Production of l-rhamnulose,a rare sugar,from l-rhamnose using commercial immobilized glucose isomerase

Abstract

A commercial immobilized d-glucose isomerase from Streptomyces murines (Sweetzyme) was used to produce l-rhamnulose from l-rhamnose in a packed-bed reactor. The optimal conditions for l-rhamnulose production from l-rhamnose were determined as pH 8.0, 60?°C, 300?g L^?1 l-rhamnose as a substrate, and 0.6?h^?1 dilution rate. The half-life of the immobilized enzyme at 60?°C was 809?h. Under the optimal conditions, the immobilized enzyme produced an average of 135?g L^?1 l-rhamnulose from 300?g L^?1 l-rhamnose after 16 days at pH 8.0, 60?°C, and 0.6?h^?1 dilution rate, with a productivity of 81?g/L/h and a conversion yield of 45% in a packed-bed reactor.     

Phytoextraction of Ni,Pb and,Cd by duckweeds

Abstract

Heavy metals phytoextraction potential of swollen duckweed (Lemna gibba Linn.) and lesser duckweed (Lemna aequinoctialis Welw.) was determined under greenhouse conditions by exposing to untreated industrial/municipal effluent for a period of 21?days. The nickel (Ni), lead (Pb), and cadmium (Cd) concentrations in water samples were measured weekly and in plant biomass at the termination of experiments. Significant differences (p?<?0.05) between initial and final physicochemical parameters and in heavy metal concentrations of plant and water samples were observed. Periodically measured metal concentrations in mediums revealed that removal percentage was dependent on initial Ni (2.15?mg L^?1), Pb (1.51?mg L^?1), and Cd (0.74?mg L^?1) concentrations. The final metal removal percentages were in the sequence of Ni (97%) > Pb (94%) > Cd (90%) when treated with Lemna gibba L. as compared to control (9–12% reduction). High biomass production of Lemna gibba L. resulted in a large metal reduction in the growth medium and the total plant metal contents were in the sequence of Ni (427?µg) > Pb (293?µg) > Cd (105?µg). The lesser duckweed did not survive under experimental conditions. Based on these results, we concluded that Lemna gibba L. is a good candidate for phytoremediation of wastewater.     

Metabolic syndrome is associated to high-sensitivity cardiac troponin T elevation

Introduction: Metabolic syndrome (MetS) and high-sensitivity cardiac troponin T (hs-TnT) are associated with higher risk for cardiovascular diseases (CVD). Our aim was to assess the relation between hs-TnT elevation and MetS in a general population sample.

Materials and methods: Individuals participating in an annual health survey program between 2010 and 2016 were included in the study. Blood samples including hs-TnT levels were collected. The study population was divided into three groups based on hs-TnT levels – undetectable (<5?ng/L), intermediate (5–14?ng/L) and elevated (>14?ng/L).

Results: A total of 5994 subjects were included in the study, the mean age was 48.5 and 4336 (72%) were males. Compared with subjects with undetectable hs-TnT the prevalence of MetS was higher in those with detectable and elevated levels – 392 (10%) vs. 270 (15%) and 51 (33%), respectively (p?<?0.001). In a multivariate model adjusted for age, gender and multiple co-morbidities, the number of MetS components and presence of MetS were significantly associated with an increased risk for detectable hs-TnT levels (OR?=?1.02 {for each component}; 95% CI [1.00–1.05], p?=?0.04) and (OR?=?1.13; 95% CI [1.07–1.2], p?<?0.001) respectively. Only the waist, glucose and hypertension components of the MetS were significantly associated with elevated troponin.

Conclusions: The MetS and its distinct components have a cumulative impact on hs-TnT levels in apparently healthy subjects.     

Acceptor Specificity of Cyclodextrin Glycosyltransferase from Bacillus stearothermophilus and Synthesis of α-D-Glucosyl O-β-D-galactosyl-(1→4)-β-D-glucoside

Bacillus stearothermophilus CGTase had a wider acceptor specificity than Bacillus macerans CGTase did and produced large amounts of transfer products of various acceptors such as D-galactose, D-mannose, D-fructose, D- and L-arabinose, d- and L-fucose, L-rhamnose, D-glucosamine, and lactose, which were inefficient acceptors for B. macerans CGTase. The main component of the smallest transfer products of lactose was assumed to be α-D-glucosyl O-β-D-galactosyl-(l→4)-β-D-glucoside.     

