赤藓糖醇发酵工艺研究

赤藓糖醇的制备方法主要为微生物发酵法。为提高圆酵母(Torulasp.)B84512转化葡萄糖生产赤藓糖醇的发酵产量,采用控制发酵过程中葡萄糖起始浓度(30.0%)、中间流加葡萄糖浆的工艺使总葡萄糖糖浓度达到40%,发酵120h可产赤藓糖醇162.5gL,生产率为1.35gL·h,而不采取中间流加工艺,起始葡萄糖浓度为40.0%,发酵120h可产赤藓糖醇120gL,生产率为1.00gL·h。通过研究发现在赤藓糖醇发酵过程中采取中间流加葡萄糖工艺,能大大提高赤藓糖醇的发酵水平,提高幅度达30-35%,生产率也有相应提高。     

赤藓糖醇微生物合成研究进展

糖的过量摄入给人们的身体健康带来了风险.甜味剂的发现和合理使用有助于减少食品中糖的添加.作为天然甜味剂的赤藓糖醇,因其具有独特的理化性质如热值低、基本不被人体代谢、稳定性高和食用不会引起肠道不适等而受到广泛关注.目前,赤藓糖醇已被广泛用于食品、医药和化工产品中,其国内外市场需求量正逐年提升,这对赤藓糖醇的工业化生产提出...     

新型甜味剂--赤藓糖醇产生菌的筛选

从土壤、酿造食品、花粉等样品中分离赤藓糖醇产生菌的方法,分离得到约３００株耐高渗酵母,其中有３株菌产赤藓糖醇,２６０８在葡萄糖培养液中可产赤藓糖醇３２ｍｇ／ｍｌ。     

赤藓糖醇对主要致龋链球菌及耐氟菌株生长和产酸的影响

目的通过赤藓糖醇对变形链球菌、远缘链球菌及其耐氟菌株混合菌生长和产酸影响的体外研究,为赤藓糖醇防龋作用的机理提供制论依据。方法采用最小抑菌浓度递增法对变形链球菌（S.mutans ATCC 25175,S.m）、远缘链球菌（S.sobrinus 6715,S.s）进行氟化钠体外诱导耐氟菌株（S.m-FR、S.s-FR）,利用液体稀释法配制赤藓糖醇TSB液8个浓度,分别加入含有变形链球菌、远缘链球菌及其耐氟菌株的细菌混悬液48 h,用比浊法观察其对混合菌生长的影响,并用pH计测定培养前后上清液的△pH值。结果吸光度A值和△pH值实验前后与对照组相比最低浓度为12%时差异均有统计学意义（P〈0.05）,且随着浓度的升高A值和△pH值均下降。结论赤藓糖醇能抑制变形链球菌、远缘链球菌及耐氟菌株混合菌生长和产酸,并且随着浓度的升高抑制作用增强。     

赤藓糖醇高产菌株的筛选、鉴定及发酵特性的初步研究

目的：筛选出发酵性能优良的赤藓糖醇高产菌株。方法：利用含50%葡萄糖的高渗培养基筛选出耐高渗酵母,采用薄层层析和高效液相色谱分析发酵液中多元醇的组成和含量,并通过形态和生理生化试验对菌株进行初步鉴定。结果：由泰山养蜂场上采集的蜂蜜、花粉、蜂巢里筛选出13株单产赤藓糖醇的野生菌,其中7株赤藓糖醇产量高于20g/L。菌株K-23经初步鉴定为球拟酵母属,在含20%葡萄糖、1%酵母膏、0.1%尿素的发酵培养基中培养144h后赤藓糖醇的浓度达46.8g/L,转化率达23.4%。结论：所获得的菌株K-23具有一定的赤藓糖醇生产能力,且具有产物单一的优良发酵性能,为该菌株的菌种改良奠定了基础。     

