Growth and laccase production by Pleurotus ostreatus in submerged and solid-state fermentation

Pleurotus ostreatus showed atypical laccase production in submerged vs. solid-state fermentation. Cultures grown in submerged fermentation produced laccase at 13,000 U l⁻¹, with a biomass production of 5.6 g l⁻¹ and four laccase isoforms. However, cultures grown in solid-state fermentation had a much lower laccase activity of 2,430 U l⁻¹, biomass production of 4.5 g l⁻¹, and three laccase isoforms. These results show that P. ostreatus performs much better in submerged fermentation than in solid-state fermentation. This is the first report that shows such atypical behavior in the production of extracellular laccases by fungi.     

不同栽培基质对糙皮侧耳不同发酵方式下产漆酶活性的影响

为了比较糙皮侧耳栽培种在不同常规栽培基质上的漆酶活性,分析更适合糙皮侧耳生长的栽培基质,以1株糙皮侧耳Pleurotus ostreatus栽培菌株为研究材料,研究在固态和液态发酵条件下添加木屑、玉米芯和棉籽壳这3种栽培基质后,对其产漆酶活性的影响。结果表明,不同栽培基质对糙皮侧耳漆酶活性具有极显著的影响（P<0.001）;不同发酵方法对糙皮侧耳漆酶活性也具有极显著的影响（P<0.001）,仅第2天差异不显著。固体发酵与液体发酵条件下,糙皮侧耳在棉籽壳培养基上所检测到的漆酶活性均高于在木屑或者玉米芯培养基上,表明棉籽壳对提高糙皮侧耳漆酶活性的诱导能力更强。此外,糙皮侧耳在棉籽壳培养基上能够快速分泌漆酶,表明棉籽壳对缩短糙皮侧耳漆酶分泌时间的诱导能力更强。     

Cyanobacterial biomass as N-supplement to agro-waste for hyper-production of laccase from Pleurotus ostreatus in solid state fermentation

The potential application of dry biomass of a cyanobacterium Anacystis nidulans as a supplement in SSF for the production of laccase from Pleurotus ostreatus was evaluated. Experiments were carried out in solid culture using groundnut shell as a basic substrate supplemented with four independent nitrogen sources (ammonium sulphate, urea, yeast extract and dry powder of cyanobacteria). All the four supplements enhanced the enzyme yield, and yeast extract showed precedence over inorganic nitrogenous sources. However, when dry biomass of A. nidulans was used as an additive to groundnut shell (agricultural residues), it supported maximum cell growth (56.83 ± 5.56 mg/g dry substrate) and laccase production (49.21 ± 4.89 U/g dry substrate). Addition of 1 mM copper salt in the medium containing groundnut shell supplemented with yeast extract gave laccase activity of 32.64 ± 3.4 U/g dry substrate. When dry powder of cyanobacterial biomass was used as N-supplement, laccase production enhanced to 65.42 ± 6.48 U/g dry substrate. In addition to the enhancement to enzyme production inhibitory effects of high concentrations of copper was also diminished in the medium having dry cyanobacterial biomass. This study, forms the first report on the potential application of cyanobacterial biomass as an additive for production of laccase by Pleurotus ostraetus MTCC 1804 in solid state fermentation and has relevance in scale-up production of this fungal enzyme of commercial significance.     

Sorghum straw for xylanase hyper-production by Thermomyces lanuginosus (D2W3) under solid-state fermentation

This paper reports the production of very high levels of cellulase free xylanase and associated hemicellulases by an indigenous thermophilic isolate of Thermomyces lanuginosus (D(2)W(3)) using solid-state fermentation. Sorghum straw, an inexpensive and abundant source of carbon supported maximal xylanase activity (11,855 units/g dry substrate). Culturing T. lanuginosus D(2)W(3) on sorghum straw and optimizing other culture conditions (media types, particle size of carbon source, inoculum level, inoculum age and additives), yielded increased levels of xylanase (39,726 units/g dry substrate). Further optimization of enzyme production was carried out using Box-Behnken design of experiments with three independent variables (inoculum level, glycerol and ammonium sulphate concentrations) which resulted in very high levels of xylanase, 48,000+/-1774 units/g dry substrate, and 2.6+/-0.2, 13.4+/-0.56, 68+/-1.7, 1.4+/-0.08, 1.2+/-0.05 (units/g dry substrate) of beta-xylosidase, alpha-galactosidase, pectinase, beta-mannosidase and alpha-L-arabinofuranosidase, respectively.     

