Growth rate influences reductive biodegradation of the organophosphorus pesticide demeton by Corynebacterium glutamicum

The organophosphorous pesticide, demeton-S-methyl was transformed byCorynebacterium glutamicum in co-metabolism with more readilydegradable substrates. Glucose, acetate and fructose were tested as growth substrates, and the highest demeton-S-methyl biotransformation average rate (0.78 mg l^-1 h^-1) and maximum instantaneous rate (1.4 mg l^-1 h^-1) were achieved on fructose. This higher efficiency seems to be linked to the atypical behavior of C. glutamicum grown on fructose, characterized by a prolonged period of accelerating growth instead of a constant growth rate observed on glucose or acetate. More precisely, for growth rates in the 0.1–0.4 h^-1 range, a direct coupling between the specific demeton-S-methyl consumption rate and the growth rate was demonstrated on fructose during batch –, steady state continuous – or continuous cultures with a controlled transient growth rate (accelerostat technology). The demeton-S-methyl biotransformation was more favoured during an acceleration phase of the growth rate.     

The generation of high biomass from chlororespiring bacteria using a continuous fed-batch bioreactor

A continuous fed-batch reactor system was developed to rapidly obtain dense chlororespiring cultures of Anaeromyxobacter dehalogenans strain 2CP-C. A syringe pump continuously delivered concentrated 2,6-dichlorophenol (50–150 mM) to an anaerobic reactor vessel at a rate that sustained linear growth but prevented the substrate toxicity of chlorophenol. Dechlorination was not significantly inhibited by end product phenol up to 8 mM. A cell density of 76.8 mg protein l^–1 was obtained in 24 h. Specific growth rates averaged 0.033 h^–1at 50% substrate limitation, which was in agreement with the maximum specific growth rate of 0.068 h^–1. This reactor system provides an efficient, cost-effective, and convenient method to rapidly obtain dense dechlorinating biomass and is promising to accelerate investigations of enzymes involved in chlororespiration.     

Decrease of proteolytic degradation of recombinant hirudin produced by Pichia pastoris by controlling the specific growth rate

The effects of the specific growth rate and methanol concentration on the degradation of hirudin produced by recombinant Pichia pastoris were investigated. When a methanol-limited state and the specific growth rate of 0.02 h^–1 were maintained during the fermentation, a minimum degradation of hirudin and a maximum specific hirudin production rate were achieved. By this strategy, the production of intact recombinant hirudin Hir65 reached 0.7 g l^–1 in fed-batch fermentation. Its proportion was 35% to all forms of hirudin.     

Invertase and phosphatase of yeast in a phosphate-limited continuous culture

Summary Deficiency of inorganic phosphate caused the hyper production of invertase and the derepression of acid phosphatase in a continuous culture ofSaccharomyces carlsbergensis. The specific invertase activity was 40,000 enzyme units per g dry cell weight at a dilution rate lower than 0.05 h^–1 with a synthetic glucose medium of which the molecular ratio of KH₂PO₄ to glucose was less than 0.006. This activity is eight fold higher than in a batch growth and 1.5 fold as much as the highest enzyme activity observed so far in a glucose-limited continuous culture.For the hyper production of invertase, it is necessary to culture the yeast continuously by keeping the Nyholm's conservative inorganic phosphate concentration at less than 0.2 m mole per g dry weight cell. The derepression of acid phosphatase brought about by phosphate deficiency, was similar in both batch and continuous cultures.Nomenclature D dilution rate of continuous culture (h^–1) - E_i invertase concentration in culture (enzyme unit l^–1) - E_p acid phosphatase concentration in culture (enzyme unit l^–1) - P inorganic phosphate concentration in culture (mM) - S glucose concentration in culture (mM) - X cell concentration in culture (g dry weight cell l^–1) Greek Letter specific rate of growth (h^–1) Suffix f feed - 0 initial value     

Production of mannitol by a novel strain of Candida magnoliae

A novel microorganism was isolated which is able to produce mannitol when grown in the presence of fructose and glucose as carbon sources. In flask culture in a medium containing 150 g fructose l^–1, it yielded 67 g mannitol l^–1 after 168 h. In fed-batch culture with 3–12% (w/v) fructose, production reached a maximum of 209 g mannitol l^–1 after 200 h, corresponding to an 83% yield and a 1.03 g l^–1 h^–1 productivity. The isolated strain was identified as Candida magnoliae based on identical sequences in the D1/D2 domain of its 26S rDNA and a similar carbon source utilization pattern with C. magnoliae reference strains.     

