Redirection of metabolic flux for high levels of omega‐7 monounsaturated fatty acid accumulation in camelina seeds

Seed oils enriched in omega‐7 monounsaturated fatty acids, including palmitoleic acid (16:1?9) and cis‐vaccenic acid (18:1?11), have nutraceutical and industrial value for polyethylene production and biofuels. Existing oilseed crops accumulate only small amounts (<2%) of these novel fatty acids in their seed oils. We demonstrate a strategy for enhanced production of omega‐7 monounsaturated fatty acids in camelina (Camelina sativa) and soybean (Glycine max) that is dependent on redirection of metabolic flux from the typical ?9 desaturation of stearoyl (18:0)‐acyl carrier protein (ACP) to ?9 desaturation of palmitoyl (16:0)‐acyl carrier protein (ACP) and coenzyme A (CoA). This was achieved by seed‐specific co‐expression of a mutant ?9‐acyl‐ACP and an acyl‐CoA desaturase with high specificity for 16:0‐ACP and CoA substrates, respectively. This strategy was most effective in camelina where seed oils with ~17% omega‐7 monounsaturated fatty acids were obtained. Further increases in omega‐7 fatty acid accumulation to 60–65% of the total fatty acids in camelina seeds were achieved by inclusion of seed‐specific suppression of 3‐keto‐acyl‐ACP synthase II and the FatB 16:0‐ACP thioesterase genes to increase substrate pool sizes of 16:0‐ACP for the ?9‐acyl‐ACP desaturase and by blocking C18 fatty acid elongation. Seeds from these lines also had total saturated fatty acids reduced to ~5% of the seed oil versus ~12% in seeds of nontransformed plants. Consistent with accumulation of triacylglycerol species with shorter fatty acid chain lengths and increased monounsaturation, seed oils from engineered lines had marked shifts in thermotropic properties that may be of value for biofuel applications.     

The coexpression of two desaturases provides an optimized reduction of saturates in camelina oil

Reducing the saturate content of vegetable oils is key to increasing their utility and adoption as a feedstock for the production of biofuels. Expression of either the FAT5 16 : 0-CoA desaturase from Caenorhabditis elegans, or an engineered cyanobacterial 16 : 0/18 : 0-glycerolipid desaturase, DES9*, in seeds of Arabidopsis (Arabidopsis thaliana) substantially lowered oil saturates. However, because pathway fluxes and regulation of oil synthesis are known to differ across species, translating this transgene technology from the model plant to crop species requires additional investigation. In the work reported here, we found that high expression of FAT5 in seeds of camelina (Camelina sativa) provided only a moderate decrease in saturates, from 12.9% of total oil fatty acids in untransformed controls to 8.6%. Expression of DES9* reduced saturates to 4.6%, but compromised seed physiology and oil content. However, the coexpression of the two desaturases together cooperatively reduced saturates to only 4.0%, less than one-third of the level in the parental line, without compromising oil yield or seedling germination and establishment. Our successful lowering of oil saturates in camelina identifies strategies that can now be integrated with genetic engineering approaches that reduce polyunsaturates to provide optimized oil composition for biofuels in camelina and other oil seed crops.     

Expression of the Arabidopsis ADS1 gene in Brassica juncea results in a decreased level of total saturated fatty acids

Brassica juncea plants transformed with the Arabidopsis ADS1 gene, which encodes a plant homologue of the mammalian and yeast acyl-CoA Delta9 desaturases and the cyanobateria acyl-lipid Delta9 desaturase, were found to have a statistically significant decrease in the level of saturated fatty acids in seeds. The decrease in the level of saturated fatty acids is largely attributable to decreases in palmitic acid (16:0) and stearic acid (18:0), although arachidic acid (20:0), behenic acid (22:0) and lignoceric acid (24:0) were also decreased in the transgenic seeds compared to the negative control lines. As a result, the level of oleic acid (18:1) was slightly increased in the transgenic seed lines compared to the non-transformed controls. However, a decrease in saturated fatty acid is not always accompanied by the corresponding increase in mono-unsaturated fatty acids. For example, palmitoleic acid (16:1), gondoic acid (20:1) and nervonic acid (24:1) were all found to be decreased in transgenic seeds. The levels of linoleic acid (18:2) and linolenic acid (18:3) were also notably changed in the transgenic lines compared to the controls. The present study provides preliminary experimental data suggesting that the Arabidopsis ADS1 encodes a fatty acid Delta9 desaturase and could be useful in genetic engineering for modifying the level of saturated fatty acids in oilseed crops. However, the effect of ADS1 gene expression on seed oil fatty acid composition is beyond the changes of total saturated and mono-unsaturated fatty acids, which suggests a complex mechanism is involved in the regulation of fatty acid metabolism.     

