Lignin peroxidase is involved in the biobleaching of manganese-less oxygen-delignified hardwood kraft pulp by white-rot fungi in the solid-fermentation system

Biobleaching of manganese-less oxygen-delignified hardwood kraft pulp (E-OKP) by the white-rot fungi Phanerochaete sordida YK-624 and P. chrysosporium was examined in the solid-state fermentation system. P. sordida YK-624 possessed a higher brightening activity than P. chrysosporium, increasing pulp brightness by 13.4 points after seven days of treatment. In these fermentation systems, lignin peroxidase (LiP) activity was detected as the principle ligninolytic enzyme, and manganese peroxidase and laccase activities were scarcely detected over the course of treatment of E-OKP by either fungus. Moreover, a linear relationship between brightness increase and cumulative LiP activity was observed under all tested culture conditions with P. sordida YK-624 and P. chrysosporium. These results indicated that LiP is involved in the brightening of E-OKP by both white-rot fungi.     

Mineralization of C-Ring-Labeled Synthetic Lignin Correlates with the Production of Lignin Peroxidase, not of Manganese Peroxidase or Laccase

Recently, Mn(II) has been shown to induce manganese peroxidases (MnPs) and repress lignin peroxidases (LiPs) in defined liquid cultures of several white rot organisms. The present work shows that laccase is also regulated by Mn(II). We therefore used Mn(II) to regulate production of LiP, MnP, and laccase activities while determining the effects of Mn(II) on mineralization of ring-labeled synthetic lignin. At a low Mn(II) level, Phanerochaete chrysosporium and Phlebia brevispora produced relatively high titers of LiPs but only low titers of MnPs. At a high Mn(II) level, MnP titers increased 12- to 20-fold, but LiPs were not detected in crude broths. P. brevispora formed much less LiP than P. chrysosporium, but it also produced laccase activity that increased more than sevenfold at the high Mn(II) level. The rates of synthetic lignin mineralization by these organisms were similar and were almost seven times higher at low than at high Mn(II). Increased synthetic lignin mineralization therefore correlated with increased LiP, not with increased MnP or laccase activities.     

Lignin Peroxidases, Manganese Peroxidases, and Other Ligninolytic Enzymes Produced by Phlebia radiata during Solid-State Fermentation of Wheat Straw

The white rot fungus Phlebia radiata 79 (ATCC 64658) produces lignin peroxidase (LiP), manganese peroxidase (MnP), glyoxal oxidase (GLOX), and laccase in the commonly used glucose low-nitrogen liquid medium. However, the enzymes which this fungus utilizes for selective removal of lignin during degradation of different lignocellulosic substrates have not been studied before. Multiple forms of LiP, MnP, GLOX, and laccase were purified from P. radiata culture extracts obtained after solid-state fermentation of wheat straw. However, the patterns of extracellular lignin-modifying enzymes studied were different from those of the enzymes usually found in liquid cultures of P. radiata. Three LiP isoforms were purified. The major LiP isoform from solid-state cultivation was LiP2. LiP3, which has usually been described as the major isoenzyme in liquid cultures, was not expressed during straw fermentation. New MnP isoforms have been detected in addition to the previously reported MnPs. GLOX was secreted in rather high amounts simultaneously with LiP during the first 2 weeks of growth. GLOX purified from P. radiata showed multiple forms, with pIs ranging from 4.0 to 4.6 and with a molecular mass of ca. 68 kDa.     

Extracellular oxidative enzyme production and PAH removal in soil by exploratory mycelium of white rot fungi

Selected strains of three species of white rot fungi, Pleurotus ostreatus, Phanerochaete chrysosporium and Trametes versicolor, were grown in sterilized soil from straw inocula. The respective colonization rates and mycelium density values decreased in the above mentioned order. Three- and four-ringed PAHs at 50 ppm inhibited growth of fungi in soil to some extent. The activities of fungal MnP and laccase (units per g dry weight of straw or soil), extracted with 50 mM succinate-lactate buffer (pH 4.5), were 5 to 20-fold higher in straw compared to soil. The enzyme activities per g dry soil in P. ostreatus and T. versicolor were similar, in contrast to P. chrysosporium, where they were extremely low. Compared to the aerated controls, P. ostreatus strains reduced the levels of anthracene, pyrene and phenanthrene by 81–87%, 84–93% and 41–64% within 2 months, respectively. During degradation of anthracene, all P. ostreatus strains accumulated anthraquinone. PAH removal rates in P. chrysosporium and T. versicolor soil cultures were much lower.     

