蛹虫草菌丝产虫草素液体培养条件的研究

通过对蛹虫草菌丝产虫草素液体培养条件的研究,明确蛹虫草菌丝产虫草素的适宜碳源及浓度,适宜氮源及浓度,最适pH值,最适培养温度,最适转速以及最适培养时间,以便应用于虫草素的工厂化生产。结果表明,蛹虫草菌丝产虫草素的条件：适宜碳源为D-果糖,最适浓度为10g/L;适宜氮源为蛋白胨,最适浓度为15g/L;最适初始pH为7,最适培养温度为24℃,最适转速为180r/min,最适培养时间为9d,其培养液虫草素含量可达到0.537g/L。     

高活性蛹虫草菌株CMCX33子实体最佳采收时间研究

在规模化培养条件下,根据虫草素、腺苷收率确定高活性蛹虫草菌株CMCX33最佳采收时间。从不同培养时期的蛹虫草子实体性状、产量及虫草素、腺苷含量及收率等进行比较分析。试验范围内,培养65 d的菌株CMCX33子实体呈现良好的商品性状,生物学效率最高（平均生物学效率103.0%）;培养早期（35～55 d）腺苷含量呈快速累积、虫草素含量缓慢增加趋势,培养55 d时腺苷含量达到较高水平（2.42 mg/g）,随着培养时间的增加,腺苷平均含量虽然呈小幅度下降趋势,但相对稳定,培养65 d时腺苷收率最高（平均收率0.23%）;虫草素含量呈先快速增加后减少趋势,培养70 d时虫草素含量达到峰值（平均含量4.79 mg/g）,该时期菌株CMCX33子实体的生长进入衰退期,生物学效率明显下降,虫草素总收率与培养65 d的子实体相同(虫草素平均收率0.44%)。综合考虑,高活性蛹虫草菌株CMCX33最佳采收时期为65 d。明确高活性蛹虫草菌株CMCX33最佳采收时期,为其应用研究及配套栽培技术规程的建立提供参考。     

不同培养条件和前体对蛹虫草液体发酵产虫草素的影响

蛹虫草能产生虫草素等多种活性物质。为考察不同液体发酵方式及添加前体物质对虫草素积累的影响,选用蛹虫草08Y1菌株,通过光照振荡、光照静置、黑暗振荡、黑暗静置四种培养条件和添加前体物质（腺嘌呤1g/L+甘氨酸16g/L）,发酵16d后检测虫草素和腺嘌呤含量。结果表明：08Y1菌株在黑暗振荡培养条件下,虫草素积累达1,015.0mg/L,腺嘌呤利用率达98.5%,说明黑暗振荡培养并添加前体物质是提高虫草素产量的有效方法。     

柞蚕蛹虫草继代培育其活性物质变化规律

柞蚕蛹虫草中含有虫草素、腺苷、多糖等多种活性成分,具有提高免疫力、抗疲劳、保护心脑血管、抗癌等方面的作用,是冬虫夏草的良好替代品。以柞蚕蛹虫草的继代培育为基础,分别检测蛹虫草菌在不同传代次数时柞蚕蛹虫草子实体生长状态、蛹虫草中腺苷、虫草素、虫草多糖含量及蛹虫草菌菌丝、分生孢子中活性氧的分布。第1代蛹虫草菌接种后柞蚕蛹出现腐烂现象;第2、3代培育的子实体生长量、腺苷及虫草素含量均较高;第4代子实体生长量、腺苷及虫草素含量均出现大幅下降的现象。柞蚕蛹虫草中虫草多糖含量在传代过程中也逐渐降低,但降低幅度较腺苷和虫草素缓慢。第2代培育的柞蚕蛹虫草子实体生长状态优于第3代,故第2代蛹虫草菌更适合应用于批量生产。蛹虫草菌退化后含有活性氧的分生孢子比例增大,这可能是发生退化的表象之一。     

