赤藓糖醇高产菌株的筛选、鉴定及发酵特性的初步研究

目的：筛选出发酵性能优良的赤藓糖醇高产菌株。方法：利用含50%葡萄糖的高渗培养基筛选出耐高渗酵母,采用薄层层析和高效液相色谱分析发酵液中多元醇的组成和含量,并通过形态和生理生化试验对菌株进行初步鉴定。结果：由泰山养蜂场上采集的蜂蜜、花粉、蜂巢里筛选出13株单产赤藓糖醇的野生菌,其中7株赤藓糖醇产量高于20g/L。菌株K-23经初步鉴定为球拟酵母属,在含20%葡萄糖、1%酵母膏、0.1%尿素的发酵培养基中培养144h后赤藓糖醇的浓度达46.8g/L,转化率达23.4%。结论：所获得的菌株K-23具有一定的赤藓糖醇生产能力,且具有产物单一的优良发酵性能,为该菌株的菌种改良奠定了基础。     

L-丝氨酸高产菌株的选育和摇瓶发酵条件优化

采用B revibacterium flavmC-11A为出发菌株,经紫外线照射和亚硝基胍诱变处理,选育出一株L-丝氨酸高产菌株C32为目的突变株,使摇瓶产酸率由12.1 g.L-1增加到16.4 g.L-1,然后对其进行摇瓶发酵条件优化,使菌株C32的L-丝氨酸产率提高到30.1 g.L-1。     

紫外诱变原生质体选育D-核糖生产菌株

以D-核糖产生菌枯草芽孢杆(Bacillus subtilis)B941为出发菌株,采用紫外诱变原生质体的方法,获得了4株可以在含有6．0％D-核糖的培养基上生长的D-核糖高产菌株,其摇瓶发酵产糖达55．0g／L左右。通过摇瓶发酵试验,研究了D-核糖高产菌株Buvp-24的遗传稳定性。研究结果表明,经多次传代,菌株Buvp-24的发酵产糖能力及对发酵产物D-核糖的耐受性没有改变,有望应用于工业生产中。     

L-缬氨酸高产菌株的选育研究

以产L-缬氨酸的谷氨酸棒状杆菌(Corynebacterium glutamicum)为原始菌株,利用注入低能氮离子束进行一系列诱变,获得一株稳定的高产L-缬氨酸突变菌株。摇瓶培养96h后发酵能力可达38.0g·L-1,较出发菌株提高18.01%。通过对摇瓶中葡萄糖、玉米浆浓度及培养条件进行优化,发酵能力达到40.6g·L-1,50L发酵罐的发酵能力可达70g·L-1左右。     

发酵产泡性能降低的解脂耶氏酵母菌株的获得及其评价

微生物发酵过程中泡沫的产生是发酵领域遇到的共性问题。在不影响发酵性能的前提下抑制菌株的产泡,对简化操作以及降低发酵成本具有较为重要的意义。解脂耶氏酵母(Yarrowia lipolytica,之前称为Candida lipolytica)是一种常用的合成生物学底盘,也是合成赤藓糖醇等功能糖醇的生产菌株。但在发酵合成赤藓糖醇的过程中会产生大量的泡沫,需要添加消泡剂以消除泡沫。【目的】本研究旨在开发一种产泡能力显著降低的解脂耶氏酵母新菌株,以减少赤藓糖醇发酵过程中消泡剂的添加。【方法】本研究利用解脂耶氏酵母中非同源靶向重组占支配地位的原理,采用一段外源DNA随机插入基因组的手段,随机突变基因组,改变菌株的发酵产泡性能,使突变株在发酵过程中不产泡或者降低其产泡的能力。【结果】通过筛选,获得一株在发酵过程中产泡性能显著降低的工程菌株,该菌株在保留高效合成赤藓糖醇性能的同时,显著降低了泡沫的产生。【结论】所获得的菌株对工业发酵合成赤藓糖醇具有较为重要的意义,也为控制其他微生物发酵过程中泡沫的生成提供了思路。     

玉米原料高产γ-聚谷氨酸优良菌株的选育及发酵条件优化

以实验室筛选到的一株枯草芽孢杆菌（Bacillus subtilis）B-1为出发菌株,采用紫外诱变技术对出发菌株进行反复诱变,得到一株能够利用玉米原料生产γ-聚谷氨酸的优良高产菌株B-115,摇瓶发酵γ-聚谷氨酸的产量由原菌株的12.5g/L提高到19.5g/L。再以该菌株为研究对象利用响应面法进行碳源、氮源、谷氨酸钠、金属离子等发酵条件的优化实验,经48h摇瓶发酵,γ-聚谷氨酸产量达到40.98g/ L。     

L-谷氨酰胺高产菌的选育和发酵条件

以嗜乙酰乙酸棒杆菌(Corynebacterium acetoacidophilum)LG-3为出发菌株,经紫外线(UV)和硫酸二乙酯(DES)诱变处理,磺胺胍(SG)、高浓度(NH4)2SO4定向筛选,获得1株谷氨酰胺高产菌株LG-65,在未经优化的条件下摇瓶发酵72 h可产谷氨酰胺43.5 g/L,比出发菌株的产量32.4 g/L提高了34.3%.在此基础上,对其发酵条件进行优化,经72 h摇瓶发酵产量可达47～48 g/L,7 L发酵罐补料分批发酵40 h可达55 g/L.     

