Use of Pleurotus dryinus for lignocellulolytic enzymes production in submerged fermentation of mandarin peels and tree leaves

It has been shown that the wood-rotting mushroom Pleurotus dryinus IBB 903 is able to effectively produce cellulases, xylanase, laccase, and manganese peroxidase in submerged fermentation of mandarin peels and tree leaves. Gradual increasing of lignocellulosic substrates concentration from 1 to 4–6% enhanced enzyme accumulation in culture liquid. A simple and inexpensive medium containing mandarin peels and yeast extract as sole carbon and nitrogen sources allowed simultaneous production of high levels of both hydrolases and oxidases by P. dryinus IBB 903. Supplementation of this medium by copper and manganese caused earlier and faster accumulation of laccase and manganese peroxidase increasing their yield by 1.5 and 7.5 times, respectively. In addition, by adding manganese to the medium it is possible to regulate the ratio of laccase and MnP in enzyme preparation. The presence of lignocellulosic substrate is the requisite for MnP production by P. dryinus IBB 903 since there was no production of MnP when mushroom has been cultivated in the synthetic medium with different carbon source. Among carbon source tested only utilization of glucose resulted to 21-fold increase of fungus laccase specific activity compared to control medium without carbon source. Carboxymethyl cellulase and xylanase appeared to be inducible enzymes.     

Effect of growth substrate,method of fermentation,and nitrogen source on lignocellulose-degrading enzymes production by white-rot basidiomycetes

The exploration of seven physiologically different white rot fungi potential to produce cellulase, xylanase, laccase, and manganese peroxidase (MnP) showed that the enzyme yield and their ratio in enzyme preparations significantly depends on the fungus species, lignocellulosic growth substrate, and cultivation method. The fruit residues were appropriate growth substrates for the production of hydrolytic enzymes and laccase. The highest endoglucanase (111 U ml⁻¹) and xylanase (135 U ml⁻¹) activities were revealed in submerged fermentation (SF) of banana peels by Pycnoporus coccineus. In the same cultivation conditions Cerrena maxima accumulated the highest level of laccase activity (7,620 U l⁻¹). The lignified materials (wheat straw and tree leaves) appeared to be appropriate for the MnP secretion by majority basidiomycetes. With few exceptions, SF favored to hydrolases and laccase production by fungi tested whereas SSF was appropriate for the MnP accumulation. Thus, the Coriolopsis polyzona hydrolases activity increased more than threefold, while laccase yield increased 15-fold when tree leaves were undergone to SF instead SSF. The supplementation of nitrogen to the control medium seemed to have a negative effect on all enzyme production in SSF of wheat straw and tree leaves by Pleurotus ostreatus. In SF peptone and ammonium containing salts significantly increased C. polyzona and Trametes versicolor hydrolases and laccase yields. However, in most cases the supplementation of media with additional nitrogen lowered the fungi specific enzyme activities. Especially strong repression of T. versicolor MnP production was revealed.     

Lignocellulose-degrading enzyme production by white-rot <Emphasis Type="Italic">Basidiomycetes</Emphasis> isolated from the forests of Georgia

The production of lignocellulolytic enzymes by eleven basidiomycetes species isolated from two ecosystems of Georgia was investigated for the first time under submerged (SF) and solid-state fermentation (SSF) of lignocellulosic by-products. Notable intergeneric and intrageneric differences were revealed with regard to the extent of hydrolase and oxidase activity. Several fungi produced laccase along with hydrolases in parallel with growth during the trophophase, showing that the synthesis of this enzyme is not connected with secondary metabolism. The lignocellulosic substrate type had the greatest impact on enzyme secretion. Some of the substrates significantly stimulated lignocellulolytic enzyme synthesis without supplementation of the culture medium with specific inducers. Exceptionally high carboxymethyl cellulase (CMCase, 122 U ml⁻¹) and xylanase (195 U ml⁻¹) activities were revealed in SF of mandarin peelings by Pseudotremella gibbosa IBB 22 and of residue after ethanol production (REP) by Fomes fomentarius IBB 38, respectively. The SSF of REP by T. pubescens IBB 11 ensured the highest level of laccase activity (24,690 U l⁻¹), whereas the SSF of wheat bran and SF of mandarin peels provided the highest manganese peroxidase activity (570–620 U l⁻¹) of Trichaptum biforme IBB 117. Moreover, the variation of lignocellulosic growth substrate provides an opportunity to obtain enzyme preparations containing different ratios of individual enzymes.     