Solid state fermentation of Achras zapota lignocellulose by Phanerochaete chrysosporium

The biological transformation of lignocellulose of Achras zapota by white rot fungi, Phanerochaete chrysosporium, in solid state fermentation (SSF) was studied for 28 days. The kinetic transformation of lignocellulose was monitored through the determination of acid soluble and acid insoluble lignin content, total organic carbon (TOC) and chemical oxygen demand (COD). The lignolytic enzymes, lignin peroxidase (LiP) and manganese peroxidase (MnP) were quantified on weekly intervals. The degradation of lignin and other structural moieties of A. zapota lignocellulose were confirmed by high performance liquid chromatography (HPLC), Fourier transform infrared spectroscopy (FTIR) and scanning electron microscopy (SEM). The degradation of lignin was increased after 7 days of fermentation with the release of water soluble and fermentable products. The LiP and MnP activities were increased in the first week of SSF and lignin degradation was also set to increase. This was accompanied with increase in COD by 94.6% and TOC by 80% and lignin content was decreased by 76%. The maximum activities of the enzymes LiP and MnP in extracellular fluid of SSF under nitrogen limitation, at pH 5.0, at temperature 37 degrees C and at 60% humidity were 2100 U/L and 1200 U/L.     

Growth, dye degradation and ligninolytic activity studies on Zimbabwean white rot fungi

White rot fungi were collected from Chirinda and Chimanimani hardwood forests in Zimbabwe and studied with respect to growth temperature optima and dye decolorization. Temperature optima were found to vary (between 25-37 degrees C) amongst the isolates. The isolates were screened for their ability to degrade the polymeric dyes; blue dextran and Poly R478 and the triphenylmethane dyes; cresol red, crystal violet and bromophenol blue. Semi-quantitative determination of the hydrolytic enzyme activities possessed by the white rot fungi was determined using the API ZYM system. Lignin peroxidase (LiP), manganese peroxidase (MnP) and laccase activities in the fungi were also determined. No LiP was detected in any of the isolates but all isolates showed manganese peroxidase and laccase activities. Time related decolorization studies and optimum pH determinations for Poly R478 degradation by the isolates were carried out in liquid cultures. The most significant rates of Poly R478 decolorization in liquid cultures were found with the following isolates: Trametes cingulata, Trametes versicolor, Trametes pocas, DSPM95 (a species to be identified), Datronia concentrica and Pycnoporus sanguineus.     

Manganese Peroxidase, Produced by Trametes versicolor during Pulp Bleaching, Demethylates and Delignifies Kraft Pulp

Previous work has shown that Trametes (Coriolus) versicolor bleaches kraft pulp brownstock with the concomitant release of methanol. In this work, the fungus is shown to produce both laccase and manganese peroxidase (MnP) but not lignin peroxidase during pulp bleaching. MnP production was enhanced by the presence of pulp and/or Mn(II) ions. The maximum level of secreted MnP was coincident with the maximum rate of fungal bleaching. Culture filtrates isolated from bleaching cultures produced Mn(II)- and hydrogen peroxide-dependent pulp demethylation and delignification. Laccase and MnP were separated by ion-exchange chromatography. Purified MnP alone produced most of the demethylation and delignification exhibited by the culture filtrates. On the basis of the methanol released and the total and phenolic methoxyl contents of the pulp, it appears that MnP shows a preference for the oxidation of phenolic lignin substructures. The extensive increase in brightness observed in the fungus-treated pulp was not found with MnP alone. Therefore, either the MnP effect must be optimized or other enzymes or compounds from the fungus are also required for brightening.     

