Efficacy of various pasteurization time-temperature conditions in combination with homogenization on inactivation of Mycobacterium avium subsp. paratuberculosis in milk

The effect of various pasteurization time-temperature conditions with and without homogenization on the viability of Mycobacterium avium subsp. paratuberculosis was investigated using a pilot-scale commercial high-temperature, short-time (HTST) pasteurizer and raw milk spiked with 10(1) to 10(5) M. avium subsp. paratuberculosis cells/ml. Viable M. avium subsp. paratuberculosis was cultured from 27 (3.3%) of 816 pasteurized milk samples overall, 5 on Herrold's egg yolk medium and 22 by BACTEC culture. Therefore, in 96.7% of samples, M. avium subsp. paratuberculosis had been completely inactivated by HTST pasteurization, alone or in combination with homogenization. Heat treatments incorporating homogenization at 2,500 lb/in2, applied upstream (as a separate process) or in hold (at the start of a holding section), resulted in significantly fewer culture-positive samples than pasteurization treatments without homogenization (P < 0.001 for those in hold and P < 0.05 for those upstream). Where colony counts were obtained, the number of surviving M. avium subsp. paratuberculosis cells was estimated to be 10 to 20 CFU/150 ml, and the reduction in numbers achieved by HTST pasteurization with or without homogenization was estimated to be 4.0 to 5.2 log10. The impact of homogenization on clump size distribution in M. avium subsp. paratuberculosis broth suspensions was subsequently assessed using a Mastersizer X spectrometer. These experiments demonstrated that large clumps of M. avium subsp. paratuberculosis cells were reduced to single-cell or "miniclump" status by homogenization at 2,500 lb/in2. Consequently, when HTST pasteurization was being applied to homogenized milk, the M. avium subsp. paratuberculosis cells would have been present as predominantly declumped cells, which may possibly explain the greater inactivation achieved by the combination of pasteurization and homogenization.     

Heat inactivation of Mycobacterium avium subsp. paratuberculosis in milk

The effectiveness of pasteurization and the concentration of Mycobacterium avium subsp. paratuberculosis in raw milk have been identified in quantitative risk analysis as the most critical factors influencing the potential presence of viable Mycobacterium paratuberculosis in dairy products. A quantitative assessment of the lethality of pasteurization was undertaken using an industrial pasteurizer designed for research purposes with a validated Reynolds number of 62,112 and flow rates of 3,000 liters/h. M. paratuberculosis was artificially added to raw whole milk, which was then homogenized, pasteurized, and cultured, using a sensitive technique capable of detecting one organism per 10 ml of milk. Twenty batches of milk containing 10(3) to 10(4) organisms/ml were processed with combinations of three temperatures of 72, 75, and 78 degrees C and three time intervals of 15, 20, and 25 s. Thirty 50-ml milk samples from each processed batch were cultured, and the logarithmic reduction in M. paratuberculosis organisms was determined. In 17 of the 20 runs, no viable M. paratuberculosis organisms were detected, which represented > 6-log10 reductions during pasteurization. These experiments were conducted with very heavily artificially contaminated milk to facilitate the measurement of the logarithmic reduction. In three of the 20 runs of milk, pasteurized at 72 degrees C for 15 s, 75 degrees C for 25 s, and 78 degrees C for 15 s, a few viable organisms (0.002 to 0.004 CFU/ml) were detected. Pasteurization at all temperatures and holding times was found to be very effective in killing M. paratuberculosis, resulting in a reduction of > 6 log10 in 85% of runs and > 4 log10 in 14% of runs.     