亚致死浓度赤藓糖醇对红火蚁工蚁觅食和弃尸行为的影响

红火蚁是国际上最具危险性外来害虫之一,已入侵华南地区并造成严重危害。为弄清潜在杀虫剂赤藓糖醇在亚致死浓度下对红火蚁的影响,本研究使用0.05 g/mL赤藓糖醇水溶液喂食室内蚁群24 h,观察了工蚁的觅食行为和弃尸行为的变化。结果显示,取食赤藓糖醇后工蚁发现食物时间约为5 min,而取食10%蔗糖水后发现食物时间缩短到2 min以内;取食赤藓糖醇后工蚁招募速度和食物搬运效率也显著低于对照。取食赤藓糖醇后工蚁发现尸体时间和弃尸速度变化显著,发现尸体时间由对照的3.45 min延长至8.13 min,开始丢弃尸体时间由20 min延长至37.5 min,丢弃完所有尸体耗时由3.08 h增大至5.37 h。亚致死浓度赤藓糖醇显著降低了红火蚁工蚁觅食和弃尸能力。     

陶瓷膜系统在赤藓糖醇发酵液提取应用研究

当前，陶瓷膜已经在发酵液中的赤藓糖醇提纯过程中得到了广泛应用，工艺技术人员将陶瓷膜组件引进各大生产企业，实现了对赤藓糖醇发酵液的分离提取。文章结合陶瓷膜在赤藓糖醇的提取实验和工业中的实际应用，总结分析了在陶瓷膜运行过程中，运行压力、运行温度、浓缩倍数、加水量等对陶瓷膜组件运行的通量、稳定性及收率的影响。较之传统工艺，陶瓷膜过滤的优点主要体现在以下几方面，即工艺流程更短、过滤清液的质量更稳定、除菌效果更好以及运行成本更低等。     

耐高渗产赤藓糖醇酵母的诱变筛选与鉴定

使用含碘乙酸的固体平板培养基对自然界中富含高浓度糖分的含菌样品进行筛选,获得一株产赤藓糖醇的菌株,再运用紫外线、氯化锂和硫酸二乙酯(DES)对出发菌株进行诱变育种,利用纸层析、高碘酸氧化法和高效液相色谱(HPLC)进行定性、定量分析赤藓糖醇,最终获得一株能够高产赤藓糖醇的耐高渗菌株JunA-27.对该菌株的细胞形态进行了扫描电子显微镜(SEM)观察,提取了菌株的DNA并对18S rDNA进行PCR扩增、测序和DNA序列同源性比对,确定该菌株与Yarrowia lipolytica相似性最高,并将其命名为Yarrowia lipolytica WX 506.     

甘氨酸和赤藓糖醇胶饵对红火蚁工蚁的毒杀效果

前期研究发现甘氨酸和赤藓糖醇对红火蚁Solenopsis invicta Buren有较好的毒杀效果,为进一步挖掘这两种物质的实际应用价值,在室内测试了甘氨酸和赤藓糖醇不同浓度配比的水溶液及胶状饵剂对红火蚁工蚁的毒杀效果.结果显示,20％的配比为1∶3、3∶1的赤藓糖醇和甘氨酸溶液喂饲48 h红火蚁工蚁的死亡率分别为83.1％和84.93％,而72h后,死亡率分别为95.07％和95.21％,与取食茚虫威饵剂的工蚁死亡率(48 h:92.57％;72 h:100％)无显著差异.20％的配比为1∶3、3∶1的赤藓糖醇和甘氨酸水凝胶颗粒喂饲48 h红火蚁工蚁的死亡率分别为58.94％和55.05％,而72 h后,死亡率分别为85.11％和80.05％,显著低于取食茚虫威饵剂的工蚁死亡率(48 h:95.71％;72 h:99.59％).研究结果为进一步利用开发红火蚁环保型饵剂提供参考.     

HOG1抑制剂调节球头三型孢菌多元醇生产及机理

目的:采用HOG1抑制剂对球头三型孢菌产多元醇进行调控。方法:向培养基中加入SB239063、SB202190和SB203580三种抑制剂进行发酵实验,比较三种抑制剂对发酵的影响。结果:实验结果表明SB239063可以降低球头三型孢菌细胞内胞浆3-磷酸甘油脱氢酶(ct GPD)的酶活,提高赤藓糖还原酶(ER)的酶活。此外对HOG1和Phospho-HOG1的Western blot结果分析显示,SB239063还会抑制球头三型孢菌细胞内HOG1的脱磷酸化。最终添加10μmol/L SB239063使发酵120 h后的多元醇产物中甘油产量下降20.57%,赤藓糖醇产量提高31.16%,底物转化率提高24.73%。结论:SB239063可以降低球头三型孢菌产甘油的能力,提高赤藓糖醇的产量。     