Targeting the superoxide/nitric oxide ratio by L-arginine and SOD mimic in diabetic rat skin

Abstract

Setting the correct ratio of superoxide anion (O₂^?-) and nitric oxide (^?NO) radicals seems to be crucial in restoring disrupted redox signaling in diabetic skin and improvement of ^?NO physiological action for prevention and treatment of skin injuries in diabetes. In this study we examined the effects of L-arginine and manganese(II)-pentaazamacrocyclic superoxide dismutase (SOD) mimic – M40403 in diabetic rat skin. Following induction of diabetes by alloxan (blood glucose level ≥12?mMol l?^?1) non-diabetic and diabetic male Mill Hill hybrid hooded rats were divided into three subgroups: (i) control, and receiving: (ii) L-arginine, (iii) M40403. Treatment of diabetic animals started after diabetes induction and lasted for 7 days. Compared to control, lower cutaneous immuno-expression of endothelial NO synthase (eNOS), heme oxygenase 1 (HO1), manganese SOD (MnSOD) and glutathione peroxidase (GSH-Px), in parallel with increased NFE2-related factor 2 (Nrf2) and nitrotyrosine levels characterized diabetic skin. L-arginine and M40403 treatments normalized alloxan-induced increase in nitrotyrosine. This was accompanied by the improvement/restitution of eNOS and HO1 or MnSOD and GSH-Px protein expression levels in diabetic skin following L-arginine, i.e. SOD mimic treatments, respectively. The results indicate that L-arginine and M40403 stabilize redox balance in diabetic skin and suggest the underlying molecular mechanisms. Restitution of skin redox balance by L-arginine and M40403 may represent an effective strategy to ameliorate therapy of diabetic skin.     

Enzymatic Assay of d-Xylose Isomerase Activity

The d-xylose isomerase activity was assayed spectrophotometrically as NADH oxidation in a coupled reaction with the d-arabitol dehydrogenase. The assay system is based on the following reactions:

d-Arabitol dehydrogenase was purified from the d-sorbitol-grown cells of Agrobacterium tumefaciens. The standard assay condition is as follows: 5 μmoles of Tris-HCl buffer (pH 7.0), 0.2 μmole of MnCl₂, 2 μl of reduced glutathione (25 mg/ml), 0.05 μmole of NADH, 6 units of d-arabitol dehydrogenase, 5 μmoles of d-xylose and d-xylose isomerase in a total volume of 0.30 ml. The reaction was carried out at 30°C. With the assay system, it was confirmed that d-xylose isomerase did not produce d-xylulose from d-lyxose.     

Studies on d-Glucose-isomerizing Activity of d-Xylose-grown Cells from Bacillus coagulans,Strain HN-68

d-Glucose-isomerizing enzyme has been extracted in high yield from d-xylose-grown cells of Bacillus coagulans, strain HN-68, by treating with lysozyme, and purified approximately 60-fold by manganese sulfate treatment, fractionation with ammonium sulfate and chromatography on DEAE-Sephadex column. The purified d-glucose-isomerizing enzyme was homogeneous in polyacrylamide gel electrophoresis and ultracentrifugation and was free from d-glucose-6-phosphate isomerase. Optimum pH and temperature for activity were found to be pH 7.0 and 75°C, respectively. The enzyme required specifically Co⁺⁺ with suitable concentration for maximal activity being 10^?3 m. In the presence of Co⁺⁺, enzyme activity was inhibited strongly by Cu⁺⁺, Zn⁺⁺, Ni⁺⁺, Mn⁺⁺ or Ca⁺⁺. At reaction equilibrium, the ratio of d-fructose to d-glucose was approximately 1.0. The enzyme catalyzed the isomerization of d-glucose, d-xylose and d-ribose. Apparent Michaelis constants for d-glucose and d-xylose were 9×10^?2 m and 7.7×10^?2 m, respectively.     

Regulatory Properties of Prephenate Dehydrogenase and Prephenate Dehydratase from Corynebacterium glutamicum

Regulatory properties of the enzymes in l-tyrosine and l-phenyalanine terminal pathway in Corynebacterium glutamicum were investigated. Prephenate dehydrogenase was partially feedback inhibited by l-tyrosine. Prephenate dehydratase was strongly inhibited by l-phenylalanine and l-tryptophan and 100% inhibition was attained at the concentrations of 5 × 10^?2mm and 10^?1mm, respectively. l-Tyrosine stimulated prephenate dehydratase activity (6-fold stimulation at 1 mm) and restored the enzyme activity inhibited by l-phenylalanine or l-tryptophan. These regulations seem to give the balanced synthesis of l-tyrosine and l-phenyl-alanine. Prephenate dehydratase from C. glutamicum was stimulated by l-methionine and l-leucine similarly to the enzyme in Bacillus subtilis and moreover by l-isoleucine and l-histidine. C. glutamicum mutant No. 66, an l-phenylalanine producer resistant to p-fluorophenyl-alanine, had a prephenate dehydratase completely resistant to the inhibition by l-phenylalanine and l-tryptophan.     

