On-line estimation of O<Subscript>2</Subscript> production,CO<Subscript>2</Subscript> uptake,and growth kinetics of microalgal cultures in a gas-tight photobioreactor

Growth of the green algae Chlamydomonas reinhardtii and Chlorella sp. in batch cultures was investigated in a novel gas-tight photobioreactor, in which CO₂, H₂, and N₂ were titrated into the gas phase to control medium pH, dissolved oxygen partial pressure, and headspace pressure, respectively. The exit gas from the reactor was circulated through a loop of tubing and re-introduced into the culture. CO₂ uptake was estimated from the addition of CO₂ as acidic titrant and O₂ evolution was estimated from titration by H₂, which was used to reduce O₂ over a Pd catalyst. The photosynthetic quotient, PQ, was estimated as the ratio between O₂ evolution and CO₂ up-take rates. NH₄ ⁺, NO₂ ⁻, or NO₃ ⁻ was the final cell density limiting nutrient. Cultures of both algae were, in general, characterised by a nitrogen sufficient growth phase followed by a nitrogen depleted phase in which starch was the major product. The estimated PQ values were dependent on the level of oxidation of the nitrogen source. The PQ was 1 with NH₄ ⁺ as the nitrogen source and 1.3 when NO₃ ⁻ was the nitrogen source. In cultures grown on all nitrogen sources, the PQ value approached 1 when the nitrogen source was depleted and starch synthesis became dominant, to further increase towards 1.3 over a period of 3–4 days. This latter increase in PQ, which was indicative of production of reduced compounds like lipids, correlated with a simultaneous increase in the degree of reduction of the biomass. When using the titrations of CO₂ and H₂ into the reactor headspace to estimate the up-take of CO₂, the production of O₂, and the PQ, the rate of biomass production could be followed, the stoichiometrical composition of the produced algal biomass could be estimated, and different growth phases could be identified.     

Utilization of cyanobacterial biomass from water bloom for bioproduction of lactic acid

Cyanobacterial biomass obtained from water blooms was successfully utilized as a material for lactic acid production. The starch contained in the biomass could be converted to D- and L-lactic acid with 80–90% yield by Lactobacillus amylovorus, in a manner similar to that contained in laboratory-cultured cyanobacterial biomass. The starch was also available for L-lactic acid production with similar high yields by L. agilis and L. ruminis that specifically produce L-lactic acid. The lactic acid production from the cyanobacterial biomass did not require any supplements such as yeast extract which are essential for lactic acid production from reagent soluble starch, indicating that nutrients contained in the cyanobacterial biomass might be effectively used for the production instead of the supplements. The starch content of the fresh cyanobacterial biomass from water bloom was increased from 10 to 19 and 24% by cultivation in 1 and 5% CO₂ in air, respectively. Using such starch-rich biomass, the concentration of lactic acid produced was successfully increased without changes in the conversion yield. These results indicate that wastewater bloom cyanobacteria could be utilized for the production of a useful compound, lactic acid.     

Enhanced methane production in a two-phase anaerobic digestion plant, after CO2 capture and addition to organic wastes

Cost-effective technologies are needed to reach the international greenhouse gas (GHG) reduction targets in many fields, including waste and biomass treatment. This work reports the effects of CO₂ capture from a combustion flue gas and its use in a newly-patented, two-phase anaerobic digestion (TPAD) process, to improve energy recovery and to reduce CO₂ emissions. A TPAD process, fed with urban wastewater sludge, was successfully established and maintained for several months at pilot scale. The TPAD process with injection of CO₂ exhibits efficient biomass degradation (58% VSS reduction), increased VFA production during the acidogenic phase (leading to VFA concentration of 8.4 g/L) and high biomethane production (0.350 Sm³/kg_SSV; 0.363 Sm³/m³_react·d). Moreover, CO₂ intake in the acid phase has a positive impact on the overall GHG balance associated to biomethane production, and suggests an improved solution for both emission reduction and biomass conversion into biomethane.     

Prostaglandin E<Subscript>2 </Subscript>production by high and low virulent strains of <Emphasis Type="Italic">Paracoccidioides brasiliensis</Emphasis>

The production of prostaglandins (PGs) during fungal infections could be an important suppressor factor of host immune response. Host cells are one source of prostaglandin E₂ (PGE₂); however another potential source of PGE₂ is the fungal pathogen itself. Thus, both host and fungal PGE2 production is theorized to play a role in pathogenesis, being critical for growth of the fungus and to modulate the host immune response. The purpose of this work was to investigate if high and low virulent strains of Paracoccidioides brasiliensis have the capacity to produce PGE₂ in vitro, and if this production was related to the fungal growth. The results demonstrated that both strains of P. brasiliensis produce high levels of PGE₂ and the treatment with indomethacin, a cyclooxygenase inhibitor, significantly reduced the production of this mediator, as well as the viability of the fungus. Thus, our data indicate that PGE₂ is produced by P. brasiliensis by a cyclooxygenase–dependent metabolic pathway, and its production is required for fungal survival. This discovery reveals an important factor that has potentially great implications for understanding the mechanisms of immune deviation during infection.     