Expression of yeast acyl-CoA-∆9 desaturase leads to accumulation of unusual monounsaturated fatty acids in soybean seeds

An acyl-CoA-Δ9 desaturase from Saccharomyces cerevisiae was expressed by subcellular-targeting in soybean (Glycine max) seeds with the goal of increasing palmitoleic acid (16:1Δ9), a high-valued fatty acid (FA), and simultaneously decreasing saturated FA in oil. The expression resulted in the conversion of palmitic acid (16:0) to 16:1Δ9 in soybean seeds. 16:1Δ9 and its elongation product cis-vaccenic acid (18:1Δ11) were increased to 17 % of the total fatty acids by plastid-targeted expression of the enzyme. Other lipid changes include the decrease of polyunsaturated FA and saturated FA, suggesting that a mechanism exists downstream in oil biosynthesis to compensate the FA alternation. This is the first time a cytosolic acyl-CoA-?9 desaturase is functionally expressed in plastid and stronger activity was achieved than its cytosolic expression. The present study provides a new strategy for converting 16:0 to 16:1Δ9 by engineering acyl-CoA-Δ9 desaturase in commercialized oilseeds.     

Functional complementation of a periila ω3 fatty acid desaturase under the seed-specific SeFAD2 promoter

Functional characterization of the fatty acid desaturase genes and seed-specific promoters is prerequisite for altering the unsaturated fatty acid content of oilseeds by genetic manipulation. The ω-6 fatty acid desaturase (FAD2) and ω-3 fatty acid desaturase (FAD3) catalyze extra-plastidial desaturation of oleic acid to linoleic acid and linoleic acid to linolenic acid, respectively. These are major constituents in seed storage oils. Here, we report the complementation of a perilla linoleic acid desaturase (PrFAD3) cDNA under the seed-specific sesame FAD2 (SeFAD2) promoter in the Arabidopsis fad3 mutant. PrFAD3 is functionally active and the SeFAD2 promoter is applicable for modifying fatty acid composition in developing seeds. Transient expression of the GUS gene under that promoter in the developing seeds and leaves of sesame, soybean, and corn via microprojectile bombardment indicated that the SeFAD2 promoter likely will be useful for altering the seed phenotypes of dicot and monocot crops.     

A mutation in Arabidopsis cytochrome b5 reductase identified by high-throughput screening differentially affects hydroxylation and desaturation

As a model for analyzing the production of novel fatty acids in oilseeds, we used the genetic and molecular techniques available for Arabidopsis to characterize modifying mutations affecting the accumulation of hydroxy fatty acids in the seeds of Arabidopsis plants that express a transgene for the castor bean fatty acid hydroxylase, FAH12. We developed a high-throughput analytical system and used it to identify three complementation classes of mutations with reduced hydroxy fatty acid accumulation from among Arabidopsis M3 seed samples derived from chemical mutagenesis. We identified one of the mutations by positional cloning as a single base pair change in a gene encoding NADH:cytochrome b5 reductase (CBR1, At5g17770). When expressed in yeast, the mutant form of the enzyme was less active and less stable than the wild-type enzyme. Characterization of homozygous mutant lines with and without the FAH12 transgene (FAH12 cbr1-1 and cbr1-1, respectively) indicated that the only detectable consequence of the cbr1-1 mutation was on desaturase and hydroxylase reactions in the developing seed. The leaf and root fatty compositions, as well as the growth, development and seed production of mutant plants were indistinguishable from wild type. Interestingly, while the cbr1-1 mutation reduced the accumulation of hydroxy fatty acids in seeds by 85%, the effects on 18:1 and 18:2 desaturation reactions were much less (<25% and <60%, respectively). These results suggest that there is competition in developing seeds among the several reactions that utilize reduced cytochrome b5.     