Effects of a Feedback-Resistant Aspartokinase III Gene on L-Isoleucine Production in Escherichia coli K-12

An L-isoleucine-overproducing recombinant strain of E. coli, TVD5, was also found to overproduce L-valine. The L-isoleucine productivity of TVD5 was markedly decreased by addition of L-lysine to the medium. Introduction of a gene encoding feedback-resistant aspartokinase III increased L-isoleucine productivity and decreased L-valine by-production. The resulting strain accumulated 12 g/l L-isoleucine from 40 g/l glucose, and suppression of L-isoleucine productivity by L-lysine was relieved.     

Production of l-allose and d-talose from l-psicose and d-tagatose by l-ribose isomerase

l-ribose isomerase (L-RI) from Cellulomonas parahominis MB426 can convert l-psicose and d-tagatose to l-allose and d-talose, respectively. Partially purified recombinant L-RI from Escherichia coli JM109 was immobilized on DIAION HPA25L resin and then utilized to produce l-allose and d-talose. Conversion reaction was performed with the reaction mixture containing 10% l-psicose or d-tagatose and immobilized L-RI at 40 °C. At equilibrium state, the yield of l-allose and d-talose was 35.0% and 13.0%, respectively. Immobilized enzyme could convert l-psicose to l-allose without remarkable decrease in the enzyme activity over 7 times use and d-tagatose to d-talose over 37 times use. After separation and concentration, the mixture solution of l-allose and d-talose was concentrated up to 70% and crystallized by keeping at 4 °C. l-Allose and d-talose crystals were collected from the syrup by filtration. The final yield was 23.0% l-allose and 7.30% d-talose that were obtained from l-psicose and d-tagatose, respectively.     

Accumulation of S-Adenosylmethionine by Molds

Aspergillus tamani accumulated about 20 μmoles of S-adenosylmethionine (SAM) in 1 g of dry cells when cultured secondarily in a medium containing more than 10 mm of l- methionine. The accumulation was not so high when l-methionine was replaced by d- methionine. Addition of nucleic acid-related substances was not effective for the accumulation. Addition of d, l-ethionine in place of methionine caused accumulation of S-adenosylethionine (SAE) in place of SAM. Among 100 strains of molds tested, a number of strains belonging to the genera Penicillium, Aspergillus, Rhizopus and Mucor could accumulate SAM in their mycelia. Especially Mucor jansseni had the highest ability; it accumulated 45 μmoles of SAM in 1 g of dry cells.     

Radiation Chemistry of Foods

An intermediate radical, ?H₂OH, was produced in aqueous methanol solution containing nitrous oxide by γ-irradiation. Yields of ethylene glycol and formaldehyde, the major and the minor product from ?H₂OH, respectively, changed on the addition of some solutes. Cysteine lowered the both product yields to zero even at a low concentration of 5 × 10^?5m. Oxygen of low concentrations (2.5~7.5 × 10^?5 m) changed effectively the major product from ethylene glycol to formaldehyde. k _(CySH+?H2OH)/k_(O2+?H2OH) was calculated as 0.5.

Ascorbic acid (5 × 10^?5 m) lowered ethylene glycol yield to 48%, cystine (10^?3m) to 15%, methionine (10^?3m) to 31%, histidine (10^?3m) to 42%, tryptophan (10^?3m) 46%, tyrosine (10^?3m) to 77%, phenylalanine (10^?3m) to 73%, hypoxanthine (10^?3m) to 37%, adenine (10^?3m) to 52%, uracil (10^?3m) to 20%, thymine (10^?3m) to 10%, cytosine (10^?3 m) to 49%, rutin (10^?3m) to 23%, pyrogallol (10^?3m) to 41%, and gallic acid (10^?3m) to 78% of the control. These results suggest that the reactions of the secondary radicals such as ?H₂OH perform an important role in material change of foods irradiated with γ rays.     

Studies on d-Glucose-isomerizing Enzyme of Bacillus coagulans,Strain HN-68

Cells of Bacillus coagulans, strain HN-68 grown on the medium containing d-glucose, did not show any measurable d-glucose-isomerizing activity. However, when d-glucose-grown cells were shaked for a few hours in an induction medium containing d-xylose, induced formation of d-glucose-isomerizing enzyme occurred in the cells. Cell weight and number of survival cells showed only an increase of 30 and 10%, respectively during 6 hr induction.