Effect of n-dodecane on Crypthecodinium cohnii fermentations and DHA production

The potential use of n-dodecane as an oxygen vector for enhancement of Crypthecodinium cohnii growth and docosahexaenoic acid (DHA) production was studied. The volumetric fraction of oxygen vector influenced the gas–liquid volumetric mass transfer coefficient k _L a positively. The k _L a increased almost linearly with the increase of volumetric fraction of n-dodecane up to 1%. The stirring rate showed a higher influence on the k _L a than the aeration rate. The effects of this hydrocarbon on C. cohnii growth and DHA production were then investigated. A control batch fermentation without n-dodecane addition (CF) and a batch fermentation where n-dodecane 1% (v/v) was added (DF) were carried out simultaneously under the same experimental conditions. It was found that, before 86.7 h of fermentation, the biomass concentration, the specific growth rate, the DHA, and total fatty acids (TFA) production were higher in the CF. After this fermentation time, the biomass concentration, the DHA and TFA production were higher in the DF. The highest DHA content of biomass (6.14%), DHA percentage of TFA (51%), and DHA production volumetric rate r _DHA (9.75 mg l⁻¹ h⁻¹) were obtained at the end of the fermentation with n-dodecane (135.2 h). The dissolved oxygen tension (DOT) was always higher in the DF, indicating a better oxygen transfer due to the oxygen vector presence. However, since the other C. cohnii unsaturated fatty acids percentages did not increase with the oxygen availability increase due to the n-dodecane presence, a desaturase oxygen-dependent mechanism involved in the C. cohnii DHA biosynthesis was not considered to explain the DHA production increase. A selective extraction through the n-dodecane was suggested.     

Influence of agitation and aeration on growth and antibiotic production by <Emphasis Type="Italic">Xenorhabdus nematophila</Emphasis>

The effect of agitation and aeration on the growth and antibiotic production by Xenorhabdus nematophila YL001 grown in batch cultures were investigated. Efficiency of aeration and agitation was evaluated through the oxygen mass transfer coefficient (K _L a). With increase in K _L a, the biomass and antibiotic activity increased. Activity units of antibiotic and dry cell weight were increased to 232 U ml⁻¹ and 19.58 g l⁻¹, respectively, productivity in cell and antibiotic was up more than 30% when K _L a increased from 115.9 h⁻¹ to 185.7 h⁻¹. During the exponential growth phase, DO concentration was zero, the oxygen supply was not sufficient. So, based on process analysis, a three-stage oxygen supply control strategy was used to improved the DO concentration above 30% by controlling the agitation speed and aeration rate. The dry cell weight and activity units of antibiotic were further increased to 24.22 g l⁻¹ and 249 U ml⁻¹, and were improved by 24.0% and 7.0%, compared with fermentation at a constant agitation speed and a constant aeration rate (300 rev min⁻¹, 2.5 l min⁻¹).     

The combined effects of elevated CO2 levels and UV-B radiation on growth characteristics ofElymus athericus (= E. pycnanathus)

Elymus athericus (Link) Kerguélen, a C₃ grass, was grown in a greenhouse experiment to determine the effect of enhanced atmospheric CO₂ and elevated UV-B radiation levels on plant growth. Plants were subjected to the following treatments; a) ambient CO₂-control UV-B, b) ambient CO₂-elevated UV-B, c) double CO₂-control UV-B, d) double CO₂-elevated UV-B. Elevated CO₂ concentrations stimulated plant growth, biomass production was 67% higher than at ambient CO₂. Elevated UV-B radiation had a negative effect on growth, biomass production was depressed by 31%. Enhanced CO₂ combined with elevated UV-B levels caused a biomass depression of 8% when compared with the control plants. UV-B induced growth depression can be modified by a growth stimulus caused by high CO₂ concentrations. Growth analysis has been performed and possible physiological mechanisms behind changing growth parameters are discussed.     