Emergence timing and fitness consequences of variation in seed oil composition in Arabidopsis thaliana

Early seedling emergence can increase plant fitness under competition. Seed oil composition (the types and relative amounts of fatty acids in the oils) may play an important role in determining emergence timing and early growth rate in oilseeds. Saturated fatty acids provide more energy per carbon atom than unsaturated fatty acids but have substantially higher melting points (when chain length is held constant). This characteristic forms the basis of an adaptive hypothesis that lower melting point seeds (lower proportion of saturated fatty acids) should be favored under colder germination temperatures due to earlier germination and faster growth before photosynthesis, while at warmer germination temperatures, seeds with a higher amount of energy (higher proportion of saturated fatty acids) should be favored. To assess the effects of seed oil melting point on timing of seedling emergence and fitness, high‐ and low‐melting point lines from a recombinant inbred cross of Arabidopsis thaliana were competed in a fully factorial experiment at warm and cold temperatures with two different density treatments. Emergence timing between these lines was not significantly different at either temperature, which aligned with warm temperature predictions, but not cold temperature predictions. Under all conditions, plants competing against high‐melting point lines had lower fitness relative to those against low‐melting point lines, which matched expectations for undifferentiated emergence times.     

Engineering the production of conjugated fatty acids in Arabidopsis thaliana leaves

The seeds of many nondomesticated plant species synthesize oils containing high amounts of a single unusual fatty acid, many of which have potential usage in industry. Despite the identification of enzymes for unusual oxidized fatty acid synthesis, the production of these fatty acids in engineered seeds remains low and is often hampered by their inefficient exclusion from phospholipids. Recent studies have established the feasibility of increasing triacylglycerol content in plant leaves, which provides a novel approach for increasing energy density of biomass crops. Here, we determined whether the fatty acid composition of leaf oil could be engineered to accumulate unusual fatty acids. Eleostearic acid (ESA) is a conjugated fatty acid produced in seeds of the tung tree (Vernicia fordii) and has both industrial and nutritional end‐uses. Arabidopsis thaliana lines with elevated leaf oil were first generated by transforming wild‐type, cgi‐58 or pxa1 mutants (the latter two of which contain mutations disrupting fatty acid breakdown) with the diacylglycerol acyltransferases (DGAT1 or DGAT2) and/or oleosin genes from tung. High‐leaf‐oil plant lines were then transformed with tung FADX, which encodes the fatty acid desaturase/conjugase responsible for ESA synthesis. Analysis of lipids in leaves revealed that ESA was efficiently excluded from phospholipids, and co‐expression of tung FADX and DGAT2 promoted a synergistic increase in leaf oil content and ESA accumulation. Taken together, these results provide a new approach for increasing leaf oil content that is coupled with accumulation of unusual fatty acids. Implications for production of biofuels, bioproducts, and plant–pest interactions are discussed.     

What limits production of unusual monoenoic fatty acids in transgenic plants?

Unusual monounsaturated fatty acids are major constituents (greater than 80%) in seeds of Coriandrum sativum L. (coriander) and Thunbergia alata Bojer, as well as in glandular trichomes (greater than 80% derived products) of Pelargonium x hortorum (geranium). These diverged fatty acid structures are produced via distinct plastidial acyl-acyl carrier protein (ACP) desaturases. When expressed in Arabidopsis thaliana (L.) Heynh. under strong seed-specific promoters the unusual acyl-ACP desaturases resulted in accumulation of unusual monoene fatty acids at 1-15% of seed fatty acid mass. In this study, we have examined several factors that potentially limit higher production of unusual monoenes in transgenic oilseeds. (i) Immunoblots indicated that the introduced desaturases were expressed at levels equivalent to or higher than the endogenous delta9 18:0-ACP desaturase. However, the level of unusual fatty acid produced in transgenic plants was not correlated with the level of desaturase expression. (ii) The unusual desaturases were expressed in several backgrounds, including antisense 18:0-ACP desaturase plants, in fab1 mutants, and co-expressed with specialized ACP or ferredoxin isoforms. None of these experiments led to high production of expected products. (iii) No evidence was found for degradation of the unusual fatty acids during seed development. (iv) Petroselinic acid added to developing seeds was incorporated into triacylglycerol as readily as oleic acid, suggesting no major barriers to its metabolism by enzymes of glycerolipid assembly. (v) In vitro and in situ assay of acyl-ACP desaturases revealed a large discrepancy of activity when comparing unusual acyl-ACP desaturases with the endogenous delta9 18:0-ACP desaturase. The combined results, coupled with the sensitivity of acyl-ACP desaturase activity to centrifugation and low salt or detergent suggests low production of unusual monoenes in transgenic plants may be due to the lack of, or incorrect assemble of, a necessary multi-component enzyme association.     