The induced formation of d-glucose-isomerizing enzyme required organic nitrogen such as polypeptone in addition to d-xylose. Development of the maximum activity was observed when the concentration of d-xylose and polypeptone were 2 and 3%, respectively. Initial velocity of induced formation of d-glucose-isomerizing enzyme increased in proportion to the decrease of initial pH values of the induction medium, i.e., at 2 hr induction, activity at pH 4.5 was 5-fold increase than that at pH 8.0.

Induced formation of d-glucose-isomerizing enzyme was inhibited strongly by addition of chloramphenicol, tetracycline, streptomycin, cyanide or azide, and was promoted by threonine plus glycine.     

L-Threonine Production by a Mutant of Arthrobactev paraffineus

An isoleucine leaky auxotroph of Arthrobacter paraffineus, which was isolated by Takayama et al.³⁾ as a mutant producing L-threonine and L-valine from n-paraffin, was subjected to further mutagenesis in an attempt to obtain better L-threonine producers. Some of the double auxotrophs derived from the isoleucine auxotroph and some of their revertants with respect to isoleucine requirement produced more L-threonine than the original isoleucine auxotroph. In contrast to the original isoleucine auxotroph, a revertant derived from a methionine plus isoleucine double auxotroph, KY7135, produced an increased amount of L-threonine and a decreased amount of L-valine. The optimum level of L-methionine for L-threonine production in KY7135 was much higher (1000 ~ 2000 μg/ml) with n-paraffin medium than with sorbitol or mannitol medium (10 ~ 50 μg/ml). L-Threonine production reached a maximum level (11.5 mg/ml) in 7 days incubation with the medium containing 10% n-paraffin (C₁₂ ~ C₁₄ rich). Several mutants which produce L-threonine more than 12 mg/ml were obtained from KY 7135 by monocolony isolation procedure.     

Microbial Production of l-Threonine

The growth of Brevibacterium flavum No. 2247 was inhibited over 90% at a concentration above 1 mg/ml of α-amino-β-hydroxyvaleric acid, a threonine analogue, and the inhibition was reversed by the addition of l-threonine, and to lesser extent by l-leucine, l-isoleucine, l-valine and l-homoserine. l-Methionine stimulated the inhibition. Several mutants resistant to the analogue produced l-threonine in the growing cultures. The percentage of l-threonine producer in the resistant mutants depended on the concentration of the analogue, to which they were resistant. The best producer, strain B-183, was isolated from resistant strains selected on a medium containing 5 mg/ml of the analogue. Mutants resistant to 8 mg/ml of the analogue was derived from strain B-183 by the treatment with mutagen, N-methyl-N’-nitro-N-nitrosoguanidine. Among the mutants obtained, strain BB-82 produced 13.5 g/liter of l-threonine, 30% more than did the parental strain. Among the resistant mutants obtained from Corynebacterium acetoacidophilum No. 410, strain C-553 produced 6.1 g/liter of l-threonine. Several amino acids other than l-threonine were also accumulated, and these accumulations of amino acids were discussed from the view of regulation mechanism of l-threonine biosynthesis.     

The effects on plasma L-arginine levels of combined oral L-citrulline and L-arginine supplementation in healthy males

We investigated the effects of combining 1 g of l-citrulline and 1 g of l-arginine as oral supplementation on plasma l-arginine levels in healthy males. Oral l-citrulline plus l-arginine supplementation more efficiently increased plasma l-arginine levels than 2 g of l-citrulline or l-arginine, suggesting that oral l-citrulline and l-arginine increase plasma l-arginine levels more effectively in humans when combined.     

Properties of Tyrosinase from Pseudomonas melanogenum

The properties of the tyrosinase from Pseudomonas melanogenum was investigated with the crude enzyme preparation. Optimum temperature and pH of the enzyme were 23°C and 6.8, respectively. l-Tyrosine, d-tyrosine, m-tyrosine, N-acetyl-l-tyrosine and l-DOPA were utilized as a substrate by the enzyme. The value for Km obtained were as follows: l-tyrosine 6.90 × 10^?4 m, d-tyrosine 1.43 ×10^?3 m and l-DOPA 9.90 × 10^?4 m. The enzyme was inhibited by chelating agents of Cu²⁺ l-cysteine, l-homocysteine, thiourea and diethyl-dithiocarbamate and the inhibition was completely reversed by the addition of excess Cu²⁺ From these results it is concluded that the enzyme is a copper-containing oxidase.     