Effect of high-temperature, short-time (HTST) pasteurization on milk containing low numbers of Mycobacterium paratuberculosis

The efficacy of high-temperature, short-time (HTST) pasteurization (72 °C/15 s) when low numbers (≤ 10³ cfu ml ⁻¹ ) of Mycobacterium paratuberculosis are present in milk was investigated. Raw cows' milk spiked with Myco. paratuberculosis (10³ cfu ml⁻¹, 10² cfu ml⁻¹, 10 cfu ml⁻¹, and 10 cfu 50 ml⁻¹) was subjected to HTST pasteurization using laboratory pasteurizing units. Ten bovine strains of Myco. paratuberculosis were tested in triplicate. Culture in BACTEC Middlebrook 12B radiometric medium detected acid-fast survivors in 14·8% and 10% of HTST-pasteurized milk samples at the 10³ and 10² cfu ml⁻¹ inoculum levels, respectively, whereas conventional culture on Herrold's egg yolk medium containing mycobactin J detected acid-fast survivors in only 3·7% and 6·7% of the same milk samples. IS900-based PCR confirmed that these acid-fast survivors were Myco. paratuberculosis . No viable Myco. paratuberculosis were isolated from HTST-pasteurized milk initially containing either 10 cfu ml⁻¹ or 10 cfu 50 ml⁻¹.     

Mycobacterium avium subspecies paratuberculosis cultured from locally and commercially pasteurized cow's milk in the Czech Republic

Between November 2002 and April 2003, 244 bottles and cartons of commercially pasteurized cow's milk were obtained at random from retail outlets throughout the Czech Republic. During the same period, samples of raw milk and of milk that was subsequently subjected to a minimum of 71.7 degrees C for 15 s in a local pasteurization unit were also obtained from two dairy herds, designated herds A and B, with low and high levels, respectively, of subclinical Mycobacterium avium subsp. paratuberculosis infection, and from one herd, herd C, without infection. Infection in individual cows in each herd was tested by fecal culturing. Milk samples were brought to the Veterinary Research Institute in Brno, Czech Republic, processed, inoculated onto Herrold's egg yolk slants, and incubated for 32 weeks. Colonies were characterized by morphology, Ziehl-Neelsen staining, mycobactin J dependency, and IS900 PCR results. M. avium subsp. paratuberculosis was cultured from 4 of 244 units (1.6%) of commercially pasteurized retail milk. M. avium subsp. paratuberculosis was also cultured from 2 of 100 (2%) cartons of locally pasteurized milk derived from infected herds A and B and from 0 of 100 cartons of milk from uninfected herd C. Raw milk from 1 of 10 (10%) fecal culture-positive cows in herd A and from 13 of 66 (19.7%) fecal culture-positive cows in herd B was culture positive for M. avium subsp. paratuberculosis. These findings confirm that M. avium subsp. paratuberculosis is present in raw milk from subclinically infected dairy cows. The culture of M. avium subsp. paratuberculosis in the Czech Republic from retail milk that had been pasteurized locally or commercially to the required national and European Union standards is in agreement with similar research on milk destined for consumers in the United Kingdom and the United States and shows that humans are being exposed to this chronic enteric pathogen by this route.     

Persistence of Mycobacterium paratuberculosis during manufacture and ripening of cheddar cheese

Model Cheddar cheeses were prepared from pasteurized milk artificially contaminated with high 10(4) to 10(5) CFU/ml) and low (10(1) to 10(2) CFU/ml) inocula of three different Mycobacterium paratuberculosis strains. A reference strain, NCTC 8578, and two strains (806PSS and 796PSS) previously isolated from pasteurized milk for retail sale were investigated in this study. The manufactured Cheddar cheeses were similar in pH, salt, moisture, and fat composition to commercial Cheddar. The survival of M. paratuberculosis cells was monitored over a 27-week ripening period by plating homogenized cheese samples onto HEYM agar medium supplemented with the antibiotics vancomycin, amphotericin B, and nalidixic acid without a decontamination step. A concentration effect was observed in M. paratuberculosis numbers between the inoculated milk and the 1-day old cheeses for each strain. For all manufactured cheeses, a slow gradual decrease in M. paratuberculosis CFU in cheese was observed over the ripening period. In all cases where high levels (>3.6 log(10)) of M. paratuberculosis were present in 1-day cheeses, the organism was culturable after the 27-week ripening period. The D values calculated for strains 806PSS, 796PSS, and NCTC 8578 were 107, 96, and 90 days, respectively. At low levels of contamination, M. paratuberculosis was only culturable from 27-week-old cheese spiked with strain 806PSS. M. paratuberculosis was recovered from the whey fraction in 10 of the 12 manufactured cheeses. Up to 4% of the initial M. paratuberculosis load was recovered in the culture-positive whey fractions at either the high or low initial inoculum.     

