低温脂肪酶产生菌的筛选、产酶发酵及粗酶性质研究

利用含有Tween 80的琼脂平板和摇瓶发酵法,从若尔盖高原土壤中筛选产脂肪酶菌株.通过菌落形态和菌体特征观察初步对菌种进行鉴定,得到一株产低温脂肪酶的适冷菌Pseudomonassp.DL-B,并设计正交试验对该菌株的产酶发酵培养条件进行了优化.摇瓶实验表明,该菌株最适产酶发酵培养基为:蔗糖10 g/L,蛋白胨20 ...     

黑曲霉生产菊粉酶工艺条件的研究

从徐州市沛县河口镇秦庄村牛蒡种植基地取得的土壤样本中,筛选出产菊粉酶的菌株,对从土壤中分离到的40株产菊粉酶的各类微生物进行酶活的测定。通过透明圈法初筛及摇瓶复筛,获得产菊粉酶能力较高的霉菌菌株3株,为C122803、D081506和D081513,这3株菌株的酶活分别达到：C122803：1.411 U/ml;D081506 ：1.895U/ml;D081513 ：1.792U/ml。其中D081506的酶活最高,为1.895U/ml;对D081506号黑曲霉产菊粉酶的发酵条件进行了研究,确定了优化的发酵条件为：牛蒡汁2%,酵母膏1.6%,(NH4)2SO41.6%,NaCl 0.5%,K2HPO4 0.5%,pH 5.0,在27℃、140 r/min条件下,摇瓶培养24h, D081506酶活力为2.958U/ml,酶活力提高56.09%。     

一株产几丁质酶菌株的筛选及其产酶条件的研究

采用平板透明圈法从土壤中分离筛选到一株产几丁质酶放线菌株L12,用250mL摇瓶发酵初筛和复筛,酶活力为0.63U/mL。通过产酶条件实验,初步确定了该菌株较适产酶培养基和摇瓶发酵条件。条件优化后,30℃、250mL摇瓶发酵48h,几丁质酶活力达到1.06U/mL。     

产黄曲霉毒素B1降解酶菌株的筛选鉴定及发酵条件优化

以香豆素为唯一碳源筛选到27株能高效降解黄曲霉毒素B1(AFB1)的微生物菌株.用高效液相色谱检测AFB1含量的方法进行AFB1降解酶活力测定.以不同菌株发酵上清液中AFB1降解酶活力高低为复筛条件,筛选到AFB1降解酶活力最高的一株菌并命名为HSD8.该菌株经形态学、生理生化及系统发育学方法鉴定为Sinomonas sp..筛选所得最优菌株的发酵上清液中酶活达443 U/mL,通过单因素试验对其产酶发酵条件进行优化,以提高酶活.优化所得最佳发酵条件为:装液量50 mL/250 mL,发酵周期48 h,初始pH 5.0,接种量8％,发酵温度37℃,摇床转速160r/min.在最佳发酵条件下,该菌株发酵上清液中酶活可达548 U/mL,比优化前提高23.7％.优选菌株HSD8在生物降解黄曲霉毒素B1方面具有应用潜力,值得进一步研究开发.     

产弹性蛋白酶菌种的筛选及发酵条件优化研究

从合肥肉联厂附近的土壤和污水中分离得到19株产弹性蛋白酶菌株,初步鉴定该菌株属于假单胞菌属.经过发酵复筛有三株产酶能力超过15u/mL.实验对菌株最佳产酶发酵条件进行了优化2%干酪素、0.5%葡萄糖、0.4%酵母膏、0.2% K2HPO4、0.01% MgSO4·7H2O;起始pH值7.0;最适发酵温度为30℃;装液量为25mL/250mL;该菌株在28h左右产弹性蛋白酶的量达18u/mL.     