Identification,characterization and field testing of Brassica napus mutants producing high‐oleic oils

Producing healthy, high‐oleic oils and eliminating trans‐fatty acids from foods are two goals that can be addressed by reducing activity of the oleate desaturase, FAD2, in oilseeds. However, it is essential to understand the consequences of reducing FAD2 activity on the metabolism, cell biology and physiology of oilseed crop plants. Here, we translate knowledge from studies of fad2 mutants in Arabidopsis (Arabidopsis thaliana) to investigate the limits of non‐GMO approaches to maximize oleic acid in the seed oil of canola (Brassica napus), a species that expresses three active FAD2 isozymes. A series of hypomorphic and null mutations in the FAD2.A5 isoform were characterized in yeast (Saccharomyes cerevisiae). Then, four of these were combined with null mutations in the other two isozymes, FAD2.C5 and FAD2.C1. The resulting mutant lines contained 71–87% oleic acid in their seed oil, compared with 62% in wild‐type controls. All the mutant lines grew well in a greenhouse, but in field experiments we observed a clear demarcation in plant performance. Mutant lines containing less than 80% oleate in the seed oil were indistinguishable from wild‐type controls in growth parameters and seed oil content. By contrast, lines with more than 80% oleate in the seed oil had significantly lower seedling establishment and vigor, delayed flowering and reduced plant height at maturity. These lines also had 7–11% reductions in seed oil content. Our results extend understanding of the B. napusFAD2 isozymes and define the practical limit to increasing oil oleate content in this crop species.     

Comparative evaluation of rumen‐protected fat,coconut oil and various oilseeds supplemented to fattening bulls

The effects of five different dietary fat supplements on fatty acid composition and oxidative stability of subcutaneous and kidney fat were evaluated in 36 Brown Swiss bulls and compared to a low fat diet in a monofactorial design. The following fat supplements were provided as additional fat at 30 g per kg feed dry matter: crystalline rumen‐protected fat, coconut oil, and three types of crushed whole oilseeds (rapeseed, sunflower seed and linseed). Adipose tissues reflected differences (P < 0.05) in dietary fatty acid composition although to a lower extent. Using protected fat, which contained elevated levels of trans fatty acids, and sunflower seed, containing a high proportion of linoleic acid, significantly increased C18:1 trans fatty acid proportion in the adipose tissues. The use of sunflower seed increased conjugated linoleic acid. The oilseeds resulted in lower amounts of C16:0 in favour of C18:0. Except for linseed, all fat supplemented groups improved oxidative stability of adipose tissues as compared with control. This was explained by lower proportions of unsaturated fatty acids in adipose tissue (protected fat), by elevated α‐tocopherol contents (rapeseed, sunflower seed) or by a combination of both (coconut oil). Fat colour remained unaffected by treatments. Compared to other fat supplements oilseeds, especially sunflower seed and rapeseed, can therefore be recommended to be fed to bulls in order to increase the proportions of C18 unsaturated fatty acids in adipose tissues and to maintain or improve oxidative stability.     