Effect of commercial-scale high-temperature, short-time pasteurization on the viability of Mycobacterium paratuberculosis in naturally infected cows' milk

Raw cows' milk naturally infected with Mycobacterium paratuberculosis was pasteurized with an APV HXP commercial-scale pasteurizer (capacity 2,000 liters/h) on 12 separate occasions. On each processing occasion, milk was subjected to four different pasteurization treatments, viz., 73 degrees C for 15 s or 25 s with and without prior homogenization (2,500 lb/in(2) in two stages), in an APV Manton Gaulin KF6 homogenizer. Raw and pasteurized milk samples were tested for M. paratuberculosis by immunomagnetic separation (IMS)-PCR (to detect the presence of bacteria) and culture after decontamination with 0.75% (wt/vol) cetylpyridinium chloride for 5 h (to confirm bacterial viability). On 10 of the 12 processing occasions, M. paratuberculosis was detectable by IMS-PCR, culture, or both in either raw or pasteurized milk. Overall, viable M. paratuberculosis was cultured from 4 (6.7%) of 60 raw and 10 (6.9%) of 144 pasteurized milk samples. On one processing day, in particular, M. paratuberculosis appeared to have been present in greater abundance in the source raw milk (evidenced by more culture positives and stronger PCR signals), and on this occasion, surviving M. paratuberculosis bacteria were isolated from milk processed by all four heat treatments, i.e., 73 degrees C for 15 and 25 s with and without prior homogenization. On one other occasion, surviving M. paratuberculosis bacteria were isolated from an unhomogenized milk sample that had been heat treated at 73 degrees C for 25 s. Results suggested that homogenization increases the lethality of subsequent heat treatment to some extent with respect to M. paratuberculosis, but the extended 25-s holding time at 73 degrees C was found to be no more effective at killing M. paratuberculosis than the standard 15-s holding time. This study provides clear evidence that M. paratuberculosis bacteria in naturally infected milk are capable of surviving commercial high-temperature, short-time pasteurization if they are present in raw milk in sufficient numbers.     

Inactivation of Mycobacterium paratuberculosis by pulsed electric fields

The influence of treatment temperature and pulsed electric fields (PEF) on the viability of Mycobacterium paratuberculosis cells suspended in 0.1% (wt/vol) peptone water and in sterilized cow's milk was assessed by direct viable counts and by transmission electron microscopy (TEM). PEF treatment at 50 degrees C (2,500 pulses at 30 kV/cm) reduced the level of viable M. paratuberculosis cells by approximately 5.3 and 5.9 log(10) CFU/ml in 0.1% peptone water and in cow's milk, respectively, while PEF treatment of M. paratuberculosis at lower temperatures resulted in less lethality. Heating alone at 50 degrees C for 25 min or at 72 degrees C for 25 s (extended high-temperature, short-time pasteurization) resulted in reductions of M. paratuberculosis of approximately 0.01 and 2.4 log(10) CFU/ml, respectively. TEM studies revealed that exposure to PEF treatment resulted in substantial damage at the cellular level to M. paratuberculosis.     