Roles of Lignin Peroxidase and Manganese Peroxidase from Phanerochaete chrysosporium in the Decolorization of Olive Mill Wastewaters

The relative contributions of lignin peroxidase (LiP) and manganese peroxidase (MnP) to the decolorization of olive mill wastewaters (OMW) by Phanerochaete chrysosporium were investigated. A relatively low level (25%) of OMW decolorization was found with P. chrysosporium which was grown in a medium with a high Mn(II) concentration and in which a high level of MnP (0.65 (mu)M) was produced. In contrast, a high degree of OMW decolorization (more than 70%) was observed with P. chrysosporium which was grown in a medium with a low Mn(II) concentration but which resulted in a high level of LiP activity (0.3 (mu)M). In this culture medium, increasing the Mn(II) concentration resulted in decreased levels of OMW decolorization and LiP activity. Decolorization by reconstituted cultures of P. chrysosporium was found to be more enhanced by the addition of isolated LiP than by the addition of isolated MnP. The highest OMW decolorization levels were obtained at low initial chemical oxygen demands combined with high levels of extracellular LiP. These data, plus the positive effect of veratryl alcohol on OMW decolorization and LiP activity, indicate that culture conditions which yield high levels of LiP activity lead to high levels of OMW decolorization.     

Production of laccase, manganese peroxidase and lignin peroxidase by Brazilian marine-derived fungi

Marine-derived fungi are a potential for the search of new compounds with relevant features. Among these, the ligninolytic enzymes have potential applications in a large number of fields, including the environmental and industrial sectors. This is the work aimed to evaluate the enzymatic activities of three marine-derived fungi (Aspergillus sclerotiorum CBMAI 849, Cladosporium cladosporioides CBMAI 857 and Mucor racemosus CBMAI 847) under different carbon sources and salinity conditions by using statistical experimental design. MnP, LiP and laccase were detected when these fungi were cultured in malt extract, however when grown on basal medium containing glucose and wheat bran LiP was not detected and yet an increase in MnP and laccase was observed. Statistical analysis through surface responses was performed and results showed high values of MnP and laccase activities under 12.5% and 23% (w/v) salinity, highlighting the potential use of these fungi for industrial applications and in bioremediation of contaminated sites having high salt concentrations. The highest values for LiP (75376.34 UI L⁻¹), MnP (4484.30 IU L⁻¹) and laccase (898.15 UI L⁻¹) were obtained with the fungus M. racemosus CBMAI 847 and it is the first report concerning ligninolytic enzymes production by a zygomycete from this genus.     

Enzymes produced by <Emphasis Type="Italic">Ganoderma australe</Emphasis> growing on wood and in submerged cultures

Enzymes produced by Ganoderma australe in solid-state fermentation and submerged cultures were evaluated. Strain A464 produced laccase activity in liquid medium and in solid-state cultures containing Drimys winteri or Eucalyptus globulus wood chips, while MnP and LiP activities were not detected. On the other hand, strain A272 cultured for 75 days on E. globulus presented MnP activity of 719 IU/kg of wood. The suitability of D. winteri wood as a substrate enabling MnP production was checked with a well-documented MnP-producing basidiomycete, Ceriporiopsis subvermispora, which produced MnP activity of 327 IU/kg of wood in 9-day-old cultures. Data from two different G. australe strains (A272 and A464) indicated that MnP secretion depended on strain origin as well as on culture conditions.     