Purification and properties of an extracellular pectin lyase produced by the strain of Penicillium oxalicum in solid-state fermentation

A pectin lyase (PNL, EC 4.2.2.10) produced extracellularly by the strain of Penicillium oxalicum in solid-state fermentation medium containing deoiled mandarin orange peel meal was purified to apparent homogeneity by a protocol that included ammonium sulfate precipitation, DEAE-Sephadex A-50 and Sephadex G-100 chromatography. The enzyme had molecular mass of 50 kD, as determined by SDS- PAGE and showed optimum pH and temperature at 8.0 and 50 degrees C respectively. It had an isoelectric point (pI) of 5.0 and showed a K(m) of 1.1 mg/ml of citrus pectin. The enzyme was strongly inhibited by Mo4+, Ag+ and Pb2+ and also by polyphenolic compounds, in particular tannic acid.     

Production and partial characterization of xylanase by Sporotrichum thermophile under solid-state fermentation

A number of factors affecting production of xylanase, by the thermophilic fungus Sporotrichum thermophile under solid state fermentation (SSF) were investigated. Initial moisture content and type of carbon source were consecutively optimized. Solid state fermentation in a laboratory horizontal bioreactor using the optimized medium allowed the production of 320 U g^–1 of carbon source which compared favourably with those reported for other microorganisms. Optimal xylanase activity was observed at pH 5 and 70 °C. Chromogenic (fluorogenic) 4-methylumbelliferyl -glycoside of xylobiose (MUX₂) was used to characterize the xylanase multienzyme component, after separation by isoelectric focusing and native PAGE electrophoresis. The zymograms indicated one major xylanase fraction exhibiting pI and molecular mass values 4 and 90–120 kDa, respectively.     

Production and partial characterization of arabinoxylan-degrading enzymes by Penicillium brasilianum under solid-state fermentation

The production of a battery of arabinoxylan-degrading enzymes by the fungus Penicillium brasilianum grown on brewer’s spent grain (BSG) under solid-state fermentation was investigated. Initial moisture content, initial pH, temperature, and nitrogen source content were optimized to achieve maximum production of feruloyl esterase, xylanase, and α-l-arabinofuranosidase. Under the optimum growth conditions (80% moisture, pH 6, 26.5°C, and 5 g/l nitrogen source), the maximum level of feruloyl esterase (1,542 mU/g BSG) was found after 196 h, whereas xylanase (709 U/g BSG) and ArabF activity (3,567 mU/g BSG) were maximal after 108 h and 96 h, respectively. Based on substrate utilization data, the feruloyl esterases produced by P. brasilianum was anticipated to subclass B. A crude enzyme (CE) preparation from P. brasilianum culture grown on BSG was tested for the release of hydroxycinnamic acids and pentoses from BSG. The P. brasilianum CE produced in this work contains a balance of cell wall-modifying enzymes capable of degrading arabinoxylan of BSG by more than 40%.     

Enhancement of laccase production by Pleurotus ostreatus and its use for the decolorization of anthraquinone dye

The white-rot fungus Pleurotus ostreatus strain 32 is an excellent producer of the industrially important enzyme laccase. Laccase was the only ligninolytic activity detected in the supernatant when the fungus was grown in liquid culture with or without shaking. Growth and laccase production in static cultivation were superior to that in agitated cultivation, and N-limited culture is of benefit to laccase production. When using cellobiose and peptone as carbon and nitrogen source, a higher activity level was obtained. 2,2′-Azino-di-(3-ethylbenzothialozin-6-sulfonic acid) (ABTS) (1 mM) was shown to be the best inducer of laccase production, reaching maximum values of about 400 U/ml. Cu²⁺ (1 mM) also had a positive effect on laccase production, activity being enhanced to 360 U/ml. In addition, anthraquinone dye SN4R can be effectively decolorized by crude laccase (30 U/ml), the rate of which was 66%. The decolorization rate was increased by 90% with ABTS (0.16%) addition as a mediator of laccase.     

