Selectivity in citric acid production by Yarrowia lipolytica

This experimental study reports about production selectivity in the fermentation of glucose to citric acid by Yarrowia lipolytica as a function of substrate concentration. Batch runs featuring biomass growth and one or two citric acid production phases were carried out in a 15-l stirred tank fermentor. The presented results demonstrate that working at high initial substrate concentration in the production phase is beneficial both in terms of a higher production rate of citric acid, the desired metabolite (reaching 0.077 h(-1)) and of a higher utilization degree of the employed carbon source (yield up to 0.384 g(c.a.)/g(glucose)). The production rate of isocitric acid, the major undesired metabolite, was found to be practically constant over the tested initial substrate concentration range.     

Chemostat study of citric acid production from glycerol by Yarrowia lipolytica

The aim of the study was to examine how the dilution rate and the chemical composition of the production medium impacts on the synthesis of citric acid by the Yarrowia lipolytica strain Wratislavia AWG7 from glycerol in a chemostat culture. The yeast Y. lipolytica Wratislavia AWG7, an acetate (acet(-)) and morphological (fil(-)) mutant, was cultured in a nitrogen- and phosphorus-limited medium at the dilution rate of 0.009-0.031h(-1) in the chemostat. Under steady-state conditions, the increase in the dilution rate was paralleled by the decrease in citric acid concentration (from 86.5 to 51.2gL(-1)), as well as by the increase in the volumetric rate (from 0.78 to 1.59gL(-1)h(-1)) and specific rate (from 0.05 to 0.18gg(-1)h(-1)) of citric acid production. The yield of the production process varied from 0.59 to 0.67gg(-1). In a 550-h continuous culture of the yeast test, at a dilution rate of 0.01h(-1), in a medium with enhanced concentrations of carbon, nitrogen and phosphorus sources, the concentration of citric acid, the concentration of biomass and the volumetric rate of citric acid production were 97.8gL(-1), 22.2gL(-1) and 0.98gL(-1)h(-1), respectively. The yield of the process decreased to 0.49gg(-1). The number of dead cells did not exceed 1% while that of the budding cells accounted for about 20%. Owing to the low content of isocitric acid and polyols, the fermentation process was characterized by a high purity. This study has produced the following finding: the double mutant Y. lipolytica AWG7 is an effective citric acid producer, with the ability to preserve its properties unchanged during the long run of the continuous chemostat process. This is a valued technological feature of such mutants.     

Biosensor online control of citric acid production from glucose by Yarrowia lipolytica using semicontinuous fermentation

Our study aimed at the development of an effective method for citric acid production from glucose by use of the yeast Yarrowia lipolytica. The new method included an automated bioprocess control using a glucose biosensor. Several fermentation methodologies including batch, fed‐batch, repeated batch and repeated fed‐batch cultivation were tested. The best results were achieved during repeated fed‐batch cultivation: Within 3 days of cycle duration, approximately 100 g/L citric acid were produced. The yields reached values between 0.51 and 0.65 g/g and the selectivity of the bioprocess for citric acid was as high as 94%. Due to the elongation of the production phase of the bioprocess with growth‐decoupled citric acid production, and by operating the fermentation in cycles, an increase in citric acid production of 32% was achieved compared with simple batch fermentation.     

Oxygen requirements for growth and citric acid production of Yarrowia lipolytica

During continuous cultivation of Yarrowia lipolytica N 1, oxygen requirements for growth and citric acid synthesis were found to depend on the iron concentration in the medium. A coupled effect of oxygen and iron concentrations on the functioning of the mitochondrial electron transport chain in Y. lipolytica N 1 was established. Based on the results obtained in continuous culture, conditions for citric acid production in a batch culture of Y. lipolytica N 1 were proposed. At relatively low pO(2) value and a high iron concentration, citric acid accumulation was as high as 120 g l(-1); the specific rate of citric acid synthesis reached 120 mg citric acid (g cells h)(-1). The mass yield coefficient was 0.87 and the energy yield coefficient was 0.31.     