Laccase, cellulase and xylanase activities during growth ofPleurotus sajor-caju on sagohampas

Sagohampas, the fibrous pith residue left after starch extraction from sago palm, is abundant at sago-processing factories and can be used as a substrate for the production of laccase by solid substrate fermentation (SSF) withPleurotus sajorcaju, an edible mushroom. The fungus grown onhampas with an adjusted carbon : nitrogen ratio of 35:1, exhibited high laccase activity together with variable cellulase (0.3-2.8 U/g) and xylanase (0.9-10.1 U/g) activity. The maximum amount of laccase produced was approximately 17.7 U/g after 6 days of SSF using 4-week-old inoculum at a density of 10%. With the mature four-week inoculum, laccase activity increased 12-fold compared to that achieved with two-week-old inoculum. The optimum pH and temperature of the crude laccase were 6.0 and 50‡C, respectively. The apparent K_m and V_max values obtained were 0.073 mM and 0.962 U/min, respectively. The maximum laccase activity could be almost doubled after 6 days of fermentation by addition of 0.2 mM vanillin or ferulic acid; the cellulose to lignin ratio increased significantly during the 12 days of SSF, from 2.74 in the control to 3.3, when 0.2 mM of either vanillin or ferulic acid was added to the substrate.     

Laccase and Manganese Peroxidase Activities of Phellinus Robustus and Ganoderma Adspersum Grown on Food Industry Wastes in Submerged Fermentation

Phellinus robustus produced both laccase (700–4,000 U l⁻¹) and manganese peroxidase (MnP) (1,000–11,300 U l⁻¹) in fermentation of nine food wastes, whereas Ganoderma adspersum produced only laccase (600–34,000 U l⁻¹). Glucose provided high laccase and MnP activity of P. robustus but repressed enzyme production by G. adspersum. Ammonium sulphate and ammonium tartrate increased the P. robustus laccase yield (3-fold), whereas the accumulation of MnP was not enhanced by additional nitrogen.     

Optimization of manganese peroxidase and laccase production in the South American fungus<Emphasis Type="Italic"> Fomes sclerodermeus</Emphasis> (Lév.) Cke

Fomes sclerodermeus produces manganese peroxidase (MnP) and laccase as part of its ligninolytic system. A Doehlert experimental design was applied in order to find the optimum conditions for MnP and laccase production. The factors studied were Cu²⁺, Mn²⁺ and asparagine. The present model and data analysis allowed us not only to define optimal media for production of both laccase and MnP, but also to show the combined effects between the factors. MnP was strongly influenced by Mn²⁺, which acts as an inducer. Under these conditions Cu²⁺ negatively affected MnP activity. At 13 days of growth 0.75 U ml^–1 were produced in the optimized culture medium supplemented with 1 mM MnSO₄ and 4 g l^–1 asparagine. The laccase titer under optimized conditions reached maximum values at 16 days of growth: 13.5 U ml^–1 in the presence of 0.2 mM CuSO₄, 0.4 mM MnSO₄ and 6 g l^–1 asparagine. Mn²⁺ promoted production of both enzymes. There were important interactions among the nutrients evaluated, the most significant being those between Cu²⁺ and asparagine.     