Successful high‐level accumulation of fish oil omega‐3 long‐chain polyunsaturated fatty acids in a transgenic oilseed crop

Omega‐3 (also called n‐3) long‐chain polyunsaturated fatty acids (≥C20; LC‐PUFAs) are of considerable interest, based on clear evidence of dietary health benefits and the concurrent decline of global sources (fish oils). Generating alternative transgenic plant sources of omega‐3 LC‐PUFAs, i.e. eicosapentaenoic acid (20:5 n‐3, EPA) and docosahexaenoic acid (22:6 n‐3, DHA) has previously proved problematic. Here we describe a set of heterologous genes capable of efficiently directing synthesis of these fatty acids in the seed oil of the crop Camelina sativa, while simultaneously avoiding accumulation of undesirable intermediate fatty acids. We describe two iterations: RRes_EPA in which seeds contain EPA levels of up to 31% (mean 24%), and RRes_DHA, in which seeds accumulate up to 12% EPA and 14% DHA (mean 11% EPA and 8% DHA). These omega‐3 LC‐PUFA levels are equivalent to those in fish oils, and represent a sustainable, terrestrial source of these fatty acids. We also describe the distribution of these non‐native fatty acids within C. sativa seed lipids, and consider these data in the context of our current understanding of acyl exchange during seed oil synthesis.     

Traits of fatty acid accumulation in dimorphic seeds of the euhalophyte Suaeda salsa in saline conditions

The mechanism on of how salinity affects seed fatty acids accumulation remains unclear in halophytes. The present results revealed that the content of total unsaturated fatty acids in black seeds was higher than in brown seeds in the euhalophyte Suaeda salsa under controlled saline conditions. Salinity (200?mM NaCl) significantly increased the total oil content, unsaturated acid/saturated acid ratio, and content of α-linolenic acid (C18:3) (ALA), especially in brown seeds. The most abundant fatty acid in dimorphic seeds is linoleic acid (C18:2) (>70%). It appears that more ALA accumulated in brown seeds compared to black seeds. The enzyme activity of omega-3 fatty acid desaturase (ω-3 FAD) in brown seeds was much higher than that in black seeds, but salinity had no significant effect on the activity of ω-3 FAD in both brown and black seeds. The relative expression of SsFAD7 was increased by salinity, and the value in brown seeds was much higher than that in black seeds. This means salinity can, salinity can improve the quantity of fatty acids in dimorphic seeds of S. salsa, and the enzyme of ω-3 FAD and SsFAD7 may involve in the accumulation of ALA in dimorphic seeds under salinity.     

Cloning and characterization of unusual fatty acid desaturases from Anemone leveillei: identification of an acyl-coenzyme A C20 Delta5-desaturase responsible for the synthesis of sciadonic acid

The seed oil of Anemone leveillei contains significant amounts of sciadonic acid (20:3Delta(5,11,14); SA), an unusual non-methylene-interrupted fatty acid with pharmaceutical potential similar to arachidonic acid. Two candidate cDNAs (AL10 and AL21) for the C(20) Delta(5cis)-desaturase from developing seeds of A. leveillei were functionally characterized in transgenic Arabidopsis (Arabidopsis thaliana) plants. The open reading frames of both Delta(5)-desaturases showed some similarity to presumptive acyl-coenzyme A (CoA) desaturases found in animals and plants. When expressed in transgenic Arabidopsis, AL21 showed a broad range of substrate specificity, utilizing both saturated (16:0 and 18:0) and unsaturated (18:2, n-6 and 18:3, n-3) substrates. In contrast, AL10 did not show any activity in wild-type Arabidopsis. Coexpression of AL10 or AL21 with a C(18) Delta(9)-elongase in transgenic Arabidopsis plants resulted in the production of SA and juniperonic fatty acid (20:4Delta(5,11,14,17)). Thus, AL10 acted only on C(20) polyunsaturated fatty acids in a manner analogous to "front-end" desaturases. However, neither AL10 nor AL21 contain the cytochrome b(5) domain normally present in this class of enzymes. Acyl-CoA profiling of transgenic Arabidopsis plants and developing A. leveillei seeds revealed significant accumulation of Delta(5)-unsaturated fatty acids as acyl-CoAs compared to the accumulation of these fatty acids in total lipids. Positional analysis of triacylglycerols of A. leveillei seeds showed that Delta(5)-desaturated fatty acids were present in both sn-2 and sn-1 + sn-3 positions, although the majority of 16:1Delta(5), 18:1Delta(5), and SA was present at the sn-2 position. Our data provide biochemical evidence for the A. leveillei Delta(5)-desaturases using acyl-CoA substrates.     