Anaerobic fermentation of Salmonella typhimurium with and without pyruvate carboxylase

A plasmid that expressed pyruvate carboxylase (PYC) from Rhizobium etli was introduced into Salmonella typhimurium LT2. Anaerobic fermentations of S. typhimurium with and without PYC were compared with glucose as a carbon source. The presence of PYC increased the succinate yield from glucose from 0.044 g g^–1 to 0.22 g g^–1, while the lactate yield decreased from 0.31 g g^–1 to 0.16 g g^–1. Metabolic flux calculations during the early growth phase indicate that under these growth conditions in the presence of PYC more carbon flows to oxaloacetate via pyruvate carboxylase than via phosphoenolpyruvate carboxylase. Also, under these growth and induction conditions, the presence of PYC diminished the cell growth rate from 0.34 h^–1 to 0.28 h^–1, the specific rate of ATP formation from 45 mmol l^–1 h^–1 to 27 mmol l^–1 h^–1, and the specific rate of glucose consumption from 17 mmol l^–1 h^–1 to 10 mmol l^–1 h^–1.     

Fed-batch fermentation of Lactobacillus lactis for hyper-production of l-lactic acid

A fed-batch fermentation of Lactobacillus lactis to produce l-lactic acid was developed in which the residual glucose concentration in the culture was used to control a continuous feeding strategy. Up to 210 g l-lactic acid l^–1 (97% yield) was obtained. The maximal dry cell was 2.7 g l^–1 and the average l-lactic acid productivity was 2.2 g l^–1 h^–1.     

Metabolic and kinetic studies of hybridomas in exponentially fed-batch cultures using T-flasks

Exponentially fed-batch cultures (EFBC) of a murine hybridoma in T-flasks were explored as a simple alternative experimental tool to chemostats for the study of metabolism, growth and monoclonal antibody (MAb) production kinetics. EFBC were operated in the variable volume mode using an exponentially increasing and predetermined stepwise feeding profile of fresh complete medium. The dynamic and steady-state behaviors of the EFBC coincided with those reported for chemostats at dilution rates below the maximum growth rate. In particular, steady-state for growth rate and concentration of viable cells, glucose, and lactate was attained at different dilution rates between 0.005 and 0.05 h^–1. For such a range, the glucose and lactate metabolic quotients and the steady-state glucose concentration increased, whereas total MAb, volumetric, and specific MAb production rates decreased 65-, 6-, and 3-fold, respectively, with increasing dilution rates. The lactate from glucose yield remained relatively constant for dilution rates up to 0.03 h^–1, where it started to decrease. In contrast, viability remained above 80% at high dilution rates but rapidly decreased at dilution rates below 0.02 h^–1. No true washout occurred during operation above the maximum growth, as concluded from the constant viable cell number. However, growth rate decreased to as low as 0.01 h^–1, suggesting the requirement of a minimum cell density, and concomitant autocrine growth factors, for growth. Chemostat operation drawbacks were avoided by EFBC in T-flasks. Namely, simple and stable operation was obtained at dilution rates ranging from very low to above the maximum growth rate. Furthermore, simultaneous operation of multiple experiments in reduced size was possible, minimizing start-up time, media and equipment costs.Abbreviations EFBC exponentially-fed batch culture - CSC continuous suspended culture - MAb monoclonal antibody - D dilution rate - q _i metabolic quotient or specific rate of consumption or production of i     

Production of antithrombotic hirudin in <Emphasis Type="Italic">GAL1</Emphasis>-disrupted <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis>

A gratuitous strain was developed by disrupting the GAL1 gene (galactokinase) of recombinant Saccharomyces cerevisiae harboring the antithrombotic hirudin gene in the chromosome under the control of the GAL10 promoter. A series of glucose-limited fed-batch cultures were carried out to examine the effects of glucose supply on hirudin expression in the gratuitous strain. Controlled feeding of glucose successfully supported both cell growth and hirudin expression in the gratuitous strain. The optimum fed-batch culture done by feeding glucose at a rate of 0.3 g h^–1 produced a maximum hirudin concentration of 62.1 mg l^–1, which corresponded to a 4.5-fold increase when compared with a simple batch culture done with the same strain.     