Carbohydrate Storage in the Entomopathogenic Fungus Beauveria bassiana

The entomopathogenic fungus Beauveria bassiana was grown in 1% (wt/vol) gelatin-liquid media singly supplemented with a monosaccharide (glucose or fructose), a disaccharide (maltose or trehalose), a polyol (glycerol, mannitol, or sorbitol), or the amino sugar N-acetyl-d-glucosamine. The relative contributions of the carbohydrate, protein, and water contents in the fungal biomass were determined. Carbohydrates composed 18 to 42% of the mycelial dry weight, and this value was lowest in unsupplemented medium and highest in medium supplemented with glucose, glycerol, or trehalose. Biomass production was highest in liquid cultures supplemented with trehalose. When liquid cultures were grown in medium supplemented with 0 to 1% (wt/vol) glucose, trehalose, or N-acetyl-d-glucosamine, there was an increase in the biomass production and the contribution of carbohydrate to mycelial dry weight. Regardless of the glucose concentration in the culture, water content of the mycelia remained about 77.5% (wt/wt). Mycelial storage carbohydrates were determined by capillary gas chromatography. In gelatin-liquid medium supplemented with 1% (wt/vol) glucose, B. bassiana stored glycogen (12.0%, wt/dry wt) and the polyols mannitol (2.2%), erythritol (1.6%), glycerol (0.4%), and arabitol (0.1%). Without glucose, B. bassiana stored glycogen (5.4%), mannitol (0.8%), glycerol (0.6%), and erythritol (0.6%) but not arabitol. To our knowledge, this is the first report of carbohydrate storage in an entomopathogenic fungus, and the results are discussed in relation to other fungi and the potential implications to commercial formulation and insect-fungus interactions.     

Soil fungal communities in a Castanea sativa (chestnut) forest producing large quantities of Boletus edulis sensu lato (porcini): where is the mycelium of porcini?

A study was conducted in a Castanea sativa forest that produces large quantities of the edible mushroom porcini (Boletus edulis sensu lato). The primary aim was to study porcini mycelia in the soil, and to determine if there were any possible ecological and functional interactions with other dominant soil fungi. Three different approaches were used: collection and morphological identification of fruiting bodies, morphological and molecular identification of ectomycorrhizae by rDNA-ITS sequence analyses and molecular identification of the soil mycelia by ITS clone libraries. Soil samples were taken directly under basidiomes of Boletus edulis, Boletus aestivalis, Boletus aereus and Boletus pinophilus. Thirty-nine ectomycorrhizal fungi were identified on root tips whereas 40 fungal species were found in the soil using the cloning technique. The overlap between above- and below-ground fungal communities was very low. Boletus mycelia, compared with other soil fungi, were rare and with scattered distribution, whereas their fruiting bodies dominated the above-ground fungal community. Only B. aestivalis ectomycorrhizae were relatively abundant and detected as mycelia in the soil. No specific fungus-fungus association was found. Factors triggering formation of mycorrhizae and fructification of porcini appear to be too complex to be simply explained on the basis of the amount of fungal mycelia in the soil.     

Determination of carbohydrates, sugar alcohols, and glycols in cell cultures and fermentation broths using high-performance anion-exchange chromatography with pulsed amperometric detection

Cell cultures and fermentation broths are complex mixtures of organic and inorganic compounds. Many of these compounds are synthesized or metabolized by microorganisms, and their concentrations can impact the yields of desired products. Carbohydrates serve as carbon sources for many microorganisms, while sugar alcohols (alditols), glycols (glycerol), and alcohols (methanol and ethanol) are metabolic products. We used high-performance anion-exchange chromatography with pulsed amperometric detection (HPAE-PAD) to simultaneously analyze for carbohydrates, alditols, and glycerol in growing yeast (Saccharomyces cerevisiae) cultures and their final fermentation broths. Both cultures were grown on complex undefined media, aliquots centrifuged to remove particulates, and the supernatants diluted and directly injected for analysis. Pulsed amperometry allowed a direct detection of the carbohydrates, alditols, and glycols present in the cultures and fermentation broths with very little interference from other matrix components. The broad linear range of three to four orders of magnitude allowed samples to be analyzed without multiple dilutions. Peak area RSDs were 2-7% for 2, 3-butanediol, ethanol, glycerol, erythritol, rhamnose, arabitol, sorbitol, galactitol, mannitol, arabinose, glucose, galactose, lactose, ribose, raffinose, and maltose spiked into a heat-inactivated yeast culture broth supernatant that was analyzed repetitively for 48 h. This method is useful for directly monitoring culture changes during fermentation. The carbohydrates in yeast cultures were monitored over 1 day. A yeast culture with medium consisting primarily of glucose and trace levels of trehalose and arabinose showed a drop in sugar concentration over time and an increase in glycerol. Yeast growing on a modified culture medium consisting of multiple carbohydrates and alditols showed preference for specific carbon sources and showed the ability to regulate pathways leading to catalysis of alternative carbon sources.     