一株产胆固醇氧化酶的不动杆菌的筛选鉴定及特性研究

目的：筛选鉴定产胆固醇氧化酶的菌株并对其酶的性质及发酵条件进行初步的研究。方法：利用唯一碳源的胆固醇平板筛选,酶活测定比较得酶活力最高的菌株;生理生化试验结合16S rDNA序列分析鉴定其种属,单因素及正交实验优化培养基及发酵条件。结果：所得菌株H4与产不动杆菌（Acinetobacter）有最近的亲缘关系,其胆固醇氧化酶作用的最适温度和pH分别为37℃和8.0,金属离子Mg2＋、Zn2＋、Fe2＋对该酶具有一定激活作用,菌株产酶的最适培养基为（g/L）：胆固醇1.5,蔗糖5,蛋白胨7,硝酸铵3,吐温1.0,pH7.5;最适培养条件为33℃,15mL培养基/100mL三角瓶,摇床培养（200r/min）48h,优化后发酵液酶活达135.8U/L。结论：获得了1株产胆固醇氧化酶的菌株H4,并初步鉴定为不动杆菌（Acinetobacter）。     

海藻糖产生菌的筛选及其发酵条件研究

通过液体发酵筛选,从土壤中分离的241株菌株及保藏的95株菌株中得到15株海藻糖生产菌,对这些菌株进一步筛选得到产海藻糖最多的一株菌Bacillus sp。其发酵最适合条件为：以麦芽糖为碳源,发酵初始pH值7.0,接种量为6%,30℃条件下培养48h,另外该菌株在分别以葡萄糖和蔗糖为碳源的培养基中都能产生海藻糖。     

α-葡萄糖苷酶高产菌株HB-9-5的选育及产酶条件的优化

从土壤中筛选出一株高产α-葡萄糖苷酶的细菌HB-09-5,对其粗酶液进行研究发现,最适反应pH为6.0,最适反应温度为50℃,pH在4.0-7.0,温度在55℃以下保持酶活力相对稳定。通过对产酶条件进行优化,单因素试验表明,最佳碳源为可溶性淀粉,最佳氮源为牛肉膏,Mg2+和Ca2+对产酶有促进作用。优化发酵条件后,菌株HB-09-5产酶水平可达到20.95U/mL,比出发菌酶活提高了2.3倍。     

一株中温淀粉酶菌株的分离鉴定及其产酶条件分析

利用固体淀粉筛选培养基,从安阳市郊区面粉厂附近的土壤里分离筛选出1株产淀粉酶的菌株,编号为MF-3-2.经过菌株形态、革兰氏染色、16S rDNA鉴定及系统进化树分析,初步确定其为枯草芽孢杆菌(Bacillus subtilis).摇瓶培养后对其酶学性质研究发现,该菌株淀粉酶的最适温度为65℃,最适pH值为6.0,在pH值4.8～6.0范围内仍能残余70％以上的酶活力.该菌株的最适生长温度为40℃,最适生长pH值为6.5.产酶条件优化结果表明:最适碳源为马铃薯淀粉,最适氮源为豆粕粉,最适碳氮比为1∶15,发酵温度30℃,发酵pH值6.0,装液量10％,种龄10h,接种量5％,转速200 r/min,48 h达到产酶高峰.通过发酵产酶条件优化,其淀粉酶活性达到86.8 U/mL,是优化前的35倍.另外,在酸性条件下还具有较好的活性.因此,该菌株的淀粉酶具有潜在的工业应用前景.     

一株脂肪酶产生菌的筛选及产酶条件优化研究

通过利用溴甲酚紫显色培养基初筛和酶活测定法复筛得到产脂肪酶的一株细菌HP2,经形态学观察和生理生化测定初步鉴定该菌株为不动杆菌属。并对该菌株的摇床培养产酶条件进行了初步研究,采用正交试验对HP2菌株发酵产脂肪酶的条件进行了优化,得到最佳发酵条件为初始pH为7.7,培养温度为35℃,接种量(V/V)为1.5%,发酵周期为48 h,酶活力达到129.7 U/mL。     