The citric acid production from raw glycerol by Yarrowia lipolytica yeast and its regulation

The optimal cultivation conditions ensuring the maximal rate of citric acid (CA) biosynthesis by glycerol-grown mutant Yarrowia lipolytica NG40/UV7 were found to be as follows: growth limitation by inorganic nutrients (nitrogen, phosphorus, or sulfur), 28 °C, pH 5.0, dissolved oxygen concentration (pO₂) of 50 % (of air saturation), and pulsed addition of glycerol from 20 to 80 g L^?1 depending on the rate of medium titration. Under optimal conditions of fed-batch cultivation, in the medium with pure glycerol, strain Y. lipolytica NG40/UV7 produced 115 g L^?1 of CA with the mass yield coefficient of 0.64 g g^?1 and isocitric acid (ICA) amounted to 4.6 g L^?1; in the medium with raw glycerol, CA production was 112 g L^?1 with the mass yield coefficient of 0.90 g g^?1 and ICA amounted to 5.3 g L^?1. Based on the activities of enzymes involved in the initial stages of raw glycerol assimilation, the tricarboxylic acid cycle and the glyoxylate cycle, the mechanism of increased CA yield from glycerol-containing substrates in Y. lipolytica yeast was explained.     

Repeated fed-batch fermentation using biosensor online control for citric acid production by Yarrowia lipolytica

Biosensor-controlled substrate feeding was used in a citric acid production process with the yeast strain Yarrowia lipolytica H222 with glucose as the carbon source. The application of an online glucose biosensor measurement facilitated the performance of long-time repeated fed-batch process with automated bioprocess control. Ten cycles of repeated fed-batch fermentation were carried out in order to validate both the stability of the microorganism for citric acid production and the robustness of the glucose biosensor in a long-time experiment. In the course of this fermentation with a duration of 553 h, a slight loss of productivity from 1.4 g/(L×h) to 1.1 g/(L×h) and of selectivity for citric acid from 91% to 88% was observed. The glucose biosensor provided 6,227 measurements without any loss of activity.     

Production of citric acid with immobilized Yarrowia lipolytica

Summary Citric acid was produced with immobilized Yarrowia lipolytica yeast in repeated batch-shake-flask and air-lift fermentations. In active and passive immobilization methods calcium alginate, -carrageenan, polyurethane gel, nylon web and polyurethane foams were tested as carriers in repeated-batch fermentations. The highest citric acid productivity of 155 mg l^–1 h^–1 was reached with alginate-bead-immobilized cells in the first batch. A decrease in bead diameter from 5–6 mm to 2–3 mm increased the volumetric citric acid productivity threefold. In an air-lift bioreactor the highest citric acid productivity of 120 mg l^–1 h^–1 with a product concentration of 16.4 g l^–1 was obtained with cells immobilized in -carrageenan beads. Offprint requests to: H. Kautola     

Simultaneous production of citric acid and invertase by Yarrowia lipolytica SUC+ transformants

Simultaneous production of citric acid (CA) and invertase by Yarrowia lipolytica A-101-B56-5 (SUC⁺ clone) growing from sucrose, mixture of glucose and fructose, glucose or glycerol was investigated. Among the tested substrates the highest concentration of CA was reached from glycerol (57.15 g/L) with high yield (Y_CA/S = 0.6 g/g). When sucrose was used, comparable amount of CA was secreted (45 g/L) with slightly higher yield (Y_CA/S = 0.643 g/g). In all cultures amount of isocitrate (ICA) was below 2% of total citrates. Considering invertase production, the best carbon source appeared to be sucrose (72 380 U/L). The highest yield of CA and invertase biosynthesis calculated for 1 g of biomass was obtained for cells growing from glycerol (9.9 g/g and 4325 U/g, respectively). Concentrates of extra- and intracellular invertase of the highest activity were obtained from sucrose as substrate (0.5 and 1.8 × 10⁶ U/L, respectively).     