Effects of osmotic and matric potential on radial growth and accumulation of endogenous reserves in three isolates of Pochonia chlamydosporia

For the first time, the effects of varying osmotic and matric potential on fungal radial growth and accumulation of polyols were studied in three isolates of Pochonia chlamydosporia. Fungal radial growth was measured on potato dextrose agar modified osmotically using potassium chloride or glycerol. PEG 8000 was used to modify matric potential. When plotted, the radii of the colonies were found to grow linearly with time, and regression was applied to estimate the radial growth rate (mm day^?1). Samples of fresh mycelia from 25-day-old cultures were collected and the quantity (mg g^?1 fresh biomass) of four polyols (glycerol, erythritol, arabitol and mannitol) and one sugar (glucose) was determined using HPLC. Results revealed that fungal radial growth rates decreased with increased osmotic or matric stress. Statistically significant differences in radial growth were found between isolates in response to matric stress (P<0.006) but not in response to osmotic stress (P=0.759). Similarly, differences in the total amounts of polyols accumulated by the fungus were found between isolates in response to matric stress (P<0.001), but not in response to osmotic stress (P=0.952). Under water stress, the fungus accumulated a combination of different polyols important in osmoregulation, which depended on the solute used to generate the stress. Arabitol and glycerol were the main polyols accumulated in osmotically modified media, whereas erythritol was the main polyol that was accumulated in media amended with PEG. The results found that Pochonia chlamydosporia may use different osmoregulation mechanisms to overcome osmotic and matric stresses.     

Polyol accumulation by two filamentous fungi grown at different concentrations of NaCl

The accumulation of polyols by Aspergillus niger (van Tiegh) strain S 1 and Penicillium chrysogenum (Thom) strain S 30 was followed during growth in media of different concentrations of NaCl. The major polyols found were glycerol, erythritol and mannitol. The total polyol pool increased in both organisms in response to raised salinity, and the proportion of glycerol and erythritol was markedly enhanced at high salinity.     

Production of erythritol and mannitol by Yarrowia lipolytica yeast in media containing glycerol

Glycerol is a by-product generated in large amounts during the production of biofuels. This study presents an alternative means of crude glycerol valorization through the production of erythritol and mannitol. In a shake-flasks experiment in a buffered medium, nine Yarrowia lipolytica strains were examined for polyols production. Three strains (A UV'1, A-15 and Wratislavia K1) were selected as promising producers of erythritol or/and mannitol and used in bioreactor batch cultures and fed-batch mode. Pure and biodiesel-derived crude glycerol media both supplemented (to 2.5 and 3.25?%) and not-supplemented with NaCl were applied. The best results for erythritol biosynthesis were achieved in medium with crude glycerol supplemented with 2.5?% NaCl. Wratislavia K1 strain produced up to 80.0?g?l(-1) erythritol with 0.49?g?g(-1) yield and productivity of 1.0?g?l(-1)?h(-1). Erythritol biosynthesis by A UV'1 and A-15 strains was accompanied by the simultaneous production of mannitol (up to 27.6?g?l(-1)). Extracellular as well as intracellular erythritol and mannitol ratios depended on the glycerol used and the presence of NaCl in the medium. The results from this study indicate that NaCl addition to the medium improves erythritol biosynthesis, and simultaneously inhibits mannitol formation.     

Differences in polyols content among fermentations of the same must with several yeasts

Summary Changes in polyols contents of must after fermentation with different yeasts were determined by gas-liquid chromatography (GLC). A decrease in sorbitol, mannitol and inositol as well as the formation of erythritol, arabitol and xylitol were observed in all samples. Maximum decrease in sorbitol and mannitol was detected when flor yeast was employed.     