耐高渗产赤藓糖醇酵母的诱变筛选与鉴定

使用含碘乙酸的固体平板培养基对自然界中富含高浓度糖分的含菌样品进行筛选,获得一株产赤藓糖醇的菌株,再运用紫外线、氯化锂和硫酸二乙酯(DES)对出发菌株进行诱变育种,利用纸层析、高碘酸氧化法和高效液相色谱(HPLC)进行定性、定量分析赤藓糖醇,最终获得一株能够高产赤藓糖醇的耐高渗菌株JunA-27.对该菌株的细胞形态进行了扫描电子显微镜(SEM)观察,提取了菌株的DNA并对18S rDNA进行PCR扩增、测序和DNA序列同源性比对,确定该菌株与Yarrowia lipolytica相似性最高,并将其命名为Yarrowia lipolytica WX 506.     

丛梗孢酵母发酵产赤藓糖醇的响应面优化

为了提高丛梗孢酵母发酵产赤藓糖醇的产量,在前期单因素实验结果的基础上,利用Plackett-Burman实验设计对影响其产赤藓糖醇的发酵条件进行评估并筛选出了影响显著的3个因素:葡萄糖、初始pH和温度.采用响应面法进行实验方案设计,利用SAS软件对其结果进行二次回归分析,确定了优化后的发酵条件为:葡萄糖260g/L、酵...     

1,3-丙二醇产生菌的诱变育种及培养基优化

以实验室自然筛选的克雷伯氏杆菌(Klebsiella sp.)为出发株,采用紫外诱变及亚硝基胍和超声波协同处理获得一株1,3-丙二醇高产突变株。在摇瓶发酵中,其产1,3-丙二醇产量由17.39 g/L提高到24.11 g/L,提高38.64%。变异株经10次传代培养,发酵能力稳定。对发酵培养基成分进行了优化,优化后1,3-丙二醇产量为30.05g/L,为优化前的1.25倍。     

Production of erythritol from glucose by an osmophilic mutant of Candida magnoliae

Candida magnoliae and its mutants were analyzed to produce erythritol from glucose with high yield and productivity. One mutant, M2, showed higher erythritol conversion yield and productivity than the wild strain. The osmophilic mutant produced 25 g erythritol l^–1 after 83 h of a flask culture in a medium containing 10% (w/v) glucose, corresponding to a 25% increase in erythritol and a 30% increase in erythritol productivity compared with the wild type. The fermentation properties were further improved by cultivating the osmophilic mutant in a fermenter containing 20% (w/v) glucose medium with 0.54 g l^–1 h^–1 of erythritol productivity and 43% of erythritol conversion yield based on glucose.     

液蜡发酵制取混合二元酸的研究

A mutant of Candida tropicalis FYD-2 was obtained from its parental strain SFP-1186 by ultraviolet treatments.On shaking flask,the yield of mixed dicarboxylic acid(DCA) by the mutant was 21.4% higher than that by its ancestor.The amount of mixed DCA reached 156g/L for 120h incubation in a 10 L autoconrolled fermentor where the culture medium contained 25% n-paraffin.The process of induced and screening mutant was introduced and the time course of fermentation in 10 L fermentor was discussed.     

酿酒酵母突变株J-X25胞内合成GSH的研究

以筛选得高产谷胱甘肽(GSH)产生酵母甲硫氨酸缺陷型变株J-X25为试验菌株。对其培养条件进行研究,结果表明：发酵培养基的最适初始pH值为6.0、最佳发酵温度为30℃、最佳装液量为100ml/500ml、接种量10%、摇床转速为220r/min。在酵母细胞培养到对数期,加入过氧化氢刺激细胞发生应激反应和乳酸钠作为表面活性剂改变细胞通透性,GSH总量达到0.253g/L,比不添加两者情况下的GSH产量高出52％。结果表明优化培养条件后,J-X25胞内积累GSH比出发株提高79％。     

复合诱变被孢霉原生质体获高产γ-亚麻酸的研究

以拉曼被孢霉（Mortierella remanniana）为出发菌株M₅,通过原生质体制备,经亚硝酸和激光等进行复合诱变;进行初筛,经摇瓶发酵法复筛,并测定其相关性能指标,获得一生产性能比出发菌株显著提高的突变株M_?;其干菌体收率为46.8g/L、油脂产率达34.6g/L、γ-亚麻酸的产率达12.5g/L,分别是出发菌株的1.73倍、2.02倍和2.6倍。通过基因传代实验,说明突变株的基因可稳定遗传。     

