Redirecting Carbon Flux in Torulopsis glabrata from Pyruvate to α-Ketoglutaric Acid by Changing Metabolic Co-factors

The nutrition conditions needed to redirect the carbon flux in Torulopsis glabrata, a pyruvate hyper-production yeast, from pyruvate to α-ketoglutaric acid (KG) were investigated in a stirred fermentor. A minor amount of KG (1.3 gl⁻¹) was produced when NaOH was used to control the pH, while 12 g KG l⁻¹ was produced when CaCO₃ was used instead. When thiamine and biotin were included in the medium, 13 g KG l⁻¹ and 68 g pyruvate l⁻¹ were produced after 48 h when glucose was nearly consumed (approximately 5 gl⁻¹). With fermentation continuing for a further 16 h, the concentration of pyruvate decreased to 31 gl⁻¹, and KG increased to 30 gl⁻¹. KG thus accumulated at the expense of pyruvate consumption. Received 2 June 2005; Revisions requested 30 June 2005 and 1 September 2005; Revisions received 1 September 2005 and 28 October 2005; Accepted 28 October 2005     

Reduction of Cr(VI) by a Bacillus sp.

A Bacillus sp. RE was resistant to chromium and reduced Cr(VI) without accumulating chromium inside the cell. When Cr(VI) was 10 and 40 μg ml⁻¹, >95% of the total Cr(VI) was reduced in 24 and 72 h of growth, respectively, whereas at 80 μg Cr(VI) ml⁻¹ only 50% of Cr(VI) was reduced. However growth was not affected; the cell mass was 0.7–0.8 mg ml⁻¹ in all cases. The cell-free extract showed Cr(VI) reducing enzyme activity which was enhanced (>5 fold) by NADH and NADPH. Like whole cells the enzyme also reduced Cr(VI) with decreasing efficiency on increasing Cr(VI) concentration. The enzyme activity was optimal at pH 6.0 and 30 °C. The enzyme was stable up to 30 °C and from pH 5.5 to 8, but from pH 4 to 5 the enzyme was severely destabilized. Its K_m and V_max were 14 μm and 3.8 nmol min⁻¹ mg⁻¹ respectively. The enzyme activity was enhanced by Cu²⁺ and Ni²⁺ and inhibited by Hg²⁺. Received 21 September 2005; Revisions requested 5 October 2005; Revisions received 16 November 2005; Accepted 16 November 2005     

Heterotrophic cultivation of Paracoccus denitrificans in a horizontal rotating tubular bioreactor

In this work, the heterotrophic cultivation of bacterium Paracoccus denitrificans has been studied in a horizontal rotating tubular bioreactor (HRTB). After development of a microbial biofilm on the inner surface of the HRTB, conditions for one-step removal of acetate and ammonium ion were created. The effect of bioreactor process parameters [medium inflow rate (F) and bioreactor rotation speed (n)] on the bioprocess dynamics in the HRTB was studied. Nitrite and nitrogen oxides (NO and N₂O) were detected as intermediates of ammonium ion degradation. The biofilm thickness and the nitrite concentration were gradually reduced with increase of bioreactor rotation speed when the medium inflow rate was in the range of 0.5–1.5 l h⁻¹. Further increase of inflow rate (2.0–2.5 l h⁻¹) did not have a significant effect on the biofilm thickness and nitrite concentration along the HRTB. Complete acetate consumption was observed when the inflow rate was in the range of 0.5–1.5 l h⁻¹ at all bioreactor rotation speeds. Significant pH gradient (cca 1 pH unit) along the HRTB was only observed at the highest inflow rate (2.5 l h⁻¹). The results have clearly shown that acetate and ammonium ion removal by P. denitificans can be successfully conducted in a HRTB as a one-step process.     