Effective heat inactivation of Mycobacterium avium subsp. paratuberculosis in raw milk contaminated with naturally infected feces

The effectiveness of high-temperature, short holding time (HTST) pasteurization and homogenization with respect to inactivation of Mycobacterium avium subsp. paratuberculosis was evaluated quantitatively. This allowed a detailed determination of inactivation kinetics. High concentrations of feces from cows with clinical symptoms of Johne's disease were used to contaminate raw milk in order to realistically mimic possible incidents most closely. Final M. avium subsp. paratuberculosis concentrations varying from 10(2) to 3.5 x 10(5) cells per ml raw milk were used. Heat treatments including industrial HTST were simulated on a pilot scale with 22 different time-temperature combinations, including 60 to 90 degrees C at holding (mean residence) times of 6 to 15 s. Following 72 degrees C and a holding time of 6 s, 70 degrees C for 10 and 15 s, or under more stringent conditions, no viable M. avium subsp. paratuberculosis cells were recovered, resulting in >4.2- to >7.1-fold reductions, depending on the original inoculum concentrations. Inactivation kinetic modeling of 69 quantitative data points yielded an E(a) of 305,635 J/mol and an lnk(0) of 107.2, corresponding to a D value of 1.2 s at 72 degrees C and a Z value of 7.7 degrees C. Homogenization did not significantly affect the inactivation. The conclusion can be drawn that HTST pasteurization conditions equal to 15 s at > or =72 degrees C result in a more-than-sevenfold reduction of M. avium subsp. paratuberculosis.     

Surveillance of bulk raw and commercially pasteurized cows' milk from approved Irish liquid-milk pasteurization plants to determine the incidence of Mycobacterium paratuberculosis

Over the 13-month period from October 2000 to November 2001 (inclusive), the Food Safety Authority of Ireland (FSAI) carried out surveillance of Irish bulk raw (n = 389) and commercially pasteurized (n = 357) liquid-milk supplies to determine the incidence of Mycobacterium paratuberculosis. The pasteurization time-temperature conditions were recorded for all pasteurized samples. Overall, 56% of whole-milk pasteurized samples had been heat treated at or above a time-temperature combination of 75 degrees C for 25 s. All analyses were undertaken at the Department of Food Science (Food Microbiology) laboratory at Queen's University Belfast. Each milk sample was subjected to two tests for M. paratuberculosis: immunomagnetic separation-PCR (IMS-PCR; to detect the presence of M. paratuberculosis cells, live or dead) and chemical decontamination and culture (to confirm the presence of viable M. paratuberculosis). Overall, M. paratuberculosis DNA was detected by IMS-PCR in 50 (12.9%; 95% confidence interval, 9.9 to 16.5%) raw-milk samples and 35 (9.8%; 95% confidence interval, 7.1 to 13.3%) pasteurized-milk samples. Confirmed M. paratuberculosis was cultured from one raw-milk sample and no pasteurized-milk samples. It is concluded that M. paratuberculosis DNA is occasionally present at low levels in both raw and commercially pasteurized cows' milk. However, since no viable M. paratuberculosis was isolated from commercially pasteurized cows' milk on retail sale in the Republic of Ireland, current pasteurization procedures are considered to be effective.     

Incidence of Mycobacterium paratuberculosis in bulk raw and commercially pasteurized cows' milk from approved dairy processing establishments in the United Kingdom

Over a 17-month period (March 1999 to July 2000), a total of 814 cows' milk samples, 244 bulk raw and 567 commercially pasteurized (228 whole, 179 semi-skim, and 160 skim), from 241 approved dairy processing establishments throughout the United Kingdom were tested for the presence of Mycobacterium paratuberculosis by immunomagnetic PCR (to detect all cells living and dead) and culture (to detect viable cells). Overall, M. paratuberculosis DNA was detected by immunomagnetic PCR in 19 (7.8%; 95% confidence interval, 4.3 to 10.8%) and 67 (11.8%; 95% confidence interval, 9.0 to 14.2%) of the raw and pasteurized milk samples, respectively. Confirmed M. paratuberculosis isolates were cultured from 4 (1.6%; 95% confidence interval, 0.04 to 3.1%) and 10 (1.8%; 95% confidence interval, 0.7 to 2.8%) of the raw and pasteurized milk samples, respectively, following chemical decontamination with 0.75% (wt/vol) cetylpyridinium chloride for 5 h. The 10 culture-positive pasteurized milk samples were from just 8 (3.3%) of the 241 dairy processing establishments that participated in the survey. Seven of the culture-positive pasteurized milk samples had been heat treated at 72 to 74 degrees C for 15 s; the remainder had been treated at 72 to 75 degrees C for the extended holding time of 25 s. When typed by restriction fragment length polymorphism and pulsed-field gel electrophoresis methods, some of the milk isolates were shown to be types distinct from those of laboratory strains in regular use within the testing laboratory. From information gathered at the time of milk sample collection, all indications were that pasteurization had been carried out effectively at all of the culture-positive dairies. That is, pasteurization time and temperature conditions complied with the legal minimum high-temperature, short-time process; all pasteurized milk samples tested phosphatase negative; and post-process contamination was considered unlikely to have occurred. It was concluded that viable M. paratuberculosis is occasionally present at low levels in commercially pasteurized cows' milk in the United Kingdom.     

