostable xylanase has been produced from newly isolated strain of Bacillus pumilus under submerged fermentation in a basal medium supplemented with wheat bran (2%, w/v) pH 8.0 and at 37 °C. After optimization of various production parameters, an increase of nearly 13-fold in xylanase production (5407 IU/ml) was achieved. The produced xylanase is stable in neutral to alkaline pH region at 70 °C. The suitability of this xylanase for use in the bioleaching of eucalyptus Kraft pulp was investigated. A xylanase dose of 5 IU/g of oven dried pulp of 10% consistency exhibited the optimum bleach boosting of the pulp at pH 7.0 and 60 °C after 180 min of treatment. An increase of 5% in brightness along with an increase of 21% and 28% in whiteness and fluorescence respectively, whereas 18% decrease in the yellowness of the biotreated pulp was observed. Enzyme treated pulp when subjected to chemical bleaching, resulted in 20% reduction in chlorine consumption and up to 10% reduction in consumption of chlorine dioxide. Also a reduction of about 16% in kappa number and 83% in permanganate number, along with a reduction in COD value and significant improvement in various pulp properties, viz. viscosity, tensile strength, breaking length, burst factor, burstness, tear factor and tearness were observed in comparison to the conventional chemical bleaching.     

樟绒枝霉(Malbranchea cinnamomea)固体发酵产木聚糖酶的发酵条件优化

[目的] 研究樟绒枝霉(Malbranchea cinnamomea) CAU521利用农业废弃物固体发酵产木聚糖酶的发酵条件.[方法]采用单因素试验法优化影响菌株产酶的各个条件,包括碳源种类、氮源种类、初始pH、初始水分含量、培养温度及发酵时间共6个因素.[结果]获得的最佳产酶条件为:稻草为发酵碳源、2％(W/W)的酵母提取物为氮源、初始pH 7.0、初始水分含量80％和发酵温度45℃.在此条件下发酵6d后木聚糖酶的酶活力达到13 120 U/g干基碳源.[结论]樟绒枝霉固体发酵产木聚糖酶的产酶水平高,生产成本低,具有潜在的工业化应用前景.     

Utilization of agro-industrial waste for xylanase production by Aspergillus foetidus MTCC 4898 under solid state fermentation and its application in saccharification

Xylanase production by Aspergillus foetidus MTCC 4898 was carried out under solid state fermentation using wheat bran and anaerobically treated distillery spent wash. Response surface methodology involving Box–Behnken design was employed for optimizing xylanase production. The interactions among various fermentation parameters viz. moisture to substrate ratio, inoculum size, initial pH, effluent concentration and incubation time were investigated and modeled. The predicted xylanase activity under optimized parameters was 8200–8400 U/g and validated xylanase activity was 8450 U/g with very poor cellulase activity. Crude xylanase was used for enzymatic saccharification of agroresidues like wheat straw, rice straw and corncobs. Dilute NaOH and ammonia pretreatments were found to be beneficial for the efficient enzymatic hydrolysis of all the three substrates. Dilute NaOH pretreated wheat straw, rice straw and corncobs yielded 4, 4.2, 4.6 g/l reducing sugars, respectively whereas ammonia treated wheat straw, rice straw and corncobs yielded 4.9, 4.7, 4.6 g/l reducing sugars, respectively. The hydrolyzates were analysed by HPTLC. Xylose was found to be the major end product with traces of glucose in the enzymatic hydrolyzates of all the substrates.     

Isolation, purification and characterization of xylanasefrom Staphylococcus sp. SG-13 and its application in biobleaching of kraft pulp

A haloalkalophilic Staphylococcus sp. SG-13 produced an alkalistable xylanase in wheat bran medium. A 12-fold purification was achieved by using standard purification techniques. The purified xylanase exhibited a dual pH optima of 7.5 and 9.2. The optimum temperature for enzyme activity was 50 degrees C. The enzyme was stable at 50 degrees C for more than 4 h. The xylanase exhibited Km and Vmax values of 4 mg ml-1, 90 micromol min-1 per mg for birchwood xylan and 7 mg ml-1, 55 micromol min-1 per mg for oatspelt xylan, respectively. The substrate binding affinity of xylanase was more for oatspelt xylan but birchwood xylan was hydrolysed more rapidly. The xylanase activity was stimulated by Fe2+, Ni2+, Cu2+ and dithiothreitol up to 60% and was strongly inhibited in the presence of Co2+, Hg2+, Pb2+, phenyl methane sulphonyl fluoride, ethylenediaminetetraacetic acid, and acetic anhydride up to 100%. The xylanase dose of 1.8 U g-1 moisture free pulp, exhibited bleach boosting of kraft pulps optimally at pH 9.5-10.0 and 50 degrees C after 4 h of reaction time. Pretreatment of pulp with xylanase and its subsequent treatment with 8% hypochlorite, reduced the kappa number by 30%, enhanced the brightness and viscosity by 11% and 1.8%, respectively, and improved the paper properties such as tensile strength and burst factor up to 10% and 17%, respectively.     