Purification and Properties of a Pectate Lyase in Erwinia aroideae

A strain of Erwinia aroideae produced an extracellular pectolytic enzyme under growth conditions with pectin or pectic acid as the inducer. This strain also produced a pectin lyase when nalidixic acid is added to a culture medium. The pectolytic enzyme produced under the growth conditions was purified approximately 40-fold from the culture fluid by carboxy- methyl cellulose and Sephadex G-75 gel column chromatographies. The purified enzyme was almost homogeneous on sodium dodecyl sulfate polyacrylamide gel electrophoresis, having a molecular weight of about 36,000 to 38,000. This enzyme, with optimal activity at pH 9.0 to 9.2, produced reaction products which had a strong absorption at 230 nm indicating a lyase type of the reaction. The enzyme activity was markedly stimulated by calcium ion and completely inhibited by cobalt and mercuric ions and by ethylenediaminetetraacetate. Pectic acid or pectin with lower methoxyl content was a good substrate for this enzyme, while no significant activity was observed when pectin with higher methoxyl content was used as a substrate. It was concluded that the enzyme produced under the normal growth conditions is an endo-pectate lyase and differs from the pectin lyase induced by nalidixic acid.     

Optimization of culture conditions for the production of thermostable polygalacturonase by <Emphasis Type="Italic">Penicillium</Emphasis> SPC-F 20

Penicillium strain isolated from citrus fruit was found to produce thermostable polygalacturonases. Optimization of process parameters resulted in high levels of enzyme production after 3 days of incubation at a pH of 5.0 at 30 degrees C in the presence of 1% pectin. The optimum temperature for enzyme activity was 60 degrees C and a pH of 5.5 was found to be the optimal pH. The enzyme showed a high level of thermostability in the presence of substrate with a residual activity of 48% after 2 h of incubation at 60 degrees C. A thermostable nature with a high pH range for activity makes it an industrially important enzyme.     

Purification and Properties of a Polygalacturonic Acid Trans-Eliminase Produced by Bacillus pumilus

A strain of Bacillus pumilus produced an extracellular pectic enzyme with polygalacturonic acid as the substrate. This enzyme, with optimal activity at pH 8.0 to 8.5, produced reaction products that strongly absorbed light at 232 nm, indicating the presence of a pectic acid trans-eliminase (PATE). Neither pectin esterase nor polygalacturonase was detected in the cell-free culture fluid. Chromatographic examination of the end products revealed the presence of large quantities of unsaturated oligouronides unlike those found with B. polymyxa. It was found that the PATE was produced extracellularly during the negative logarithmic death phase of the organism. The filtrate from sonically treated cells did not show any activity for PATE or hydrolases for lower oligogalacturonides at any time during the growth cycle. The enzyme was inducible. Pectin, National Formulary (NF) was the best inducer, followed by polygalacturonic acid and galacturonic acid. Enzyme activity was markedly stimulated by calcium and other divalent ions. Copper and cobalt ions were inhibitory. The partially purified enzyme showed no significant activity on pectin containing a high methoxyl content (96% esterified). However, pectin NF with a lower methoxyl content (68% esterified) was attacked to a degree by the partially purified and crude enzyme preparations. The initial rate of PATE activity increased up to 60 C, about 16-fold higher than that observed at room temperature. The activation energy was calculated as 12,183 cal/mole. A protective action of calcium chloride against heat inactivation of the PATE was observed. Degradation of polygalacturonic acid by this enzyme produced several unsaturated oligouronides soon after its addition to the substrate. The major endproduct was thought to be different from that of other known PATE enzymes. Paper chromatographic studies and viscosity measurements disclosed the random cleaving nature of the enzyme an endo-PATE.     