Effect of chemical decontamination and refrigerated storage on the isolation of Mycobacterium avium subsp. paratuberculosis from heat-treated milk

AIMS: To assess the impact of chemical decontamination and refrigerated storage before culture on the recovery of Mycobacterium avium subsp. paratuberculosis from heat-treated milk. METHODS AND RESULTS: Five-millilitre samples of ultra heat-treated (UHT) milk spiked with Myco. paratuberculosis NCTC 8578, B4 or 806R (ca 10(6) CFU ml(-1)) were heated at 63 degrees C for 20 or 30 min by submersion in a water bath. Heat-treated milk (0.5 ml) was cultured immediately into BACTEC 12B medium or refrigerated at 4 degrees C for 48 h before culture. Milk samples that received a 20-min heat treatment were also subjected to decontamination with 0.75% cetylpyridinium chloride (CPC) for 5 h at room temperature before inoculation into BACTEC 12B medium when tested immediately and after 48 h at 4 degrees C. BACTEC vials were monitored for evidence of growth over an 18-week incubation period at 37 degrees C. CPC decontamination resulted in a significant reduction in the number of culture-positive milk samples recovered immediately after heating (P < 0.05) and after refrigerated storage for 48 h (P < 0.01). Refrigerated storage for 48 h before testing did not have any significant effect, beneficial or detrimental, on Myco. paratuberculosis recovery rates. CONCLUSIONS: CPC decontamination applied to milk immediately or 48 h after heating will adversely affect the recovery of viable Myco. paratuberculosis, possibly leading to nonrecovery of the organism although viable cells are present in the original milk sample. SIGNIFICANCE AND IMPACT OF THE STUDY: Published pasteurization studies in which milk samples were decontaminated before culture will have underestimated the survival capability of Myco. paratuberculosis after high-temperature, short-time pasteurization. CPC decontamination should not be applied to pasteurized milk in future studies.     

Efficacy of Various Pasteurization Time-Temperature Conditions in Combination with Homogenization on Inactivation of Mycobacterium avium subsp. paratuberculosis in Milk

The effect of various pasteurization time-temperature conditions with and without homogenization on the viability of Mycobacterium avium subsp. paratuberculosis was investigated using a pilot-scale commercial high-temperature, short-time (HTST) pasteurizer and raw milk spiked with 10¹ to 10⁵ M. avium subsp. paratuberculosis cells/ml. Viable M. avium subsp. paratuberculosis was cultured from 27 (3.3%) of 816 pasteurized milk samples overall, 5 on Herrold's egg yolk medium and 22 by BACTEC culture. Therefore, in 96.7% of samples, M. avium subsp. paratuberculosis had been completely inactivated by HTST pasteurization, alone or in combination with homogenization. Heat treatments incorporating homogenization at 2,500 lb/in², applied upstream (as a separate process) or in hold (at the start of a holding section), resulted in significantly fewer culture-positive samples than pasteurization treatments without homogenization (P < 0.001 for those in hold and P < 0.05 for those upstream). Where colony counts were obtained, the number of surviving M. avium subsp. paratuberculosis cells was estimated to be 10 to 20 CFU/150 ml, and the reduction in numbers achieved by HTST pasteurization with or without homogenization was estimated to be 4.0 to 5.2 log₁₀. The impact of homogenization on clump size distribution in M. avium subsp. paratuberculosis broth suspensions was subsequently assessed using a Mastersizer X spectrometer. These experiments demonstrated that large clumps of M. avium subsp. paratuberculosis cells were reduced to single-cell or “miniclump” status by homogenization at 2,500 lb/in². Consequently, when HTST pasteurization was being applied to homogenized milk, the M. avium subsp. paratuberculosis cells would have been present as predominantly declumped cells, which may possibly explain the greater inactivation achieved by the combination of pasteurization and homogenization.     