Endogenous arabitol and mannitol improve shelf life of encapsulated <Emphasis Type="Italic">Metarhizium brunneum</Emphasis>

Successful commercialization of microbial biocontrol agents, such as Metarhizium spp., is often constrained by poor drying survival and shelf life. Here, we hypothesized that culture age would influence endogenous arabitol, erythritol, mannitol and trehalose contents in M. brunneum mycelium and that elevated levels of these compounds would improve drying survival and shelf life of encapsulated mycelium coupled with enhanced fungal virulence against T. molitor larvae. We found that culture age significantly influenced endogenous arabitol and mannitol contents in mycelium with highest concentrations of 0.6?±?0.2 and 2.1?±?0.2 µg/mg after 72 h, respectively. Drying survival of encapsulated mycelium was independent of culture age and polyol content with 41.1?±?4.4 to 55.0?±?6.2%. Best shelf life was determined for biomass harvested after 72 h at all investigated storage temperatures with maximum values of 59.5?±?3.3% at 5 °C followed by 54.5?±?1.6% at 18 °C and 19.4?±?1.3% at 25 °C after 6 months. Finally, high fungal virulence against T. molitor larvae of 83.3?±?7.6 to 98.0?±?1.8% was maintained during storage of encapsulated mycelium for 12 months with larval mortalities being independent of culture age and polyol content. In conclusion, our findings indicate beneficial effects of endogenous polyols in improving shelf life of encapsulated mycelium and this may spur the successful development of microbial biocontrol agents in the future.     

蝉拟青霉菌丝体与天然蝉花中化学成分的比较分析

以天然蝉花Cordyceps cicadae做对比,对一株蝉拟青霉Paecilomyces cicadae菌株发酵菌丝体的化学成分进行了分析,包括粗成分、生物活性成分、无机元素、氨基酸、脂肪酸等。结果表明:蝉拟青霉菌丝体中虫草多糖的含量为33.2mg/g,甘露醇的含量为78.9mg/g,麦角甾醇的含量为0.6256mg/g,腺苷的含量为1.0620mg/g,钙、铁、锌、硒和锰微量元素的含量分别为5187.59μg/g、207.23μg/g、41.93μg/g、0.087μg/g和28.24μg/g,18种氨基酸齐全,不饱和脂肪酸是优势脂肪酸,以亚麻油酸、油酸为主,其相对含量分别为53.91%和20.63%,与天然蝉花相比,发酵菌丝体中虫草多糖、甘露醇、麦角甾醇、腺苷、氨基酸总量、必需氨基酸总量和不饱和脂肪酸的含量明显高于后者,其它化学成分和天然蝉花中相应成分基本一致。     

Nonelectrolyte penetration and sodium fluxes through the axolemma of resting and stimulated medium sized axons of the squid Doryteuthis plei

The penetration of ¹⁴C-labeled erythritol, mannitol, and sucrose through the axolemma was determined in medium sized paired axons, one at rest and the other stimulated 25 times per sec. The resting permeabilities, in 10^-7 cm/sec, are erythritol, 2.9 ± 0.3 (mean ± SEM); mannitol, 2.3 ± 0.4; and sucrose 0.9 ± 0.1. In the stimulated axons they are: erythritol, 5.2 ± 0.3; mannitol, 4.0 ± 0.5; and sucrose, 1.8 ± 0.3. Thus, the calculated permeabilities during activity (1 msec per impulse), in the same units, are: 100, 75, and 38, respectively. These changes in permeability are reversible. The effects of external potassium and sodium concentrations on erythritol penetration were also studied. At rest, erythritol penetration is independent of potassium and sodium concentrations. In the stimulated axons, erythritol penetration decreases when the extracellular sodium is diminished. Sodium influx (not the efflux) decreases during rest and activity when the extracellular sodium is diminished. The diminution during activity of erythritol and sodium entries in low sodium solutions may be related to a decrease of a drag effect of sodium ions on the nonelectrolyte molecules or to independent effects of the sodium concentration on sodium influx and the nonelectrolyte pathways. The axolemma discriminates among erythritol, mannitol, sucrose, and the different ionic species during rest and activity.