On-line monitoring of cell concentration of Perilla frutescens in a bioreactor

This article demonstrates the successful in situ real-time monitoring of the cell concentration of Perilla frutescens in a bioreactor by using a laser turbidimeter. It was found that turbidity measurements at 780 nm with the laser sensor were hardly affected by the red color of the anthocyanin produced by P. frutescens cells, nor by the aeration rate or agitation speed within the ranges investigated. There was an excellent linear relationship, with a correlation coefficient (r(2)) higher than 0.99, between the sensor's response and the cell concentration. The whole growth stage of the cells, i.e., lag, logarithmic, and stationary phases, in bioreactor cultivations, could be satisfactorily estimated on-line by means of the in situ turbidimeter. However, during the declining phase of the cells, an apparent deviation was observed between the on-line estimations and off-line measurements of cell concentrations by dry cell weight, while the wet cell weight could be estimated by the same turbidimeter system. We found that this deviation was caused by a decrease in the cell density due to an increase of the individual cell volume and a decrease of the cell dry weight during the declining phase. (c) 1993 John Wiley & Sons, Inc.     

Nutrient-split feeding strategy for dialysis cultivation of Escherichia coli

Reduction in nutrient loss during dialysis cultivation of Escherichia coli on a glycerol medium was investigated. A dialysis reactor with an inner fermentation and an outer dialysis chamber was used. Aerobic condition was maintained by limiting the glycerol feed rate to an optimum value which was estimated from the oxygen requirements for glycerol oxidation and oxygen transfer capacity of the reactor. High reduction in nutrient loss was achieved by using water as the dialyzing fluid. However, osmotic movement of water from the dialysis to the fermentation chamber was observed, and the final cell concentration was low. With a nutrient-split feeding strategy (feeding glycerol directly to the fermentation chamber and dialyzing with salt solution), glycerol loss was small, there was no osmotic flux of water to the fermentation chamber, and the cell concentration was high. Both glycerol and salt loss could be avoided, and a cell concentration of 170 g/L was obtained when the dialysis process was substituted by addition of XAD adsorbents to the dialysis chamber. Application of this nutrient-split feeding strategy to cell cultivation in a stirred tank reactor, coupled with dialysis in external dialyzer modules, resulted in low cell concentrations. (c) 1993 Wiley & Sons, Inc.     

中国优质水果资源的分布与适宜生态环境

根据农业部在80年代两次组织评选出的全国189个优质水果产地的生态环境资料,用微型电子计算机系统建立数据库,统计分析柑桔、苹果和梨优质产品的构成比例、产区分布地域及其适宜的环境指标和主栽品种的生态适应性,为果树良种区域化栽培与选育提供依据。     

Protein enrichment of sweet potato residue by solid-state cultivation with mono- and co-cultures of amylolytic fungi

The degree of protein enrichment of sweet potato residue by different amylolytic moulds in solid-state cultivation was much greater than that obtained using amylolytic yeasts. The optimum initial moisture content for protein enrichment was about 65% (w/w). Adding nitrogen sources to the culture twice (at the start of the incubation and after 24 h) considerably improved the final protein content. A co-culture of amylolytic mycelial fungi yielded a product with 32% (w/w) crude protein after 4 days' incubation at 30°C. In a column reactor, the highest temperatures reached were 42°C and 40°C and the minimum O₂ concentrations were 1.5% and 2.5% of full saturation in the central and bottom layers, respectively.     

日本大萝卜引种栽培研究

本文报道日本大萝卜引种栽培的试验结果,并为推广这一蔬菜新品种提供了有效的栽培技术措施。     

中国东北地区三种蜜环菌的生物学特性及奥氏蜜环菌人工培养

蜜环菌属Armillaria真菌具有较高的食药用价值。由于蜜环菌的生长发育过程较复杂,还未完全实现商业化栽培,野生资源的供应受到季节性和地域性的影响。本研究以采自东北地区蜜环菌属的3个菌株为研究对象,通过培养物的形态特征及分子标记确定菌株JG19016为奥氏蜜环菌A. ostoyae,菌株JG19017为高卢蜜环菌A. gallica,菌株JG19018为中国蜜环菌生物种C。奥氏蜜环菌JG19016最适生长温度为25 ℃,高卢蜜环菌JG19017的最适生长温度为22 ℃,中国蜜环菌生物种C JG19018则在22-25 ℃时菌丝生长速度最快;3个菌株最适pH为5-6。奥氏蜜环菌JG19016对葡萄糖和蔗糖利用率较好,高卢蜜环菌JG19017对葡萄糖利用率较好,中国蜜环菌生物种C JG19018对葡萄糖和淀粉利用率较好;蛋白胨对3个菌株促进作用最强,为最适氮源。培养基中加入VB₁,对3个菌株的菌丝生长均有明显的促进作用。奥氏蜜环菌JG19016菌丝生长的最优培养基配方为：葡萄糖20 g,蛋白胨3 g,磷酸二氢钾2 g,硫酸镁1.5 g,VB₁ 10 mg,琼脂20 g,水1 L。在木屑基质中培养,其配方的最优碳氮比为38:1,最佳木屑粗细比为3:1以上。出菇条件探索结果显示,菌丝及菌索长满菌袋(17 mm×33 mm×5 mm丝聚乙烯袋)需要50-60 d,之后在18 ℃、60%湿度和12 h散射光的环境中,10 d左右可观察到原基产生。增加菇房湿度到90%-95%,2-3 d可观察到1-3 cm的幼子实体,7 d左右菌柄和菌盖完全分化,10 d左右观察到菌盖展开。     

Continuous culture of Humicola lutea 120-5 for acid proteinase production

Acid proteinase production by the fungus Humicola lutea 120-5 in continuous culture was studied. The maximum activity of the culture broth reached 2200 U/ml at a dilution rate (D) of 0.05/h. The continuous process was carried out for 1 month without any bacterial contamination, due to low pH (3.0–3.5) during the cultivation.     

双碳源单细胞蛋白间歇培养及流加培养的动力学模型

应用非结构的逻辑增殖模型研究了两种酵母的单碳源和双碳源单细胞蛋白间歇培养的动力学,用改进的逻辑增殖模型研究了双碳源流加培养过程的动力学,从实验数据拟合了动力学模型参数,模型计算值与实验数据吻合良好。     

Characterization of a pilot plant airlift tower loop bioreactor: II. Evaluation of global mixing properties of the gas phase during yeast cultivation

Saccharomyces cerevisiae was cultivated in a 4-m(3) pilot plant airlift tower loop reactor with a draft tube in batch and continuous operations and for comparison in a laboratory airlift tower loop reactor of 0.08 m(3) volume. The reactors were characterized during and after the cultivation by measuring the distributions of the residence times of the gas phase with pseudostochastic tracer signals and mass spectrometer and by evaluating the mixing in the liquid phase with a pulse-shaped volatile tracer signal and mass spectrometer as a detector. The mean residence times and the intensities of the axial mixing in the riser and downcomer, the circulation times of the gas phase, and the fraction of the recirculated gas phase were evaluated and compared.     

Spray system for re-attachment of Gelidium sesquipedale (Clem.) Born. et Thur. (Gelidiales: Rhodophyta)

A system is described for rapid re-attachment of the rhodophycean alga Gelidium sesquipedale (Clem.) Born. et Thur. on artificial or natural substrata. This method is applicable to industrial cultivation of this species. The function of rhizoidal clusters and the origin of germlings from the apical portion of the thalli are analyzed in relation to the re-attachment process. The role that re-attachment might play in the maintenance and spreading of natural populations and in the observed anomalies of the life-history of this species is discussed.