Culture conditions for the production of pectinolytic enzymes by the white-rot fungus Trametes trogii on a laboratory scale

Different cultural parameters that regulate pectinolytic enzyme production in vitro by Trametes trogii were studied. When grown in a medium containing pectin, T. trogii produced extracellular polymethylgalacturonase, polygalacturonase and pectin lyase but no pectate lyase activity. No significant differences in the maximum enzyme activities measured were observed with the addition of xylan, carboxymethylcellulose or both to the medium containing pectin. The addition of glucose to that medium considerably decreases all the activities studied, and in a medium with glucose as the sole carbon source no galacturonase activity could be measured, and pectin lyase activity was at its minimum. The low synthesis of pectin lyase in cultures containing glucose suggests that this enzyme is constitutive in contrast to the polygalacturonases that were not detected. The increase in pectin concentration stimulated growth and enzyme production. The highest specific activities were attained with the greatest concentration tested (15 g/l). Casamino acids were the best nitrogen source for enzyme production. Maximum growth was measured at pH 3.3; pH values of around 4.5 stimulated enzyme production, but high pectinase activities were also detected in media with more alkaline initial pH values (6.2 for galacturonases and 6.6 for lyases), probably owing to the specific induction of particular isoforms. In the range of 23 to 28°C, good results were obtained in growth as well as in enzyme production. The addition of Tween 80 promoted growth and gave the highest yield of polymethylgalacturonase and pectin lyase (0.37 and 36.2 E.U./ml, respectively). The highest polygalacturonase activity (1.1 E.U/ml) was achieved with polyethylene glycol. Tween 20 and Triton X-100 inhibited growth and pectinase production.     

类芽胞杆菌碱性果胶裂解酶的纯化与酶学性质表征

从类芽胞杆菌Paenibacillus sp.WZ008的发酵上清液中纯化得到一个高活力碱性果胶裂解酶,经SDS-PAGE电泳估算其亚基相对分子质量为4.5×104。通过对该酶进行酶学性质研究发现：该酶能催化裂解果胶酸、低酯果胶和高酯果胶;酶催化反应最适温度范围为55～60℃,最适pH为9.6,在最适条件下以低酯果胶为底物酶的比酶活达3 021.6 U/mg;Ca2＋能增强该酶的活力,而Mn2＋,Ba2＋和EDTA强烈抑制该酶活力;当没有Ca2＋存在时,高度酯化的果胶是该酶的最适底物,在4 mmol/L Ca2＋存在时,该酶以果胶酸为底物比酶活最高（25 467 U/mg）。该酶N端序列比对分析发现与类芽胞杆菌Paenibacillus amylolyticus strain 27c64果胶裂解酶高度同源。     

Studies on Pectic Enzymes of Microorganisms

Conditions for the production of endo-polygalacturonase (endo-PG) with Aspergillus saitoi IAM 2217 in the submerged culture was examined. This strain was selected as the most potent producer of endo-PG. Endo-PG of this strain was produced in the absence of pectin, but the addition of pectin increased endo-PG activity when inoculated with proliferated mycelia.

As far as examined with a modified Czapek medium (ordinary constituents + pectin and ammonium tartrate), the addition of organic nitrogen sources, such as corn steep liquor, markedly reduced the enzyme producibility. As for the carbon and nitrogen amount in the medium, sucrose: 4%, pectin: 2%, NaNO₃: 1.15%, C/N = 10, gave the best result among tested.     

Pectin lyase from <Emphasis Type="Italic">Aspergillus giganteus</Emphasis>: Comparative study of productivity of submerged fermentation on citrus pectin and orange waste

The aim of this study was to investigate some of the factors affecting pectin lyase (PL) production by an Aspergillus giganteus strain, and to characterize this pectinolytic activity excreted into the medium. The highest activities were obtained with orange waste, citrus pectin and galacturonic acid as carbon sources. The highest activity, using citrus pectin as carbon source, was obtained in 11-day-old standing cultures, but the highest specific activity was obtained in 6.5-day-old shaken cultures, at pH 6.5 and 35°C. Using orange waste as carbon source, the highest activity was observed in 8-day-old standing cultures, at pH 7.0 and 30°C. Optimal assay conditions were pH 8.5–9.0 and 50°C. The PL activity showed thermal stability, with half-lives of 30 and 27 min when incubated at 45 and 50°C, respectively. High stability was observed at room temperature from pH 6.0 to 10.0; more than 85% of enzyme activity was preserved in this pH range. Under optimum conditions, the highest pectin lyase activity in the medium was 470 U/ml, with orange waste as carbon source.     