锌富集对蛹虫草菌丝体内虫草素、腺苷含量的影响

为了解蛹虫草菌丝体对锌的富集特性,研究锌富集对蛹虫草菌丝体内虫草素、腺苷含量的影响,通过在液体培养基中添加不同质量浓度的锌离子(0~35 g/L),探讨其对蛹虫草菌丝生物量、菌丝体内锌积累量,以及锌的富集对菌丝体内虫草素、腺苷含量产生的影响。结果表明:在0~35 g/L锌离子的梯度范围内,蛹虫草菌丝生物量与锌质量浓度呈显著负相关,锌质量浓度35 g/L为蛹虫草菌丝生长极限浓度。锌质量浓度40.0 g/L及以上菌丝生长受到完全抑制。菌丝体内锌的积累量随锌质量浓度的增加而显著升高,锌质量浓度为35.0 g/L时锌积累量可达到193.87 mg/g(干重)。蛹虫草菌丝体内腺苷的含量随锌质量浓度的增加而降低,在锌质量浓度为5 g/L时降幅显著,腺苷含量仅为对照组的17.24%,之后腺苷含量变化趋势趋于水平。腺苷含量的降低可能是因为锌的富集干扰了蛹虫草菌丝体内初生代谢的正常进行。虫草素的含量随锌质量浓度的增加而显著降低,可能是由于其直接前体腺苷含量的降低,或是Zn离子的加入,使得某些被刺激的酶和基因通过转录因子影响了虫草素的合成。     

虫草液体培养的研究进展

论述了液体培养主要涉及的碳源、氮源、碳氮比和其他元素等营养因素和温度、通气、pH等环境条件对虫草菌丝产量和活性成分(以多糖和虫草素为主)产量的影响,展望了虫草液体培养的发展趋势.     

发酵虫草菌质与天然虫草主要活性成分含量比较研究

用大米作为固体发酵基质,通过蛹虫草菌种发酵后制成虫草菌质,测定菌质中腺苷、虫草素、多糖等成分含量.比较人工发酵虫草菌质与天然虫草腺苷、虫草素、多糖等主要活性成分的含量.结果表明,虫草菌质中虫草素、多糖含量分别超过天然虫草的40倍和3倍.因此.人工发酵虫草菌质可以替代天然虫草应用.     

蛹虫草多糖发酵工程研究

报道了蛹虫草(Gordyceps militaris)多糖发酵工程中的关键因子对菌丝体生物量和多糖产量影响的研究结果.对蛹虫草液体发酵培养基中的碳源、氮源和温度进行了正交试验,考察了三因子对蛹虫草生物量以及多糖的综合效应.实验结果表明:各因素不同水平间的组合对蛹虫草生物量、胞外多糖、胞内多糖以及总多糖的影响不同.其中.在6%的碳源和1%的氮源以及25℃的条件下.能获得蛹虫草的最大生物量以及总多糖和胞外多糖的最大产量;碳源为6%、氮源为1%、温度为22℃时.胞内多糖的产量达到最高.     

虫草制品中腺苷和虫草素含量的RP-HPLC分析

采用超声提取,反相高效液相色谱方法分析了各种虫草制品中的腺苷和虫草素的含量,以含0．05mol／L 的磷酸二氢钾：甲醇（85／15,V／V）作为流动相。检测波长为260nm。进样量为10μL,40℃条件下检测。在5mg／L到250mg／L的浓度范围内呈线性相关。研究显示利用蒸馏水在60℃超声提取20min,腺苷和虫草素的回收率在85％-95％之间。     

虫草素高产菌株的筛选及不同添加物对虫草素产量的影响研究

通过对14株蛹拟青霉菌株进行摇瓶液体发酵培养试验,筛选虫草素产量最高的蛹虫草菌株,并确定了虫草素的最佳收获期;比较8种营养添加物对虫草发酵过程中虫草素积累的影响,筛选出最佳的营养添加物,以提高液体发酵生产虫草素的产量。结果表明：蛹虫草CM001号菌株的虫草素产量最高,蛹虫草菌在第10天细胞量达到最大值20.44mg/mL,虫草素含量在第13天达到最大值73.81mg/L,70%以上的虫草素分布在发酵液中。其中分别添加腺苷、腺嘌呤、丙氨酸、L-天冬氨酸、甘氨酸5种物质,对虫草素合成的促进作用均较明显,均能有效提高蛹虫草液体发酵虫草素的产量,特别是添加1g/L的腺嘌呤能使10号菌株的虫草素产量提高7.09倍。     