Ligninolytic Enzymes of the White Rot Basidiomycete Trametes trogii

The white rot fungus Trametes trogii strain BAFC 463 produced laccase, manganese peroxidase, lignin peroxidase and cellobiose dehydrogenase, as well as two hydrogen peroxide‐producing activities: glucose oxidizing activity and glyoxal oxidase. In high‐N (40 mM N) cultures, the titres of laccase, MnP and GLOX were 27 (6.55 U/ml), 45 (403.00 mU/ml)and 8 (32,14 mU/ml) fold higher, respectively, than those measured in an N‐limited medium. This is consistent with the fact that the ligninolytic system of T. trogii is expressed constitutively. Lower activities of all the enzymes tested were recorded upon decreasing the initial pH of the medium from 6.5 to 4.5. Adding veratryl alcohol improved GLOX production, while laccase activity was stimulated by tryptophan. Supplying Tween 80 strongly reduced the activity of both MnP and GLOX, but increased laccase production. The titre of MnP was affected by the concentration of Mn in the culture medium, the highest levels were obtained with 90 μM Mn (II). LiP activity, as CDH activity, were detected only in the mediumsupplemented with sawdust. In this medium, laccase production reached a maximum of 4.75 U/ml, MnP 747.60 mU/ml and GLOX 117.11 mU/ml. LiP, MnP and GLOX activities were co‐induced, attaining their highest levels at the beginning of secondary metabolism, but while MnP, laccase, GLOX and CDH activities were also present in the primary growth phase, LiP activity appears to beidiophasic. The simultaneous presence of high ligninolytic and hydrogen peroxide producing activities in this fungus makes it an attractive microorganism for future biotechnological applications.     

High-level xylanase production by alkaliphilic Bacillus pumilus ASH under solid-state fermentation

Bacillus pumilus ASH produced a high level of an extracellular and thermostable xylanase enzyme when grown using solid-state fermentation (SSF). Among a few easily available lignocellulosics tested, wheat bran was found to be the best substrate (5,300 U/g of dry bacterial bran). Maximum xylanase production was achieved in 72 h (5,824 U/g). Higher xylanase activity was obtained when wheat bran was moistened with deionized water (6,378 U/g) at a substrate-to-moisture ratio of 1:2.5 (w/v). The optimum temperature for xylanase production was found to be 37°C. The inoculum level of 15% was found to be the most suitable for maximum xylanase production (7,087 U/g). Addition of peptone stimulated enzyme production followed by yeast extract and mustard oil cake, whereas glucose, xylose and malt extract greatly repressed the enzyme activity. Repression by glucose was concentration-dependent, repressing more than 60% of the maximum xylanase production at a concentration of 10% (w/v). Cultivation in large enamel trays yielded a xylanase titre that was slightly lower to that in flasks. The enzyme activity was slightly lower in SSF than in SmF but the ability of the organism to produce such a high level of xylanase at room temperature and with deionized water without addition of any mineral salts in SSF, could lead to substantial reduction in the overall cost of enzyme production. This is the first report on production of such a high level of xylanase under SSF conditions by bacteria.     

A new role for veratryl alcohol: regulation of synthesis of lignocellulose-degrading enzymes in the ligninolytic ascomyceteous fungus, Botryosphaeria sp.; influence of carbon source

A new physiological role for veratryl alcohol in fungi important in the biodegradation of the lignified plant cell wall is presented. Botryosphaeria sp., grown on starch, pectin, cellulose or xylan produced amylase, pectinase, cellulase, xylanase and laccase, whereas glucose and xylose repressed the synthesis of cellulase and xylanase, but not laccase. When cultured on each of these substrates in the presence of veratryl alcohol, laccase activity increased but the activities of amylase, pectinase, cellulase and xylanase significantly decreased. Basal medium containing softwood kraft lignin in the presence of veratryl alcohol induced laccases above constitutive levels. Ethyl alcohol also stimulated laccase production.     

Effects of carbon and nitrogen sources on Pleurotus ostreatus ligninolytic enzyme activity

Summary The effect of various carbon and nitrogen sources on laccase, manganese-dependent peroxidase (MnP), and peroxidase production by two strains of Pleurotus ostreatus was investigated. The maximal laccase yield of P. ostreatus 98 and P. ostreatus 108 varied depending upon the carbon source from 5 to 62 U l⁻¹ and from 55 to 390 U l⁻¹, respectively. The highest MnP and peroxidase activities were revealed in medium supplemented by xylan. Laccase, MnP, and peroxidase activities of mushrooms decreased with supplementation of defined medium by inorganic nitrogen sources. Peptone followed by casein hydrolysate appeared to be the best nitrogen sources for laccase accumulation by both fungi. However, their positive effects on enzyme accumulation were due to a higher biomass production. The secretion of MnP and peroxidase by P. ostreatus 108 was stimulated with supplementation of casein hydrolysate to the control medium since the specific MnP and peroxidase activities increased 15-fold and 3.5-fold, respectively.     