Trametes sp. LS-10C固态发酵产漆酶培养基优化及其对双酚A的降解

漆酶是一种绿色高效的多酚氧化酶,在降解双酚A方面具有巨大潜力。为降低发酵产漆酶的成本及考察漆酶在双酚A降解中的能力,本研究以麸皮和柚皮为主要基质,优化了栓菌固态发酵产漆酶条件,对优化后获得的漆酶在双酚A降解中的应用进行了研究。结果表明,在培养基组分为：麸皮和柚皮粉比例为6:4（W/W）、固液比1:2.5（W/V）、铜离子2%（W/W）、蔗糖3%（W/W）、硝酸钾2%（W/W）、稻壳20%（W/W）的条件下,栓菌发酵产漆酶的酶活最高,发酵11d后,酶活可达到38.4U/gds。当双酚A初始浓度为10μg/mL时,在55℃条件下酶解140min后,双酚A基本降解完全。     

Characterization and immobilization of the laccase from Pleurotus ostreatus and its use for the continuous elimination of phenolic pollutants

A laccase, the only ligninolytic enzyme produced by the basidiomycete Pleurotus ostreatus strain RK 36 was purified to homogeneity and characterized. The enzyme is a monomeric protein with a molecular weight of 67 000 Da and an isoelectric point of 3.6. Type I and type III Cu(2+) centers were identified by spectrophotometry. With syringaldazine as substrate laccase showed the highest oxidation rates at pH 5.8, 50 degrees C, and in 40 mM phosphate buffer. Among the tested stabilization parameters laccase retained most of its activity in high ionic buffer, pH 10, -20 degrees C, in the presence of 10 mM benzoic acid and with 35% ethylene glycol respectively. Crude laccase was covalently immobilized to Eupergit((R))C. Benzoate was found to stabilize the enzyme during the immobilization process. The activity loss of laccase during 10 days at 25 degrees C storage was 2% on average. Continuous elimination of 2,6-dimethoxyphenol by immobilized laccase was carried out in a packed bed reactor followed by filtration of the formed precipitate. The solubility of the polymerisates of oxidized syringaldazine, o-dianisidine, and 2,6-dimethoxyphenol with respect to temperature, pH-value and organic solvents were examined. The precipitates were found to be insoluble under non-extreme environmental conditions.     

Production and purification of statins from Pleurotus ostreatus (Basidiomycetes) strains

Pleurotus ostreatus strains were cultured in liquid medium and on wheat straw. The yields of lovastatin were compared.     

Electroreduction of O(2) to water at 0.6 V (SHE) at pH 7 on the "wired" Pleurotus ostreatus laccase cathode

O(2) was electroreduced to water at 0.6 V (SHE) near neutral pH on the "wired" Pleurotus ostreatus laccase cathode. We previously reported high-current density (5 mA cm(-2)), four-electron electroreduction of O(2) to water on a "wired" Coriolus hirsutus laccase electrode at +0.7 V (SHE) in pH 5 in citrate buffer. Since the enzyme was inhibited by chloride and because its activity declined steeply when the pH was raised to neutral, the rate of O(2) electroreduction in a physiological buffer solution was only approximately 1% of that at pH 5 in absence of chloride. Here we show that substitution of the C. hirsutus laccase by laccase from P. ostreatus allows the upward extension of the pH range of O(2) electroreduction. The current density of the electrode made with laccase from P. ostreatus in pH 7 citrate buffer was approximately 100 microA cm(-2) and at pH 7 and in phosphate buffered NaCl (PBS, 20 mM phosphate, 0.1 M NaCl) it still retained 6% of its maximal (1 mA cm(-2)) current density at pH 5 in citrate buffer. The electrocatalyst consisted of the crosslinked P. ostreatus laccase and the electron conducting redox polymer PVI-Os(dmebpy)(tpy)(2+/3+) [PVI=poly(N-vinyl imidazole) with about 1/5th of the rings complexed with (Os-dmebpy-tpy)(2+/3+); dmebpy=4,4'-dimethyl-2,2'-bipyridine; tpy=2,2',6',2"-terpyridine].     

Production of tylosin in solid-state fermentation by Streptomyces fradiae NRRL-2702 and its gamma-irradiated mutant (γ-1)

Aims:  To develop solid-state fermentation system (SSF) for hyper production of tylosin from a mutant γ-1 of Streptomyces fradiae NRRL-2702 and its parent strain.
Methods and Results:  Various agro-industrial wastes were screened to study their effect on tylosin production in SSF. Wheat bran as solid substrate gave the highest production of 2500 μg of tylosin g⁻¹ substrate by mutant γ-1 against parent strain (300 μg tylosin g⁻¹ substrate). The tylosin yield was further improved to 4500 μg g⁻¹ substrate [70% moisture, 10% inoculum (v/w), pH 9·2, 30°C, supplemental lactose and sodium glutamate on day 9]. Wild-type strain displayed less production of tylosin (655 μg of tylosin g⁻¹ substrate) in SSF even after optimization of process parameters.
Conclusion:  The study has shown that solid-state fermentation system significantly enhanced the tylosin yield by mutant γ-1.
Significance and Impact of the Study:  This study proved to be very useful and resulted in 6·87 ± 0·30-fold increase in tylosin yield by this mutant when compared to that of wild-type strain.     