β-蜕皮激素对蛹虫草液体培养菌丝体生长及代谢产物的促进作用(英文)

The effects of β-ecdysone on mycelial dry weight (MDW) and the yield of extracellular polysaccharide (EPS), intracellular polysaccharide (IPS) and cordycepin of Codyceps militaris in submerged cultivation was investigated. Adding 12mg/L of β-ecdysone to the culture medium, the MDW, the secretion volume of EPS per unit of MDW and total yield of EPS were increased by 18.5%, 181.7% and 63.2%, respectively. The yield of IPS was enhanced by 29.2%, when 1.2mg/L of β-ecdysone was added. When 4mg/L of β-ecdysone was provided, the amount of cordycepin per unit of MDW and the total yield of cordycepin were increased by 65.4% and 84.7%, respectively. These results demonstrated that β-ecdysone promoted the yield of MDW, EPS, IPS and cordycepin of Codyceps militaris mycelia, though this effect varied among different components. Significantly, β-ecdysone showed a more positive role in secondary metabolite (cordycepin) accumulation than in primary metabolite (IPS) production and growth of mycelia. Furthermore, β-ecdysone stimulated the secretion of EPS.     

Effects of culture conditions on the mycelial growth and bioactive metabolite production in submerged culture of Cordyceps militaris

The influence of initial pH value, various nitrogen sources, plant oils, and modes of propagation (shake-flask and static culture) on the production of biomass, exopolysaccharide (EPS), adenosine and, in particular, cordycepin, by Cordyceps militaris CCRC 32219 were investigated. Optimal conditions for mycelial growth, EPS and cordycepin production were observed at relatively low pH. Amongst organic sources, yeast extract (YE) was favorable for EPS and cordycepin production, while corn steep powder (CSP) was favorable for adenosine production. A lower C/N ratio was favorable for adenosine and cordycepin production; however, too low a C/N ratio led to diminished production. All plant oils tested stimulate mycelial growth and EPS production of C. militaris, but they did not show much effect on the adenosine and cordycepin production. A two-stage fermentation process by combining shake-flask fermentation with static culture significantly enhanced cordycepin production. A Box–Behnken experimental design was employed to optimize the production of cordycepin, which showed that the optimum conditions to produce cordycepin by C. militaris CCRC 32219 were at pH 6, YE concentration of 45 g/l and 8.0 day of the shake culture followed by 16 days of the static culture. Under the optimized conditions, the maximum production (2214.5 mg/l) of cordycepin was obtained, which is much higher than those reported up to date.     

β-蜕皮激素对蛹虫草液体培养菌丝体生长及代谢产物的促进作用

The effects of β-ecdysone on mycelial dry weight (MDW) and the yield of extracellular polysaccharide (EPS), intracellular polysaccharide (IPS) and cordycepin of Codyceps militaris in submerged cultivation was investigated. Adding 12mg/L of β-ecdysone to the culture medium, the MDW, the secretion volume of EPS per unit of MDW and total yield of EPS were increased by 18.5%, 181.7% and 63.2%, respectively. The yield of IPS was enhanced by 29.2%, when 1.2mg/L of β-ecdysone was added. When 4mg/L of β-ecdysone was provided, the amount of cordycepin per unit of MDW and the total yield of cordycepin were increased by 65.4% and 84.7%, respectively. These results demonstrated that β-ecdysone promoted the yield of MDW, EPS, IPS and cordycepin of Codyceps militaris mycelia, though this effect varied among different components. Significantly, β-ecdysone showed a more positive role in secondary metabolite (cordycepin) accumulation than in primary metabolite (IPS) production and growth of mycelia. Furthermore, β-ecdysone stimulated the secretion of EPS.     