Production and characterisation of lignocellulases of Panus tigrinus and their application

This study on the lignocellulases in broth cultures of the basidiomycete Panus tigrinus indicates that laccase and xylanase enzymes are constitutive and cellulase is inducible. In stationary culture at 28°C, the greatest laccase and xylanase activity was observed after growth for approximately nine days. Laccase production was dependent on the presence, and the particular brand, of malt extract in the growth medium. While production of laccase was enhanced by growth at 37°C and 42°C, xylanase was not. Raising the pH of the growth medium from pH 5.6 to pH 7.0 did not affect xylanase production, but laccase production was reduced at the higher pH. In shake culture, growth was pelleted and biomass lower than in stationary culture, and synthesis of both enzymes was strongly inhibited. Cultures of P. tigrinus decolourised Poly R-478 and the toxic triphenyl methane dye, crystal violet. It was also shown to degrade a natural lignocellulosic waste, sawdust.     

Induction of manganese peroxidase and laccase by <Emphasis Type="Italic">Lentinula edodes</Emphasis> under liquid culture conditions and their isozyme detection by enzymatic staining on native-PAGE

The white-rot basidomycete Lentinula edodes often produces the lignin-degrading enzymes manganese peroxidase (MnP; EC 1.11.1.13) and laccase (Lcc; EC 1.10.3.2) in sawdust-based media. In the present study, MnP from L. edodes was induced under liquid culture supplemented with sawdust extracts of Castanopsis cuspidata. Lcc activity was induced by the addition of 2 mM CuSO₄·5H₂O into the same media 7 days after initial inoculation. Phenoloxidase enzymes were distinguished by polyacrylamide gel electrophoresis (native-PAGE), followed by sequential enzymatic staining with an improved staining solution. The isozyme bands detected under MnP-induced conditions were identified as manganese peroxidase (lemnp2) and bands detected under Lcc-induced conditions were identified as laccase (lcc1) by Q-TOF mass spectrometry.     

Optimization of xylanase production using inexpensive agro-residues by alkalophilic Bacillus subtilis ASH in solid-state fermentation

Alkalophilic Bacillus subtilis ASH produced high levels of xylanase using easily available inexpensive agricultural waste residues such as wheat bran, wheat straw, rice husk, sawdust, gram bran, groundnut and maize bran in solid-state fermentation (SSF). Among these, wheat bran was found to be best substrate. Xylanase production was highest after 72 h of incubation at 37 °C and at a substrate to moisture ratio of 1:2 (w/v). The inoculum level of 15% resulted in maximum production of xylanase. The enzyme production was stimulated by the addition of nutrients such as yeast extract, peptone and beef extract. In contrast, addition of glucose and xylose repressed the production of xylanase. The extent of repression by glucose (10%, w/v) was 81% and it was concentration-dependent. Supplementation of the medium with 4% xylose caused 59% repression. Under optimized conditions, xylanase production in SSF (8,964 U of xylanase/g dry wheat bran) was about twofold greater than in submerged fermentation. Thus, B. subtilis produced a very high level of xylanase in SSF using inexpensive agro-residues, a level which is much higher than that reported by any other bacterial isolate. Furthermore, the enzyme was produced at room temperature and with tap water without the addition of any mineral salt in SSF, leading to a marked decrease in the cost of xylanase production, which enhances its industrial potential.     

Degradation of the herbicide bentazon as related to enzyme production by Phanerochaete chrysosporium in two solid substrate fermentation systems

Enzyme production and degradation of the herbicide bentazon by Phanerochaete chrysosporium growing on straw (solid substrate fermentation, SSF) and the effect of nitrogen and the hydraulic retention time (HRT) were studied using a small bioreactor and batch cultures. The best degradation of bentazon was obtained in the low nitrogen treatments, indicating participation of the ligninolytic system of the fungus. The treatments that degraded bentazon also had manganese peroxidase (MnP) activity, which seemed to be necessary for degradation. Pure MnP (with Mn(II) and H₂O₂) did not oxidize bentazon. However, in the presence of MnP, Mn(II) and Tween 80, bentazon was slowly oxidized in a H₂O₂-independent reaction. Bentazon was a substrate of pure lignin peroxidase (LiP) and was oxidized significantly faster (22,000–29,000 times) as compared to the MnP-Tween 80 system. Although LiP was a better enzyme for bentazon oxidation in vitro, its role in the SSF systems remains unclear since it was detected only in treatments with high nitrogen and high HRT where no degradation of bentazon occurred. Inhibition of LiP activity may be due to phenols and extractives present in the straw.     