Effect of turbulent-flow pasteurization on survival of Mycobacterium avium subsp. paratuberculosis added to raw milk

A pilot-scale pasteurizer operating under validated turbulent flow (Reynolds number, 11,050) was used to study the heat sensitivity of Mycobacterium avium subsp. paratuberculosis added to raw milk. The ATCC 19698 type strain, ATCC 43015 (Linda, human isolate), and three bovine isolates were heated in raw whole milk for 15 s at 63, 66, 69, and 72 degrees C in duplicate trials. No strains survived at 72 degrees C for 15 s; and only one strain survived at 69 degrees C. Means of pooled D values (decimal reduction times) at 63 and 66 degrees C were 15.0 +/- 2.8 s (95% confidence interval) and 5.9 +/- 0.7 s (95% confidence interval), respectively. The mean extrapolated D72 degrees C was <2.03 s. This was equivalent to a >7 log10 kill at 72 degrees C for 15 s (95% confidence interval). The mean Z value (degrees required for the decimal reduction time to traverse one log cycle) was 8.6 degrees C. These five strains showed similar survival whether recovery was on Herrold's egg yolk medium containing mycobactin or by a radiometric culture method (BACTEC). Milk was inoculated with fresh fecal material from a high-level fecal shedder with clinical Johne's disease. After heating at 72 degrees C for 15 s, the minimum M. avium subsp. paratuberculosis kill was >4 log10. Properly maintained and operated equipment should ensure the absence of viable M. avium subsp. paratuberculosis in retail milk and other pasteurized dairy products. An additional safeguard is the widespread commercial practice of pasteurizing 1.5 to 2 degrees above 72 degrees C.     

Comparison of four different culture media for isolation and growth of type II and type I/III Mycobacterium avium subsp. paratuberculosis strains isolated from cattle and goats

Culture is considered the definitive technique for Johne's disease diagnosis, and it is essential for later applications of certain molecular typing techniques. In this study, we have tested four solid media (Herrold's egg yolk medium [HEYM] with sodium pyruvate and mycobactin [HEYMm-SP], HEYM with mycobactin and without sodium pyruvate [HEYMm], Middlebrook 7H11 with mycobactin [Mm], and L?wenstein-Jensen with mycobactin [LJm]) for isolation of Mycobacterium avium subsp. paratuberculosis strains in 319 tissue samples from cattle herds and goat flocks. We have shown that each of the two main groups of M. avium subsp. paratuberculosis (type II and type I/III) has different requirements for growth in the culture media studied. The recommended solid media for isolation of type I/III strains are LJm and Mm, since the combination of both media allowed the recovery of all these strains. The most widespread culture medium, HEYM, is not suitable for the isolation of this group of M. avium subsp. paratuberculosis strains. Regarding the type II strains, HEYMm-SP was the medium where more strains were isolated, but the other three media are also needed in order to recover all type II strains. The incubation period is also related to the strain type. In conclusion, because the type of strain cannot be known in advance of culture, coupled with the fact that cattle and goats can be infected with both groups of strains, we recommend the use of the four solid media and the prolongation of the incubation period to more than 6 months to detect paratuberculous herds/flocks and to determine the true prevalence of the infection.     