Relationship between Poly- β-hydroxybutyrate Production and δ-endotoxin for Bacillus thuringiensis var. kurstaki

A linear relationship between total solid concentration (TSC), δ-endotoxin production [Cry = 0.2795(TSC)−0.2472, R² = 0.8644] and poly-β-hydroxybutyrate (PHB) accumulation [PHB = 0.1327(TSC) + 0.3974, R² = 0.9877] in Bacillus thuringiensis var. kurstaki HD-73 was observed. A similar correlation between δ-endotoxin and PHB accumulation [Cry = 2.1573(PHB)−1.1248, R² = 0.9181] was found. A minimum PHB accumulation of 0.52 mg l⁻¹ was required before the onset of δ-endotoxin production. Revisions requested 28 September 2005 and 4 November 2005; Revisions received 28 October 2005 and 1 February 2006     

Influence of Agitation on the Removal of Nonylphenol by the White-rot Fungi Trametes versicolor and Bjerkandera sp. BOL 13

Bjerkandera sp. BOL 13 removed 95% of nonylphenol (at 9.7 mg nonylphenol l⁻¹ day⁻¹) from aqueous medium after 5 days of incubation in agitated cultures. This removal rate decreased 2.5-fold in static cultures. By comparison, Trametes versicolor removed nonylphenol at 2.8 mg l⁻¹ day⁻¹ under conditions of static incubation, probably due to the action of laccase, but no growth was recorded in the agitated bottles. Received 4 August 2005; Revisions requested 18 August 2005 and 27 September 2005; Revisions received 22 September 2005 and 3 November 2005; Accepted 7 November 2005     

Lactose-induced Production of Human Soluble B Lymphocyte Stimulator (hsBLyS) in E. coli with Different Culture Strategies

Over-production of human soluble B lymphocyte stimulator (hsBLyS) was carried out with four different fed-batch culture strategies using lactose as inducer, instead of IPTG, in a fed-batch culture of Escherichia coli. As lactose acted as both inducer and carbon source, the best and simplest culture strategy was direct feeding of lactose after batch culture, thereby giving hsBLyS at 3.7 g l⁻¹ and a productivity of 0.11 g l⁻¹ h⁻¹. Revisions requested 1 September 2005 and 11 November 2005; Revisions received 7 November 2005 and 4 January 2006     

Using Redox Potential to Detect Microbial Activities During Clavulanic Acid Biosynthesis in <Emphasis Type="Italic">Streptomyces clavuligerus</Emphasis>

Production of clavulanic acid (CA) by Streptomyces clavuligerus in a shake-flask culture increased from 92 to 180 mg l⁻¹ with an increased O₂ transfer efficiency (0.039 → 0.058 s⁻¹), which maintained the redox potential values above −250 mV. Compared with traditional measures, such as dissolved O₂ concentration and respiratory activity, the redox potential can easily be determined and correlates closely with CA production. It can therefore be used to monitor microbial activities during biosyntheses of secondary metabolites. Revisions requested 5 April 2005 and 19 July 2005; Revisions received 19 July 2005 and 9 September 2005     

Isolation and Characterization of a Novel Thraustochytrid-like Microorganism that Efficiently Produces Docosahexaenoic Acid

A thraustochytrid-like microorganism (strain 12B) was isolated from the mangrove area of Okinawa, Japan. On the basis of its ectoplasmic net structure and biflagellate zoospores we determined strain 12B to be a novel member of the phylum Labyrinthulomycota in the kingdom Protoctista. When grown on glucose/seawater at 28 °C, it had a lipid content of 58% with docosahexaenoic acid (DHA; 22:6 n−3) at 43% of the total fatty acids. It had a growth rate of 0.38 h⁻¹. The DHA production rate of 2.8 ± 0.7 g l⁻¹ day⁻¹ is the highest value reported for any microorganism. Received 7 October 2005; Revisions requested 7 October 2005; Revisions received 15 November 2005; Accepted 15 November 2005     

Methyl Oleate Modulates <Emphasis Type="Italic">LIP2</Emphasis> Expression in the Lipolytic Yeast <Emphasis Type="Italic">Yarrowia lipolytica</Emphasis>