Ligninolytic Enzymes of the White Rot Basidiomycete Trametes trogii

The white rot fungus Trametes trogii strain BAFC 463 produced laccase, manganese peroxidase, lignin peroxidase and cellobiose dehydrogenase, as well as two hydrogen peroxide‐producing activities: glucose oxidizing activity and glyoxal oxidase. In high‐N (40 mM N) cultures, the titres of laccase, MnP and GLOX were 27 (6.55 U/ml), 45 (403.00 mU/ml)and 8 (32,14 mU/ml) fold higher, respectively, than those measured in an N‐limited medium. This is consistent with the fact that the ligninolytic system of T. trogii is expressed constitutively. Lower activities of all the enzymes tested were recorded upon decreasing the initial pH of the medium from 6.5 to 4.5. Adding veratryl alcohol improved GLOX production, while laccase activity was stimulated by tryptophan. Supplying Tween 80 strongly reduced the activity of both MnP and GLOX, but increased laccase production. The titre of MnP was affected by the concentration of Mn in the culture medium, the highest levels were obtained with 90 μM Mn (II). LiP activity, as CDH activity, were detected only in the mediumsupplemented with sawdust. In this medium, laccase production reached a maximum of 4.75 U/ml, MnP 747.60 mU/ml and GLOX 117.11 mU/ml. LiP, MnP and GLOX activities were co‐induced, attaining their highest levels at the beginning of secondary metabolism, but while MnP, laccase, GLOX and CDH activities were also present in the primary growth phase, LiP activity appears to beidiophasic. The simultaneous presence of high ligninolytic and hydrogen peroxide producing activities in this fungus makes it an attractive microorganism for future biotechnological applications.     

Rapid decolorization of azo dyes by crude manganese peroxidase from Schizophyllum sp. F17 in solid-state fermentation

The production of ligninolytic enzymes by the fungus Schizophyllum sp. F17 using a cost-effective medium comprised of agro-industrial residues in solid-state fermentation (SSF) was optimized. The maximum activities of the enzymes manganese peroxidase (MnP), laccase (Lac), and lignin peroxidases (LiP) were 1,200, 586, and 109 U/L, respectively, on day 5 of SSF. In vitro decolorization of three structurally different azo dyes by the extracellular enzymes was monitored to determine its decolorization capability. The results indicated that crude MnP, but not LiP and Lac, played a crucial role in the decolorization of azo dyes. After optimization of the dye decolorization system with crude MnP, the decolorization rates of Orange IV and Orange G, at an initial dye concentration of 50 mg/L, were enhanced to 76 and 57%, respectively, after 20 min of reaction at pH 4 and 35°C. However, only 8% decolorization of Congo red was observed. This enzymatic reaction system revealed a rapid decolorization of azo dyes with a low MnP activity of 24 U/L. Thus, this study could be the basis for the production and application of MnP on a larger scale using a low-cost substrate.     

Degradation of 4-chlorophenol by the white rot fungus Phanerochaete chrysosporium in free and immobilized cultures

4-Chlorophenol (4-CP) degradation was investigated by suspended and immobilized Phanerochaete chrysosporium conducted in static and agitated cultures. The best results were achieved when experiment was carried out in a rotating biological contactor instead of an Erlenmeyer flask, for both batch degradation and repeated batch degradation. The relative contribution of lignin peroxidase (LiP) versus manganese peroxidase (MnP) to the 4-CP degradation by P. chrysosporium was investigated. 4-CP degradation slightly increased and a high level of MnP (38 nKat ml(-1)) was produced when P. chrysosporium was grown at high Mnll concentration. High LiP production in the medium had no significant effect on 4-CP degradation. 4-CP degradation occurred when P. chrysosporium was grown in a medium that repressed LiP and MnP production. This result indicates that LiP and MnP are not directly involved in 4-CP degradation by P. chrysosporium.     