Effect of the dilution rate on the biomass yield ofBacillus thuringiensis and determination of its rate coefficients under steady-state conditions

Depending on the biomass yield on glucose and the cell morphology ofBacillus thuringiensis, three different metabolic states were observed in continuous culture. At dilution rates between 0.18 h^–1 and 0.31 h^–1 vegetative cells, sporulating bacteria and spores coexisted, while glucose and amino acids were consumed. Only vegetative cells were observed at dilution rates between 0.42 h^–1 and 0.47 h^–1 and glucose was used as the main carbon and energy source. AtD = 0.50 h^–1 the biomass yield on glucose decreases sharply. To define better the specific growth rate range in which the microorganism uses mainly glucose, a dilution rate of 0.25–0.45 h^–1 was studied. The experimental data could be adjusted to a Monod model and the following rate coefficients and growth yields were determined: maximum specific growth rate 0.54 h^–1, saturation constant 0.56 mg glucose ml^–1, biomass growth yields 0.43 g cells (g glucose)^–1, and 0.76 g cells (g oxygen)^–1, and maintenance coefficients 0.065 g glucose (g cells)^–1 h^–1 and 0.039 g oxygen (g cells)^–1 h^–1.     

Glucoamylase production in batch, chemostat and fed-batch cultivations by an industrial strain of Aspergillus niger

The Aspergillus niger strain BO-1 was grown in batch, continuous (chemostat) and fed-batch cultivations in order to study the production of the extracellular enzyme glucoamylase under different growth conditions. In the pH range 2.5–6.0, the specific glucoamylase productivity and the specific growth rate of the fungus were independent of pH when grown in batch cultivations. The specific glucoamylase producivity increased linearly with the specific growth rate in the range 0–0.1 h⁻¹ and was constant in the range 0.1–0.2 h⁻¹. Maltose and maltodextrin were non-inducing carbon sources compared to glucose, and the maximum specific growth rate was 0.19 ± 0.02 h⁻¹ irrespective of whether glucose or maltose was the carbon source. In fed-batch cultivations, glucoamylase titres of up to 6.5 g l⁻¹ were obtained even though the strain contained only one copy of the glaA gene. Received: 5 May 1999 / Received revision: 7 September 1999 / Accepted: 17 September 1999     

Glucose repression of xylitol production in Candida tropicalis mixed-sugar fermentations

Glucose repressed xylose utilization inCandida tropicalis pre-grown on xylose until glucose reached approximately 0–5 g l^–1. In fermentations consisting of xylose (93 g l^–1) and glucose (47 g l^–1), xylitol was produced with a yield of 0.65 g g^–1 and a specific rate of 0.09 g g^–1 h^–1, and high concentrations of ethanol were also produced (25 g l^–1). If the initial glucose was decreased to 8 g l^–1, the xylitol yield (0.79 g g^–1) and specific rate (0.24 g g^–1 h^–1) increased with little ethanol formation (<5 g l^–1). To minimize glucose repression, batch fermentations were performed using an aerobic, glucose growth phase followed by xylitol production. Xylitol was produced under O₂ limited and anaerobic conditions, but the specific production rate was higher under O₂ limited conditions (0.1–0.4 vs. 0.03 g g^–1 h^–1). On-line analysis of the respiratory quotient defined the time of xylose reductase induction.     

