Mycelial growth and ochratoxin A production by Aspergillus section Nigri on simulated grape medium in modified atmospheres

Aims:  To evaluate the impact of modified atmosphere packaging on in vitro growth of Aspergillus carbonarius and Aspergillus niger , and possible effects on ochratoxin A (OTA) biosynthesis.
Methods and Results:  Ochratoxigenic isolates belonging to the species A. carbonarius and A. niger were grown on a synthetic grapejuice medium (SNM) and packaged in combinations of controlled O₂ (1% and 5%) and CO₂ levels (0% and 15%), and in air as a control. Colony diameters were recorded every 3 days up to 21 days, and OTA was analysed after 7, 14 and 21 days. The greatest reductions in mycelial growth rate were observed at 1% O₂ followed by 1% O₂/15% CO₂, whereas 5% O₂ stimulated the growth of all isolates. OTA production by A. carbonarius and A. niger isolates was minimized at 1% O₂/15% CO₂ and 1% O₂, respectively, after 7 days of incubation. Maximal OTA accumulation after 7 days was observed for all isolates in the control pack and at 5% O₂.
Conclusions:  Of the atmospheres tested, only 1% O₂ combined with 15% CO₂ consistently reduced fungal growth and OTA synthesis by A. carbonarius and A. niger .
Significance and Impact of the Study:  Storage under modified atmospheres is unlikely to be suitable as the sole method for OTA minimization and grape preservation; other inhibitory factors are necessary.     

Predictive assessment of ochratoxin A accumulation in grape juice based-medium by Aspergillus carbonarius using neural networks

Aims:  To study the ability of multi-layer perceptron artificial neural networks (MLP-ANN) and radial-basis function networks (RBFNs) to predict ochratoxin A (OTA) concentration over time in grape-based cultures of Aspergillus carbonarius under different conditions of temperature, water activity ( a _w) and sub-inhibitory doses of the fungicide carbendazim.
Methods and Results:  A strain of A. carbonarius was cultured in a red grape juice-based medium. The input variables to the network were temperature (20–28°C), a _w (0·94–0·98), carbendazim level (0–450 ng ml⁻¹) and time (3–15 days after the lag phase). The output of the ANNs was OTA level determined by liquid chromatography. Three algorithms were comparatively tested for MLP. The lowest error was obtained by MLP without validation. Performance decreased when hold-out validation was accomplished but the risk of over-fitting is also lower. The best MLP architecture was determined. RBFNs provided similar performances but a substantially higher number of hidden nodes were needed.
Conclusions:  ANNs are useful to predict OTA level in grape juice cultures of A. carbonarius over a range of a _w, temperature and carbendazim doses.
Significance and Impact of the Study:  This is a pioneering study on the application of ANNs to forecast OTA accumulation in food based substrates. These models can be similarly applied to other mycotoxins and fungal species.     

Specific detection of Aspergillus carbonarius by SYBR® Green and TaqMan® quantitative PCR assays based on the multicopy ITS2 region of the rRNA gene

Agroproducts contaminated by ochratoxin A (OTA) represent a risk for human and animal health and, therefore, maximum limits have been established by Food Safety Authorities. Reduction of OTA contamination may be accomplished by early detection of OTA-producing fungal species using rapid, specific and sensitive detection and quantification by PCR-based methods. Aspergillus carbonarius is one of the most important OTA-producing species, in particular in grapes and derivatives from Mediterranean regions. In this work, highly efficient quantitative PCR assays using SYBR Green I and TaqMan methods were developed for specific detection of A. carbonarius to be used in grapes. The primers and the TaqMan probe were based on the internal transcribed region 2 multicopy region (internal 2 sequence of the rRNA gene). The specificity and sensitivity of both assays were tested on genomic DNA mixtures of several A. carbonarius strains and other fungal species frequently present in grapes. Both methods were also compared using grapes inoculated with different spore concentrations of A. carbonarius , detecting up to 0.4 pg DNA g⁻¹ grape berries. The efficiency and sensitivity of both methods were comparable and only the lower cost of SYBR Green might favour its use in routine screenings.     