高效木质素降解菌的筛选及其对玉米秸秆的降解效果

本研究利用愈创木酚和苯胺蓝固体培养基对菌株进行初筛,利用形态学和分子生物学对筛选出的菌株进行鉴定,以黄孢原毛平革菌Phanerochaete chrysosporium CGMCC 5.0776为对照,利用其对玉米秸秆进行预处理并测定木质素和纤维素的降解率,测定筛选菌株在预处理玉米秸秆过程中漆酶、锰过氧化物酶（manganese peroxidase,MnP）和木质素过氧化物酶（lignin peroxidase,LiP）活性。结果表明:利用愈创木酚和苯胺蓝固体培养基,从16株白腐真菌菌株中筛选出2株具有较高漆酶或MnP活性的菌株,鉴定其为桦栓孔菌Trametes betulina (L.) Pilát（ZT-153）和亚黑管孔菌Bjerkandera fumosa (Pers.) P. Karst.（ZT-307）,测定T. betulina ZT-153和B. fumosa ZT-307对玉米秸秆酸不溶木质素降解效率分别为13.60%和21.87%,较对照P. chrysosporium CGMCC 5.0776高1.58%和9.85%,对纤维素的降解率较低,分别为4.10%和4.50%。2株菌株在预处理玉米秸秆过程中,T. betulina ZT-153表现出漆酶和MnP活性,B. fumosa ZT-307只表现出LiP活性。其中B. fumosa ZT-307对玉米秸秆酸不溶木质素的降解效率最高,在秸秆资源的综合利用方面具有较好的潜力和应用前景。     

Changes in oxidative enzyme activity during interspecific mycelial interactions involving the white-rot fungus Trametes versicolor

Interspecific fungal antagonism leads to biochemical changes in competing mycelia, including up-regulation of oxidative enzymes. Laccase, manganese peroxidase (MnP), manganese-repressed peroxidase (MRP) and lignin peroxidase (LiP) gene expression and enzyme activity were compared during agar interactions between Trametes versicolor and five other wood decay fungi resulting in a range of interaction outcomes from deadlock to replacement of one fungus by another. Increased laccase and Mn-oxidising activities were detected at all interaction zones, but there were few changes in activity in regions away from the interaction zone in T. versicolor mycelia compared to self-pairings. Whilst no LiP activity was detected in any pairing, low level LiP gene expression was detected. MnP activity was detected but not expression of MnP genes; instead, MRP could explain the observed activity. No relationship was found between extent of enzyme activity increase and interaction outcome. Similarities between patterns of gene expression and enzyme activity are discussed.     

Temperature affects the production,activity and stability of ligninolytic enzymes in<Emphasis Type="Italic">Pleurotus ostreatus</Emphasis> and<Emphasis Type="Italic">Trametes versicolor</Emphasis>

Enzyme activity was determined in cultures of Pleurotus ostreatus and Trametes versicolor with cellulose as a sole C source and high C/N ratio. The fungi were able to grow and produce laccase and Mn-peroxidase (MnP) at 5-35 degrees C, the highest production being recorded at 25-30 degrees C in P. ostreatus and at 35 degrees C in T. versicolor. Production of both enzymes at 10 degrees C accounted only for 4-20% of the maximum value. Temperature optima for enzyme activity were 50 and 55 degrees C for P. ostreatus and T. versicolor laccases, respectively, and 60 degrees C for MnP. Temperatures causing 50% loss of activity after 24 h were 32 and 47 degrees C for laccases and 36 and 30 degrees C for MnP from P. ostreatus and T. versicolor, respectively.     

Lignin-modifying enzymes of the white rot basidiomycete Ganoderma lucidum

Ganoderma lucidum, a white rot basidiomycete widely distributed worldwide, was studied for the production of the lignin-modifying enzymes laccase, manganese-dependent peroxidase (MnP), and lignin peroxidase (LiP). Laccase levels observed in high-nitrogen (HN; 24 mM N) shaken cultures were much greater than those seen in low-nitrogen (2.4 mM N), malt extract, or wood-grown cultures and those reported for most other white rot fungi to date. Laccase production was readily seen in cultures grown with pine or poplar (100-mesh-size ground wood) as the sole carbon and energy source. Cultures containing both pine and poplar showed 5- to 10-fold-higher levels of laccase than cultures containing pine or poplar alone. Since syringyl units are structural components important in poplar lignin and other hardwoods but much less so in pine lignin and other softwoods, pine cultures were supplemented with syringic acid, and this resulted in laccase levels comparable to those seen in pine-plus-poplar cultures. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis of concentrated extracellular culture fluid from HN cultures showed two laccase activity bands (M(r) of 40,000 and 66, 000), whereas isoelectric focusing revealed five major laccase activity bands with estimated pIs of 3.0, 4.25, 4.5, 4.8, and 5.1. Low levels of MnP activity ( approximately 100 U/liter) were detected in poplar-grown cultures but not in cultures grown with pine, with pine plus syringic acid, or in HN medium. No LiP activity was seen in any of the media tested; however, probing the genomic DNA with the LiP cDNA (CLG4) from the white rot fungus Phanerochaete chrysosporium showed distinct hybridization bands suggesting the presence of lip-like sequences in G. lucidum.     