Epistatic interaction among loci controlling the palmitic and the stearic acid levels in the seed oil of sunflower

Two sunflower (Helianthus annuus L.) mutants with high concentrations of saturated fatty acids in their seed oil have been identified and studied extensively. The mutant line CAS-5 has high concentrations of palmitic acid (C16:0) (>25% compared with 7% in standard sunflower seed oil) and low-C18:0 values (3%). CAS-3 is characterized by its high levels of stearic acid (C18:0) (>22% compared with 4% in standard sunflower seed oil) and a low-C16:0 content (5%). CAS-5 also possesses elevated levels of palmitoleic acid (C16:1) (>5%), which is absent in standard sunflower seed oil. The objective of this study was to determine the relationships between the loci controlling the high-C16:0 and the high-C18:0 traits in these mutants. Plants of both mutants were reciprocally crossed. Gas chromatographic analyses of fatty acids from the seed oil of F₁, F₂, F₃ and the BC₁F₁ to CAS-5 generations indicated that the loci controlling the high-C16:0 trait exerted an epistatic effect over the loci responsible for the high-C18:0 character. As a result, the phenotypic combination containing both the high-C16:0 levels of CAS-5 and the high-C18:0 levels of CAS-3 was not possible. However, phenotypes with a saturated fatty acid content of 44% (34.5% C16:0+9.5% C18:0) were identified in the F₃ generation. These are the highest saturated (C16:0 and C18:0) levels reported so far in sunflower seed oil. When F₃ C16:0 segregating generations in both a high- and a low-C18:0 background were compared, the high-C16:1 levels were not expressed as expected in the high-C18:0 background (CAS-3 background). In this case, the C16:1 content decreased to values below 1.5%, compared with >5% in a low-C18:0 background. As the stearoyl-ACP desaturase has been reported to catalyze the desaturation from C16:0-ACP to C16:1-ACP, these results suggested that a decrease in its activity was involved in the accumulation of C18:0 in the high-C18:0 mutant CAS-3. Received: 10 March 1999 / Accepted: 16 June 1999     

Can the fatty acid selectivity of plant lipases be predicted from the composition of the seed triglyceride?

To address the question can the fatty acid selectivity of plant lipases be predicted from the composition of the seed triglyceride, we have characterised the selectivity of lipases from a wide range of oilseeds with diverse fatty acid compositions. For this study, a novel hydrolysis assay using a fully randomised oil, was developed. From some seed sources (e.g. Cinnamomum camphora), lipases show high preference for particular fatty acids, whilst from others (e.g. Brassica napus, Theobroma cacao80% saturated or 'unusual' fatty acids may contain lipases which exhibit selectivity. It therefore follows that since the majority of seeds are composed of unsaturated fatty acids, that highly selective lipases will be unusual in nature. However lipases from some species of the Cuphea genera show exceptionally high preference for particular fatty acids. For example, lipase from seeds of Cuphea procumbans has over 20-fold selectivity for C10:0.     

Metabolic engineering of seeds can achieve levels of omega-7 fatty acids comparable with the highest levels found in natural plant sources

Plant oils containing ω-7 fatty acids (FAs; palmitoleic 16:1Δ(9) and cis-vaccenic 18:1Δ(11)) have potential as sustainable feedstocks for producing industrially important octene via metathesis chemistry. Engineering plants to produce seeds that accumulate high levels of any unusual FA has been an elusive goal. We achieved high levels of ω-7 FA accumulation by systematic metabolic engineering of Arabidopsis (Arabidopsis thaliana). A plastidial 16:0-ACP desaturase has been engineered to convert 16:0 to 16:1Δ(9) with specificity >100-fold than that of naturally occurring paralogs, such as that from cat's claw vine (Doxantha unguis-cati). Expressing this engineered enzyme (Com25) in seeds increased ω-7 FA accumulation from <2% to 14%. Reducing competition for 16:0-ACP by down-regulating the β-ketoacyl-ACP synthase II 16:0 elongase further increased accumulation of ω-7 FA to 56%. The level of 16:0 exiting the plastid without desaturation also increased to 21%. Coexpression of a pair of fungal 16:0 desaturases in the cytosol reduced the 16:0 level to 11% and increased ω-7 FA to as much as 71%, equivalent to levels found in Doxantha seeds.