Limitations in substrate utilization efficiency by Zymomonas mobilis

Summary Optimal growth conditions for Zymomonas mobilis have been established using continuous cultivation methods. Optimal substrate utilization efficiency occurs with 2.5 g l^–1 yeast extract, 2.0 g l^–1 ammonium sulfate and 6.0 g l^–1 magnesium sulfate in the media. Catabolic activity is at its maximum with glucose uptake rates of 16–18 g l^–1 h^–1 and ethanol production rates of 8–9 g l^–1 h^–1, Q_g values of 22–26 and Q_p values between 11 and 13, which results in 40 g l^–1 h^–1 ethanol yields using a 100 g l^–1 substrate feed. Any increase in these parameters goes on cost of substrate utilization efficiency. Calcium pantothenate can not substitute yeast extract.Abbreviations G Glucose (%) - Pant Calcium pantothenate (mg l^–1) - D Dilution rate (h^–1) - NH₄ Ammonium sulfate (%) - M_g Magnesium sulfate (%) - S₁ Residual glucose in the fermenter (g l^–1) - S₀ Glucose feed (g l^–1) - Eth Ethanol concentration (g l^–1) - GUR Glucose uptake rate (g l^–1 h^–1) - Q_g Specific glucose uptake rate (g g^–1 h^–1) - Q_p Specific ethanol production rate (g g^–1 h^–1) - EPR Ethanol production rate (g l^–1 h^–1) - Y_g Yield coefficient for glucose (g g^–1) - Y_p Conversion efficiency (%) - C Biomass concentration (g l^–1) Present address: (Until June 1982) Institut für Mikrobiologie, TH Darmstadt, 6100 Darmstdt, Federal Republic of Germany     

Modeling of the pyruvate production with<Emphasis Type="Italic"> Escherichia coli</Emphasis> in a fed-batch bioreactor

A family of 10 competing, unstructured models has been developed to model cell growth, substrate consumption, and product formation of the pyruvate producing strain Escherichia coli YYC202 ldhA::Kan strain used in fed-batch processes. The strain is completely blocked in its ability to convert pyruvate into acetyl-CoA or acetate (using glucose as the carbon source) resulting in an acetate auxotrophy during growth in glucose minimal medium. Parameter estimation was carried out using data from fed-batch fermentation performed at constant glucose feed rates of q_VG=10 mL h^–1. Acetate was fed according to the previously developed feeding strategy. While the model identification was realized by least-square fit, the model discrimination was based on the model selection criterion (MSC). The validation of model parameters was performed applying data from two different fed-batch experiments with glucose feed rate q_VG=20 and 30 mL h^–1, respectively. Consequently, the most suitable model was identified that reflected the pyruvate and biomass curves adequately by considering a pyruvate inhibited growth (Jerusalimsky approach) and pyruvate inhibited product formation (described by modified Luedeking–Piret/Levenspiel term).List of symbols c_A acetate concentration (g L^–1) - c_A,0 acetate concentration in the feed (g L^–1) - c_G glucose concentration (g L^–1) - c_G,0 glucose concentration in the feed (g L^–1) - c_P pyruvate concentration (g L^–1) - c_P,max critical pyruvate concentration above which reaction cannot proceed (g L^–1) - c_X biomass concentration (g L^–1) - K_I inhibition constant for pyruvate production (g L^–1) - K_I^A inhibition constant for biomass growth on acetate (g L^–1) - K_P saturation constant for pyruvate production (g L^–1) - K_P inhibition constant of Jerusalimsky (g L^–1) - K_S^A Monod growth constant for acetate (g L^–1) - K_S^G Monod growth constant for glucose (g L^–1) - m_A maintenance coefficient for growth on acetate (g g^–1 h^–1) - m_G maintenance coefficient for growth on glucose (g g^–1 h^–1) - n constant of extended Monod kinetics (Levenspiel) (–) - q_V volumetric flow rate (L h^–1) - q_VA volumetric flow rate of acetate (L h^–1) - q_VG volumetric flow rate of glucose (L h^–1) - r_A specific rate of acetate consumption (g g^–1 h^–1) - r_G specific rate of glucose consumption (g g^–1 h^–1) - r_P specific rate of pyruvate production (g g^–1 h^–1) - r_P,max maximum specific rate of pyruvate production (g g^–1 h^–1) - t time (h) - V reaction (broth) volume (L) - Y_P/G yield coefficient pyruvate from glucose (g g^–1) - Y_X/A yield coefficient biomass from acetate (g g^–1) - Y_X/A,max maximum yield coefficient biomass from acetate (g g^–1) - Y_X/G yield coefficient biomass from glucose (g g^–1) - Y_X/G,max maximum yield coefficient biomass from glucose (g g^–1) - growth associated product formation coefficient (g g^–1) - non-growth associated product formation coefficient (g g^–1 h^–1) - specific growth rate (h^–1) - _max maximum specific growth rate (h^–1)     