Control of Aspergillus section Flavi growth and aflatoxin accumulation by plant essential oils

Aims:  The antifungal effect of Pimpinella anisum (anise), Pëumus boldus (boldus), Mentha piperita (peppermint), Origanum vulgare (oregano) and Minthosthachys verticillata (peperina) essential oils against Aspergillus section Flavi (two isolates of Aspergillus parasiticus and two isolates of Aspergillus flavus ) was evaluated in maize meal extract agar at 0·982 and 0·955 water activities, at 25°C.
Methods and Results:  The percentage of germination, germ-tube elongation rate, growth rate and aflatoxin B₁ (AFB₁) accumulation at different essential oils concentrations were evaluated. Anise and boldus essential oils were the most inhibitory at 500 mg kg⁻¹ to all growth parameters of the fungus. These essential oils inhibited the percentage of germination, germ-tube elongation rate and fungal growth. AFB₁ accumulation was completely inhibited by anise, boldus and oregano essential oils. Peperina and peppermint essential oils inhibited AFB₁ production by 85–90% in all concentrations assayed.
Conclusions:  Anise and boldus essential oils could be considered as effective fungitoxicans for Aspergillus section flavi .
Significance and Impact of the Study:  Our results suggest that these phytochemical compounds could be used alone or in conjunction with other substances to control the presence of aflatoxigenic fungi in stored maize.     

Comparison of methods to detect resistance of Penicillium expansum to thiabendazole

Aims:  Because of the lack of a standard method, the aim of this work is to evaluate the suitability of the broth microdilution method CLSI M38-A in determining the resistance level of some Penicillium expansum isolates to thiabendazole (TBZ). The ability of the isolates to produce patulin (PAT) and citrinin (CIT) has been also assessed.
Methods and Results:  Penicillium expansum isolates (128) were assayed (apples, pears, grapes and five reference strains). It was observed that 69·4% of the strains isolated from apples and pears were resistant to TBZ. Sensitive isolates were inhibited at 0·25–0·5 μg ml⁻¹ whilst resistant isolates still grew at 512 μg ml⁻¹. PAT was produced by all P. expansum isolates. CIT was detected in 98·8% of TBZ-resistant isolates and in 89·1% of the TBZ-sensitive isolates.
Conclusions:  The preliminary screening method combined with the adaptation of the method CLSI M38-A, can be a good strategy to be used in assessing the in vitro activity of TBZ against a large number of isolates.
Significance and Impact of the Study:  The proposed methodology can be a contribution to the standardization of susceptibility tests to fungicides against P. expansum.     

More effective induction of spawning with long-acting GnRH agonist in the shi drum, Umbrina cirrosa L. (Sciaenidae, Teleostei), a valuable candidate for Mediterranean mariculture

Three experiments of spawning induction in shi drum, Umbrina cirrosa L., were performed in six different commercial Italian hatcheries from May to August (water temperatures: 19–29 °C; salinity: 21–37 p.p.t.). In the first experiment, 119 females (1–4.7 kg), subdivided into 29 lots, were injected with a single dose (2, 5, 8, 10, 15 and 20  μ g kg⁻¹ body weight) of short-acting gonadotropin- releasing hormone agonist (GnRHa-S), des-Gly10,[D-Ala6]-LH-RH ethylamide. In the other two experiments, 85 females (0.7–5.8 kg), subdivided into 22 and four lots, were treated with one (40 or 80  μ g kg⁻¹) or three doses (40  μ g kg⁻¹) of long-acting GnRHa (GnRHa-L), respectively. GnRHa-S stimulated spawning in 69% of the 29 treated lots; the number of eggs laid reached a maximum of 130 000 and a weighted mean of 29 200 total eggs kg⁻¹. GnRHa-L elicited a spawning response in 95% of the 22 one-dose treated lots; the number of laid eggs was higher than with GnRHa-S, reaching a maximum of 213 100 and a weighted mean of 59 400 total eggs kg⁻¹. The yield of developing embryos in 67% of the single GnRHa-L treatments was higher (sometimes up to three times) than with GnRHa-S. Triple treatments of the four lots of females with GnRHa-L always resulted in spawning responses; the best result corresponded to a number of total laid eggs of 358 900 eggs kg⁻¹ with a yield of 177 300 developing embryos.     