Methyl oleate was used as a primary carbon source and as an alternative inducer for the production of an extracellular lipase, Lip2, in Y. lipolytica strain LgX64.81 grown in a 20-l bioreactor. The lipase-encoding gene, LIP2, was investigated during culture on methyl oleate using a pLIP2–LacZ reporter fusion and we provide evidence for the involvement of methyl oleate in its regulation. Revisions requested 7 July 2005; Revisions received 30 August 2005     

Anti-apoptotic Activity of Laminarin Polysaccharides and their Enzymatically Hydrolyzed Oligosaccharides from Laminaria japonica

Laminarin polysaccharides (LP1) were prepared from Laminaria japonica, a marine brown alga with potential biological activities, by hot water extraction, ultrafiltration and gel chromatography; the molecular weights of the LP1s were between 5 and 10 kDa. Laminarin oligosaccharides (LO) derived by hydrolyzing LP1 with an endo-β-(1→3)-glucanase from Bacillus circulans were mainly di- and penta-oligosaccharides. Treatment of mouse thymocytes with LO or LP1 (1–4 mg ml⁻¹) suppressed apoptotic death around 3- or 2-fold and extended cell survival in culture at a rate of about 30 or 20%. A mouse cDNA microarray showing the genes coding for immune response proteins were induced and apoptotic cell death proteins were reduced significantly by LO provided preliminary information regarding the immunomodulatory mechanism of LO. These results suggest that laminarin oligosaccharides and polysaccharides can be utilized to develop new immunopotentiating substances and functional alternative medicines. Revisions requested 26 October 2005; Revisions received 19 December 2005     

Production of Bioactive Human β-defensin-3 in Escherichia coli by Soluble Fusion Expression

A codon optimized mature human β-defensin-3 gene (smHBD3) was synthesized and fused with TrxA to construct pET32-smHBD3 vector, which was transformed into E. coli BL21(DE3) and cultured in MBL medium. The volumetric productivity of fusion protein reached 0.99 g fusion protein l⁻¹, i.e. 0.21 g mature HBD3 l⁻¹. Ninety-six percentage of the fusion protein was in a soluble form and constituted about 45% of the total soluble protein. After cell disruption, the soluble fusion protein was separated by affinity chromatography and cleaved by enterokinase, and then the mature HBD3 was purified by cationic ion exchange chromatography. The overall recovery ratio of HBD3 was 43%. The purified mature HBD3 demonstrated antimicrobial activity against E. coli. Revisions requested 13 December 2005; Revisions received 24 January 2006     

Production of raw-starch-hydrolysing α-amylase from the newly isolated Geobacillus thermodenitrificans HRO10

An extracellular raw-starch-digesting α-amylase was isolated from Geobacillus thermodenitrificans HRO10. The culture conditions for the production of α-amylase by G. thermodenitrificans HRO10 was optimized in 1.2–l bioreactor using full 2⁴ and 3² factorial designs. From the optimal reaction conditions, a model (Y = − 594.206 − 0.178T² − 8.448pH² + 6.020TpH − 0.005T²pH²) was predicted, which was then used for α-amylase production. In the bioreactor studies, the enzyme yield under optimized conditions (pH 7.1, 49°C) was 30.20 U/ml, a 51% improvement over the results (19.97 U/ml) obtained when the traditional one-factor-at-a-time method was employed. This α-amylase does not require extraneous calcium ions for activity, which may be a commercially important observation.     

Cloning and Production of a Novel Bacteriocin, Lactococcin K, from Lactococcus lactis Subsp. lactis MY23

A gene encoding the antimicrobial peptide, lactococcin K, was isolated from Lactococcus lactis subsp. lactis MY23 then cloned and expressed in Escherichia coli. Because the expressed lactococcin K was formed as an inclusion body in recombinant E. coli, a fusion protein containing lactococcin K and maltose-binding protein (MBP) was produced in a soluble form. For high-level production of lactococcin K, we performed a pH-stat fed-batch culture to produce 43,000 AU lactococcin K ml⁻¹ in 12 h. Revisions requested 3 November 2005; Revisions received 7 December 2005     

Monoclonal antibody production: viability improvement of RC1 hybridoma cell in different types of bioreactor