Xylanase production in solid-state fermentation: a study of its properties

Summary Xylanase production by Aspergillus niger van Tieghem was studied in solid-state cultivation. The screening of substrates was carried out in column incubators aerated with humidified air at 30°C. Results of physiological studies showed that the best yield of xylanase was 2500 U/g dry matter on a mixture of straw+bran 1:1 at 70% of moisture content.In order to compare some properties of the xylanase produced in both liquid and solid cultures, A. niger was also grown on xylan in submerged cultures. The enzymes produced in solid and liquid cultures have an optimum pH of about 3.8 and 4.5, respectively. Xylanase synthetized in solid fermentation is a little more thermostable than that from liquid culture and is maximally active at 50° C, compared to 45° C for enzyme from liquid culture.     

嗜热真菌DSM10635生产耐热木聚糖酶的小试研究

应用嗜热真菌Thermomyces lanuginosus DSM10635,采用固体发酵的方法探索耐热木聚糖酶的优化生产条件。在研究玉米芯,玉米皮,玉米秆,麸皮,松树屑,桦树屑等不同底物,在不同温度、玉米芯颗粒大小以及料水比条件下培养比较酶产量后,发现该嗜热真菌产耐热木聚糖酶的最佳底物为玉米芯或玉米皮,最佳培养温度为50℃--55℃,在加水量为1份玉米芯：2．8份水,玉米芯的颗粒直径大约为1mm时产酶量最高。实验结果显示,嗜热真菌DSM10635在优化后的培养条件下木聚糖酶产量可达到12525．80IU／g玉米芯。     

Production of a xylose-stimulated β-glucosidase and a cellulase-free thermostable xylanase by the thermophilic fungus Humicola brevis var. thermoidea under solid state fermentation

Humicola brevis var. thermoidea cultivated under solid state fermentation in wheat bran and water (1:2 w/v) was a good producer of β-glucosidase and xylanase. After optimization using response surface methodology the level of xylanase reached 5,791.2 ± 411.2 U g(-1), while β-glucosidase production was increased about 2.6-fold, reaching 20.7 ± 1.5 U g(-1). Cellulase levels were negligible. Biochemical characterization of H. brevis β-glucosidase and xylanase activities showed that they were stable in a wide pH range. Optimum pH for β-glucosidase and xylanase activities were 5.0 and 5.5, respectively, but the xylanase showed 80 % of maximal activity when assayed at pH 8.0. Both enzymes presented high thermal stability. The β-glucosidase maintained about 95 % of its activity after 26 h in water at 55 °C, with half-lives of 15.7 h at 60 °C and 5.1 h at 65 °C. The presence of xylose during heat treatment at 65 °C protected β-glucosidase against thermal inactivation. Xylanase maintained about 80 % of its activity after 200 h in water at 60 °C. Xylose stimulated β-glucosidase activity up to 1.7-fold, at 200 mmol L(-1). The notable features of both xylanase and β-glucosidase suggest that H. brevis crude culture extract may be useful to compose efficient enzymatic cocktails for lignocellulosic materials treatment or paper pulp biobleaching.     

Hyper production of alkali stable xylanase in lesser duration by Bacillus pumilus SV-85S using wheat bran under solid state fermentation

High level production of an extracellular cellulase-poor alkali stable xylanase has been conceded from newly isolated Bacillus pumilus SV-85S under solid state fermentation using wheat bran as a substrate. Optimization of the fermentation conditions enhanced the enzyme production to 73,000 ± 1,000 IU/g dry substrate, which was 13.8-fold higher than unoptimized conditions (5,300 IU/g). The enzyme titre was highest after 48 h of incubation at 30°C with 1:3 ratios of substrate to moistening agent using wheat bran as a carbon source. The enzyme could be produced in significant levels by using either tap water or distilled water alone as a moistening agent. An elevated production of xylanase by B. pumilus SV-85S in the presence of wheat bran, a cheap and easily available agro-residue, in shorter duration would apparently reduce the enzyme cost substantially. The enzyme was completely stable over a broad pH (5-11) range and retained 52% of its activity at a temperature of 70°C for 30 min. The desired characteristics of this enzyme together with economic production would be important for its application in paper and pulp industry.     