Synthesis of L-Tyrosine or 3,4-Dihydroxyphenyl-L-alanine from DL-Serine and Phenol or Pyrocathechol

Reaction conditions for the synthesis of L-tyrosine or L-dopa from DL-serine and phenol or pyrocatechol were studied with intact cells of Erwinia herbicola (ATCC 21434) containing high tyrosine phenol lyase activity. The optimum pH for this reaction was around 8.0, and the optimum temperature range was between 37~40°C for the synthesis of L-tyrosine and between 15~25°C for that of L-dopa. Sodium sulfite and EDTA were added to protect the synthesized L-dopa from decomposition. As high concentrations of phenol or pyrocatechol denatured the enzyme, each substrate was fed to maintain the optimum concentration during incubation.

The reaction mixture (100 ml) containing 4.0 g of DL-serine, 1.0 g of phenol or 0.7 g of pyrocatechol, 0.5 g of ammonium acetate and the cells, was incubated. During incubation, phenol or pyrocatechol was fed at intervals to maintain the substrate at the initial concentration. 5.35 g of L-tyrosine or 5.10 g of L-dopa was synthesized in 100 ml of the reaction mixture.     

Fukiic Acid Isolated from the Hydrolysate of a Polyphenol in Petasites japonicus

d-Glucose-isomerizing enzyme was purified in a crystalline form with a good yield from the cells of Bacillus coagulans, strain HN-68, and some phsicochemical properties were investigated.

The purified enzyme was homogeneous on both ultracentrifugal and disc-electrophoretical analyses. The molecular weight of the enzyme was determined to be 175,000 and 160,000 from the sedimentation-viscosity method and the gel filtration method, respectively.

The sedimentation coefficient , partial specific volume, at 280 mμ, and the nitrogen content of the enzyme were determined to be 10.2×10^?13 sec, 0.705 cm³g^?1, 10.6 and 16.2%, respectively. The integral numbers of amino acid residues per molecule calculated on the basis of 160,000 were as follows; Lys₁₂₀, His₄₉, Arg₆₁, Asp₁₈₂, Thr₈₇, Ser₇₀, Glu₁₃₆, Pro₄₄, Gly₁₀₆, Ala₁₄₀, Half-Cys₀, Val₅₃, Met₂₇, Ileu₅₁, Leu₁₃₄, Tyr₅₈, Phe₉₆, Try₁₃, and amide-ammonia₈₀.

Purified enzyme preparation obtained from Bacillus coagulans, strain HN-68 requires Co²⁺ for d-glucose- and d-ribose-isomerizing activities and Mn²⁺ for d-xylose-isomerizing activity. The values of Km for d-glucose, d-xylose and d-ribose were 9×10^?2, 1.1×10^?3, 7.7×1O^?m and of the relative V_max were 0.52, 1.1 and 0.25 mg/min at 40°C, respectively. d-Glucose-isomerizing activity was inhibited by d-xylose and d-ribose. However, there was not a difference among three activities of the enzyme with respect to following properties: Activation energy was 14,600 cal per mol. The enzyme was inhibited in a competitive manner by tris(hydroxymethyl)aminomethane, d-xylitol, d-sorbitol and d-mannitol, and the Ki values for these inhibitor were 3×10^?4, 2.5×10^?3, 2.9×10^?2 and 7×10^?2m, respectively. The ratio of three activities did not change by heat- and pH-treatments. Mn²⁺, Co²⁺ and Ni²⁺ protected strongly the enzyme from heat denaturation. The enzyme can isomerize d-glucose, d-xylose and d-ribose to their corresponding ketose, but the kinetic constants and induction studies indicated that ^d-xylose is the natural substrate for the enzyme.     

l-Tryptophan Production by 5-Methyltryptophan-resistant Mutants of Glutamate-producing Bacteria

1. Some of 5-methyltrypotophan (5MT)-resistant mutants derived from glutamate-producing bacteria such as Brevibacterium flavum, Corynebacterium acetoglutamicum and Micrococcus glutamicus produced a small amount of l-tryptophan, while tyrosine and phenylalanine auxotrophs of B. flavum did not.

2. 5-MT-resistant mutant derived from the auxotroph for tyrosine and phenylalanine produced 390 mg/liter of l-tryptophan at most. A mutant resistant to a higher concentration of 5MT, which was derived from a tyrosine and phenylalanine auxotrophic mutant which was resistant to a low concentration of 5MT, produced 660 mg/liter of l-tryptophan. Using this mutant, the effects of the concentrations of components of the culture medium on the l-tryptophan production were examined. The high concentration of l-tyrosine, but not l-phenylalanine, inhibited the l-tryptophan production. Using the improved culture medium, this strain produced 1.9 g/liter of l-tryptophan.