The study was done to improve the viability of the RC1 hybridoma cell in order to produce more amount of monoclonal antibody (mAb). By using the optimized media, the cell had been cultured in two bioreactor systems which were the MiniPerm and Stirred Tank bioreactor (ST bioreactor), and the results were compared to the one obtained by using the T-Flask bioreactor which was used as a standard. The results showed that the ST bioreactor was able to improve the viability of the cell to the value of 91.8% which was a little bit better than the one obtained by the MiniPerm bioreactor (88.6%) and far better than that of achieved by the T-Flask bioreactor (76.4%). This was well correlated with the good growth performance of the cell in the ST bioreactor with the specific growth rate (μ) value of 0.0289 h⁻¹ followed by MiniPerm bioreactor with the value of 0.0243 h⁻¹ and then the T-Flask with the value of 0.0151 h⁻¹. The low value of doubling time (t _d ) obtained in the ST bioreactor (24 h) compared to the one obtained in the MiniPerm (29 h) and T-Flask bioreactor (46 h) had also contributed to the higher value of cell viability. As a result a higher concentration of mAb was able to be produced by the ST bioreactor (0.42 g l⁻¹) compared to that of the MiniPerm (0.37 g l⁻¹) and T-Flask bioreactor (0.23 g l⁻¹).     

Use of plant growth regulators in micropropagation of Kappaphycus alvarezii (Doty) in airlift bioreactors

The effects of plant growth regulators on callus induction rate and regeneration of K. alvarezii explants was evaluated. K. alvarezii calluses were induced in vitro with kinetin (K), 6-benzylaminopurine (B), 1-naphtalene acetic acid (N) and spermine (S). After 30 days, K. alvarezii explants produced filamentous calluses and isolated crystalline filaments growing from the medullar region and from cortical cells at the cut edge. The plant growth regulators 1-naphtalene acetic acid (1 mg L⁻¹) and 6-benzylaminopurine (1 mg L⁻¹) and the 1-naphtalene acetic acid + kinetin + spermine (1, 1, 0.018 mg L⁻¹ respectively) combination produced 85 to 129% more calluses, with significant differences versus the control (p<0.05). Spermine at 0.018 mg L⁻¹ produced calluses in the apical, intercalary and basal regions of explants. Spermine also reduced callus induction time to 7 days, which is faster than previously reported induction times with other plant growth regulators. An airlift bioreactor was designed and characterized to micropropagate K. alvarezii calluses. The bioreactor had mixing times ranging from 4.6–10.3 s at T ₉₀ and T ₉₅, which is shorter than those for the Fernbach (5.2–13.4 s) and balloon flasks (6.3–17.3 s). Mixing time standard deviations were smaller for the bioreactor (1.1–4.6) than for the Fernbach (9.3–13.6) and balloon flasks (5.5–15.8), suggesting an adequate flow regime within the bioreactor. The results are useful for improving callus induction in K. alvarezii and propagating microplantlets in an airlift bioreactor, and provide baseline data for macroalgal bioreactor culture.     

Direct Electrochemical Immunoassay Based on Immobilization of Protein-Magnetic Nanoparticle Composites on to Magnetic Electrode Surfaces by Sterically Enhanced Magnetic Field Force

A direct electrochemical immunoassay system based on the immobilization of α-1-fetoprotein antibody (anti-AFP), as a model system, on the surface of core-shell Fe₂O₃/Au magnetic nanoparticles (MNP) has been demonstrated. To fabricate such an assay system, anti-AFP was initially covalently immobilized on to the surface of core-shell Fe₂O₃/Au MNP. Anti-AFP-modified MNP (bio-nanoparticles) were then attached to the surface of carbon paste electrode with the aid of a permanent magnet. The performance and factors influencing the performance of the resulting immunosensor were studied. α-1-Fetoprotein antigen was directly determined by the change in current or potential before and after the antigen–antibody reaction versus saturated calomel electrode. The electrochemical immunoassay system reached 95% of steady-state potential within 2 min and had a sensitivity of 25.8 mV. The linear range for AFP determination was from 1 to 80 ng AFP ml⁻¹ with a detection limit of 0.5 ng AFP ml⁻¹. Moreover, the direct electrochemical immunoassay system, based on a functional MNP, can be developed further for DNA sensor and enzyme biosensor. Revisions requested 2 November 2005; Revisions received 17 January 2006     