Enhanced ligninolytic enzyme production and degrading capability of Phanerochaete chrysosporium and Trametes versicolor

Ligninolytic enzyme production by the white-rot fungi Phanerochaete chrysosporium and Trametes versicolor precultivated with different insoluble lignocellulosic materials (grape seeds, barley bran and wood shavings) was investigated. Cultures of Phanerochaete chrysosporium precultivated with grape seeds and barley bran showed maximum lignin peroxidase (LiP) and manganese-dependent peroxidase (MnP) activities (1000 and 1232 U/l, respectively). Trametes versicolor precultivated with the same lignocellulosic residues showed the maximum laccase activity (around 250 U/l). For both fungi, the ligninolytic activities were about two-fold higher than those attained in the control cultures. In vitro decolorization of the polymeric dye Poly R-478 by the extracellular liquid obtained in the above-mentioned cultures was monitored in order to determine the respective capabilities of laccase, LiP and MnP. It is noteworthy that the degrading capability of LiP when P. chrysosporium was precultivated with barley bran gave a percentage of Poly R-478 decolorization of about 80% in 100 s, whereas control cultures showed a lower percentage, around 20%, after 2 min of the decolorization reaction.     

Substrate specificity of lignin peroxidase and a S168W variant of manganese peroxidase

Lignin peroxidase (LiP) and manganese peroxidase (MnP) are structurally similar heme-containing enzymes secreted by white-rot fungi. Unlike MnP, which is only specific for Mn(2+), LiP has broad substrate specificity, but it is not known if this versatility is due to multiple substrate-binding sites. We report here that a S168W variant of MnP from Phanerochaete chrysosporium not only retained full Mn(2+) oxidase activity, but also, unlike native or recombinant MnP, oxidized a multitude of LiP substrates, including small molecule and polymeric substrates. The kinetics of oxidation of most nonpolymeric substrates by the MnP variant and LiP were similar. The stoichiometries for veratryl alcohol oxidation by these two enzymes were identical. Some readily oxidizable substrates, such as guaiacol and ferrocyanide, were oxidized by MnP S168W and LiP both specifically and nonspecifically while recombinant MnP oxidized these substrates only nonspecifically. The functional similarities between this MnP variant and LiP provide evidence for the broad substrate specificity of a single oxidation site near the surface tryptophan.     

A proposed role of oxalic acid in wood decay systems of wood-rotting basidiomycetes

Abstract: The possible roles of oxalic acid, veratryl alcohol, and manganese were investigated in relation to lignin biodegradation by white-rot basidiomycetes. Oxalate inhibited both lignin peroxidase (LiP) and manganese-peroxidase (MnP). and was decarboxylated by the mediation of veratryl alcohol and Mn. Oxalate was shown to regulate the mineralization of lignin in the in vivo system of Phanerochaete chrysosporium . In the brown-rot wood decay process, oxalic acid may serve as an acid catalyst as well as an electron donor for the Fenton reaction, to breakdown cellulose and hemicellulose. Oxaloacetase and glyoxylate oxidase may play a key role in production of oxalic acid by white-rot and brown-rot basidiomycetes such as Phanerochaete chrysosporium, Coriolus versicolor and Tyromyces palustris . A possible role of oxalate metabolism is discussed in relation to the physiology of wood-rotting fungi.