Increased production of extracellular laccase by the white rot fungus Coriolus versicolor MTCC 138

Summary The white rot fungus Coriolus versicolor MTCC 138 has been identified as an excellent producer of the industrially important enzyme laccase. The basal medium containing glucose gave laccase activity of 155 U/ml. Screening of different media components and their effects on laccase production by Coriolus versicolor was studied using one factor at a time and L₉ (3⁴) orthogonal array method. A two-fold increase (305 U/ml) in laccase production was observed using a combination of glucose and starch as carbon source and yeast extract as nitrogen source. This activity is very high as compared to most of the reported strains. Hence this strain was explored for enhancement in laccase. The formation of extracellular laccase could be considerably stimulated by the addition of copper in the optimized medium. Addition of 1 mM copper enhanced laccase activity to 460 U/ml. Laccase production was further enhanced using different aromatic inducers. Among different inducers used 2,5-xylidine was found to be the best, and gave maximum laccase activity of 820 U/ml with 1 mM concentration. Thus, this strain could be an efficient and attractive source for laccase production.     

Influence of cultivation conditions on production of lignocellulolytic enzymes by Ceriporiopsis subvermispora

The aim of this work was to make a survey describing factors that influence the production of extracellular enzymes by white-rot fungus Ceriporiopsis subvermispora responsible for the degradation of lignocellulolytic materials. These factors were: carbon sources (glucose, cellulose, hemicellulose, lignin, maltose and starch), nitrogen sources (ammonium sulphate, potassium nitrate, urea, albumin and peptone), pH, temperature and addition of three different concentrations of Cu²⁺ and Mn²⁺. The cellulase and xylanase activities were similar in medium with different carbon sources and the highest cellulase and xylanase activities were measured in medium with urea and potassium nitrate as nitrogen sources, respectively. The highest laccase activity was observed in medium with lignin and peptone as carbon and nitrogen sources. In other experiments, time course of production of lignocellulolytic enzymes by white-rot fungus C. subvermispora in medium with lignin or glucose as carbon sources was observed.     

Effect of different cultural conditions for phytase production by <Emphasis Type="Italic">Aspergillus niger</Emphasis> CFR 335 in submerged and solid-state fermentations

The present article deals with the studies on the effect of media ingredients, such as carbon, nitrogen, inorganic phosphates, surfactants, and metal salts, on phytase enzyme production by Aspergillus niger CFR 335 in submerged (SmF) and solid-state fermentations (SSF). The results obtained showed a 1.5-fold higher enzyme yield in the presence of sucrose in both SmF and SSF, while peptone was found to be a favorable nitrogen source for SmF. Sodium dihydrogen phosphate (NaH₂PO₄) favored 34% higher enzyme yield than the control, which was followed by 19% higher activity in potassium dihydrogen phosphate (KH₂PO₄) in SSF at 0.015% w/v. The addition of Tween-20 in SmF showed a maximum yield of 12.6 U/mL while, SDS suppressed the growth of the fungus. None of the surfactants favored the enzyme yield in SSF. Calcium chloride (CaCl₂) was extensively efficient in stimulating more than 55% higher phytase production in SmF at 0.01% v/v. In SSF, none of the metal salts stimulated phytase production.     