Lipopolysaccharide of Escherichia coli, polyamines, and acetic acid stimulate cell proliferation in intestinal epithelial cells

Summary Our aim was to examine whether lipopolysaccharide of Escherichia coli, polyamines of dietetic and/or bacterial origin, and products of the bacterial metabolism influence cell proliferation in epithelial cells from the colon and small intestine. Lipopolysaccharide of Escherichia coli 0111:B4 was incubated with cultures from human colonic mucosa. The mitoses were arrested with Vincristine and the total number of metaphases per crypt was counted. In addition, lipopolysaccharide was incubated with a human colonic epithelial cell line from adenocarcinoma (LS-123 cells) and with a nontransformed small intestinal cell line from germ-free rats (IEC-6 cells) for 24 h. In the last 4 h, the cells were labeled with tritiated thymidine. The cells were incubated with putrescine, cadaverine, and spermidine at 10⁻¹¹–10⁻³ M and with acetic acid (10⁻⁵–10⁻¹ M), acetaldehyde (10⁻¹⁰–10⁻⁴ M) and ammonium chloride (1–20 mM). Lipopolysaccharide of Escherichia coli increased the number of arrested metaphases in human colonic crypts and DNA synthesis in L-123 and IEC-6 cells (P<0.001). All polyamines increased DNA synthesis in the colonic and small intestinal cell lines, the effects being more marked for putrescine (P<0.001). The higher concentrations of acetic acid increased DNA synthesis in both epithelial cell lines (P<0.001). Acetaldehyde slightly decreased DNA synthesis in LS-123 cells at cytotoxic concentrations. Ammonium chloride did not significantly affect DNA synthesis. The final concentration of nonionized ammonia was less than 3%. It is concluded that lipopolysaccharides of Escherichia coli and intraluminal factors derived from microorganisms increase cell proliferation in human colonic crypts and intestinal epithelial cell lines.     

Polymeric and Compositional Properties of Novel Extracellular Microbial Polyglucosamine Biopolymer from New Strain of Citrobacter sp. BL-4

A novel polyglucosamine polymer, PGB-2, was produced extracellularly from a new strain Citrobacter sp. BL-4 using pH-stat fed batch cultivation. It was composed of 97.3% glucosamine and 2.7% rhamnose; its average molecular weight, solubility in 2% acetic acid and viscosity were 20 kDa, 5 g l⁻¹ and 2.9 cps, respectively. FT-IR and ¹H NMR spectra of PGB-2 revealed a close identity with chitosan from crab shells. Received 20 September 2005; Revisions requested 6 October 2005; Revisions received 16 November 2005; Accepted 16 November 2005     

High-level Expression of an α-l-arabinofuranosidase from Thermotoga maritima in Escherichia coli for the Production of Xylobiose from Xylan

To efficiently produce xylobiose from xylan, high-level expression of an α-l-arabinofuranosidase gene from Thermotoga maritima was carried out in Escherichia coli. A 1.5-kb DNA fragment, coding for an α-l-arabinofuranosidase of T. maritima, was inserted into plasmid pET-20b without the pelB signal sequence leader, and produced pET-20b-araA1 with 8 nt spacing between ATG and Shine–Dalgarno sequence. A maximum activity of 12 U mg⁻¹ was obtained from cellular extract of E. coli BL21-CodonPlus (DE3)-RIL harboring pET-20b-araA1. The over-expressed α-l-arabinofuranosidase was purified 13-fold with a 94% yield from the cellular extract of E. coli by a simple heat treatment. Production of xylooligosaccharides from corncob xylan by endoxylanase and α-l-arabinofuranosidase was examined by TLC and HPLC: xylobiose was the major product from xylan at 90 °C and its proportion in the xylan hydrolyzates increased with the reaction time. Hydrolysis with in the xylanase absence of α-l-arabinofuranosidase gave only half this yield. Revisions requested 27 October 2005; Revisions received 5 September 2005     