Obtaining of the mutant Yarrowia lipolytica strains producing citric acid from glucose

The possibility of obtaining mutant yeasts Yarrowia lipolytica VKM Y-2373 with increased ability to synthesize citric acid from glucose by using UV irradiation and N-methyl-NT-nitro-N-nitrosoguanidine was studied. Of 1500 colonies of the Y. lipolytica treated with either UV or N-methyl-NT-nitro-N-nitrosoguanidine, three mutants were selected that displayed higher (by 23%) biosynthetic ability as compared with the initial strain. Additionally, three mutants were selected from 1000 colonies of the Y. lipolytica exposed to a combined action of UV and N-methyl-NT-nitro-N-nitrosoguanidine; their biosynthetic activity exceeded that of the initial strain by 43.9%. The selective media with citrate and acetate were developed for a rapid selection of mutants as well as the express methods for the detection of active citric acid producers on the solid media with chalk and bromocresol containing a limiting concentration of amine nitrogen and an excess of glucose.     

High-yield production of citric acid by Yarrowia lipolytica on glycerol in repeated-batch bioreactors

An acetate negative mutant of Yarrowia lipolytica Wratislavia AWG7 was found to be suitable for the production of high amounts of citric acid in long-term repeated-batch cultures. When 40% of fresh replaced medium was fed, this strain produced 154 g l⁻¹, on average, which corresponded to a 0.78 g g⁻¹ yield and a productivity of 1.05 g l⁻¹ h⁻¹. The activity of the culture remained stable for more than 1,650 h, i.e., 16 cycles of the repeated-batch bioreactors.     

Acetate enhances citric acid production by Yarrowia lipolytica when grown on sunflower oil

It was discovered that the addition of 10 g/l acetate to a medium containing 30 g/l sunflower oil caused a drastic increase in citric acid production by Yarrowia lipolytica UOFS Y-1701 i.e. from 0.5 g/l in the absence of acetate to 18.7 g/l in the presence of acetate. Similarly, the ratio of citric acid:isocitric acid increased significantly from 1.7:1 in the absence of acetate to 3.7:1 in the presence of acetate after 240 h of growth.     

Yarrowia lipolytica as a potential producer of citric acid from raw glycerol

AIMS: To study the biochemical response of Yarrowia lipolytica LGAM S(7)1 during growth on raw glycerol (the main by-product of bio-diesel production units) in order to produce metabolic products of industrial significance. METHODS AND RESULTS:Yarrowia lipolytica was cultivated on raw glycerol or glucose in flasks. Although nitrogen-limited media were employed, growth was not followed by production of reserve lipid. Nitrogen limitation led to citric acid excretion. Growth and citric acid production parameters on glycerol were similar to those obtained on glucose. When high initial glycerol media were used, citric acid up to 35 g l(-1) (yield 0.42-0.44 g acid g(-1) glycerol consumed) was produced. CONCLUSIONS: Raw glycerol was an adequate substrate for Y. lipolytica. Growth was not followed by reserve lipid accumulation, but amounts of citric acid were produced. SIGNIFICANCE AND IMPACT OF THE STUDY: Raw glycerol is an industrial feedstock appearing in increasing quantities as the main by-product of bio-diesel production facilities. The present study describes an alternative way of glycerol valorization, with the production of remarkable amounts of citric acid, in addition to its main valorization way (production of 1,3-propanediol by bacteria).     

Citric acid production from sucrose by recombinant Yarrowia lipolytica using semicontinuous fermentation

The genetically modified yeast strain Yarrowia lipolytica H222‐S4(p67ICL1)T5 is able to utilize sucrose as a carbon source and to produce citric and isocitric acids in a more advantageous ratio as compared to its wild‐type equivalent. In this study, the effect of pH of the fermentation broth (pH 6.0 and 7.0) and proteose‐peptone addition on citric acid production by the recombinant yeast strain were investigated. It was found that the highest citric acid production occurred at pH 7.0 without any addition of proteose‐peptone. Furthermore, two process strategies (fed‐batch and repeated fed‐batch) were tested for their applicability for use in citric acid production from sucrose by Y. lipolytica. Repeated fed‐batch cultivation was found to be the most effective process strategy: in 3 days of cycle duration, approximately 80 g/L citric acid was produced, the yield was at least 0.57 g/g and the productivity was as much as 1.1 g/Lh. The selectivity of the bioprocess for citric acid was always higher than 90% from the very beginning of the fermentation due to the genetic modification, reaching values of up to 96.4% after 5 days of cycle duration.     