Fruiting of Agaricus bisporus

Several enzymes were assayed in extracts from mycelium-colonised compost during growth and fruiting of Agaricus bisporus (Lange) Imbach. Comparison of changes of enzyme levels in axenic and nonaxenic cultures and in cultures of non-fruiting strains indicated that they were associated directly with the fungal mycelium. Large changes were found in the amounts of laccase and cellulase which were correlated with fruit body development. Laccase concentration increased during mycelial growth and then declined rapidly at the start of fruiting. Cellulase activity could be detected throughout growth but increased at fruiting. No such changes were observed in xylanase, alkaline protease, laminarinase and acid and alkaline phosphatases. Activities of laccase and cellulase were measured in axenic cultures arrested at various stages of fruiting development. Such cultures showed that the changes in concentration of laccase and cellulase were associated with the enlargement of fruit bodies.     

Effect of nutritional parameters on laccase production by the culinary and medicinal mushroom, Grifola frondosa

Summary Extracellular laccase in cultures of Grifola frondosa grown in liquid culture on a defined medium was first detectable in the early/middle stages of primary growth, and enzyme activity continued to increase even after fungal biomass production had peaked. Laccase production was significantly increased by supplementing cultures with 100–500 (M Cu over the basal level (1.6 mM Cu) and peak levels observed at 300 mM Cu were ∼ ∼7-fold higher than in unsupplemented controls. Decreased laccase activity similar to levels detected in unsupplemented controls, as well as an adverse effect on fungal growth, occurred with further supplementation up to and including 0.9 mM Cu, but higher enzyme titres (2- to 16-fold compared with controls) were induced in cultures supplemented with 1–2 mM Cu²⁺. SDS-PAGE combined with activity staining revealed the presence of a single protein band (M _r ∼ ∼70 kDa) exhibiting laccase activity in control culture fluids, whereas an additional distinct second laccase protein band (M _r␣∼ ∼45 kDa) was observed in cultures supplemented with 1–2 mM Cu. Increased levels of extracellular laccase activity, and both laccase isozymes, were also detected in cultures of G. frondosa supplemented with ferulic, vanillic, veratric and 4-hydroxybenzoic acids, and 4-hydroxybenzaldehyde. The optimal temperature and pH values for laccase activity were 65 °C and pH 2.2 (using 2,2′-azinobis(3-ethylbenzthiazoline-6-sulfonate) {ABTS} as substrate), respectively, and the enzyme was relatively heat stable. In solid-state cultures of G. frondosa grown under conditions adopted for industrial-scale mushroom production, extracellular laccase levels increased during the substrate colonization phase, peaked when the substrate was fully colonized, and then decreased sharply during fruit body development.     

Effect of Nutritional Parameters on Laccase Production by the Culinary and Medicinal Mushroom, <Emphasis Type="Italic">Grifola frondosa</Emphasis>

Extracellular laccase in cultures of Grifola frondosa grown in liquid culture on a defined medium was first detectable in the early/middle stages of primary growth, and enzyme activity continued to increase even after fungal biomass production had peaked. Laccase production was significantly increased by supplementing cultures with 100–500 μM Cu over the basal level (1.6 μM Cu) and peak levels observed at 300 μM Cu were 7-fold higher than in unsupplemented controls. Decreased laccase activity similar to levels detected in unsupplemented controls, as well as an adverse effect on fungal growth, occurred with further supplementation up to and including 0.9 mM Cu, but higher enzyme titres (2- to 16-fold compared with controls) were induced in cultures supplemented with 1–2 mM Cu²⁺. SDS-PAGE combined with activity staining revealed the presence of a single protein band (M _r 70 kDa) exhibiting laccase activity in control culture fluids, whereas an additional distinct laccase protein band (M _r 45 kDa) was observed in cultures supplemented with 1–2 mM Cu. Increased levels of extracellular laccase activity, and both laccase isozymes, were also detected in cultures of G. frondosa supplemented with ferulic, vanillic, veratric and 4-hydroxybenzoic acids, and 4-hydroxybenzaldehyde. Using 2,2′-azino-bis(ethylbenzothiazoline-6-sulfonate) (ABTS) as substrate, the optimal temperature and pH values for laccase activity were 65°C and pH 2.2, respectively, and the enzyme was relatively heat stable. In solid-state cultures of G. frondosa grown under conditions adopted for industrial-scale mushroom production, extracellular laccase levels increased during the substrate colonization phase, peaked when the substrate was fully colonized, and then decreased sharply during fruit body development.