Seasonal dynamics of fine root biomass, root length density, specific root length, and soil resource availability in a Larix gmelinii plantation

Fine root turnover is a major pathway for carbon and nutrient cycling in terrestrial ecosystems and is most likely sensitive to many global change factors. Despite the importance of fine root turnover in plant C allocation and nutrient cycling dynamics and the tremendous research efforts in the past, our understanding of it remains limited. This is because the dynamics processes associated with soil resources availability are still poorly understood. Soil moisture, temperature, and available nitrogen are the most important soil characteristics that impact fine root growth and mortality at both the individual root branch and at the ecosystem level. In temperate forest ecosystems, seasonal changes of soil resource availability will alter the pattern of carbon allocation to belowground. Therefore, fine root biomass, root length density (RLD) and specific root length (SRL) vary during the growing season. Studying seasonal changes of fine root biomass, RLD, and SRL associated with soil resource availability will help us understand the mechanistic controls of carbon to fine root longevity and turnover. The objective of this study was to understand whether seasonal variations of fine root biomass, RLD and SRL were associated with soil resource availability, such as moisture, temperature, and nitrogen, and to understand how these soil components impact fine root dynamics in Larix gmelinii plantation. We used a soil coring method to obtain fine root samples (⩽2 mm in diameter) every month from May to October in 2002 from a 17-year-old L. gmelinii plantation in Maoershan Experiment Station, Northeast Forestry University, China. Seventy-two soil cores (inside diameter 60 mm; depth intervals: 0–10 cm, 10–20 cm, 20–30 cm) were sampled randomly from three replicates 25 m × 30 m plots to estimate fine root biomass (live and dead), and calculate RLD and SRL. Soil moisture, temperature, and nitrogen (ammonia and nitrates) at three depth intervals were also analyzed in these plots. Results showed that the average standing fine root biomass (live and dead) was 189.1 g·m⁻²·a⁻¹, 50% (95.4 g·m⁻²·a⁻¹) in the surface soil layer (0–10 cm), 33% (61.5 g·m⁻²·a⁻¹), 17% (32.2 g·m⁻²·a⁻¹) in the middle (10–20 cm) and deep layer (20–30cm), respectively. Live and dead fine root biomass was the highest from May to July and in September, but lower in August and October. The live fine root biomass decreased and dead biomass increased during the growing season. Mean RLD (7,411.56 m·m⁻³·a⁻¹) and SRL (10.83 m·g⁻¹·a⁻¹) in the surface layer were higher than RLD (1 474.68 m·m⁻³·a⁻¹) and SRL (8.56 m·g⁻¹·a⁻¹) in the deep soil layer. RLD and SRL in May were the highest (10 621.45 m·m⁻³ and 14.83m·g⁻¹) compared with those in the other months, and RLD was the lowest in September (2 198.20 m·m⁻³) and SRL in October (3.77 m·g⁻¹). Seasonal dynamics of fine root biomass, RLD, and SRL showed a close relationship with changes in soil moisture, temperature, and nitrogen availability. To a lesser extent, the temperature could be determined by regression analysis. Fine roots in the upper soil layer have a function of absorbing moisture and nutrients, while the main function of deeper soil may be moisture uptake rather than nutrient acquisition. Therefore, carbon allocation to roots in the upper soil layer and deeper soil layer was different. Multiple regression analysis showed that variation in soil resource availability could explain 71–73% of the seasonal variation of RLD and SRL and 58% of the variation in fine root biomass. These results suggested a greater metabolic activity of fine roots living in soil with higher resource availability, which resulted in an increased allocation of carbohydrate to these roots, but a lower allocation of carbohydrate to those in soil with lower resource availability. __________ Translated from Acta Phytoecologica Sinica, 2005, 29(3): 403–410 [译自: 植物生态学报, 2005, 29(3): 403–410]