Effect of soil drying on growth,biomass allocation and leaf gas exchange of two annual grass species

Influence of short-term water stress on plant growth and leaf gas exchange was studied simultaneously in a growth chamber experiment using two annual grass species differing in photosynthetic pathway type, plant architecture and phenology:Triticum aestivum L. cv. Katya-A-1 (C₃, a drought resistant wheat cultivar of erect growth) andTragus racemosus (L.) All. (C₄, a prostrate weed of warm semiarid areas). At the leaf level, gas exchange rates declined with decreasing soil water potential for both species in such a way that instantaneous photosynthetic water use efficiency (PWUE, mmol CO₂ assimilated per mol H₂O transpired) increased. At adequate water supply, the C₄ grass showed much lower stomatal conductance and higher PWUE than the C₃ species, but this difference disappeared at severe water stress when leaf gas exchange rates were similarly reduced for both species. However, by using soil water more sparingly, the C₄ species was able to assimilate under non-stressful conditions for a longer time than the C₃ wheat did. At the whole-plant level, decreasing water availability substantially reduced the relative growth rate (RGR) ofT. aestivum, while biomass partitioning changed in favour of root growth, so that the plant could exploit the limiting water resource more efficiently. The change in partitioning preceded the overall reduction of RGR and it was associated with increased biomass allocation to roots and less to leaves, as well as with a decrease in specific leaf area. Water saving byT. racemosus sufficiently postponed water stress effects on plant growth occurring only as a moderate reduction in leaf area enlargement. For unstressed vegetative plants, relative growth rate of the C₄ T. racemosus was only slightly higher than that of the C₃ T. aestivum, though it was achieved at a much lower water cost. The lack of difference in RGR was probably due to growth conditions being relatively suboptimal for the C₄ plant and also to a relatively large investment in stem tissues by the C₄ T. racemosus. Only 10% of the plant biomass was allocated to roots in the C₄ species while this was more than 30% for the C₃ wheat cultivar. These results emphasize the importance of water saving and high WUE of C₄ plants in maintaining growth under moderate water stress in comparison with C₃ species.     

PO2 and pH changes in the retina of the crab Ocypode ryderi: evidence for aerobic glycolysis

Summary The isolated retina of the terrestrial crab Ocypode ryderi exhibits a pronounced lactate production in spite of being supplied with sufficient O₂ (140 torr). To determine whether this lactate production is caused by hypoxic areas in the tissue or represents aerobic glycolysis, oxygen partial pressure and pH measurements with two-channel glass microelectrodes and additional biochemical analyses were carried out on this organ. Distinct profiles were obtained for O₂ partial pressure and pH inside the tissue. At a depth of 200 m different O₂ partial pressure levels could be observed depending on the O₂ partial pressure in the medium (85 torr at 280 torr and 36 torr at 130 torr, respectively). The extracellular pH displays a similar pattern; it reaches a stable value of 7.15 at 100 m inside the tissue. Lowering bath O₂ partial pressure from 280 torr to about 15 torr (hypoxia) induces a decrease of the O₂ partial pressure in the tissue with different time-courses for different tissue depths. However, hypoxia did not change the extracellular pH. Addition of antimycin A (100 mol · 1^-1) to the medium abolishes the O₂ partial pressure gradient and the delayed recovery of the tissue O₂ partial pressure after hypoxia. These results and the biochemical data suggest that in the crab retina a high glycolytic activity occurs simultaneously with oxydative carbohydrate degradation (aerobic glycolysis).Abbreviations AEC Atkinson energy charge - DC bioelectric potential - dw dry weight - HEPES N-[2-Hydroxyethyl]piperazine-N-[2-ethanesulphonic acid] - PCO₂ carbon dioxide partial pressure - PO₂ oxygen partial pressure - P _tO₂ oxygen partial pressure inside the tissue - P _mO₂ oxygen partial pressure in the medium - pH_t pH inside the tissue - pH_m pH in the superfusion medium     

Coenzyme Q<Subscript>10</Subscript> production by <Emphasis Type="Italic">Rhodobacter sphaeroides</Emphasis> in stirred tank and in airlift bioreactor

A higher Coenzyme Q₁₀ (CoQ₁₀) concentration of 25.04 mg/l was found in airlift bioreactor than the value of 18.11 mg/l obtained in stirred tank under the aerobic-dark cultivation of Rhodobacter sphaeroides. Aeration rate didn’t show obvious impact to CoQ₁₀ production in airlift bioreactor. The fed-batch operation in airlift bioreactor could increase the biomass concentration and led to the maximum CoQ₁₀ concentration of 33.91 mg/l measured, but a lower CoQ₁₀ cell content (3.5 mg CoQ₁₀/DCW) was observed in the fed-batch operation as compared to the batch operation. To enhance the CoQ₁₀ content, an aeration-change strategy was proposed in the fed-batch operation of airlift bioreactor. This strategy led to the maximum CoQ₁₀ concentration of 45.65 mg/l, a 35% increase as compared to the simple fed-batch operation. The results of this study suggested that a fed-batch operation in airlift bioreactor accompanying aeration-change could be suitable for CoQ₁₀ production.