Submerged fermentation of cellolignin materials (compared with solid-state fermentation and other alternatives)

The review characterizes the submerged and solid state fermentation processes (SF and SSF) for obtaining of microbial biomass protein (MBP) on cellulose- and lignin-containing (CL) agricultural wastes (straw, wine, branches of fruit trees). There are discussed other alternatives as well. The main technological parametres are presented (protein (biomass) yield, degree of available substrate utilization, process efficiency, etc.). The use of a special stirring system of the authors' design for mycelial cultures results in an increase of CL substrate concentration in the initial nutrient medium from 2% to 8%of dry matter (DM) and in a threefold increase of the specific productivity (from 0.07 g biomass/l · h to 0.21 g biomass/l · h). The technological parametres can be increased also in the processes with substrate addition. The obtained preparations are analyzed as to their usefulness for the feeds of ruminants.     

137Cs distribution and accumulation in the tissues of cultivated fungi (Pleurotus ostreatus)

The authors examined 137Cs accumulation and distribution in different structures and tissues of Pleurotus ostreatus cultivated under laboratory conditions. The fungi were shown to concentrate 137Cs. A higher concentrations of the radionuclides in the fungi compared to their substrate is manifested at the first stages of the fruit body formation, the maximum content of 137Cs is accumulated by fungi in the middle of bearing stage. The fungus tissues are different by their accumulative capacity as follows (ascending range): central, more dense part of the stipe < stipe < mycelium < cap < generative tissues. 137Cs accumulation in the fruit bodies depends also on the fungus size and age.     

The development of genetic and molecular markers to register and commercialize Penicillium rubens (formerly Penicillium oxalicum) strain 212 as a biocontrol agent

Penicillium oxalicum strain 212 (PO212) is an effective biocontrol agent (BCA) against a large number of economically important fungal plant pathogens. For successful registration as a BCA in Europe, PO212 must be accurately identified. In this report, we describe the use of classical genetic and molecular markers to characterize and identify PO212 in order to understand its ecological role in the environment or host. We successfully generated pyrimidine (pyr‐) auxotrophic mutants. In addition we also designed specific oligonucleotides for the pyrF gene at their untranslated regions for rapid and reliable identification and classification of strains of P. oxalicum and P. rubens, formerly P. chrysogenum. Using these DNA‐based technologies, we found that PO212 is a strain of P. rubens, and is not a strain of P. oxalicum. This work presents PO212 as the unique P. rubens strain to be described as a BCA and the information contained here serves for its registration and commercialization in Europe.     

Degradation of Chrysanthemum (Dendranthema grandiflora) wastes by Pleurotus ostreatus for the production of reducing sugars

In Colombia, a great amount of waste is generated during the cut-off and harvest stages in flowers culture. This study examines the possibility of degrading Chrysanthemum wastes by using Pleurotus ostreatus, Trametes versicolor, and Phanerochaete chrysosporium cultures; this has not been studied previously. The initial effect of fungi on the degradation of Chrysanthemum wastes were studied individually and in co-cultures. The highest degradation was by P. ostreatus. After that, the influence of pH and waste, copper, and manganese concentrations on reducing sugars concentration were determined in a submerged culture in 100 mL Erlenmeyer flasks. There was a significant effect of manganese and waste concentrations on sugar concentration, while the effect of copper concentration and pH were not significant. Following, the process was carried out in a 1.5 L reactor at the optimal values of the variables studied in Erlenmeyer flask but varying air injection from 0 to 2 vvm. The highest concentration of sugars was 21.2 g/L with 78% of glucose content at 6.3% w/v of waste, 7.5 mM of Mn and Cu and 2 vvm of air injection. Finally, laccase, Manganese peroxidase, endo-1,4-β-glucanase, exo-1,4-β-glucanase and 1,4-β-glucosidase were detected in the extract obtained under these conditions. The highest activities were obtained for laccase (4,694 U/L) and 1,4-β-glucosidase (9,513 U/L).