Optimisation of culture medium and conditions for alpha-l-Arabinofuranosidase production by the extreme thermophilic eubacterium Rhodothermus marinus

The culture medium for Rhodothermus marinus was optimised on a shake-flask scale by using statistical factorial designs for enhanced production of a highly thermostable alpha-L-arabinofuranosidase (AFase). The medium containing 3.6 g/l birch wood xylan and 8.2 g/l yeast extract yielded a maximum of 110 nkat/ml AFase activity together with 125 nkat/ml xylanase and 65 nkat/ml beta-xylosidase activity. In addition, low levels of beta-mannanase (30 nkat/ml), alpha-galactosidase (0.2 nkat/ml), beta-galactosidase (0.3 nkat/ml), endoglucanase (5 nkat/ml) and beta-glucosidase (30 nkat/ml) were detected in the culture filtrate. Among the various carbon sources tested, birchwood xylan was most effective for the formation of AFase and xylanase activities, followed by oat spelt and beechwood xylans, and xylan-rich lignocelluoses (e.g., starch-free sugar beet pulp and wheat bran). Constitutive levels of enzyme activities were detected when the bacterium was grown on other polysaccharides and low-molecular-weight carbohydrates. A fermentation in a 5-l fermenter (3-l working volume) using the optimised medium yielded 60 nkat/ml AFase associated with 65 nkat/ml xylanase and 35 nkat/ml beta-xylosidase activities. The crude AFase displayed optimal activity between pH 5.5 and 7 and at 85 degrees C. It had half-lives of 8.3 h at 85 degrees C and 17 min at 90 degrees C. It showed high stability between pH 5 and 9 (24 h at 65 degrees C). The combined use of AFase-rich xylanase and mannanase from R. marinus in the prebleaching of softwood kraft pulp gave a brightness increase of 1.8% ISO. To our knowledge, this is the first report on the production of a high AFase activity by an extreme thermophilic bacterium and this enzyme is the most thermostable AFase reported so far.     

Tamarind seed powder and palm kernel cake: two novel agro residues for the production of tannase under solid state fermentation by Aspergillus niger ATCC 16620

Palm kernel cake (PKC), the residue obtained after extraction of palm oil from oil palm seeds and tamarind seed powder (TSP) obtained after removing the fruit pulp from tamarind fruit pod were tested for the production of tannase under solid-state fermentation (SSF) using Aspergillus niger ATCC 16620. The fungal strain was grown on the substrates without any pretreatment. In PKC medium, a maximum enzyme yield of 13.03 IU/g dry substrate (gds) was obtained when SSF was carried out at 30 degrees C, 53.5% initial substrate moisture, 33 x 10(9) spores/5 g substrate inoculum size and 5% tannic acid as additional carbon source after 96 h of fermentation. In TSP medium, maximum tannase yield of 6.44 IU/gds was obtained at 30 degrees C, 65.75% initial substrate moisture, 11 x 10(9) spores/5 g substrate inoculum, 1% glycerol as additional carbon source and 1% potassium nitrate as additional nitrogen source after 120 h of fermentation. Results from the study are promising for the economic utilization and value addition of these important agro residues, which are abundantly available in many tropical and subtropical countries.     

Response surface optimization of fermentation conditions for producing xylanase by <Emphasis Type="Italic">Aspergillus</Emphasis><Emphasis Type="Italic">niger</Emphasis> SL-05

Fermentation conditions were statistically optimized for producing extracellular xylanase by Aspergillus niger SL-05 using apple pomace and cotton seed meal. The primary study shows that culture medium with a 1:1 ratio of apple pomace and cotton seed meal (carbon and nitrogen sources) yielded maximal xylanase activity. Three significant factors influencing xylanase production were identified as urea, KH(2)PO(4), and initial moisture content using Plackett-Burman design study. The effects of these three factors were further investigated using a design of rotation-regression-orthogonal combination. The optimized conditions by response surface analysis were 2.5% Urea, 0.09% KH(2)PO(4), and 62% initial moisture content. The analysis of variance indicated that the established model was significant (P < 0.05), "while" or "and" the lack of fit was not significant. Under the optimized conditions, the model predicted 4,998 IU/g dry content, whereas validation experiments produced an enzymatic activity of xylanase at 5,662 IU/g dry content after 60 h fermentation. This study innovatively developed a fermentation medium and process to utilize inexpensive agro-industrial wastes to produce a high yield of xylanase.     

Xylanase production by Burkholderia sp. DMAX strain under solid state fermentation using distillery spent wash

Xylanase production by a newly isolated strain of Burkholderia sp. was studied under solid state fermentation using anaerobically treated distillery spent wash. Response surface methodology (RSM) involving Box-Behnken design was employed for optimizing xylanase production. The interactions between distillery effluent concentration, initial pH, moisture ratio and inoculum size were investigated and modeled. Under optimized conditions, xylanase production was found to be in the range of 5200-5600 U/g. The partially purified enzyme recovered after ammonium sulphate fractionation showed maximum activity at 50 degrees C and pH 8.6. Kinetic parameters like Km and Vmax for xylan were found to be 12.75 mg/ml and 165 micromol/mg/min. In the presence of metal ions such as Ca2+, Co2+, Mn2+, Ba2+, Mg2+ and protein disulphide reducing agents such as beta-mercaptoethanol and dithiotheritol (DTT) the activity of enzyme increased, where as strong inhibition of enzyme activity was observed in the presence of Cu2+, Ag+, Fe2+ and SDS. The crude enzyme hydrolysed lignocellulosic substrate, wheat bran as well as industrial pulp.