In vitro efficacy of nisin Z against Candida albicans adhesion and transition following contact with normal human gingival cells

Aim:  To investigate the nisin Z innocuity using normal human gingival fibroblast and epithelial cell cultures, and its synergistic effect with these gingival cells against Candida albicans adhesion and transition from blastospore to hyphal form.
Methods and Results:  Cells were cultured to 80% confluence and infected with C. albicans in the absence or presence of various concentrations of nisin Z. Our results indicate that only high concentrations of nisin Z promoted gingival cell detachment and differentiation. Determination of the LD₅₀ showed that the fibroblasts were able to tolerate up to 80  μ g ml⁻¹ for 24 h, dropping thereafter to 62  μ g ml⁻¹ after 72 h of contact, compared to 160  μ g ml⁻¹ after 24 h, and 80  μ g ml⁻¹ after 72 h recorded by the gingival epithelial cells which displayed a greater resistance to nisin Z. The use of nisin Z even at low concentration (25  μ g ml⁻¹) at appropriate concentrations with gingival cells significantly reduced C. albicans adhesion to gingival monolayer cultures and inhibited the yeast's transition.
Conclusion:  These findings show that when used at non-toxic levels for human cells, nisin Z can be effective against C. albicans adhesion and transition and may synergistically interact with gingival cells for an efficient resistance against C. albicans .
Significance and Impact of the Study:  This study suggests the potential usefulness of nisin Z as an antifungal agent, when used in an appropriate range.     

Influence of phosphorus on biofilm formation in model drinking water distribution systems

Aims:  This study investigated the effects of phosphorus on biofilm formation via annular reactor systems in terms of biofilm cell growth, exopolysaccharide (EPS) production, biofilm structure and cell metabolic potential.
Methods and Results:  Drinking water biofilms were developed in annular reactors with supplement of carbon and different levels of phosphorus. The biofilm formation was monitored over a period of 30 days. Biofilm related parameters were examined by various methods, which included heterotrophic plate count, total carbohydrate content, confocal laser scanning microscopy and GN2 microplate assay. Our results showed that phosphorus addition can promote the biofilm cell growth (cell count increased about 1 log with addition of 30 and 300 μg l⁻¹ of phosphorus). However, the addition of 30 and 300 μg l⁻¹ of phosphorus caused 81% and 77% decrease in EPS production, respectively. The results of biofilm structure analysis showed that the addition of 30 and 300 μg l⁻¹ of phosphorus can induce thicker and less homogeneous biofilms with more biomass. Furthermore, the addition of 30 and 300 μg l⁻¹ of phosphorus dramatically increased the biofilm cell metabolic potential. The addition of 3 μg l⁻¹ of phosphorus was found to have minor effects on the parameters examined.
Conclusions:  The results indicate phosphorus addition to drinking water distribution system (DWDS) has a complicated effect on the biofilm formation.
Significance and Impact of the Study:  As the addition of phosphorus at certain levels can affect the biofilm growth in DWDS, care should be taken when phosphate-based corrosion inhibitors are used in the DWDS.     

Study of Spanish grape mycobiota and ochratoxin A production by Isolates of Aspergillus tubingensis and other members of Aspergillus section Nigri