片烟产果胶酶细菌的鉴定及酶活测定

以果胶为碳源, 对津巴布韦片烟烟叶表面产果胶酶细菌进行分离, 采用16S rDNA限制性酶切片段长度多态性分析(ARDRA)和测序方法, 结合形态学、生理生化实验, 对所分离产果胶酶菌株进行鉴定, 同时研究培养时间、温度、起始pH、接种量对菌株产酶的影响。结果表明, 从津巴布韦片烟烟叶表面分离得到的产果胶酶菌株主要为芽孢杆菌属的枯草芽孢杆菌Bacillus subtilis和产碱菌属的粪产碱菌Alcaligenes faecalis。在所分离的菌株中, 枯草芽孢杆菌T10酶活力最高, 以6%的接种量, 在温度为35 °C、起始pH为7.5条件下培养48?56 h, 其果胶酶酶活为571 U/mg, 聚半乳糖醛酸裂解酶酶活为297 U/mg。     

Fermentation of pectin and glucose, and activity of pectin-degrading enzymes in the rumen bacterium Lachnospira multiparus

AIMS: Lachnospira multiparus belongs to the main rumen pectinolytic bacteria. Its carbohydrate metabolism was studied in growth experiments on laboratory fermenters, and using assays of activities of enzymes involved in pectin fermentation. METHODS AND RESULTS: The type strain of this species and two substrates were used. Lachnospira multiparus ATCC 19207 grew on pectin and glucose at a similar rate and had no preference for one or the other substrate. Pectin-grown cultures, however, produced significantly more acetate and less formate, lactate, ethanol, hydrogen, cell dry matter and protein than corresponding cultures grown on glucose. Extracellular exopectate lyase (EC 4.2.2.9) was the principal enzyme degrading the pectin macromolecule. Cell extracts possessed 2-keto-3- deoxy-6-phosphogluconate aldolase (EC 4.1.2.14) and fructosediphosphate aldolase (EC 4.1.2.13) activity. The former enzyme catalyses the final reaction in the Entner-Doudoroff pathway; the latter is the key enzyme of glycolysis and the pentose phosphate pathway. CONCLUSION: These results are consistent with the assumption that acidic products of pectin degradation are catabolized via a modified Entner-Doudoroff pathway. Phosphogluconate was not metabolized by cell extracts of the strain studied. SIGNIFICANCE AND IMPACT OF THE STUDY: This suggests that the conventional Entner-Doudoroff pathway of glucose utilization does not operate in this bacterium, presumably because of the lack of 6-phosphogluconate dehydrase (EC 4.2.1.12) activity.     

Activity of an atypical <Emphasis Type="Italic">Arabidopsis thaliana</Emphasis> pectin methylesterase

An Arabidopsis thaliana pectin methylesterase that was not predicted to contain any signaling sequence was produced in E. coli and purified using a His tag added at its N-terminus. The enzyme demethylesterified Citrus pectin with a Km of 0.86 mg/ml. The enzyme did not require salt for activity and was found to be relatively temperature-sensitive. The precipitation of enzyme-treated pectin by CaCl2 suggested that the enzyme had a blockwise mode of pectin demethylesterification. A purified kiwi (Actinidia chinensis) pectin methylesterase inhibitor had no effect on the activity of the enzyme whereas it strongly inhibited a flax pectin methylesterase. A model of the protein structure revealed that an extra amino acid sequence in this particular Arabidopsis pectin methylesterase could form a ss-strand outside the core structure, which might be preventing the inhibitor from binding the protein.