Effect of high pressure and pasteurization on Mycobacterium avium ssp. paratuberculosis in milk

AIMS: To determine the effect of high pressures alone and in conjunction with pasteurization on the viability of two strains of Mycobacterium avium ssp. paratuberculosis (Map). METHODS AND RESULTS: Map in a milk matrix was subjected to 400, 500 and 600 MPa with and without pasteurization (72 degrees C for 15 s) and plated onto Herrold's egg yolk medium (HEYM) and Middlebrook 7H10 (7H10) agar, both containing antibiotic supplements. Medium 7H10 was found to give a significantly (P < 0.001) better recovery than HEYM. A significantly greater (P < 0.001) reduction in viable numbers was observed using 500 MPa (mean log reduction of 6.52) compared with 400 MPa (mean log reduction of 2.56) and between 400 MPa and control (no applied pressure) for 10 min treatments. A treatment time of 10 min resulted in significantly (P < 0.001) fewer survivors than 5 min. Low numbers of survivors were still detected when pressure treatment at 400 and 600 MPa was combined with subsequent pasteurization. CONCLUSIONS: The use of high-pressure was effective in reducing viable numbers of Map but even when combined with pasteurization there were still survivors, albeit when high inoculum levels of Map were used. SIGNIFICANCE AND IMPACT OF THE STUDY: To the authors' knowledge the work reported here represents the first study of the efficacy of high-pressure treatments alone and in combination with pasteurization to kill Map. The results indicate that further research is warranted before more commercial-scale studies are commissioned.     

Heat inactivation of Mycobacterium paratuberculosis in raw milk: are current pasteurization conditions effective?

Currently, it is not known whether commercial pasteurization effectively kills Mycobacterium paratuberculosis in contaminated raw milk. Results from holder test tube experiments indicated that a residual population of viable bacteria remained after treatment at 65, 72, 74, or 76 degrees C for 0 to 30 min. Use of a laboratory-scale pasteurizer unit demonstrated that treatment of raw milk at 72 degrees C for 15 s effectively killed all M. paratuberculosis.     

Inducible gene expression by nonculturable bacteria in milk after pasteurization

The viability of bacteria in milk after heat treatments was assessed by using three different viability indicators: (i) CFU on plate count agar, (ii) de novo expression of a gfp reporter gene, and (iii) membrane integrity based on propidium iodide exclusion. In commercially available pasteurized milk, direct viable counts, based on dye exclusion, were significantly (P < 0.05) higher than viable cell counts determined from CFU, suggesting that a significant subpopulation of cells in pasteurized milk are viable but nonculturable. Heating milk at 63.5 degrees C for 30 min resulted in a >4-log-unit reduction in the number of CFU of Escherichia coli and Pseudomonas putida that were marked with lac-inducible gfp. However, the reduction in the number of gfp-expressing cells of both organisms under the same conditions was <2.5 log units. These results demonstrate that a substantial portion of cells rendered incapable of forming colonies by heat treatment are metabolically active and are able to transcribe and translate genes de novo.     

Thermal inactivation of several Mycobacterium spp. in milk by pasteurization

I.R. GRANT, H.J. BALL AND M.T. ROWE. 1996. The thermal inactivation of Mycobacterium avium, Myco. bovis, Myco. fortuitum, Myco. intracellulare and Myco. kansaii in milk at 63.5°C was investigated. Survivors were enumerated after heating for 0, 5, 10, 15, 20 and 30 min and thermal death curves were constructed for each species. Mycobacterium bovis and Myco. fortuitum were found to exhibit linear thermal death curves and neither species demonstrated any survival after heating at 63.5°C for 30 min (equivalent to holder pasteurization). In contrast, Myco. avium, Myco. intracellulare and Myco. kansassi yielded thermal death curves which exhibited significant 'tailing' and all three strains survived holder pasteurization.     