The native mycobiota of five grape varieties grown in Spain has been studied. Four (Bobal, Tempranillo, Garnacha, and Monastrell) were red varieties and one (Moscatel) was white. The main fungal genera isolated were Alternaria, Cladosporium, and Aspergillus. The isolation frequency of Aspergillus spp. section Nigri in contaminated samples was 82%. Ochratoxin A (OTA) production was assessed using yeast extract-sucrose broth supplemented with 5% bee pollen. Cultures of 205 isolates from this section showed that 74.2% of Aspergillus carbonarius and 14.3% of Aspergillus tubingensis isolates produced OTA at levels ranging from 1.2 to 3,530 ng/ml and from 46.4 to 111.5 ng/ml, respectively. No Aspergillus niger isolate had the ability to produce this toxin under the conditions assayed. Identification of the A. niger aggregate isolates was based on PCR amplification of 5.8S rRNA genes and its two intergenic spacers, internal transcribed spacer 1 (ITS1) and ITS2, followed by digestion with restriction endonuclease RsaI of the PCR products. The restriction patterns were compared with those from strains of A. niger CECT 2807 and A. tubingensis CECT 20393, held at the Spanish Collection of Type Cultures. DNA sequencing of the ITS1-5.8S rRNA gene-ITS2 region of the OTA-producing isolates of A. tubingensis matched 99 to 100% with the nucleotide sequence of strain A. tubingensis CBS 643.92. OTA determination was accomplished by liquid chromatography with fluorescence detection. OTA confirmation was carried out by liquid chromatography coupled to ion trap mass spectrometry. The results showed that there are significant differences with regard to the isolation frequency of ochratoxinogenic fungi in the different grape varieties. These differences were uncorrelated to berry color. The ability of A. tubingensis to produce OTA and the influence of grape variety on the occurrence of OTA-producing fungi in grapes are described in this report for the first time.     

Contribution of fungal biomass to the growth of the shredder, Pycnopsyche gentilis (Trichoptera: Limnephilidae)

1.  1. It has been accepted that aquatic hyphomycetes colonising submerged leaves increase the nutritional value of leaf detritus and suggested that fungal biomass plays a greater role in the growth of shredders than leaf tissue itself. However, it is not clear what proportion of the nutritional needs of shredders is met by fungal biomass.
2.  We fed Pycnopsyche gentilis larvae with tulip poplar ( Liriodendron tulipifera ) leaf discs colonised by the aquatic hyphomycete, Anguillospora filiformis , which had been radiolabelled to quantify the contribution of fungal carbon to the growth of the shredder at different larval developmental stages. Instantaneous growth rates of larvae on this diet were also estimated.
3.  When provided with fungal-colonised leaves (14–16% fungal biomass), the third and the fifth instar larvae of P. gentilis grew at the rates of 0.061 and 0.034 day⁻¹, respectively, but on a diet of sterile leaves, both larval instars lost weight. The incorporation rates of fungal carbon were 31.6 μg C mg⁻¹ AFDM day⁻¹, accounting for 100% of the daily growth rate of the third instar larvae and 8.6 μg C mg⁻¹ AFDM day⁻¹, accounting for 50% of the daily growth rate of the fifth instar larvae.
4.  These results suggest that leaf material colonised by A. filiformis is a high quality food resource for P. gentilis larvae, and that fungal biomass can contribute significantly to the growth of these larvae. Differences in feeding behaviour and digestive physiology may explain the significantly greater assimilation of fungal biomass by the earlier instar than the final instar. To satisfy their nutritional needs the fifth instar larvae would have to assimilate detrital mass that may have been modified by fungal exoenzymes.     

Antifungal effect of gaseous nitric oxide on mycelium growth, sporulation and spore germination of the postharvest horticulture pathogens, Aspergillus niger, Monilinia fructicola and Penicillium italicum

Aim:  To evaluate the antifungal activity of nitric oxide (NO) against the growth of the postharvest horticulture pathogens Aspergillus niger , Monilinia fructicola and Penicillium italicum under in vitro conditions.
Methods and Results:  Different volumes of NO gas were injected into the Petri dish headspace to obtain the desired concentrations of 50–500  μ l l⁻¹ . The growth of the fungi was measured for 8 days of incubation in air at 25°C . All concentrations of NO were found to produce an antifungal effect on spore germination, sporulation and mycelial growth of the three fungi, with the most effective concentration for A. niger and P. italicum being 100 and 500  μ l l⁻¹ for M. fructicola .
Conclusions:  Short-term exposure to a low concentration of NO gas was able to inhibit the subsequent growth of A. niger , M. fructicola and P. italicum .
Significance and Impact of the Study:  NO gas has potential use as a natural fungicide to inhibit microbial growth on postharvest fruit and vegetables.     