Studies on the variables and kinetics of SCP production from nopal fruit juice

Summary Submerged batch cultivation under controlled environmental conditions of pH 3.8, temperature 30°C, and K_La200 h^–1 (above 180 mMO₂ l ^–1 h^–1 oxygen supply rate) produced a maximum (12.0 g·l ^–1) SCP (Candida utilis) yield on the deseeded nopal fruit juice medium containing C/N ratio of 7.0 (initial sugar concentration 25 g·l ^–1) with a yield coefficient of 0.52 g cells/g sugar. In continuous cultivation, 19.9 g·l ^–1 cell mass could be obtained at a dilution rate (D) of 0.36 h^–1 under identical environmental conditions, showing a productivity of 7.2 g·l ^–1·h^–1. This corresponded to a gain of 9.0 in productivity in continuous culture over batch culture. Starting with steady state values of state variables, cell mass (C_X–19.9 g·l ^–1), limiting nutrient concentration (C_ln–2.5 g·l ^–1) and sugar concentration (C_S–1.5 g·l ^–1) at control variable conditions of pH 3.8, 30°C, and K_La 200 h^–1 keeping D=0.36 h^–1 as reference, transient response studies by step changes of these control variables also showed that this pH, temperature and K_La conditions are most suitable for SCP cultivation on nopal fruit juice. Kinetic equations obtained from experimental data were analysed and kinetic parameters determined graphically. Results of SCP production from nopal fruit juice are described.Nomenclature C_ln concentration of ammonium sulfate (g·l ^–1) - C_S concentration of total sugar (g·l ^–1) - C_X cell concentration (g·l ^–1) - D dilution rate (h^–1) - K_ln Monod's constant (g·l ^–1) - m maintenance coefficient (g ammonium sulfate cell^–1 h^–1) - m_(S) maintenance coefficient (g sugar g cell^–1 h^–1) - t time, h - Y yield coefficient (g cells/g ammonium sulfate) - Y_m maximum of Y - Y_S yield coefficient based on sugar consumed (g cells · g sugar^–1) - Y_S(m) maximum value of Y_S - ^µm maximum specific growth rate constant (h^–1)     

Fed-batch production of <Emphasis Type="SmallCaps">d</Emphasis>-ribose from sugar mixtures by transketolase-deficient <Emphasis Type="Italic">Bacillus subtilis</Emphasis> SPK1

d-Ribose, a five-carbon sugar, is used as a key intermediate for the production of various biomaterials, such as riboflavin and inosine monophosphate. A high d-ribose-producing Bacillus subtilis SPK1 strain was constructed by the chemical mutation of the transketolase-deficient strain, B. subtilis JY1. Batch fermentation of B. subtilis SPK1 with 20 g l^–1 xylose and 20 g l^–1 glucose resulted in 4.78 g l^–1 dry cell mass, 23.0 g l^–1d-ribose concentration, and 0.72 g l^–1 h^–1 productivity, corresponding to a 1.5- to 1.7-fold increase when compared with values for the parental strain. A late-exponential phase was chosen as the best point for switching to a fed-batch process. Optimized fed-batch fermentation of B. subtilis SPK1, feeding a mixture of 200 g l^–1 xylose and 50 g l^–1 glucose after the late-exponential phase reduced the residual xylose and glucose concentrations to less than 7.0 g l^–1 and gave the best results of 46.6 g l^–1d-ribose concentration and 0.88 g l^–1 h^–1 productivity which were 2.0- and 1.2-fold higher than the corresponding values in a simple batch fermentation.     