蛹虫草菌株退化特征及鉴别方法

蛹虫草菌株在继代培养和低温长期保藏过程中极易退化导致子实体产量下降,对产业造成重大影响。本研究以正常菌株、PDA斜面长期4 ℃保藏导致退化的菌株和连续继代培养的菌株为材料,观察其子实体、菌落、菌丝形态和分生孢子数量,对菌丝细胞核、线粒体、活性氧积累和芽生孢子内脂滴进行染色观察;并对菌丝中虫草素、腺苷和麦角甾醇含量进行比较分析。结果表明PDA斜面长期4 ℃保藏和连续继代培养导致的蛹虫草菌株退化表型大多数一致,即退化菌株较正常菌株子实体产量降低、菌丝粘连打结、分生孢子数量显著降低、菌丝活性氧含量升高、细胞内线粒体数量减少、芽生孢子脂滴由弥散的小脂滴融合为大脂滴。然而,在菌落见光转色方面,长期低温保藏退化菌株基本不转色,而继代培养退化菌株转色不稳定;长期保藏退化菌株菌丝细胞核数目无明显变化,继代培养退化菌株细胞核数量明显减少;长期保藏退化菌株菌丝中虫草素、腺苷和麦角甾醇含量较正常菌株降低58%、41%和70%,继代培养退化菌株麦角甾醇含量无明显变化。因此,显微观察菌丝是否出现粘连打结及氮蓝四唑NBT检测菌丝活性氧含量,操作简单、用时较短,可用于大规模生产中蛹虫草菌株退化的检测手段;线粒体和脂滴染色也可作为退化菌株的鉴别方法;而生产中常用的通过菌落见光转色判断菌株优劣的方法需要慎重。继代培养菌株第4代开始出现明显的退化特征,因此在生产中使用的菌株最好控制在继代培养3代以内。     

灰树花发酵工艺及培养基研究

详细、系统地研究了碳源、氮源、无机盐、维生素以及种龄、接种量、摇床转速、摇瓶装液量和培养基 pH值等因素对灰树花液体深层发酵菌丝体产量的影响 ,结果表明 :玉米粉、葡萄糖为最佳碳源 ,豆饼粉为最佳氮源 ,KH2 PO4 ,MgSO4 以及少量VB1的添加均使菌丝体产量明显增加     

产银杏内酯内生真菌的筛选及培养条件研究

通过对内生真菌的发酵提取物进行TLC和HPLC-UV分析,进行菌株筛选;对该菌株在不同培养基上的生长情况、产孢量、银杏内酯类物质产量的测定,确定最佳培养基;并用HPLC-ELSD测定了不同时间段的发酵液中银杏内酯类物质含量。结果,筛选出一株产量较高的烟曲霉原变种(Aspergillus fumigatusvar.fumigatus)FG052;对其培养条件的研究表明,PDA培养基、查氏培养基分别为其最佳传代和发酵培养基,菌丝最大生物量在发酵168 h,产银杏内酯类物质高峰在发酵144 h,此时总内酯产量可达0.13 mg/mL,pH值为4.86。本实验筛选的菌株稳定性较好,筛选的培养基价格低廉,碳氮比明确,且总内酯的产量高,可作为规模生产银杏内酯类物质的培养基。     

Exopolysaccharides, proteins and lipids in Pleurotus pulmonarius submerged culture using different carbon sources

For many years mushrooms have been consumed and appreciated by their nutritional value, and medicinal properties. The traditional mushroom cultivation takes too long and the macrofungi biotechnology has not been explored in its full potential yet. The goal of this work was to observe if different carbon sources could improve the yield and diversify fungi nutrient composition in submerged culture.Pleurotus pulmonarius mycelia and exopolysacharide productions were evaluated using glucose, galactose, xylose and arabinose. The mycelia yield varied depending on the culture medium, and galactose showed to be the best carbon source to produce EPS. Samples that showed the highest protein contents were grown with xylose (19.44%) and arabinose (26.05%). Furthermore, the biomass cultivated with these carbohydrates and with galactose showed five essential amino acids. All cultured biomass showed low lipid contents (∼1%), being composed mainly of unsaturated fatty acids. All EPS fractions showed as main structures glucans and mannogalactans.