Gamma-linolenic acid production of Mucor rouxii by solid-state fermentation using agricultural by-products

Aims:  This study aims to maximize the yield of gamma-linolenic acid by a filamentous fungus, Mucor rouxii , using low cost production by solid-state fermentation.
Methods and Results:  We optimized substrate types and culture conditions including inoculum size and temperature. The optimal growth of M. rouxii was found in the cultures inoculated with 5 × 10⁵ spores g⁻¹ substrate. The fungal cells grew well on rice bran and soy bean meal, whereas a lower biomass was found in the cultures grown on polished rice, broken rice and spent malt grain. The GLA content was highly accumulated in rice bran ferment and its maximal content of about 6 g kg⁻¹ fermented mass was observed in the 5th-day culture grown at 30°C. However, the GLA content in the rice bran ferment was not enhanced by low temperature.
Conclusions:  The GLA production of M. rouxii could be enhanced by optimizing the agricultural by-product substrates and culture condition.
Significance and Impact of the Study:  Low cost GLA production process was achieved, and fermented product containing GLA can be incorporated into feed additives without further oil extraction to alternate the expensive plant oils.     

Investigation of the anti-fungal activity of coptisine on Candida albicans growth by microcalorimetry combined with principal component analysis

Aims:  This study investigated the anti-fungal activity of coptisine on Candida albicans growth.
Methods and Results:  The metabolic power-time curves of Candida albicans growth at 37°C affected by coptisine were measured by microcalorimetry using an LKB-2277 Bioactivity Monitor with stop-flow mode. Then, the diameter of inhibitory zones in the agar layer was observed using agar cup method, and the minimal inhibitory concentration (MIC) of coptisine on Candida albicans growth was determined by serial dilution method. From the principal component analysis on nine quantitative parameters obtained from the power-time curves, we could easily evaluate the anti-fungal activity of coptisine by analysing the change of values of the main two parameters, growth rate constant k and maximum power output in the log phase P _{m, log}. The results showed that coptisine had strong anti-fungal activity: at a low concentration (45  μ g ml⁻¹) began to inhibit the growth of Candida albicans and at a high concentration (500  μ g ml⁻¹) completely inhibited Candida albicans growth. Coptisine gave big inhibitory zones with diameters between 11 and 43 mm within test range, and the MIC of it was 1000  μ g ml⁻¹.
Conclusions:  Coptisine had strong anti-fungal activity on Candida albicans growth. The method of microcalorimetry applied for the assay of anti-fungal activity of coptisine was quantitative, sensitive and simple.
Significance and Impact of the Study:  This work will provide useful information for the development of chemical biology policy in the use of anti-microbials in food and drug production.     

Potential of Bacillus sp. to produce polyhydroxybutyrate from biowaste

Aim:  To test the Bacillus strains for their abilities to produce polyhydroxybutyrate (PHB) from different sugars and biowaste (Pea-shells).
Methods and Results:  Six Bacillus strains were checked for their ability to produce PHB from GM2 medium supplemented with different sugars at the rate of 1% (w/v) and from biowaste and GM2 (BW : M) combinations (3 : 7, 1 : 1, 7 : 3). Glucose supplemented GM2 medium resulted in maximum PHB production of 435 mg l⁻¹ constituting 31–62% w/w of the total cell dry mass. Substituting GM2 medium to the extent of 50% with biowaste (pea-shell slurry) resulted in 945–1205 mg l⁻¹ PHB (55–65% w/w). Optimization for additional nitrogen supplementation, inoculum size resulted in a final PHB production of 3010–3370 mg l⁻¹ equivalent to 300 g kg⁻¹ biowaste (dry wt).
Conclusion:  The Bacillus strains were able to produce PHB from biowaste (Pea-shells) as cheap source of substrate.
Significance and Impact of the Study:  This is the first report on usage of pea-shells as feed for PHB production, opening new possibilities for its use for production of PHB and Bacillus as potential candidate for the purpose.     