Effect of agitation and aeration on the citric acid production by Yarrowia lipolytica grown on glycerol

The effects of agitation rates from 400 to 900 rpm and aeration rates ranging from 0.18 to 0.6 vvm on biomass and citric acid production on glycerol media by acetate-negative mutants of Yarrowia lipolytica, Wratislavia 1.31 and Wratislavia AWG7, in batch culture were studied. The agitation rates of 800 and 900 rpm (at a constant aeration rate of 0.36 vvm) and aeration rates within the range of 0.24-0.48 vvm (at a constant agitation rate of 800 rpm), which generated dissolved oxygen concentration (DO) higher than 40%, were found the best for citric acid biosynthesis from glycerol. An increase in agitation rate (higher than 800 rpm) and aeration rate (higher than 0.36 vvm) had no impact on DO and citric acid production. The highest citric acid concentration (92.8 g/L) and yield (0.63 g/g) were obtained with Wratislavia 1.31 strain at 0.24 vvm. The highest volumetric citric acid production rate (1.15 g/Lh) and specific citric acid production rate (0.071 g/gh) were reached at 0.48 vvm.     

Optimization of citric acid production from Candida lipolytica Y-1095 using n-paraffin

Currently, the majority of worldwide microbial production of citric acid utilizes Aspergillus niger in a carbohydrate based submerged fermentation. Due to their high carbon content, hydrocarbons also have the potential of producing high concentrations of citric acid. Initial lab experiments conducted using 1875 ml batch fermentations with n-paraffin found that Candida lipolytica NRRL-Y-1095 assimilated the feedstock and had a citric acid productivity of 47 mg l(-1) h(-1). To determine the optimum level of initial biomass concentration, n-paraffin concentration, iron concentration and temperature for the production of citric acid, a central composite design was developed using 200 ml batch fermentations. The design involved conducting 31 batch fermentations under various combinations of high and low values of these four parameters. From this investigation empirical models were developed describing the interactions between the experimental parameters and citric acid production. It was found that the maximum concentration of citric acid produced was 9.8 g l(-1) and the optimum levels of each parameter for citric acid production were, 10--12% volume for initial biomass concentration, 10--15% volume for n-paraffin concentration, 10 mg l(-1) for ferric nitrate concentration, and 26--30 degrees C for temperature.     

Citric acid production from sucrose using a recombinant strain of the yeast Yarrowia lipolytica

The yeast Yarrowia lipolytica is able to secrete high amounts of several organic acids under conditions of growth limitation and carbon source excess. Here we report the production of citric acid (CA) in a fed-batch cultivation process on sucrose using the recombinant Y. lipolytica strain H222-S4(p67ICL1) T5, harbouring the invertase encoding ScSUC2 gene of Saccharomyces cerevisiae under the inducible XPR2 promoter control and multiple ICL1 copies (10–15). The pH-dependent expression of invertase was low at pH 5.0 and was identified as limiting factor of the CA-production bioprocess. The invertase expression was sufficiently enhanced at pH 6.0–6.8 and resulted in production of 127–140 g l⁻¹ CA with a yield Y _CA of 0.75–0.82 g g⁻¹, whereas at pH 5.0, 87 g l ⁻¹ with a yield Y _CA of 0.51 gg⁻¹ were produced. The CA-productivity Q _CA increased from 0.40 g l ⁻¹ h⁻¹ at pH 5.0 up to 0.73 g l ⁻¹ h⁻¹ at pH 6.8. Accumulation of glucose and fructose at high invertase expression level at pH 6.8 indicated a limitation of CA production by sugar uptake. The strain H222-S4(p67ICL1) T5 also exhibited a gene–dose-dependent high isocitrate lyase expression resulting in strong reduction (<5%) of isocitric acid, a by-product during CA production.     