Optimized conditions for high erythritol production by<Emphasis Type="Italic">Penicillium</Emphasis> sp. KJ-UV29, mutant of<Emphasis Type="Italic">Penicillium</Emphasis> sp. KJ81

To improve the erythritol productivity ofPenicillium sp. KJ81, mutants were obtained using UV irradiation and NTG treatment. Among these mutants,Penicillium sp. KJ-UV29 revealed no morphological changes, yet was superior to the wild strain in the following three points: (1)Penicillium sp. KJ-UV29 produced more erythritol than the wild strain under the same conditions, (2) no foam was produced during cultivation, unlike the wild strain, and (3) the mutant produced a significantly lower amount of glycerol.Penicillium sp KJ-UV29 produced as much as 15.1 g/L of erythritol, whereas the wild-typePenicillium sp. KJ-UV29 produced as much as 15.1 g/L of erythritol, whereas the wild-typePenicillium sp. KJ81 only produced 11.7 g/L.Penicillium sp. KJ-UV29 only generated 6.1 g/L of glycerol, compared to 19.4 g/L produced by the wild strain. When investigating the optimal culture conditions for erythritol production by the mutant strainPenicillium sp. KJ-UV29, sucrose was idetified as the most effective carbon source, and the mutant was even able to produce erythritol in a 70% sucrose-containing medium, although a 30% sucrose medium exhibited the highest productivity. The production of erythritol byPenicillium sp. KJ-UV29 was also significantly increased by the addition of ammonium carbonate, potassium nitrate, and sodium nitrate. Accordingly, under optimal conditions,Penicillium sp. KJ-UV29 produced 45.2 g/L of erythritol in a medium containing 30% sucrose, 0.5% yeast extract, 0.5% (NH₄)₂C₂O₄ 0.1% NaNO₃, and 0.01% FeSO₄ with 1 vvm aeration and 200 rpm agitation at 37°C for 7 days in a 5-L jar fermentor.     

丙烯酸对十六碳二元酸发酵的影响和16L罐扩试

本文报道丙烯酸对发酵生产十六碳二元酸(DC_(16))的影响,加入0.1%丙烯酸,DC_(16)产量提高20—30%.在16L自动控制罐上,在最佳条件下,加入20%(v/v)正十六烷(nC_(16)),发酵5天,DC_(16)高达120g/L,nC_(16)的转化率高达79%.     

High-level production of erythritol by mutants of osmophilic Moniliella sp.

An erythritol-producing osmophilic yeast-like fungus, Moniliella sp. 440, was isolated from honey and then successively mutated with iterative rounds of N-methyl-N′-nitro-N-nitrosoguanidine (NTG) treatment and selection. Six generations of mutants, named N12115-6, N21105-6, N31074-3, N42208-2, N53199-9, and N61188-12, were selected for and produced erythritol at 151.0, 157.2, 177.8, 191.4, 196.6, and 237.8 g/L, respectively, while the wild type strain produced 113.0 g/L erythritol in media containing 40% glucose and 1% yeast extract. The mutant cells were found to have a short rod-like shape, while the wild type cells have a long rod-like shape. The most efficient erythritol producer, N61188-12, assimilated myo-inositol and weakly assimilated erythritol. However, the wild type strain did not assimilate myo-inositol and assimilated erythritol well. In 250-L and 2000-L pilot-scale fermentors, the erythritol production by N61188-12 was 151.4 g/L and 152.4 g/L, respectively. A simple fed-batch culture of strain N61188-12 in a 2000-L fermentor increased erythritol production to 189.4 g/L after 10 days fermentation.     

麦芽糖诱导软化芽孢杆菌α-环糊精葡萄糖基转移酶在枯草杆菌中的表达

通过PCR扩增软化芽孢杆菌α-环糊精葡萄糖基转移酶基因,将基因片段克隆到大肠杆菌-枯草杆菌穿梭载体pGJ103中,转化枯草杆菌WB600得基因工程菌进行外源表达。在1.5%的麦芽糖初始发酵培养基上摇瓶培养,48 h后重组枯草杆菌产酶活性为6.1U/ml。通过单因素分析和响应面分析对重组枯草杆菌产CGT酶摇瓶发酵条件进行优化。分析得到培养基关键组分麦芽糖,玉米淀粉和酵母粉三者最佳浓度分别为:15.5g/L,13g/L和20g/L。在此条件下,摇瓶培养36h后α-CGT酶活性为17.6U/ml,5L罐分批发酵30h后酶活达到20U/ml (水解活性为1.4×10⁴ IU/ml)。