Fungal endophytes from Acer ginnala Maxim: isolation, identification and their yield of gallic acid

Aims:  The aim of the study was to isolate the endophytic fungi from Acer ginnala and screen isolates rich in gallic acid.
Methods and Results:  After epiphytic sterilization, 145 fungal endophytes were isolated from the stem, annual twig and seed of Acer ginnala . The endophytes were grouped into ten different taxa, Phomopsis sp., Neurospora sp., Phoma sp., Epicoccum sp., Penicillium sp., Alternaria sp., Fusarium sp., Trichoderma sp., Cladosporium sp. and a species of Pleosporales Incertae Sedis , by their morphological traits and ITS-rDNA sequence analysis. The content and yield of gallic acid of 141 isolates were determined by HPLC. On average, the species of Pleosporales Incertae Sedis had the highest content and yield of gallic acid (13·28 mg g⁻¹ DW; 119·62 mg l⁻¹), while Alternaria sp. had the lowest.
Conclusions:  Of 141 fungal endophytes from A. ginnala , Phomopsis sp. isolate SX10 showed both the highest content and the highest yield of gallic acid (29·25 mg g⁻¹ DW; 200·47 mg l⁻¹).
Significance and Impact of the Study:  Endophytic fungi isolated from A. ginnala may be used as potential producers of gallic acid and other compounds with biological activities, or functioned as elicitors to produce natural compounds.     

Response of Listeria monocytogenes to liquid smoke

Aims:  To investigate the effect of liquid smoke on growth, survival, proteomic pattern and haemolytic potential of Listeria monocytogenes.
Methods and Results:  Growth and survival curves were recorded in brain–heart infusion broth supplemented with three concentrations of liquid smoke. L. monocytogenes growth was inhibited in the presence of 15 μg ml⁻¹ phenol while a rapid decrease in cell viability occurred in the presence of 30 μg ml⁻¹ phenol. The proteome of L. monocytogenes cytosoluble proteins was slightly modified after 2-h incubation with 30 μg ml⁻¹ phenol but no protein already characterized in response to other known stresses was induced, except the protease ClpP. Liquid smoke inhibited the haemolytic potential without affecting hly gene expression, showing a potential inhibition of protein activity or stability.
Conclusions:  The presence of liquid smoke in a rich medium strongly affected growth and survival of L. monocytogenes . Brief smoke stress affected the metabolic pathways and inhibited the haemolytic activity of L. monocytogenes .
Significance and Impact of Study:  This study is a first step in the investigation of the influence of a smoked product on L. monocytogenes strains.     

Antifungal properties of selected lactic acid bacteria and application in the biological control of ochratoxin A producing fungi during cocoa fermentation

Thirteen Lactic acid bacteria strains isolated from fermenting cocoa and seven reference strains were used in order to assess their antifungal properties towards three ochratoxin A (OTA) producing fungi (Aspergillus carbonarius, Aspergillus niger and Aspergillus ochraceus). Furthermore, two of the isolates strains (A19 and A21) identified as belonging to the genus of Pediococcus as well as Lactobacillus plantarum B4496, Lactobacillus brevis 207 and Lactobacillus sanfranciscensis BB12 showed interesting in vitro broad antifungal activities towards the three ochratoxin-producing fungi with inhibition percentages ranging from 15% to 66.7%. Treatment of cell-free supernatant at 100°C affected antifungal activity suggesting that the main compounds responsible for this activity were of proteic nature, and hence could be bacteriocins. Application of isolate A19 in cocoa fermentation as starter inhibited the growth of each of the OTA-producing species. At the end of fermentation in boxes inoculated with A19, A. niger was not detectable while A. carbonarius concentration was found to be 2 Log CFU/g of wet beans. The assessment of the ochratoxin produced during fermentation of cocoa inoculated with A. carbonarius indicated that the use of isolate A19 as starter could reduce their level of growth so as to have only a toxin production of 0.0012 ± 0.0005 μg/kg after 40 days of storage, while this was 2.45 ± 0.35 μg/kg of fermented and dried cocoa beans in the absence of A19. This work is a contribution for the application of biological control of OTA-producing fungi during cocoa production.     