Mycobacterium avium Subspecies paratuberculosis Cultured from Locally and Commercially Pasteurized Cow's Milk in the Czech Republic

Between November 2002 and April 2003, 244 bottles and cartons of commercially pasteurized cow's milk were obtained at random from retail outlets throughout the Czech Republic. During the same period, samples of raw milk and of milk that was subsequently subjected to a minimum of 71.7°C for 15 s in a local pasteurization unit were also obtained from two dairy herds, designated herds A and B, with low and high levels, respectively, of subclinical Mycobacterium avium subsp. paratuberculosis infection, and from one herd, herd C, without infection. Infection in individual cows in each herd was tested by fecal culturing. Milk samples were brought to the Veterinary Research Institute in Brno, Czech Republic, processed, inoculated onto Herrold's egg yolk slants, and incubated for 32 weeks. Colonies were characterized by morphology, Ziehl-Neelsen staining, mycobactin J dependency, and IS900 PCR results. M. avium subsp. paratuberculosis was cultured from 4 of 244 units (1.6%) of commercially pasteurized retail milk. M. avium subsp. paratuberculosis was also cultured from 2 of 100 (2%) cartons of locally pasteurized milk derived from infected herds A and B and from 0 of 100 cartons of milk from uninfected herd C. Raw milk from 1 of 10 (10%) fecal culture-positive cows in herd A and from 13 of 66 (19.7%) fecal culture-positive cows in herd B was culture positive for M. avium subsp. paratuberculosis. These findings confirm that M. avium subsp. paratuberculosis is present in raw milk from subclinically infected dairy cows. The culture of M. avium subsp. paratuberculosis in the Czech Republic from retail milk that had been pasteurized locally or commercially to the required national and European Union standards is in agreement with similar research on milk destined for consumers in the United Kingdom and the United States and shows that humans are being exposed to this chronic enteric pathogen by this route.     

Inactivation of Bacillus anthracis spores by a combination of biocides and heating under high-temperature short-time pasteurization conditions

The milk supply is considered a primary route for a bioterrorism attack with Bacillus anthracis spores because typical high-temperature short-time (HTST) pasteurization conditions cannot inactivate spores. In the event of intentional contamination, an effective method to inactivate the spores in milk under HTST processing conditions is needed. This study was undertaken to identify combinations and concentrations of biocides that can inactivate B. anthracis spores at temperatures in the HTST range in less than 1 min. Hydrogen peroxide (HP), sodium hypochlorite (SH), and peroxyacetic acid (PA) were evaluated for their efficacy in inactivating spores of strains 7702, ANR-1, and 9131 in milk at 72, 80, and 85 degrees C using a sealed capillary tube technique. Strains ANR-1 and 9131 were more resistant to all of the biocide treatments than strain 7702. Addition of 1,260 ppm SH to milk reduced the number of viable spores of each strain by 6 log CFU/ml in less than 90 and 60 s at 72 and 80 degrees C, respectively. After neutralization, 1,260 ppm SH reduced the time necessary to inactivate 6 log CFU/ml (TTI6-log) at 80 degrees C to less than 20 s. Treatment of milk with 7,000 ppm HP resulted in a similar level of inactivation in 60 s. Combined treatment with 1,260 ppm SH and 1,800 ppm HP inactivated spores of all strains in less than 20 s at 80 degrees C. Mixing 15 ppm PA with milk containing 1,260 ppm SH resulted in TTI6-log of 25 and 12 s at 72 and 80 degrees C, respectively. TTI6-log of less than 20 s were also achieved at 80 degrees C by using two combinations of biocides: 250 ppm SH, 700 ppm HP, and 150 ppm PA; and 420 ppm SH (pH 7), 1,100 ppm HP, and 15 ppm PA. These results indicated that different combinations of biocides could consistently result in 6-log reductions in the number of B. anthracis spores in less than 1 min at temperatures in the HTST range. This information could be useful for developing more effective thermal treatment strategies which could be used in HTST milk plants to process contaminated milk for disposal and decontamination, as well as for potential protective measures.