Improved production of citric acid by Yarrowia lipolytica using oleic acid as the oxygen‐vector and co‐substrate

Yarrowia lipolytica is able to secrete large amounts of citric acid (CA), which is greatly affected by the dissolved oxygen concentration (DOC) in the fermentation medium. In this study, oleic acid was selected as oxygen‐vector to improve DOC during CA fermentation. When 2% (v/v) of oleic acid was added to the culture broth, higher DOC (>42.1%) was determined throughout the CA synthesis phase. The yield of CA reached a maximum of 32.1 g/L (25.4% higher than the control) and the biomass was 8.8 g/L. The substrate uptake rate, products formation rate and key enzyme activities were also determined, and the results indicated that CA synthesis was strengthened with oleic acid addition. Furthermore, it was detected that oleic acid could be assimilated by the cells, which means that oleic acid could be served both as oxygen‐vector and co‐substrate for CA synthesis by Y. lipolytica. In a bioreactor with working volume of 3 L, the highest concentration of CA reached to 36. 4 g/L in the presence of 2% (v/v) oleic acid after 192 h of fermentation. These results confirmed that oleic acid could be applied in the large‐scale production of CA by Y. lipolytica.     

Investigation of mitochondrial protein expression profiles of Yarrowia lipolytica in response to citric acid production

Bioprocess and Biosystems Engineering - Nitrogen-limiting condition is essential for citric acid production by Yarrowia lipolytica. Mitochondrial protein expression profiles of Y. lipolytica IMUFRJ...     

Studies on citric acid production with immobilized Yarrowia lipolytica in repeated batch and continuous air-lift bioreactors

Citric acid was produced from glucose in repeated-batch shake-flask and continuous air-lift cultivations by calcium-alginate-immobilized Yarrowia lipolytica A-101 yeast. The medium composition was systematically studied in a batch system by using experimental design and empiric modelling. The highest citric acid product concentration of 39 g/l was reached with a medium containing 150 g/l of glucose, 0.105 g/l of potassium dihydrogen phosphate, 0.84 g/l of magnesium sulphate and 21 mg/l of copper sulphate (5.2 mg/l of copper). The results were further improved by hardening the alginate carrier beads with glutaraldehyde, and by activation of the immobilized biocatalyst in a nutrient solution. In continuous air-lift bioreactors with varying height-to-diameter ratio the highest productivity of 350 mg/l per hour with a dilution rate of 0.023 l/h and a citric acid product concentration of 12 g/l was reached with a ratio of 3. Correspondence to: H. Kautola     

Isocitric acid production from rapeseed oil by Yarrowia lipolytica yeast

Production of d _S-threo-isocitric acid (ICA) by yeast meets serious difficulties since it is accompanied by a simultaneous production of citric acid (CA) in significant amounts that reduces the yield of desired product. In order to develop an effective process of ICA production, 60 yeast strains of different genera (Candida, Pichia, Saccharomyces, Torulopsis, and Yarrowia) were tested for their ability to produce ICA from rapeseed oil; as a result, wild-type strain Yarrowia lipolytica VKM Y-2373 and its mutant Y. lipolytica 704-UV4-A/NG50 were selected as promising ICA producers. The effects of temperature, pH, aeration, and concentrations of rapeseed oil, iron, and itaconic acid on ICA production by selected strains were studied. Under optimal conditions (pH 6.0; aeration 50–55 %; rapeseed oil concentration of 20–60 gl^?1, iron ion concentration of 1.2 mg l^?1, and itaconic acid amount of 30 mM), selected strains of Y. lipolytica produced predominantly ICA with a low amount of a by-product, CA.