Inhibitory effects of sucrose fatty acid esters on survival of Yersinia enterocolitica on eggshell surface and use of blue lake as indicator of bacterial penetration into eggs

Aims:  To determine the effectiveness of sucrose monolaurate (SML) and sucrose monocaprate (SMC), alone and in combination with ethylenediaminetetraacetic acid (EDTA), propionic acid (PA) or citric acid (CA) in reducing mesophilic aerobic bacteria (MAB) and Yersinia enterocolitica O:9 populations on eggshells and their damage potential on the microstructure of shell cuticle.
Methods and Results:  Uninoculated eggs and eggs submerged in a solution of Y. enterocolitica were immersed in solutions of the various treatments. MAB and Y. enterocolitica counts on the surface of the eggs were carried out before and after treatment. MAB counts decreased less than 2 logs on uninoculated eggshells irrespective of treatment and reductions of 3·2 and 3·0 logs of Y. enterocolitica were obtained with 1000 μg ml⁻¹ SML plus 0·1% CA or 1000 μg ml⁻¹ SML plus 600 μg ml⁻¹ EDTA solutions, respectively. Y. enterocolitica 2/O:9 was recovered from natural microflora. Use of blue lake staining revealed minimal damage to the shells from the washing treatments.
Conclusions:  SML and SMC at 1000 μg ml⁻¹ combined with CA or EDTA could be effective in reducing Y. enterocolitica on eggshells with a minimal risk of later bacterial recontamination.
Significance and Impact of the Study:  Eggs are a recognized vehicle for transmission of Y enterocolitica although a prevalence of only 2·7% was detected in this study. Washing eggs in solutions containing SML or SMC could eliminate Y. enterocolitica contamination of egg shells.     

Aspergillus fumigatus toxicity and gliotoxin levels in feedstuff for domestic animals and pets in Argentina

Aims:  To evaluate gliotoxin production by Aspergillus fumigatus strains isolated from feedstuff intended for domestic animals and pets, and to determine the amount of gliotoxin in these substrates.
Methods and Results:  A total of 150 feedstuff samples were collected. They were composed of 30 samples each of five different feed types (pigs, poultry, cattle, horse and pets). Aspergillus fumigatus gliotoxin production ability and gliotoxin presence in feedstuff was determined by HPLC. Aspergillus fumigatus strains were isolated from all of the tested samples. Strains from cattle, horses and pet food were able to produce gliotoxin. Corn silage samples intended for cattle did not show gliotoxin contamination. All the other tested samples had gliotoxin levels ranging from 29 to 209 μg g⁻¹. Horse and poultry feed samples had the greatest contamination frequency.
Conclusions:  Feed samples contaminated with gliotoxin are potentially toxic to animals.
Significance and Impact of the Study:  The presence of gliotoxin could affect animal productivity and health. Moreover, there are risks of contamination to farm workers handling improperly stored animal feed. Aspergillus fumigatus strains isolated from different sources should be investigated to determine prevention and control strategies.     

Indigestible carbohydrates alter the intestinal microbiota but do not influence the performance of broiler chickens

Aims:  Prebiotics are a potential alternative to in-feed antimicrobials to improve performance of chickens. We investigated the effects of mannanoligosaccharide (MOS) and fructooligosaccharide (FOS) on growth, performance and the intestinal microbiota.
Methods and Results:  Cobb 500 birds were fed either: Control, starter diet without antimicrobials; ZnB, Control + 50 ppm zinc bacitracin; MOS, Control + 5 g kg⁻¹ MOS; or FOS, Control + 5 g kg⁻¹ FOS. An energy metabolism study was conducted and intestinal microbial communities assessed by T-RFLP and Lac PCR-DGGE. Diet did not influence performance. Ileal microbial communities were significantly different in ZnB-fed birds compared to all diets, and FOS-fed chickens compared to Control. MOS-fed chickens had a different caecal profile to ZnB and FOS-fed birds. Consensus Lac PCR-DGGE profiles indicated Lactobacillus communities clustered according to diet with Lactobacillus johnsonii characteristic of ZnB diet. Control and MOS-fed chickens displayed significantly different jejunal Lactobacillus profiles to each other whilst ileal profiles were different between MOS and FOS-fed birds.
Conclusion:  Prebiotics influenced the intestinal microbiota, but did not affect performance.
Significance and Impact of the Study:  In light of pressure for in-feed antimicrobial withdrawal, the impact of alternative compounds on the intestinal microbiota and bird performance is critical to the poultry industry.