Acetone butanol ethanol (ABE) production from concentrated substrate: reduction in substrate inhibition by fed-batch technique and product inhibition by gas stripping

Acetone butanol ethanol (ABE) was produced in an integrated fed-batch fermentation-gas stripping product-recovery system using Clostridium beijerinckii BA101, with H₂ and CO₂ as the carrier gases. This technique was applied in order to eliminate the substrate and product inhibition that normally restricts ABE production and sugar utilization to less than 20 g l^–1 and 60 g l^–1, respectively. In the integrated fed-batch fermentation and product recovery system, solvent productivities were improved to 400% of the control batch fermentation productivities. In a control batch reactor, the culture used 45.4 g glucose l^–1 and produced 17.6 g total solvents l^–1 (yield 0.39 g g^–1, productivity 0.29 g l^–1 h^–1). Using the integrated fermentation-gas stripping product-recovery system with CO₂ and H₂ as carrier gases, we carried out fed-batch fermentation experiments and measured various characteristics of the fermentation, including ABE production, selectivity, yield and productivity. The fed-batch reactor was operated for 201 h. At the end of the fermentation, an unusually high concentration of total acids (8.5 g l^–1) was observed. A total of 500 g glucose was used to produce 232.8 g solvents (77.7 g acetone, 151.7 g butanol, 3.4 g ethanol) in 1 l culture broth. The average solvent yield and productivity were 0.47 g g^–1 and 1.16 g l^–1 h^–1, respectively.     

Characteristics of fed-batch cultures of recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis> containing human-like collagen cDNA at different specific growth rates

Fed-batch cultures of recombinant Escherichia coli BL21 for producing human-like collagen were performed at different specific growth rates (0.1~0.25 h⁻¹) before induction and at a constant value of 0.05 h⁻¹ after induction by the method of pseudo-exponential feeding. Although the final biomass (around 69 g l⁻¹) was almost the same in all fed-batch cultures, the highest product concentration (13.6 g l⁻¹) was achieved at the specific growth rate of 0.15 h⁻¹ and the lowest (9.6 g l⁻¹) at 0.25 h⁻¹. The mean productivity of human-like collagen was the highest at 0.15 h⁻¹ (0.57 g l⁻¹ h⁻¹) and the lowest at 0.1 h⁻¹ (0.35 g l⁻¹ h⁻¹). In the phase before induction, the cell yield coefficient (Y_X/S) decreased when the specific growth rate increased, while the formation of acetic acid increased upto 2.5 g l⁻¹ at 0.25 h⁻¹. The mean product yield coefficient (Y_P/S) also decreased with specific growth rate increasing. The respiration quotient (RQ) increased slightly with specific growth rate increasing before induction, and the mean value of RQ was around 72%. The optimum growth rate for human-like collagen production was 0.15~0.2 h⁻¹.     

Modelling the production of nisin by Lactococcus lactis in fed-batch culture

Nisin production in batch culture and fed-batch cultures (sucrose feeding rates were 6, 7, 8, and 10 g l^–1 h^–1, respectively) by Lactococcus lactis subsp. lactis ATCC 11454 was investigated. Nisin production showed primary metabolite kinetics, and could be improved apparently by altering the feeding strategy. The nisin titer reached its maximum, 4,185 IU ml^–1, by constant addition of sucrose at a feeding rate of 7 g l^–1 h^–1; an increase in 58% over that of the batch culture (2,658 IU ml^–1). Nisin biosynthesis was affected strongly by the residual sucrose concentration during the feeding. Finally, a mathematical model was developed to simulate the cell growth, sucrose consumption, lactic acid production and nisin production. The model was able to describe the fermentation process in all cases.     

Effect of growth rate on the production of<Emphasis Type="SmallCaps">l</Emphasis>-proline in the fed-batch culture of<Emphasis Type="Italic">Corynebacterium acetoacidophilum</Emphasis>

Corynebacterium acetoacidophilum RYU3161 was cultivated in al-histidine-limited fed-batch culture. To investigate the effect of cell growth on thel-proline production, 5l fed-batch culture was performed using an exponential feeding rate to obtain the specific growth rates (μ) of 0.04, 0.06, 0.08, and 0.1 h⁻¹. The results show that the highest production ofl-proline was obtained at μ=0.04 h⁻¹. The specificl-proline production rate (Q_p) increased proportionally as a function of the specific growth rate, but decreased after it revealed the maximum value at μ=0.08 h⁻¹. Thus, the highest productivity ofl-proline was 1.66 g L⁻¹ h⁻¹ at μ=0.08 h⁻¹. The results show that the production of L-proline inC. acetoacidophilum RYU3161 has mixed growth-associated characteristics.